2023 Ford Bronco

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2022· VISIBILITY/WIPER

  The wipers on low mode stop working after about 30 seconds, requiring to turn off/on again or try the higher wiper speed. On a rainy day, when the wipers stopped there was near zero visibility. There were now warning lights when they stopped working. I see many other 2023 Ford Bronco report similar issues online; however I see no responses or issue acknowledgement from Ford. It is very scary when the wipers stop; especially during a moderate or heavy rain event. My Bronco was purchased week 3 December 2022 and the problem happened during my first rain event a few days after purchase.

• 12/29/2023· POWER TRAIN

  Rotational scraping noise from manual transmission, especially when cold and neutral (1st and 2nd gear). Ford Dealer at Autonation Ford Union City, Georgia stated that they would need to replace the 5th and 6th synchronizer rings to resolve this issue. Bought certified used from Capitol Ford in Charlotte, NC with 8213 miles, hear noises but it was soft, but the more I drove the louder it got. Now Bronco has 9064 miles. No accidents, no off-roading, and this seems like a safety issue from the manufacturer because the shifting is difficult.

• 12/25/2025· SUSPENSION,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

  My vehicle has both cracked and leaking rear shocks as well as issues with the rearview camera and infotainment system. I have gone through two Ford Dealerships to remedy this issue and was told parts are on back order. I attempted to remedy this issue when I first received notification that parts were available in August 2025. When I drive, I can feel the suspension is not providing support and continued use will cause other issues with the vehicle that may not be covered under warranty or the recall. My vehicle will also trigger the collision avoidance feature when there is physical trigger. This has caused my brakes to lock up in traffic.

• 12/17/2025· ENGINE

  Check engine light stayed on, constant. Code run showed cylinder 4 misfire. Bronco still under warranty so took to dealership. Mechanic said coolant was inside cylinder so he requested recommended remedy from Ford and would probably be engine replacement.

• 12/17/2025· UNKNOWN OR OTHERFire

  The vehicle was parked and not in operation when a fire occurred. There was no collision or impact. The fire originated in the vehicle and caused significant damage. Emergency services responded to extinguish the fire. The vehicle had been properly maintained and there were no aftermarket modifications. The cause of the fire is unknown at this

• 12/12/2023· ELECTRICAL SYSTEM

  Wireless charging pad not working correctly. It is causing my phone to overheat to the point it is uncomfortable to hold in your hand.

• 12/10/2023· STRUCTURE,VISIBILITY/WIPER

  The windshield was faulty upon delivery of our new 2 door Ford Bronco. Every time it rains, water pours inside the vehicle through the gaps in the windshield sealant. The water flows through the passenger side A-pillar, and comes out of the airbags, as well as the defrost vents, then flowing down the side of the dashboard, and landing on the front passenger floorboard. The service department had to replace the entire front passenger side A-pillar during our most recent visit. The windshield is a major structural component of a vehicle, and our dealership service department confirmed that our faulty windshield puts our safety and the safety of our passengers in danger of experiencing serious injury when the windshield sealant completely fails. We have been to the dealership twice for the water intrusion caused by the faulty windshield. The Ford service department staff said Ford has previously issued a recall for this exact issue, but the recall is not for our specific model, so the Ford service department was not able to replace our faulty windshield under warranty. The inability of the dealership to replace our faulty windshield under warranty forced us to make an insurance claim and replace the windshield on our own. Upon installing the new OEM windshield, the technician pointed out to us in person where the faulty windshield issue stemmed from. It is obviously clear that Ford never tested our vehicle's windshield sealant gaps before they shipped it out for delivery. If they did not test our windshield structure, there could be many other 2023 Ford Bronco 2 door models delivered with faulty windshields. NOTE: We have never taken our vehicle to any kind of car wash, as the owner's manual is very clear about avoiding these. We have also never removed any of the roof panels. Process of elimination removes both of these situations as secondary causes for water intrusion.

