2022 Ford Bronco

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2022· VISIBILITY/WIPER

  During moderate to heavy rain when the windshield wipers are on constant low speed or high speed they will operate normally for 60 to 90 seconds then go into an intermittent wiping mode. This cause very poor visibility increasing the chance for an accident. I have taken the vehicle to the dealership (Newberg Ford in Newberg Oregon) for warranty repair and was advised this is normal operation. The dealership staff provided me with Ford Technical Service Bulletin SSM 50692 and said there was nothing they could do. The bulletin states that the wiper speed could be reduced if the windshield is dry or obstructed to prevent damage to the wiper motor. I continue to have the wipers reduce speed on a WET windshield with no obstructions. I have video to demonstrate this.

• 12/27/2022· VISIBILITY/WIPER

  Unknown- t he wipers on the bronco do not stay at the correct speeds for severe rain or snow. If I have them on high they work for a bit and then start to slow down and make it hard to see so I have to turn them off and on again to keep the speed at a pace where I have visibility.

• 12/25/2023· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  Battery charge, over heated, failed power train, and failed 4x4 happened all within seconds of each other. We were on a 2 lane hwy where there was very little room to pull off the main road. It was Christmas Eve and we were about 60 miles from home. We had to pay around $400 dollars to have it towed home and it was freezing outside while we waited.

• 12/22/2022· VISIBILITY/WIPER

  The wipers will slow down when operating at low, high, or intermittent. Ford claims these are "Smart Wipers" I believe there is an issue that requires a feature correction or re-flash of the related program to correct. I have to continually adjust the wiper control knob to re-set the wipers to the proper speed.

• 12/20/2022· VISIBILITY/WIPER

  Wiper blades slow down or stop working when raining. Have to constantly adjust the wiper control. Only have 500 miles on the car

• 12/18/2024· TRACTION CONTROL SYSTEM

  The contact owns a 2022 Ford Bronco. The contact stated that while his wife was driving approximately 55 MPH, the electronic traction control failed causing the vehicle to become unstable and difficult to steer or control. Additionally, the braking system had malfunctioned, and the brake pedal was firm while depressed, and the driver was unable to immediately stop the vehicle. The driver was able to steer the vehicle from the middle lane to the shoulder and used the parking brake to slow the vehicle to an eventual stop. The vehicle was later towed to the local dealer. The cause of the failure was not yet determined. During the failure, the driver’s side rear axle and the rear driver’s side wheel studs and aftermarket lug nuts were damaged and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 13,664.

• 12/17/2022· POWER TRAIN

  2022 Ford Bronco that I've owned for about 2-3 weeks. Started it up and went to drive off this morning, and I received a '"Check 4x4" error, followed by "Service Vehicle Soon". This ultimately has locked the vehicle into 4WD-High and makes it not only more difficult to drive, but is also prematurely wearing tires as it's driven and adding a lot of unnecessary stress to the vehicle as corners are taken. I've taken it to the local Ford dealership, where they weren't able to pull any useful codes or information for a quick fix unfortunately. As I've researched into this further, this sounds like a frequently occurring issue; wherein a problem with an axle solenoid or a powertrain control module seems likely blames.

• 12/15/2022· VISIBILITY/WIPER

  If windshield wipers are placed in normal or fast mode they start out fine, then get slower and slower until they stop completely. I needed to toggle between normal and fast just to keep them working. (I verified I’m NOT in interment mode).

• 12/13/2024· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  On [XXX] I was driving the vehicle during heavy rain. I commute 47 miles each way to work, when nearing my work location the car started to sputter like it was out of fuel and slowed to a crawl, applying pressure to the gas pedal had no impact - acted like it was getting no fuel, was able to pull vehicle over to side of the road. Vehicle would turn over but would not start - Check Engine light came on - codes displayed on code reader indicated that the high pressure fuel sensor and the low pressure fuel sensor were having issues. I had the vehicle towed to the closest Ford Dealer and they ended up replacing the fuel sensors and fuel pump. Thought that it was a faulty fuel pump. The Mileage I believe was 59516. On Wednesday [XXX] I was again driving this vehicle to work in a rain storm and at almost the exact same distance from home on the exact route the vehicle exhibited the exact same symptoms and the vehicle abruptly stopped running after shuttering to a stop with no fuel. In both cases the vehicle had a nearly full tank of fuel. The vehicle has been taken back to the Ford Dealership for repair. It appears that there is an issue when driving for extended periods on very wet roads water is entering the fuel systems electrical components and causing the system to fail causing a very unsafe driving condition. On December 11th the area had received 3.23 inches of rain in a 3 day period with the heaviest falling on the morning of December 11th. December was when Hurricane Helene passed to the west of our location in South Carolina dropping several inches of rain. Have made short trips in light rain with no issues, only in heavy rain and long distance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/13/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,BACK OVER PREVENTION

