2025 Toyota RAV4

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/18/2025· VISIBILITY/WIPER

  Unknow

• 12/16/2025· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,WHEELS

  The front camera fails which does not allow for the cruise control to operate. The speed odometer does not specify the correct speed when driving the car. The feature of telling you how fast you are supposed to go does not operate correctly specifying the wrong speed you are supposed to go. The tires have already been replaced because the metal was coming out of the tires causing the car to not operate correctly there was wobbling in the tires causing the car to feel like the tires were about to come off the tires. The transmission not shifting properly in eco mode.

• 12/05/2025· ELECTRICAL SYSTEM,ENGINE

  Formal Complaint to Toyota Motor Corporation (Manufacturing) Regarding: Serious Manufacturing Defect and Failure of New Vehicle Safety Customer: [XXX] Customer Contact: Phone – [XXX] | Email – [XXX] Vehicle Purchased: (New/Recently Purchased Toyota Model) Date of Purchase: [XXX] Selling Dealership: Round Rock Toyota Vehicle Identification Number (VIN) (Last 4 Digits): [XXX] ________________________________________ I. Overview of Complaint: Critical Safety Defect I am filing this formal complaint directly with Toyota Motor Corporation regarding a vehicle that, due to an apparent critical manufacturing defect, failed dangerously and repeatedly within days of purchase. This failure represents a lapse in Toyota's quality control and a serious threat to consumer safety. The vehicle, purchased new or recently, on [XXX], exhibited critical operational defects less than three days after leaving the dealership. This vehicle is demonstrably defective and unsafe, having compromised my life during a near-fatal failure on a major interstate. As the manufacturer, Toyota is ultimately responsible for the quality and safety of the product delivered to consumers. II. Factual Timeline of Critical Defects and Safety Incidents The vehicle exhibited multiple critical failures less than 77 miles and three days after purchase, severely compromising my safety and confidence in the quality of the Toyota product: •Immediate Operational Failures: The vehicle began experiencing multiple mechanical failures shortly after purchase. •Near-Fatal Highway Stall: The most severe incident involved the vehicle suddenly failing and stalling while traveling on a major interstate. This catastrophic failure is indicative of a serious underlying manufacturing or component defect and severely endangered my life and the lives of others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/21/2025· STRUCTURE

  I discovered early rust formation on my vehicle shortly after purchase. The dealership only proposed painting over the rust instead of investigating the underlying cause. This may indicate a factory-related structural defect and could pose a long-term safety risk. I am requesting an investigation.

• 11/19/2025· VISIBILITY/WIPER

  Stress fracture in the windshield

• 11/17/2025· STEERINGCrash

  2025 RAV4 - While driving the car, changing from reverse to drive the steering wheel got stuck and would not go back to straight position. This causes an accident and hit another car. There was not indicator that there is a problem. Inspection was done by the dealership and asap and they identified and confirmed of faulty steering wheel angle. This car was bought end of June and accident happened first week of October. The car is since with the dealership with no resolution yet. Dealership have us call Toyota, but we were not provided with any help. One and half month in, we continue to pay insurance but we do not have the car.

• 11/15/2025· STEERING,ELECTRICAL SYSTEM,ENGINE

  While waiting in a drive-thru with “hold” feature enabled, car vibrated abnormally and shut off by itself. When I attempted to restart the vehicle, I received an error message “Engine Stopped. Steering Power Low” and another screen also appeared that said, “Not Ready to Drive. Press Brake and Push Engine Start Switch.” I followed those instructions several times and the car wouldn’t start. Eventually had to put in neutral to get out of drive-thru. Once out of drive-thru, I once again attempted to restart the car, but this time it worked. Should mention it was raining pretty heavily outside when this happened.

• 11/14/2025· BACK OVER PREVENTION

  While reversing vehicle screen went blank once and another time flickering on screen, felt safety issue reversing.