• 12/05/2023· VISIBILITY/WIPER

  While driving at multiple different speeds in the rain and snow, the wiper blades on the vehicle slow down on their own to an intermittent speed without driver input. This slowing of the wiper blades causes the driver to lose visibility while driving, creating a safety hazard on the road. This issue has occurred numerous times when the wiper blades are set to the highest speed. After about one minute, the wiper blades start to slow down and eventually reach a stop/start speed where the blades only wipe every 5-10 seconds. To remedy this, the driver has to turn the wiper blades off and turn them back on again to get the wiper blades going again at the higher rate of speed. However, this only lasts for a short period of time (about one minute) and then the wiper blades slow down again on their own. The driver has to keep repeating this to be able to maintain visibility while driving in rain and snow conditions. This causes the driver to have to take a hand off of the steering wheel in inclement weather to keep adjusting the wiper blade speed. This issue has not yet been taken to a dealership for inspection, but this issue has been referenced in several online forums for this particular vehicle. There were no warning lamps or messages that appeared on the vehicle. In fact, in online forums, other Bronco customers have stated that Ford says this is how the wipers are supposed to operate.

• 12/02/2025· EXTERIOR LIGHTING

  On November 30th, 2025 I drove southbound from Milwaukee to Chicago, leaving at approximately 5:30 a.m., on I-41. There was a winter storm warning in effect. Approximately every twenty miles I needed to stop and deice my headlights as light output had diminished to almost zero, resulting in extremely dangerous visibility. I have experienced similar problems in Manitoba and western Minnesota. In these areas, there is often more than fifteen miles before you can exit the highway or find a safe place to pull over. It is not possible to get this problem diagnosed by a dealer. However, it is a common complaint among Bronco (and Jeep) owners. The combination of an upright grill and the low heat output of LED lighting quickly render headlights useless in snowy or icing conditions. No warnings appear; light output simply quickly drops to almost nothing.

• 12/01/2023· VISIBILITY/WIPER

  Received Truck end of Dec 2022, immediately noticed that when it rains, the wipers at a certain speed have a glitch that suddenly stops and starts at a lower speed. I have video recording and took it to dealer. Dealer told me that it is a feature so the motor does not overheat. It made no sense because I could activate the higher speed and no problem with that one. First time it happened, was heavy rain at night while changing lanes and could have ended in an accident if there was more cars on the freeway. In short, dealer dismissed my concern even though I provided video of the issue.

• 12/01/2023· VISIBILITY/WIPER

  My 2023 Ford Bronco has these "Advanced" wipers that automatically stop wiping when they think the windshield is dry or think the wiper motor may be damaged. When driving in heavy rain and you put the wipers on High (or even Low), they automatically switch to Intermittent after about 1 minute. They actually stop wiping at a high speed and pause between wipes for several seconds. In order to keep the wipers going in heavy, blinding rain you have to keep switching the wipers from Low to High to keep them moving. This is a safety hazard since you honestly cannot see though the windshield during heavy rain. After reading the Manual it appears this is a "feature" of the new Ford Bronco. This is a major safety issue and Ford should be required to fix the wiper motor on these vehicles.

• 11/30/2023· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Since I took delivery of my 2023 Ford Bronco on August 1, 2023 I have not been able to connect to the FordPass (get updates, etc..). Dealer replaced the Gateway Module and has not been able to load software onto the module. The Gateway Module is a "hub" that routes signal to major components of the vehicle (safety, body control, telematics, power train, etc..). Since replacing the Gateway Module, Ford has been unable to get the software to load properly. This issue has manifested itself in not only the Bronco, but the F-150 and Bronco Sport as well. My vehicle has been in dealership for this fix for over 10 weeks. Given this is a critical component to vehicle safety and I have seen on Bronco and F150 forums over 50 cases of this I believe someone needs to question the ability of Ford to service such a critical component of vehicle safety.

