2021 KIA Seltos

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2024· ENGINE

  My 2021 Kia seltos has a flashing engine light and when put on a code reader it indicates a misfire/ piston. This has been going for two weeks . My engine is a 2.0 and the recall for this vehicle has the same incident as mine. The engine keeps shutting off

• 12/30/2022· ENGINE

  The contact owns a 2021 Kia Seltos. The contact stated that the low oil pressure warning light was illuminated. The contact stated that after every 1000-miles of driving, she had to add 1 quart of engine oil to the engine. The vehicle was taken to the dealer where an oil consumption test was performed. The contact was informed that the piston rings needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 11,000.

• 12/30/2021· ENGINE

  Im on my 2nd kia and im so over it. I have a 2021 kia seltos and i took it in for the recall and my scheduled maintenance for july 9th 2021, I scheduled my app a week out and i had been noticing my engine running strange off and on for awhile but its a new car so i thought i was being paranoid until i saw the recall. Then the day before my appointment the check engine light comes on. I checked the oil and it didnt even register on the stick, had my dad also check it to confirm! He added 2 quarts to it just to get me to the next day. Take it in and tell them my light has come on now and that its been running rough. When they call they say nothing, pick up my car they tell me nothing! The notes say the piston oil ring was performed? What was performed? It passed the recall test? What are they looking for? Why was my check engine light on?! And then i read in the notes that the oil was dirty and 3/4 of a quart below fill mark. It also says .i have a maintenance package on a new car..i take it in when im supposed to and only to kia. It also said cel is not on at this time and ran fault code "p0011- intake timing over advanced" stored as history and that they cleared dtc reset adaptive values and further diag will bbe required if dtc returns..no one seems concerened why i have a code stored in history or why the light was on one day and off another. It still sounds terrible most of the time and the oil level is magically decreasing and no signs of a leak took it in 10/6/21 and they say they check it out and that nothing is wrong and send me on my way. 12/6/21 go in for oil change multi point inspectionand winterization and they tell me they also need to check a recall...all good again. 12/30/21 driving my car and my check engine light starts flashing while im driving about 55. Its at the shop now! Im beyond stressed and heated over this. I have 2 toddlers i drive around in this car. I need it to be SAFE and RELIABLE! Im paying way to much for this car to be dealing with

• 12/29/2022· ELECTRICAL SYSTEM

  2021 Kia Seltos ~50,000 miles. My horn doesn't work. I live in Tampa, so definitely need a horn. Also my infotainment center is trash. It works perfect about 30% of the time. The other 70%. Oh well where do I start? It will completely freeze, the screen turns black, when I get a call in, oh boy that's a showdown. It'll freeze, then I have to grab my phone, and answer it. Can't even use the BT (Bluetooth) in the car, I've used both Android Auto, and Carplay. It doesn't matter it's still terrible. It's unresponsive to touch about 90% of the time. Absolute trash. I've only had this car for a few months (I'm the second owner), and I can see why that last owners got rid of it. I've had nothing but issues out of this car. If I wasnt screwed by the dealership and payed 20k more than it was worth, I would have done traded the stupid thing in. I'm honestly thinking about trading it in to a Tesla, and just transfer all the negative equity over. Yea it'll cost an arm and a leg, but atleast I'd have something I'd like.

• 12/29/2021· ELECTRICAL SYSTEM

  The entire electrical system (display, gauges, exterior lights, etc.) resets while driving. This may be a one off or may happen several times in a few minutes. The engine never stops running, which is good as this happened in the interstate. In the dark, this could be dangerous as the headlights and taillights go out for a moment. I am not aware if this is easily replicated or if this poses issues to other systems.

• 12/27/2023· POWER TRAIN,ENGINE

  esta quemando aceite de motor muy rapido y antes de tiempo. mientras se utiliza esta lento y cuando sube cuestas muy pesado tiene que hacer mucha fuerza.

• 12/27/2021· ENGINE

  The car shut off completely while driving without warning. The car was restarted and the check engine light turned on.

• 12/26/2024· POWER TRAIN

  Came to a stop at an intersection on a busy highway, went to accelerate and turn left when the transmission locked without warning. Vehicle would not shift into gear.

