2025 KIA Telluride

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/15/2025· STEERING,LANE DEPARTURECrash

  The contact rented a 2025 Kia Telluride. The contact stated that there was damage to the rear bumper upon retrieval. While using lane assist, traveling around a curve at 55 MPH, the steering wheel was pushing and pulling, and failed to turn and continued going straight; the vehicle crossed the highway and crashed into a ditch. There were no warning lights illuminated. The contact sustained injuries to his back and had bruises, but no medical assistance was provided. The vehicle was towed to a tow lot. The air bags deployed. There was no reported fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The rental company was notified of the failure. The manufacturer was not notified OF THE FAILURE. The failure mileage was approximately 33,000. The VIN was not available.

• 12/10/2025· STRUCTURE

  The contact owns a 2025 Kia Telluride. The contact received notification of NHTSA Campaign Number: 25V494000 (Structure) and requested to be removed from the recall distribution list. The local dealer was contacted, and the vehicle was repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure.

• 11/23/2024· VISIBILITY/WIPER

  My 2025 Kia Teulluride that I bought on 10/21/2024 was sitting in my garage over night on 11/20/2024. The next morning 11/21/2024 I went to leave for work and notice a huge crack in the windshield. Goes from the driver side to about half way to the middle of the windshield

• 11/20/2025· STRUCTURE,UNKNOWN OR OTHER

  There is excessive noise coming from both passenger and driver side windows. It sounds like the windows are opened. The dealer said all seals are good but the windows aren't fully sealed.

• 11/10/2025· UNKNOWN OR OTHER,VISIBILITY/WIPER

  The front windshield cracked without any impact. We drove from Arizona to California and nothing hit our windshield or vehicle. We parked our vehicle and a visible spot and can see our vehicle at all times and we walked out and our windshield was cracked down the middle all the way into the driver side. It was not drivable back home to Arizona.

• 11/08/2025· UNKNOWN OR OTHER

  We traveled from bullhead Arizona to garden Grove California. We didnt hit nothing on the road and we parked our car and have full visibility of it. Nothing touched my new car. When we walked out there was a huge windshield crack right in front of the camera. I had to get a new windshield. This is a well known issue with kia. Is there windshield crack while in the highway.

• 11/04/2024· VISIBILITY/WIPER

  I bought my Kia Telluride on 10/25/2024. The windshield already has a long crack in the bottom going upwards. A chip will not normally extend the crack this quick after a purchase of a vehicle. Several others have reported the same from earlier Telluride models. This poses a driving risk especially at night with glare.

• 10/16/2025· ELECTRICAL SYSTEM,ENGINE

  When I was driving in a parking lot on 10/03/25 my car displayed a warning light that my engine was off and I needed to shift to neutral or park. This occurred 2 other times. I was parked at a light on 10/10 and when we left dinner and turned at a light it also shut off. This is a huge safety concern and I have saw others reporting this same issue.

• 10/08/2025· ENGINE

  ENGINE SHUTS OFF WHILE DRIVING. VEHICLE WARNING "Engine off! Shift to P or N, then start engine". THE ENGINE SHUTTING OFF WHILE DRIVING IS A SERIOUS SAFETY HAZARD IN REGARDS TO HAVING ENOUGH TIME TO PULL OVER FOR ONCOMING TRAFFIC AND STALLING AT/IN A STOPLIGHT/INTERSECTION. THE PROBLEM HAS NOT YET BEEN REPRODUCED BY THE DEALERSHIP. THE VEHICLE HAS BEEN INSPECTED BY THE MANUFACTURER WITH THE SERVICE CENTER STATING "COULD NOT DUPLICATE CONCERN AT THIS TIME, VEHICLE HAS ALREADY BEEN DRIVEN ABOUT 68 MILES AND VEHICLE IS OPERATING NORMALLY". THERE WERE NO OTHER warning lamps, messages or other symptoms OF THE PROBLEM PRIOR TO FAILURE. FIRST APPERANCE ON 8/4/25. OTHER INSTANCES OCCURED ON 9/15/25 AND 10/6/25.

