2025 Hyundai Santa FE Hybrid

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/26/2025· POWER TRAIN,ELECTRICAL SYSTEM

  Started car, reading paperwork and suddenly my car went into Neutral bycitself and rolled backwards in a parking lot. Thank goodness no one was walking behind my car. This is the 2nd time it has happened. Additionally, twice previously, my car screen blacked off. 1 other time while sitting at a traffic light, the car shut off. I have been patient but now I'm afraid ti drive this car with only 2,650 miles on it.

• 12/25/2025· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINECrash

  I was stopped at a red light. When the light turned green, I proceeded to apply the gas and accelerate. I quickly noticed that the vehicle began accelerating at a faster rate than I was intending. The vehicle continued to accelerate without me applying my foot to the gas pedal. Nothing would stop the continued acceleration (application of brake). I crashed into the rear of a vehicle in my lane going approximately 50-60mph (estimate). I am unsure what the issue was that resulted in this crash. In doing some internet searching, it seems it could have something to do with the transition from electric to gas when I was stopped temporarily at the intersection. It could have been a faulty sensor (throttle position) or software glitch. These components have not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, messages or other symptoms of the problem prior to the failure. The crash resulted in the airbags being deployed, I was taken to the hospital with a likely concussion and moderate injuries to my chest and hand. The vehicle that I rear ended was a [XXX] woman with a [XXX] old in the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/07/2025· VEHICLE SPEED CONTROL,ENGINE

  Description of the Problem: I own a 2025 Hyundai Santa Fe Hybrid Limited with approximately 3 months of use. While driving on highway, the vehicle suddenly stalled displaying “Hybrid System Failure-Stop by side”. I had to stop on shoulder and restart, drove it couple of days and it happened again. Engine would not start, leaving the vehicle stuck in EV mode only with no ability to accelerate properly, Vehicle wouldnt go beyond 35mph. The vehicle then stalled and became unsafe to operate on a public road. After restarting, the vehicle displayed a Check Engine Light. Tookk it to the dealer and the dealer reported DTC P1122000, but did not provide clear evidence of an internal system fault. The dealer claimed the event was caused by “20% ethanol in the fuel,” which is inconsistent with U.S. pump labeling laws. When I checked my credit card entries around the time for refuel, all of them are reputed gas stations with nothing lower than "87" gas which is in alignment with car manufacturer's recommendation. This sudden stall created a serious safety hazard, and I am concerned this may be a broader issue with the 2025 Hyundai Santa Fe Hybrid drivetrain, fuel system sensors, or hybrid control module. I am requesting NHTSA to look into whether similar complaints exist, as this failure mode can result in loss of propulsion at speed, putting occupants at risk.

• 11/26/2024· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving 55 MPH, the Forward Collision Avoidance Warning Alert System Failed to operate as needed. The contact stated that the vehicle independently accelerated, and the contact depressed the brake pedal and the vehicle responded as needed. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 133,000.

• 11/20/2024· ELECTRICAL SYSTEM,ENGINE

  Hi Hyundai- my 2025 Santa Fe calligraphy HEV, with around 900 miles wasn’t turning on and only able to start with a jump. After parking, it was unable to maintain a charge to start up again even after driving 1-2 hours. The dealer wasn’t sure why, replaced the 12v battery first and recharged it overnight. Unfortunately it also drained. Finally diagnosed that the hybrid starter generator needed replacing. More bad news, after replacing they discovered what the service manager said was a defective relay pack of some sort had fused. And the kicker is the part is unavailable until January. I am not sure how widespread or rampant this issue is, but I am concerned there might be more or further issues identified.

• 11/18/2025· UNKNOWN OR OTHER

  On August 8, I was traveling to work on the interstate. The car started losing speed even though my foot was on the accelerator. I was unable to get the car above 30 mph despite having my foot on the accelerator. I exited the interstate to try and find a safe place to pull over. I parked the car, turned it off, restarted it and attempted to drive it. The problem continued. There were no icons or alerts showing up on the dashboard of the car to alert me that there was an issue. The vehicle has been at the dealership for repair for over 100 days. They will not communicate with me about the issue or provide updates.

• 11/05/2025· FUEL/PROPULSION SYSTEM

  SantaFe Hybrid Calligraphy 2025 with about 9000 miles purchased new from Hyundai dealer. Several times and unpredictably, the vehicle loses power while driving mostly on highway 60-70 mph. operator can push the gas pedal to the floor and the car does not accelerate more than about 25 mph. My wife was on an off ramp with no shoulder to pull off. Very dangerous situation. A message on the dash states to "park and let battery charge". The battery is suppose to charge itself while the gasoline engine is operating.A search engine query reveals many folks are experiencing this same situation.

