2022 Toyota Highlander

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2025· ELECTRICAL SYSTEM

  Vehicle Issue Description (Rear Liftgate): The rear power liftgate intermittently fails to operate and presents a safety concern. The liftgate often will not open at all. At other times, it opens only partially (approximately one-quarter of the way) and then stops. When this occurs, the liftgate frequently will not close properly and sometimes fails to latch securely. This issue has been ongoing for approximately two years and has progressively worsened. It has now reached the point where the rear liftgate is no longer usable. If the liftgate does not open in an emergency, occupants may be unable to exit the vehicle through the rear, which could be dangerous in the event of an accident. Additionally, when the liftgate fails to latch securely, there is a risk it could open while driving, potentially causing cargo loss, reduced visibility, or allowing exhaust fumes to enter the cabin. Numerous Toyota Highlander owners report the same issue on public forums such as Reddit, indicating this is a widespread and known problem. According to these reports, dealerships are commonly diagnosing the failure as a failed liftgate strut, with quoted repair costs of approximately $1,500. I reported this issue to Toyota directly today and was told that Toyota does not issue recalls and that concerns should be reported to NHTSA. I am frustrated that this appears to be a known issue that has existed for years without corrective action. Component/System Failed: Rear power liftgate system (including latch and power operation components). Available for inspection upon request. Safety Risk: Risk of liftgate opening while driving and inability to exit through the rear in an emergency, potentially trapping occupants. Dealer Confirmation: Not formally confirmed. A reset was recommended during a prior service visit, which worked temporarily for one day. Resets no longer resolve the issue. Inspected by Others: No. Warnings Prior to Failure: No warning lamps or messages.

• 12/30/2025· ELECTRICAL SYSTEM

  When turning on the heated steering wheel and about 5-10 minutes, it seems there is smoke coming from the steering wheel leather and it’s very hot that almost burnt my hand and forced me to take my left hand off. I immediately turned the heated steering wheel and stopped. There is a burning spot left on the steering wheel also. The heating option still can be enabled and the same situation repeats (like no fuse was broken)

• 12/29/2025· UNKNOWN OR OTHER

  While driving, the vehicle’s moonroof glass spontaneously shattered/exploded without impact. It sounded like a gunshot, which caused an immediate and dangerous distraction. There was no object strike that I am aware of and no prior warning. The sudden loud noise and breaking glass created a safety hazard due to distraction and potential glass intrusion.

• 12/29/2025· POWER TRAIN

  The contact owns a 2022 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended and made an unusual whining sound. No warning lights were illuminated. The contact's husband, a certified mechanic, diagnosed that the transmission had failed. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The contact related the failure to several unknown TSBs. The contact was informed that the repair was not covered under warranty. In addition, the contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 71,000.

• 12/22/2025· POWER TRAIN

  early transmission failure and whining at 40,000 miles

• 12/22/2024· SERVICE BRAKES

  Sudden acceleration when applying the brakes. This has happened several times

• 12/22/2023· SERVICE BRAKES

  Occasionally when slowing to a stop, the brakes feel like they slip and i begin to speed up suddenly. Pressing hard on the brakes stops the car again. This is a safety issue if for example you were braking for someone in a crosswalk or a car in front of you. The dealer was unable to reproduce the issue. It happens maybe once a week, for the last several months. They examined the brakes and said they are fine. No warning lights.

• 12/18/2023· SEAT BELTS

  The 3rd row seat belt buckle is imbedded too deep in the seat. This makes it very difficult for a child to buckle themselves and in several attempts the parent or another adult was required to insert the seat belt into the locking device. What is more concerning is the difficulty a child has when trying to release the seat belt. While this may be an annoyance that requires adult intervention it is of particular concern when a child, in an emergency is required to release the seat belt.

• 12/18/2023· STRUCTURE

  Sunroof shattered and detached at highway speed without impact

• 12/16/2025· POWER TRAIN

  Car developed a whining noise coming from transmission at 63,000 miles. Known manufacturing defect that will lead to transmission failure. No recall issued and Toyota would not extend warranty. I do not feel safe driving the car pending a transmission failure. Toyota’s solution is to replace the transmission at a cost of $9000.

• 12/16/2025· POWER TRAIN

  Premature transmission failure

• 12/16/2023· UNKNOWN OR OTHER

  The hood is latched, but not sealing flush. There is approximately a half inch gap. While driving the wind catches. I can see the hood moving up and down while driving. Especially if I am on the interstate.

