2022 BMW X3

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/18/2025· UNKNOWN OR OTHER

  On 12/17/25, I was driving on I-10 in New Orleans, there were no cars around that could have kicked up a rock to cause the sunroof to explode. When the sunroof exploded, I immediately pulled over and that is when I first noticed the strong smell of residue and then I heard the glass shattering. The cover to the sunroof was closed because if not, glass would have been all over me causing a major accident on major 4 lane interstate. The heat was not on to cause any type of pressure to make it explode. When I pulled over, I called 911 and Louisiana State Police answered the call. When the officer arrived he looked at the situation and he could not see a rock, bullet, or anything that would have caused it. Since he could not find anything that caused the issue, he was not able to do an incident report but told me to take it straight to the dealership. The vehicle has been to two different BMW dealerships where I have been told warranty does not cover this issue even though there are multiple reports about this being a normal occurrence with BMW after a 7 year investigation. There were no warnings before this incident. I could have killed myself along with others if I would have lost control of the car due to the car shaking with the sunroof exploded. The vehicle is able to inspected upon request if needed while it sits at the dealership. This vehicle was also bought on 10/27/25.

• 12/17/2025· POWER TRAIN

  Transfer case fluid has been replaced as well as drivetrain fluid in the front and rear and and the car is still having slight issues shuttering when stopping.

• 12/10/2024· STRUCTURE,LATCHES/LOCKS/LINKAGES

  The contact owns a 2022 BMW X3. The contact stated while driving 10 MPH, the contact looking in the rearview mirror and became aware that the tailgate had opened. The contact pulled over and closed the tailgate. The contact stated that while entering the garage, the tailgate opened unintendedly. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 51,000.

• 11/18/2025· LATCHES/LOCKS/LINKAGES

  The driver side rear door locking mechanism keeps locking, even when the car is unlocked with the key fob. This is a safety concern, as our granddaughter rides in the rear seat regularly and if an emergency arises where I need to get her out of the back seat quickly, the rear door can stay locked and not allow me to get her out. There were no warning notices for this issue on the dashboard system.

• 11/14/2025· UNKNOWN OR OTHER

  windshield glass excessively weak and prone to crack and chip. yes, a weak (defective windshield) has great safety concerns. yes, Safelight glass repair has repaired this windshield several times in 2 months. yes, we have recently brought this vehicle to a BMW service center. no warning light for this issue. There are several websites that confirm there is a significant problem with the windshield on this specific make. model and year.

• 11/08/2024· STRUCTURE

  The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/06/2024· STRUCTURE

  The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.  

• 11/03/2021· ELECTRICAL SYSTEM

  When a door or hatch is opened, the car horn is continuously activated for up to two minutes. No switches or key fob buttons deactivate the horn. The dealer service department thinks it is a defective switch or relay in the steering column. The vehicle is underivable because of he loud noise of the horn. It risks damaging hearing, making other sounds undetectable, disturbing others including drivers, pedestrians, and neighbors (one called me to complain, thank you). It also puts one at risk for violent road rage incidents.

• 10/27/2023· FORWARD COLLISION AVOIDANCE

  Adas camera bracket on windshield deformed due to heat. The bracket will no longer hold the camera and the deformation was so severe it broke the mounting tab that holds the adas camera.

• 10/21/2024· STRUCTURE

  The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/19/2022· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  While driving on the highway my rear hatch opened and I was not given any warning that the hatch was open. My car was full of luggage on our return trip to florida and I could not see that the hatch had opened. We lost boxes that were in the trunk. It could have been a lot worse if we were not notified by passing drivers that something was wrong with my car. Looking for previous issues this happened in 2019 for my model car, BMW X3. I do not understand why this has happened again.

• 10/18/2023· FORWARD COLLISION AVOIDANCECrash

  The front collision warning failed and had not given any problem prior to the failure. We were in a car accident where a person turned left (we were going straight) and passed right in front of us when we hit them. The Forward Collision Warning did not display and our vehicle was deemed a total loss by the insurance. We may of avoided the accident if the sound and display of the warning had triggered.