• 10/12/2025· ENGINE,FUEL/PROPULSION SYSTEM

  My 2025 Hyundai Santa Fe Hybrid has experienced repeated, dangerously abrupt power loss while driving at highway speeds, causing the vehicle to go into "limp mode" without any warning or prior indication. This safety hazard occurred on three separate occasions: First Incident: 7/29/25; Mileage: 9,205. Situation: While traveling at 70 MPH on the interstate, the vehicle suddenly decelerated to 35 MPH and entered "limp mode" without any warning lights or notifications. Dealer Repair: Replaced ignition coil assembly (Parts: 27301R1H, 27301-2M417). Second Incident: 8/27/25; Mileage: 12,898 Situation: While accelerating to 65 MPH on the interstate, the same loss of power and abrupt forced deceleration occurred, again with no warning. This sudden loss of speed created a serious safety hazard for me and other drivers. Dealer Repair: Replaced fuel pump & O Ring Assy-High Pressure (Parts: 35326-2M500, 35305-2m414 LH). Third Incident: 9/25/25; Mileage: 14,830. Situation: Traveling at 70 MPH on the interstate, the car abruptly decelerated, again entering limp mode. This caused surrounding vehicles to swerve to avoid rear-ending me, putting myself and others at risk. Dealer Repair: Replaced High Pressure Sensor (3534202M400), Packing Fuel Pump (31115-0W000), and Fuel Pump and Tube Assy (31119-L1400). In all three cases, there was never any warning light, check engine notification, or app alert before the incident. Hyundai and my dealership confirmed and replicated the issue during each repair. I have reported the vehicle to the Texas DMV, Hyundai and the dealer.These recurring “limp mode” incidents have repeatedly jeopardized my safety, my family’s safety, and the safety of the public due to the sudden, unanticipated loss of power at high speeds. Since the underlying issue persists and has required three separate major repairs, I am fearful for my safety while operating this vehicle and believe it constitutes a serious safety defect needing federal investigation.

• 10/02/2025· FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  The driver assistance warning system continuosly goes into shutdown mode. Eye monitoring system always states that you are not keeping your eyes on the road. I have tried using different glasses or no glasses. Changing the steering wheel settings also seem to have no effect. This is very dangerous as it will start decelerating and stopping in the middle of a freeway in heavy traffic when this warning is activated. This only happens with the lane keeping assistance and adaptive cruise control are on. Hyundai issued Technical service bulletin 25-GI-001H, but they did not solve the problem

• 09/23/2025· VISIBILITY/WIPER

  Vehicle was in driveway for 3 days. When I got into vehicle to drive I saw the windshield had a large crack on driver’s side approximately 16” long. No vandalism or rock damage caused this problem. Has to be a stress fracture.

• 09/18/2025· FORWARD COLLISION AVOIDANCE

  Driver attention warning system constantly gives aggravating notices of "suggest take a break" with chiming sound when driving with or without sunglasses or other glasses. I cannot use cruise control. I have tried several different sunglass types with no success. After first warning, goes off every 4 minutes, either cancelling cruise control when I am using it or just causing annoying aggravation which takes my attention off the road. I cannot turn this feature off. It is so aggravating that it draws my attention from the road ahead and impacts my patience while driving. Due to eye condition, I must use sunglasses while driving in sun. Hyundai did not make this limitation clear when I was buying the vehicle, and they refuse to do anything about it now.

• 09/12/2025· AIR BAGS,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCECrash

  My wife was parking our vehicle near the front of our home, simply rolling forward toward the car in front of her to complete parking on the left side of the street when the vehicle unexpectedly accelerated on its own. The vehicle turned hard to the right, struck the bumper of the parked car she was pulling up behind, continued right across the traffic lane where it hit two parked cars on the other side of the street with significant impact, lifting and turning one onto the sidewalk, at which point our vehicle went across the sidewalk and stopped after hitting a fence. The forward collision avoidance that we have experienced engaging previously, never engaged, despite hitting multiple vehicles on the lefft side and then right side of the street. The collision avaoidance alarms that we have experienced sounding previously, also never went off. The airbags never deployed, despite hitting 3 cars at two different sides of the street, as well as an iron fence that never moved. The vehicle went from traveling less than 5 mph while completing the last few feet of parking to a high rate of acceleration within a path of less than 40 feet, as evidenced by the significant damage it left. Had my wife not come to a stop as quickly as she did, she could have been seriously injured. If anyone had been on the sidewalk - there are 3 shcools on this block that children are often present - someone could have been killed. The vehicle is currently at a body shop being evaluated by insurance adjuster and likely a total loss. We reported tot the manufacturer and they intend to repsond to us by 9/16 and inspect the vehicle in its current state.