• 12/09/2025· POWER TRAIN,UNKNOWN OR OTHER

  AUTOMATIC TRANSAXLE WHINING FROM 35MPH-45MPH ACCELERATION. Needs to be replaced this is the third vehicle this week the dealership said had the same issue.

• 12/07/2022· VISIBILITY/WIPER

  Wipers quit working. Available for inspection. Unable to see road because it was raining. Wipers haven’t been inspected. No messages or warning lamps. I was driving in rainy weather with the temperature slightly above the freeze point..

• 12/06/2023· STRUCTURE

  In November 2023, I received a notification about TOYOTA HIGHLANDER 2022 OPEN SAFETY RECALL WITH NO REMEDIES. I went to the local DeLuca Toyota (www.delucatoyota.com ) Dealership. The address is 1719 SW College Rd, Ocala, FL 34471, (352) 732-0770. I bought this car from this dealership. I was talking with service manager about these issues about safety recall WITH NO REMEDIES. He said they cannot do anything about. They offered a different car as a rental solution. The first problem with rental car is an additional cost. I must pay for the rental vehicle. Another problem is limit of the mileages per day. I am working in Gainesville, FL, which is 49 miles away (one way) from my home. I will use this limit in one week, and then I must pay for the mileage excess in addition to rental cost, monthly payments for Highlander and additional rental car insurance. Dealers do not know when the remedy is going to be and try to push/refer to the “LOW RISK” issue. LAW RISK cannot be measured yet should not be discussed. Risk is the risk that is why an open safety recall was issued. I discussed with repair service department and seller’s department to provide me with either of these options: repair, replacement, or refund. All these remedies were denied. I mention that I carry “A CAP INSURANCE”. The associates stated that the cap insurance, is not suitable for this situation. I think, if there are no remedies available for safety recall available for 0ver 45 days, and I aren’t provided with any of remedies, I am intitle by law, my consumer’s rights have been violated.

• 12/05/2023· UNKNOWN OR OTHER

  Driver side mirror shakes in its housing at varying speeds and on non-smooth roads. It becomes a distraction of focus when you are looking at the mirror to then switch back to front. The mirror vibration almost caused an accident while overcorrecting a turn.

• 12/03/2024· STRUCTURE

  The contact owns a 2022 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure). The contact stated that while driving 65 MPH, the contact heard an abnormal popping and dragging sound coming from the vehicle. The contact pulled over to the side of the road and inspected the vehicle. The contact stated that the driver’s side bumper had detached, and the passenger’s side bumper was hanging down. The front bumper was popped back into place and the contact continued to drive. The contact stated that while continuing to drive the bumper fully detached and ripped the covering under the vehicle. The vehicle was taken to a dealer where it was diagnosed that the upper and lower bumpers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 20,000.

• 12/03/2022· EXTERIOR LIGHTING

  When I drive at night time, the opposite driver complains on low beams that looks like high beams. They are too bright.

• 11/24/2025· AIR BAGS

  Vehicle is parked in the sun for over 30 minutes and when the start button is pushed the Air Bag System Malfunction light is on. After restarting the light goes away.

• 11/24/2025· AIR BAGS

  When the vehicle is parked in the sun for 30 minutes or more. After pushing the start button, the SRS airbag system malfunction light came on. After restarting the vehicle, the airbag light was out.

• 11/24/2025· EXTERIOR LIGHTING,BACK OVER PREVENTION

  When starting up the vehicle, the headlight system malfunctioned light came on and a pre-collision system light came on. After shutting it off and restarting the vehicle. The lights were off.

• 11/24/2021· UNKNOWN OR OTHER

  When driving down interstate, ticking came from above followed by a loud bang. Moon roof busted out and glass shattered out while on interstate.

• 11/19/2025· POWER TRAIN

  Four days ago, engine started making a whining noise when accelerating, especially in lower gears. No warning signs. 2022 Highlander Platinum is 3 years old, 80K miles, out of warranty; no extended warranty purchased due to historical, stellar Toyota reliability. Toyota service department at Toyota dealership today said whining is due to a bearing issue within the transmission (my personal mechanic inspected and said that is also likely) and cannot be repaired. Transmission could last another 10K-20K miles they said, before it becomes undrivable or just drops, causing a potential safety issue. Net, the entire transmission needs to be replaced to the tune of $9186. Just shocking.