• 12/24/2021· STEERING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  The car sometimes will be locked in park and unable to move. Sometimes the dashboard lights up with all error lights and auto shuts the car off in the middle of driving. Sometimes on the highway, the speed notifier goest to 0mph when I am going atleast 65-70mph.

• 12/21/2021· SERVICE BRAKES,ENGINE,FUEL/PROPULSION SYSTEM

  July 2021, While my son and daughter were driving the car engine shut off, the brakes, the gas pedal and steering wheel locked. The vehicle was on a slight incline and rolled backwards. My son quickly pulled the emergency brake in order to stop the vehicle from going into the vehicle behind him. The vehicle was restarted and all the problems were gone. We brought the vehicle to the dealer. They checked and found nothing wrong and could not recreate the problem. At the same time the dealer performed the recall 21V259 (letter dated 6/11/2021) which was rectified by performing an engine vibration inspection which passed. At that time we also reported a ticking sound coming from the engine which the dealer stated is a normal noise from the injectors. A NY state inspection was also performed and passed.

• 12/21/2021· POWER TRAIN

  TRANSMISSION FAILURE REQUIRING TRANSMISSION REPLACEMENT. After approximately 17,700 miles the engine surged and the check engine light illuminated. After the vehicle was stopped, the transmission would no go into reverse. Vehicle was towed to Kia dealer service department, Diagnosis was transmission failure requiring complete transmission replacement.

• 12/19/2020· SUSPENSION,UNKNOWN OR OTHER

  NO MATTER WHAT SPEED, CAR WILL RANDOMLY JERK FROM LEFT TO RIGHT, FEELING LIKE DEATH WOBBLE. AT HIGHER SPEEDS MORE THAN 45MPH THE CAR WILL VIOLENTLY JERK FROM LEFT TO RIGHT, FEELING OUT OF CONTROL. KIA DEALERSHIP ON CENTRAL AVE IN ALBANY NY USA NOTIFIED, SAID THE ALIGNMENT WAS OFF AND PASS REAR CAMBER BOLT IS BENT. STATED THEY DID AN ALIGNMENT FOR THE FRONT TWO AND THE LEFT REAR BUT NOT THE RIGHT REAR, PROBLEM IS NOT FIXED.

• 12/16/2025· FUEL/PROPULSION SYSTEM

  Can smell gas fumes in and around car. Afraid to drive. Took to dealer. Fuel pump and associated gaskets fittings needed to be replaced. Not cover under 10 yr, 100K warranty even though the vehicle only has 83K miles. Just to right.

• 12/16/2025· ENGINE

  This 2021 Kia Seltos car’s engine has randomly seized up 4 times over the last year causing very serious safety concern. Fortunately, these 4 seize-ups happened when the powerless Seltos car could be safely directed to the shoulder of the road while driving in slower paced traffic. Each time this occurred, our 2021 Kia Seltos had to be towed; towed twice to a mechanic shop and twice to directly to the dealer. The mechanic diagnosed the problem as the vehicle using excessive oil resulting in the vehicle safety sensors shutting the engine down. However, in those instances when we towed the vehicle to the dealer, the dealership always obfuscated and gave us the impression that they were not taking our safety concerns seriously. They never adequately addressed our concerns and often conducted some minor repairs seemingly to placate us to get us down the road. None of their minor repairs worked or solved the problem. In each instance after their repair the problem repeated. We expressed our extreme frustration and concern for our life safety. We communicated to them that this vehicle’s engine has proven unsafe and that has randomly seize-up several times We have researched the 2021 Seltos and found that these Kia models have many serious recalls for multiple items including the problem that we have experiences with excess oil usage. It is our experience that our KIA dealership will not adequately address our concerns and will not take necessary measures to adequately address our very serious safety issues. We believe that our 2021 Seltos is a "Lemmon" and needs to be replaced, or at least its engine replaced. We hope this complaint results in serious action and that I'm not writing again indicating that this 2021 Seltos “Lemmon" vehicle has again seized up and has resulted in a life-threatening safety issue.