• 10/08/2025· EXTERIOR LIGHTING,FORWARD COLLISION AVOIDANCE

  Front lights gets foggy when it gets hand wash, contacted the dealership and they are willing to replace the “Gasket” because the headlights must have “ventilation”. While driving with nobody in front the collision warning went off non stop, the road was completely clear.

• 09/19/2025· UNKNOWN OR OTHER

  On 9/18/2025, I was driving on the highway my son and I and out of nowhere I hear a loud explosion and glass shattering. I was terrified, fearing for my life not knowing or understanding what happened. Trying not to wreck. My sunroof was closed but when I pulled over and looked on top of the truck, my whole sunroof had shattered. I called 911 they came and examined the incident. I was directed to contact KIA asap being that they didn’t see any thing that could’ve caused the impact. I contacted Kia and was told by the service dept that they never heard of that happening.

• 09/10/2025· EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM

  Headlights does not display full visibility. It seems as if the headlights are cut off with blind spots. Headlights doesn't have full visibility. Headlight projection is not 100 percent. Dealership technician have said Kia doesn't have a fix for it. When its very dark outside their are blind spots. Vehicle smokes from the exhaust. Upon acceleration it feels rough with trembling effect.

• 09/03/2026· ENGINE

  The engine just quit when making a brake stop. The RPM went to zero. The car did restart but failed a second time after a few feet of travel and the brakes were applied. There are at least two occasions when the issue occurred within the past two days.

• 09/03/2025· VISIBILITY/WIPER

  The contact owns a 2025 Kia Telluride. The contact stated that while driving approximately 40 MPH in the snow, the windshield wipers were activated to clear the snow, but failed to consistently wipe the windshield. The wipers were intermittently operating. The vehicle was taken to the dealer, who was unable to identify the cause of the failure. The vehicle was taken to the dealer again; however, the vehicle was not diagnosed because the dealer was unable to duplicate the failure. The failure persisted. The vehicle was taken a third time to the dealer to be diagnosed, and the contact was informed that the ring sensor was defective and needed to be replaced. The ring sensor was replaced; however, the next day, during a rainstorm, the wipers failed to operate while activated. The failure reoccurred several days later while driving approximately 40 MPH. The vehicle was returned to the dealer for a fourth time, but the vehicle had not been repaired. The vehicle remained at the dealer for a month. The manufacturer was informed of the failure, and a case was opened. The failure mileage was 25.

• 08/31/2026· STEERING,ELECTRICAL SYSTEM,ENGINE

  When driving, the vehicle will randomly shut off. Every warning light and alarm goes off. A message displays on the dash to put the vehicle on P or N to turn it back on. This happens unexpectedly. It's happened about 16 times on the road and 2 times on the highway. This is a huge safety issue. We notified Kia in February of 2026, it's gone to the service department three times for this specific issue, but they are unable to recreate it and no codes are stored for them to see what it is. We have recorded the vehicle acting up once it's shut off. This is very dangerous that a new vehicle randomly shuts off, and no one knows what is causing it. Now, it's at the shop for the fourth time. This time the Kia engineers have asked the service shop to replace the engine harness along with some sensors and send it to them. We have recordings from Kia Corporate stating they dont know what it is. We even have a service tech stating that there are others with this issue but no solution has been uncovered.

