2023 Ford Maverick HEV

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/20/2025· POWER TRAIN

  When driving at higher speeds (60-70mph) and needing to pass another vehicle the clutch slips which triggers the accelerator to shut down. Leaving you helpless in the passing lane. All you can do is hope there is space to safely pull off the road and shut the engine off. This puts it in limp mode.

• 12/06/2024· TIRES

  The contact owns a 2023 Ford Maverick equipped with Continental Tires, Tire Line: ProContact TX, Tire Size: 225/65/R17, DOT Number: 1P50FBC3K. The contact stated while his wife was driving approximately 65 MPH, she heard an abnormal bang or popping sound. The contact stated that the low tire pressure warning light for the rear driver's side tire was displayed. The contact stated that his wife stated that the tire pressure fell to zero pressure in seconds. The contact stated that his wife was able to exit the highway and called the contact. The contact arrived and changed the tire and had not observed any damages to the tire, and there were no signs of a blowout. The contact stated that prior to the tire failure he had noticed that all four tires had a single indent on the sidewall the width of a pencil starting at the rim and running to where the sidewall the tread was joined. The vehicle was not taken to a dealer or tire dealer. The tire was not diagnosed. The vehicle manufacturer was notified of the failure. The approximate vehicle and tire failure mileages were 15,000.

• 12/02/2025· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/01/2025· POWER TRAIN

  The 2023 Ford Maverick Hybrid is experiencing a recurring safety failure of the Front CV Axle Shafts. The vehicle exhibits violent, uncontrollable shaking of the front end during acceleration at highway speeds (40–65 MPH). This severe vibration compromises vehicle stability and steering control, creating a significant safety risk during merging or overtaking maneuvers. The vehicle was previously repaired for this exact issue by an authorized Ford dealer on May 30, 2024 (at ~32,000 miles). However, the failure has recurred 18 months and 33,000 miles later. Inspection of the current failed parts reveals that during the 2024 warranty repair, the dealership installed obsolete, superseded part numbers (Series "NZ", specifically NZ67-3B436) instead of the updated, corrected design (Series "SZ") released by Ford to fix this known defect. Because the dealership replaced defective parts with the same defective/superseded design, the safety hazard has returned prematurely. The defect was previously confirmed by a dealer technician. The current failure is confirmed by visual inspection of the part labels showing the obsolete "NZ" code. No warning lights appeared prior to failure; the symptom is immediate mechanical vibration under load.

• 11/05/2025· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".

• 11/05/2025· POWER TRAIN,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

  I had been driving for 2 hours on the interstate when the truck starts losing power and warning lights start flashing. I got the truck to the shoulder before it slammed to a stop. I turned the engine off and waited until all the power turned off before restarting. The truck would only run in limp mode at 35 mph. I drove on the shoulder of the interstate to the next exit. I disconnected the battery and reconnected which allowed me to drive it normally to the dealership. After two days the dealer called to say they didn’t see any codes and there wasn’t anything wrong with it even after I sent pictures of the warning messages. This is the 5th time this has happened under similar circumstances.

• 11/01/2024· POWER TRAIN,ENGINE,FORWARD COLLISION AVOIDANCE

  On 1028/24, driving at approximately 55 mph in the right lane of a local highway, the front collision braking system engaged almost totally stopping my vehicle. There were no vehicles, animals, nor pedestrians in front of my vehicle. I was able to pull to the shoulder. The collection detection icon appeared on the screen, as well as the check engine light, and the wrench. Then a message saying collision warning system unavailable, then service vehicle immediately. The drive gear dial remained in drive (D) position and was flashing. From there, with my warning light activated, I was able to get the vehicle to go up to 25 mph in order to drive to the Ford dealership nearby. I was told by the service department that they operate on appointments only, I would "try to look at it soon." The Ford Pass App states a powertrain malfunction, pre-collision assist not available, and service engine soon warning. Even if the system resets itself when vehicle turned back on, it is totally unsafe to drive in traffic not knowing if these systems will unexpected fail again, causing an accident and injury. I understand that this problem has occurred with other drivers on this model in the recent past.

