2025 Hyundai Tucson Plug IN Hybrid

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2025· FORWARD COLLISION AVOIDANCE

  The automatic brake system triggers when there is no obstacle. It has caused the car to stop suddenly in the middle of the road and almost become rear ended several times. We took it to the Hyundai service center and they said they’ve had complaints of this before but checked the system and don’t see any issues.

• 12/23/2025· POWER TRAIN,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

  This vehicle has had numerous problems since I leased it. To summarize, at times the vehicle randomly shifts out of the ECO mode, usually into the SNOW mode. The engine has also raced, hesitated, bucked, rattled and vibrated when trying to change gears. Sometimes, these actions are subtle and sometimes they are borderline violent. This happens more frequently when the engine is cold. Additionally, the AEB system has activated a number of times while in stop and go traffic, even though the vehicle in front was moving forward. On at least 3 of these occasions, i barely avoided being rear-ended by the vehicle following me. The final issue that I have noticed is a problem with the odometer. It has appeared to work normally most of the time, but I have noticed times where I didn't think the odometer accurately reflected the distance I had traveled. I was able to synch the odometer with the trip odometer on a local road that I was quite familiar with. The trip odometer registered 1.8 miles while the odometer only registered 1 mile traveled. All of these issues happened multiple times and are intermittent. I have had the vehicle to Hyundai dealers on 5 occasions, and they claim to have not been able to duplicate any of the problems that I have been consistently logging in to a "diary" that represents a list of when I have noticed these issues. I have been in constant contact with Hyundai, but they promised to send out a factory rep, then reneged, instead relying on the local service techs. Said techs had the vehicle for nearly 2 weeks, but only drove it for 16 miles (until I called AFTER a determination was made and they hurriedly drove it an additional 22 miles to give the appearance of a more complete exam), using less than a quarter tank of gas. To me, this wasn't a thorough exam and appeared to be a cover-up to avoid having to buy back the vehicle. Note: these problems have occurred on multiple occasions, therefore the date below is the lease date.

• 12/22/2025· FORWARD COLLISION AVOIDANCE

  The car in front of me, 8 to 10 feet ahead, slow down and turn on their blinker. My car slammed so hard on its break. It threw me and my dog forward. It never gave us a warning until it slammed. There was plenty of time for me to slow down, but also the car was partially already in the turn lane. There is then 223 seconds where my car will not move forward. I am a sitting duck to cars coming behind me.

• 12/22/2025· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  I was travelling East in the left kane on the southern state parkway in Long Island, NY. The car in fron of me stopped short. I had plenty of time to slow down, then my car brakes locked up and I was almost rearended. Fortunately the driver behind me was alert and moved to the shoulder to avoid contact.

• 12/20/2025· UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  Multiple times the car has locked the brakes when there was a car several car lengths in front of me. This has resulted in me nearly being rear ended three different times. The force of the stop has also caused me to have neck and back pain. This is u safe and will result in injuries. There are many reports about this on Reddit.

• 12/18/2025· UNKNOWN OR OTHER

  -The center display screen system failed. The screen intermittently glitches, strobes, freezes or goes completely black while the vehicle is in operation. This screen controls GPS/Navigation, backup camera display, vehicle settings and warning alerts. The vehicle and system are available for inspection upon request. -The failure creates a significant safety risk. When the screen blacks out or strobes, I lose access to navigation, backup camera visibility, vehicle alerts and system controls. The strobing/glitching is distracting and unsafe while driving, and the loss of display during driving and parking maneuvers increases the risk of collision or injury to myself, passengers, pedestrians and other vehicles. -Yes, the vehicle has been brought to an authorized Hyundai dealership 5 separate times for the same issue. This dealership has attempted repairs, replacements, and troubleshooting of the screen system but the problem continues to occur. -Yes. The vehicle has been inspected multiple times by authorized Hyundai dealership service departments acting on behalf of the manufacturer. Hyundai corporate has also been contacted regarding the unresolved defect. -The primary symptom is sudden screen malfunction without warning, including flickering, strobing, freezing or complete black out. There are no consistent warning lamps prior to failure. The issue first appeared in August 2025 and has continued intermittently since that time. No collision, accident, injury or property damage has occurred as a result of this malfunction.