• 11/12/2025· SERVICE BRAKESCrash

  I rented the Toyota RAV4 from Fox Rent a Car (855 571-8414) at the Denver International Airport for a trip to Boulder, CO. On November 9 evening, I drove to the Sugarloaf Mountain Trail Head (GPS: 40.05, -105.425) for a time-lapse photography. Date/Time: 2025-11-09 6:29 PM Location Description: Uneven dirt parking area commonly used by sightseers. Visibility was completely dark at the time of arrival. After arriving at the hilltop, as I parked the vehicle, while applying very light pressure to the accelerator pedal with my right foot, I felt a gradual drop of several inches on the passenger side of the vehicle. Instinctively, I moved my right foot to the brake pedal and applied pressure. However, I immediately sensed that the vehicle was not decelerating; instead, it was accelerating forward. I pressed the brake pedal more firmly, and the vehicle accelerated further until it came to a complete stop after colliding with a rock on the driver's side approximately 15 feet from the point of initial acceleration. Once the situation stabilized, I exited the vehicle and observed a red, non-oily liquid of normal viscosity leaking from underneath the vehicle on the front driver's side, which I later identified as coolant. Upon opening the hood, I confirmed that approximately half of the coolant had been depleted. I Googled AI Mode: Question: For a Toyota RAV4 HEV, is it possible for the vehicle to accelerate when the brakes are applied forcefully and abruptly? Answer (Source): [XXX] Potential Perceptions and Known Issues While the car will not accelerate due to the brakes being applied correctly, drivers have occasionally reported sensations that might be might be misinterpreted as acceleration, such as a slight "lurch" when the braking system transitions between regenerative and friction braking, ** especially at very low speeds or over rough surfaces. ** INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/12/2025· UNKNOWN OR OTHER

  El día 2 de octubre compré una Rav 4 2025.El día 14 de octubre me doy cuenta que los cristales se encontraban rayados como por dentro del cristal, entiendo que esto pudo haber puesto en riesgo mi seguridad ya que si cualquiera de los cristales se rompe puede cortarme a mi o a un pasajero. En la primera inspección no notaron nada luego llamaron a un especialista de Toyota para verificarlo y en conclusión si noto dicho defecto en los cristales pero noto que en el mismo concesionario había varios vehículos con el mismo problema me notificó que su deber es reportar este problema pero que por el momento no hay nada que hacer con mi auto estos rayones por dentro del cristal únicamente son vistos específicamente bajo los rayos de la luz solar.No hubo ningún símbolo ni falla antes de notarlo el día 14 de octubre2025

• 11/10/2025· VISIBILITY/WIPER

  The windshield is warped and distorted. The dealership also told me that they can also see the warp in it. The original windshield was replaced, and the new one also has the same issue. The brand engagement rep I spoke with at Toyota told me that he has received multiple calls about the windshield issue. This vehicle was purchased 7/30/2025, and only has 271 miles on it and is on the original tank of gas. I have to rely on other people to give me rides places, as I am unable to drive this vehicle. The safety risk is due to the dizziness, nausea and migraine it causes me to drive it. My eyes feel like they are going cross eye, and I have to look out the driver's side window to get any kind of relief, which isn't allowing me to be alert while driving. This causes a huge issue for my safety as well as others. The Toyota Brand engagement rep that I spoke with said it is an issue and he has received multiple calls about it. The dealership has also acknowledged that they were able to see the defect.

• 11/06/2025· STRUCTURE

  The power rear liftgate will close on a person or object and cannot be stopped except if one presses on a very specific part of the edge of the liftgate, towards its center. This happens no matter how much upward force is applied to the area of the pull handles and the edges. When my wife pulled the handle, the liftgate closed with force that she could not resist. This obviously creates a serious safety hazard for small children, pets, or really anyone trying to close the liftgate or who may have inadvertently hit the button or pulled the handle.