• 10/31/2025· UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

  The car have a Big vibration when speed up over 45 MPH

• 10/30/2025· POWER TRAIN

  PREMATURE CV axle failure due to regenerative braking. This cause violent wobble leading to the death wobble

• 10/26/2025· POWER TRAIN

  At 20k miles the vehicle starts shaking back and forth and rattling while accelerating and I brought it to the dealership and its being serviced under warranty to get both front CV axels replaced. It was shaking so badly and vibrating the whole vehicle, the dealership told me it was unsafe to drive when they saw how badly the axels failed. There were no warnings or check engine lights. Especially dangerous because it doesn't shake at low speeds only when accelerating and at high speeds.

• 10/23/2023· TIRES

  225/65R17 SIDEWALL BLEW OUT AND TOOK TO MAVIS THEY SAID YOUR OTHER 3 TIRES ARE GOING TO FAIL THEN TOOK TO DEALER THEY SAID SIDEWALL INDENTATION IS NORMAL.

• 10/08/2025· VEHICLE SPEED CONTROL

  Vehicle stopped accelerating while doing an U turn with oncoming traffic. Had to pull over because the vehicle would not move.

• 10/03/2025· POWER TRAIN,UNKNOWN OR OTHER

  Truck shakes when accelerating and limits acceleration and safety. Belief is the CV axles failing.

• 10/02/2025· POWER TRAIN

  Vehicle started shaking during acceleration above 40 mph. Felt like the wheels were going to come off. The issue is that the front axle drive shafts are very corroded and failing.

• 10/01/2025· UNKNOWN OR OTHER

  Vehicle information: Ford Maverick 2023 Hybrid, with roughly 37,000 miles, observed failure on [XXX]. The failed component/system is the A/C evaporator condensation drain system. The drain line became clogged, which I believe is a critical defect in either the design, component, or construction of the drainage system. The lack of a fail-safe in this system, instead of draining water outside of the vehicle, the condensation backed up and leaked directly into the vehicle's cabin onto the driver and passenger side footwells. The vehicle is currently at the dealership (Windward Ford), undergoing diagnosis/repair, and available for inspection upon request. The pooling of a large volume of water on both the driver and passenger side floorboards to include the path of where the water originates as it collects at the footwell, creates an unreasonable risk of safety failure due to the proximity of critical electrical systems; fire/short circuit risk, loss of vehicle control due to damage to electronic modules from water intrusion, as well as health hazard with prolonged saturation of pores material resulting to mold and mildew growth. The issue has been reproduced at the dealership (Windward Ford), and confirmed that the issue is an A/C evaporator drain clog, causing the leak, and the carpet and interior padding were saturated, requiring extensive cleaning and replacement. The failed component/system has been inspected by technicians at the dealership. The diagnosis and repair estimates are on file with the dealership. There were no warning lamp indicators or messages, just the damped smell, which was noticed a few weeks prior to the visual indicator of a water puddle in the floorboard. The odor is a direct result of the ongoing, hidden water leak and saturation of the carpet, indicating a slow, chronic problem caused by the defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 09/22/2025· ELECTRICAL SYSTEM

  Receive "Has Entered Deep Sleep Mode" daily notification through the Ford APP. The dealership keeps telling me there isn't anything wrong with the battery, as it's test good. Even though the can see (an I've shown them) the notifications. It's being driven as it's my daily driver. It hasn't put me at risk at this time.

• 09/19/2025· UNKNOWN OR OTHER

  My entire front end is vibrating badly. I replaced all tires and did a front end alignment. It didn't fix the issue. I took it to the dealership for diagnosis and they said the axels are bad and a known issue on the make model and year.

• 08/24/2026· POWER TRAIN

  Truck started to shake when accelerating past 50 mph. The shaking would stop once the speed limit was reached and you let off the accelerator. Web search results showed 2022, 2023 & 2024 Ford Maverick hybrids are known for CV axle failures with those symptoms. Vehicle was around 48,000 miles. Dealership replaced both CV axles under the 5 year/60,000 mile warranty.