• 12/15/2025· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  THE CAR WAS MAKING A GRINDING SOUND, VIBRATES, SLOWS DOWN. GRINDING SOUND IS LIKE GRINDING GEARS OR A SNOWPLOW SCRAPING PAVEMENT. THE ENGINE WAS REPLACED IN APRIL BECAUSE OF RECALL. I ONLY HAVE 23765 MILES ON IT BUT ORIGINAL 5 YEAR WARRANTY EXPIRED ON 12/09/2025. THE SAME NOISE STARTED AGAIN ON 12/10/2025 AND IT WAS TOWED TO DEALER I BOUGHT FROM ON 12/10/25. The master warning light came on 12/10/25 incident and some text. There was traffic so unable to read it and light went off.

• 12/15/2021· UNKNOWN OR OTHER

  I took my car 4 times to the dealer telling them it shut off. N they refused to do more work on the car due to they could not recreate the incident. Means they went ahead and put me in danger.

• 12/13/2025· ENGINE

  Car had 59,522 miles when I purchased it (now has 64,320), and after driving 1,500 miles, it began hot-idle stall with oil light indicator lit. Restarted and drove OK, but when slowing, it kept stalling. This also happened on the roads when slowing for a light or for traffic, posing a risk to myself and others. After 6-7 times and doing some research, this problem exactly matches the symptoms in Kia’s TSB ENG222 Rev 6. I had it towed to a KIA service center due to the concern that it can throw a bearing during stall (as well as be unsafe). Dealer performed combustion chamber cleaning and replaced the PCV valve ($1,000!). They asked me to keep a close eye on oil consumption. Over the next less-than-1,000 miles of driving, engine consumed 3 quarts, well in excess of Kia’s expectation of no more than 1 quart per 1,000 miles. The dealer contacted Kia’s technical assistance for help and was denied an engine replacement due to me being the second owner, out of power train warranty and just purchasing the vehicle, as well as indicating that the engine had previously been “fixed” pursuant to the TSB; however, clearly it is not fixed. I now unfortunately know that this problem is associated with the poor design of the engine and up to 20% of the owners who have had the problem “fixed” continue to have the same problem recur. The engine has barely more than 60,000 miles on it and was maintained, according to CarFax, rather flawlessly by the previous (and only other) owner. There is no way that properly built and appropriately maintained engine should fail with less than 60,000 miles on it unless there is something inherently wrong with the design or build of the engine. It also seems like a huge copout on Kia’s part to not honor their 100,000 mile, 10 year powertrain warranty simply because the car transferred owners (once), especially with the history of known appropriate servicing AND that the car’s engine has already failed the repair directed by TSB ENG222 Rev 6.

• 12/11/2025· ENGINE

  I took my car to the dealership for the recall fix on its engine where they put the noise sensors in. I told them my car was burning oil and my car check engine light came on so I took it back in. Just before going in the light went off, but the code was for a misfire in cylinder 2. They did could not recreate the misfire and sealed my engine and told me to bring it back in 1000 miles. During this time the check engine light came on and went off again for the same code. When I brought it back at 1000 miles they could not recreate the misfire and said my car burned 0.77 quarts of oil in 1000 miles and in order for the engine to be bad that it needed to burn 1.0 quarts in that timeframe. They resealed the engine and I am to bring it back again in 1000 miles. A car should burn next to nothing for oil in 1000 miles. So my engine could burn out almost all its oil before a regular oil change and burn up the engine unless I keep adding oil. I am betting the cylinder misfire is because of oil fouling the plug. I could be on the highway and my motor could stall or blowup from lack of oil. Their recall fix is a joke and saying a regular gas enginecan burn up to 1 quart of oil every 1000 miles is ridiculous. This and every car with this engine problem should have the engine properly repaired or replaced

• 12/11/2021· POWER TRAIN,UNKNOWN OR OTHER

  My car Cutts off while driving especially when I’m Turning happening more frequently now it’s shuts off all dash lights come on and I have to put it back in park and start it up agian

• 12/09/2024· POWER TRAIN

  Transmission unreliable. While crossing a 4 lane highway the engine revved but would not engage.

• 12/07/2020· POWER TRAIN

  AT 5,800 MILES, MY SELTOS SUDDENLY STOPPED ACCELERATING WHILE IN MOTION. RPMS SHOT UP TO 7 AND 8, AND THE CAR WOULD NOT GO ABOVE 35 MPH. THE ENGINE WAS GRINDING. I GOT THE CAR TO THE DEALERSHIP AND WAS TOLD THE TRANSMISSION NEEDS TO BE REPLACED. I WAS ALSO TOLD THERE IS NO TRANSMISSION IN THE COUNTRY SO ONE HAS BEEN ORDERED.