• 08/31/2026· UNKNOWN OR OTHER

  The infotainment displayed information at the home screen is so close to the left side of the screen that when you are driving, the steering wheel and my hand covers it, so if you want to see it, you need to bend a little to the right, taking the eyes off the road and more important things. The infotainment screen design has a lot of room in the middle of the screen, but somebody with very low brain, had to be a designer, decided it was better to put everything stacked up to the left

• 08/30/2026· ENGINE

  XXX While returning home, we were crossing a 2 lane bridge between [XXX] and [XXX] heading south, an audible alarm sounded which surprised us and then a message appeared that stated "Engine Off! Shift to P or N, then start engine". Once I was able to refocus my attention to the road, I was then able to turn on my hazard signals, stop the car, shift to Park and restart the car. This all happened with traffic behind us and passing us in the opposite lane. There was no shoulder for us to use to get out of the way. I should also mention we were traveling a slight incline up as we were crossing the bridge. This was the second time this has happened and again it forced my attention away from the road so that I could address this issue. Fortunately, this all occurred at low speed, approx 30-35mph. Also, luckily I was able to get my hazard signals on quickly to avoid being rear ended by the sudden occurrence of this issue. I cannot imagine what would have happened if I had been on the interstate going 70+ mph. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/30/2026· ENGINE

  Aug 1 2026 While going to the store, we were waiting at the traffic light to make a left turn, as we were making the left turn and entering the store parking lot an audible alarm sounded which surprised us and then a message appeared that stated "Engine Off! Shift to P or N, then start engine". Fortunately, there were no cars behind us and I was able to shift into Park and restart my car. With engine off, we had no power steering or power brakes, again a surprise. Had there been traffic, the surprise loss of these features makes driving difficult. The mere fact that the engine turned off alone in the middle of a parking lot driveway poses risk for traffic accidents ... I had to take my eyes off the road to see what the alarm was. Not to mention had there been traffic and having to stop in a somewhat sudden manner could pose risk for accidents from other drivers.

• 08/30/2026· ENGINE

  XXX While returning home, we just turned right onto [XXX] heading south, an audible alarm sounded which surprised us and then a message appeared that stated "Engine Off! Shift to [XXX], then start engine". This same problem had just occurred not 10 minutes earlier while crossing the bridge into [XXX] from [XXX]! Again, once I was able to refocus my attention to the road, I was then able to turn on my hazard signals, stop the car (no power brakes), shift to Park and restart the car. With this occurrence we were fortunate there was no traffic on the street at the time. We were traveling at about 30mph. This was the 3rd occurrence of this problem within 30 days and then again the second occurrence within 10 minutes on the same day! This is really unnerving to have your engine turn off suddenly and without any warnings! Just a sudden audible alarm, followed by a message, completely out of the blue! I cannot imagine what will happen should this occur at higher speeds? Or in heavier traffic? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/28/2026· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  The contact owns a 2025 Kia Telluride. The contact stated that while idling, the vehicle stalled. The contact turned off and restarted the vehicle with no issues. The contact stated that while making a left turn on another occasion, the vehicle stalled and was nearly rear-ended. The vehicle was shifted to park(P) and restarted. The contact stated that while making a left turn on a third occasion, the vehicle stalled. The vehicle was restarted. The immobilizer, oil, and check engine warning lights illuminated after the failure occurred on each occasion. The vehicle was taken to a dealer; however, the failure could not be duplicated. The manufacturer was notified of the failure. The failure mileage was approximately 14,000.

• 08/26/2026· VISIBILITY/WIPER

  Large crack appeared with no impact point observed. Crack originates at the bottom edge under the hood. There is an ongoing class action regarding similar incidents involving KIA windshields.