• 08/20/2025· ENGINE

  The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 65 MPH, the check engine warning light illuminated, and the "Service Engine Immediately" message was displayed. The contact stated that the vehicle started losing motive power. The accelerator pedal was depressed, but the vehicle decelerated to 5 MPH. The contact stopped and had the vehicle towed to a dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact used a handheld scanner and retrieved DTC: P1061 (Faulty Rod Bearing). The vehicle was towed to the same dealer, but the dealer was unable to duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the same dealer where it was determined that the long block needed to be replaced. The vehicle was not repaired. The contact spoke with a mechanic and was informed that the failure was related to Customer Satisfaction Program: 23N06 (Long Block Replacement). The manufacturer was contacted for confirmation that the vehicle was covered under the CSP; however, the contact was informed that the vehicle was not covered under the CSP. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

• 08/15/2025· ELECTRICAL SYSTEM

  The 12-volt battery loses charge and issues a warning that remote features have been disabled. This issue has been going on since January 2025. To date, I have recharged the battery 15 times, plus taken it to 2-different Ford dealerships for warranty service. Both were unable to resolve the problem. Beginning with the 2025 model year, Ford commenced installing AGM 12-volt batteries which resolved the problem. The vehicle is still under warranty but the dealerships simply recharge the battery and return the vehicle. My vehicle is not part of the Ford recall for this problem. The root cause appears to be poor quality Chinese batteries used in the early model years.

• 08/12/2026· POWER TRAIN

  At around 27K miles the two front CV axles began to fail. I brought it to the Ford dealership and they confirmed that both needed to be replaced. It was a $1600 repair. There have been a lot of complaints from Ford Maverick owners who have had CV axle failures at very low miles on their vehicles. These parts typically last 100K to 150K miles and it's not unusual for them to last the lifetime of the vehicle. There is no reason both front CV axles should be failing with 27K miles on a vehicle. This should be covered by a recall.

• 08/12/2025· SUSPENSION,POWER TRAIN,UNKNOWN OR OTHER

  At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.

• 08/07/2025· UNKNOWN OR OTHER

  violent shaking on accelerating

• 08/06/2025· ELECTRICAL SYSTEM

  Battery in truck continually dead Malfunctioning equipment had left me stranded Vehicle has been inspected numerous times and ford will Not fix

• 08/05/2025· SERVICE BRAKES, HYDRAULIC,FORWARD COLLISION AVOIDANCE

  The contact owns a 2023 Ford Maverick Hybrid. The contact stated that while driving at an undisclosed speed and depressing the brake pedal, the pedal vibrated and pulsated, but the vehicle did not immediately stop, causing the braking distance to be extended. Additionally, the contact stated that the warning message "Pre Collision Activated" was erroneously displayed while driving with no other vehicles or large objects nearby. The vehicle was taken to the local dealer, who was unable to determine the cause of the failures. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 10,000.

• 07/31/2026· STEERING,LANE DEPARTURE

  The truck was being towed behind a motor home, while making a normal left turn from a complete stop the truck began swing wildly from side to side (death wobble). After stopping I found a dash warning "Steering Assist Fault, Service Required" and "Drive Mode Not Available". At that time the truck steering was very difficult to turn, the truck was not drivable. This is the second time this has happened. In June 2024 the exact same thing happened. Ford replaced the steering assembly (twice, the first part was defective) under warranty. I believe this to be a safety hazard. I tow the truck behind the motor home in order to have reliable transportation when I arrive to a destination and also to provide a safe way to get help if some incident occurs while on the road (motor home break down) or for an emergency at the destination. Both steering assist incidents occurred when I was in a remote area with no cell service or internet service. Had there been any kind of medical emergency it could have had unwelcome results.

• 07/29/2025· ELECTRICAL SYSTEM

  The contact owns a 2023 Ford Maverick. The contact stated that on three occasions, while the vehicle was parked, the vehicle failed to start. The contact attempted to jumpstart the vehicle however, the vehicle failed to start. The vehicle was taken to a dealer to be diagnosed, and it was determined that the battery needed to be replaced. The vehicle was repaired but the failure reoccurred three months later. The contact stated that the dealer replaced the battery, and the vehicle was taken to the dealer, where it was determined that the battery was defective and needed to be replaced. The battery was replaced however, the failure reoccurred approximately four months later. The vehicle was taken to a different dealer, where it was diagnosed that the battery needed to be replaced. The manufacturer was notified of the failure. The contact believed that the failure was related to Manufacturer Recall Number: 53801. The failure mileage was approximately 22,000.

• 07/28/2026· POWER TRAIN

  Significant disruptive vibration upon acceleration at high speeds due to premature failure of front CV Axles. Confirmed failure of both axles by manufacturer at approximately 61,000 miles.