• 11/04/2025· UNKNOWN OR OTHER

  The vehicle's CarPlay is malfunctioning, showing incorrect vehicle location and navigation directions. The vehicle's screen often shows incorrect location and directions, and changes directions as it updates where it thinks the car is. This is available for inspection upon request. The safety of the driver and passengers is put at risk because the screen showing incorrect location and directions causes a constant distraction, taking your eyes away from the road to figure out if the map is showing you the correct location or not. Sometimes, when the carplay is looking for the correct location, the map spins around and shifts location which is also distracting even when you try to ignore it. The consistent distraction this causes while trying to navigate through unknown streets has caused both my wife and I to get lost, take the wrong turns, or get stressed and confused while driving because we don't know what the directions are telling us, or we don't know if we are following the right directions. We are worried we will hit a car or person during these times of confusion. This has been repeated multiple times at Toyota dealership and is a known issue acknowledged by Toyota corporate. The vehicle has been inspected by Toyota's regional technician who installed an unreleased software update at my last visit, but the problem persists without improvement. There isn't a warning sign. I have requested a replacement or reimbursement for this vehicle from Toyota but their Dispute Resolution team says I have not given enough opportunity for Toyota to repair the car. I then brought the car back in and they kept it for three weeks and installed an unreleased software update. The loaner car they provided me was the same car different year and had no carplay issues. I am trying to bring it back but the dealership cancelled my appointment telling me they won't accept the car because they can't fix it. I am trying to escalate again to corporate.

• 10/21/2025· UNKNOWN OR OTHER

  During an AWS outage on 10/20/2025, the connect app which can turn on or off the vehicle, unlock/lock doors, etc had issues where it performed an unlock on our vehicle 5 times in 24hrs without us doing anything. Key fob was in sleep mode / low power mode (cannot signal vehicle). Reports of this happening to others found online, but Toyota dealership states no reports on any of this happening.

• 10/21/2025· ELECTRICAL SYSTEM

  component: main engine wiring harness. cause: rodent caused damage: the rodent severely damaged this component and made the vehicle inoperable. fix: required the replacement of this component. insurance covered the 8,500 repair bill (minus deductible). a check engine light appeared eventually.

• 10/08/2025· TIRES

  The contact owns a 2025 Toyota Rav4 equipped with Michelin Tires, Tire Line: Primacy A/S, Tire Size: 225/60/R16, DOT Number: (N/A). The contact stated while driving 70 MPH, the rear passenger’s tire detached from the rim. The contact stated that the failure had occurred while driving on a three-lane highway. The vehicle was driven over to the shoulder of the roadway. The contact inspected the vehicle and noticed that the passenger’s side rear tire had detached from the rim. Roadside Assistance was contacted and replaced the wheel with the spare tire. The manufacturer was made aware of the failure but provided no assistance. The contact was advised that without a part of the tire, no assistance would be provided. The failure mileage was approximately 7,000.

• 10/04/2025· UNKNOWN OR OTHER

  I was driving on CA Highway 20 on Thursday afternoon, Oct. 2, when the sunroof spontaneously shattered. I was not driving under a bridge or overpass or tree. There were no vehicles directly in front of me. I heard a loud pop, like an exploding bottle, but could see no damage inside the car. Within a few miles, glass was flying off the roof and striking cars behind me. That's when I pulled off the road and saw the roof was shattered. The shape of the break mounded up in the middle, implying the roof had broken upward. There were no rocks inside on the sunroof cover, nor any other debris than shattered glass.

• 09/26/2025· SERVICE BRAKES

  Stopped to allow a car to pass. Once the car passed, there was acceleration of the engine but the car would not move. When the car gear was changed to park and then back to drive, it would not move. In order to get the car out of the traffic lane, the car was placed in neutral but the car brakes were locked. All this time the red 'park' on the dash and the red button on the console kept flashing. We called AAA and they arrived in 40 minutes. The man got in the car and stated they sometimes reset themselves. The car did start and he was able to drive it as the brakes were no longer locked. We took it to Toyota of Orange but they were unable to find the cause. They stated that they elevated this incident to a test case. TA252650358 This car only has 2,689 miles on it !!