  The vehicle’s back-up camera completely malfunctions about 20% - 30% of the time making it completely impossible to see anything behind the vehicle when backing up. Sometimes, when the vehicle is put into reverse, the display screen will be completely dark, other times the image freezes on a load up image or screen and there is no display of what is behind the vehicle, and worst of all, other times the display will lock on the first image from the rear facing camera and not show real-time video of what is behind the vehicle, making the driver think it is safe to back up when it may not be. The vehicle has been brought to two different Ford dealerships three different times over the last two years regarding this problem. The first time I was told the problem had been addressed. The problem continued to occur. The second time, I was told the issue could not be addressed at that time. I was told that Ford Corp was aware of the problem but they did not have a fix available at that time. I was told that Ford Corp was working on software enhancements that would be available sometime in the future that would address the issue. The problem continued to occur. The third time I was advised the problem could not be addressed at that time and “Ford is working on additional software enhancements which are expected to be delivered over-the-air (OTA) by late Q4 2024” and “Software will update automatically if vehicle connectivity is enabled in the vehicle’s settings.” The problem continues to occur, so much so that I have several recorded videos of the problem occurring.

• 12/11/2022· VISIBILITY/WIPER

  When the windshield wipers are set to normal operation (not intermittent), the wipers would slow down and sometimes stop completely after a few wipes. There is no a automatic wiper mode. This is a safety defect on a new car. The wipers would stop during heavy rain. It does not matter if the vehicle is moving or not.

• 12/10/2024· UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEMFire

  We were returning home from a trip. We pulled into a gas station to get gas. As we pulled up to the gas pump, we smelled smoke and then saw smoke and fire. We immediately turned the Bronco off and jumped out. Shortly after, the whole engine compartment area was on fire. Luckily, there was a tow truck in the parking lot and was able to drag it away from the gas pumps. I had gotten an oil change prior to our trip. There were no warning signals, lights, or indication of temperature or oil problems. I had intermittently smelled gas while driving during our trip, but my wife said she did not smell gas on the passenger side.

• 12/10/2022· VISIBILITY/WIPER

  The windshield wiper will not stay on continuously. It malfunctions every time I have it on continuous low or high speed. I was driving in heavy rain with the windshield wiper on high continuous speed. After about 30 seconds it goes into intermittent mode, only cleaning the windshield every 3-4 seconds or so. It makes driving very difficult in the rain and dangerous as I cannot see the road. Same thing happens on the regular continuous speed setting. It is reproducible every time I use the wipers rain or shine. I checked on the Ford Bronco Forum website, and it is a common complaint.

• 12/08/2022· UNKNOWN OR OTHER

  There is an open recall on my vehicle for possible poor adhesion between the windshield and body (violation of federal motor vehicle safety standard FMVSS 212). I took my vehicle to a Ford dealership on 12/5/22 for this repair, as well as the repair other minor issues. I received a call on 12/7/22 from the dealership to inform me that they would not perform the recall fix due to the fact that my windshield has a crack across the middle and could possibly break during the removal. They said that I need to have the windshield replaced at my own cost, then bring it back in so that they can remove the new windshield and perform the recall fix. Nothing in the recall notification says that the windshield must be in "like new" condition in order to be eligible for the repair.

• 12/07/2022· POWER TRAIN

  The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 5 MPH and attempting to shift the manual transmission from first to second gear, the transmission failed, and the clutch went to the floorboard. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer where it was diagnosed and determined that the clutch had burned, and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 4,500.

• 12/05/2022· WHEELS,UNKNOWN OR OTHER

  I am filing a complaint because as I was driving my new 2022 Ford Bronco Big Bend the front passenger wheel popped off. There was no previous warning signs to let me know something was wrong. It seems as though the bolts/ lug nuts just snapped as I was driving. The tire popped off rolled back hit the car causing it to bounce and then fall and drag for a bit before I was able to come to a full stop while the wheel rolled down the street. This caused a lot of damage to the car from body to suspension. Luckily I was traveling at low speeds so I was not injured and luckily no one else was near to be injured by the run away wheel. I had the car towed to AutoNation Ford in Katy where they and insurance representatives inspected it. AutoNation has had the car for over a month and they still have not fully repaired the vehicle. I do not fully understand what went wrong.