• 07/26/2025· POWER TRAIN

  Both front axles had to be replaced at 62000 miles. Just about of fords power train warranty. Have read multiple issues of these trucks having the same problem.

• 07/22/2025· STEERING,POWER TRAIN

  2023 Maverik Hybrid at around 30,000 miles Vehicle would start shaking while accelerating. I took it to the dealership and they had to replace all the components in the front end of the truck. I know have about 60,000 miles on the vehicle and I'm having the same shaking problem while accelerating. It looks like this is a common occurrence with this vehicle. It is no longer under warranty and is going to cost a lot to get fixed. Not excited about having a major repair every 30,000 miles.

• 07/17/2025· STEERING,POWER TRAIN

  Cv axles went out at 55k causing shaking at highway speeds while accelerating. Frequently when starting the car the steering wont activate right away even after the car begins to move for 5-10 feet. Dealer cant replicate because it doesnt happen every time. But it is still doing it and may cause a crash in the future....

• 07/16/2025· POWER TRAIN,ELECTRICAL SYSTEM

  The contact owns a 2023 Ford Maverick Hybrid. The contact stated while driving 65 MPH, the vehicle unintendedly decelerated to 35 MPH while driving downhill and decelerated to 6 MPH while driving uphill. The message "Engine Repair" was displayed, and the power train warning light was illuminated. The vehicle was taken to the dealer, where the diagnostic trouble codes were cleared; however, the vehicle was not diagnosed or repaired. The contact stated that the PCM was previously updated under an unknown recall in 2024; however, the failure recurred while driving. The vehicle was taken to Maguire's Ford of Hershey, Inc. (100 N Thistledown Dr, Palmyra, PA 17078); where the diagnostic trouble codes were cleared; however, the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 25V158000 (Power Train, Electrical System); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the dealer and to the NHTSA Hotline for assistance. The failure mileage was approximately 400.

• 07/16/2024· UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  May 25, 2024 I was driving north on a 2 lane road at about 50 mph. No other vehicles around. Passed a pedestrian walking SB on the opposite shoulder and shortly thereafter my collision assist startled me when it activated fully locking my seat belt and applying the brakes. Only "obstacle" was a very large dark shadow cast over the roadway by a stand of trees. June 9, 2024 Driving EB on a two lane highway, about 55 mph, approaching an intersection with a vehicle stopped at a red light on the south side of the intersection. Pre-collision assist activated again, slamming on the brakes, throwing me and my passenger forcefully forward into our locked seat belts. Scared us both, as there were no obstacles in our path. Thankfully no one was behind us, so we avoided a rear end collision. I have since deactivated the automatic emergency braking, because I no longer trust it will operate correctly and I don't want to be rear ended and/or sustain whiplash or other injuries because of erroneous activation of a "safety" system.

• 07/10/2025· ELECTRICAL SYSTEM

  The vehicle has less than 12,000 miles. Vehicle repeatedly entered "deep sleep" mode, disabling vehicle remote features and lights inside of vehicle. Took to dealership multiple times. Battery test showed sulfation and can no longer function as designed. Factory 12v battery replaced and software update completed yet still experiencing the same “deep sleep” mode.

• 07/02/2024· UNKNOWN OR OTHER,SERVICE BRAKES

  I believe this incident occurred on June 25th (though it might have been the 24th or 26th). I left work shortly after 5:00 pm and was driving around a roundabout. I was going slowly, lightly tapping the gas pedal to maintain a speed between 10-15 mph. During one of these light taps, my truck gave an audible alert and the brakes engaged suddenly for a split second. I immediately took my foot off the gas pedal. The alert and chime stopped, and I continued driving normally. I'm fairly sure some kind of alert appeared on the instrument panel cluster, but it happened and disappeared so quickly that I couldn't see anything clearly. It all happened in the blink of an eye. The brakes engaged and released so rapidly that I tried to recreate the event using the brake pedal to ensure my foot wasn't on it by mistake. However, the brakes did not engage as quickly or abruptly during my attempts. I am certain my foot was on the gas pedal, not the brake. The gas pedal has a lighter, bouncy feel, while the brake pedal requires more pressure. And I remember a light touch causing this issue. When this incident occurred, I am confident that the light taps on the gas pedal to maintain a low speed triggered the issue. I drove home without any further problems, and this has not happened since. I also want to mention that my truck had previously gone into limp mode suddenly, but I had that recall issue fixed shortly afterward.