• 09/17/2025· UNKNOWN OR OTHER

  Unintended/unwanted sudden acceleration - we are aware of this happening 5 times while I was driving, all times coasting to proceed into a turn. (I DO NOT DRIVE WITH 2 FEET). In each instance, while coasting my right foot covered (above) the brake pedal. BOTH feet were off the gas and brake pedal. Tachometer suddenly and rapidly spiked and car appeared/sounded like it would surge forward. In hopes of avoiding this sudden surge forward, I quickly put car in neutral and applied brake. Car slows and tachometer returns to normal. Brought to dealer, they stated from black box inspection that I was applying brake and gas simultaneously. THIS IS NEARLY IMPOSSIBLE FOR ME; as I demonstrated to folks at dealer I physically cannot do this without causing the arthritic pain in my ankle/foot to rise to a very noticeable level. The pain would be prolonged while doing what they claimed I was doing. I vehemently deny their explanation for these occurrences. No accidents occurred, nobody was injured (in these incidents). Obviously those in my car and others near my vehicle on the road should this happen again could be injured. No warning lights, messages etc were displayed. Sporadic occurrences. Purchased vehicle July 11,2025, first occurrence (I noticed) at July 31, 2025. Dealer stated their case is closed on this as of 9/04/25. Today 9/17/25 another occurrence happened. Car is available for inspection upon request.

• 09/15/2025· ELECTRICAL SYSTEM

  The contact owns a 2025 Toyota Rav4. The contact stated that upon leaving the keys in the ignition overnight, the battery was drained. The contact stated that the jumper cables were in a compartment located inside the trunk. The contact stated that due to the battery failure, the contact was unable to unlock the vehicle. In addition, there was no keyhole for the trunk of the vehicle. The contact entered the trunk through the inside of the vehicle; however, the compartment where the jumper cables were located had failed to open due to the battery failure. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 5,500.

• 09/13/2025· EXTERIOR LIGHTING

  Back up camera delay in lighting up when car is started

• 09/09/2025· AIR BAGS,FORWARD COLLISION AVOIDANCECrash

  On 9/5, a car darted out in front of me while I was traveling straight at 45 miles per hour. I hit the brakes but t-boned him. The car then spins around and hits me again on the passenger quarter panel. No emergency brake, precollision no warning light came on. The airbag didnt deploy. I hit my chest on the steering while and my head on the window. The seat belt didnt lock me down. I purchased the brand new Rav4 a week prior.

• 08/17/2025· STRUCTURE

  I noted the body is made up of soft materials that slightly bend when push lightly with hand. I put a magnet to see if it’s made up of metal but noted a weak attraction of the magnet to the body. When I used my buttock to push the door to close ( my hands were not free and held several grocery bags), my buttock sunk to the part of the area I pressed on. I heard and felt the bending and clicking sound of plastic then it lifted back to its shape. I almost lost my balance since I’m not expecting the door that soft. I was scared that I dented the door. So how safety is this 2025 RAV4 ? We also have 2023 RAV4 of same model XLE AWD Premier. I wonder what will happen if it has accident with another vehicles on the road. With this body materials will save me from any kind of collisions ? I just noticed this brought by my experience today.

• 07/29/2026· ELECTRICAL SYSTEM,ENGINE

  Drove home vehicle under 20,000 miles 2025, got to drove way parked and car stalled shaking amd stated steering power low, and shut off. Tried to re start it and did the same thing stalled shook amd shut off with the same warning. No previous issues

• 07/27/2025· TIRES

  I was driving on the Highway at 70 mph and the rear passenger tire blew out. Thank God I was able to stopped the car safely and no one was injured. It was a scary moment and it is still is.My safety and other was at risk It is a brand new car with only 4397 miles. I took the car to the dealership and they replaced the tire. They found NO indications of a puncture or road hazard. Tire split at the shoulder and sidewall. Tire description Dunlop Grantrek 225/60 R 18