• 12/05/2022· FUEL/PROPULSION SYSTEM

  The vehicle started leaking fuel from under the passenger front fender. We were able to get the vehicle off of the highway. When I opened the hood it appeared that the leak was coming from the top area of the engine. The vehicle was towed to a Ford dealership and we are waiting for the reason it was leaking. This vehicle is a bit over 6 months old and has less than a thousand miles on it. I am aware that Ford has a recall on the Bronco Sport model but mine is a regular Bronco with the 2.7 liter engine. There were no warning lights or buzzers prior to this incident.

• 12/02/2023· ENGINE

  Flat towed vehicle behind motorhome. Followed Fords instructions to the letter. Transmission fried even though computer showed flat tow engaged. Ford refused to warranty this issue and blames the operator due to an internal memo. Ford dealerships have acknowledged their is an issue with their flat tow system but Ford refuses to warranty.

• 12/02/2022· UNKNOWN OR OTHER

  Inside above the rear seats is a metal bar and it’s invaded with plastic. At first the plastic where the screw is at cracked all around the bar in 2 places. Now the plastic is completely off of the bar . Ford is saying it’s normal wear and tear and it’s NOT…

• 11/30/2024· POWER TRAIN,UNKNOWN OR OTHER

  UNKNOWN grinding sound when at idle or in/out of gear ( manual transmission) sounds like transfer case. Other owners of 2021-2023 broncos regardless of trim levels have heard this sound with their broncos as well (manual trans)

• 11/29/2025· SUSPENSION

  Ford has an active recall for failed rear shock absorbers. My bronco was inspected at the Ford dealership, the tech indicated the shock absorbers failed inspection and needed a recall. A picture was sent to Ford, Ford declined the recall stating the rust was not corrosion. Therefore, my bronco did not receive the recall. Recall number is.25V025.

• 11/29/2025· SUSPENSION,UNKNOWN OR OTHER

  Tried to get my vehicle fixed under recall Ford mistakenly told me that these were aftermarket rear shocks and that they weren't covered upon fixing the vehicle myself and bringing the shocks into a different dealership they told me that they were covered and should have been fixed under recall I've been trying to get reimbursed by Ford for this and I've been getting the runaround I've been promised call backs from supervisors and have not got any they are well past their 60 day window per their policy to respond this is going on 6 months now I've been trying to get reimbursed for this fix

• 11/24/2025· SEATS

  See attached document for complaint. Dear Ford Motor Company, NHTSA Officials, and Lindsay Ford of Wheaton: I am the registered owner of a 2022 Ford vehicle, XXXXX. I am in receipt of NHTSA Safety Recall Notice 22S72 (dated November 2025, enclosed herein), which states in part: "Vehicle identification Number (VIN): [partial VIN redacted] ... This recall applies to vehicles which may have a defective motor assembly that can cause sudden loss of power, stalling, or fire risk while driving. Until parts are available, Ford recommends parking the vehicle outdoors and away from structures." I am terrified to drive this vehicle. The recall explicitly warns of fire risk, sudden power loss, and inability to restart, all life-threatening conditions. Ford admits no remedy is currently available, and the interim instruction to park outdoors is not a fix; it is an admission that the vehicle is unreasonably dangerous. My Legal Rights Under Federal and State Law: NHTSA Authority (49 CFR § 577.5) "The manufacturer shall remedy the defect or noncompliance without charge when the vehicle is presented for remedy." 1. Ford has failed to provide a timely remedy and instead issued a "park outside" advisory, which does not eliminate the hazard. 2. Magnuson-Moss Warranty Act (15 U.S.C. § 2301 et seq.) Ford's express and implied warranties of safety and merchantability have been breached. A vehicle that can catch fire or stall without warning is not fit for its ordinary purpose (safe transportation). 3. Maryland Lemon Law / UCC § 2-314 (Implied Warranty of Merchantability) A known fire hazard renders the vehicle defective and unmerchantable. I have a right to revocation of acceptance and replacement or refund. 4. Ford's Own Recall Language The notice states: "If you are not comfortable driving your vehicle, contact your dealer. "I am not comfortable. I am afraid for my life and my family's safety. I am copying the dealership as well. DEMAND FOR RELIEF: Within seven (7) business days of receipt of this letter, I demand: 1. A brand-new, identical or comparable 2022+ model replacement vehicle (same trim, options, and features), delivered at Ford's expense, with: 0 Zero miles or loaner credit until delivery All taxes, title, registration, and delivery fees paid by Ford 0 Full transfer of remaining factory warranty 2. Immediate pickup of the defective vehicle at Ford's expense 3. Written confirmation that the replacement vehicle is not subject to Recall 22S72 or any open safety recalls 4. $1,500 inconvenience stipend for stress, loss of use, and reliance on unsafe transportation FAILURE TO COMPLY: If Ford fails to meet this demand within seven (7) business days, I will pursue small claims/superior court action for breach of warranty, revocation, and damages; and, seek punitive damages for reckless endangerment (knowingly selling/distributing a fire-hazard vehicle).

