2022 Ford Maverick

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/17/2024· BACK OVER PREVENTION

  The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

• 12/16/2024· ENGINE

  The contact owns a 2022 Ford Maverick. The contact stated that while stopped at an intersection, the vehicle stalled. The contact stated that the hazard light was inoperable. There was no warning lights illuminated. The vehicle was towed to the local dealer who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The vehicle was restarted and operated as needed. The manufacturer was contacted and opened a case. The contact was referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 50,000. The VIN was not available.

• 12/13/2022· FUEL/PROPULSION SYSTEMFire

  The main fuel line feeding the fuel pump ruptured without warning, causing gas to spray across the engine compartment. The hot engine caused the gas to start cooking off, resulting in a fire in the engine compartment. The fuel line rupture has been confirmed by my Ford dealership.

• 12/09/2025· ELECTRICAL SYSTEM

  Battery in the passenger compartment is charging at 15.2 volts constantly. Ford dealer claims this is not a problem, but the battery life has been shortened, and the battery model number states it should be charged between 13.8 and 14.2 volts. The battery is located under the rear seat, inside the passenger compartment. From my limited understanding of battery technology, over-charging can produce hydrogen into the passenger compartment. My vehicle is now on the third battery, and has only 73,511 miles.

• 12/02/2025· WHEELS

  The contact owns a 2022 Ford Maverick. The contact stated that while her son was driving approximately 60-65 MPH on the Interstate, the passenger’s side front wheel detached. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

• 12/02/2025· ELECTRICAL SYSTEM

  The contact owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to respond. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed, and determined that the battery needed to be replaced. The contact stated that the failure had occurred on several occasions. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 19,150.

• 11/15/2024· SUSPENSION,ELECTRICAL SYSTEM

  CV axles make a very concerning, loud noise when driving. Any small bump on the road and it sounds like the front of my truck is going to fall off. When turning, there are loud knocking and clicking sounds coming from the front end, mainly passenger side. Electrical: My radio and head unit restarts randomly, both while driving and when the vehicle is turned off with keys removed from ignition. When it restarts, I hear a popping noise from the speakers, and the screen blacks out.

• 11/15/2024· AIR BAGS,SEAT BELTS

  The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.

• 11/15/2024· POWER TRAIN

  CV AXLE SHUDDER

• 11/14/2024· UNKNOWN OR OTHER

  Vehicle shut off spontaneously with out steering control or ability to turn on hazard lights. Upon shut off vehicle dash and all internal lights flickered on off for hours no power with key ignition would not function

• 11/13/2024· BACK OVER PREVENTION

  The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated while reversing, the rearview camera image was frozen. The contact stated that the rearview camera image remained displayed and frozen upon shifting into drive(D). The contact stated that upon turning off and restarting the vehicle, the image was no longer displayed. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 33,400. VIN tool confirms parts not available.

• 11/06/2023· ENGINE

  Engine shut down at speed. Power totally went off. No power steering. Service engine light came on. I was able to restart vehicle but it kept shutting off. Vehicle starts with engine warning light but cannot be derived without shutting down. this has happened twice. Once with about 200 miles and the second time with 3,500 miles

• 11/02/2025· STRUCTURE

  Door check has failed in the frame. The spot welds have broken in similar fashion to the Ford Customer Satisfaction Program 23B56 on the Escapes. There are popping noises, creaking, alignment issues, and prevents the window from rolling down.

• 10/21/2024· POWER TRAIN,ELECTRICAL SYSTEM

  This morning before my drive to work, a service vehicle soon message popped up on the screen. During my drive to work the vehicle began to respond sluggishly and lose power and acceleration on the highway. My safety and the safety of others was put at risk and the vehicle was unable to maintain highway speeds. I was able to make it to work driving at reduced speeds, and after parking the vehicle received a message on my Ford App of a Powertrain Malfunction / Reduced Power alert. My vehicle was serviced by Ford on 06/20/2024 for a recall related to the Powertrain Control Module (PCM).

• 10/19/2022· STRUCTURE,FUEL/PROPULSION SYSTEM

  The 2022 Ford Maverick has a design flaw the harms the environment and places driver and passengers at risk. Specifically the vehicle does not have a metal skid plate which places the Evap System at risk for damage. If the system is damaged the vehicle is still driveable, but doing so allows gas vapors into the environment and worse, possibly into the passenger compartment. Looking under the vehicle, one finds some sort of fabric or mesh material which is definately not robust enough to protect the evap system components from damage. Driving on paved roads....no problem. Using this vehicle as a truck involves driving on farm land, pastures, lightly wooded areas,etc. This is where the damage may occur. There is no warning posted on the vehicle or in the owners manual that warns drivers to avoid these areas. The solution is simple. A recall to replace the fabric or mesh material with a metal skid plate. Most trucks and off-road vehicles have metal skid plates as standard components. Why the 2022 Maverick does not is beyond my understanding.