• 11/14/2022· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES

  While driving at a constant speed of approximately 45 mph the vehicle suddenly skidded sideways and launched to the right, causing us to nearly hit a guardrail. I dropped speed to 30 mph and this continued to occur at random for the next 10 miles until destination was reached. Road conditions were patchy snow up to fully covered in snow. Other vehicles passed at 50+ mph with no issues. No warning lights/messages or traction control light turned on. Today the same issue occurred while driving 15mph that caused the vehicle to almost run into a parked car. This has occurred at random over the past two days. All instances occurred while driving at a constant speed, no brakes were being applied and while driving in a straight line. This isn’t the first time the vehicle has been driven in these road conditions but first time problem has occurred. This is a safety hazard for my wife and child due to the fact the driver looses control at random and vehicle veers off to the side. Putting them at risk of impacting objects near the road or veering into oncoming traffic, putting other drivers at risk. Car was brought to the Toyota dealer 11/14. They plugged it into their computer and no codes were active. No open recalls either. I went for a drive , was given 5 minutes of their time, with the shop manager and the problem didn’t present itself. They said there was nothing else they could do. There was a recall on the VSC, vehicle stability control, but that was fixed on this vehicle in July 2022. Vehicle acts like a sensor or module isn’t calibrated correctly and causes either/or braking and acceleration to be applied in a manor that will result in a crash. Vehicle is not safe to drive.

• 11/13/2022· STRUCTURE

  Vibrating driver side mirror in speeds 50-70 MPH on concrete or asphalt

• 11/11/2025· POWER TRAIN

  About 4 weeks a go i started hearing a whining noise from my Highlander. Thinking it was a belt we replaced. Whining continued to get worse only on acceleration. We are at 88,000 miles and it is now at Toyota getting a new transmission. Is there not something that can be done about this? I have read thousands of articles that show the UA 80E/F transmissions that are in the 2021-2022 models are junk. Luckily we bought a Toyota VSA and it is covering it. What about after 100,000 miles. Whats to say after another 80,000 it won't go out again which will cost me the $10,000. When the dealers put new transmissions in these vehicles are they using the same parts for the UA 80 E/F or the upgrade parts that fixed the 2023? If we have a VSA it should extended a year past the 100,000 mile mark because of the issue or they should have to replace them completely to match the 2023 models.

• 11/11/2022· ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

  While driving on the highway the entire dashboard warning system came on all the ADAS and messages saying braking failure to loss of control. This vehicle is not even three months old and is a platinum AWD vehicle fully loaded version. Toyota Dealership never mentions or stated this vehicle had any issues, even today they seem not to know what caused the vehicle to underperform. This is dangerous and this vehicle going at 65 MPH and unable to stop is a real danger to the occupants and others. They say its safe to drive, I disagree for the safety of all indivduals on the roadways.

• 11/08/2024· TIRES

  The contact owns a 2022 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 24V419000 (Tires); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 55 MPH, the TPMS warning light illuminated. The contact stated that the front passenger’s side wheel was deflating. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was 33,000. Parts distribution disconnect.

• 11/08/2023· AIR BAGSCrash

  I got hit by a full size van at the red light and pushed to the traffic. Van is totaled and airbags deployed. I and my passenger got a whiplash, yet airbags deploy.

• 11/02/2022· TIRES

  I was traveling at highway speed with five passengers, luggage, and bike rack with five bicycles and without warning the driver's side rear tire sidewall completely blew out. The vehicle fishtailed but I was able to move over to the right emergency lane to change the tire. We did not hit any debris. This was a Bridgestone Alenza A/S Sport 235/65R18 tire that was original equipment with my 2022 Toyota Highlander Hybrid SUV. The tires were inflated to 38 lbs. I called Bridgestone and they told me to take the tire to a Bridgestone dealer in Charlotte, NC. They replaced the tire at no charge. I left the failed tire with them but took photos.

• 10/29/2025· LANE DEPARTURE,VISIBILITY

  See attached document for complaint.

• 10/28/2025· POWER TRAIN

  2022 TOYOTA HIGHLANDER TRANSMISSION IS MAKING A HIGH PITCH WHINING SOUND AND IS GETTING WORSE. MY WIFE DRIVES 20 MILES A DAY, 6 DAYS A WEEK AT 65 MPH TO WORK AND THE TRANSMISSION NOISE IS GETTING LOUDER. IF THE TRANSMISSION FAILS AND LOCKS UP, IT COULD CAUSE AN ACCIDENT. THE VEHICLE WAS TAKEN INTO FINDLAY TOYOTA IN PRESCOTT AZ. AND WAS TOLD THE TRANSMISSION IS DEFINITELY FAILING BUT WOULD NOT WARRANTY THE ISSUE BECAUSE SHE WAS 2500 MILES PAST THE 60K WARRANTY.