• 11/24/2023· UNKNOWN OR OTHER

  The transmission has a grinding or scraping noise when clutch is not engaged. No warning lamps or messages. It has been below 50 degrees, but even after the day warms, the noise is still there. I have not taken it to the dealer yet as there are many reports from other people with the same issue and all have been told it is "normal" when it gets cold. This does not make sense. I have had manual transmissions in the past and have never heard this type of noise when it was cold.

• 11/23/2023· VISIBILITY/WIPER

  Driving 25 mph on a residential concrete road lost vision through windshield . A sudden storm caused leaves to block sewer grates from draining water . When going through 6-8” at curb side . I started turning wipers to high and I didn’t see improvement quickly. I slowed down to 20 mph for the following one and same thing again total loss of visibility . Thinking about it I’ve driven through the same amount of rain sitting on this same road with many different automobiles… And never experienced this kind of loss of visibility, especially at this slow of speed . Help us before someone gets hurt or killed .

• 11/22/2022· ENGINE

  The contact owns a 2022 Ford Bronco. The contact stated while starting the vehicle he heard a rattling nosing coming from the vehicle. There was no warning light illuminated. The contact stated that after the vehicle warmed up, the sound went away. The vehicle was taken to the dealer and the mechanic confirmed the abnormal sound coming from the vehicle, but no failure was found. The manufacturer was contacted and advised the contact to reach out to the NHTSA Hotline and file a complaint. The failure mileage was 12.

• 11/21/2025· SUSPENSION

  The front shocks are leaking and not operating properly. This is a similar known issue with the rear shocks. This is a similar part on the front and Ford is not acknowledging the issue. Loss of vehicle control could occur if they continue to leak and degrade in performance.

• 11/21/2024· ENGINE

  The contact owns a 2022 Ford Bronco. The contact stated while driving at various speeds, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that a bent valve stem needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 103,000.

• 11/19/2022· SEAT BELTS

  Front passenger seatbelt buckle will not engage the latch plate. Vehicle was inspected by dealer after customer complaint. Dealer informed customer that seatbelt buckles were all inspected and working normally. This issue is still occurring on intermittent basis. Was told by dealer that it would not "accept a video showing the problem."

• 11/18/2023· SERVICE BRAKES

  Nearly every time I operate my vehicle I get a brake warning pop up on my instrument cluster. It definately happens every time cruise control is activated

• 11/17/2025· FORWARD COLLISION AVOIDANCE

  Adaptive Cruise Control was enabled and in use and the vehicle nearly rammed into the leading vehicle. The vehicle speed and distance became erratic and finally the vehicle had an alert that the ACC was unavailable. This was a very scary incident and could have resulted in a collision. an earlier model Bronco had a misalignment radar module recall but it appears my vehicle should also be included in this recall as well.

• 11/17/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2022 Ford Bronco. The contact stated that while at a complete stop, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact was almost struck by another vehicle due to the hesitation of vehicle. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue, and the mechanic was unable to duplicate the failure. The dealer confirmed that the failure was likely related to the recall; however, parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000.

