2024 Ford Maverick HEV

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2024· POWER TRAIN

  CV axle joint near engine failed and leaked grease out of joint. Axle is damaged but still drive able until replacement part comes in on 1/31/25. This is a FWD hybrid.

• 12/31/2024· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER

  My 2024 Ford Maverick manufactured 9/24 has failed to unlock on two separate occasions with key fob and the interior lights failed to come on when I unlocked the driver door with the mechanical metal key. When I checked the charge status of my battery it was depleted below 75%. I also noticed that the battery was a flooded acid type and is installed under the rear seat within the passenger compartment. The placement of a flooded acid type of battery in the passenger compartment poses a significant danger and risk of acid exposure in the event of a collision.

• 12/27/2025· VEHICLE SPEED CONTROL,ENGINE,FORWARD COLLISION AVOIDANCE

  I STARTED THE CAR AND MY ENGINE WONT TURN ON ONLY HYBRID SYSTEM. THE MAINTIENCE LIGHTAND ENGINE LIGHT APPEAR WITH FUEL DOOR OPEN ERROR AND TRACTION OFF AND DRIVER ASSITANCE OFF . I THEN JUMP STARTED TRUCK . TRUCK ENGINE THEN TURNED ON AND SAME ERRORS LIGHTS STILL APPEARED . BUT I WAS ABLE TO SHIFT INTO GEAR NOW WITH JUMP START . HOW EVER TRUCK WOULD NOT ACCELERATE WHEN I PUSH GAS PEDAL . BUT IF I LET GO OF THE BRAKES , THE TRUCK WILL SLOWLY ACCELERATE ON ITS ON . AND SPEED UP TO 30-40 MPH WITH OUT PRESSING THE GAS .

• 12/26/2024· ELECTRICAL SYSTEM

  VEHICLE KEEPS GOING INTO " DEEP SLEEP" MODE. Can ot start and can not get into the vehicle. Requires a jump start and you are left stranded anywhere. Ford told me they are aware of this issue in the hybrid but their engineering department has NO solution. You can be left stranded in unsafe or dangerours places. I bought the vehicle in march 2024, new, so that at 74 years old Iv would have a reliable and safe vehicle.

• 12/26/2024· FUEL/PROPULSION SYSTEM

  Vehicle was parked in attached garage. Smelled gasoline smell inside the house. Investigated the source of the smell and found the vehicle to be leaking fuel where the filler neck attaches to the fuel tank.

• 12/24/2024· POWER TRAIN,SERVICE BRAKES

  When stopped in drive with brakes applied, the vehicle will lurch forward without me releasing the brakes. This is not an intermittent issue - it happens constantly. This is obviously a safety issue and many other owners have reported the same issue on several forums.

• 12/23/2024· ELECTRICAL SYSTEM

  The contact owns a 2024 Ford Maverick. The contact stated that while the vehicle was turned off and the doors were opened, the interior lights failed to illuminate. On another occasion, while the vehicle was parked for approximately four days, the doors were closed while in Sleep Mode, and none of the exterior lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the battery was not holding a charge, and the battery was replaced. The vehicle was repaired but the failure reoccurred approximately a week later. The vehicle was taken to another dealer where it was diagnosed and determined that a software update needed to be performed. The manufacturer was notified of the failure. The failure mileage was 1,475.

• 12/17/2024· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  lost acceleration function on freeway, no error code or warning sound. I didn't lose power just wasn't able to accelerate had to pull over and restart engine for the problem to go away.

