2025 Ford Expedition MAX

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 09/04/2026· ENGINE

  EXHAUST FUMES ENTER CABIN WHEN DRIVING LOW SPEEDS AND AT IDLE, ODORS CONFIRMED BY DEALER REPAIR ATTEMPTS MADE BUT PROBLEM STILL EXSIST. FUMES STRONG ENOUGH TO MAKE EYES WATER AND GIVE OCCUPANTS HEADACHES

• 08/23/2026· UNKNOWN OR OTHER

  Relating to NHTSA ID Number 11027142 (Ford SSM 5446 and purported remedy SSM 54692). Experience a left turn signal that is automatically erroneously activated after a sharp right hand turn with right turn signal activated. There are two other complaints filed with NHTSA regarding this problem. In my case the left turn signal DOES NOT CANCEL AFTER RETURN TO CENTER. This is a potentially dangerous situation, since other drivers don't know what moves you might be intending to make. Ford claims SSM 54692 is a remedy with part number SL1Z-13K359-AA installation. This part was installed on 8/5/26 and did NOT remedy the problem. Since then have been awaiting contact from dealer re Ford engineers solution. Dealer's communications have been quite lacking.

• 08/12/2026· ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  On August 11, 2026 at approximately 5:17 PM, the vehicle was traveling about 25–30 MPH and approaching a stop sign. The driver began braking normally, but the vehicle did not adequately slow despite repeatedly pressing the brake pedal. The vehicle continued completely through the stop sign and intersection. Fortunately, no cross traffic was present and no collision occurred. After passing through the intersection, the vehicle slowed while traveling uphill. At approximately 5 MPH, the electronic parking brake automatically applied by the vehicle and brought the vehicle to a stop. After being placed in Park, the vehicle would not shift out of Park and displayed multiple fault messages. FordPass recorded simultaneous faults for Antilock Brakes, Electronic Parking Brake, Powertrain Malfunction/Reduced Power, Pre-Collision Assist, and Blind Spot/Cross Traffic systems. One message specifically stated that the anti-lock brake system had detected a fault and was disabled. After several power cycles, the vehicle could be moved, but an orange wrench remained illuminated and cruise control was unavailable. After being shut down for approximately one hour, the warnings cleared and the vehicle appeared to operate normally. There were no warning lamps, messages, or braking symptoms before the failure occurred. Because the vehicle failed to respond normally to braking and traveled through an intersection, the incident created a serious risk of collision, injury, or death. The vehicle was subsequently towed to an authorized Ford dealership and is currently available for inspection. Dealer diagnosis is pending. The dealer has been asked to preserve the diagnostic trouble code/fault history and investigate the brake, electronic brake booster/ABS, electrical, and related control systems.

• 08/11/2026· STEERING,SUSPENSION

  The rear suspension oscillates and bounces violently over bumps, expansion joints, broken or uneven pavement, and washboard surfaces. It occurs at highway speed, at normal neighborhood speeds, and while slowing or coming to a stop over rough pavement. The rear suspension does not recover after a bump: it continues bouncing, the rear of the vehicle steps sideways, and steering correction is required to keep the vehicle in its lane. The condition is highly unpredictable. It does not occur on every bump and the driver cannot anticipate it, so there is no way to drive around it. Because it is intermittent, a short test drive may not reproduce it. On a recent drive on [XXX] south of Salt Lake City it occurred approximately 20 to 40 times over a seven mile stretch, with my wife driving. She has had to slow well below the posted 70 mph limit to maintain control. She will no longer drive the vehicle or transport our children in it. The vehicle was previously presented to an authorized Ford dealer for this concern and the condition was not corrected. It has worsened since. We have stopped driving it and had it towed to the dealer on August 11, 2026 because we do not consider it safe to drive. The vehicle is at the dealer now and is available for inspection. The manufacturer has opened a case and a repurchase review. No warning lamps or messages have appeared. The vehicle is completely stock with no aftermarket suspension, wheels, or tires. This is a loss of control risk at highway speed to my family and to other road users. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)