• 06/23/2026· SERVICE BRAKES

  The Ford Maverick has a known issue with "grabby brakes." I recently took my vehicle in for service and was advised the vehicle had an outstanding service bulletin to solve this problem. The repair given by Ford is ineffectual. There is a potential problems, even at low speeds, for sudden braking and collisions. This is ongoing at every stop and experienced by other Maverick owners.

• 06/23/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  While traveling at speed there was a severe malfunction of the vehicle's stereo system. While driving the stereo was initially silent but later began to produce extremely loud noise/static. The volume of the noise was so extreme I had to take my hands off the steering wheel to cover my ears. The stereo did not respond to any power or volume input to stop the sound and I was forced to quickly pull over to the side of the road to turn off and exit the vehicle. The sound only stopped after exiting the vehicle and locking with the key fob. There were no warning signals prior to this failure. I have experienced this problem several times in the past while the vehicle was parked, when first starting the vehicle. This was the first instance of experiencing the problem while driving, within the first 1 minute after starting the vehicle. The stereo was initially on and set to a reasonable volume level, but was malfunctioning and completely silent. After driving for ~45 seconds the stereo began producing this extremely loud noise. I have found several reports of similar stereo issues with the Ford Maverick and also F150 trucks that are equipped with a similar B&O sound system.   This malfunction could potentially lead to an extremely dangerous situation, inability to safely operate the vehicle, and loss of situational awareness. I have dash cam footage of the incident, which I can provide upon request.

• 06/21/2026· POWER TRAIN,ELECTRICAL SYSTEM

  12 volt electrical system no power. Dealer changed battery cable wiring harness. Received vehicle back. One week later vehicle exhibited no 12 volt power. Informed that it could be the Thinkware dash cam. Which was purchased from Ford and Ford dealer installed. Now informed that it could be the dash cam itself. The dash cam was installed via the OBD port which is always powered. This will drain the 12 volt battery unless vehicle is driven for extended periods. Ford is aware of the issue but no remedy for over 3 weeks. I have told the Ford dealer to have the dash cam installed so that when the ignition is on the dash cam is also powered on and off when the ignition switch is turned off. Using this method negates the parking mode on the dash cam. Another issue is when the drivers side door is opened the interior lights do not activate. Ford notified. Problem not resolved. Low 12 volt battery issue?

• 06/19/2026· ELECTRICAL SYSTEM

  12-Volt battery gets extremely hot and gives off invisible fumes. Model number is BAGM-H14. Vehicle was towed to dealership for diagnostic evaluation. Also, dashboard shows various warning messages. Battery could not be charged, plus does not maintain charge.

• 06/19/2025· POWER TRAIN

  The front of the vehicle started shaking with acceleration. This shaking became worse and vehicle was unsafe to drive. The vehicle was brought to ford dealership and they will be replacing the front half shafts and brackets.

• 06/06/2026· STEERING,WHEELS,UNKNOWN OR OTHER

  This vehicle has chronic clicking when turning , when taken to a mechnanic i was informed the CV Axles both were torn and that it was a common issue for the 22 ford mavericks and they issue replacements for free. However when it comes to this they don’t cover it. The issue is still present and left untreated could be a dangerous issue.

• 06/03/2026· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM

  Receiving daily Battery Saver Mode notices telling me some remote features including lock/unlock may temporarily be unavailable. Not to use my AC and go for longer rides, which I have done with no change. My interior lights are not coming on. My radio powers off and on while driving. Constant clicking and noises come from the vehicle when turned off. Difficulties starting the vehicle at times. Feel power losses when driving and accelerating, feel like I could be rear ended when this happens. In doing some online research, I am clearly not alone in this issue, when I contacted Ford and the dealership they both acted as if this is not a current issue and I would have to it inspected by a Ford dealership with no guarantee that the inspection would be covered. I found a recall 24S24 that sounds like my exact issue, yet they say it's not been authorized for my vehicle.

• 06/01/2026· POWER TRAIN,ENGINE

  Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.