• 10/17/2022· FORWARD COLLISION AVOIDANCE

  - Bracket holding KAFAS camera system to windshield failed causing Driver Assistance system errors in vehicle; surrounding area gets very hot to the touch - System errors restricted certain driver assistance features including collision warnings - Problem was found by two dealerships; first dealership denied claim, second repaired via windshield replacement - Service advisor mentioned another vehicle had similar failure - BMW forum (Bimmerpost) confirmed several identical failures

• 10/15/2024· SEAT BELTS

  The front passenger seats warmer is not working. In spite of multiple attempts to get it fixed from BMW of Denver Downtown has not fixed the issue. This can have serious impact during winter weather

• 10/14/2024· UNKNOWN OR OTHER

  BMW has a safety recall on my vehicle for over two months now with no fix available. I am in the process of moving to Japan and need to sell the vehicle. BMW is prohibiting a lease transfer or sale until the vehicle is fixed, but they cannot fix it. Meanwhile I lost a potential buyer and BMW wants to charge me an early lease termination fee of over $6000 but they will not fix the vehicle and they will not allow me to sell or complete a lease transfer. BMW should accept this vehicle back without charging me extra money for a lease termination fee on a defective vehicle.

• 10/02/2024· STRUCTURE

  The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/30/2024· STRUCTURE

  The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/28/2025· ELECTRICAL SYSTEM

  Starter

• 09/27/2025· UNKNOWN OR OTHER

  I am a [XXX] male who has been driving for [XXX]. I am very familiar with cars. I recently experienced a situation which could be catastrophic for anyone, especially children. I was sitting in the car on a moderately cool day with the sun shining very bright. I was in a parking lot parked in a remote location. My wife, who was driving went into a store to shop. She took the FOB with her. She shopped longer than expected. The car's interior started to heat up and eventually I realized i was in a very dangerous situation. I could not open the doors or windows without the FOB. I was considering kicking out a window when my wife returned to the car and opened a door. She later went to the dealership and was told there is a special procedure one most follow to unlock the doors without the FOB being present and someone in the car. This is a ridiculous situation which could become tragic if a child was involved. The simple remedy would be to have the interior locking pin for each door extend far enough beyond the door panel so one can unlock the door in an emergency like they did in the "old" days. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 09/27/2024· STRUCTURE

  The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/26/2024· STRUCTURE

  The contact owns a 2022 BMX X3. The contact received notification of NHTSA Campaign Number: 24V534000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/20/2025· ENGINEFire

  While driving, noticed smoke coming from under the hood. Immediately pulled in a parking lot where the smoke turned to fire and burned the entire car by the time fire dept arrived. I was the only person in the car and was luckily able to exit the vehicle before the actual fire started. Incident reported to insurance company and they are investigating. There were no dash warning lights of any kind.

• 09/18/2024· STRUCTURE

  The contact owns a 2022 BMW X3 The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/15/2023· LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

  The BMW front facing kafas camera system is prone to failure in the BMW X3. The plastic piece that holds the camera module in place has small plastic tabs that attach it to the windshield. These tabs are prone to breaking. Once the tabs break the front camera system is no longer in alignment and all front safety systems will be disabled. This puts the occupants of the vehicle in danger as all front facing safety systems will be disabled. The dealers do not want to warranty these failures as they try to pass it off as the fault of the owner. The first dealership rejected my issue saying that since my vehicle has a modified suspension that the camera is not able to calibrate which is incorrect. The second dealer I took it to saw the problem was the failed plastic mount but since my front windshield is aftermarket UV rejecting film it must have been damaged by the individual that installed it. This is not the case since the film did not extend behind the plastic pieces covering the electronics. In order to get this issue fixed I to pay out of pocket $2000 even though my vehicle is still under warranty. This issue has been reported by several people on various BMW forums.

• 09/06/2023· LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

  Mount for BMW KAFAS camera melts/deforms in the heat (normal exposure). This causes the camera to become uncalibrated and disables Pedestrian avoidance braking as well as lane keep assist. I am unsure what other functions are unavailable. After 2+ months of waiting for a new part, the BMW dealer nor BMW NA could not give a timeline on when the windshield/mount would be available for replacement. This means that the safety features that were advertised and paid for by the owner are unavailable to the owner for an indeterminate amount of time. Forum participants indicate that this is a common problem with this model with some owners experiencing multiple failures of this safety system in a short period of time during summer months.

