crashtest

2021 / Ford

2021 Ford Explorer

5/5

Overall rating (best variant)

Safety ratings

2021 Ford Explorer SUV 4WD

5/5Overall
5/5Frontal crash
5/5Side crash
5/5Side pole
4/5Rollover
Frontal, driver: 5★Frontal, passenger: 5★Side, driver: 5★Side, rear passenger: 5★Rollover risk: 15.1%
  • Lane departure warningStandard
  • Forward collision warningOptional
  • Electronic stability controlStandard

2021 Ford Explorer SUV RWD

5/5Overall
5/5Frontal crash
5/5Side crash
5/5Side pole
4/5Rollover
Frontal, driver: 5★Frontal, passenger: 5★Side, driver: 5★Side, rear passenger: 5★Rollover risk: 14.7%
  • Lane departure warningStandard
  • Forward collision warningOptional
  • Electronic stability controlStandard

Crash test videos & photos

Crash test #1NHTSA test 11053

Full test report (PDF) ↗

Crash-test footage is converted for smooth playback the first time someone requests it — usually under a minute.

No. 001 Load Cell Location.JPGNo. 002 Pre-Test Load Cell Wall.JPGNo. 003 Post-Test Load Cell Wall.JPGNo. 004 Manufacturer’s Label.JPGNo. 005 Tire Placard.JPGNo. 006 2020 Ford Explorer Frontal As Delivered for web.jpgNo. 007 Left Rear 3-4 View, as Received.JPGNo. 008 Pre-Test Front View of Test Vehicle.JPGNo. 009 Post-Test Front View of Test Vehicle.JPGNo. 010 Pre-Test Left View of Test Vehicle.JPGNo. 011 Post-Test Left View of Test Vehicle.JPGNo. 012 Pre-Test Right View of Test Vehicle.JPGNo. 013 Post-Test Right View of Test Vehicle.JPGNo. 014 Pre-Test Right Front 3-4 View.JPGNo. 015 Post-Test Right Front 3-4 View.JPGNo. 016 Pre-Test Left Rear 3-4 View.JPGNo. 017 Post-Test Left Rear 3-4 View.JPGNo. 018 Pre-Test Windshield View.JPGNo. 019 Post-Test Windshield View.JPGNo. 020 Pre-Test Engine Compartment View.JPGNo. 021 Post-Test Engine Compartment View.JPGNo. 022 Pre-Test Fuel Filler Cap View.JPGNo. 023 Post-Test Fuel Filler Cap View.JPGNo. 024 Pre-Test Front Underbody View.JPGNo. 025 Post-Test Front Underbody View.JPGNo. 026 Pre-Test Rear Underbody View.JPGNo. 027 Post-Test Rear Underbody View.JPGNo. 028 Pre-Test Dummy Cable Routing.JPGNo. 029 Post-Test Dummy Cable Routing.JPGNo. 030 Pre-Test Driver Dummy Front View.JPGNo. 031 Post-Test Driver Dummy Front View.JPGNo. 032 Pre-Test Driver Dummy Window View.JPGNo. 033 Post-Test Driver Dummy Window View.JPGNo. 043 Post-Test Driver Dummy Feet.JPGNo. 046 Pre-Test Driver’s Side Floorpan.JPGNo. 048 Post-Test Driver Dummy Face.JPGNo. 053 Pre-Test Passenger Dummy Front View.JPGNo. 056 Post-Test Passenger Dummy Window View.JPGNo. 060 Post-Test Passenger’s Seat Fore-Aft Markings.JPGNo. 069 Pre-Test Passenger’s Side Floorpan.JPGNo. 075 Post-Test Stoddard Solvent Spillage Location View, If Required.jpgNo. 082 2020 Ford Explorer Frontal Impact Event.jpg

Recalls (26)

  • BACK OVER PREVENTION:DISPLAY FUNCTIONCampaign 23V305000 · 28/04/2023

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer Police Interceptor Utility vehicles equipped with a 12.1-inch Integrated Computer Screen (ICS). When the Display On/Off Button is used to turn the display to "Off" prior to placing the vehicle in reverse, the backup camera rearview image will not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

    Risk: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.

    Fix: Dealers will update the ICS software, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C14.

  • BACK OVER PREVENTION:SOFTWARECampaign 25V442000 · 27/06/2025

    Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

    Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

    Fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

  • POWER TRAIN:AUTOMATIC TRANSMISSIONCampaign 26V402000 · 24/06/2026

    Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

    Risk: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

    Fix: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

  • POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)Campaign 23V199000 · 24/03/2023

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

    Risk: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

    Fix: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

  • ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICALCampaign 24V635000 · 23/08/2024

    Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.

    Risk: A loss of drive power increases the risk of a crash.

    Fix: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.

  • AIR BAGS:SIDE/WINDOW:CURTAINCampaign 21V652000 · 23/08/2021

    Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. The side air bag attachment weld studs could detach during the deployment of the side air bag, resulting in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 214, "Side Impact Protection".

    Risk: Improper deployment of a side air bag increases the risk of injury during a crash.

    Fix: Dealers will replace the side air bag assemblies, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C19.

  • BACK OVER PREVENTION: SENSING SYSTEM: CAMERACampaign 23V022000 · 23/01/2023

    Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.

    Risk: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

    Fix: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.

  • BACK OVER PREVENTION:SOFTWARECampaign 21V735000 · 22/09/2021

    Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.

