2022 Hyundai Ioniq 5

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2024· FUEL/PROPULSION SYSTEM

  Driving on the highway the car entered limp mode allowing only 30 mph. Messages "stop vehicle and check power supply" with 12V battery indicator. Classic ICCU failure.

• 12/31/2024· SEATS

  Passenger side rear seat (40% side) is missing all mounting bolts required to secure seat to vehicle. I purchased the vehicle as a preowned unit and noticed squeaking and a rattle coming from the rear seats. Upon inspection, I discovered that the seat is only resting on the floor and with little effort the seat can be dislodged.

• 12/31/2024· ELECTRICAL SYSTEM

  12 V battery died after being plugged in to charge overnight. The 12V battery was replaced in May 2024 due to a similar issue. It seems that the ICCU recalls and software updates have not been fixing the problem.

• 12/30/2023· ELECTRICAL SYSTEM

  The vehicle was being driven normally on city street and I heard a thump in the rear end of the vehicle. Very soon after, got a message on screen to check electrical charging system with the indicator lights for 12 volt battery and EV system illuminating. Parked the vehicle a kilometer after thump to deliver something to a friend (the car sat for 10 minutes). Resumed driving and then within a kilometer received a message that drive power would be limited -- significant decline in drive power... put my flashers on but did not stop because on busy street with no parking ... within two blocks, message of "stop vehicle and check power supply" appeared with full drive power ending within one block -- within that block, I was able to turn down a side street and coast down a hill to a parking lot. Attempting to turn vehicle off, the screen showed erratic behavior and headlights went on and off. Finally, was able to get everything off but was not able to lock the vehicle. If this drastic loss of power had occurred on a highway, there is a likelihood that such a power failure would have led to an accident.

• 12/29/2025· STEERING

  Shift gear was not engaging then i noticed the knob was slightly sticking out so I pushed it back in. The car changed gear then but it happened again a couple days later but this time the knob fell off while i was trying to push it back in. Brought to the dealers for inspection in September within a week after the problem started. Followed up twice now with no update as to when it will be fixed, I was told they will need to order part and that the entire shift gear will need to be replaced. They didn’t seem to be concerned about the safety of driving the vehicle around meantime. My husband used my car for a long trip while i was out of the country and he said the shift gear fell again. If it gets loose the gear does not engage.

• 12/29/2023· ELECTRICAL SYSTEM

  Known level 2 charging issue with Hyundai Ioniq 5 vehicles. Overheating issue with charging system, previously the issue shut down charging with a temperature exceeded ~212 Fahrenheit. TSB issued that "throttles" down charging rate, irrespective of the brand of level 2 charger doubling the time to charge the vehicle. Not as advertised and significantly reducing the utility of the vehicle.

• 12/27/2024· ELECTRICAL SYSTEM

  Unknowingly my cars ICCU failed. I went to charge my car on December 23. The EVSE then immediately tripped the breaker. The EVSE gave an error code of a stuck relay fault and made the EVSE unusable. This happened to 2 different Juicebox chargers and both are not permanently disabled and need to be replaced.

• 12/23/2025· ELECTRICAL SYSTEM

  Was charging the car at home in my garage when the charging session stopped. Opened the door and smelled electrical burning. Was able to put the car in neutral and push it out onto my driveway, fearing that an electrical fire could be disastrous. Called Hyundai roadside assistance and they had it towed to the closest dealership that can work on EV's (35 miles away). No report yet, but I'm pretty sure it's an ICCU failure.

• 12/23/2022· FUEL/PROPULSION SYSTEM

  The car randomly stops charging when plugged into either of my Level 2 home Juicebox 40 chargers before it reaches capacity, generally after adding another 4-8% to the battery. It was impossible for me to fully charge the car without plugging it in multiple times. The service people including the EV specialist said they hadn’t heard of this problem, and it was probably due to my charging unit at home. See the attached service and repair invoice . This was not true It is apparently a well-known defect in the Hyundai and Genesis cars using this platform and Hyundai is aware of the issue. it is not a problem with my charger. It happens whether it is hot or cold and generally when it is cooler as we only charge the car at night. Please note the following: 1.Saying this was a unique isolated problem was NOT accurate as this is a problem with many Hyundai and Genesis cars on this battery/charging platform. The Hyundai forums are full of these accounts, and they occur with all different types of chargers. For instance, see: a.https://www.youtube.com/watch?v=_3eh0BTSdng b.https://www.reddit.com/r/Ioniq5/comments/wrilke/ioniq_5_stops_charging_randomly_on_level_2_any/ c.https://www.ioniqforum.com/threads/charging-issues.42357/ d.https://www.kiaevforums.com/threads/charging-problem-automatically-stops-charging-at-home-the-charging-for-ev6-failed-please-check-vehicle.3659/page-12 3.The Ioniq 5 charges fine on level 3 superchargers 4.I spoke to Juicebox and they said other Ioniq 5 owners have reported the same problem in fact before I even mentioned the car I had, when I mentioned the problems, the technical advisor said, “Do you have an Ioniq 5?” He showed me downloaded graphs that show that the Ioniq 5 halts charges prior to being fully charged even though the charger is delivering power to the car. 5. I called Hyundai and they said they would look into this, but other people have received the same response, but nothing has been done