• 09/06/2023· FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  There is a failure with the camera not being able to calibrate and a number of error messages

• 09/06/2023· LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

  The main windshield bracket holding the front camera (responsible for Driver's Assistant including front collision warning, pedestrian warning, lane departure warning, etc.) has the tendency to break on its own. The bracket is made of thin plastic and can melt under direct sunlight and/or usage of vehicle as the camera gets hot as well. Any reasonable exposure or usage will eventually cause the bracket to melt/deform and fail, causing the camera to fall from its original position. The misalignment of camera will cause a cascade of error codes and completely fail to work, rendering the entire safety systems to be useless. The bracket itself is not sold separately and requires the manufacturer to install a completely new windshield which is the only method of fixing this issue. Manufacturer and/or dealerships refuse to warranty if preventative methods are used (such as windshield tint) even though the camera or mounts remain untouched.

• 08/27/2025· STEERING,ELECTRICAL SYSTEM,SERVICE BRAKES

  When starting the vehicle, the message center displays "Loss Communications Brake System Control Module A." The vehicle losses power steering, speedometer indication, tire pressure monitoring, and stability control. There are numerous codes displayed for Brake System, Power Steering, Parking Brake and Stability Control. This is the third time that this event has happened. Turning the vehicle off and restarting after approximately 1 hour the codes were clear and everything appears to work properly. This event occurs randomly and resets after the vehicle is turned off and restarted after a period of approximately 1 hour. The loss of power steering and speed indication is a safety hazard. I have been driving this vehicle when the power steering and speedometer stopped working. The steering requires a lot more effort to turn and you do not know the current speed of the vehicle. The BMW dealer charged us the customer for a software update to fix this issue. We are not confident that the vehicle is fixed because this is a random event. I believe this should be a safety recall. There is a recall on BMW 2023 and 2024 models for the same issue. The recall does not include the 2022 model at this time. Codes displayed: U0129, U0418, P15C9, P15C8, P15B9, P15B8, P0507, P0610, P152B, P152A.

• 08/18/2024· UNKNOWN OR OTHER

  I am filing this complaint regarding the recall on my 2022 BMW X3, which involves the interior rear cargo rails. The recall, added to the NHTSA database over a month ago, indicates that in an extreme rear crash, the attachment between the rear cargo rail and the vehicle body could become damaged. This issue could lead to the rail separating from the vehicle body, increasing the risk of injury. Despite the significant safety risk outlined in the recall, there has been no update on when repair kits will be made available to service centers to begin the necessary repairs. This delay in providing the remedy is causing concern as it leaves my vehicle potentially unsafe for an extended period. I urge the NHTSA to look into the timeliness of this repair process to ensure that the necessary parts are distributed promptly to mitigate the associated safety risks.

• 08/04/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  I believe there is a flaw in the architecture of start-stop technology in conjunction with the electronic shifting technology installed in cars today.. I have ran into this issue twice in a 18month period and I believe it is something the NHTSA should institute new requirements on car manufacturers. My wifes BMW X3 start stop technology has failed twice in 18months and that is not a big deal. Things break and need to be repaired but given the car can not be put in neutral it left us stranded unable to move the vehicle in the middle of the road until a tow truck could move us out of the road. I could have easily put the car in the neutral (if allowed) and pushed the car off to the side of the road out of traffic. Luckily in both occasions a police officer pulled up very quickly and was able to alert traffic there was a vehicle stopped in the middle of the road. I want you to imagine being in stop and go traffic on highway 95 and this happens. Then the traffic actually dissipates and your vehicl is in the middle lane on hwy 95 unable to be moved until a tow truck arrives and now the traffic is going 65-70 mph. The BMW X3 can not be place in neutral unless you go underneath the car in some sort of service panel. I do not believe given the mandate of auto-stop start on these new cars coupled with the inability to place cars into neutral is a good design point and I would hope the the NHTSA would mandate cars be able to put cars in neutral to avoid potentially catastrophic accidents on the highways across America..