• 08/26/2026· SEAT BELTS

  My stepson became entangled in the left/driver-side third-row seat belt of my 2025 Kia Telluride. The seat belt webbing became wrapped/tangled around him and the seat belt retractor entered a locked condition. We were unable to create sufficient slack or otherwise release him from the restraint. The situation became a life-threatening child-entrapment emergency. Emergency services were called and responders ultimately had to CUT THE FACTORY SEAT BELT WEBBING to free the child. My safety concern is not simply that a child became tangled in a seat belt. My concern is that once this occurred, the seat belt/retractor locked in a manner that prevented us from releasing tension and freeing the child. The only available solution during the emergency was for first responders to physically cut the restraint. I have also located reports from other Kia Telluride owners describing children becoming trapped when third-row seat belts became wrapped around an occupant or seat component and subsequently locked. I am also aware of NHTSA Recall 26V356 / Kia Safety Recall SC372 involving certain 2027 Kia Telluride and Telluride Hybrid vehicles. That recall involves a driver's seat belt emergency locking retractor that may lock while the webbing is being extended. I understand that recall applies to a different model year and seating position and may have a different underlying cause. However, because my 2025 Telluride experienced a serious seat-belt retractor locking event involving a child, I am requesting that NHTSA evaluate whether this incident represents a related, broader, or separate restraint-system safety defect. This incident required emergency intervention and destruction of the factory seat belt to free a child. I believe the inability to release tension from the locked restraint presents a potentially serious child entrapment and strangulation hazard, and I am requesting that NHTSA investigate.

• 08/20/2026· ENGINE

  This started May 8th and is still going on. Engine randomly shuts down while driving. Vehicle alarms and message says Engine OFF Shift to P or N then start engine. No warning, happens about once a week. Very scary when in traffic and I cannot move because my engine randomly shuts down. The dealership has had it 3 different times totaling 6 weeks and 5 days and cannot duplicate it.

• 08/20/2026· ENGINE

  Over the course of two days, the engine stalled when decelerating at intersections three different times. The engine died with warning lights on the dash and a message: “ Engine Off! Shift to P or N then start engine.” I had to completely stop, shift gears, and then restart the engine, then back to drive. This happened at or near intersections, creating a significant hazard for myself and others around. Dealer has not been able to identify or replicate the issue. I have safety concerns about driving the vehicle. The third time happened without auto hold or auto start/stop on.

• 08/18/2026· UNKNOWN OR OTHER

  Was driving with my husband and granddaughter in the car and had just left the house. Horrible, loud explosive sound like a gunshot and glass sound and glanced to make sure all glass ok and our granddaughter was safe. Could see the glass flying behind us and a car swerving behind us to miss it. Pictures are attached showing the sunroof exploded outward. No glass hanging down, no central area point of impact. Sunroof glass is covered under Kia’s 5-year/60,000-mile New Vehicle Limited Warranty; if they deem it to be spontaneous explosion or shattering. Contacted KIA Corporate. Case # XXX Under advice of KIA corporate (Crystal), we took it too the dealership I bought it from this am , [XXX], and they were very rude and dismissive; argumentative. He said it would take about 4 days to even inspect it, that they were behind. And he could rent a car to me for $40 a day. This is a new car I have had for less than 6 months! So, we took it to Boomer Kia. (after calling and they were so nice, they said come right in) He said he took pics, submitted our pics and description of story to the KIA rep that came in this afternoon, and he just called and said they will not cover it under warranty. It is in the warranty but is up to their discretion. Everything I read said this happens and that is why people are suing Kia....because they do this and dont cover and because they refuse to a recall, even though they know either the glass or the setup is faulty. I think personally the construction allows for heat to get under the glass and that is why it explodes outward. Spontaneous shattering and exploding sunroofs have been proven to occur in the 2025 Kia Tellurides due to thermal and/or structural pressure. There are numerous lawsuits, currently. Photos all over the internet that look just like mine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/18/2026· STEERING,ELECTRICAL SYSTEM,ENGINE