• 12/21/2025· POWER TRAIN,FUEL/PROPULSION SYSTEM

  3rd ICCU failure. Was Driving and went into limp turtle mode. Was in a dangerous area for it to happen and took a while to get to a safe place.

• 12/20/2024· ELECTRICAL SYSTEM

  Open ICCU Fuse, car would not charge

• 12/18/2024· UNKNOWN OR OTHER

  Drove less than one mile and the car suddenly dropped from 45 mph to 20 and would not accelerate (I was almost rear ended by a bus). I was able to pull off the road and the battery died.

• 12/17/2025· ELECTRICAL SYSTEM

  The car stopped both Level 1 and 2 charging. But Level 3 charging worked. When it stopped in the middle of Level 2 charging, it tripped my circuit and bricked my Juicebix Level 2 charger. Hyundai replaced the ICCU.

• 12/14/2023· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Feared ICCU leaving us stranded after reading so many reported failures, took car to dealership where they inspected and did some ineffective software update, few weeks later experience EV warning light and sudden loss of power, car wont go more than 25 so we parked and were effectively stranded. Dealer suspects ICCU....great. exactly what we wasted time trying to prevent. A KNOWN PREDICATABLE PROBLEM IS CALLED A DEFECT!!!!!!

• 12/12/2025· ELECTRICAL SYSTEM

  The contact owns a 2022 Hyundai Ioniq 5. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 24V868000 (Electrical System); however, the repair failed to prevent a failure from occurring shortly afterwards. The contact stated that while driving at 55 MPH, the vehicle was rattling abnormally. The vehicle was taken back to the same local dealer where it was diagnosed, and determined that all four tires needed to be replaced. The four tires were replaced. In addition, the contact stated that while driving at 35 MPH, the instrument panel abnormally illuminated. The vehicle was towed to the local dealer where the vehicle was originally purchased. The vehicle was later towed back to the same local dealer and diagnosed with a leak that contaminated the rear inverter. The vehicle was not repaired due to the costs and the warranty being invalid. The manufacturer was made aware of the failure. The failure mileage was approximately 132,000.

• 12/12/2023· ELECTRICAL SYSTEM,VISIBILITY

  The contact owns a 2022 Hyundai Ioniq 5. The contact stated while driving in rain or snow the rear windshield failed to be cleaned. The contact stated that the failure was a dangerous while driving at night while the headlights from vehicles behind caused the rear windshield to become opaque. The contact questioned a dealer and was informed that the vehicle was designed that way and that the windshield needed to be cleaned manually. Additionally, the contact stated that the vehicle lost electrical power while driving at approximately 60 MPH with the cruise control activated. The contact stated that the vehicle lost motive power with several unknown warning lights illuminated. The contact pulled over, stopped, restarted the vehicle, and the vehicle functioned as needed. The contact stated that the failure recurred once. The manufacturer was informed of the failure. The failure mileage was approximately 22,000.

• 12/07/2024· ELECTRICAL SYSTEM

  Hyundai has absolutely dropped the ball on this Ioniq 5's ICCU and 12V battery issue. After numerous recalls to fix a hardware problem through a series of software fixes that don't work and refusal to give a loaner for loss of use, I would like to pursue a buyback option for this vehicle. On Tuesday, [XXX], I went to Napleton Valley Hyundai in Aurora, IL to complete RECALL CAMPAIGN #272 NHTSA RECALL # 24V868000. After the recall, my 12V battery went dead on Wednesday, [XXX] and had to be towed to dealership. Their only solution was yet another software update and then charge the 12V and said it was ready for pickup on Thursday, December 5. I told them then to also do a wheel alignment and they said during that process, the 12V battery went down again. They then charged it back up and gave it back to me and said it was good. I encouraged them to pursue a better solution but they had no interest. So, it was picked up on Friday, [XXX]. On Saturday [XXX], the 12V battery went dead again and will have to be towed back to the dealership. Over the phone, my service advisor said it would have to be charged and released. If this issue then happens again, then a replacement might be considered. Calls to Hyundai North America headquarters have not yielded any results and they claim they need 3 business days to assign my case while I have no working car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/05/2024· ELECTRICAL SYSTEM