• 10/17/2025· POWER TRAIN

  The vehicle begins to vibrate in the front end when accelerating and reaching 80 km/h. It becomes extremely unstable. The dealership was unable to find the cause of the problem.

• 10/17/2024· POWER TRAIN

  Premature failure of both front CV axles. The vehicle had an extremely unsafe vibration in the front end during acceleration. Dealer has replaced both axles under warranty. This is a known failure and many of these vehicles are experiencing premature failure. Warranty will cover but failures are continuing to happen. Many owners have replaced the axles multiple times, prior to getting to even 65k miles.

• 10/16/2025· POWER TRAIN

  The rear drive unit (rdu) begin to shutter and lock rear tires at low turning speeds. The vehicle was out of warranty with 85k miles. I paid a Ford dealer to replace the rdu and 2 weeks later the same issue was occurring.

• 10/14/2025· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ENGINE

  My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises

• 10/12/2024· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER

  My license plate light has stopped working. It was replaced and still isn’t working. This reduces visibility and increases risk of a crash. This is in addition to the legal requirement to have an operating license plate light.

• 10/12/2024· AIR BAGS,STRUCTURECrash

  I was involved in an accident. During the accident none of the airbags deployed. The impact was so hard that it lifted the truck up off the ground and spinned us around 90 degrees. This resulted in the individuals seated on the passenger side of the truck to be thrown into the door fairly hard, with one passenger hitting her head on the window even with the seatbelt on. The point of impact was the drivers side back tire and bumper area.

• 10/07/2024· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V293000 (Exterior Lighting, Electrical System), and the software update was completed. After receiving the update, the contact stated that the instrument panel failed to display the starting messages and displayed the vehicles in many different systems. The vehicle was taken to the dealer who had completed the software update a second time. After receiving the software update the second time, the instrument panel began functioning as intended and properly displaying the necessary information. The contact stated that the radio and display screen started malfunctioning. The vehicle was returned to the dealer who was not able to determine the cause of the failure and was only able to complete the remedy the manufacturer had authorized. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 38,000.

• 10/07/2024· BACK OVER PREVENTION

  The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/03/2024· POWER TRAIN,UNKNOWN OR OTHER

  The whole car shut down while i was driving. I lost all power to the car and couldnt get it started again.

• 09/27/2022· AIR BAGS

  The side curtain airbags in my 2022 Ford Maverick have been recalled, but the replacement parts will not be available for 5-6 months. This is a Massive safety concern for me as I drive the truck with my 1 and 3-year-old daughters. This is a dangerous situation that I am being told can not be remedied in a timely manner. I can not be expected to cover the added cost of a rental vehicle for close to half of a year and I refuse to put my children and myself in danger by continuing to use this faulty vehicle.

• 09/24/2023· ELECTRICAL SYSTEM

  I was driving back home from errands and during a stop, the entire car suddenly powered off and became unresponsive. I couldn’t even flash my hazards and was stuck in the middle of a busy intersection. Also couldn’t put it in neutral since the gear shifter is electronically powered. Some bystanders tried to jump my car, but it took 6 solid tries before they could restore power. I drove it another 1000 ft, trying to head to a service center and this time it completely powered off while in motion. I had to fight with the steering wheel to pull it to the shoulder as the power steering went out and the car started making clicking noises. The entire car was completely dead, once again. A tow truck diagnosed the battery as still healthy and suspects a deeper electrical fault with the car. It has been towed to the dealer for service under warranty, but I am reading that I am not the only one with this issue. A lot of folks are getting battery swaps and having the issue recur later. Could this be a wiring harness fault, or a much more pervasive electrical issue? The entire episode was terrifying, and I could have gotten into a major accident if this was on a busier road.

• 09/23/2023· ELECTRICAL SYSTEM,ENGINE

  This vehicle was purchased in 2021 with a 3 year 36k mile warranty. At 39k miles the truck has started to shut off randomly while driving. It has put us in very dangerous situations and it happens multiple times every day. The vehicle will be driving down the road and suddenly shut off. It will not switch to neutral so cannot be pulled off the road. It will not turn on for at least 20 minutes so we get stuck in the middle of the road. Sometimes it will turn back on but other times it has to be jumped. Ford is telling us that any repairs will not be covered because this brand new car is out of warranty.

