2022 KIA Telluride

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2023· ELECTRICAL SYSTEM

  Screens remain black on start up. Unable to read USB

• 12/28/2024· VISIBILITY/WIPER

  Description of the Problem: I noticed a crack suddenly appearing on my car’s windshield without any external impact, such as a rock or debris. The crack seems to have formed spontaneously, starting from the bottom edge and growing through the center of the glass, and there are no visible signs of external damage or impact points. This raises concerns about the quality or structural integrity of the windshield. It started early in the morning at about 6 inches but now has more than 12 inches and two ramifications. The car was parked in front of our garage and there were no extreme temperature changes. Concerns: I am worried that the windshield may have a manufacturing defect or material issue that could compromise the safety of the vehicle. This could pose a risk if the crack spreads or the windshield fails under stress.

• 12/28/2021· UNKNOWN OR OTHER

  Windshield keeps getting chips and cracks

• 12/27/2024· VISIBILITY

  The contact owns a 2022 Kia Telluride. The contact stated that while driving at an undisclosed speed, the rear windshield inadvertently shattered. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who was unable to diagnose the failure. The contact was informed that the manufacturer was aware of the issue. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 37,000.

• 12/24/2025· STRUCTURE

  While driving our 2022 Kia Telluride under normal operating conditions, the panoramic sunroof glass suddenly and spontaneously shattered outward with a loud explosion-like noise. The sunroof was fully closed at the time of the explosion. There was no impact with any object, no debris strike, no road hazard, and no external cause observed. Weather conditions were clear, traffic was normal, and the vehicle was traveling at a normal speed. The failure occurred without warning. There were no prior cracks, chips, noises, warning lights, or messages before the incident. A large hole immediately formed in the sunroof glass, and glass fragments fell into the vehicle and were caught by the shade. The sudden shattering and loud noise scared the driver and passengers and created an immediate safety hazard, requiring us to pull over right away. Occupants were placed at risk of injury from falling glass and sudden driver distraction. For safety reasons, loose and hanging glass was removed after stopping the vehicle. At the time of this report, the vehicle has not yet been inspected by a Kia dealer, manufacturer representative, or independent service center, as the incident occurred recently (we have an appointment in two days). The remaining sunroof components and vehicle are available for inspection upon request. This appears to be a sudden and spontaneous glass failure occurring during normal vehicle operation.

• 12/24/2022· UNKNOWN OR OTHER

  Dashboard Center LCD screen blacked out right after starting the vehicle. Tried restating the engine but the LCD screen remained blank. I drove 10 miles and after a second restart, the screen came back. The LCD displays important information like the speed and fuel consuption, but I like to use it to display the speed I am driving at as it is more readable than the speedometer. I have scheduled an appointment to have it checked by the dealership.

• 12/24/2021· POWER TRAIN

  My new AWD 2022 Kia Telluride vibration/ humming at 65 mph and above from day 1. It’s been in service 5 times and they are not able to fix the problem. The dealership we bought it from didn’t even admit there is a problem so we had to take it to another dealership which actually admitted there is a problem. They just changed the drive shaft and rear differential and the problem is still there . It’s been in service longer than it’s been with me. Very frustrating.

• 12/24/2021· VISIBILITY/WIPER

  Windshield easily cracked with a small small kick up in snow. Several small chips in the windshield for low visibility in a car with less than 1500miles on it. Several groups of telluride owners report the same problem on 2020-2022 models

• 12/19/2025· VISIBILITY/WIPER

  I had noticed a 1" wide crack had formed in the center of the windshield after first night of cold weather (~10°F). There was no prior damage to the windshield before the crack formed. I'm concerned that the crack will continue to spread as we progress into the winter in the upper Midwest, ultimately shattering while I'm driving.

• 12/18/2023· ELECTRICAL SYSTEM

  ESC check failure.

• 12/16/2022· VISIBILITY/WIPER

  I was traveling on a local road at approximately 35 mph, with only 1 other vehicle near me. I heard a crack, but did not see any rock hit the windshield. I immediately saw a spider crack form on the driver's side. The car is less than a month old and the windshield has no previous wear.

• 12/09/2025· ENGINE

  Plastic oil filter housing cracked after oil change around 100k miles.