• 12/17/2024· EXTERIOR LIGHTING

  Drives side headlight has a dark spot on low beam that is in the drivers field of vision. This causes the driver not to be able to see clearly. A certain portion of the drivers field of view is blocked out. Please see the picture below. Took it to the dealer for repair, he acknowledged the black spots were in the drivers field of view but, he compared it to another 2025 Tucson with the same trim on his lot and the headlights were the same. Therefore, their was nothing wrong with the lights. However, he did agree that their were black spots in the drivers field of view that would inhibit the divers ability to see clearly at night. Attached is the Dealership repair order.

• 12/15/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  The dashboard and heads up display intermittently goes on and off. All warning lights are on when the dashboard comes back on. It goes off long enough to not know how fast you are going. Hyundai has this as a known issue for Limited trims of the Hyundai Tucson yet they only tell you to take it to the dealer for the vehicle to be fixed. Customers have taken their vehicle back to the dealership after the dealerships stated that the issue was fixed because the issue happens again a few days later. This is a safety issue that needs to be addressed.

• 12/15/2025· ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  Approximate date 10/7/2025. Driving 20mph clear daylight sunny conditions in right lane,another vehicle in left lane put on right blinker to merge in front of me into my lane. The merging vehicle was 3 car lengths ahead and had plenty of space to merge. Merging vehicle was only half way into right lane when without touching the brakes and no warning alarm the wheels locked up completely,skidding to a complete stop,almost got rear ended. 2 days later on 10/9/2025 same weather conditions while driving on highway the traffic was stop and go,speed 40mph. A vehicle ahead of me applied their brakes,no imminent threat, I placed my foot on brake pedal as a precaution,then brakes locked up so I pumped brakes thinking what else could I do? This did nothing,brakes remained locked until vehicle stopped. Almost got rear ended again. I can’t remember if any audible alarm or dash warning. These were the only 2 incidents with braking failure. Hyundai Dealer booked appointment but they could not find any issues with the braking system on 10/2025. Mechanic could not reproduce braking issue. When I picked up vehicle I spoke to the mechanic. He said “ if the braking issue occurs again please make another appointment. The salesman who I purchased the vehicle said “shut off the warning system”. Which I declined his offer. Thank you!

• 12/14/2024· ELECTRICAL SYSTEM

  Battery issue does not resolved, had to jump-start the vehicle twice, leading to significant inconvenience as I drove nearly an hour each way to the dealership. This situation has resulted in lost work hours and has left me feeling mentally and physically exhausted. Despite my efforts, I still have not received a satisfactory answer regarding the problem

• 12/10/2025· STRUCTURE,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCECrash

  I crossed red light, truck coming from my left , I hit his car side , he hit my front car , my airbag didn't open although it is totally loss , despite the other car air bag opened

• 12/09/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Component that fails & available for inspection upon request? HVAC heat exchange and faulty gas gauge. I drive from Minneapolis to Warroad, MN frequently and the floor wells has insufficient heat hence impairing use and safety in Minnesota's severe climate. I have videos on the following but I am unable to upload videos to your site: (1) when I have heat on high, full blast and to foot well ONLY, the dashboard vent is 115-143 degrees (using a digital food thermometer) and a ~60 degree difference with the footwell at 65-85 (although 85 degrees sounds warm at 1 degree outside my feet are very cold - I would be happy to have you test this with me). (2) Brand new SUV consistently 1.5 - 3 hrs to warm up. I explained to Hyundai this is NOT a software issue rather an HVAC air exchange issue. (3) The gas gauge consistently underestimates the remaining fuel available by 50% in cold weather - an issue that between Bemidji, MN and Baudette, MN (102 miles/1hr 45min) there are few gas stations. On 11/11/2025 I took the SUV to first Bloomington Hyundai - they said it is working as designed. Then 11/20/2025 to Morries Hyundai said they are aware of a similar situation with the EON. However, without an "error code" Hyundai is unwilling to fix the air exchange. Additionally, I opened case#: XXX[XXX] -68 with Hyundai corporate - additionally they are unwilling to admit fault - this vehicle should NOT be sold in Minnesota's extreme climate conditions. How was your safety of others put at risk? If I run out of gas, my passengers and I risk frost bite or fatality of hypothermia. Has the problem been reproduced or confirmed by a dealer service center? Yes. Has the vehicle or component been inspected by the manufacturer? Yes. Were there any warning messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning messages have ever appeared. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/06/2024· FORWARD COLLISION AVOIDANCE

