2024 Ford Bronco

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2024· UNKNOWN OR OTHER

  Navigation maps are wrong and out of date for 29420 and 29418 zip codes.

• 12/21/2024· STRUCTURE

  There are multiple spots on a 2024 4-door Outer Banks Bronco (purchased in 03/2024) that are melted. Most of the plastic components of the exterior body of the Bronco are bubbled, warped, or the paint is peeling away from the plastic. See affected areas listed below (see also photos attached). Areas Affected: -entire rear side of hard top, including 3rd brake light mount -passenger front mirror -driver's side rear wheel well -top of hard top -passenger's side rear door handle This seemingly occurred over a short period of time (1-2 weeks). This vehicle was taken to three different Ford dealership; the third kept the car for evaluation and inspection for over a week and wrote up an estimate for $14k in replacement parts and $2k for labor. They are unwilling to perform replacements/repairs under warranty as they report this is a problem caused by environmental/external factors and is not a defect of the multiple parts that have melted. This has begun to compromise the integrity of the body of the vehicle, and there would be serious concern for the safety of the vehicle operator as well as others on the road if the deterioration continues to progress.

• 12/19/2025· EXTERIOR LIGHTING

  The contact owns a 2024 Ford Bronco. The contact stated that while driving the vehicle at night, the headlights failed to provide adequate illumination and created a visibility hazard for the driver. While inspecting the vehicle, the contact discovered that there was condensation inside the front headlight assemblies, which caused the illumination from the headlights to be reduced. The contact indicated that the failure occurred while the temperature was below 50 degrees. The cause of the failures was not yet determined, and the vehicle was not repaired. The manufacturer and the local dealer were notified of the issue. The failure mileage was 3,500.

• 12/18/2024· SERVICE BRAKES

  When the Vehicle is put into Neutral Tow Mode and Towed behind a vehicle while using a supplemental braking system. The Bronco's Brake system becomes intermittently Active. Causing the slightest pressure to lock up the brakes. The Same issue as reported in. SSM 51415 . The Bronco power brake system is supposed to be de activated once it is put into neutral tow mode. Thus you set the supplemental brake system to respond as a vacuum brake system. So when the brake system on the Bronco becomes active during a stop it will lock up the wheels on the bronco and all four wheels skid. The brakes will stay locked up for what seems to be a long time but, may only be 10 or 15seconds to get them to release. Causing a dangerous traffic situation, huge stress on tires, towing equipment and the towing vehicle, The manufactures service refuses to any more troubleshooting saying the issue does not fall within the SSM 51415. Being this is a new 24 model year. They looked at the firmware and said i have the latest. I had this issue twice the same day. I have used my RVI supplemental brake system on several vehicles for thousands of miles without issue. Only with this bronco and my first 21 bronco have I had these kind of issues.

• 12/13/2024· EXTERIOR LIGHTING

  Ford and other manufacturer are in huge rushes to convert to LED headlights. Ford designed the front headlights to be completely vertical, with no headlight housing heater. In freezing fog, snow and sleet the headlights almost immediately get covered and are useless and you can’t see anything. It’s only a matter of time for a major accident Attached are some of the numerous complaints of owners all over the internet.

• 12/08/2025· EXTERIOR LIGHTING

  While driving on the interstate in light snow and mostly clear and semi dry roads, ice accumulates on both the head lights and the foglights to a degree that they no longer project enough light to see far enough ahead at even moderate speeds. When I pulled over to inspect them, the surface was coated with a mix of ice and dirt rendering them useless. Ambient temperatures were between 24 and 30 degrees. It seems that the LED lights lack enough heat to protect from ice accumulation and a heat element of some type should have been included given the placement of the lights being somewhat recessed and that allows for accumulation. Obviously in pre-dawn darkness this produced an unsafe operation of a vehicle at highway speeds due to not being able to see the road far enough in advance. As far as I know it has not been addressed or noticed by Ford since there is no information about this in their manual. I have seen aftermarket products that heat the light surface and prevent the accumulation of ice - Ford should retrofit something to prevent the accumulation of ice on light surfaces.