• 12/14/2024· UNKNOWN OR OTHER,BACK OVER PREVENTION

  My Ford Maverick truck was purchased and delivered on [XXX]. From the very first day, I have experienced issues with the central infotainment screen. Specifically, the screen frequently freezes, particularly when using Google Maps. My vehicle is an essential tool for my daily work, as I am an air conditioning technician and spend long hours driving. Additionally, I have noticed a significant delay in the rearview camera display, which also frequently freezes. This poses a considerable risk to pedestrians and vehicles that may pass behind my truck, turning it into a serious safety and convenience issue. I have taken my vehicle to the dealership three times, leaving it for several days on each occasion, but the problems persist after every visit. I purchased my truck from "Planet Ford Spring" in Spring, TX, but due to its proximity to my residence, I have carried out maintenance and filed complaints regarding this issue at "Tomball Ford" in Tomball, TX. I have repeatedly requested that the service advisors involved in my case replace the screen or upgrade it to a more reliable system. However, they claim that, according to Ford’s procedures, they are not authorized to make such changes. I urgently request a definitive solution to this issue, as I cannot continue visiting the dealership month after month hoping for a resolution. This problem must be addressed immediately for safety reasons. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/14/2024· FUEL/PROPULSION SYSTEM

  The fuel tank is leaking where the fill tube enters the tank on the drivers side. It was at the dealership for this issue once. A hose clamp was found to be loose. It was tightened and considered fixed. Just tonight while.the truck had a full.tank I decided to inspect the repair. I found it to be leaking still. I have read of 22MY trucks having an issue with the interface between the fuel tank and the tank inlet hose barb fitting. (The white part in the attached picture.) I only noticed the gas smell originally whith a full tank and while parked in the garage. The fumes where overwhelming.

• 12/09/2024· POWER TRAIN

  Car battery died. When jumped, it then started up. However, upon getting onto the street - only the hybrid battery would engage (not the combustion engine). Thus, my speed was limited to ~10 miles per hour and this made the drive very unsafe.

• 11/25/2024· POWER TRAIN

  Front right cv joint failed after only 30,000 miles

• 11/20/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES

  It happened twice in 3 days. The first time I lost electrical power, the battery died. I use a trickle charger to recharge it for 4 hours, then it functioned as normal for one day, I went to the dealer for service and they looked at it and said there was nothing wrong and sent me home. On the third day, it died again. All electrical power was lost, the car was locked up, and could not be shifted to neutral for towing. It is now sitting at my driveway waiting for Ford roadside service to tow it to a dealer for diagnostic and services.

• 11/18/2024· VEHICLE SPEED CONTROL,ENGINE,FORWARD COLLISION AVOIDANCE

  I have a 2024 hybrid Maverick with 17,000 miles on. The The 12 volt battery is a known issue in the vehicle that Ford has failed to address. When I went to go start my truck the other morning the battery had failed. I hooked up a jump pack to the proper terminals under the hood so that I could start the vehicle. I was successful in starting the vehicle after that. I had every warning message pop up on the dashboard. I turn the vehicle off and try to restart a few times to no avail. I had somewhere that I had to be so I started to drive. The accelerator pedal did not register at all from zero to all the way down to the floor. The truck was accelerating on its own to about 35 mph. The brakes worked the steering worked the accelerator pedal did not register at all. I parked the vehicle to try it again three or four times each time same. Then I parked for sometime maybe an hour. I tried it and it seemed to drive just fine but with a check engine light. The vehicle through all sorts of low voltage codes. This is unacceptable and should never happen to a vehicle when jump stared. I have never seen a vehicle operate the accelerator without input from the driver and I could literally put the pedal to the floor multiple times and it did not rev up or speed up at all just continue to accelerate on its own accord to about 35 mph. Going down hills the brakes work but as soon as I let off the brakes it would accelerate again. I am very busy and I have not had time to go to the dealership with the issue. I don't have time for them to take my truck for multiple days just to tell me what I already know the 12 volt battery is no good. Now I am stuck with a need to replace a battery on a vehicle that is less than 1-year-old and less than 20,000 miles just unacceptable. They could give me another battery but from what I have read the battery fails time and time again. I also have issues trusting the vehicle now if I do have to jumpstart it.

• 11/17/2025· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  On November 9th, the vehicle became undrivable with the following alerts: "Stop safely now", "Pre-collision assist not available", "Check Brake System", "Front Camera Temporarily not available", "service vehicle soon", "service advance trac", "hill start assist not available" The accelerator was non-functional; however, when releasing the brake pedal the vehicle starts to accelerate, without pressing the accelerator. Dealer said they are unable to reproduce the event. This is the second time this has occurred with this vehicle, previously submitted complaint on this same VIN.