• 12/09/2022· ELECTRICAL SYSTEM

  On 12/09/22, the center lcd instrument cluster went blank 2 different times while my wife was driving. Vehicle has 2200 miles on it. Kia issued a recall in May 2022 for this exact issue but only covered roughly 2700 vehicles. This vehicle does not have an active recall and was produced after the issue was supposedly fixed at the kia factory. Obvious safety issue and clearly affects more than the 2700 vehicles already recalled.

• 12/06/2025· SUSPENSION

  Noise over bumps from the rear

• 12/04/2025· ENGINE

  This is a very well known issue among all model years of the Kia Telluride. The plastic filter housing is made out of plastic and over time it ends up failing causing an oil leak. I ended up having to pay out of pocket for a aftermarket housing that was metal and not plastic that won’t fail.

• 12/04/2021· UNKNOWN OR OTHER

  Windshield broke by itself

• 12/03/2025· ELECTRICAL SYSTEM,STRUCTURE,SEATS

  My 2022 Kia Telluride is experiencing several serious safety-related defects. The backup camera does not work, the second-row bucket seats fold up on their own while driving, and the electronic parking brake becomes stuck on and will not disengage. The transmission hesitates and shifts harshly, creating a risk during acceleration and lane changes. The engine is consuming oil between changes. The heating and air conditioning stop working when the vehicle is idling at stoplights, and electrical components including the front phone charger and heated passenger seat have failed. The exterior window trim is deteriorating. These issues are ongoing and have not been resolved by Kia. Several of these failures match known defect and recall categories. These create a significant crash and safety risk for my family. I am requesting investigation and manufacturer action.

• 12/02/2022· UNKNOWN OR OTHER

  The windows are very loose, if they are down or cracked while driving 60mph+ they shake and rattle seeming like they are going to bust. I only have video proof. The dealership wasn’t able to test drive the vehicle at the speed the problem occurs

• 12/01/2022· EXTERIOR LIGHTING

  Since the purchase of my vehicle 7 30 2022 & after driving the first several times in the darkness/evening hours & since I have had safety concerns that the headlamps in my vehicle are insufficient/inadequate - not just the normal headlights illumination but also the high beams. When the high beams are activated the additional effect is negligible/deliver inferior performance. I have continued to reach out to Kia & thus far they have not been helpful. I believe driving at night time is putting me at a safety risk. The dealership did/does not have a way to test the headlamps in any sort of calibration or measuring means other than to turn on the headlights while in the service area and shine them on a wall. When driving during the night time hours I keep my speed on rural roads typically below the speed limit as I do not feel I could brake/stop the vehicle in the field of vision that the headlight illumination provides. I have reached out repeatedly to the Kia Assistance number & thus far there has been no action or contact made by any positive measures taken to address my concerns. I have even contacted my insurance agent twice to express my frustration of Kia's inadequacy to provide a solution or address my concerns. I ask please for any assistance that you may be able to help remedy this safety/risk concern.

• 11/27/2022· UNKNOWN OR OTHER

  Windshield has cracked and required replacement twice since I purchased the vehicle in Nov 2021.

• 11/24/2025· SEATS

  My daughter was trying to get into the backseat of our Kia Telluride. She had one leg raised with her knee resting on the stepping area inside the rear passenger door. While in this position, she pressed the handle to fold the rear seat. The lower portion of the seat suddenly swung forward and closed with fast, strong force onto her folded knee joint, pinning it between the moving seat and the vehicle floor. She screamed immediately in pain and could not free her leg. I had to run around to the opposite side of the vehicle (the rear passenger side) and physically lift the seat off her knee to release her. The impact left a noticeable bruise just above her left knee. The folding seat mechanism appeared to move too quickly and with excessive force, and it did not stop or slow down once it encountered her knee. This presents a potential safety hazard, especially for children or passengers entering the vehicle who may accidentally activate the seat handle.

• 11/24/2025· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  The vehicle intermittently fails to shift gears and loses acceleration without warning, creating a serious safety hazard. The problem began in October 2024 when the check-engine light first appeared and has continued since. Despite multiple repair attempts by the Kia dealership—including replacement of the fuel pump, fuel pressure sensors, and ECU—the root cause remains undiagnosed, and the defect persists. When the vehicle was brought back in August 2025, the dealer’s latest recommendation on 9/30/25 was to replace the injector harnesses and front wire assembly, but they cannot guarantee this will resolve the issue.