  2025 Kia Telluride, rental vehicle, 29,450 miles at failure. Driving XXX W toward the [XXX] exit with my wife and two children (ages [XXX] and [XXX]), the cluster lit with simultaneous failures: electric power steering, electronic parking brake, ABS, stability control disabled, tire pressure monitoring, forward collision-avoidance, lane keeping, master warning. I photographed it. Nothing about how the vehicle drove had changed. At highway speed traveling straight, steering effort felt normal. There was no progressive degradation and no warning I could feel. I noticed a slight difference changing lanes for the exit. On the ramp itself, a banked turn taken at speed, the wheel required extreme force to turn. The loss of assist was undetectable until significant steering input was actually required, which happened mid-maneuver on an interstate ramp. I am a large, physically strong adult and forced the wheel through the turn. I do not believe a smaller, older, or weaker driver could have completed it, and a crash at that interchange seems a likely outcome for many drivers. Stopping on an interstate shoulder with two young children seemed more dangerous than continuing two miles to the airport exit, so I continued, with ABS and stability control also inoperative. The vehicle developed harsh, jerky shifting and audible clunking. In the rental return lot the wheel would not turn far enough to complete a tight turn. I shifted to reverse; the vehicle did not move, then shut down completely and would not restart. With the vehicle dead the front doors opened, but the rear doors and liftgate would not, and the windows were inoperable. My children were confined inside roughly 10-15 minutes at 86F until an employee climbed in from the front and released the rear doors from inside. The inability to open rear doors or the liftgate from outside after a total power loss is a serious defect in its own right. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/09/2026· ENGINE

  While driving, car alerted “Engine Off! Shift to P or N, then start engine”. I had to immediately pull to the side of the road and follow instructions. Due to previous unresolved issues car has had I recorded the message car was giving.

• 08/09/2026· UNKNOWN OR OTHER

  During less than 25 mph vehicle Emergency Alarm stating "Engine Off Shift to P or N Then Start Engine". This causes loss of acceleration capabilities in active traffic and forces the car to stop to clear alarm in active traffic. At no time is the engine off during the alarm and I believe this is a false alarm caused by electronics. Video of alarm in real time available upon request.

• 07/30/2026· ENGINE

  On four different occasions the car starts flashing red saying to immediately put in park. We lose all control of the car, have to slowly coast to the side of the highway and turn the car off. When we turn it back on, drive again, it will happen shortly after. It has happened two different days about a month apart, two times each day. Our car has been at the dealership for two months and since they can’t duplicate it Kia consumer affairs says we have to go get the car and deal with it.

• 07/30/2025· UNKNOWN OR OTHER

  While driving, the sunroof on my 2025 Kia Telluride exploded. I had the it closed, so at first I didn't know what had happened. It sounded like I was shot. I was not able to pull over right away due to traffic. However, I heard the glass and figured out what had happened. Nothing struck my car. When I was able to get out and look at it, the glass was protruding outwards and a huge hole was left in the middle of the sunroof (almost as big as the sunroof). This was terrifying. It could have caused a wreck, easily. I immediately hit my breaks and the car behind me swerved. I had to think fast and tell myself to just keep driving because I couldn't pull over safely. I have not had the vehicle 7 months and thought this would not be a problem to get fixed because it is clearly not a normal, or natural occurance. At first, they gave me a loaner and said it would be fixed. Then, they said it could not be covered by warranty and to come pick it up and return the loaner. When, I got there I asked to speak to the manager and he was very sympathetic. He said he would work on getting it paid for and let me take the loaner back home. I am still waiting to hear from them. However, the internet tells me this is a recurring problem. Therefore, I wanted to fill out this form so that the NHTSA is aware of this issue.

• 07/20/2026· STRUCTURE

  The contact owns a 2025 Kia Telluride. The contact stated that while driving at an undisclosed speed, road debris damaged the A/C condenser. The contact stated that the front grill setup failed to adequately protect the part from road debris. The dealer was contacted and determined that there was a hole in the A/C condenser. The vehicle was not repaired. The manufacturer was contacted and denied the warranty coverage due to the condenser being damaged by an external force. The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 7,000.

• 07/19/2026· VISIBILITY/WIPER

  The car randomly has inoperable wipers. Both in auto and non auto mode. Doesn’t happen every time but it has happened to my family on rainy days. The back wipers work fine. We took the car to the dealer and they said nothing was wrong, they blamed it on my cars window tint. Which makes no sense considering it’s not functioning in the non-auto position. After doing my own research it seems to be that multiple other owners have had similar issues, yet no recall has been issued.