  I could not find an exact category check above, but this does sort of relate to cruise control. The Driver Attention Warning cannot be disabled even though there is an option to disable it. Turning it off has no affect. This is a warning that basically tells you to keep your eyes on the road. Sunglasses and regular eyeglasses can often cause it to create a warning. The system will then turn off cruise control if it's being used. According to several owners, this is common on newer model Hyundais and Hyundai either chooses not to or simply cannot fix this. My wife has notified Hyundai and is awaiting a response.

• 12/03/2025· POWER TRAIN

  I am reporting a serious safety and reliability concern with my 2025 Hyundai Tucson. At only about 2,000 miles, I was informed by the Hyundai dealership that the transmission has already failed and needs to be replaced. This vehicle is essentially brand new and should not be experiencing a major powertrain failure so early in its lifespan. The transmission issue has caused significant concern regarding the safety of the vehicle. Sudden failure of a major drivetrain component creates an increased risk of loss of power, unpredictable drivability, and unsafe operation in traffic. This is especially concerning because this vehicle was already given to me as a replacement for a previous Hyundai Tucson that qualified under my state’s lemon law. A transmission failure at such a low mileage indicates a possible manufacturing defect or a systemic quality issue that could affect other consumers. I am requesting that NHTSA investigate this matter to determine if this is part of a broader problem in the 2025 Hyundai Tucson model line. This situation is unacceptable for a vehicle this new, and it raises serious concerns about long term safety and reliability. I am seeking further review and action so that other consumers are not placed in similar unsafe situations.

• 12/03/2025· UNKNOWN OR OTHER

  I purchased the 2025 Hyundai Tuscon Limited in October this year. My conern is the headlights. When driving at night using the normal headlights, on the road on the left side shining there appears to be a black spot ahead of me. I've had asked front seat passenger if they noted it also to which they affirmed. I did asked my Hyundai Dealer about this and they stated that it is intended that way so that the oncoming vehicle is not blinded by my headlights. I'm driving on a 4 lane divide highway and it is very disracting to me as I feel I cannot see anything on the left side of the left lane when I am in the right lane. This is very distracting and they informed that it's that way on all of thier moderls

• 12/01/2025· UNKNOWN OR OTHER

  Bought car end of April brand new. June 25 brought in, console display went blank. Tried to start my car 11/10 and it would not recognize the key. Had to have it towed to dealership. Car battery was not dead, fob could start car, open doors, etc, but the car shut off as soon as you tried to start the car inside. Originally told fob problem. Nope. The told security control. Nope. Now being told it’s the BDC, basically the “control brain” of the car. Part is back ordered and my car is sitting parked at the dealership. It’s useless. Did some research and found that the BDC is becoming more and more common with a lot of people that have this car. It’s only 7 months old. No warning, dealer knows it won’t recognize fobs and not a fob problem. I was told, that the screen going blank in June was connected to this.

• 12/01/2025· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  The Forward Attention Warning system performs erratically, frequently disabling the adaptive cruise control without warning. Even when it does emit a warning, which again, is erractic, the warning is barely audible. When conditions, such as grooved pavement or loud cabin noises, such as when a window or moonroof is open, the warning is completely in-audible. Similarly, the warning message displayed is not readable within the 0.5 - 1.0 sec (best estimate) that it is shown, as it is several lines of text - a distraction in itself. The disabling occurred during times when this ADAS feature is most value, cruising at highway speeds in heavier traffic - a time when automatic speed control and braking, along with maintaining a clear distance, are all invaluable to driver safety.

• 11/30/2025· ELECTRICAL SYSTEM

  Once entire display screen including entertainment display and dashboard display went black/ turned off while driving. It came back on within a few seconds. Once dashboard display (without entertainment) went black/ turned off while driving. Last a few seconds.