• 12/01/2025· VISIBILITY

  The contact owns a 2024 Ford Bronco. The contact stated that while the defroster was engaged, the windshield cracked on the driver’s side. The crack started at the bottom of the windshield and spread to approximately 7-inches. The contact had not taken the vehicle to a local dealer or a glass repair shop to be repaired. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to an issue with the OEM windshield. The manufacturer was not informed of the failure. The failure mileage was approximately 3,000.

• 11/25/2025· SERVICE BRAKES

  The caliber seized causing the brake pad the fall and destroy the rotator. No brake indicators like turned on to advised of an issue. Ford does not want to take full responsibility for the faulty part that could have caused a major accident. Ford case# CXH06202259-S8K4B1. The vehicle is still at Ford for the repair so I don't have the repair documents yet.

• 11/23/2025· ENGINEFire

  The failure appears to have originated in the passenger side engine compartment, but the exact component or system (fuel, electrical, or other) is unknown. The vehicle is a total loss from the fire but should be available for inspection at the tow or storage facility. Our safety and the safety of others were put at risk because the vehicle caught fire suddenly while driving with traffic on a public road; my wife was driving, I was in the passenger seat, and our dog was in the back, and if we had not noticed the smoke and pulled over, the fire could have led to loss of control, injury, or a larger fire. The problem has not been reproduced or confirmed by a dealer or independent service center because the vehicle is completely burned and not drivable. As of now, the vehicle has not yet been inspected by the manufacturer; a claim has been initiated with my insurance company, and I expect their representatives and/or a fire investigator to inspect the vehicle, and local emergency services responded to the scene. There were no warning lamps or messages on the dashboard prior to the fire; the only prior symptom was an abnormal odor from the exhaust that smelled like mothballs or ammonia, first noticed immediately after starting the vehicle at the beginning of the trip on November 23, 2025, followed later in the trip by smoke and then the fire.

• 11/16/2025· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SERVICE BRAKES

  Tail lights sensors / control are defective in some way. To be clear the tail lights at the rear of the vechile work perfectly fine and are very bright. They light up during lock and unlock. Also if you set headlight to on when parked. Also note brake lights still work in all situations. However. When they are set to auto at times they don’t light at all even at night. Also if in auto every time when you shift into reverse or drive they also go out. Took video of this issue after two dealer visits they said they were unable to replicate. They are suppose to replace the vechile control unit next week. I have my doubts that’s the issue. I’m willing to wager it’s the body control unit that’s the issue which my vechile doesn’t have for some reason because it wasn’t equipped with the tow package.

• 11/09/2024· FUEL/PROPULSION SYSTEM

  There is an issue when I try to pump gas the pump repeatedly kicks off. It happens every time I put gas in my vehicle. It causes me to not know when the fuel is full. It’s not an issue with the gas pump because it happens at all different locations. It’s a problem with the vehicle itself.

• 11/07/2025· ELECTRICAL SYSTEM,AIR BAGS,STRUCTURECrash

  Vehicle sustained significant front-end impact in a collision, but none of the airbags deployed. Front bumper, hood, and frame sustained visible damage. Concern that sensors or airbag system failed to activate during qualifying crash.