• 07/17/2026· UNKNOWN OR OTHER

  clear coat is coming off of 2025 white kia Telluride

• 07/13/2026· VISIBILITY/WIPER

  After sitting in the driveway came out to a crack across half of the passenger side front side window. In the process of getting the window replaced. Crack originated from underneath the door trim. Window could shatter while driving if not noticed.

• 07/11/2026· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  Twice I was making a right hand turn through a green light and an alarm sounded and the dash displayed an ”Engine Off” message. I was able to pull over and restart the car. I took it to the dealership but they were not able to replicate the incident. They told me that they tightened a few connections and sent me on my way. About three weeks later, I was driving straight at about 45mph and it shut off again. Fortunately I was again able to safely pull over and restart the car. This time I recorded it. I will return it to the dealership ASAP. I am afraid this will happen again while I am on the freeway or in heavy traffic and I won’t be as lucky as I have been.

• 07/10/2026· ENGINE

  About 3 months after I bought a brand new 2025 Telluride the vehicle started to randomly accelerate rapidly without increasing the gas while driving and stall when idling at lights, stop signs, or slowing down and would not turn back on for several minutes. When it does start back it misfires causing a rumbling before the check engine light comes on. It would show code P006800 and P017100 saying “critical engine error”. Despite bringing it into the dealership multiple times we were told they couldn’t replicate the problem and sent home with no solutions just to wait for it to happen again. This became a extremely dangerous situation when recently at a red light on a busy highway in the rain my telluride stalled leaving me and my young children trapped inside unable to restart the car while other vehicles flew past narrowly missing us. I’m extremely concerned for the safely of my children if we continue to drive this car. We went back to the dealership just to be told that Kia may not honor our warranty despite this being a documented problem with the 2025 Kia Telluride.

• 07/10/2026· ELECTRICAL SYSTEM

  All vehicle electronics shut down when ISG / ASG activates

• 07/07/2026· ELECTRICAL SYSTEM,ENGINEFire

  The vehicle had been throwing different Electrical Codes for several months around August through December 2025. The last code it through was an engine management system error. On December 22nd 2025 the car caught fire in the engine and exploded while parked in the driveway. Fire investigators are leaning towards in electrical issue in the engine. I currently have an additional 2025 Kia Telluride vehicle which is also starting to display some of the same electrical messages

• 07/06/2026· ELECTRICAL SYSTEM,ENGINE

  System/Component Malfunction & Availability: The vehicle's electronic safety and engine control systems malfunctioned while driving at speed. This issue has occurred twice under identical thermal conditions, with the first instance occurring on 5/19/26. The vehicle is fully intact and available for inspection upon request. Safety Risk: During the first incident, a false dashboard warning triggered, but the physical engine remained running. However, during the most recent incident on 7/2/26, the defect escalated and the engine physically stalled while driving on the road in high 90-degree ambient temperatures. The stall caused an immediate loss of power and a complete loss of power steering assist, making the vehicle incredibly difficult to control and creating an imminent risk of a crash for my family and surrounding drivers. Dealer Confirmation & Inspection: Following the first incident, the vehicle was brought to a certified Kia dealership and left in their custody for 10 days for diagnostic troubleshooting. The service center stated they could not pull a hard diagnostic trouble code (DTC) and could not replicate the failure on a standard test drive. No other entities (police, insurance) have inspected the vehicle yet. Corporate Kia was notified (Case #26160914) but refused to authorize a specialized repair plan because the dealer could not replicate the issue. Warning Symptoms & Messages: There were no mechanical or performance warning symptoms prior to either failure. Both times, the issue began instantly with an audible cabin alarm and a prominent dashboard display message stating: "Engine Off! Shift to P or N, then start engine." During the first incident, the physical engine remained running despite the message, allowing us to safely pull over and reset the vehicle by cycling the ignition. During the second incident, under the same extreme outside heat (high 90s), the engine completely cut out mechanically, creating a severe stalling hazard.