• 11/21/2025· EXTERIOR LIGHTING

  The passenger side headlight randomly goes off. An alert comes on on the dashboard to check the headlight. The headlight comes back on randomly. I made several appointments to get it checked, but would be back on again when at the appointment. Diagnostic check showed no issues. The dealer replaced the bulb (not under warranty) and it worked for 1 year. The issue started again, another diagnostic was done, and a found no issues because the headlight came back on. A few weeks later it was out again and the whole lamp assembly was replaced. Not covered by warranty.

• 11/21/2025· POWER TRAIN,ENGINE

  Borescope inspection of the engine shows multiple signs of internal mechanical failure involving oil control, piston ring integrity, coolant intrusion, and cylinder wall damage. Excessive oil buildup is visible above the oil control ring, far beyond what is expected at 59k miles. Cylinder walls show heavy polishing where cross-hatching should be visible, indicating loss of lubrication and abnormal wear. Carbon deposits are extremely thick; in several areas carbon has flaked off and been pulled downward into the cylinder, creating scoring. Straight vertical scoring marks cut through the normal diagonal honing pattern, confirming blow-by and damage to the cylinder sleeves. Evidence of coolant intrusion is present, including orange discoloration consistent with rust/coolant contamination, excessive moisture, and steam-cleaned areas of the combustion chamber. The intake valve and combustion surfaces appear abnormally clean, consistent with coolant steam-washing. This suggests head-gasket failure, a block or head casting defect, or ring damage (possible cracked scraper ring). Coolant in the cylinders can wash away oil from the bore, leading to rusted pistons and accelerated scoring. Multiple pictures show severe scoring and loss of lubrication. This compromises the ability of new pistons or rings to seal, meaning the cylinder walls would continue to allow blow-by, oil burning, coolant intrusion, and friction. Even attempting to polish or recondition these bores would enlarge them, causing piston flutter, noise, and long-term failure. Based on the level of damage, the engine is no longer safe or reliable. A seized piston could cause sudden loss of power at highway speeds, creating a safety risk. The observed defects indicate a potential manufacturing or casting issue that may affect other engines. The dealership and KIA Consumer Affairs have been notified but there has been no replacement or resolution after 3 months of ongoing issues, and 8 weeks of holding my vehicle.

• 11/18/2025· UNKNOWN OR OTHER

  Sunroof glass exploded

• 11/15/2024· UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  Subject: Urgent Safety Complaint Regarding Recall Delays for My Kia Vehicle Dear National Highway Traffic Safety Administration, I am reaching out to file a safety complaint regarding an ongoing recall issue with my Kia vehicle that has not been addressed, despite multiple attempts to have it resolved. Kia has been aware of the necessary recall for several months, and I recently scheduled an appointment with my local dealership to address these recalls. Unfortunately, the dealership canceled my appointment the day before, citing that they still do not have the necessary parts to complete the repair. This situation has escalated to a serious safety hazard, not only for my family and me but for others around us. Recently, while my vehicle was parked at my child’s school, I experienced a malfunction that caused the vehicle to roll forward while still in park. I was momentarily unaware of the movement and was horrified to realize it almost struck a mother and her child who were exiting the school. This has been a frightening and deeply disappointing experience, and I am concerned about the lack of urgency from Kia in addressing this issue. I urge NHTSA to look into this matter and take action as needed to ensure that Kia expedites the resolution of these critical safety recalls. This issue cannot wait any longer, as it poses a serious risk to public safety. Thank you for your attention to this matter. Sincerely, [XXX] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/15/2023· SERVICE BRAKES

  A Kia dealership documented they performed the voluntary service recall SC252 HECU Inspection and determined my vehicle was within the guidelines and did not need replacement. 6 months later my vehicle experienced the symptoms of the HECU issue. The EPB, Auto Hold, and the ABS lights appeared on the console. We took the vehicle in for service, we were told they didn't have someone available to look at the issue and told us to reschedule, that is a separate issue. Weeks later when we took it and asked someone to look at it, since their next appointment wasn't for almost a month. The mechanic said immediately we can't let you leave with this car it is not safe. The brake fluid had leaked into the HECU box. So either the voluntary recall is inadequate or dealerships are not properly doing the inspection. I can not find detailed information on the risk associated with this but this is similar to the fire risk Kia has had in the past. In any case leaking brake fluid into the Hydraulic Electronic Control Unit can't be safe. If this is a know issue why is this still a voluntary recall. My family was put in danger and Kia continues to ignore this is an issue.