• 09/09/2025· FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  The contact owns a 2025 Hyundai Santa Fe. The contact stated that while his wife was driving at an undisclosed speed, the Forward Attention Warning (FAW) system activated. Shortly afterward, the message "System Shutting Off" was displayed, and the Automatic Emergency Braking System briefly engaged, jerking the vehicle and dramatically reducing its speed of the vehicle but not to a complete stop. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the vehicle was functioning as designed but informed the contact that his wife's glasses may be interfering with the Forward Attention Warning (FAW) system's eye detection ability to monitor her eyes. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 13,000.

• 09/04/2026· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  First Incident – XXX Weekend ([XXX]) Accelerating at an on-ramp to a major highway (I-37S) in [XXX], vehicle suddenly lost power. Speed dropped from 60 mph to 45 mph, then 28 mph, in a 65 mph zone during rush hour traffic. No apparent cause: had ¾ tank of fuel, a clean maintenance history, and no prior issues. Managed to reach the shoulder and, after several minutes, able to exit the highway. Vehicle would not accelerate above 35–45 mph and stayed around 30mph, and the hybrid battery showed less than 25% charge. Notified Red McCombs Hyundai (original seller). When a loaner vehicle became available, we brought the Santa Fe in. After a week, the dealership stated they could not duplicate the problem and returned the vehicle to us. Second Incident – XXX ([XXX]) On a planned trip from [XXX] to [XXX], again experienced a sudden and severe loss of power. While merging onto I‑10W, in [XXX], the vehicle speed dropped from 80 mph to 60, then 50, then 38 mph. Able to avoid a collision because of an unusually wide median where I could safely stop. Used GPS to find a local Hyundai dealer - Casa Hyundai of [XXX] - and drove there, using surface roads only. Turned vehicle in for maintenance and continued trip using a loaner vehicle. Casa Hyundai reported, days later, that despite logged error messages indicating problem with hybrid system and advising user to immediately stop, they were unable to isolate problem. Third Incident – XXX (Unknown location in [XXX]) Entering I-10E after fuel stop (80mph zone) and accelerating hard on a slight incline, again experienced sudden loss of power, slowing to less than 40 mph. Drove on shoulder for two miles to next exit 284 and stopped w/motor running to recharge. No error codes or warnings displayed on dash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 09/03/2026· ELECTRICAL SYSTEM

  The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving 40 MPH, the instrument panel went blank. The contact was able to pull over safely after the failure. The contact associated the failure with NHTSA Campaign Number: 26V047000 (Electrical System); however, the VIN was not include in the recall. The dealer was contacted by phone. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 7,900.

• 09/02/2026· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  While driving, the vehicle suddenly lost motive power on the highway and would not accelerate beyond approximately 20 mph despite accelerator input. There were no warning lights or check-engine light. The condition created a safety hazard because the vehicle could not maintain normal traffic speed. Hyundai dealer has been unable to determine the cause on other vehicles with the same problem, and was trying to discourage me from reporting this. They also said that they'd keep the car for 3 days, and likely return it with no diagnosis, so do I really want to go through this? They seemed unconcerned that this is a very dangerous issue in a highway.

• 08/31/2026· FUEL/PROPULSION SYSTEM

  I've had this vehicle for 13 months, and it has roughly 13K miles on it. Since 7/3/26, it has been in the service department at Hyundai of Noblesville on three separate occasions. This all started on 7/3/26 when we were driving on the interstate and out of nowhere the vehicle lost critical power and would not go more than 20 MPH. There was some kind of warning message that momentarily popped up but then disappeared. We were so rattled, we didn't get a chance to take notice of what it said. It was towed to the dealership and they said they cleared the codes and drove it a little and the problem was resolved. It was driving OK and then on 7/15/26, we had just got onto the interstate and there was a sudden loss of power AGAIN. We had it towed to the dealership. They replaced the high pressure fuel pump and assured us that the problem was resolved. Then on 8/29/26, the same thing happened again on the interstate--critical loss of power. Had it towed to the dealership again. This morning, they say that it is the fuel pump railings that are the issue. I have placed a formal Hyundai Corporate Case and I am notifying you of this safety issue which presents major risk to the safety of anyone in the car.