• 11/29/2025· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  In October 2025, the center display screen in my 2025 Hyundai Tucson Hybrid began shutting off repeatedly while the vehicle was in motion. The screen controls essential functions including speed information, navigation, backup camera, safety alerts, and hybrid system data. When it shuts off, all of these features become unavailable without warning. The failure is intermittent and continues to reoccur. The component involved is the center display/infotainment system and may affect related radar and safety-system warnings. The dealer stated they duplicated the issue and reported that it was repaired, but the same display failure occurred again afterward while I was driving. The vehicle is currently with the dealer and is available for inspection upon request. My safety and the safety of others is put at risk because when the screen shuts off, I lose access to critical vehicle information. This has happened at highway speeds, including one instance where the display shut off approximately eight times within 20 minutes. In addition, the radar warning system has activated when no nearby vehicles were present, creating distraction and uncertainty. The problem has been reproduced by the dealership, documented by me on video, and reported to the manufacturer. The vehicle has been inspected multiple times by an authorized Hyundai service center and reviewed by the manufacturer’s customer service department. There have been no police or insurance inspections because the defect has not resulted in a crash, though the safety risk is significant. Warning symptoms include intermittent radar system alerts appearing without surrounding traffic. These symptoms began in October 2025 and have continued even after dealer repairs. The display failure persists and the vehicle remains unsafe to operate. P.S. I cannot upload video evidence as the website would not allow me and I have to start over.

• 11/29/2025· FORWARD COLLISION AVOIDANCECrash

  The automatic braking was inappropriately applied while I was coming to a controlled stop on a 45mph stop light intersection. I was already slowing down and about 30 feet behind the car in front of me the Collision Avoidance warning starting going off, slightly applied brakes (to the additional amount I was already applying) then slammed on the brakes to a complete stop. There was some teen behind me who wasn't paying attention, and obviously no one expects the car in front of them to slam on their brakes 30 feet behind the cars in front of them, then plowed into back end of my car. This isn't the first time it's happened and I wasn't even at risk of collision as I was already slowing down in the other instances. But this time it caused an accident and injury. I am suffering from whiplash and possible herniated disk. The system is on the Late setting as well but is still dangerous to drive. There needs to be a firmware update or sensor recall, this is very dangerous!

• 11/27/2025· UNKNOWN OR OTHER

  Defective horn after a few months. Had to take to dealership for repair

• 11/26/2025· ELECTRICAL SYSTEM

  Attention warning... If you wear glasses that transition to dark, the system shuts down the car on cruise control. Numerous warning lights and bells. Take a break warning and sounds continuously popping up on the screen. There is no way to disable the eyes forward attention system. You cannot wear sunglasses as it can't see your eyes. I use my cruise control all the time. But the system shuts it down. This happens on all 2025 Hyundai equipped with the attention system.

• 11/25/2025· FORWARD COLLISION AVOIDANCE

  The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed on three occasions and depressing the brake pedal, the Forward Collision Avoidance system malfunctioned. The contact stated that upon depressing the brake pedal, the Forward Collision Avoidance system activated the Automatic Emergency Braking system excessively, causing the brakes to engage forcefully, and almost caused a crash on one occasion. The dealer was not notified of the failure. No further information was available. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 2,000.

• 11/25/2024· VISIBILITY/WIPER

  We purchased a brand new 2025 Hyundai Tucson from Earnhardt Hyundai North Scottsdale on October 26, 2024. We brought the car home and while it was parked facing the afternoon sun, we noticed that the entire windshield was speckled with thousands or more spots that greatly reduced the visibility. It was difficult to see through the windshield. We also noticed the same defect on the other windows, however, not as bad. We contacted the dealership and subsequently brought it into their service center for inspection. They confirmed the visibility defect and ordered a new factory replacement windshield and installed it. The replacement windshield, while not perfectly clear of spots, was acceptable for safe driving. The original windshield had such poor visibility in certain conditions that it would be hard to see anything, which would be hazardous while driving. We took possession of the car after the windshield replacement was completed but still feel that the spots on the other windows are a manufacturing defect but do not necessarily create a hazard. Along with employees of Earnhardt dealership, we looked at other brand new 2025 Hyundai vehicles of varying makes and models and observed the same windshield defect in many of the cars we looked at on their sales lot. This does not appear to be an isolated incident, but the dealership said that we were the first customers to bring it to their attention. We feel that knowing there are other cars on the road with diminished visibility that means drivers of those vehicles may not even be aware until conditions prevent them from seeing the road and their surroundings.