• 11/11/2025· ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER

  2022 Kia Telluride Issues: 1. **Sunroof:** Completely broken. 2. **Exterior Window Moldings:** Fading and discoloration. 3. **Axel Boots:** Need replacement with less than 60,000 miles on the odometer. 4. **Child Lock:** Malfunctioning. -

• 11/10/2022· STRUCTURE,VISIBILITY/WIPER

  Windshield cracked. Also oxidation on trim on both sides of windshield.

• 11/08/2024· AIR BAGSCrash

  A deer ran into my vehicle while I’m traveling at 55MPH and my airbags did not deploy. My vehicle is leaking fluids and smoking.

• 11/08/2022· VISIBILITY

  Rear passenger window spontaneously imploded while driving on a freeway. I took photos immediately upon arrival at home. No one was harmed, but had it been one of the front seat windows or someone seated in the back seat, they would have been harmed. Has not been inspected. Have appointment at the Kia dealership. They have not seen it yet. They resisted repairing it until we told them of other reports of KIA windows and sunroofs shattering without cause. I now have some fear of driving it and it occurring again. No warning or indication of the event.

• 11/04/2021· SEAT BELTS

  Unable to put the seatbelt latch in the buckle with a booster seat in place.

• 11/03/2022· VISIBILITY

  Sunroof suddenly exploded an hour ago while driving on the interstate at 70mph. It was loud, startling both the driver and passenger. It could have caused an accident. Fortunately, the sun shield was closed which prevented glass from entering the passenger compartment. There were no cars in our path. I have not taken it to the dealer yet or called insurance. There was no warning prior to the glass exploding.

• 11/02/2022· EXTERIOR LIGHTING

  Headlights are NOT bright enough for night driving.

• 11/01/2022· VISIBILITY/WIPER

  1st crack in windshield was a pebble, the 2nd was a bug that hit windshield.

• 10/31/2023· ELECTRICAL SYSTEM

  Instrument Cluster A blank LCD display may be missing information, such as the digital speedometer, gear selection indicator, and odometer, which may increase the risk of a crash.

• 10/31/2022· TIRES

  245/50 R20 Tire exploded no rubber left on wheel I was on the freeway doing 70, and there wasn't a secure place to pull completely over. no I got 5 second warning my tire was at 26 all others at 30... then BAM

• 10/29/2025· UNKNOWN OR OTHER

  PAINT IS FLAKING ON HOOD

• 10/29/2022· ELECTRICAL SYSTEM

  Blank instrument cluster same as NHTSA Campaign # 22V344000. This issue started happening about 2 weeks ago and has happened approximately 5 times so far.

• 10/28/2022· SUSPENSION

  At 13,500 miles I started hearing a clunking noise in the rear of the vehicle. There is also a strong burning rubber smell after I have been driving. The Kia dealer confirmed that my rear self leveling shocks need to be replaced. I'm not sure if the melting rubber smell is a fire concern. I am concerned that the reduced braking and cornering ability with the defective shocks would make it harder to avoid an accident. I'm currently waiting for the parts to arrive for repair but was instructed to continue to drive it. These shocks are specific to Tellurides with the tow package and it seems to be a known issue from the response I've gotten at both the dealer I purchased from and the dealer where I took it for service.

• 10/25/2024· ELECTRICAL SYSTEM,STRUCTURE

  Sunroof is stuck in an open position unable to be closed. Upon attempting to open the sunroof, the deflector snapped off the assembly and the sunroof track broke. Took car to dealership (Raceway Kia, 4044 US-9, Freehold, NJ 07728) for service. Dealership indicated the sunroof is beyond repair and requires installation of an entirely brand new sunroof assembly at a cost of $5730 because it occurred outside the warranty (warranty expired at 60,000 miles and the car had 70,463 miles when sunroof broke). They were unable to manually close the sunroof as a temporary solution. Therefore, the sunroof remains open due to the broken track and is covered with plastic to avoid the elements. There were no prior symptoms indicating that the sunroof would break in this way. In fact, in three years of ownership, the sunroof was rarely used and only opened a handful of times before breaking. At this time of this writing, the sunroof is available for inspection while I look for more economical means of repair versus the dealership's plan to replace the entire assembly.