• 11/08/2024· SERVICE BRAKES

  Grabby brakes when stopping at lower speed just before coming to a complete stop. sudden braking causing one to feel like being forced forward in seat. Very concerned if it gets icy on roads and losing control of vehicle! This is a hybrid.

• 11/04/2024· UNKNOWN OR OTHER

  Vehicle spontaneously shifted to neutral while driving on highway.

• 10/18/2024· UNKNOWN OR OTHER,VISIBILITY/WIPER

  Rearview camera lags and occasionally freezes image during reversing. Lagging and freezing gives a false sense of vehicle position. There has been one occasion where the image froze and stayed frozen even after putting vehicle in "D" and traveling up to 30mph+. Vehicle is not part of latest recall for frozen rearview camera issue.

• 10/06/2025· SEAT BELTS

  Restraints indicator warning lamp for passenger side went off repeatedly in August (four times). Took into dealership where they replaced what they said was a faulty seatbelt tensioner. Now, the same indicator warning is going off again, two times, 9/28, 10.4. Either the part is still bad, or the sensor is defective. I suspect the latter, but it's hard to know.

• 09/30/2025· STRUCTURE

  The contact owns a 2024 Ford Maverick. The contact stated that while the vehicle was parked, the contact became aware that the front driver's side door middle hinge was not properly welded. The contact stated that the front driver's side door was not properly welded when the vehicle was manufactured. The contact stated that the failure caused issues while rolling down the window. The vehicle was taken to the dealer, and the failure was confirmed. The contact was informed that the driver's side front door needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The manufacturer agreed to a 40 percent discount on the cost of the repair. The failure mileage was approximately 46,000.

• 09/29/2024· UNKNOWN OR OTHER

  Backup camera can freeze or jump frames, particularly if you use shortly after starting the car. This makes it hard to trust the camera view.

• 09/29/2024· ELECTRICAL SYSTEM

  The vehicle goes into what they call a sleep mode. It shuts systems down to save the battery. At this point, it’s more of a nuisance than a major problem. Fortunately, every time I got in the vehicle, it started and was fine but what happens is it shuts down all the remote functions, you can’t use your app on the phone go to get in the car at night the interior lights aren’t working. It’s pitch black, just a inconvenience but Ford has no answer that answer was to shut down all the remote functions on the car to me that doesn’t make sense. Why have those features if you can’t use them?

• 09/28/2024· SERVICE BRAKES

  My wife and I purchased the NEW truck in May 2024. It now has 4970 miles and had our first issue Sept 10th. When we attempted to reverse out of the driveway, with the foot firmly on the brake and the start button engaged, the truck unexpectedly rolled out of the driveway. This alarming incident poses a significant safety risk, as the brake pedal was fully pressed, yet the truck was in motion. I drove back into the spot. Multiple check engine lights came on, and the ABS and parking brake faults were on. I called Ford and had it towed the next day. It is currently still in the Ford dealership shop. They gave us a rental car, thinking it was a faulty Electronic brake booster controller. Still waiting on ETR. My wife and I couldn't be more grateful that this happened in our driveway; this could have been a serious accident if it was to occur on the freeway.

• 09/25/2024· UNKNOWN OR OTHER

  While driving my hybrid Maverick on the interstate at approximately 75 mph, I accelerated to overtake another vehicle going up a slight hill (very slight). When it hit around 80mph, the power meter hit 100% and there was a momentary complete loss of power (peddle felt dead under foot) and vehicle started to decelerate. I let off the pedal and reapplied gently staying well below 50% power. The truck seemed to have less power for the remainder of the interstate drive but returned to normal after shutting off, restarting and driving again. A very dangerous situation on the interstate when you press the accelerator and change lanes to overtake someone only to start slowing down immediately. Have not visited dealership, vehicle has not been inspected by any third party, and no lamps messages or warnings on the dash or in the app.