• 05/22/2026· VISIBILITY/WIPER

  Recall 24S51 from Ford says that 87,000 Maverick trucks have had the wiper motor fail due to moisture getting into the housing due to a sealant problem with the supplier. The recalled VINs can have a free inspection and replacement. I believe my VIN is also impacted by this problem because 37 months and 31,000 miles into my car, my wipers failed. I was driving in light rain and the wipers would only go up about 6" from their resting position before returning to the resting position, then repeat the same thing. Thankfully the rain wasn't so heavy that I had to stop and could continue driving home (very carefully!). We've had a very dry winter, so I haven't used my wipers in months. The prior week before the failure, we had a big snow/rain storm spanning two days with about 1.5" of moisture coming down. Hence, I think this storm precipitated, literally, my issue. I took my Maverick to the Ford dealership for a hitch recall, asking about this wiper motor recall problem at the same time. I picked up my truck today and after it's been sitting in the sun, my wipers work again. It sure seems that when moisture is getting into the housing, the wipers fail, then the sun dries it out, then the wipers work. Note, my truck is not garaged. I believe my VIN should be part of the 24S51 or 24-594 recall. Since in my almost 60 years of driving, I've never had a failure of a windshield wiper motor in this way, it seems to be a very rare thing to occur. With a recall of this part in other Mavericks similar to mine, I think mine is actually affected as well.

• 05/20/2025· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  Total 12v battery drain/failure which is a known problem with the Ford Maverick Hybrid, could not even put hazards on to avoid getting hit on the side of the road. Ford tests battery and says battery is good, but the problem is the Maverick Hybrid is not adequately charging the battery when it is driven.

• 05/18/2025· POWER TRAIN,ELECTRICAL SYSTEM

  On Tuesday, [XXX], my wife and I were driving her, new to her, 2023 Ford Maverick Hybrid XLT, that we purchased from Stuckey Ford in Bellefonte, PA on [XXX]. She was behind the wheel. We were heading west on [XXX] and had just passed into Pennsylvania by crossing the Delaware River. The check engine light and battery lights went on suddenly & we immediately lost power. The power steering was no longer working, but the brakes were. As we were in the passing lane going 65 mph & there was an 18-wheeler in the right lane, we could not cross two lanes to reach the Matamoras exit ramp. She steered into the median between lanes to our left. The Maverick would not start. We were about 6" off the left hand white line of the west bound passing lane. I called 911 who sent a PA State Trooper to park behind us with his flashers on. We were towed off the [XXX] exit ramp to a garage. We tried to start the truck five times, it would not start. The sixth time it did start but when the tow truck operator tried it, the truck only started intermittently. We called the nearest Ford Dealer, Healy in Goshen, NY. We were towed to Healy the same afternoon. They said their diagnostics could find no problems. Their invoice is attached. Since the event on [XXX], the Maverick has not turned on when the key is turned & brake pedal depressed multiple times. When this happens the same two lights (check engine & battery) stay on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 05/17/2026· POWER TRAIN

  While driving the vehicle at low speed (roughy 25mph) a loud sqeek was heard. This occured a few more times so I stopped to inspect. I countinued my trip after not finding the source of the noise. When it occured again, I pulled into a parts store and had them run codes. After finding none I purchased a code scanner so that I could monitor while under way. Once on the highway the sound became more frequent, after just a few miles warning lights appeared on my dash and the vehicle had a complete loss of power. I was able to coast to the side of the road. At that time the vehicle did have code P1061. Dealer diagnosted the truck with a failed transmission. I removed the trasmission and disassembled it. The main shaft had been stripped of it's splines on the gear that connects to the engine. I have a video of the gears and shaft here: [XXX] I saved the parts and will be happy to provide them for investigation if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 05/13/2025· ELECTRICAL SYSTEM

  I own a 2023 Ford Maverick XLT Hybrid. I am having issues with the 12v battery. The battery drains unexpectedly making the truck go into Battery Saver Mode. I already took it to the Ford de leadership where it received a new 12v battery. Couple of months go by and now the replacement battery is having the same issue.

• 05/08/2026· UNKNOWN OR OTHER

  CV axles bad, intense shuddering during acceleration and between 25-55mph. Severe enough to shake side to side in my lane on occasion. Serious safety concern and seems to be a ubiquitous issue.

• 05/08/2025· SUSPENSION,POWER TRAIN,WHEELS

  On acceleration from a stand still or in motion, the vehicle will start to shake/wobble pretty violently. It will go away when letting go of the gas. Seems to be coming from the front end wheels. Going under the car and checking all connecting points, the CV axle has a lot of play. You can move it around.