• 12/06/2023· ELECTRICAL SYSTEM,ENGINE

  Car stalled when at complete stop (at lights or stop signs) The auto restart feature seems to fail. Then it progressed to stuttering while driving and unable to drive above certain speeds (more than 40 mph). Service engine light on. Code by dealer P0017.

• 12/04/2023· ENGINE

  The contact owns a 2021 Kia Seltos. The contact stated while driving 78-80 MPH, the vehicle started losing motive power. The contact stated depressed the accelerator pedal to the floorboard however, the vehicle failed to respond. Several unknown warning lights were illuminated. The contact was able to pull to the side of the road. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed that the engine threw a rod through the oil pan, which drained the oil, and caused the engine to seize. The dealer determined that the engine needed to be replaced under warranty; however, the part was not available. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the part to repair the vehicle was not available. The failure mileage was approximately 49,281.

• 12/04/2020· VISIBILITY/WIPER

  THIS VEHICLE HAS A HUGE FLAW. THE DESIGN ANGLE OF THE WIND SHIELD PICKS UP A GLARE FROM THE DASH WHICH COVERS THE ENTIRE VIEWING ANGLE FROM CENTER WIND SHIELD TO THE RIGHT. ONLY REALLY VISIBLE WHEN THE SUN IS OUT. KIA CONSUMER AFFAIRS HAS ADMITTED VIA EMAIL AND CASE STATEMENT THAT IT IS A DESIGN ISSUE AND NOTHING CAN BE DONE. PHOTO SHOWS DASH GLARE. ANYTHING THAT IS PLACED ON THE DASH IS REFLECTED ON THE WINDOW SHIELD.

• 12/02/2021· POWER TRAIN

  Brand new car on Dec 2020. Second time with a transmission problem. Was repaired at 6500 miles in June of this year. Dealer replaced it with a re-manufactured one. At 9300 miles I was driving in cruise control at about 70 miles per hour for a couple hours and while going up a long hill the transmission started slipping again and rpms went from 2000 to 4000 while it was trying to shift. The car began to shudder just like back it june so I knew the transmission was going. I slowed down and pulled off highway as the transmission continued to slip and had no power to go above 20 mph. I saw a parking lot up the hill to pull over at to be more safe off the highway and the rpms went up to 6000 and barely moved car then it caught and lurched the car forward and I almost hit the sign in the parking lot. I waited over 3 hours for a tow truck and after car cooled it did move enough to get it near the tow truck to be pulled up on the flatbed. This car needs a beefier transmission or some kind of cooler or warning light to prevent accidents. When is it a lemon and due for recall??

• 12/01/2025· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  I am writing regarding my vehicle, a 2021 Kia Seltos LX - VIN Number [XXX] , which is subject to a recall NHTSA #25V099, Manufacturer Recall Number SC336. I was informed of the recall April 2025 and have since experienced engine stalling while driving on the highway with my young children with me, abnormal engine noise, complete oil loss and eventually complete engine failure. Unfortunately, this defect caused my vehicle to become unsafe and completely inoperable for the last 8 weeks. Kia said "We have completed the SC336 Piston Oil Ring recall, and your vehicle did pass. This means that the failure of the engine is not covered within the scope of that recall. This vehicle also does not have Kia warranty coverage active now due to age and miles. At this stage, Metro Kia does not have any further recourse for warranty coverage." My kia was stalling on the highway, complete oil loss where it was bone dry which led to engine failure. How did the vehicle "PASS" when EVERYTHING from the description of the recall is EXACTLY what happened to me? This is absolutely wild that Kia is refusing to do anything about this vehicle. It is a 2021, with 65,000 miles on it. The repairs are over 13K and I am being told I would get nothing for the car if I traded it in because it is worth nothing. Because of this situation, I have experienced a complete loss of transportation and have been relying on other methods of transportation and emptying my bank account for numerous towing visits to and from the dealership. Kia has not fixed the recall and instead quoted me over $13,000 to repair the car. I have enclosed copies of relevant documents, including the recall notice, service records, and any related correspondence. I messaged the BBB and attached Kia's response to that, as well as an email with the service advisor at Kia. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/30/2020· ENGINE