• 11/06/2025· UNKNOWN OR OTHER

  Rear window of 2024 Bronco spontaneously broke with a loud bang while driving 40 mph down 2 lane smooth asphalt road in town, 55 degrees outside. Only 8000 miles on vehicle. Nobody else was on the road, there are no sidewalks. It would be impossible for a rock or other object to hit it from the back while I was driving 40mph. There was nothing being transported inside the back area of the vehicle and no sudden braking or movements in the car. The entire window exploded into the vehicle while all supporting parts dangled. I drove directly to the Ford dealership who confirmed it, took pictures, vacuumed up the window, and filed a claim, but Ford corporate denied a warranty claim. Similar stories can be found on [XXX] , Facebook, Reddit, and [XXX] . It sounded like a gunshot and then the interior of the car was sprayed with glass. I assume other glass fell outward as well. There were no other indications or warnings, and this is a vehicle driven for pleasure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/03/2024· POWER TRAIN,STRUCTURE

  The left front driveshaft is a problem. Had a 2022 Ford Bronco and Ford did a RAV Lemon law. Bought a 2024 and now the same problem is happening again. Same issues and 800 miles on a new Bronco. Also on m 2022 had the hard top replaced 5 times and the axle 2 times. And the top now shows cracks with 800 miles as well. Thought Ford would figure it out. Bronco is a great vehicle, just horrible parts. The main thing is the driveshaft I feel be a HUGE safety ISSUE!!! I hope Ford corporate looks here and gets feedback. By the way, happens after 20 or so minutes of driving, gets warm and it sounds like birds chirping and squeaking.

• 10/28/2025· STEERING,SUSPENSION

  The vehicle started showing excessive tire wear with only 3500 miles on it. We took it to the dealership to have this checked and discovered it the front suspension was severely out of alignment they aligned the suspension and 1500 miles later it was out of alignment again and was re aligned. Then 1500 miles later it was aligned yet again because of excessive wear and pulling hard to the left. The vehicle was returned to the dealership it was purchased from and they kept it for 27 straight days and claimed to have done 5 alignments and the 5th one worked. We drove the vehicle 1000 miles and the front tires were showing even worse wear and the front end was discovered to be out of alignment yet again. As of today the vehicle is scheduled to be returned to the dealership for a 5th time with no real remedy or answer on the issue. I uploaded 10 documents but have 11 more available.

• 10/26/2025· UNKNOWN OR OTHER

  The turn signal stalk automatically switches the active turn signal to the opposite turn signal after a turn is completed, with no turn signal sound for the new opposite side signal. This is repeatable and has occurred since the purchase of the new vehicle. Example: Engaging the left turn signal using the stalk initiates the left turn signal. However, once the left turn is completed and the stalk clicks back into its neutral position, the right signal is automatically engaged, and there is no sound accompanying the flashing right turn indicator light on the dashboard. Other owners and drivers of this make and model have complained on social media about this issue, which can create havoc in certain traffic situations.

• 10/23/2025· VISIBILITY/WIPER

  Went out to start the vehicle one afternoon to notice a Crack from the outside passenger edge by the frame. Nothing hit the windshield and just a single line of Crack spread from one side of the windshield straight across took to ford to be told that while they couldn't see an impact they wouldn't cover it under warranty be cause they couldn't prove it was their fault

• 10/08/2024· UNKNOWN OR OTHER

  The soft top headliner is detaching from the main roof structure right above the driver. This secondary liner is now impeding my view of the road and my view out the passenger side window. This "inner" liner has been pushed back into place numerous times but it is continuing to fall un-expectantly when I am operating the vehicle. This is very startling to be struck in the head from this inner liner at any time. The Dealer is stating this is not under warranty to be repaired and I would have to purchase a new top at my expense - Will the next top have the same problem? I am aware from internet searches that a TSB exists for model years '21-'23. [XXX] - our Ford is a 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 09/30/2025· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  The contact owns a 2024 Ford Bronco. The contact stated that while driving and coming to a stop, the Engine Auto Start-Stop system failed to engage, and the engine revved significantly, causing the vehicle to move forward unintendedly. The contact stated that the failure persisted while standing on the brake pedal, requiring the contact to shift to neutral(N) or to park(P) to stop the engine. The contact stated that the failure had occurred on two occasions. The contact stated that the vehicle nearly moved into oncoming traffic on the first occasion and the vehicle nearly crashed into the rear of another vehicle on the second occasion. The failure also required the contact to steer the vehicle away from another vehicle or to shut off the engine to avoid a crash. The vehicle was taken to the dealer, where it was determined that the failure might be related to a low battery. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 6,000.