• 11/17/2022· POWER TRAIN,ENGINE

  Bronco has less than 43 miles. Took vehicle on highway and went to go pass a semi and the vehicle lost all power. This could of caused a wreck if there was someone behind me trying to pass the semi as well. Took back to the Dealership and the turbo failed on my brand new Bronco. Please see Bronco6G for someone who is logging a list of other members that had similar issues. https://www.bronco6g.com/forum/threads/2-3-2-7-failed-turbo-list-7-counting-slowly-working-on-list.59162/

• 11/16/2023· ENGINE

  Driving down the road on 10/31/23, all of a sudden the entire vehicle started to shake, then the check engine light came on, then the vehicle started shaking even worse- losing power and sputtering. Pulled over and had it towed to dealer- Buckhannon WV- they checked the compression and found nothing. I am still waiting for someone to look at the vehicle's engine to determine the issue- I have not even owned this Bronco for 3 months when this happened. It only has 24000 miles on it. It left me stranded along the highway- my friend had to come and pick me up. I currently have no vehicle to get back and forth to work. Its sad that you pay such for a vehicle so you don't have to worry about getting back and forth and now it looks like I will be waiting for months- no Bronco and no one seems to be concerned.

• 11/14/2025· FUEL SYSTEM, GASOLINE,BACK OVER PREVENTION

  The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V312000 (BACK OVER PREVENTION) and 25V455000 (FUEL SYSTEM, GASOLINE); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure.

• 11/14/2022· ENGINE

  Brand New Bronco Black Diamond Edition. Driven 1000 miles and now engine will not accelerate. Loud noises coming from engine with multiple warnings from the app: 1) powertrain / 4 wheel drive fault 2) transmission Control module / electrical fault with transmission sensor and it’s associated wiring 3)power train control module has detected one of the transmission speed sensors readings is operating outside of the expected range for the vehicle

• 11/12/2024· SERVICE BRAKES

  AT 2.5 YEARS OLD AND 46K MILES THE VACCUM BRAKE BOOSTER ASSEMBLY HAS GONE OUT. THIS WAS ON ISSUE WITH THE BRONCO SPORT AND RECALLED, BUT NOT YET ON THE FULL SIZE BRONCO. SSM 50472 - 2021-2022 Bronco - 2.3L - Illuminated Brake Warning Lamp And/Or Brake System Warning Message – DTC P050F Set In The ABS Module And Firm Brake Pedal

• 11/09/2023· POWER TRAIN

  Ford is experiencing a problem under normal driving conditions on multi year Broncos (21' to current) that have very limited miles - with regards to the front pinion seal leaking badly (noticed during a routine oil change) and it appears to be IMHO a design flaw that not only impacts the seal but also the front differential, internal parts and possibly the axle. Any disruption to the drive train has the potential beyond just rendering the vehicle inoperable,..while driving in 2 or 4WD conditions, the impacts could be widespread. IMHO, Ford needs to look at the design and redesign and test. This has also happened multiple times on the same vehicle (from Bronco6G forum reports). In addition to the recall - Ford should immediately publish a TSB on this as wel

• 11/05/2022· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  Powertrain malfunction. Decreased power sent to powertrain. No turbocharge activation. Minimal acceleration, got up to only 45 on highway. Check engine light on, followed by Turbocharge wastegate malfunction. 6500 miles, 4 months old. 2.7L engine. Daily driver awaiting dealer service appointment. Not drivable.

• 11/01/2022· ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  Randomly the following takes place while vehicle is in motion at various speeds… Hill assist warning followed by (in rapid succession) pre collision assist not available, antilock brake fault Then the brakes momentarily give out then come back in non-powered mode which dangerously locks up the wheels when stopping System then resets itself Bronco6g forums have reported similar issues

• 10/31/2022· UNKNOWN OR OTHER

  We received a recall notice letter from our dealer, AutoNation Ford Bellevue, with instructions to call their service department. We cross checked our recall status by entering our vehicle's VIN on the NHTSA website's Recalls page and verified that there is indeed a recall associated with our vehicle. However, when we called the dealer, the dealer claimed that there is no recall for our vehicle in their system and refused to perform repairs. In our second attempt to contact the dealer, the service representative forwarded our information to an advisor, claiming that recalls with this campaign number must be scheduled by an advisor, but the advisor never called us back.