  GOING ON A SLIGHT INCLINE MY ENGINE FELT LIKE IT WAS SURGING SLIGHTLY AND AFTER 5 MIN THE ENGINE WAS REALLY SURGING AND THE NO MATTER HOW HARD YOU PRESSED ON THE ACCELERATOR THE SPEEDOMETER WOULD MAX OUT AT 65. AND THEN AFTER 10 MIN NO MATTER HOW MUCH YOU PRESSED ON THE ACCELERATOR THERE WOULD BE ABOUT A 5 SECOND DELAY IN THE RPMS. WHICH WOULD GO FROM 1 TO 8 MAX. AND IT FINALLY DIED ON THE FREEWAY. WHEN I FINALLY GOT IT TO THE DEALERSHIP THEY SAID THE TRANSMISSION BLEW ON IT AND TO GET A NEW ONE THEY WOULD HAVE TO ORDER IT FROM KOREA. I WILL BE WITHOUT A CAR FOR ALMOST 2 FULL MONTHS.

• 11/28/2020· STRUCTURE

  THERE IS A CONSTANT RATTLING NOISE COMING FROM THE REAR AREA. IT SOUNDS AT BOTHS LOW AND HIGH SPEED. NOT SURE IF IS FROM THE SUSPENSION OR SOMETHING INSIDE THE TRUNK AREA. MY VEHICLE HAS LESS THAN 600 MILES.

• 11/27/2025· POWER TRAIN,ENGINE

  My 2021 Kia Seltos is experiencing engine problems that match the piston-ring defect involved in Kia Recall SC336. I first took the vehicle to the dealership in August 2025 for excessive oil consumption and engine knocking. The dealer documented the engine was 1 quart low and stated the oil was “most likely being used internally getting past the piston rings.” However, they only performed the software update from SC336 and did not perform any internal engine inspection. Since that visit, the condition has significantly worsened. The vehicle is now consuming more oil than before, the knocking/ticking noises have become louder and more frequent, and fuel economy has declined. I am adding oil between changes to keep the engine from running dangerously low. There are no external leaks, so the oil is being burned internally, which is consistent with piston-ring failure. These symptoms are identical to other Seltos vehicles already included in the recall, yet my VIN is not currently part of it. The progression of engine noise and oil consumption raises serious safety concerns, including potential engine failure, loss of power, or stalling while driving. The dealer acknowledges the internal oil use but refuses further diagnostic work without direction from Kia. I am reporting this because the defect is worsening and poses a safety risk, and the vehicle appears to have the same failure pattern as recalled engines.

• 11/26/2022· UNKNOWN OR OTHER

  My car door flew open while I was driving. Car did not recognize that my door was open. The locking mechanism on the driver side of the vehicle seems to have given out. Cannot close driver side door.

• 11/25/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  DEATH TRAP! Point blank~Engine will STILL Jerk, Skip, Not Do Anything Or even Shut Off Without Warning!!! The Driver's Screen will still Flash and go out but only once in a while now. Dealership didn't understand that. They told me Radio was Fine Now. I told them Screen Directly in Front of Driver's with Speedometer on it. IT'S HARD TO FIND GOOD HELP. EVEN HARDER, to FIND a SAFE RELIABLE VEHICLE that YOUR KIDS CAN BE IN!!! % RUST {definitely} up under Near the License Plate Bracket. ALSO, the Windshield WIPERS STOP WORKING WHENEVER THEY CHOOSE!!! The Best part is, the Dealership CAN'T DO ANYTHING about ANY OF THIS. Why? Pretty much because KIA REDID the TEST so that ALL the Vehicles PASS Now. It makes it LOOK like the Engines are OK, when in Reality they are . I bought this Vehicle 12-30-24 with 44,068 miles on it. My Daughter and I thought we were going to Die in it on 4-26-25. We didn't even have it a full 4 months Before We Found Out WE HAVE A LEMON from KIA. There were 3,310 Miles put on it. Come on... I was told there was No Way to NOTE My Account at the Dealership for the Different Times {Everytime} this NEGLIGENT STUFF Kept and Still Does Happening. That's OK. I just Hope and Pray for KIA's sake, that Nothing Ever Seriously Happens to Anyone because of How THIS 2021 KIA SELTOS VEHICLE Operates DEFECTIVELY in So MANY DIFFERENT WAYS that ARE SAFETY HAZARDS. IF they were Smart, they would REPLACE ALL OF THEM with a Brand New Vehicle to AVOID A POSSIBLE SERIOUS FATALITY. I only say this because that's what WE experienced more than once. We fear this Daily. We ended up with this Vehicle after our Honda CRV-EXL was Totaled by Someone running a Red Light. It was the OTHER PERSON'S FAULT, but after paying off car... Kia was all in could afford. I had NO Choice but to get this KIA. Being a Single Mom on Low Social Security Disability Income, I did what I had to do! I have to have a GOOD RELIABLE AWD VEHICLE to get to Doctors Appointments. THIS ISN'T ONE.