  Hyundai issued TSB 22-01-094H for my vehicle which is an update to the battery management system,, but after 4 attempts Hyundai dealerships have still not been able to complete the TSB. Hyundai corporate has also not helped after multiple cases. After many hours of research, I have determined that my vehicle's BMS software was updated to an intermittent version (version 700x) that does not support this TSB via automatic update, and the correct BMS Rom (version 540x) must be selected manually, which the dealerships are unwilling or unable to do.

• 12/05/2024· ELECTRICAL SYSTEM

  Received an error message upon starting car that said "stop vehicle and check power supply". Had car towed to dealership.

• 12/05/2023· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  The vehicle show an error message relating to the electrical system, refused to go over 24 mph for a short time, then went completely dark with no control and wheel locked. Dealer says ICCU + fuse is at fault, but there is no date for a new part. Vehicle is undriveable until new part comes in.

• 12/04/2025· UNKNOWN OR OTHER

  I plugged the car into our Juicebox charger and waited for the car to say “charging scheduled” before I walked away. My husband didn’t realize I plugged in and managed to back out of the garage, ripping the charger from the car. We need to buy a new charger now. We understand the car should never move if the charger is connected.

• 12/04/2023· POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES

  The car gave an warnings of “Check Electric Vehicle System@ and started slowing down in the middleman of the road. I could have been easily rear ended or got into a serious injury. After googling, it seems almost all if not most of ioniq 5 are having this issue after certain mileage

• 12/03/2025· ELECTRICAL SYSTEM,ENGINE

  I have had all recall updates on the car including a recent one on 10/13/2025. Turned on the heater on the first cold night in Dallas this fall and got the engine warning light. Checked the ODB and code was P1A90(96). I was able to drive it to the dealer with a 40 mph max speed. The funny thing is my ICCU has already been replaced under warranty once like 16 months ago, so it seems the replacement parts aren't much better than the original. Dealer confirmed it is an ICCU failure and I'm now waiting on the part. Hyundai has NOT fixed this ICCU problem even when they replace with a new ICCU. Someone needs to hold them accountable for finding a real fix.

• 12/01/2025· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  On November 29 2025 my 2022 Hyundai Ioniq 5 with 49000 miles was warming up in the driveway. I heard a pop sound from the back seat like a soda can being opened (or a fuse blowing). Immediately afterwards warning lights appeared on the dash saying "Check Electrical System." The vehicle lost power to accelerate and could not be driven effectively. After a few moments, another error saying "Power is Limited" appeared. This could have happened on the roadway which would have been hazardous to myself and other drivers. The car is scheduled to be diagnosed next week by Simmons Rockwell Hyundai in Elmira, NY. These symptoms are similar to the hundreds of other reports of ICCU failures in this car and similar models. On Sept 10, 2025 the car was previously issued software updates to the ICCU software , which were required under NHTSA Recall Number 24V868000. If this problem is proven to be an ICCU failure, the experience with this car is an example of the 2025 software update failing to prevent the ICCU Failure. I request swift action from the NHTSA to compel Hyundai to implement a permanent fix for my vehicle and all other afflicted models in order to make Americas roadways safe again. Until then, everyone should be extra careful when driving behind a Hyundai Ioniq, 5 because it is at risk of dying and coming to a complete stop at any moment. Hyundai is a large corporation and has the resources and technology to fix this, but they have not done so, despite there being more than 300 complaints to the NHTSA about these cars at the time of this writing.

• 11/30/2025· POWER TRAIN,ELECTRICAL SYSTEM

  Check Vehicle Electric System warming shows up on dashboard, then vehicles enters turtle mode and then cuts power shortly with violent jerking of the vehicle. Shortly after, all system shuts down, 12V is said to be weak and car cannot move.

• 11/30/2023· ELECTRICAL SYSTEM

  The car started reporting error messages including "Stop vehicle and check power supply". It briefly went into limp mode before dying completely. Flat bed to dealer who can't begin diagnosis for at least a week. This sounds identical to the ICCU issue that many owners are experiencing.