• 07/05/2025· VISIBILITY/WIPER

  I was driving on the freeway and the windshield spontaneously cracked. There were no cars even around me. My 2025 Telluride is brand new and has less than 5k miles on it…

• 07/02/2026· ENGINE

  My 2025 Kia Telluride has experienced seven engine overheating events across three separate incidents, all under identical conditions: air conditioning on while climbing in altitude on Colorado mountain highways. Incident 1 (XXX: Driving from [XXX] to [XXX]. Engine temperature gauge reached H and the "Engine Overheated" warning displayed. Pulled over and allowed engine to cool. Vehicle taken to Kia dealership; diagnostics found no fault. Incident 2 (XXX): Driving to [XXX]. Vehicle overheated twice on the same trip. Dealership kept vehicle for multiple days; reported no issues found. Incident 3 (XXX): Driving to [XXX]. Vehicle overheated FOUR times during the trip, including in an area with no cellular reception. Occupants included an infant and a [XXX]. Had the engine failed completely, we would have been stranded with no ability to call for emergency assistance. The failure is consistent and reproducible in real-world conditions (sustained grade + AC load) but has not been reproduced by dealership diagnostics performed at the shop. No fault codes were reportedly stored. The pattern is consistent with a cooling system deficiency under high load (cooling fan circuit, condenser airflow, or thermostat), and similar complaints from other Telluride owners describe the same scenario with dealers unable to replicate. Safety concern: repeated loss of propulsion capability on steep mountain grades, risk of engine failure and stranding in remote areas without cell coverage, with young children aboard. Two dealer service visits have not resolved the defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 07/01/2026· ENGINE

  In the past 2 days, my vehicle engine has shut off 11 times while driving. This is happening while I am moving so it is a huge safety issue for myself and other drivers. Over the course of 3 months, the vehicle has done this over 20 times. It happens when coasting, slowing down at a stop light and people in the other lane start moving, going through roundabouts, turning when there is oncoming traffic, and moving through congestion. The engine kills, lights flash and beeping starts. It says to put the engine in P or N and restart the engine. I have no power so I try to do this quickly or have the ability to pull over but most times that is not the case. This is a severe safety issue. The dealership says they cannot find anything wrong with the vehicle.

• 07/01/2026· UNKNOWN OR OTHER

  My 2025 Kia Telluride is suddenly shutting off in traffic. It first happened 6/24/26 I was pulling away from a stop light when my vehicle shut off. I received a red dash as you would for collision warning and a message to shift into park or neutral to restart the vehicle, I tried to restart it started but without RPM's then would not restart my husband had to push the vehicle off of the roadway. I then tried to restart it again it started and shut off in less than 20 feet. I had it towed to the dealership after keeping it 1 week they say they can not recreate the problem. I picked up my vehicle yesterday and it again shut off before I made it 2 miles down the road, I had stopped at a stop light to make a left turn accelerated to make to my turn and the vehicle again shut off I coasted into a parking lot was able to restart it and drove it back to the dealership. The vehicle is currently with them. The vehicle had no warning lights prior to this happening everything was fine in fact when the vehicle shuts off the radio and Air Conditioner stay running like nothing happened. I have searched the internet and found many others having this issue with their dealerships also saying they can't recreate the problem.

• 06/24/2026· ENGINE

  While driving, alarm bells go off and the display reads “engine is off. Pull over and put in p/n”. Car maintains radio but engine is off until able to be restarted. Has happened twice and been brought to dealership twice. They say there is no code showing and send us home without repairs. Extreme safety concerns for car to turn off mid driving.

• 06/23/2026· VISIBILITY

  The contact owns a 2025 Kia Telluride. The contact stated that while driving at an undisclosed speed, there was a loud sound coming from the sunroof glass before the glass shattered. There was no impact on the sunroof glass to cause the failure. Small glass fragments fell into the second and third row seats. The vehicle was taken to the dealer; however, the vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 22,000.