• 11/24/2025· UNKNOWN OR OTHER

  I started the car and put it in gear and it would not move. Then the check hybrid system and transmission warning showed up. This happened two times and I had to have the car towed in. The second time, it was determined that it is related to a recent recall for the Oil pump unit OPU Software. This recall is not listed any where and drivers are not being informed of it. Hyundai is not responding to my complaint.

• 11/24/2025· ELECTRICAL SYSTEM

  The contact owns a 2025 Hyundai Tucson. The contact stated while driving 55 MPH, the instrument panel turned black. The contact pulled over to the right side of the road, turned off and restarted the vehicle, and the vehicle operated as intended. The dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, but the diagnostic information was not provided. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.

• 11/23/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Twice car is completely dead for 3 weeks car is at the dealership

• 11/22/2025· FORWARD COLLISION AVOIDANCE

  We were driving on I4 in stop and go traffic. Our speed was under 25 mph and we were over a full car length back from the vehicle in front of us. I was actively braking to come to a stop due to traffic and the forward collision / emergency braking kicked in and stopped us immediately. This caused a car behind us to almost hit us and cause an accident due to sudden stopping. This happened 3 separate times within a 30 minute timeframe with 2 different cars behind us. The system will take control of braking the car and the steering wheel, and will not always give it back immediately to be able to continue driving. This has occurred previously when slowing down due to someone turning in front of us just in every day driving, and has almost caused a wreck then as well. Our local Hyundai dealer said there was no recall or issue with the system. This is dangerous and going to cause an accident sooner or later.

• 11/21/2025· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  While driving my car to Virginia to see my daughter, the oil light came on in the middle of a highway, where the speed limit was 70, The car slowed down and I had to pull off to the shoulder as the car lost all acceleration, making it very dangerous on a highway I waited for about 2 hours for a tow truck I waited for almost 2 months to get my car back and it happened again after having it back for a little over a week Mind you, I bought the car brand new with 45 miles on it and the first problem happened a little over 2 weeks after I bought it Hopefully this can be resolved so that my car doesn’t spend more time being serviced than me driving it

• 11/19/2025· FORWARD COLLISION AVOIDANCE

  Forward collision alert system has slamed the breaks on for no reason. The vehicle begins abruptly stop for no reason. On two of the occasions I was almost rear-end by following vehicles. The system needs to be recalled.

• 11/19/2025· ELECTRICAL SYSTEM

  Instrument cluster screen and HUD go entirely blank intermittently, for various lengths of time. Loss of speedometer is a safety issue. Also, have no idea of what other functions may, or may not be working. Dealer acknowledges seeing and servicing this problem for other owners. And Hyundai owners online forum report the same issue. Dealer has replacement component ordered, but not 100% sure of cause or solution. No warning whatever. First occurred shortly after purchase in July 2025, with less than 1000 miles on it.

• 11/17/2025· UNKNOWN OR OTHER

  The screen display in front of the driver showing speed, gas level, warning signals, traffic lane departure alerts goes blank and flashes on and off. Sometimes no screen at all for miles. At times all warning signals are lit up for many miles. This is an ongoing problem that has not been fixed over 3 visits soon to be 4.

• 11/17/2025· ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  2 times, while driving 35-40 mph, the vehicle automatically slammed hard on brakes to full stop without any danger or other vehicle near, causing neck pain/whip lash. 3 days ago, I attempted a U-turn in busy intersection, suddenly the vehicle braked hard and came to full stop without any danger near. The dash lights lit up, the vehicle stalled. I was in middle of very busy intersection. It would not move forward. I reversed just in time to miss being slammed into by fast moving oncoming traffic.

• 11/17/2025· STRUCTURE

  The contact owns a 2025 Hyundai Tucson. The contact stated that while exiting the vehicle, he opened the front driver's door and scraped his leg on the edge of the door. The contact stated that shortly after, he and his wife noticed a significant amount of blood coming from the cut. The contact sought medical attention a few days later. The contact's wife added that the contact was diabetic and takes blood thinners. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, a complaint was filed, and an engineer was sent to take pictures of the vehicle. The failure mileage was approximately 13,000.