• 11/25/2020· POWER TRAIN

  IN STOP AND GO TRAFFIC THE TRANSMISSION TEMPERATURE TOO HOT WARNING CAME ON. EVENTUALLY GOT INTO THE RED ZONE, HAD TO PULL OVER AND KEEP FOOT ON BRAKE TO DISENGAGED DUAL CLUTCH SYSTEM TO HELP DISSIPATE HEAT. EVENTUALLY WENT BACK DOWN TO NORMAL RANGE OF TEMPERATURE. DEALER STATED FOUND NO ARTICLES OR RESOURCES FOR THIS ISSUE.

• 11/23/2020· VEHICLE SPEED CONTROL,ENGINE

  CAR HAS 3000 MILES,CAR HAD BEEN SURGING WHEN ACCELERATING, IT REVVED UP WHEN IN DRIVE, WOULDN'T GO AS I WAS EXITING OFF OF INTERSTATE. WAS TOWED TO DEALER, THEY COULDN'T FIND ANYTHING WRONG, SENT ME HOME. I MADE IT 47 MILES WHEN IT STOPPED ACCELERATING AND STOPPED GOING. WAS TOWED BACK TO DEALER, WHERE IT HAS BEEN FOR OVER 2 WEEKS. THEY ARE PUTTING IN A NEW TRANSMISSION.

• 11/17/2022· ENGINE

  Motor stalled while driving down the road almost causing an accident with my son and wouldn’t run again on my brand new Kia Seltos right under 37,000 miles. Towed the car to the dealership & they said the motor was blown they insist it’s my fault because I can’t provide a receipt for an oil change in a 10month period. I purchased brand new with and extended premium KIA warranty and they won’t do anything, sorry we can’t help you. They say all they can do is replace the motor while charging me $7,600. The motor never had lights flashing with oil pressure, overheating or any alerts it just died while driving down the road.

• 11/16/2020· POWER TRAIN,ENGINE

  VEHICLE WAS HAVING DIFFICULTY SHIFTING BETWEEN GEARS, UNTIL ONE TIME IT DID NOT SWITCH FROM AUTOMATIC OFF AT STOPLIGHT BACK INTO GEAR. HAD TO TURN CAR OFF/ON TO GET IT INTO GEAR. LATER ON THE HIGHWAY AT ~60MPH, AS IT WAS TRYING TO DOWNSHIFT TO GO UP A HILL, IT FAILED TO ENGAGE A GEAR. ENGINE LIGHT CAME ON AND HAD TO COAST INTO SHOULDER TO AWAIT IT BEING TOWED. DEALERSHIP SAID IT NEEDS A NEW TRANSMISSION, WAS BAD FROM FACTORY - CAR HAS ~2K MILES ON IT. TECHNICIAN SAID IT'S NOT THE FIRST HE'S SEEN LIKE THIS.

• 11/15/2020· ELECTRICAL SYSTEM,ENGINE

  HVAC BLOWER WOULD NOT BLOW. DEALER FOUND MELTED RELAYS. ONE WEEK AFTER REPLACING THE ENTIRE ENGINE WIRING HARNESS I STARTED TO GET A BURNT ELECTRICAL SMELL THROUGH THE VENTS. I LOOKED IN THE ENGINE FUSE BOX AND THERE WERE MELTED RELAYS AGAIN.