• 10/25/2022· ELECTRICAL SYSTEM,BACK OVER PREVENTION

  Electronic speedometer cluster goes out sporadically. Back up camera glitches out randomly and says No camera signal received. At least 4-5 times in a year. Kia service won’t do anything about it unless the can “duplicate the issues”.

• 10/23/2025· ELECTRICAL SYSTEM,SEATS

  The contact owns a 2022 Kia Telluride. The contact stated that while attempting to start the vehicle, the infotainment system and instrument panel displayed black screens. A dealer was contacted. The contact stated that the middle rear passenger’s seat independently folded with or without a passenger seated in the seat. The vehicle was taken to a dealer where it was diagnosed and determined that the instrument panel and infotainment system needed to be replaced. The instrument panel and infotainment system were replaced on several occasions. The manufacturer was notified of the failure and opened a case. The dealer was contacted, and the contact was informed that no additional assistance would be provided. The approximate failure mileage was 83,000.

• 10/22/2024· ELECTRICAL SYSTEM,STRUCTURE

  The sunroof broke while being opened which required immediate repair since it was propped open. The only fix according to the dealer was to replace the entire unit which cost more than $5k with parts and labor

• 10/21/2022· VISIBILITY/WIPER

  Windshield cracked with less than 5,000 miles on the vehicle. I noticed it after picking it up from the dealership for an oil change.

• 10/16/2025· STRUCTURE

  White Paint Chipping prematurely

• 10/15/2021· VISIBILITY/WIPER

  Windshield already has a 'rock chip' on the driver's side. We've only had our 22 telluride for 1 week and only has 200 miles.

• 10/13/2025· POWER TRAIN

  The Telluride has developed a shimmy. At first, the shimmy was noted at lower speeds, around 35 to 45 mph while under minimal load such as going uphill and slightly accelerating. The car was taken to the dealership. The tires were balanced. We were told no other problems. A month later, same thing, same result. We just took a 2700 mile trip. The shimmy is apparent at higher speeds and in all transmission modes of operation.

• 10/11/2023· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  Problem started 4-5 months ago and was very intermittent; about 2-3 occurences per month. Problem has become more frequent and become much more severe. When foot is on brake and just coming to stop, engine races to around 6000 rpm. Originally would return to normal rpm in a second or two. Most recent occurences were on Oct. 10 2023, problem manifested 9 times. At stop, engine raced to 6000 rpm and remained there. Some times returned to normal rpm after few seconds, other times shifting to neutral and back to drive caused rpm to normal; 3 times I had to turn off engine. Once when restarting, engine immediately raced back to 6000 rpm and I had to stop engine again. Problem is intermittent so dealer says cannot tackle problem until they can experience problem themselves despite my very detailed description. Vehicle is unsafe to drive. Fortunately so far problem occured with foot on brake pedal so instantly increased brake pressure prevented vehicle from lurching forward into an accident.

• 10/07/2025· UNKNOWN OR OTHER,ENGINE

  We went to get the vehicle serviced at a dealership we did not buy the vehicle from. we told them to knock out the open decals and when we came to pick up the vehicle they said that the recalls had already been completed. We have owned the vehicle for over 2 years and not had any of the completed. They printed off a form with all of the recalls and it showed the dealership we bought the vehicle from in Missouri as completing the recalls. It’s not possible for them to complete them as we have lived in Texas for the last 2 years. I called the dealership multiple times with no reply. I contacted Kia corporate and they were told by the dealership in Missouri that they had completed them on a different vehicle but marked them as complete on ours. After months of not hearing back with a way forward from the dealership or corporate. I do not know where else to go to get this corrected. It is in very poor taste to have to fight to get an error on the dealerships side fixed. The recalls are for safety issues with the vehicle.