• 11/15/2025· ELECTRICAL SYSTEM

  INTERMITTENT FLICKERING ON AND OFF OF THE CARS DIGITAL GUAGES AND HEADS UP DISPLAY. NO KNOWN CAUSE OR CORRELATION. DEALERSHIP UNABLE TO DETERMINE CAUSE.

• 11/13/2025· UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  The front end collision avoidance “feature” slammed on my brakes so hard today, for zero reason. I was already braking, going less than 20mph and had plenty of room. This is NOT the first time, closer to double digits since I purchase in April. This time the car behind me narrowly avoided hitting me which was made worse as my vehicle takes too long to unlock and allow me to begin driving again. This is going to cause an accident and ruin my tires/brakes costing me money.

• 11/13/2025· UNKNOWN OR OTHERFire

  Shortly after arriving home from approximately 60 mile trip, vehicle had been park approximately 10 minutes, came out to smoke and flames coming from inside of vehicle. The vehicle has been picked up by insurance but unsure whether the vehicle fire has been reported to NHTSA or Hyundai. The vehicle has not been to the dealer since the fire. Fire department stated it appears fire started inside vehicle. No warning lamps, messages, or other problems prior to the fire.

• 11/12/2024· ELECTRICAL SYSTEM

  Dashboard screen display shut off while driving. Did not feel safe. local HYUNDAI dealer has confirmed problem. Unsure if vehicle has been inspected by manufacturer, has been at the local HYUNDAI for service for one week. There where no warnings messages prior to the failure

• 11/11/2025· ELECTRICAL SYSTEM,VISIBILITY/WIPER,FORWARD COLLISION AVOIDANCE

  The FAWS Forward Assistance Warning System incorrectly identifies a "sleepy driver" and turns off Adaptive Cruise Control. FAWS has a dozen triggers that will cause this system to incorrectly alert the driver that his eyes aren't looking at the road and it turns off ACC. The FAWS has a turn off switch but it does not turn it off. So, without this safety feature of Adaptive Cruise Control, the driver just gets constant alerts to stay alert. Hyundai claims it is working "as designed" and has a suggestion to invest in specific sunglasses, or not be taller than 6'1" so the eyes can be detected, or don't wear a hat. Seriously, these are in the manual.

• 11/08/2025· UNKNOWN OR OTHER

  I was 15 minutes into my commute home on route 9 in Massachusetts when I stopped at a red light. When I took my foot off the brake and stepped on the gas the car would not accelerate more than 5 miles an hour. I was stuck in the intersection for about 10 minutes and had to put on my hazards and get into the right lane and Keep driving at 5 mph until I found a place to pull over and restart the car. When I restarted it it drove ok

• 11/08/2025· FORWARD COLLISION AVOIDANCECrash

  On numerous occasions (over 20) the forward collision system just slams on the brakes to a full stop, there was nothing close enough to vehicle to cause this issue. Sometimes it’s caused by rain or wind, sometimes for no apparent reasons. One time it caused a no damage accident as person behind me tapped my bumper. In traffic it is set off often with nothing within a safe distance away. There was no obstacles or sudden movements from other vehicles around me. I have brought the car back too Hyundai 3 times only to tell me either a dumb excuse or nothing is wrong with vehicle. I have seen on forums there are a lot of incidents with this particular car We have serviced the vehichle 3 different times over this issue and were told there is nothing wrong with the vehicle Accident happened in summer so I will say there was a crash in additional details but last date occurrence of automatic stop was this morning

• 11/07/2025· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  Concern: DAW Driver Monitoring System False alerts shuts down cruise control. Safety issue when passing on interstate and suddenly the cruise shuts off and has to be reset. This warning sometimes goes off randomly and not due to driver attentiveness. If my arm is in top of steering wheel it blocks camera and wearing certain types of sunglasses. This system is asking the driver to not put his arm on top of wheel which is ridiculous.

• 11/07/2025· ELECTRICAL SYSTEM

  All warning lights illuminate and the dashboard showing the speedometer shuts off while driving as well as the heads up display. You have no idea how fast you are going or if you are have any warning lights.