• 11/12/2025· ENGINE

  My 2021 Kia Seltos with the 1.6L turbo engine is burning an excessive amount of oil — about one quart every 800–1000 miles — and is showing blue smoke from the exhaust. A certified technician indicated that the likely cause is faulty piston rings, which is a known issue on this engine and has led to engine replacements in other Kia vehicles. The vehicle was purchased as a Certified Pre-Owned Kia, and I have maintained it properly. Despite this, Kia and the dealership and the certified preowned warranty company have denied warranty coverage, calling it "oil consumption," even though the oil loss is clearly excessive and mechanical in nature. This defect poses a potential safety hazard, as engine failure or oil-related fires could occur if the engine runs low on oil while driving. There are many similar reports online from 2021 Kia Seltos owners experiencing the same problem. I am requesting that NHTSA investigate this issue and require Kia to address these engine defects, as they appear to be widespread and potentially dangerous.

• 11/11/2025· ENGINE

  Recall was initiated for my 2021 Kia Seltos for potential defective engine piston rings which could lead to increased oil consumption and lead to damage/fire to engine compartment. My vehicle has been burning through oil to the point i have to add it weekly to keep it from running out before next scheduled oil changes. Two separate local mechanics confirmed this is highly indicative of bad piston rings and should definitely be covered for repair/replacement by Kia dealer under recall. I took car in for recall assessment, they stated they performed an oil consumption test and engine knocking test to which they deemed it passed. I spoke with lead mechanic explaining that the car is burning through oil so quickly it would be completely empty by next scheduled oil changes if i wasnt continuously adding it - to which they replied they were aware and to "just keep adding oil". I stated this didnt seem right as it we know it is burning up oil at an alarming rate inside engine and was told unless it is pretty much spewing oil on the floor in front of us, it will pass the consumption test and you just have to continue adding oil. The piston rings would not even be checked unless you "failed the oil consumption test first". This is very concerning to drive now since there are reports of this issue leading to engine fires.

• 11/10/2023· ENGINE

  Engine began knocking and would stall on turns. Check oil light briefly flashed. No oil visible on dipstick about 2000 miles after oil change. Placed 4 quarts at home and was full. Stalling and knocking resolved. Brought to dealer and they said nothing wrong. Changed oil and did 1000 mile return to dealer to check oil consumption rate. The oil was about a quart or less low and they said this was normal, nothing to do. After 2000 miles oil level again checked and no oil visible on dipstick. Took photos of oil level each of these times. Called dealer and they towed it in. They confirmed that it is burning excessive oil and said it’s several quarts low. They say that they will now try to perhaps “soak” the engine? They have to check with Kia for approval. Not sure what this means. It is now with the dealer and we have no car to drive. They are not sure how long they will have it and have no loaner. We are obviously concerned about the safety of this engine/car which has just over 30000 miles and is running out of oil prior to recommended oil changes and was stalling intermittently when this was first discovered. Obviously concerned that engine will seize and be ruined at some point in essentially a brand new vehicle. The dealer (Preston Kia) denied any issue initially. I have read about ring issues in seltos engines requiring engine replacement. It seems that a similar problem is occurring here and I hope that Kia will do the right thing and repair/replace the faulty parts/engine. There are many similar complaints on line.

• 11/07/2025· ENGINE,FUEL/PROPULSION SYSTEM

  I bought this vehicle brand new in 2021. I noticed at the beginning that when I accelerated that the car would delay in acceleration. This would happen sporadically. Now it is happening all the time and has almost caused me to get into several accidents because of the delay in acceleration. This is a major safety risk. I've had the car inspected at Kia Dealers and they just say yeah, we hear that a lot with this model but there is no recall. There are no warning lamps or messages.

• 11/05/2021· ENGINE

  The engine shut off while driving.

• 11/03/2023· POWER TRAIN

  While driving I noticed my Seltos felt like it was shifting hard. I then attempted to put it in reverse. There was NO reverse. I had to get bystanders to push me off the road. This is a safety risk because there were no warning signs that reverse would fail to engage. Kia states there is no recall, but several of same instances were found in forums. My car is scheduled at dealership next week. No rental, no recall, no warranty. I will have to pay out of pocket for something that has been known to fail. Supposedly an actuator of some sort. This repair will be costly and I feel it is a manufacturer responsibility. This is not normal wear and tear item. I bought this used, it was practically new. Now I know why someone traded it in. Kia should disclose their warranty limitations when they advertise. The 10 year, 100,000 mile is not a true representation.