• 09/09/2025· POWER TRAIN

  At approximately 42K miles, front wobble upon acceleration. Front axels replaced under 60k power train warranty

• 09/07/2025· UNKNOWN OR OTHER

  On sept6,2025 while driving on highway at 65mph truck went into limp mode so you could not accelerate although trying to and the speed of the truck decreased. Had to pull off to berm of road for safety. Turned truck of and it appeared to reset itself and there were No Warning lights on dashboard when this occurred. This could have been a deadly accident if I wasn't able to get off on berm as quickly as I did! Vehicle will be scheduled with dealer this week! But this is an ongoing problem as stated in Ford maverick community website.

• 09/04/2026· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES

  1. 50% of my braking results in grinding stop where it jumps and doesn’t stop all the way at first, this is even driving at slow speeds of 25 mph. 2. When my truck was set on cruise control approx 70mph and all of a sudden started decelerating on its own and nothing I did made it accelerate. I had to coast/slow brake to pull over, cut the car off and then restart it to begin driving again.

• 09/02/2026· STRUCTURE

  Defective spot welds of interior door hinges bind resulting in destruction of 3 remaining spot welds making door inoperable, not closing correctly, damaging other hinge and locking mechanisms. Local and corporate denied. out of warranty at 42645 miles.

• 08/31/2024· ENGINE

  Exhaust flange clamp improperly installed during manufacturing process causing exhaust leak not identified until consumer noticed after approximately 40 miles of use. At time of writing dealership has not inspected. No warning lights or indicators. Audible sputtering heard when gas engine runs. Hybrid vehicle.

• 08/21/2025· VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

  While driving on the freeway complete loss of power, loud sound, visible smoke. Determined by the dealer that an internal engine part failed.

• 08/15/2025· POWER TRAIN

  Significant shaking in the front end during acceleration due to CV axle failure

• 08/12/2025· STEERING,UNKNOWN OR OTHER

  I was flat towing the vehicle behind a motorcoach. I pulled off the interstate and made a gradual left turn. The maverick started to violently wobble. Pulled off to the side of road and could not tell if anything was wrong. Spent the night at a campground. Next morning I had a steering assist warning come up.

• 08/09/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Truck is draining its battery after sitting in a downtime period. (6-12 hours) leaving me stranded. This has happened more than 20 times since 12/26/2024. I DO HAVE INFORMATION TO SUBMIT FOR SHOP (VISITS), HOWEVER AT THE TIME I AM FILLING THIS OUT I HAVE NO WAY TO ENTER THAT INFORMATION HERE. THE SHOP HAS HAD THE VEHICLE MULTIPLE TIMES AT THE LONGEST 20days STRAIGHT, UNKNOWN HOW MANY DAYS TOTAL. Most of the shop visits concluded with either battery charges OR battery changes. I have been told by Ford Dealership Maintenance Shop many times they have no idea what is going on with the vehicle. I have digital proof from the Ford app when this happens. My concern is that I have noticed that Ford is removing Digital information off of the app that supports my case. ALSO, They have started to “lose my paper work” when I go to pick up my vehicle from their shop. My vehicle has ONLY been to the dealership shop where I purchased it.

• 08/09/2025· STRUCTURE

  After parking next to a gas pump to refuel, I twice pulled the hood-release handle on the left-side kick panel to check under-hood fluids. The gas pump did not accept my payment, so I drove to a second pump which also did not accept my payment. At this point I drove to a second gas station. As I approached 35 mph moving air suddenly caught the unlatched hood, then lifted and flipped it until it landed against the windshield. The hood severely obscured my view while the vehicle was still. Even so, I was able to peek under it enough to limp into a restaurant parking lot, where I stopped the vehicle and moved the hood back to its locked position. The hood latch mechanism does not incorporate a secondary safety hook designed for release while standing in front of the vehicle grill. Nor does the vehicle have an instrument cluster warning light or a DIC (driver information center) alert like it does for a passenger-compartment door not fully closed. Ideally, the vehicle should have an electronic interlock that prevents driving it until the hood is fully closed.