• 10/30/2025· SERVICE BRAKES

  I am writing to formally report a safety-related malfunction involving the parking brake system in my vehicle. The issue poses a significant safety hazard while driving and warrants investigation for potential design or manufacturing defects. During normal operation, the parking brake actuator malfunctioned, causing the vehicle to pull to one side and creating an unsafe driving condition. When I took the car to an authorized dealership, I was informed that the issue was due to a faulty parking brake switch. The switch was replaced; however, the malfunction persisted. Further inspection revealed that the parking brake motor and actuator needed replacement. Even after these repairs, while driving, the dashboard repeatedly displayed warnings such as: •“Parking brake engaged,” •“Please release parking brake,” and •“Parking brake system overheated.” When attempting to release the brake, the system would only disengage after manually pressing the release button, rather than automatically disengaging when the vehicle began to move — as it should. This malfunction not only causes confusion but also increases the risk of loss of vehicle control or brake system failure during operation. Given the repeated failures and persistent warnings, I believe this issue represents a potential safety defect that should be reviewed by your agency to determine if other vehicles are affected. Thank you for your attention to this matter. I look forward to your response and to ensuring this issue is properly addressed to prevent future incidents.

• 10/29/2025· SEAT BELTS,FUEL/PROPULSION SYSTEM

  My 2022 Ford Bronco has two active recalls for low pressure fuel pump failure and front seat height-adjust pivot bolt and link replacement with no available remedies. This vehicle has gone thru numerous recalls which I believe this poses a safety and financial hardship.

• 10/27/2023· POWER TRAIN

  The contact owns a 2022 Ford Bronco. The contact stated that while stopped, the contact noticed that the vehicle would not move after it had gotten towed. the wrench and service engine warning light was illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the failure was due to the transmission independently engaging and the transmission had overheated fluid, the transfer case had failed as well. The vehicle had been replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.

• 10/24/2022· SERVICE BRAKES,ENGINE,FORWARD COLLISION AVOIDANCE

  Vehicle reported Anti-Brake Fault. Vehicle reported Pre-Collision Fault. Vehicle reported 4 different hill start Assist Failures. I noticed the Pre-Collison feature did not work because the breaks never activated when there was a sudden merge into my lane going 65 miles per hour. The car says that the pre-collision feature is enabled but did not respond to a vehicle that came close to causing a wreck.

• 10/23/2023· SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

  The contact owns a 2022 Ford Bronco. The contact stated that with the cruise control activated, the brake pedal failed to respond as needed with the "Check Brake System" message displayed on the instrument panel. The contact was forced to disengage the cruise control or depress the brake pedal to the floorboard. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 58,000.

• 10/19/2022· EXTERIOR LIGHTING

  The contact owns a 2022 Ford Bronco. The contact stated while the vehicle was parked and not driven for more than 30 minutes, the headlights turned on independently. The contact stated that the failure had been intermittent however, the frequency of the failure had increased. The contact stated that the headlights warning light was illuminated. The contact stated that the four-position headlight dial could be rotated beyond the point where the markers on the dial indicated the level of lighting. The contact had not taken the vehicle to a local dealer. The vehicle had not been diagnosed and had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to NHTSA ID Number: 10214159 (Exterior Lighting). The failure mileage was 2,177.

• 10/17/2022· ENGINE

  Conducting the Bronco's 1st oil change at 5,003 miles at my home and the oil pan has missing or damaged pins/tabs that guide the oil plug out of and into the oil pan. When I turned the hand plug counter clockwise it did not ride out on the pans internal pins/tabs, it stayed fully seated and rotated fully to the stops. Was able to just just twist the the plug from stop to stop while fully inserted. Pulled the plug straight out and drained the oil. Once oil was drained tried feeling in the drain plug hole for any type of pin/tab that the plug is designed to guide in and out on and felt none. Did not see any damage to the plug.

• 10/17/2022· POWER TRAIN,ENGINE

  The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud knocking sounds. The vehicle was towed to the dealer where it was diagnosed with metal shavings in the engine oil and filter. The dealer performed an oil change and informed the contact that the two transmission pumps and the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 60.

• 10/17/2022· ELECTRICAL SYSTEM,SERVICE BRAKES

  The 2022 Bronco is listed as being able to be flat towed behind a motorhome and the software allows it to be put into flat tow mode. 49 states require that flat towed vehicles over a certain weight have supplemental braking. When the supplemental brake system is installed in a Bronco with the 2.7 liter engine it stops working correctly after 45 minutes because the electronic brake booster shuts off. This results in the supplemental braking system not having enough power to activate the brakes and can cause a serious accident because the motorhome cannot stop soon enough. Ford issued TSB 22-2210 to temporarily correct this issue but it simply disables the electronic brake booster (must remove fuses) and again leaves the towed vehicle with insufficient braking. Ford claims they are working a software update due out in September 2022, it is now mid October and no recall has been issued.