• 09/08/2025· UNKNOWN OR OTHER

  Soft top cable that secures stop top became loose or broke. Only opened the top 5-10 times. There is now i rattle and the top is not secure. This is horrible. I have found this mentioned mulitple online threads trying to figure out how to fix. This is obviously a manufacture defect. I bought the bronco in feb of 2025.

• 08/26/2026· UNKNOWN OR OTHER,VISIBILITY/WIPER

  The vehicle was parked in my garage, engaging from park to Drive. The glass blew out from the inside out and the struts shot outward. Luckily, there was no injuries caused by this, but if I were to be driving it could have caused an accident. the dealership said that the manufacturer would deny the claim that there was a manufacturing defect and I went through insurance to correct the issue. there were no warnings, lights, or otherwise associated with this sudden window break.

• 08/17/2026· ELECTRICAL SYSTEM,ENGINE

  The most recent recall on my vehicle has not been corrected by my local Ford dealer yet. The deadline was July 31, 2026 and it is now August 17, 2026.

• 08/12/2024· UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  The display screen freezes up disabling all functions.Including back up camera,A/C, and radio.

• 08/10/2026· UNKNOWN OR OTHER

  JUL 20, 2026 Manufacturer Recall Number26S55 NHTSA Recall Number26V468 Recall StatusRecall Incomplete, remedy not yet available Summary ON my VEHICLE, AN ENGINE COMPARTMENT WIRING HARNESS COVERING MAY CHAFE AND EXPOSE INTERNAL CIRCUITS, WHICH CAN CREATE A SHORT TO GROUND. It’s a Safety Risk. HEAT OR SPARK AT THIS SHORT MAY CAUSE SMOKE OR IGNITE NEARBY FLAMMABLE COMPONENTS. SMOKE OR FIRE FROM THE ENGINE COMPARTMENT AREA INCREASES THE RISK OF INJURY OR A CRASH. A REMEDY IS NOT YET AVAILABLE.

• 07/25/2026· UNKNOWN OR OTHER

  MIC Hardtop is cracking and honeycomb

• 07/24/2026· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Vehicle hands free for phone is not understandable to others after a software update over a year ago. After an automatic software update I made a phone call and the person called complained about me not being understandable. I disconnected and called again. Still unreadable. I tried calling someone else. Not readable. Was told I sounded like I had my head in a bucket of water. I called a third person. Not readable. All this happened immediately after the software update. I took my vehicle to the dealer the first opportunity I had time. The problem was verified by a service tech. He did a hard reboot of the system. The problem did not improve. I was asked to make an appointment. The vehicle has been back to the dealer many times since. The problem has not been resolved. The SAFETY PROBLEM is that I am not able to use my phone hands free. PA passed a law that touching a phone is a moving violation. The dealer said it was my phone. I have a Kyocera ruggedized phone. I replaced it with a newer version of the phone. Cost was over $800. FYI - I have used my phone on my wife's Bronco which has NEVER had a software update as the auto updates was turned off. I also own a Ford F-350 with Sync3 and the phone works fine. I was driving a Mack dump truck with hands free. No problem. I have checked it on 2 friends Honda cars. No problem. Apparently my phone works with everything but my Ford Bronco. Sometime during the last few months there was a safety recall for the same entertainment system that the phone uses going black. I never had this problem. Ford engineering still says the problem is my phone. I am not replacing my phone again to find that I still can't be understood. I have done some online research on this and found posts on multiple bulletin boards there seems to be the same problem with other owners of Ford Broncos and F-150s with Sync4. Not being able to use the hands free is a serious safety problem.