• 11/27/2024· SERVICE BRAKES

  A little over 10000 miles, the "Check Brake System" and "Parking" Brake Lights came on after starting the vehicle. Both Ford and the dealership were contacted and was advised that the coding through the system showed brake fluid level low with possible indication of brake fluid leaking. I asked if the vehicle was safe to drive and neither Ford or the dealership would say either way. The vehicle was taken to the dealership. For the first visit, the vehicle was at the dealership for an entire day and was told by the service advisor there wasn't anything wrong and to take it home. After leaving the dealership, the lights came on again. I took my vehicle to the dealership a second time and it sat there for another two days. Upon picking up my vehicle on the 2nd visit, I was told that the brake fluid level switch needed to be replaced and was resolved. The next day, the light comes on once again while driving. I called the dealership to talk to a service manager and was advised she would have an experienced technician dedicate their time to try and resolve the issue. The vehicle was at dealership for two days and upon pickup of the vehicle was told that the issue was due to an air bubble in the brake line and issue was resolved. I requested that the vehicle be test driven before pickup. Upon five minutes into my drive home, the lights come on once again. I've taken my vehicle to the dealership 3 times now and the dealership has had it for about 6 days during that time without resolution. I've contacted Ford customer service and the representative advised the issue would be documented, but there were currently no recalls for this issue. I've communicated with several other owners of the same vehicle experiencing the same issue without resolution. The lights are accompanied by a loud beeping noise and come on and off constantly making it a distraction when driving, and I am unable to tell if the parking brake is actually on or off since the light is constantly lit.

• 11/22/2023· ENGINE

  Engine service light came on indicating reduced power/power failure. Called Ford dealership and they said to bring it in asap. After diagnosis the Ford dealership said there was a problem with the wastegate. The dealership has no eta on when the part will be available.

• 11/18/2024· ENGINE

  My vehicle has the 2.7L V6 Ecoboost engine. This engine apparently has a design defect that results in repeated cam phaser failure. My engine recently had cam phaser failure and I had them replaced. A week later I was driving at speed on a highway when my engine completely died. I had to pull to the side of the road and could not restart my engine. I ended up being towed to a dealership and am awaiting diagnosis.

• 11/18/2024· ENGINE

  My engine has had a knocking problem since 3000 miles. Everytime I take it to Ford they agreed it has a knock but won't fix the problem stating it's normal and some engine knock more than others. The engine knocks at low rpm when stepping on the accelerator then smooths out about 1500 to 2000 rpm. One mechanic said it's an issue but they won't fix it unless it has a catastrophic failure this is unacceptable to me as they just want the vehicle to fall out of warranty when the engine finally gives way and doesn't turn on anymore. There are multiple Ford vehicles that have this issue and Ford does not seem to look into it and fix it please investigate the issues with knocking on all the Ford vehicles with the EcoBoost engines.

• 11/15/2023· STRUCTURE

  The hardtop is failing in a critical mounting point location. Stress cracks are forming on the exterior of the hardtop directly parallel to the interior mounting bolts. The vehicle has 1,500 miles. The risk of the hardtop failing to remain attached to the vehicle on the road due to structural cracks is the safety concern. For structural cracks to occur within the first 1,500 miles does not imply future safety of passengers or others on the road. The problem has been documented by a local Ford dealer that deemed this is not a warrantable condition. The cracks began to appear before the first 1,000 miles of ownership. This vehicle was purchased new and is 5 months old. There were no other symptoms prior to the failure. With how quickly the cracks appeared the concern is sudden and imminent failure while driving.

• 11/14/2023· SERVICE BRAKES

  Two different times, my brakes have lost power. Both times were at slower speeds while coasting. The first time a car pulled out in front of me (about 50 feet ahead) and even though I was only going about 15 miles per hour I was barely able to stop in time. When I hit the brake pedal it felt rock hard (like when you pump the brakes with the engine off). The pedal did not go to the floor or anything like that. It stayed high in the stroke. No ABS sensation or warning lights. The next time I hit the brakes they worked normally. I couldn't reproduce the problem until about 2 months later I was leaving work and was pulling up the street at about 5 miles per hour when it did the same thing. It was almost flat ground and It was all I could do to press the brake pedal hard enough to stop in time. The symptoms were the same as the first time. The moment I hit the brake pedal again, all was normal. The weather was warm both times. The dealer cannot reproduce the problem

• 11/05/2024· SERVICE BRAKES

  See attached document for complaint.