• 06/21/2025· UNKNOWN OR OTHER

  6/10/25 - 8:40am - Vehicle was in "comfort" drive mode and was stopped in traffic when it stalled. Vehicle would not move when foot removed off brake and pressing accelerator. Warning light "Put vehicle in park and re start vehicle". Driver able to put hazards on, place vehicle in park and restart vehicle. Dangerous situation. Contacted dealer for immediate inspection/resolution. Despite notifying the dealership of their dangerous vehicle they failed to act on it in a timely manner resulting in another dangerous scenario on 6/20. Dealership's first available appointment for service was scheduled for 6/26. During this time, driver would press a button so that the engine system would not shut off. This button must be pressed every time driver starts vehicle, or it defaults to the engine management system that turns the engine off when stopped in traffic. 6/20 - Stopped at a red light. Shut off in traffic again. Could not restart. Police arrived to help and troubleshoot. Would not restart. Could not place in neutral to push to side of the road. Attempted to find some button to unlock the transmission but button not there? Stuck in the middle of traffic for ~ 1 hour while waiting on tow truck.

• 06/19/2026· VISIBILITY/WIPER

  I purchased a 2025 Kia Telluride on 6/23/2025. In February 2026 I started having issues with the windshield wiper system. When I spray the front windshield, it would leak fluid on the back windshield. Brought the car in for service at the end of February and they said I needed a new motor, but never called me back to replace it. On 5/7/2026, I brought the car in and they couldn’t replicate the issue. On 5/28/2026 I brought it back, they again told me they couldn’t duplicate the issue. The service coordinator repeatedly told me this was a “feature”. When I picked it up, I replicated the issue immediately and they said I had some weird setting on which is why it happened. The issue continued so I brought it back 6/3. They claimed to have opened a tech line case with Kia so they replaced the motor and switch. I went to pick it up on 6/18 and the issue was still there. Again I have the service manager telling me it’s a “feature” and all Tellurides do this. Except the loaner I had for 3 weeks was the same year and model and did NOT do it. Also my car didn’t do this for the first 8 months I owned it. They swapped a piece from the loaner I had and put it on my car because the loaner wasn’t leaking. Swapping this piece did not fix the issue. They have no idea how to fix it and they never actually opened a tech line case with Kia. Confirmed this with Kia Consumer Affairs.

• 06/19/2026· ENGINE

  While driving the car the engine lost all rpm, as in it went to zero rpms. The electrical system did not lose power. The console flashed a red warning light and had a message that I should shift to park or neutral, and restart the engine. You must apply the brake to restart the engine. When you shift to park/neutral and restart the engine, everything works fine. There was absolutely no warning that this was going to happen. No noises, no console warning lights, nothing. I believe it is a matter of time before this causes an accident. The engine just quits without warning. It has happened mostly at lower speeds while decelerating or braking, but has occurred once on a highway. Should this issue happen in high traffic, or high speed, it could absolutely cause an accident. The car has been at a dealership since 21MAY over this issue. They have driven it, but have not found anything wrong. They found no stored error codes. We have had a loaner vehicle since then. I'm fearful they will force us to take the car back.

• 06/19/2025· VISIBILITY/WIPER

  As I was driving on the interstate, a small pebble hit the corner of my windshield (lower left corner on the driver side). It made a small chip that has quickly turned into a 3" crack. Upon inspection by a windshield repair company, it has been deemed unrepairable and the entire windshield must be replaced due to the location of the incident. I also have a small chip directly in the driver's line of sight in the windshield from the pebble as well. KIA Motors has a known issue on previous year (2020-2023) models of the Telluride, in which the windshields of these models chipped and cracked unusually easy (sometimes without anything even impacting it), clearly causing a safety issue. There was a class action lawsuit for many states. I now have to file a claim with my car insurance company to have it replaced, which will negatively impact all my future insurance rates.

• 06/17/2025· STRUCTURE

  The lower opening in the front grille allows road debris to damage the A/C condenser. This repair has an average cost of 2500.00 to 2800.00