• 11/07/2025· FORWARD COLLISION AVOIDANCE

  The Forward Collision-Avoidance Assist (FCA) is braking aggressively without a valid hazard, creating a serious rear-end collision risk. Incident 1 [XXX] , approx. 60 mph) : A vehicle legally changed into my lane with safe separation. The FCA system detected this as a collision risk and applied hard braking on the freeway. Following traffic had to brake abruptly and I narrowly avoided being rear-ended. Incident 2 (Intersection U-turn, 15 mph): While completing a permitted U-turn on a green light, the FCA detected a distant cross-traffic vehicle and suddenly braked in the intersection, leaving me stopped in an unsafe position. I set FCA sensitivity to the minimum/“Late” setting after the first event. The false hard-braking continues. Hyundai dealership [Anaheim Hyundai] states “no issue found.” This behavior is repeatable and unsafe. I request investigation into false positives and unintended hard braking, a software remedy, and guidance to disable automatic braking until fixed (warning-only) if permitted by Hyundai.Currently even if it is disabled it resets after the SUV is turned OFF. I realized there are multiple threads on reddit on the same issue for Tuscon 2025 models with some of them resulting in accidents. (Reddit thread - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/06/2025· FORWARD COLLISION AVOIDANCE

  FCA system slammed brakes all the way to a complete stop in middle of traffic for no reason. Car in front was slowing down, and I was already braking at more than a safe distance. This is completely unacceptable and extremely dangerous. There needs to be a way to permanently disable this overkill feature that creates way worse problems than it is supposed to solve. There are numerous complaints about this issue from other owners of this model, please help!

• 11/05/2025· FORWARD COLLISION AVOIDANCE

  I was driving on the road this morning approx. 25 mph (clear road, no rain, snow etc.) The car came to a full abrupt stop. Collusion/warning notification never came on (there was nothing in front of me) seatbelt locked. Car would not move. I put the car in park and had to turn the car off and back on to get the car to move. This honestly scared the life out of me. I had several cars behind me that could of rear ended my car and caused serious harm to myself or other drivers. I called the dealership (will be dropping off this evening) but they made it very clear that if they can not duplicate the problem there is nothing that they can do. The car has 8,000 miles on it and was purchased in April 2025.

• 11/03/2025· FORWARD COLLISION AVOIDANCE

  Multiple times my vehicle has come to a complete stop unwarranted. There have been multiple instances of the automatic braking triggering on Michigan left hand turns with no traffic oncoming. This was reported to the dealer and they found no issue, however it has happened again since. The vehicle has also multiple times come to a full stop in heavy traffic when I was already braking and a full stop was unnecessary. There were two instances from this where I was very nearly rear ended, including on the expressway. There were no warnings that the system was malfunctioning.

• 11/03/2025· UNKNOWN OR OTHER

  Driver Assist Warning system. The driver assist warning in the vehicle provided a false alarm every 4-5 minutes while driving on the interstate. The trip was during the day and the driver was alert staying between the lane lines. The driver assist warning system was disabled in the vehicle settings. This problem has been reported by multiple individuals in the Hyundai forums.

• 10/28/2025· ENGINE

  The engine dipstick plastic bottom presents an issue to remove dipstick. Dipstick must be wiggled or twisted as it is pulled up without force for removal. The engine head and block holes are not in perfect alignment. The concern is if the dipstick is removed by force the plastic on the end of dipstick could be broken off and end up in the oil pan. That could cause engine damage and a possible safety issue losing power. Hyundai National Consumer Affairs has been notified but states they cannot report a design complaint directly. They offered the NHTSA as a place to report this concern. This was also experienced on another same make/model car on dealers' lot.

• 10/23/2025· FORWARD COLLISION AVOIDANCE

  While driving at speed in heavy traffic, I quickly merged from the right lane to the left lane to avoid an obstacle. My vehicle and the new vehicle in front of me (in the left lane) were traveling at approximately the same speed, although there was an admittedly small (one half car length) distance between us. My forward collision assist inaccurately identified this new vehicle in front of me as a sudden danger that I was going to hit. It immediately applied full braking power and played the forward collision alert sound. This aggressive and unexpected stop spilled and broke items in my car as they slid, roughly strained me against my seat belt, and caused the vehicle behind me to aggressively brake. A rear end collision was narrowly avoided, only due to the fast reaction of the driver behind me. This aggressive and dangerous forward assist and emergency braking can only be temporarily disabled for one drive, and resets every time the vehicle is turned on. I have not had my vehicle inspected for this issue, but communities on the internet have confirmed that this is a common problem.