• 11/01/2024· STRUCTURE

  The contact owns a 2023 Ford Bronco. The contact stated while the vehicle was parked, the contact noticed that the hard top was detaching. The vehicle was driven to the dealer but was not diagnosed nor repaired. The manufacturer was notified of the failure. The failure mileage was 45,000.

• 10/30/2025· BACK OVER PREVENTION

  The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V273000 (Back Over Prevention), and the vehicle was taken to the dealer for the recall repair. The dealer replaced the rearview camera, but the rearview camera software update could not be completed. The dealer replaced the rearview camera a second time; however, the issue persisted. The dealer informed the contact that the software update might have failed due to the aftermarket 2-inch lift that was performed on the vehicle. The contact was advised that a fee would be charged for the lift removal and was informed that the lift removal might not correct the issue. The contact stated that the aftermarket 2-inch lift was a replication of the Sasquatch, 2-3" Lift package that the manufacturer offered. The recall repair was not completed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but no assistance was provided. The contact had not experienced a failure.

• 10/30/2023· ELECTRICAL SYSTEM,BACK OVER PREVENTION

  Faulty APIM (Accessory Protocol Interface Module) on 2023 Ford Bronco Wildtrak at delivery. The APIM allows the Sync4 suite to function properly. Dealer inspected, determined APIM is faulty. Vehicle delivered on 8/14/2023. Sync4 system continually glitches: reverse camera doesn't appear, or freezes, or is on a delay sync4 lets out a high pitch sound all the time turning on 360 degree cameras causes a glitch calls drop screen freezes

• 10/18/2023· ELECTRICAL SYSTEM,ENGINE

  The contact owns a 2023 Ford Bronco. The contact stated that while driving at 70 MPH and attempting to brake, the brake pedal traveled all the way to the floorboard and all the lights had flashed on the instrument panel. The contact stated that after restarting the vehicle the entire dashboard shook uncontrollably. Several unknown warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty cam phaser. The vehicle had not been repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 12,000

• 10/15/2023· EQUIPMENT

  Base plate wield on driver side failed allowing one side of the tow bar to disconnect from the tow vehicle and it is available for inspection. The tow vehicle was allowed to move into the adjacent lane and if there was a vehicle there it would have cause an accident luckily we had pulled into a campground. The wield broke on late Friday and the dealer has not contacted me yet.

• 10/09/2024· WHEELS,ENGINE

  We installed new tires and wheels on our vehicle and it immediately started having engine problems and the check engine light comes on. We took it to the dealer and after several days back and forth Ford told the deal that it's a known problem with the 2.3L version of the Ford Bronco however they had no fix and no timeline to fix the problem. This creates a safety hazard as the engine program can't be updated and could cause damage to the engine and cause it to fail. The dealer then stated that they could not return the vehicle to us with the new tires and wheels we purchased and we had to put our old tires and wheels on. We counted on the old tires for a spare since we already blew one tire out. So in addition to a safety hazard we are currently out $2,500 we spent on new tires and wheels, and now have to purchase another tire of the exact same original size to have a spare, costing us another $300.

• 10/08/2024· SERVICE BRAKES

  I have owned my Bronco for a little over a year now, the Check Brake System light has been coming on the whole time. I have taken it to Ford 4 times now with no result of it being repaired. The dealership has no idea how to fix this issue. From reading other posts, I'm not the only owner experiencing this issue. Being its the brakes that are affected it is a serious issue.

• 10/05/2023· ENGINE

  The contact owns a 2023 Ford Bronco. The contact stated while driving 65 MPH, the power train and service engine soon had warning lights illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that there was bad gasoline in the vehicle, and gasoline needed to be drained from the fuel tank. The fuel tank was drained and refilled; however, the failure recurred. The vehicle was taken to another dealer and diagnosed with a faulty turbocharger. The contact was informed that the turbocharger needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,100.