• 07/22/2026· UNKNOWN OR OTHER

  While driving using Apple Carplay with maps loaded, the multimedia screen switches to Toyota's Experience Drive Connect. The only way to get directions back up is to reboot the Multimedia screen by holding down the power switch, which takes a long time while trying to navigate. I called Toyota Connected Services and was informed that they are aware of the problem, but there is nothing they can do unless I pay for services I don't want or need. this has been happening since we purchased the car new 12/31/2026

• 07/22/2026· VISIBILITY

  The contact owns a 2025 Toyota Rav4. The contact stated that while driving the vehicle at an undisclosed speed and activating the A/C, there was hot air coming from the vents. The dealer was contacted, and the contact was informed that the A/C condenser was damaged by an object, causing a refrigerant leak. The contact stated that the vehicle was sold with the pre-existing failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 556.

• 07/12/2026· UNKNOWN OR OTHER

  Navigation system does not place the car in the correct location. The location will shift and "float" while trying to navigate. Toyota has acknowledged that the navigation failure is due to a firmware issue with no current available solution or repair. We have tried working with the dealer with repeated visits, a certified letter and arbitration with NCDS.

• 07/02/2026· VEHICLE SPEED CONTROL

  Sudden self-acceleration by new RAV4 hybrid with less than 1000 miles on it. I made a hard left at low speed onto an uphill residential street. Saw a car backing down the street 1/2 block ahead so I took my foot off accelerator to slow down. Instead, car self-accelerated while my foot was not pressing any pedal, and shot uphill and over a speed bump, throwing the car off course toward parked cars. I stepped hard on brake, and assisted braking probably also kicked in. Car slammed to a stop. No damage or injuries. I took the car to Toyota dealer service immediately to report and address self-acceleration. Was told Vehicle Control History confirmed an event but not its nature or cause; didn’t find problem. Dealer claimed they reported incident to Toyota national center as UA (Unintended Acceleration), as we requested. Returned the car to me without repair or further diagnostic steps. There was never any follow up by Toyota, local or national. One year later, a similar self-acceleration by this car after a hard left turn at low speed caused life-threatening event and damage. I was told then that Toyota corporate had no record of first UA incident. The 2nd incident is reported separately on this site. I have now realized it’s important to report each incident.

• 06/22/2026· TIRES

  Properly inflated at all times "Firestone Destination LE2 225/65R17" tire ruptured suddenly! There is a 1" radial slit in the sidewall near the beginning of the tread line.

• 06/20/2026· UNKNOWN OR OTHER

  As i was driving to work my sunroof shattered out of nowhere, there was no provocation. There was a big pop and then there were noises coming from the roof. When i checked I saw the sunroof had shattered into tine pieces. Toyota does not want to take responsability into this incident.

• 06/15/2026· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  UNKNOWN - On XXX, at just 7,741 miles, my 2025 Toyota RAV4 XLE Premium AWD (VIN: [XXX]) suffered a catastrophic and life-threatening complete mechanical and hydraulic transmission failure. The vehicle completely lost forward propulsion when placed in Drive mode, rendering it entirely immobile. When placed in Reverse gear, the transmission violently over-pressurized, causing the vehicle to suddenly surge and jump uncontrollably. Simultaneously, the dashboard displayed 6 critical safety system failures: 1. Check Engine — electronic control malfunction 2. Vehicle Stability Control System (VSC/TRAC) malfunction 3. Secondary Collision Brake System malfunction 4. Pre-Collision System malfunction 5. Parking Brake System malfunction 6. Advanced Ultrasonic Detecting and Ranging System malfunction Ourisman Toyota Chantilly (RO# XXX) has confirmed complete transmission failure. Fault codes found: P28167F — Pressure Control Solenoid H Actuator Stuck Off, P08BA7F — Pressure Control Solenoid L Actuator Stuck Off. Estimated repair cost: $11,347.42. While this failure fortunately occurred on a local road, had it occurred while merging onto I-66 or I-95 at highway speeds, it would have inevitably caused a catastrophic high-speed collision. This represents an extreme manufacturing defect and life-threatening safety hazard. Toyota Corporate Cases opened: #XXX (original case) and #XXX (full replacement request). I am requesting full vehicle replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 06/11/2026· VISIBILITY