• 09/15/2025· UNKNOWN OR OTHER

  HVAC evaporator drain is broken/cracked/clogged at firewall forcing water that should drain to outside of vehicle under the passenger side rubber floor mats, making it unknown to driver for months that this is happening and by the fuse box creating mold, mildew, and electrical issues. This is a known issue with ford trucks. Ford refuses to acknowledge and help with repair requiring removal of dashboard and replacement of moldy floor mats which is a health hazard. Dealership wants several thousand for repairs. This is an engineering design problem and must be recalled due to health hazards, electrical damage to full fuse box being under the carpet that's wet and the fact that ford knows this issue exists but won't correct the design flaw.

• 09/06/2026· POWER TRAIN

  While driving on the streets the powertrain module gave out. It started to jerk around 30 mph and then just would not go.

• 09/04/2025· SEAT BELTS

  I am getting a “rear seat belt monitor fault” warning on my dash accompanied by an air bag warning light. It is also not allowing the auto start stop function to work as the vehicle states it cannot verify the driver seat belt is fastened. I have read in online forums that this is not an isolated issue.

• 09/03/2025· VISIBILITY/WIPER

  Never in all my years of driving have I or anyone i know experienced a vehicle with such a sensitive windshield that cracks with even minimal impact. I've owned this Ford maverick for under 3 years with 3 chip repairs and 2 replacements. This is unfair to consumers as often we are not aware of this issue until it is too late to change undo the purchases on these vehicles and have to drive faulty vehicles. It's surprising that there's no recall already assessed for something that causes customers to have higher insurance premiums, constant damage that affects visibility and causes some to drive with these defects to avoid extra costs and wasted money. I am hopeful you can assist us consumers in having Ford rectifying these issues at no cost to us as their choice to use defective windshield glass has cost all of us. This issue is widely known by owners and discussed on social media forums in abundance. Dealers are aware of this issue and offer nothing but an attempt to purchase other vehicles. Minimal research on the internet provides an abundance of evidence. I thank you for your time and assistance in advance for this issue.

• 08/31/2022· ELECTRICAL SYSTEM

  The contact owns a 2022 Ford Maverick. The contact stated that NHTSA Campaign Number: 22V193000 (Electrical System) was repaired at the dealer. The contact was stopped by the police and informed that the brake light on the trailer was illuminated. The vehicle was taken to the dealer for the Ford Tech to reprogram the brake module. The contact was informed to no use the trailer brakes. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 9,000.

• 08/30/2026· ENGINE,FORWARD COLLISION AVOIDANCECrashFire

  Engine failure with fire. Fully engulfed within seconds. Police and fire on site. AAA insurance No prior issues with vehicle

• 08/29/2022· POWER TRAIN

  Transmission Failure. Following a 550 mile road trip over two days. The transmission would fail to engage in Drive and Reverse until the engine was throttled to 4000-4500RPM. Transmission felt like a Manual with failing clutch, would slip until slowly engaging after running at high RPMs for a few seconds. The condition appeared after the first day of the trip, and was intermittent, occurring only during standing starts. Once the vehicle was moving, there was no problem maintaining speed. Over the next two days the condition deteriorated to the point where it was occurring almost every time the vehicle was started and an attempt was made to start from a stand still. It began to become noticeable shifting from 1-2, 2-3, 3-4 as well, where it felt like the transmission was slipping during acceleration. There were no warning lamps or indications from the vehicle that there was a failure. This caused a loss of power and acceleration, which endangers the vehicle occupants in situations where power and acceleration is needed, such as merging, crossing intersections, or making defensive driving maneuvers. This vehicle was towed to a dealer, where the dealer validated the concern, and the transmission was replaced under warranty. Repair notes state that the transmission converter had failed. The transmission was returned to the manufacturer during the service visit. There are multiple instances online of other vehicles with this transmission having the same problem.

• 08/27/2024· POWER TRAIN

  Both front cv axles failed at 55,000 miles causing shake while accelerating

• 08/26/2025· POWER TRAIN,ENGINE,FORWARD COLLISION AVOIDANCE

  I was at a stoplight, when the light turned green I went to press the gas and the whole car lost power and died. The car stalled and would not turn over again. The vehicle had power but would not start the engine. All the alerts were flashing on the dash and the car would not go into neutral, so I was stuck in the middle of the roadway. I followed the procedures to activate the manual override and place the car into neutral and the vehicle would still not move. The electrical brake would not allow the vehicle to move. We tried repeatedly to put the car into neutral to move out of an active roadway and would be able to push the vehicle about an inch before the electrical break would kick in again. The vehicle would not start regardless of what was attempted. We even disconnected the battery in hopes of either getting the vehicle into neutral (which did not work either) or restarting whatever was wrong with the electrical system and be able to start the truck. Nothing worked and the vehicle had to be hoisted by pulley onto a flat bed tow truck. Then required to be "shaken" off of the truck when it arrived at the Ford dealership.