• 10/02/2024· ELECTRICAL SYSTEM

  Been having problems with ford pass took vehicle to dealer a week ago and they say that has to do something with the computer of the car so that's mean is something serious computer control every single sensor engin3 etc..

• 09/30/2024· STRUCTURE

  The front flares at highway speeds blow off-Ford has known about this issue and refuses to acknowledge this issue that is very well documented on the Ford Bronco Raptor forums. The do not warranty these even though there is only a few thousand miles, they will not even give a reason why they deny the warranty. This is a safety issue as they are only held on with a few clips. these are oversize flares and the wind from hwy speeds causes the flimsy clips to break making the oversized tire flares to fly off

• 09/17/2024· POWER TRAIN

  Front pinion seal leak is detected at where the front drive shaft meets the front differential. Ford attempted to fix it with a pinion seal replacement and the leak is still unresolved, second attempt was done by changing the front differential fluid which also did not resolve the issue. This issue is fairly common amongst bronco owners on forums and will be hard to come to the users’ attention unless the user checks under the vehicle so the problem may be more widespread than reported. The undetected loss of front differential fluid may cause overheating of the front differential over time as the fluid levels become low and potentially cause a lockup at high speed when the vehicle is used in 4A AWD mode. The leak can also be a fire hazard.

• 09/09/2023· VISIBILITY/WIPER

  My 2023 Ford Bronco has these "Advanced" wipers that automatically stop wiping when they think the windshield is dry or think the wiper motor may be damaged. When driving in heavy rain and you put the wipers on High (or even Low), they automatically switch to Intermittent after about 1 minute. They actually stop wiping at a high speed and pause between wipes for several seconds. In order to keep the wipers going in heavy, blinding rain you have to keep switching the wipers from Low to High to keep them moving. This is a safety hazard since you honestly cannot see through the windshield during heavy rain. I have spoken to many Bronco owners and seen a thread on online message boards that everyone has the same issue. After reading the Manual it appears this is a "feature" of the new Ford Bronco. This is a significant safety issue and Ford should be required to fix the wiper motor on these vehicles. The problem happens on all of the model years - 2021 - 2023.

• 09/07/2023· SEAT BELTS

  There is an open recall from Ford for almost 2 months and they dont have the remedy to close the recall. I dont feel secure to drive the car and the manufacturer to fix the identified problem on priority basis.

• 08/20/2025· SERVICE BRAKES

  I have a 2.7l V6 Bronco with an automatic transmission. There is a steep downhill road (22% grade) a couple blocks from my house that ends at a stop sign for a major cross street. I apply the brake pedal to slow down for the stop sign and the Bronco behaves normally and comes to a full stop, but then with no change in brake pedal pressure by me nor any pedal feedback, i notice the Bronco starts creeping forward a few feet, then abruptly stops again. When the Bronco starts creeping downhill and then abruptly stops again, there is no brake pedal feedback or movement, and the engine does not change RPM. The only sound I hear is something that sounds like service brakes releasing pressure then suddenly reapplying full pressure. I compensate by stopping early, so I don’t drift into the intersection, or a vehicle in front of me, or pedestrian. It can startle any pedestrian that starts to cross in front of my “stopped” Bronco and it suddenly starts creeping down on them. I have noticed this for months but have not taken it to a dealer for resolution yet. The problem appears to not happen after I have been driving for a few minutes. Because this is a problem that occurs on hills in the first few minutes of driving, it likely will be hard to demonstrate to a dealership for diagnosis because there are no hills near my local Ford dealership. The incident occurrence date entered below ([XXX]) is just today’s date - this problem has been present for many months, if not since new. Other uses have reported this same issue in online forums: [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/19/2025· SERVICE BRAKES

  There are reports of Ford Broncos rolling forward under braking, after a full stop. This occurs most often on a hill. To be clear, the brakes are already fully depressed, the vehicle is stopped, and THEN the vehicle suddenly rolls forward while the brakes are depressed, endangering pedestrians and others. This is NOT caused by driver error. Here are some vehicle owner complaints about this issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/18/2025· STRUCTURE

  The contact owns a 2023 Ford Bronco. The contact stated that after opening the driver's side door and then closing the door, the passenger's side hard top fractured into several pieces. The dealer was contacted and informed of the failure. The dealer confirmed that the repair would not be covered for free. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer confirmed that the repair would not be covered. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 11,000.