  The contact owns a 2025 Toyota RAV4. The contact stated that while driving under normal conditions, the contact heard an abnormally loud, violent, and shattering sound. The contact then noticed that the moonroof glass panel had exploded without impact, causing shattered glass to fall inside the cabin. A police report was filed. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 12,838.

• 06/10/2026· WHEELS

  I purchased this car used in December 2025 with 10k miles on it. After 15k mileage, the rear tires were bald and I had to buy new tires. I then took it back to the dealer and had to pay to get an allignment, as I was concerned that is what was causing the tires to go bald so fast. That was less than 2 months ago and now I'm in getting the 20k service appointment and the rear allignment is now off way more than when I paid to get it checked. Apparently the rear wheels cannot be adjusted? The right rear is way off and this is for sure causing uneven wear on my tires. It is for sure an issue and should not be, in that the car is new. It is obvious it is a fault in design and for sure can cause major safety issues, let alone burn my money up in needing new tires every less than a year.

• 06/06/2026· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  2 incidents of Sudden Unintended Acceleration. No warning lights etc in either. Car damaged but available for inspection. Now encountering difficulties initating Toyota investigation. 1st incident (4/18/25; mileage 967) occurred after a hard left turn. After turn onto uphill street, I took my foot from accelerator to slow and maintain distance from a car backing down hill ahead. Instead, car self-accelerated and shot uphill, over speed bump with increasing speed. Did not respond to braking until it was close to hitting a parked car. Stopped with a slam; probably brake assistance engaged. No damage or injury, but I was shaken. Took car immediately to Toyota dealer to inspect. Was told RoB confirmed an event but not its nature or cause; identified nothing wrong. They hypothesized cruise control might have been triggered accidentally (no evidence, not plausible). Claimed they submitted report to Toyota national center. After 2nd incident, Toyota national said they had no record of 1st event. Their standard safety inspection protocols were not followed. Returned car to me without repair or follow up. 2nd incident ensued. 2nd self-acceleration event (2026) also occurred after hard left turn to make U turn at low speed, braking while completing turn. When I took my foot off brake, before I could press it on accelerator, car shot diagonally across street. Jumped curb and traveled at considerable speed 100' up landscaped slope. Destroyed 6 large shrubs and 3 trees 9' tall. Did not stop despite constant driver braking. Forward collision prevention system did not engage to prevent uprooting trees. Car stopped only after I turned steering wheel sharply to left to avoid hitting a full-size tree trunk. Then car responded to braking, acceleration ended, car stopped next to tree without impact. Terrifying life-threatening event but only damaged landscape and car. Police came, assessed incident, determined not a police matter, did not file police report.

• 06/05/2026· SERVICE BRAKES

  The brakes have been overly sensitive... but then, without warning, braking power is completely lost. This has happened on 2 separate occasions... the pedal goes all the way to the floor and provides ZERO braking power. We can no longer trust this car on the road. Toyota sent someone to inspect the vehicle and they claim that they have found no problems or issues and that they have not been able to reproduce the problem. There were no warning lamps or message; there were no prior symptoms, other than the brakes were overly sensitive. These symptoms occurred immediately after purchasing the car. Toyota refuses to purchased the car back from us, and now we are stuck with a very dangerous vehicle. Interestingly, I have found others talking about EXACTLY the same symptoms on other Toyota Rav4 vehicles.