• 08/22/2025· STRUCTURE

  The contact owns a 2022 Ford Maverick. The contact stated while the door was closed, the window failed to roll down; however, upon opening the door, the window was able to be rolled up. A dealer was contacted. The vehicle was taken to the dealer where it was determined that door needed to be replaced. The vehicle was not repaired. The contact related the failure to a Customer Satisfaction Program: 23B56 (Inspect front door check-arm reinforcement spot welds); however, the VIN was not included in the CSP. The vehicle was repaired. The manufacturer was notified of the failure, and the contact was informed that there were no recalls on the VIN related to the failure. The failure mileage was 27,000.

• 08/22/2025· ENGINEFire

  Truck smelled funny, pulled over to check it out. Got out truck and noticed it was on fire from engine.

• 08/22/2024· POWER TRAIN

  Front CV axles causing Intense vibration through out front suspension/drivetrain

• 08/22/2023· UNKNOWN OR OTHER

  The passenger side footwell is accumulating water. Windows are closed, no significant rainfall. Perhaps associated with the AC. Mold spores have formed on the carpet causing a health hazard. I am too worried to pull up the carpet to see what it is like underneath. After drying it several times, it continues to form puddles, again with no rain.

• 08/19/2026· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINEFire

  The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/18/2026· POWER TRAIN,FUEL/PROPULSION SYSTEM

  While driving my 2022 Ford Maverick on a public road, the vehicle suddenly lost acceleration and would not respond normally when I pressed the accelerator. I was left in the roadway and could not safely continue driving, creating a risk of being struck by other traffic. The vehicle was later inspected by a Ford dealership and diagnosed with a major internal transmission failure at approximately 62,000 miles. The Ford dealership recommended a rebuilt/replacement transmission. The vehicle remains available for inspection. I did not have advance warning that the transmission was about to fail.

• 08/15/2025· POWER TRAIN

  The vehicle vibrates or surges rapidly when accelerating or going up a steep hill. I have been advised that it is due to defective axles which are currently on backorder with no expected ETA.

• 08/15/2023· SERVICE BRAKES

  Multiple instances of Auto Hold function sucking brake to floor and haulting vehicle at low speeds causing danger of a rear collision. Recommend adding a 1 second delay to current system before engaging auto hold function.

• 08/14/2025· POWER TRAIN

  No warning transmission went out while driving on freeway. Lost all power and vehicle would not engage into gear again.

• 08/13/2025· POWER TRAIN

  The transmission is occasionally without any warning disengaging while driving. You must then try to get off the road turn the truck off put the key back to run with engine off, shift it to park, start it again and then you can drive it again until it does it again.

• 08/09/2023· ELECTRICAL SYSTEM

  I pulled my 2022 Maverick into my parking spot at work and everything went dead. I had to use my key to open my tailgate. The tow service jumped the battery and it started, however, when they went to take it off the tow truck at the Ford dealership, it had to be jump started again. I was told the battery was bad and they changed it. The vehicle worked fine for three days and on the morning of the fourth day I had difficulty starting the vehicle. The first three times I turned the key all I heard was clicking and it started on the fourth try. I then drove it straight to the dealership where it has been for the past 8 days.

• 08/03/2024· TIRES

  I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on there part.

• 07/30/2025· POWER TRAIN

  While exiting highway (removing foot from gas) vehicle thumped. The a “ Powertrain Malfunction / Reduced Power” message came up on dash.

• 07/29/2024· SERVICE BRAKES

  The rear brakes and rotors have prematurely worn out at only 28k miles, while the front brakes are like new. There is no way for me or any local repair shop to put it into brake service mode. The official Ford procedure does not work. NHTSA issued SSM 51217 acknowledging the issue, but the only solution is only to take it to a Ford dealer to do a simple procedure such as changing rear brake pads. This solution is unacceptable and causes an undue burden upon the customer in time and money for a known manufacturing defect. My closest dealer is 1 hour away. It can not pass my state safety inspection without this being done. Ford should be issuing a recall to address this defect, not simply driving people to the dealer network for basic safety maintenance.