• 08/28/2026· VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

  When traveling home from work 8/27/26, my cruise control shut off and my car immediately went into “limp” mode. This almost caused me to get into an accident with a tractor trailer, in which, I may not have survived. Immediately pulled over and tried to find out what had caused this and how to get it fixed. Nothing worked to get it out of “limp” mode. There were no warning lights or messages, except LV3. Which was a completely different issue. This issue I was able to correct. Tried fixing the “limp” mode issue by doing as told by Google AI, turn car off, lock door with key fob, waiting 10-15 minutes for computer to reset. NOTHING. Also tried checking to see if there was a battery dump, in which this case would have been the fuel system not communicating with the hybrid battery system, NOTHING. I do have an appt with the dealership on 9/2/26 to have this looked at and inspected. I have not tried to start and or drive the car again, since. Do not want to be blamed by the dealership or manufacturer, that I did something wrong or caused more issues.

• 08/25/2026· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  While driving in the evening around 9:00 pm with AC on crash detection lights came on along with other emergency dashboard lights . Speed was limited to 23 miles per hour .

• 08/24/2026· UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE

  My vehicle randomly slows it self down while driving. I would be pressing the gas and the car would voluntarily slow down on its own with no warning. This problem can lead to plenty of accidents due to me or any other driver around me being unaware when my vehicle will brake on its own. The problem has been confirmed by Hyundai Patterson of Tyler, Texas and they have worked on my car twice to fix the issue and it still hasn't been fixed. The issue started about a month ago and when the incidents would occur in the beginning their would be no warning lights on my vehicle’s dash. As of recently there maybe a check engine light that will pop up when the incident occurs. It's a hit or miss.

• 08/23/2026· POWER TRAIN,FUEL/PROPULSION SYSTEM

  Our family was driving on the highway at 55mph (I-495 in Alexandria, VA), the car instantly began to decelerate, despite having my foot completely on the accelerator and we had to limp over to the side of the road onto the shoulder. We had to wait multiple times for the hybrid motor to re-power itself to get off an exit at 10-15 mph. The car is now in "limp mode" and will not drive above 35 mph. This is the 4th time that we have had the same issue occur. Hyundai has provided a different fix each time, but they have yet to find an answer as to why this instant loss of acceleration keeps occuring. In the wrong circumstance. This instant loss of acceleration could be deadly and cause severe injuries to the individuals in the vehicle.

• 08/23/2026· AIR BAGSCrash

  On 08/22/26 at approximately 11:45 AM I was stopped at a traffic light and struck by a Ford Pickup truck whose approximate speed was 45 mph as described in the police officer who witness the accident totaling my Hyundai 2025 Santa Fe. No airbags were deployed. According to the police officer the frame was bent as well. Please see attached vehicles pictures

• 08/20/2026· VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

  sudden loss of propulsion / limp mode, particularly under load or at highway speeds.

• 08/18/2025· LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

  The “consider taking a break” warning comes on far too much and has almost made me wreck twice due to being startled.

• 08/16/2025· FORWARD COLLISION AVOIDANCE

  Vehicle unable to recognize face when wearing sunglasses and disables all driver assist aids, including turning off the cruise control

• 08/14/2025· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  Hyundai disabling critical vehicle safety systems if people wear sunglasses. I brought MY2025 hyundai santafe hybrid, this has driver attention monitoring system. Since the day i brought this vehicle i have been getting issues related to driver attention warning system. This error is being caused for no reason, this comes on when vehicle comes on and stays on (sometimes for days sometimes for weeks and sometimes for hours). HYundai says this issue is because i have a dash cam in car, error wont go away even when dash cam is removed. Recently hyundai engineers said its because you may be wearing sunglasses. What? Wearing sunglasses will disable AEB and cruise control !!!OMG. I removed sunglasses and tried still wont work. Hyundai sent me list of things not to do, including not to laugh, not to shorten your eyes and not to wink. this is a major safety concern, not allowing drivers to wear sunglass which will disable safety critical systems.