• 08/16/2025· SUSPENSION

  My rear shocks have been corroding on the external resevior attached to the lower shock body and is rusting really bad in the exact place where the manufacturer of this vehicle says that it's breaking down ( rusting ) at. I called the dealership and the service department and they REALLY gave me the impression that they really don't want to repair my vehicle and is why I'm filling this report with NHTSA . I want the dealership of the manufacturer to replace my rear shocks with new shocks and not put RTV sealant and a retention clamp on this external resevior as stated as one of the remedies the manufacturer has listed in a letter sent out to all of it's dealerships about the manufacturers recall on the rear shocks . In the manufacturer's letter it does state that one of the remedies is replacing the shocks but ONLY if the shocks are leaking oil from the shock resevior/ flange damper area . The corrosion on my shocks are bad . The manufacturer is not SERIOIS about fixing this problem and is why I trust NHTSA to help me and thank you NHTSA .

• 08/09/2024· SERVICE BRAKES

  Was driving on the highway, when the vehicle popped up the message and it caused either the emergency brake or the automatic collision detection brake to engage. It turned of when I applied gas. The brake issues remain, when I restarted the vehicle after 15 minutes of being off, no brake error was detected evening after pumping the brakes.

• 08/06/2025· PARKING BRAKE

  The contact owns a 2023 Ford Bronco. The contact stated that upon starting the vehicle, the message "Parking Brake Fault - Service Now" message was displayed. The vehicle was taken to a local dealer to be diagnosed; however, the contact was informed that further diagnostic test was needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,990.

• 08/01/2024· VISIBILITY/WIPER

  While 400 miles from home on vacation, driving in rain, the windshield wipers quit working. As rain picked up from a sprinkle to a more steady rain, I increased the wiper speed. After adjusting a time or two to match the rain coming down, the wipers stopped in the up position. When I change the speeds on the wiper control nothing happens, and it also will not spray washer fluid for the front windshield. The rear wiper and fluid spray work as expected. I checked the fuse identified in the manual, and it looks good. I even swapped the fuse with the rear wiper fuse, and the front ones still do not work. The two dealerships in the area are not able to do much, so I'm facing a 6.5 hour drive home with rain in the forecast and no working windshield wipers on a 1.5 year old vehicle.

• 07/31/2023· VISIBILITY

  While driving on a highway at +70 mph, the rear window shattered inward, with such force that it sounded like a shotgun had discharged. I did not stop, because literally thought I may have been shot at. The window shattered with such force that the plastic molding around the rear speakers were sliced by the glass. Thank goodness no one was in the back seat, my wife and I were both covered in glass fragments, including small shards of glass. The Ford dealership stated the glass must have been faulty.

• 07/30/2025· STRUCTURE

  rear tailgate on the bronco gives off a very loud rattling noise when driving

• 07/29/2025· UNKNOWN OR OTHER

  I am sending a complaint as I purchased this vehicle brand new from the dealer in June. They have not been able to give me my vehicle because Ford has not come up with a fix on these two recalls. My complaint is how long does Ford have to make this right? They keep extending the recall dates out from a month or so to now 4th quarter. I am paid for a vehicle that I can't use because of Ford's Delay. I am hoping you all as a government agency will give back some feedback and push Ford to fix the issue a bit more timely.