• 11/03/2023· ENGINE

  My 2021 Kia Seltos EX is eating oil.......... 1/2 quart a week at least and I have read online that it can lead to the engine overheating, stalling, etc. So far my car is not listed on the piston recall or any other recall, but how can Kia state it can go 7,000 miles between oil changes when it only holds 4 1/2 quarts of oil and goes through it so fast? I change my oil every 3,500 miles because of it but am still afraid of something bad happening to my car.

• 11/02/2021· UNKNOWN OR OTHER

  My car was stolen. No alarm sounded when window broken in front-passenger side. Car was locked and alarm set. It has come to my attention through various news outlets and via class-action lawsuit filed in Milwaukee, WI that there is a security flaw in Kia’s vehicles dating 2011-present.

• 10/31/2025· ENGINE

  The contact owns a 2021 Kia Seltos. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle stalled. The contact stated that unknown warning lights were intermittently illuminated. The vehicle was taken to an independent mechanic, and the contact was informed that there was less than one-quarter of oil in the engine. The contact stated that an oil change was performed. The vehicle was repaired. The contact was advised to take the vehicle to the dealer for further services. The contact was advised that the vehicle should not consume 3.5 quarts of oil within 5,000 miles. The vehicle was taken to the dealer; however, the vehicle was not inspected. The dealer was informed that the vehicle was consuming 3.5 quarts of oil within 5,000 miles. The contact was informed that it was not an issue. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

• 10/26/2022· POWER TRAIN,ELECTRICAL SYSTEM

  The contact owns a 2021 Kia Seltos. The contact stated that while at a complete stop, the vehicle would stall upon depression of the accelerator pedal as the battery, oil, and check engine warning light illuminated. The contact shifted the vehicle into park(P) and restarted the vehicle and the vehicle drove as needed. The contact took the vehicle to a dealer where a diagnostic test was performed but no failure was found. The contact also stated that the horn intermittently failed to operate as needed. The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired. The failure mileage was approximately 8,000.

• 10/26/2021· UNKNOWN OR OTHER

  21V-259 recall for inconsistent heat treating process for piston oil rings. The dates for use of the recalled piston rings Nov 20,1019 -Oct 15, 2020. My Seltos was in production at the time the damaged oil rings were used. I took my Seltos in for the repair, MY VEHICLE WAS NOT repaired. A vibration test was done and a program update was installed to detect vibration. The vehicle still has the recalled damaged oil rings. The vehicle stalls out, runs rough and continues to worsen. The first engine start up is the worst for engine noise and running rough. I expressed my concerns to the dealership, a vibration test with program software uploaded isn't a repair. Asked when will then piston rings be replaced? They stated they didn't know of that any such repair and my car is repaired. Yet it still stalls, continues to runs rough and worsening, oil check has grit feelin it. So I guess I wait till the engine stalls causing a wreck or the vehicle ignites into flames. I'm scared to drive the car and financially stuck with it because no one is willing to do anything more than what's been done. This is not fair and shouldn't be an acceptable outcome for a safety recall, as the issue of safety has not been addressed.

• 10/20/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2021 Kia Seltos. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from the vehicle. There were no warning lights illuminated. The contact was informed about NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to an independent mechanic for an oil change. After leaving the mechanic, the vehicle started smoking, and the engine seized in traffic. The vehicle was towed to the local dealer, who determined that the engine was faulty and needed to be replaced. The vehicle was not repaired. The dealer informed the contact that there were no oil change records for the vehicle. The manufacturer was contacted and notified of the issue. The failure mileage was unknown.

• 10/19/2022· ENGINE

  My kia model is excluded from the piston ring recall but is exhibiting similar engine problems. The engine stutters nearly stalls and smells of oil frequently.

• 10/19/2020· POWER TRAIN

  VEHICLE WILL NOT PROPERLY SHIFT GEARS AND WILL STALL RANDOMLY AT TRAFFIC STOPS.