• 10/28/2025· SERVICE BRAKES

  When I am slowing down and coming to a stop, my car will surge forward. It feels like my brakes stop working for a second and that I pressed the accelerator. It has happened on flat road, hills and turns.

• 10/25/2023· POWER TRAIN,ENGINE,FORWARD COLLISION AVOIDANCE

  The highlander has been having starting issue where the dash reads that the hybrid system is not functioning and won’t turn over. There is a consumer report program instead of a recall. This is deceiving. This morning the TPMS was reading that all tired were at 32 pounds of air when in fact the right front passenger was complete flat to the rim. Clearly the computer was malfunctioning with not just one aspect of the car but multiple. The local dealership isn’t helpful in that they charge $185 for diagnostic tests.

• 10/24/2025· UNKNOWN OR OTHER

  The car was parked at work and noticed the shattered panoramic moonroof when I got into leave.

• 10/21/2024· STRUCTURE

  The contact owns a 2022 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the front lower bumper cover had detached. Additionally, the contact stated while driving 60 MPH, the front lower bumper cover separated, flew underneath the vehicle and into traffic, causing the contact to temporarily lose control of the vehicle. The vehicle was taken to the local dealer, where the contact was informed that there was a cost for the repair of the front lower bumper prior to the recall repair. The contact declined to pay for the repair because it was a minor bump. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 7,000. Parts distribution disconnect.

• 10/19/2024· SERVICE BRAKES

  We have noticed that when we brake the vehicle, it intermittently LURCHES FORWARD very fast while you are breaking and trying to stop! This is extremely unsafe! We need to stop and brake and not go forward. It does this unexpectedly with no notice and does not always do it consistently but we have noticed it is getting worse and worse and we are worried we will hit another car in front or even a person because the car will not stop on time. When I looked online, this is a well known issue on Toyota Highlanders, especially hybrids like ours and Toyota has done nothing to fix this dangerous problem. They have even told car owners to drive slower but I can tell you it doesn’t seem to matter if I’m going 25 mph or faster or slower- the car gives no notice and goes FASTER while you are trying to stop!!!!! Please help us Toyota Highlander owners!!!! This car gives us no warning whatsoever. It is not consistent. But when it does this it is VERY scary!

• 10/15/2025· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  I reported twice to Tustin Toyota that my car seemed to have a strange braking issue. It felt like the car lurched/lunged forward as I was braking. Every time I brought it into service, I verbally mentioned it to the technician checking my vehicle in. I was repeatedly told there was no issue. Turns out there is an active bulletin (T-SB-0059-23) that came out but now my vehicle is out of warranty and they won't fix it unless I pay out of pocket. Why was the dealership not aware. Why is this not a recall for all affected years regardless of warranty? There have been multiple reports online with people have the same issue.

• 10/10/2022· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  While having the eco system on, with the active system present by firmly pressing the brake hard at a stoplight, the light turned green. while taking my foot off the brake and the engine turning back on, attempting to accelerate the transmission would not allow me to get through the intersection turning left. I pulled to the far left/slow lane to stay out of other traffic. The vehicle would not allow me to go past 40mph, and the rpm’s would rev between 2000-3000 at low speeds between 10-25 mph. I had my 1 1/2 year old with me in his car seat, and it would have been tragic should this happen on the freeway and this kind of situation happened. Attempting to take it to the dealership, the truck even had trouble going over some railroad tracks with a small mound present. The dealership checked out the vehicle and called it operator error, after inspecting the reported malfunctions and finding nothing. This will not be operator error when someone is seriously injured, or if it happens to be one of their family members driving a similar vehicle.

• 10/06/2025· STEERING

  This type of steering wheel cover on the steering wheel will wear out by 50,000 miles poor engineered

• 10/01/2023· STRUCTURE

  The Front bumper came loose on the interstate, creating a loud noise as it slid under the tires. Once safely pulled over on the side of the road the car appeared to have spontaneously dropped the front bumper, we did not encounter any debris in the road, the weather is good and clear, there was no prior damage to the vehicle. The clips that hold the bumper in place seemed to be broken.

• 10/01/2022· UNKNOWN OR OTHER

  Driver side window spontaneously shattered while driving down highway at 65 mph. It sounded like a pressure explosion. My wife was driving and glass flew from f9nrt to passenger side and to the rear of the vehicle. Luckily my wife was wearing sun glasses. My duaghyers were in the rear with my youngest daugthers eyes being protected by a book she was reading. Glass struck me on the passenger side on the left side of my face.