• 11/28/2025· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Electric Drive System Inoperable, sustained an immediate failure upon engaging in Drive mode. Dashboard lit up with warning lights and messages. Luckily was just pulling out onto road when vehicle completely died. Tow service unable to start vehicle with jumper module. After being towed to dealer, was diagnosed with failed ICCU. The original ICCU was replaced previously in January 2025. Luckily was not underway on the road when it happened. There was no warning, no indication that there was any problem.

• 11/22/2023· ELECTRICAL SYSTEM

  Car died in a Wegmans parking lot and dealer is telling me it will take 8-10 days to diagnose the problem which is known very well to the manufacturer and dealers. The ICCU has failed.

• 11/22/2023· ELECTRICAL SYSTEM

  My 12v battery died on 11/12 while my main battery still had 52% charge remaining. Had to jump the battery to get the electrical system to work. Since then several of the cars electrical systems are not working. This is a known issue online that Hyundai has responded to but the dealer is saying that they are not aware.

• 11/21/2025· POWER TRAIN,ELECTRICAL SYSTEM

  The ICCU (Integrated Charge Control Unit) failed. The car was in a Hyundai dealer repair shop on November 18, 2025, for an unrelated regular maintenance procedure when (i) the technician noticed a logged ICCU error code generated sometime prior to the shop visit and (ii) after the technician cleared that prior error a second new ICCU error code was generated. The shop replaced the defective ICCU. This car had been serviced on prior occasions to install updated ICCU software, most recently as part of NHTSA's recall 24V868000 of November 18, 2024 (also known as Hyundai Safety Recall 272), intended to eliminate such ICCU failures. Installation of that software as the remedy for recall 24V868000 clearly did not prevent the very ICCU failure it was intended to guard against. Please note also that it is common knowledge (as disseminated on various Ioniq 5 forums and Reddit groups) that large numbers of later Ioniq 5 vehicles with newer VINs not included in recall 24V868000, i.e., from model year 2025 onward, have also suffered from these failures despite being initially placed into service with the updated ICCU software, as well as many other pre-2025 remedied vehicles. The Hyundai ICCU software currently in operation on both remedied cars from recall 24V868000 as well as newer cars not subject to that recall is clearly entirely ineffective as a solution to this very serious safety issue. I strongly urge NHTSA to (i) declare the existing ICCU software to be an ineffective remedy for recall 24V868000, (ii) include all Hyundai Ioniq 5 cars for all model years, whether running current ICCU software or not, to be part of the group of unremedied and unsafe vehicles, and (iii) extend recall 24V868000 until such time as Hyundai can actually demonstrate that an effective remedy exists and is being made available to all Ioniq 5 vehicles.

• 11/18/2024· POWER TRAIN

  On [XXX], I was driving my 2022 Hyundai Ioniq 5 SEL when all of a sudden the car started beeping and displaying a 12V battery voltage low. Stop safely message. I was traveling on [XXX] in the Las Vegas area and the car all of a sudden came shut off seconds later. This presented a very dangerous situation with other vehicles traveling at 65+ mph and the vehicle shutting off. I was able to use a portable power jump starting pack to at least get the car restarted and pulled off the side of the highway. Even after jump starting the vehicle, it would only stay running for a minute before shutting off again. The is the second time in 2 months that my car has lost power. The dealer, ABC Hyundai in Las Vegas did a ICCU recall and said that would solve the problems. The problem has not been resolved and I do not feel this is a safe vehicle to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/17/2025· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  The Integrated Charging Control Unit (ICCU) failed - the car is no longer capable of driving due to the lack of ability to charge the battery. I was able to get it to the repair center. The ICCU on this model can fail in multiple ways, which includes the vehicle becoming inoperable at highway speeds. The issue first started 2025/11/13. I tried multiple charging units. It flipped the breaker on my home charger and caused issues for a public charger.

• 11/13/2025· POWER TRAIN,ELECTRICAL SYSTEM

  Carr went into limp mode and wouldn’t drive more than approximately 10 mph in traffic. Once I was able to pull over and reset the ignition button, the car seems to be operating normally.

• 11/11/2025· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Even after the recall service performed, the ICCU still failed 10 months later. DTC P1E011C is listed and will not charge. This is the same issue for the KIA EV9 and a TSB needs to be issued the same as the TSB 339 KIA did for the EV9.