• 08/14/2025· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  I purchased a new 2025MY Hyundai Santafe Hybrid. Since the day of my purchase there has been a constant error message that is displayed on dash saying "Driver attention warning system failure". this light stays on constantly and disables cruise control and adapative cruise system. This affects the usability of the vehicles. WHen asked Hyundai they say, drivers arent expected to wear sunglass if this system has to work properly, they even say constant blinking will cause system to fail and disable cruise control. This is a serious concern. How can people drive a car without blinking and how can a new car have disabled cruise control all the time.

• 08/13/2025· SUSPENSION

  Purchased new 2025 Hybrid AWD Santa Fe with 47 miles on 8/3/25 at 6pm. By 6:30am on 8/4/25 I noticed an occasional knocking when coming to a stop, reversing, turning and at times driving forward. The knocking became more frequent and noticeable as the day went on with more driving and not once did a service message or warning light display. At 1pm on 8/4/25 with an added 100 miles, I drove it to Hyundai Service Department to have them diagnose the issue which they immediately heard. After 8 days, I was told it was a control arm issue which them lead to a complete suspension rebuild on the driver side. I could have lost total control of the vehicle due to the bad control arm. They claimed the passenger side was fine and I picked up my car on 8/12/25 4pm. By 6:30am on 8/13/25 the knocking was back and car is pulling to the right. Car is back in the service shop to further investigate the knocking. I believe Hyundai is trying to cover up this issue as the service report they initially gave me had no mention of the control arm or suspension rebuild. I refused to sign and asked for another service report stating what the issue was and how it was repaired.

• 08/13/2025· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  Hyundai's Forward Attention Warning is so aggressively annoying it makes me want to drive off a cliff to shut it up. Driving with an arm in the 12 o'clock position? "BEEP! Keep your eyes on the road!" Polarized sunglasses? "BEEP! I can't see your eyes!" Oh, there's a setting! Let's turn it off..."BEEEEEP! WHERE ARE YOUR EYES!". I just purchased and cannot use Cruise control I need to wear glasses It has a hard time seeing my eyes I cannot turn off I have tried many positions on steering wheel to no avail.

• 08/11/2025· STEERING,POWER TRAIN,VEHICLE SPEED CONTROL

  Check emergency, stopping function alert. Check hybrid system stop safely. Both alerts came on the dash the steering wheel vibrated 11 other alerts popped up in the car steered me to the side of the road. It would not start again and This has happened four times in the 7 months I’ve had the car Hyundai cannot figure out what the issue is. In fact they tell me there is no issue because it’s not happening to them while it’s been there for almost a month.

• 08/10/2026· POWER TRAIN,FUEL/PROPULSION SYSTEM

  On XXX, at approximately 6:30 PM, my wife was driving our 2025 Hyundai Santa Fe Hybrid on [XXX] when the vehicle suddenly lost propulsion power. It would not accelerate past approximately 55 mph. With the accelerator pedal pressed fully to the floor, the vehicle did not gain speed. I drove the vehicle myself the same day, immediately after she arrived home, to verify the problem, and I reproduced the identical condition. The vehicle accelerates normally from a stop, but at approximately 40 to 50 mph it stops accelerating and will not exceed approximately 50 to 55 mph regardless of accelerator input. No warning lamps illuminated and no messages appeared on the instrument cluster before, during, or after either event. The vehicle health check in the official Hyundai application reports the vehicle status as normal. The driver receives no indication that anything is wrong. This is a serious safety hazard. Sudden inability to accelerate in traffic creates a substantial risk of a rear-end collision and makes it dangerous to merge onto a highway, pass, or clear an intersection. Because there is no warning, the driver cannot anticipate it. The vehicle has approximately 13,741 miles and was purchased new on XXX. Scheduled maintenance was performed at the selling dealer on XXX at 7,924 miles. The vehicle has not been driven since XXX and is available for inspection on request. It is scheduled for dealer inspection on XXX. The problem has not yet been reproduced or confirmed by a dealer. I am aware of numerous owner reports of a similar loss-of-power condition in 2025 Santa Fe Hybrid vehicles in which the gasoline engine reportedly fails to engage and the vehicle operates on hybrid battery power alone. In several of those reports the trouble code cleared itself before the dealer inspected the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/08/2025· FORWARD COLLISION AVOIDANCE

  Occasionally, the vehicle acts like I am not looking at the road and I’m not sure if it is because of my hair, glasses, hat, or my lazy eye. On three different occasions in nearly 8000 miles it will randomly hard break on the interstate. Initially, I had thought this was something I was doing. When I was finally able to speak with the service staff, they confirmed that this is a common issue with people wearing glasses or any other items the vehicle does not register as normal. At this point, I am afraid to drive a vehicle once I learned that this is a safety setting I cannot control. I have been told by Hyundai that the vehicle is operating as it should however it is extremely concerning that this could cause an accident on the interstate and someone could get killed.