• 07/31/2025· TIRES

  Subject: Tire Safety Concern – BMW OEM Pirelli Cinturato P7 All Season (UTQG 500) 245 50 R19 I am writing to raise a serious vehicle safety concern involving the BMW OEM Pirelli Cinturato P7 All Season tires that came factory-installed on my leased 2022 BMW X3. These tires are labeled with a UTQG 500 treadwear rating, which typically implies a lifespan of 40,000 to 50,000 miles. Yet, all four of my tires were found to be severely worn and unsafe at just 23,456 miles. More troubling, I began experiencing significant handling and traction issues as early as 18,000 miles. During normal driving—without aggressive braking, cornering, or high-speed use—the car exhibited: Hydroplaning in moderate rain Slipping and sliding under light acceleration Noticeable vibration and poor stability on dry roads These symptoms were initially confusing until a routine service appointment at Motorwerks BMW in Bloomington, MN revealed that all four tires were nearly bald and posed a safety risk. The dealership confirmed the tread depth was between 1 and 2 mm—well below the safe limit—and told me, alarmingly, that this level of premature failure is typical for this tire. This raises two critical safety issues: The tires were functionally unsafe well before 20,000 miles, long before I was aware of the degradation. The UTQG 500 label creates a false sense of security. A consumer would not expect traction loss or hydroplaning risks within the first 18,000–20,000 miles of normal use from a 500-rated tire. I have since learned that this OEM tire, while labeled identically to the Pirelli Cinturato P7 All Season Plus sold at retail, is actually a different tire made specifically for BMW. It carries no treadwear warranty, despite its 500 label, and reportedly has never been separately tested to confirm its rating. Both BMW and Pirelli have pointed fingers at each other, offering no solution or responsibility—leaving consumers with unsafe tires and no remedy. I urge NHTSA to investigate this issue.

• 07/15/2026· VISIBILITY

  - Customer Reports: ac not cooling, stopped cooling yesterday while on the highway, approved evac and recharge if needed Caused by Leaking a/c hose from compressor to condenser Tech: CHRISTOPHER ARCHER (F88) Installed 64 53 9 868 421 : B1-Pressure hose assy c Installed 64 53 9 284 018 : B1BIMIRRZN-Gasket ring Confirmed concern. Performed vehicle

• 07/10/2026· POWER TRAIN

  belt tensioner failed while on highway without warning, leading to complete shutdown of the engine. Car had to be towed for repair. Complete disintegration of the timing belt, the car only had 51,000 miles. Expensive repair

• 07/09/2026· EQUIPMENT

  The contact owns a 2022 BMW X3. The contact stated that while driving at an undisclosed speed in hot weather, the air conditioner failed to operate as intended. The vehicle was taken to the dealer, where it was determined that the air conditioner line was rubbing against a pulley, presenting a fire hazard. The contact was informed that the air conditioner hose needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

• 06/25/2026· STRUCTURE

  On June 23, 2026 around 3:30pm, we were driving 70 mph on an interstate (I40) and the panoramic sunroof spontaneously shattered on our BMW X3. We were not struck by anything and there was no inclement weather or extreme heat. The sunshade was pulled so we were not hit by the glass, but we were very much in danger. My baby was in the backseat and he would have had glass all over him. We had to pull over on the highway and had to arrange for another car to take us home.

• 06/14/2024· LANE DEPARTURE,TIRES

  This BMW vehicle's odometer readings are inconsistent and inaccurate resulting in overage of mileage for lessee. This cars BMW tires were not verifiable to be from BMW and tires subsequently failed within 15,000 miles. No entity at BMW, not the dealership, not the sales, not BMW Financial Services or BMW of North America LLC could provide any information regarding the original tires or provide any warranty information regarding the tires - this impact mileage efficiency, miles per gallon and is a way to game the systems. BMW front sensors on act erratically sometimes working and sometimes going off without anything present, during rain/snow sensors would constantly go off for no reason. Issues have been raised through certified mail to BMW and all have been ignored. There is no accountability regarding the tires with no warranty that fail, inaccurate odometer readings, car sensors and we request an investigation into these three matters.