• 05/28/2026· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  My daughter reported an incident that occurred on XXX while driving this vehicle. As she drove, it slammed on the brakes (without any input from her) causing her to skid. The vehicle brought itself to a stop and the engine turned off. She reported that there were no vehicles or other object close to the front of her vehicle. The incident did not cause a crash or cause anyone to be injured. It was, however, a very scary situation that almost caused her to be rear-ended by the vehicles that were following her. The car was taken to Cobb County Toyota in Kennesaw, Georgia for an inspection the morning of May 28, 2026. As of this submission, the vehicle is still at the dealership service department for inspection.

• 05/24/2025· STRUCTURE,UNKNOWN OR OTHER

  Enter water when open doors after to rain. All the doors. Dealer in Puerto Rico not resolver problem.

• 05/19/2026· UNKNOWN OR OTHER

  The multimedia screen which shows the map and direction guidance became to blank occasionally, just white grey since February 2026. I immediately lost the direction. It could be back by restarting the engine at the beginning. The problem got worse, happened more often, some times the screen couldn't be back by restarting engine, but I found that it could be reset by pressing the volume button for long time. I reported to Toyota local dealer - Hendrick Toyota Apex and Toyota Brand Engagement center, the case manager is Freddy. The local dealer run diagnosis twice, couldn't detect any problem. On May 11, the screen totally died, black, no any light. Restarting engine or pressing the volume Botton couldn't get the screen back any more. the audio system is still working, I tried to use the map on my iPhone, the direction map couldn't be showed, only the text direction shows. Because the system let map show on screen, it assumes that the map shows one screen but it is not. I lost car screen and the phone direction at the same time. Plus the backup camera doesn't show on the screen. Therefore, it is underivable in any unfamiliar area, and dangerous to drive in neighborhoods. I reported to local dealer and Toyota Brand Engagement center with videos. May 18, the local dealer run diagnosis again, found nothing wrong. But before I leave, the screen became blank. This morning it happened again. The problem is not fixed. Freddy told me he suggested to local dealer to replace the screen, I am waiting Hendrick Toyota Apex call me for the appointment. I can't upload videos. If you want to see the videos, please tell me where and how to upload the videos. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 05/17/2025· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  Check engine light came on as well as hybrid malfunction message. While on the highway could not accel or go past 60 mph, gas pedal would then not work and speed went down, I pulled car over to breakdown lane and car abruptly stopped and would not move. Many warnings flashed and car needed to be towed. Temperature rose and ignition messages came up, steering wheel locked and car was not drivable.

• 05/16/2025· UNKNOWN OR OTHER

  Sunroof leaks during rain events. If this continues to be a problem can cause rust, mildew and mold issues which can lead to respiratory issues. This was noted by the dealership today as well.

• 05/12/2026· VEHICLE SPEED CONTROLCrash

  COMPONENT: Electronic Throttle Control System (ETCS) / accelerator pedal. Vehicle is available for inspection at Autocentro Toyota, San Juan, PR, where it has been retained since 2/28/2026. INCIDENT: On 2/28/2026 at 7:45 AM, while entering a private driveway at under 5 MPH to park, my 2025 Toyota RAV4 Hybrid SE (VIN [XXX] , 3,164 miles) suddenly and involuntarily accelerated without driver input. I categorically affirm I did NOT press the accelerator. The vehicle struck a metal gate, causing frontal damage. Airbags did not deploy. OEM floor mat was properly secured; no aftermarket parts installed. SAFETY RISK: Sudden unintended acceleration at low-speed parking maneuver. Had a pedestrian, child, or another vehicle been in the path, this would have caused serious injury or death. The defect is unpredictable and the driver cannot anticipate or override it. INSPECTION: Vehicle inspected 3/20/2026 by Engineering Analysis Associates (EAA), a firm contracted and paid by Toyota — NOT independent. EAA downloaded electronic data and concluded the accelerator was pressed 1 second before impact. I dispute this finding: I did not press the pedal. No independent inspection has been allowed. Full EAA report was never provided to me. On 4/23/2026, Toyota Motor North America (Ms. Delve L., Legal Claims Administrator) declined assistance based solely on EAA's data. WARNING SIGNS: UNKNOWN. No warning lamps, messages, or prior symptoms appeared before the incident. The vehicle had functioned normally since purchase on 4/25/2025. ADDITIONAL: Vehicle retained by dealer 73+ days without repair or substitute vehicle. Consumer complaint filed with Puerto Rico DACO (Case XXX). Similar unintended acceleration incidents reported in 2024 RAV4 Hybrid and Prime models in NHTSA database. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 05/10/2026· POWER TRAIN,FORWARD COLLISION AVOIDANCECrash