• 09/28/2024· AIR BAGS

  On or about 9/22/24 I was driving on a parkway and was alerted by a high pitched alarm in the vehicle’s dashboard that the airbag had a malfunction and that the seatbelt was not engaged. I removed my seatbelt and clipped it back in but that did not stop the alarm. The vehicle continued to beep and say the airbag was malfunctioning. I made an appointment with Toyota service for 9/26/24 and when I arrived I was told they do not do diagnostic tests on Thursdays. They proceeded to give me a new appointment for today 9/28/24, and when I arrived they once again turned me away explaining that today was not a good day for a diagnostic. They mockingly told me that my vehicle warranty was about to expire. Furthermore, the Toyota has refused to fix the recall issue, and now is refusing to even run a diagnostic test to see what the problem is with the airbags. I am afraid the airbags will fail if I am in an accident. This is a very dangerous situation. Please help me!

• 09/28/2024· SERVICE BRAKES

  When braking the brakes will occasionally “quit”, causing unexpected acceleration. They kick back on if I stomp hard on the brake, causing the occupants to jolt forward. It could easily cause a collision if an unexpected vehicle or pedestrian were in the way, and could cause a rear end collision were I to have someone following close behind and hard brake unexpectedly. This has been reported to the dealership but they have been unable to replicate it. It happens intermittently, primarily when braking on a slight downhill slope. The issue has been since the vehicle was new. No warning lights or alerts activate inside.

• 09/27/2022· POWER TRAIN

  Highlander with approximately 650 miles on it had a transmission failure while on interstate 69 north of Evansville Indiana. The car seemed to shift into passing gear a few times while the cruise was set and we bumped it off cruise and coasted to a stop . The car would not move after we stopped . There was transmission fluid all over the drivers side and rear of the car and a puddle under it . We called Toyota roadside assistance and had the car towed to the nearest dealer .

• 09/24/2025· POWER TRAIN

  Ua80f/e transmission in the 2018-2022 Toyota Highlander are defective. Mine has a loud whistle while accelerating. Problems have been acknowledged by Toyota however they’re refusing to fix.

• 09/24/2024· POWER TRAIN,FUEL/PROPULSION SYSTEMCrash

  As my wife had the wheels turned and was pulling up to the curb stop in a parking spot the car suddenly lurched forward without putting the accelerator on and went up and over the curb. Stop and hit a pole. my thoughts are is that the engine possibly changed from hybrid to gas or vice versa and as my wife’s foot was let off on the brake to inch forward to the curb stop it suddenly lunged forward as previously stated.

• 09/24/2022· POWER TRAIN

  When I'm cruising about 35 mph, let off the gas and decelerate, then give a slight bit of gas, I feel a "bump" in the drive train. It's more like slop in the transmission....sounds like a metal To metal noise...this happens after car is driving more then 30 min or 45 min.

• 09/18/2025· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

  The screen is going out. The back tailgate hangs up and doesn’t go down.

• 09/17/2025· POWER TRAIN,FORWARD COLLISION AVOIDANCE

  I own a 2022 Toyota Highlander XLE (UA80E transmission, ~66k mi). The vehicle exhibits a severe transmission defect: uncommanded braking/drag at 35–40 mph and sudden loss of power when accelerating from a stop, making merging/crossing intersections dangerous. Two Toyota dealers (Bryan Toyota and Plano Toyota) reproduced the issue, documented the vehicle as unsafe to drive, and recommended full transmission replacement. The failed unit is preserved at the dealer for inspection. (Toyota Corporate Case #250917001779.) This mirrors long-standing defects within Toyota’s UA80 family that Toyota itself has documented: • Customer Support Program ZJC / POL19-04 (4/18/2019)—UA80 whine, harsh shifts, reduced power 2019 MC-10159730-9999 . • T-SB-0160-18 Rev1 (12/17/2018)—UA80 whine/harsh shift/MIL/reduced power 2018 MC-10198131-9999 . • T-SB-0001-18 Rev2 (1/8/2018)—ECM/UA80 mismatch causing harsh shifts 2018 MC-10185780-9999 . • T-SB-0008-21 (2/9/2021)—UA80E/F failures in 2021 Highlander (whine/grind, pinion shaft) 2021 MC-10188917-9999 . The same safety-critical behavior now recurs in my 2022 model. I request NHTSA investigate this as an ongoing UA80 transmission safety defect trend and consider recall/coverage for affected vehicles.