• 08/08/2025· ELECTRICAL SYSTEM

  On the Maverick hybrids there has been a battery issue since they first came out in Dec. '21. I first had a 2022 hybrid and would get the message "vehicle is in battery saver mode" frequently. When this would happen I would have no interior lights when I opened the doors and could not start the vehicle or check any information, tire pressure, fuel, etc through my phone app. So charge battery and drive and the message goes away. The dealer did replace the battery once since it was defective. I kept that truck for 26 months and then purchased a 2024 Maverick hybrid in Feb '24 thinking this issue would be resolved. Nope, issue was worse if anything. Started getting the same issue in just a few months. Dealer checked and replaced a defective battery in October 2024. Within 5 weeks started getting the same issues again. Dealer said battery checks good. There seems to be either a parasitic drain on the battery, a software issue regarding the charging of the battery or completely defective flooded batteries. In April 2025 Ford must have realized a problem because they started installing an AGM in the factory on the hybrids. they also issued SSM 53801 which was a software update on the A?C module that could be causing a parasitic drain. I had that done TWICE. Still have the same issue. The dealer says they can find nothing wrong and says I just need to drive my vehicle more, keep it on a battery maintainer and carry a power pack to jump start in case it doesn't start. I have been on a website [XXX] since July 2021 and this has been overwhelmingly the number one complaint about the Maverick hybrid. Ford was supposed to have had a recall in the first quarter for a software update to deal with a deeper charge of the battery but that never happened. We imply that the government step in and have Ford do a recall to replace all the defective flooded batteries with the AGM that they are now installing on the 2025's and/or do the software update promised. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/02/2024· VISIBILITY/WIPER

  I purchased a 2024 Ford Maverick Lariat Hybrid truck on [XXX] and have discovered a safety issue. When I operate the windshield washer, the washer fluid tank fully drains in about ten seconds. I can visually see the fluid level fall rapidly. Washer fluid sprays at a high velocity on my windshield until the tank is empty. There is no evidence of a fluid leak. Last week, I took the truck to a local Ford dealer. They were the ones who discovered the rapidly draining tank and they escorted me from the lounge area to the shop and showed it to me. Both the service writer and three mechanics standing at my truck stated that they had never seen anything like that occur before. The service writer brought over the service manager, who took a look and suggested that perhaps there was a problem with the nozzles. He also stated that he had never seen this issue before. The dealership ordered new nozzles. I returned to the dealership this afternoon to have the replacement nozzles installed. When the function of the windshield washer was tested, the bottle again drained in about ten seconds. One of the technicians then tested a new Ford F150 that is in the shop today and it also drained rapidly. I asked that a new Maverick on the lot be tested, which the dealership immediately did, and it also drained in about ten seconds. Evidently, Ford has an issue with this function on some of their new vehicles. Windshield washing is an important safety feature and it is not functioning as it should on these three tested vehicles. This problem was observed and verified as never having been seen before by a Ford service writer, three Ford mechanics, and a Ford service manager. The selling Ford dealer is Crossroads Ford of Wake Forest, NC and the servicing dealer is Deacon Jones Ford of Goldsboro, NC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/01/2026· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  I was driving at approx. 40 to 45 mph and in the process of braking for slowing traffic and the vehicle slammed on the brakes and left a short skid mark. I was about 50 feet behind the vehicle and braking when this occurred. I was lucky that the car behind did not rear end me. The collision alert did come on the dash at the same time it slammed on the brakes.

• 07/30/2024· AIR BAGS,FORWARD COLLISION AVOIDANCECrash

  Airbags did not go off in a head on collision besides the one at my feet Emergency auto braking did not brake and hindered my ability to brake

• 07/29/2025· SUSPENSION,WHEELS

  There is a constant wobble and shudder between 30-65 mph.