• 07/07/2026· ELECTRICAL SYSTEM,STRUCTURE

  I notified the dealership where I bought the vehicle of the issue when it first happened in Feb 2025. I have since notified them 3 additional times and I have called Ford Motor Company, twice. The roof leaks in heavy rain while driving and when going through a car wash. The water streams inside and runs down onto the lighted vanity mirror which is connected to the electrical system of the vehicle and hits the driver in the face with water. The dealership said that they tried to reproduce the issue but couldn’t get it to leak. It’s because they aren’t using water at a high pressure and speed. I have since found that the issue is know as it is listed on the internet in multiple places.

• 07/07/2025· UNKNOWN OR OTHER

  Subject: Unresolved Safety Recall – Ford Bronco To Whom It May Concern, I am writing to formally lodge a complaint regarding an outstanding safety recall on my Ford Bronco. I received a recall notification letter from the manufacturer in January of this year concerning a critical safety issue. However, as of today’s date, the issue has not been resolved, nor have I received a clear timeline for repair. When I first purchased the vehicle, I noticed a pronounced bouncing sensation while driving at speeds around 70 mph. I brought this to the attention of the dealership, but they assured me that the vehicle was functioning normally and that there was nothing wrong. However, the existence of this unresolved recall has made me question whether the issue I experienced is truly unrelated—or if it was early evidence of a deeper safety concern. I feel unsafe driving the car, and no receiving any information about when the necessary parts or services will be available. This delay in action leaves my vehicle potentially unsafe and creates significant inconvenience, as I rely on it for daily transportation. I urge the NHTSA to investigate the prolonged delay in remedying this recall. Consumers deserve prompt and transparent resolution when their safety is at risk. Please advise on any further steps I should take to escalate this issue and keep me informed of any actions that may be taken. Thank you for your attention to this matter.

• 07/05/2025· STRUCTURE

  Removable top cracks and allows moister into effected panels fostering an environment for possible black mold growth.

• 07/05/2025· STRUCTURE

  Removable top cracks allowing moisture to get into effected panels fostering an environment for black mold growth.

• 06/30/2025· POWER TRAIN,ELECTRICAL SYSTEM

  While vehicle was on a boat ramp the vehicle”s gear shift was put into the park position. The vehicle’s park gear failed to engage and it continued to roll backwards. Additional attempts to then put the vehicle into drive also failed to respond. My brand new 2024 Ford Bronco that only had just over 2300 miles on it, continued to roll backwards until it was completely submerged underwater. The vehicle had to be pulled out of the water by another truck!!! With my wife and children watching I was fortunate enough to escape without drowning!!!!

• 06/30/2025· SUSPENSION

  The contact owns a 2024 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 06/26/2025· UNKNOWN OR OTHER

  There’s been reported weakness in the back glass due to manufacturer defect in back window parked spontaneously shattered and window shocks shot through window, ford doesn’t have any current open recall but customer service says they have several people call with this, it’s being reported on the internet but again they won’t honor recall or manufacture warranty, I just bought this car a couple weeks ago

• 06/23/2026· BACK OVER PREVENTION

  The contact owns a 2024 Ford Bronco. The contact stated that on several occasions, the APIM overheated, and the rearview camera was inoperable. The VIN was not included in NHTSA Campaign Number: 26V124000 (Back Over Prevention). Additionally, the power windows and AC were inoperable due to the failure. The contact stated that the vehicle stalled due to the APIM overheating. The dealer was contacted, and a repair of the vehicle was pending. The manufacturer was not made aware of the failure. The failure mileage was unknown.

• 06/12/2024· VISIBILITY

  The contact owns a 2024 Ford Bronco. The contact stated while pulling out of the driveway, the contact noticed that the driver’s side passenger’s window fell from the vehicle. There was no warning light illuminated. The vehicle was taken to dealer where a diagnostic was undisclosed. The contact was informed that the window needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 365.