  2025 Toyota RAV4 XLE 4 door utility 2.5L 4 Cyl Gas A AWD unexpected sudden acceleration My safety as well as other vehicles and occupants as could have been at risk. National Transportation Safety Boaed has confirmed 57 cpmplaints of same issue. Vehicle determined total loss by insurance inspector, Va State Police. No warning lamps, messages, or other symptoms proir to the problem.

• 05/05/2026· ELECTRICAL SYSTEM

  The Toyota app has stopped updating vehicle data and there’s information missing entirely. The satellite symbol has a line through it on the media screen as well. When I try to opt out on the app, I get an unexpected error and to try again. It seems as though the DCM in my car has stopped communicating with Toyota’s servers.

• 04/30/2026· SERVICE BRAKES

  On April 29, 2026 around 10:00 PM, my 2025 Toyota RAV4 experienced sudden brake failure. The pedal became hard and I lost stopping and steering power. At the same time, Check Engine, battery warning, steering warning, and ‘Not Ready to Drive’ all appeared simultaneously with no prior warning. I brought it to a Toyota dealer the next morning and they found no fault. The vehicle is available for inspection.

• 04/28/2025· VISIBILITY

  The contact owns a 2025 Toyota Rav4. The contact was experiencing dizziness, nausea, and lack of focus in vision while in the driver's seat and looking through the windshield. The contact took the vehicle to the dealer who sat in the driver’s seat and noticed the glass was magnified in certain areas causing visual distortion and warping in certain areas of the windshield. The windshield was replaced. The contact experienced the same physical reaction to the new windshield. The dealer was contacted, and a message was left. The contact learned that the manufacturer had outsourced the manufacturing of the windshields from a company called AGC. The windshield was not replaced a second time. The manufacturer was not informed of the failure. The failure mileage was approximately 495.

• 04/24/2025· POWER TRAIN,VEHICLE SPEED CONTROL

  I have owned this new vehicle for only approximately 2 months and have had at least 4 instances where the vehicle does not respond immediately to my foot on the accelerator when attempting to restart from a stop. Three times I was at a stop light and when I attempted to go as the light turned green there was no acceleration response from the gas pedal for a couple of seconds, and in two of the instances because I had my foot pressed far on the gas attempting to get power, there was a sudden acceleration and lurch forward. Most recently, on the fourth occasion I was turning out into traffic from a parking lot after being at a standstill and got no response and instead rolled slowly out in front of an oncoming car until after a few seconds the accelerator finally responded and I could go. I believe this is a safety risk as it could happen when I was attempting a left turn in traffic, which would subject me and my passengers/children to an extreme risk of being hit. I took the car into the dealership after the first two instances and they were not able to reproduce the incidents and offered no help. There are no warning lamps or indicators that appear when this occurs. The first incident occurred about three weeks into my ownership of the vehicle.

• 04/21/2026· ELECTRICAL SYSTEM

  There is a parasitic drain on my battery coming from the ECM and electrical system causing it to drain my 12V battery.

• 04/15/2026· STRUCTURE,UNKNOWN OR OTHER

  The left mirror is a blind site when making a left turn at stop signs. The front hood is too high. In a parking lot you can't see the curbs. Toyota said jack up the seat. That does not help. kids can't be seen in front of the car. This is a safety issue. The number of selections to set the car for driving don't work for older people. The gas and break petal don't work for disabled people.

• 04/11/2026· UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  My car say front camera not working