• 11/09/2023· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  In stop and go traffic on freeway, car was moving at about 5 miles an hour but car kept moving, collision warning and automatic braking did not activate. Had to turn off car and coast to a stop. Nearly collided with vehicle in front

• 11/07/2025· ELECTRICAL SYSTEM

  The car would not charge. The Dealership where the car was bought assessed the problem and found out that the Integrated Charging Control Unit (ICCU) of the car had failed. They already replaced the component, however I am reporting this problem so as to be included in the statistics for this common problem with this Hyundai make.

• 11/06/2025· ELECTRICAL SYSTEM

  While charging at home with provided Level 1 Charger, the vehicle will suddenly stop charging. When it stops, it appears to be surging an electrical charge back into the home (black marks on outlets requiring an electrician to replace, black marks on the charger plug, and most recently, threw a breaker on our home electrical panel). This is a fire hazard.

• 11/06/2024· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Hyundai of Fort Myers Repair Order Number [XXXX] Dear NHTSA Team, I am reaching out to formally report a significant safety concern involving our Hyundai Ioniq 5, which recently experienced an Integrated Charging Control Unit (ICCU) failure. This malfunction occurred despite our vehicle receiving all relevant software and hardware updates that Hyundai implemented to address this known issue. This experience has caused our family considerable distress and has raised serious doubts about the reliability of this model, as well as the adequacy of Hyundai’s current safety measures to prevent ICCU failure. While my wife and young daughter were in the car, the ICCU failure occurred suddenly, producing a loud pop that alarmed us all, particularly my daughter who was seated in the rear. She has since expressed fear about riding in the Ioniq 5, making it clear that this issue has impacted her sense of security in the car. Despite the updates Hyundai has issued, the failure occurred without warning, putting us in a vulnerable situation and highlighting that the current remedies may be insufficient to prevent this risk. The gravity of this problem is amplified by my wife’s critical health needs. She is currently on the waiting list for a kidney transplant, and our family requires a dependable vehicle to ensure she can be transported quickly and safely to her medical appointments and, when the time comes, to the hospital for her transplant. We cannot rely on the Ioniq 5 for these crucial needs given our recent experience with this unexpected breakdown. I am requesting that the NHTSA investigate this issue, as our experience suggests that Hyundai’s current measures to address ICCU failure may not adequately safeguard Ioniq 5 owners. A comprehensive review of this problem could be critical in ensuring the safety of other drivers and families who may be unknowingly exposed to the risk of sudden vehicle malfunctions. We hope that the NHTSA will consider further action

• 11/04/2025· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCECrash

  I was coasting into a library parking space with my foot off the accelerator. The car accelerated even with my foot on the brake, jumped a curb and was stopped with above ground tree roots. The dashboard should have been lighted up with collision warning indicators and the automatic braking should have engaged. It did none of that. The car was totaled. Nothing was ever checked to see if it was a mechanical error. My insurer totaled the car.

• 11/03/2024· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Today when I was driving down a canyon going 40 mph, the car started coasting and the accelerator was unresponsive. I couldn't keep the car from decreasing speed and regen braking wasn't working either. I don't know whether it's related, but this happened within seconds of me turning off daylight savings time in the menu. I coasted to a safe place to pull over (the brakes worked fine), but I could not get the accelerator to work after switching from drive to park to drive again. After turning the car off and then back on, the accelerator again worked like normal. After continuing driving, I turned daylight savings time on and off a few times, but nothing adverse happened.

• 11/02/2023· POWER TRAIN,VEHICLE SPEED CONTROL,SERVICE BRAKES

  Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling!

• 10/31/2023· ELECTRICAL SYSTEM

  The 12 volt battery keeps failing. Every time I contact Hyundai AutoNation it takes forever for them to do anything about it and they don't seem to understand

• 10/30/2025· POWER TRAIN

  I am submitting an update to my existing complaint regarding the ICCU safety recall on my 2022 Hyundai Ioniq 5. Since my original submission, my vehicle has been at authorized Hyundai dealerships since July 2025 and remained undiagnosed and unrepaired for over three months. During this time, I received inconsistent and misleading information from both Hyundai corporate and the dealerships regarding the status of the recall repair, as documented via emails, texts, and recorded calls. On 10/31/2025, the dealership informed me that the issue may involve a floor harness/wiring problem and it is out of warranty; however, this appears related to the ICCU safety recall, and Hyundai has not provided a firm timeline for repair. Hyundai’s delay has caused significant inconvenience, as I have been without my vehicle while continuing to make car payments and insurance payments, and arranging temporary transportation. Additionally, Hyundai and the dealerships provided multiple assurances that the vehicle was being diagnosed and repaired, which were later contradicted, reflecting misleading and deceptive practices. I request that NHTSA consider this update as part of my ongoing complaint and investigate Hyundai’s failure to provide timely and adequate recall service, as well as the misinformation surrounding this safety recall.