• 06/03/2026· SEATS

  The contact owns a 2024 Ford Bronco. The contact recieved notice of NHTSA Campaign Number: 26V268000 (Seats). The contact stated that the vehicle was taken in to a dealer where the failed the inspection and she was notified that the bolt could come loose. The manufacturer was not notified of the failure where she was notified that they did not have the part available at this time. The failure mileage was approximately 9,004.

• 05/30/2025· UNKNOWN OR OTHER

  Roof leaking water on the hardtop bronco I own will be going to the dealer for the second time to address this issue. Order comes in next to glove box on the passenger side.

• 05/30/2025· UNKNOWN OR OTHER

  When making right turn, after completing turn the indicator automatically activates for a left turn. I have had this occur 10 times since purchasing vehicle last month.

• 05/29/2026· STEERING,SUSPENSION

  The Sta-bar continues to disconnect. Had been in shop 5xs for same issue 2 weeks each time with hopes that they fixed it. Within 500miles after leaving shop it does it again and warning flashes to seek maintenance immediately. There is no obvious reason of why. It will donit when it's dry, when it's raining or snowing. It happens when I first turn car on or it could happen going 70mph on highway. Started within the first 1000 miles on car and has continued, currently at 18000miles. Car feels unsteady on every bump and ripple and with high winds when it occurs. It happens more times then I can count now, tired of paying high monthly payment for it to sit in shop.

• 05/21/2026· STRUCTURE

  My MIC roof cracked, and I only have 6700 miles on the vehicle. I am now reading that my roof could blow off.

• 05/20/2026· STRUCTURE

  The molded in color hardtops are bad on these Ford Bronco’s. I wanted to report it because mine started cracking, fading, delaminating, and leaking after the vehicle was only 3 months old. They are very defective. Ford warranty replaced mine after a full year of me going back and forth to the dealer to argue about it. It was a long process that I never expected on a brand new vehicle. I’m already starting to see the honeycomb material on my warranty replacement top. I know people who are on their 4th and 5th replacement tops. Also, the road noise is bad with these tops as well. Mine as been warranty replaced now, but it was a rough experience over all and I have zero confidence that the replacement top is of better quality. In fact, the customer service representative at Ford stated more than likely this replacement hardtop would go bad at some point just like the original. They said it was the exact same top with no improvement.

• 05/20/2025· STRUCTURE

  The contact owns a 2024 Ford Bronco. The contact stated that after purchasing the vehicle, it was discovered that the rear trim cover did not sit flush with the soft top roof installed, making the roof unsecure. The manufacturer and local dealer was notified of the failure, but no assistance was offered. The contact was made aware of the NHTSA ID Number: 11001584 (Structure) and related the failure to the NHTSA ID number. The failure mileage was 10.

• 05/19/2026· UNKNOWN OR OTHER

  Back piece of hardtop cracked on each side, front three pieces had honeycombing and ripples down each side that you could see and feel. The dealership warrantied them out , but my front three pieces still have issues. The dealerships also told me if this happens outside of my 3yr/36,000mi warranty that they will not fix the issue even though parts typically have a 2 yr warranty on them after being replaced. But, this isn't a normal part, this is my roof/hardtop. This is a safety concern. I never received any lights, messages, or symptoms that I know of. There could have been leaking water in the back part of my Bronco. The safety of others and myself were put at risk because, there were cracks in my roof and what if it cracked all the way through and broke off?

• 05/19/2026· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  ERROR WITH STABILTIY BAR DO NOT DRIVE OVER 20 MPH. NO KEYS DETECTED IN VEHICLE. VEHICLE IS NOW BACK AT THE DEALER FOR THE 4TH TIME FOR THE SAME REPAIR.

• 05/17/2026· ELECTRICAL SYSTEM,WHEELS,ENGINEFire

  I was idling (foot on the brake) at a coffee drive thru when I started to smell smoke and suddenly a women ran up and told me my passenger side front tire was on fire.