• 08/03/2026· BACK OVER PREVENTION

  The contact owns a 2025 Hyundai Santa Fe. The local dealer was contacted and confirmed that the parts to repair the vehicle under NHTSA Campaign Number 25V808000 (Back Over Prevention) were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was able to confirm that parts were not yet available. The contact had not experienced a failure.

• 08/01/2026· ELECTRICAL SYSTEM,LANE DEPARTURE,BACK OVER PREVENTION

  Everything normal when parked in store parking lot. When vehicle was started to leave I noticed the vehicle had no sounds ... no radio sound from any source at any volume setting, no turn signal clicks, no parking proximity beeps, no navigation voice guidance, no sounds at all. All dashboard/visual displays were normal. Parked vehicle in garage when I got home and the next morning the battery was dead. Had to jump start the vehicle (the dead battery "fixed" the sound problem). An AI search shows this is a known issue for the 2024 & 2025 Hyundai Santa Fe and I found AI & You Tube fixes saying to "soft reset" the Infotainment/Sound system by turning the ignition to the "On" position (not starting the vehicle ... foot off the brake and push ignition once, then again). Use a paper clip or pen to press and hold the little dimple reset button just below the right side radio knob until the system resets, then foot on the brake and start the vehicle. If this does not work, disconnect the starting battery's Negative battery cable for 15 minutes. This is a mid level safety issue because audible warning systems will not work. Took the vehicle to the Hyundai dealer we bought it from but they didn't offer any acknowledgement that other same model vehicles have had similar problems and said they could not check or do anything since the vehicle wasn't currently having the problem. I had to argue like hell just to get them to record that the issue had occurred.

• 07/27/2026· VEHICLE SPEED CONTROL

  Vehicles accelerated on its own when going under 10mph and no pressure on pedals.

• 07/27/2026· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  1. The SUV experiences complete power loss and goes into limp mode. Have been in nearly 3 accidents on highways with a vehicle that goes from 65 to 35 with no warning and then cannot accelerate or gain speed. 2. Battery, out of no where, goes from 3/4 full to 1 or 2 bars. 3. Extreme shaking of the vehicle while driving and at rest. 4. Vehicle is less than a year old and has been in for the same issue 4x. Currently with dealership since 6 July with no communication despite calls and in-person visits. 5. Loaner not provided despite car being under warranty and brand new.

• 07/26/2026· LANE DEPARTURE,BACK OVER PREVENTION

  There are two main causes of concern that have occurred numerous times. The first is a driver attention alert will flash on the screen very frequently, which is very distracting to the driver. It says you should take a break but will come on very frequently right after starting driving and seems to be due to someone squinting their eyes. The second is that when sensors get blocked or dirty it will flash messages about the parking system, not being active while you were driving the vehicle, which is a huge issue and very distracting, especially considering that it’s a parking system that you are not using because you’re actively driving the vehicle. These notifications need to be able to be disabled or should be adjusted to not do this.

• 07/25/2025· WHEELS

  I’m reporting a recurring safety issue with the Pirelli Scorpion All Season MS tires (255/45 R20) factory-installed on my 2025 Hyundai Santa Fe Hybrid Calligraphy. At just over 7,500 miles, I began experiencing significant vibration at highway speeds. The dealership diagnosed the issue as defective tires — two were replaced, but the issue returned within 24 hours. I stopped driving the vehicle due to safety concerns. This problem appears to be common: I’ve found numerous reports of Scorpion MS tires showing early failure, poor balance, bulging, uneven and premature wear — all within low mileage. These issues compromise the vehicle’s stability and may present a serious hazard in wet or winter conditions. I’m concerned these tires are not structurally reliable and should not be standard on family SUVs like the Santa Fe. Hyundai and Pirelli should investigate this tire line for potential safety defects or recall. It also appears that the it's the MS, verde and AS Plus 3 from pirelli that have these issues. You can find additional complaints regarding these with a google search. They will be on reddit and facebook.