• 06/14/2023· FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  The clips that hold the KAFAS camera system are faulty and easily break. The KAFAS unit gets exceptionally hot and damages the clips causing the unit to go out of alignment and then cause all of the safety features to fail. The fact that you have to replace the whole windshield to repair two small plastic clips is an egregious mechanical design failure, waste of resource, and just insane design.

• 06/13/2022· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,LANE DEPARTURE

  instrument cluster sporadically working. front collision and lane departure not working when the cluster isn't working. unable to judge speed accurately, Yes problem has been reproduced by Sandy Sansing BMW in Pensacola FL.no the part hasn't been inspected.no other warmings but have had warnings since that the driver assistance restricted. Frontal collision warning, pedestrian warning . I have been given a time frame to fix this as completly unknow- forcing me to drive this car without working instruments.

• 06/07/2023· POWER TRAIN

  After taking off from a stop light, heard a loud bang and after taking it to the dealer it turns out to be a broken rear right axle and diff retaining bolt. My car is a 2022 MY with 20k miles on it. This was the first time I have done a "hard launch". The car is bone stock, with no modifications whatsoever and all maintenance and repairs done at the bmw dealership. I am going after a warranty claim as this should be covered.

• 06/06/2023· POWER TRAIN

  The contact owns a 2022 BMW X3. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently decelerated while the accelerator pedal was depressed. The service vehicle warning light was illuminated. The contact stated that a message displayed on the instrument panel “Drivetrain Malfunction”. The vehicle was taken to the dealer however, the cause of the failure could not be duplicated. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 11,712.

• 06/04/2026· ENGINE

  car starts emitting white smoke with plastic burning smell inside car and outside. no notifications on dash board before this happens therefore emitting this white smoke into car which we are subjected to inhaling further

• 05/23/2026· UNKNOWN OR OTHER

  regarding my 2022 BMW X3 due to ongoing issues involving low coolant warnings, coolant leaking, and repeated cooling system problems shortly after reaching approximately 55,000 miles. My vehicle began displaying “low coolant” warnings and has required frequent coolant refills despite normal driving conditions and regular maintenance.the vehicle appears to have an active coolant leak and ongoing cooling system malfunction that has not been permanently resolved.

• 05/21/2026· UNKNOWN OR OTHER,ENGINE

  The oil filter housing failed and needed to be replaced due to be leaking coolant.. after changed that the failure of the water pump started to failed and engine started to spike high temperatures..

• 05/21/2025· ELECTRICAL SYSTEM,LANE DEPARTURE

  Vehicle: 2022 BMW X3 sDrive VIN: [XXX] Incident Date: [XXX] A BMW dealership technician discovered that the rear radar sensor (used for blind spot detection) was misaligned due to impact damage behind the bumper. The inspection notes stated "fault present 35 times" and showed missing screws and signs of prior repair. These safety features are critical to safe lane changes and accident prevention. The vehicle was sold as Certified Pre-Owned, and the dealership never disclosed this safety-related defect. This raises serious questions about whether the vehicle had been in a prior collision and whether the blind spot safety system is fully functional or properly calibrated. The dealership later claimed the vehicle was repaired but refused to provide documentation. I have no way to verify the sensor was ever fixed to federal safety standards INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 05/19/2023· SERVICE BRAKES

  The break pads wore out on the car at around 16,000 miles. Generally brake pads are supposed to last 35,000 to 40,000 miles. My sister in law has a BMW 4 series and their cars brake pads wore out at around 15,000 miles. I'm sure there are thousands of other BMW owners who have been experiencing this same issue When the dealership was confronted they admitted that BMW has changed to a different "softer" type of brake pads and they are regularly seeing that This should be considered as a defect and the cars recalled because BMW knowingly changed their brake pads to save money and has been installing cheap brake pads that don't even last 1/2 of what regular brake pads last BMW knowingly did this because before their service included the brake pads to be changed within 3 years or 36,000 miles. They removed the brake pads as part of the service included within the 36,000 and started selling additional warranty for the brake pads This would confirm that they knew the new brake pads that they were going to be installing were cheaply made and they were going to have a lot of people coming in to get them changed within the service time period of 36,000, so they removed that as being included and starting selling additional warranty for that. The NHTSA should have minimum standards for car parts across the board, so that BMW doesn't take advantage of their customers and install cheap parts so they can make more money We have leased/owned BMW's for 15+ years and have never had this issue. Since this was done on purpose by BMW, there should be a recall issued for the defective brake pads that they have been installing