• 07/24/2026· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  "This is a formal complaint for an Inadequate Recall Remedy and severe Consequential Damage regarding NHTSA Campaign #24V684000 (Ford Recall 24S59) on my 2024 Ford Maverick XL (65,000 miles, VIN: [XXX]).The official safety recall update was originally performed at 30,000 miles by a Ford mobile service unit, but the remedy completely failed. The Audio Control Module software remains corrupted, causing a severe intermittent parasitic drain. The radio frequently locks up, and roughly once a week, it remains actively powered on for 10 minutes after the ignition is turned off, keys are removed, and doors are locked. This has permanently destroyed my 12-volt battery, forcing me to rely on a trickle charger daily.On XXX, I took the truck to Mt. Orab Ford (Ohio) under Invoice #XXX for a separate recall (Ford 26C10). They completed the hitch recall but explicitly refused to address the failed safety recall 24S59 or the resulting battery damage. The official invoice they handed me falsely logs line item B as 'GBATT BATTERY TESTED GREEN AT THIS TIME.' However, I forced the Service Manager, Kevin Wilmoth, to physically verify the battery in the parking lot. The handheld tester printout he handed me directly contradicts their official invoice, explicitly stating 'GOOD RECHARGE' with a resting voltage of only 12.16V and a 45% State of Charge. A healthy 12V battery should rest between 12.6V and 12.8V; at 12.16V with a 45% charge, the system is severely drained and starved for power. The dealership printed 'Tested Green' on the invoice before actually testing it, and Kevin Wilmoth has since refused my email request for copies of the vehicle's OASIS history and FDRS global diagnostic logs to withhold the electronic record of these faults.Contacted Ford Corp., given a claim #, promised call back in 24hrs.completely failed to respond, leaving me stranded with a severe, un-remedied safety hazard. Requesting into Ford's failure to provide a free, functioning saf INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 07/21/2026· SERVICE BRAKES, ELECTRIC

  See attached letter for petition

• 07/16/2025· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  While driving on onramp to the interstate the engine shut down and warning came on pull over now. All power was lost. The APP showed power train fuel control module could not connect. I tried to restart but had no power. On 6/16/2025 I took the vehicle in for repair (could not get appointment). It was returned (could not duplicate problem). On my way home it happened again engine lost power while driving. The vehicle was brought back to Ford. This time it was returned 6/25/2025.

• 07/14/2025· POWER TRAIN,VEHICLE SPEED CONTROL

  At approximately 10 pm driving on the interstate at approximately 65 mph, I was attempting to accelerate to 70 mph and my speedometer was decreasing in speed even though I had my foot on the accelerator. I had to pull off to the side of the interstate that has a very narrow shoulder. My car was not able to accelerate. I had to turn it off and turn it back on and then it appeared to work as usual. This has happened twice now. I took it into the dealership to have it fixed and they said they updated the control module unit and replaced my battery due to other issues I’ve been having with the car. No warning lights came on, and the car still appeared to be on and in drive when the incident occurred. The component has been inspected and the dealership said they repaired the issue, which was not the case, due to the same thing reoccurring approximately 10 days after the “repair” was made.

• 07/12/2026· SERVICE BRAKESCrash

  My 2024 Ford Maverick Hybrid rolled backward while in park. I push-started the truck and then turned on the A/C to start cooling the cabin. I left the driver’s side door open as I stepped out to begin loading my 8-month-old baby’s stroller. The open door bumped my back, so I quickly jumped back into the vehicle to press the brake. The truck eventually stopped, but not before the door folded out and scraped the entire side of a parked car. I called the police to make a report.