• 07/25/2025· TIRES

  I’m reporting a recurring safety issue with the Pirelli Scorpion All Season MS tires (255/45 R20) factory-installed on my 2025 Hyundai Santa Fe Hybrid Calligraphy. At just over 7,500 miles, I began experiencing significant vibration at highway speeds. The dealership diagnosed the issue as defective tires — two were replaced, but the issue returned within 24 hours. I stopped driving the vehicle due to safety concerns. This problem appears to be common: I’ve found numerous reports of Scorpion MS tires showing early failure, poor balance, bulging, and premature/uneven wear — all within low mileage. They stated that it was still an inherent issue with the tires and I would need new ones. Thus I requested to have a different set tires given the issues with these. These issues compromise the vehicle’s stability and may present a serious hazard in wet or winter conditions. I’m concerned these tires are not structurally reliable and should not be standard on family SUVs like the Santa Fe. Hyundai and Pirelli should investigate this tire line for potential safety defects or recall. I understand that it is the Scorpion MS, AS Plus 3 and the Verde with these similar issues. Unfortuneately for some reason your site won't let me post my photo, but I was able to file it under the same VIN under my report for the Santa Fe.

• 07/24/2026· POWER TRAIN,ELECTRICAL SYSTEM

  Vehicle went into limp mode while driving on the freeway and then would not go past 30 MPH even after pulling over and restarting it. At first there were no errors but after a restart the following warning showed up: "Park with engine On to charge battery". Everything worked fine earlier that day.

• 07/22/2026· ELECTRICAL SYSTEM,BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE

  Less than 10 month old Santa Fe Calligraphy suddenly started flashing warning signs like Check Drivers Assistance System, Check Headlight LED, Check door assistance system. It comes on randomly, sometimes when the car is running, sometimes when the car is stopped. It flashes these warnings rapidly. When it is going on, the side view cameras stop working. One time when this was happening, I was at a stop light and it automatically went to park. It has happened multiple times so far. I have 2 children ages [XXX] and [XXX] that I drive around with and am concerned about safety. I have taken it to two different service centers at 2 different dealerships based on recommendation from Hyundai and they have not been able to replicate the problem hence they can't find the diagnostics of what is wrong. We have opened a case with Hyundai. The case number is XXX The case manager is [XXX] [XXX] I have taken videos of it whenever it has happened. I am not sure how to upload it as your documentations only allow photos. I am sharing the photos with you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 07/21/2026· POWER TRAIN,ENGINE

  The vehicle has gone into a limp mode unexpectedly while driving on the highway at 60+ mph. The car immediately stopped driving and went into limp mode and cannot go over 30 mph. It was taken to a service dealer. They could not replicate the problem, therefore the vehicle was given back as undiagnosed. This next incident occurred and almost caused an accident, and that was on, again driving on the beltway around Columbus, OH. The car went from 70 mph to 30 mph. The vehicle stayed at 25 to 30 mph the entire time. Could not get it to do anything else. Drove cautiously on the side of the road and got to the dealership after driving 30 minutes at 25 mph. Dealership ended up saying the transmission needed replaced. It has been at the dealer for 3 weeks waiting on a transmission

• 07/19/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  Stopped for gas, vehicle started but would not go into gear, engine lights indicated 'Check hybrid system', warning lights shown. 1/2 hr on the phone with dealership to assist. No problem detected when returning to home dealer. Second episode occurred, vehicle at dealer for the past 4 weeks. Episode repeated at dealership yet "no abnormalities are detected with diagnostics ".

• 07/10/2025· ELECTRICAL SYSTEM

  I've been having a few issues with my 2025 Calligraphy Hybrid I bought in November related to the main screen, sometimes when I start the vehicle it doesn't properly initialize and it will show me some of the icons and nothing else. No HUD, no speedometer, no remaining fuel, no hybrid information. It's a huge safety issue, it seems to happen every couple of weeks. I thought it was the digital key not working properly so I disabled that but still having issues. I have to let the car sit for a few hours or overnight and then when i turn it on then it's back to normal. I realized that when the main screen is off, it doesn't capture the mileage so the mileage is off by close to 300 miles right now. Huge issue, I've had it happen on my way home from work (25 miles) at least 4 times, and once on a road trip (150 miles). Also when this happens because I can't see the speedometer, I have to use Waze on the infotainment screen (which works without issue) to see my actual speed because the built-in navigation only shows me increments of 10 mph on the screen (this is just stupid).