• 10/30/2025· ELECTRICAL SYSTEM

  Iccu failure for the 3rd time

• 10/26/2025· ELECTRICAL SYSTEM

  My ioniq 5 has had the ICCU and 12V battery replaced in April, due to ICCU failure. Since then on two separate occasions the car has drained the 12V battery while parked. Both times were shortly after driving the car, so the 12V battery should have been fully charged. I believe multiple recall campaigns have been made related to this issue, but my car still appears to exhibit the symptoms after receiving the updates. * I believe the ICCU software is faulty and is not correctly charging the 12V battery. * This fault makes the car likely to strand my family unexpectedly (a safety issue), as it affects even the newly replaced 12V battery. * I have not taken this vehicle back to the dealership since the ICCU was replaced, since the 12V battery has only drained twice since then, I feel like it is unlikely they will be able to reproduce the issue. * No warning lamps or fault codes stored in the ECU.

• 10/25/2023· ELECTRICAL SYSTEM

  The car suddenly showed a warning on the screen asking me to park and in a few seconds went completely dead. It won't start at all. I can't even unlock the car. I had to call roadside assistance and have them tow the car to Ideal Hyundai dealership in Frederick, MD. It's been 4 days and the dealership can't diagnose the problem or won't communicate what the issue is.

• 10/24/2023· ELECTRICAL SYSTEM

  I charge my vehicle using a home 48 amp charger. After about 10 months of ownership. I began to receive “charging unsuccessful”notifications after about ten of charging at the Maximum charging speed. I reduced the charging rate to Reduced and was able to charge continuously to 90% a couple times at that rate. However, I began to receive “charging unsuccessful” notifications at this rate as well and had to lower the charging rate to Minimum in order to charge continuously. I can not charge the vehicle at 48 amps and the vehicle can only charge at 5.7 kwh, rather than the expected 11.5 kwh. The vehicle has been repaired four times. I cannot take the car on long trips, or for intensive use, where I would need to quickly charge to car in order to continue using it. As this issue appears to be progressive, when will the car fail to charge at even the Minimum rate? When I am on the road at a remote charging station? When I have an emergency and need to use it?

• 10/23/2025· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Despite being up-to-date on recalls for this vehicle intended to address failures with the integrated charging control unit (ICCU), I still experienced an ICCU failure. I was driving along a surface road at approximately 40 mph for about 9 minutes when I heard a pop that sounded like cargo shifting in the rear cargo area. The vehicle then flashed a "Check EV System" warning but otherwise continued to operate normally. About 2 minutes later, there was a warning to stop vehicle and check power supply. After I pulled into a parking lot, I restarted the vehicle, but the errors persisted. I had the vehicle towed to the dealer, where it was diagnosed as an ICCU failure. The vehicle was last charged ~15 hours before the failure on a level 2 charger at a peak rate of 6 kw. The vehicle was driven for about an hour after charging, sat overnight, before being driven when the failure occurred. The vehicle is primarily charged using level 1 and 2 charging, typically not exceeding 6.3 kw. Only a handful of times has level 2 charging rates exceeded 6.3 kw. The vehicle previously had the ICCU fail and replaced in 2023. The car is still at the dealership with no repair timeline.

• 10/23/2024· EQUIPMENT

  At around 9pm, while charging my vehicle, I heard a loud boom and the power went out. It appears there was some sort of malfunction with the charger that has tripped/blown the circuit. I have not had an electrician come out yet, but after a quick google search it became apparent that others have experienced the same issue and I thought it was important to report. My charger is outside, not in a garage or enclosed space, so there was no fire that I am aware of.

• 10/18/2024· ELECTRICAL SYSTEM

  While we were driving the Ioniq recently when it suddenly lost all power. We had a very brief warning on the dash that it was losing its power; we barely had enough time to pull onto a side street. It lost power so quickly we couldn't position the car properly and it stayed in the middle of the side street until the tow truck came and jumped the 12 volt battery enough to get the car into gear so it could drive up the tow truck ramp. The scary part was that we were only a block away from turning onto busy Highway 522 when it died. Had the car died on the highway we could have been stranded in a very unsafe position. The dealer later diagnosed the problem as a failed ICCU and 12-volt battery and replaced both. We had to rent a car for 3 days.