• 07/07/2026· SERVICE BRAKESCrash

  This is a corrected supplement to my prior NHTSA complaints #XXX and #XXX for the 2024 Ford Maverick Hybrid, VIN [XXX]. It corrects the mileage in # XXX: the odometer at the XXX collision was approximately 68,000 miles (a current reading was auto-populated into the incident field on the prior form), and the vehicle's current odometer is 119,379 miles. I request that the Office of Defects Investigation open a Preliminary Evaluation of the Maverick Hybrid braking/ABS system. I first reported a braking concern to the selling Ford dealer in spring 2025 at approximately 35,000 miles, while the vehicle was still under the 3-year/36,000-mile warranty; Ford's applicable service bulletin (MC-XXX) was not applied. Ford's OASIS system later confirmed active fault codes C052E and U0418 when the vehicle was returned to me unrepaired on XXX6. The defect has persisted through four repair attempts and more than 50 days out of service. On XXX, another vehicle crossed multiple lanes of traffic across my path. I applied the brakes and the vehicle did not stop as it should have, and I struck the crossing vehicle (APD Crash Report # XXX; I was assigned no driver error). This loss of stopping capability is the same failure mode I have experienced repeatedly and that remains unrepaired. Ford's own recall record documents its knowledge of Maverick braking-system defects: Recall 22V-730 addressed the Maverick ABS module transmitting an incorrect signal; Recall 25V-124 was a follow-up after Ford determined the earlier software remedy had not been correctly installed even though dealer records showed the repair completed, and Ford disclosed to NHTSA in December 2024 that dealer software-repair records could be inaccurate. Ford issued Recall 25V-488 for loss of power brake assist on several model-year-2025 vehicles but did not include the Maverick, and issued a limited Maverick Electronic Brake Booster recall des INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 07/04/2024· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  Vehicle was on clear two lane road, no vehicles in sight to front, nor opposing lane, or even in Rear view. Speed between 45 and 50 mph. Vehicle was headed approximately south, and the road was shaded by trees to the west. Miles on odometer 1961.8 . Red warning appeared on dash, indicating to prepare for collision. We note that this is not the first time in the young life of this vehicle this warning has appeared, but that another time there was another vehicle, in its own lane, and slowing to the passenger side front, but not in any way moving into our lane. Then, later the same afternoon, about 18 miles later, and orange colored CANCEL appeared 2 times at about 66mph. There were about 1980 miles on the odometer, and in adaptive cruise control. I'm concerned that this "safety feature" has more possible error modes than Ford lists in its owner's operating manual, and that the faulty messages are a distraction, and possibly dangerous. As to the subject, "dangerous," we had previously submitted to NHTSA the occurrance of a dangerous automatic braking event when there was no need for braking, and we were in an express lane on Highway 680 with cars immediately behind. NHTSA has acknowledged receipt of that information. I had not noted on that there was no sudden change in roadway illumination (daytime) or orientation of the vehicle to the sun when that occurred. Monday of this same week I had just retrieved my vehicle from the dealer, whose technician had run what diagnostics they had available on events (apparently none recorded) and attempts to test for any malfunction of adaptive driver assist mode. Are we the only party experiencing random errors in the adaptive driving assist?

• 07/01/2025· ENGINE

  The contact owns a 2024 Ford Maverick. The contact stated that while driving up a hill at an undisclosed speed, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to restart the vehicle. The contact stated that the failure persisted. The contact stated that on a separate occasion, while driving 70 MPH, the vehicle lost motive power without warning and stalled. The contact was able to coast to the side of the road. The vehicle restarted independently. The contact stated that several days later, while driving 70 MPH, the vehicle stalled and restarted independently. The vehicle was taken to an independent mechanic; however, no cause for the failure was found. The vehicle was taken to the dealer but was not yet been diagnosed. The manufacturer was notified of the failure. The failure mileage was approximately 7,500.

• 07/01/2024· ENGINE

  prematurely changed engine oil on New vehicle at 2200 miles, break-in period. I refilled with recommended 5.7 quarts of oil. Removed from the ramp. Level ground dip stick check. Over full. I removed 1.5 quarts, and see metal in Brand new oil. I have video. 2 weeks later I random removed 0.75 quart to inspect the integrity. More metal flakes from engine. Ford did not debur engine components of this vehicle.

• 06/29/2024· ENGINE

  Engine lost power in middle of driving interstate at steady speed . Was not in middle of accelerating or braking .Had to coast do feeder road. Turn car off and Restart before engine would re-engage

• 06/27/2026· SERVICE BRAKES

  While driving, the red "BRAKE" light remains illuminated on the dashboard, and a "service brakes" warning message appears on the screen. This can be dismissed and the vehicle drives normally, except under sudden/heavy braking conditions. Under these conditions, the brakes make a grinding, thumping noise and the vehicle does not brake adequately. I suspect power braking was lost. I had to stop suddenly for a stoplight a few times, and the vehicle continued into the intersection before making a complete stop despite very heavy braking pressure applied to the pedal. The dealership replaced the brake booster, which they said was a "known issue". This was fixed at my expense.