• 05/04/2026· POWER TRAIN,STRUCTURE

  The contact owns a 2024 Ford Bronco. The contact stated that while coming to a stop, the vehicle would unexpectedly lunge forward and hesitate, with no warning lights illuminated. The contact also stated that a loud, abnormal rattling noise was coming from the soft top area of the vehicle. The vehicle was taken to the dealer; however, it was not diagnosed. The contact was informed that the transmission software needed to be reprogrammed. The dealer also stated that the soft top failure is a known issue with the vehicle. The vehicle was reprogrammed, but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 13,000.

• 05/01/2026· ENGINEFire

  The contact owns a 2024 Ford Bronco. The contact stated that while the vehicle was idling, a fire originated near the dashboard area without warning. The occupants inside the vehicle first noticed an abnormal smoke odor inside the vehicle. Shortly afterwards, the contact and passenger’s eyes started burning and their throats became irritated. The driver opened and then closed the windows and then safely pulled over. The heated seats were turned off during the failure. The passenger then observed flames coming from the passenger’s side air vent. The contact and passenger exited the vehicle with the engine still running. The windows blew out from the intense heat of the fire. The air bags did not deploy but started melting. The Fire Department arrived on the scene and extinguished the fire. No injuries were reported. A Police report was not filed, but the Police were directing traffic. The vehicle was towed to a collision center. The local dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a claim was opened. The manufacturer was contacted and referred the contact to the insurance company for assistance. The failure mileage was approximately 11,685.

• 05/01/2026· STEERING

  When turning right the left turn signal is triggered automatically 60-75% of the time. This mis direction signal has potential to cause confusion to surrounding drivers thus creating a potential driving hazard. The whole purpose of the turn signal is to declare driving intent to other drivers.

• 05/01/2025· SERVICE BRAKES, HYDRAULIC,POWER TRAIN

  The contact owns a 2024 Ford Bronco. The contact stated that while driving at an undisclosed speed, the "Pre-Collision System Fault Detected" message was displayed. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was towed to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The contact stated that later while driving at an undisclosed speed, the "Powertrain Fault Detected - Reduced Power”, “Service Engine Soon" and "Brake Fault Detected" messages were displayed. The vehicle was taken back to the dealer, who diagnosed a failure with the brake actuator. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 5,000.

• 04/20/2026· ELECTRICAL SYSTEM,VISIBILITY/WIPER,LANE DEPARTURE

  The following systems and features have been repeatedly failing in my vehicle, posing a safety hazard: 1) The side view mirrors change orientation automatically while driving. 2) The blind spot warning is inconsistent and is not trustworthy. 3) The infotainment display turns off erratically while crossing critical intersections where I am supposed to turn. This is extremely distracting and poses a severe safety risk. 4) The infotainment system’s audio volume, audio source and car play connection turns off randomly. This is extremely distracting and poses a severe accident risk. 5) The air conditioning strength and temperature changes automatically with the fan blowing extremely cold or extremely hot air. 6) The windshield wiper automatic speeds are mis-calibrated and gradation between the various levels is non-linear and erratic. This forces the driver to frequently adjust the wiper speed while driving, posing a distraction and accident risk. 7) The automatic high beam feature doesn’t work, or works erratically. This ambiguity causes distraction and dangerous night time driving situations. 8) With manual operation of high and low beams, there is a significant delay while switching from one to another, posing risk while night time driving. 9) The windshield cleaning feature with dispersal of the fluid works erratically. It works some of the time and doesn’t work other times. This ambiguity poses a severe risk while driving due to unclear windshield. 10) The tire pressure sensor displays inaccurate inflation pressure at times. This ambiguity can be catastrophic given the vehicle size and California’s mountain road driving under slick and snowy conditions. 11) The GPS directions displayed on phone and infotainment system are inaccurate and inconsistent, causing massive confusion while exiting. This is a new vehicle from 2024 and has been inspected and serviced at the dealership diligently. I have video evidence for some of the problems.