• 07/29/2024· AIR BAGS,FORWARD COLLISION AVOIDANCE

  The main issue is the airbag light, it is available for inspection. Warning indicator on Ford app states safe to drive without a passenger. Dealer repaired a couple parts got better for a while but continued. Was told they had a wiring harness ordered, but canceled and told to call Ford about a buyback, dealt with Ford, Better Business Bureau about lemon law, but still have not giving me a price for the buyback even though they agreed to buy it back. The vehicle had been in an accident [XXX], it was repaired at the Ford dealer And completed 6/7, was dropped off to have a new aftermarket bumper and winch, lights installed. The first time airbag light came on was [XXX]. At first, I could turn the vehicle off and then back on, and the light would go away, did not get consistent enough to take to dealer till [XXX]. Warning light was on when I dropped it off, which was witnessed by the associate but off by the time it made it to repair bay. Back to ford on [XXX]. Did get a code to change an airbag indicator and sensor in the rear seat. Picked up after repairs February 16. No warning lights, next day the warning light was back on contacted Maria at Ford. Dropped off to Ford again on 2/26. Call the dealer not being done in a timely manner on 3/15. I was told to request a buyback on March 18. The vehicle status changed on 3/20 showing no alerts on my Ford pass app. They had a wiring harness ordered, but canceled. Picked up my vehicle on March 29. I asked if the vehicle failsafe that if it can’t tell if somebody’s in a seat while the airbag go off and got no reply. Wife is afraid to drive in the front seat on the airbag light is on. Light on continuously now Ford won’t give me a rental car to do more investigation because I get no code to tell him what part to change and I’ve not been given a buyback price. Intermittent Pre-collision / adaptive cruise control will stop working while driving on the highway be out for 11 minutes and then come back on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 07/28/2025· ENGINE AND ENGINE COOLING,POWER TRAIN

  The contact owns a 2023 Ford Bronco. The contact stated that while driving at an undisclosed speed and flat towing an RV, the Flat-Tow mode inadvertently disengaged and the contact smelled a burning odor permeating the interior of the vehicle with the message "Stop vehicle immediately, excessive temperature detected" displayed. The transmission temperature warning light was illuminated. The vehicle was taken to the dealer, who determined that there was damage to the transmission and turbocharger due to the Flat-Tow mode not being engaged properly during towing. The contact was informed that the transmission and turbo charger needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 22-7086. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The contact was later informed that the manufacturer concluded that the disengagement of Flat-Tow mode was the result of user error. The manufacturer declined to cover the cost of the repair. The contact contested the manufacturer’s findings as inconceivable, stating that the Flat-Tow mode was still engaged after arriving at his destination. The failure mileage was 50,200.

• 07/28/2023· SEAT BELTS

  The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 23V358000 (Seat Belts) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 07/27/2024· POWER TRAIN

  3 separate times while driving on the on the interstate doing between 70-75 mph the vehicle completely lost power and an alert was displayed saying “Powertrain Malfunction”, the most recent incident was 07/26/24, before was 06/16/24 and 06/22/24. The vehicle speed dropped down to 35-40 and wouldn’t go any faster, and we had cars behind us, this created a major safety issue for me and my family. We had to pull over on the interstate, turn the car off and back on. We took it into the Ford service department, they said nothing was wrong with it and claimed they reset the computer.

• 07/17/2026· STRUCTURE

  The MIC hard top component on my Ford Bronco is cracking. I have gotten it replaced twice through Ford for the same issue, but now this is my 3rd top and the issue keeps coming back.

• 07/16/2024· AIR BAGS

  I turned on the car and the airbag light was on. I took to a Ford dealership they said this was not under warranty. The sensor to the airbag is not working and will not go off if I'm actually in an accident. The sensor needs to be properly installed as this was an issue with many Ford Broncos years 2021-2022.

• 07/15/2025· BACK OVER PREVENTION

  The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V315000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

• 07/14/2026· POWER TRAIN

  2023 Ford Bronco with 7 speed manual transmission. The transmission started grinding while shifting into 3rd gear and occasionally popping out of 3rd gear. This mostly occurred while upshifting and rarely while downshifting. All other gears are operating as normal. While the grinding problem would pop up occasionally around the 40,000 mile mark, it became chronic at 58,000 mile mark (24Jun2026)