• 07/08/2026· STRUCTURE

  WHAT FAILED: A panoramic moonroof shattered before delivery and was replaced by the dealer before sale. Despite the replacement, loose tempered-glass fragments remained inside the occupant cabin, including the front passenger compartment and the second-row floor where my two minor children ride. One glass fragment also tore the passenger-seat leather. SAFETY RISK: Loose tempered-glass fragments left in occupant areas create a foreseeable laceration hazard during normal vehicle use, particularly for small children riding in the second row. The presence of enough glass to tear the passenger-seat leather demonstrates that hazardous fragments remained in the vehicle after the moonroof replacement. CONFIRMED BY SERVICE CENTER: Yes. The selling dealer Hyundai of Kirkland was aware that the moonroof had shattered and was being replaced before delivery. The salesperson disclosed the moonroof damage and showed us the vehicle in the service area while repairs were being performed before sale. INSPECTED / REPAIRS: Loose glass fragments were discovered the day after delivery, prompting an immediate call to the dealer and a return visit for cleaning and inspection. Glass fragments continued to be found afterward, requiring additional follow-up visits, including a second unsuccessful repair request approximately one month later. The dealership was aware that loose glass had damaged the seat; on 09/08/2025, the salesperson directed me to repair the tear myself with clear nail polish rather than initiating a warranty repair. See file attached with evidence. No repair orders or service documentation were provided for these interior repairs. The dealer ultimately performed cleaning, third-party leather restoration, and replacement of the passenger-seat cover on 11/04/2025. Because loose glass continued to be discovered after the second repair attempt, I purchased a Prosidium protection plan for future glass-related damage. WARNING SYMPTOMS: None. This was a pre-delivery issue.

• 07/08/2026· ELECTRICAL SYSTEM

  WHAT FAILED: The 12-volt battery / no-start system. Beginning XXX, my 2025 Santa Fe Hybrid (bought new XXX suffered seven (7) sudden 12V battery failures causing a complete no-start. Each time the vehicle became inoperable with no warning, stranding my family - including two minor children (ages [XXX] and [XXX]) - and requiring roadside assistance and towing. Events: XXX (tow), 1XXX; the vehicle has sat immobilized at the dealer since XXX (~113 days). 5 dealer repair orders are attached to this complaint. SAFETY RISK: A repeated no-start can strand occupants in unsafe locations and prevent the vehicle from starting in an emergency. Once it had to be extracted from inside our garage by AAA after a 3+ hour wait; on XXX the battery died ~2 minutes after a jump-start, before I drove away. CONFIRMED BY SERVICE CENTER: Yes. AAA certified 0% state of charge at each failure; an independent OBD scan showed 4% ('Not Getting Full Done'). Hyundai issued TSBs 26-01-016H (XXX) and 26-01-016H-1 (XXX) identifying the root cause as the Fingerprint Module (FPM) failing to enter SLEEP mode when the ignition is off, draining the 12V battery - the exact defect my vehicle showed, and it applies to my vehicle. An OTA remedy released the week of XXX was never applied. INSPECTED BY MANUFACTURER: Yes - the dealer and a Hyundai field engineer inspected it. The dealer repeatedly blamed my behavior (windows down, unlocked doors, short commutes ~20 mi/day); its own draw test showed no draw, yet the diagnosis was never corrected. A Final Repair Opportunity in Jan 2026 did not fix it; failures recurred XXX and XXX As of this writing (XXX) the vehicle remains at the dealership since XXX without any status on repairs done or pending. WARNING SYMPTOMS: Sudden no-start / no-crank with no prior warning lamp, beginning XXX and recurring repeatedly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 06/23/2025· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  The cruise control system cuts of with message on screen stating that , system camera can’t see my face and the system de-activates. This is especially dangerous at highway speeds. The vehicle behind me doesn’t see a brake light as my vehicle suddenly looses speed. This is from Hyundais Driver Attention Warning (DAW) function. This function cannot be de-activated by myself or my dealership which is Webb Hyundai of Merrillville Indiana.

• 06/21/2026· VEHICLE SPEED CONTROL,ENGINE

  The car went from 70 miles an hour to 25 miles an hour all of a sudden on the highway and then would not allow to accelerate afterwards. Battery stopped charging and we had to stop it multiple times to get it to continue to drive no faults or issue on the dashboard.

• 06/20/2026· UNKNOWN OR OTHER

  There is a severe and dangerous lag in acceleration when trying to merge into traffic. Praying the accelerator all the way down often result in the car not responding for a second or two before kicking into gear. This is significant when trying to merge onto a highway or onto a cross street with incoming traffic.

• 06/18/2026· SEAT BELTS

  The dealer is unable to remedy the defect within a reasonable time. It’s been two months with no fix and my family’s safety is in jeopardy.