• 05/13/2026· ENGINE

  Oil Filter Housing leak confirmed on my 2022 BMW X3 M40i. My current odomoter reading is at 47K miles and I was told that I could have a catastrophic failure of my engine if not repaired. I am several weeks out of my warranty expiration date and am frustrated that BMW won't honor a warranty claim for an issue known to take a long time to find symptons before being able to fix.

• 05/07/2024· STEERING,SUSPENSION

  I purchased by 2022 BMW X3 new in September of 2021. Since then I have had re-occurring safety issues with the car involving steering and suspension components. I've had the front thrust rod replaced at least three times. The vehicle clunks when in reverse and consumes front tires. I had to order front tires for the car with only about 15k miles on them. I had the vehicle alignment checked multiple times and was informed that the car is in correct alignment specs. My biggest frustration is that BMW consistently lies to me and does everything in it's power to deny that there are issues with the vehicle. The thrust rod issue is a known issue which has multiple technical service bulletins. They actually re-engineered the part because it was designed so poorly that they constantly break. BMW, of course, has tried to hide this information and denies that there is anything wrong with the component. I was informed that they would be placing a re-engineered part on my car once it was available - however they had no ETA according to the dealership because BMW needs so many of these parts to replace their faulty components. When I refused to pick up the car suddenly a re-engineered part was available. I have dozens of service invoices for this issue and e-mails with the dealership and BMW representatives lying and covering up information to prevent a recall of their substandard vehicle. Recently, my steering wheel has started to get "stuck" while driving. I have to use brute force to move the wheel which results in erratic maneuvers on the highway. I brought the vehicle back to BMW who, as usual, said there is nothing wrong with it. When I refused to drive the car due to safety concerns, suddenly it needs a new steering column. Upon research, this is also apparently a huge issue with the X3's. My vehicle has proven unsafe to drive and BMW has no concern about my safety or welfare. I have a lot of evidence and service invoices if needed.

• 05/06/2025· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEMFire

  On April 26, 2025, while driving my 2022 BMW X3, the vehicle suddenly emitted smoke and caught fire. Fortunately, all five passengers, including myself, were able to exit the car before it became fully engulfed in flames. The car was destroyed and is a total loss. The BMW app later displayed a “drivetrain malfunction” message, which did not appear until after the fire had already started. The vehicle was still under the manufacturer’s 48-month new vehicle warranty and had no open recalls at the time. Routine maintenance and service had been performed at authorized BMW dealerships. I am concerned this fire may have resulted from a manufacturing defect, especially in light of similar reports and recalls involving fuel rail cracks or leakage in this model/year. No injuries were sustained, but this was a terrifying and traumatic incident, and I am now left with significant financial loss. What I am requesting: I ask that NHTSA investigate whether this fire was caused by a manufacturing defect common to the 2022 BMW X3 and whether a broader recall or corrective action is warranted

• 05/04/2022· UNKNOWN OR OTHERFire

  My BMW X3 was less then 1 month old with less then 200 miles. On the way home around 11PM I noticed sparks and some coming out the hood. I pulled to the side of the road and as soon as I stepped out of the car flames were coming out from under the car, drivers door. Called 911. Police and fire department showed up within 10 minutes. The fire was put out unfortunately the whole car melted by then. I'm glad I escaped unhurt. Few minutes more I could have been seriously hurt or dead.

• 04/30/2026· UNKNOWN OR OTHER

  While driving, my sunroof spontaneously exploded/shattered and rained glass onto me while driving.