    Risk: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

    Fix: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.

  • ENGINECampaign 20V788000 · 17/12/2020

    Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Lincoln Aviator vehicles. The right hand motor mount fasteners may have been incorrectly tightened, and may loosen over time.

    Risk: With a loose motor mount, motor vibration may cause the axle to disconnect from the engine and could result in loss of power, increasing the risk of a crash.

    Fix: Ford will notify owners, and dealers will remove and replace the right hand motor mount fasteners, free of charge. The recall began February 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S72.

  • SEAT BELTSCampaign 26V159000 · 17/03/2026

    Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

    Risk: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

    Fix: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

  • SEATS:MID/REAR ASSEMBLYCampaign 26V451000 · 14/07/2026

    Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.

    Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.

    Fix: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.

  • BACK OVER PREVENTION:SOFTWARECampaign 25V159000 · 14/03/2025

    Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.

    Risk: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

    Fix: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.

  • POWER TRAIN:DRIVELINE:DRIVESHAFTCampaign 25V166000 · 14/03/2025

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles previously repaired incorrectly under recall numbers 23V-199 or 22V-255. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

    Risk: A disconnected driveshaft can result in vehicle rollaway when the vehicle is placed in park without the parking brake applied. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

    Fix: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S22.

  • SEAT BELTSCampaign 25V093000 · 14/02/2025

    Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Aviator vehicles. The seat belt buckle anchor bolts at one or more seating positions may be improperly secured. Additionally, vehicles may have an improperly secured seat belt retractor anchor bolt and/or seat belt anchor bolt at the second-row center seating position, if equipped.

    Risk: A loose seat belt or seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

    Fix: Dealers will inspect seat belt buckle anchor bolts in all seating positions. Additionally, dealers will inspect the seat belt retractor anchor bolt and seat belt anchor bolt at the second-row center seating position, if equipped. If loose anchor bolts are found, the affected seat components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed on June 5, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S09.

  • SEATS:MID/REAR ASSEMBLYCampaign 25V393000 · 13/06/2025

    Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

    Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.

    Fix: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.

  • BACK OVER PREVENTION: SENSING SYSTEM: CAMERACampaign 23V342000 · 12/05/2023

    Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.

    Risk: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

    Fix: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.

  • SUSPENSION:REARCampaign 21V870000 · 10/11/2021

    Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. Incorrect rear suspension module components may have been installed due to a labeling error.

    Risk: A rear suspension module with incorrect components may affect vehicle handling, ride height, and braking characteristics, increasing the risk of a crash.

    Fix: Dealers will inspect the rear suspension module, and replace any incorrect parts, as necessary, free of charge. Owner notification letters were mailed December 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S47.

  • EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATERCampaign 25V685000 · 10/10/2025

    Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

    Risk: An electrical short circuit can increase the risk of a fire.

    Fix: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

  • ENGINECampaign 24V598000 · 10/08/2024

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with the Police Interceptor Utility Package. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

    Risk: An engine compartment fire increases the risk of injury.

    Fix: Owners are advised to park and shut off the engine as promptly as possible upon hearing unexpected engine noises, or after experiencing an unexpected engine power reduction, or seeing smoke from the engine compartment. Dealers will update the Powertrain Control Module (PCM) software. In addition, dealers will inspect for connecting rod bearing failure and if necessary, replace the engine long block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S52.

  • POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)Campaign 23V069000 · 10/02/2023

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

    Risk: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.

    Fix: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.

  • EQUIPMENT:OTHER:LABELSCampaign 24V852000 · 08/11/2024

    Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

    Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

    Fix: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

  • ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERYCampaign 23V626000 · 08/09/2023

    Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

    Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

    Fix: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.

  • FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMPCampaign 25V455000 · 07/07/2025

    Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

    Risk: An engine stall increases the risk of a crash.

    Fix: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

  • POWER TRAIN:DRIVELINE:DRIVESHAFTCampaign 23V675000 · 06/10/2023

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

    Risk: A disconnected driveshaft can result in a loss of drive power or a vehicle rollaway if the parking brake is not applied. Either of these scenarios can increase the risk of a crash.

    Fix: Dealers will replace the subframe bushing and rear axle bolt. They will also inspect the rear axle cover for damage near the bolt hole location and replace with a new cover if any damage is found. Repairs will be performed free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S55.

  • VISIBILITY:WINDSHIELD WIPER/WASHER:MOTORCampaign 26V117000 · 03/03/2026

    Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.

    Risk: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.

    Fix: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.

  • BACK OVER PREVENTION:SOFTWARECampaign 26V123000 · 03/03/2026

    Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

    Risk: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

    Fix: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Owner complaints

413
Complaints
14
Crashes reported
5
Fires reported
16
Injuries
0
Deaths

Most-reported areas

  • POWER TRAIN115
  • UNKNOWN OR OTHER80
  • ENGINE47
  • ELECTRICAL SYSTEM41
  • BACK OVER PREVENTION36
  • VISIBILITY/WIPER23
  • STRUCTURE23
  • SERVICE BRAKES23
Read individual complaints (50 most recent)

These are unverified consumer reports filed with NHTSA, shown as submitted.

  • 12/30/2025· POWER TRAIN

    When given gas to move from a complete stop, vehicle lost all power. After vehicle lost all power to rear wheels, warning lights flashed on cluster. Manually moved vehicle to side of road and checked under SUV to see rear axle was at a unusual angle and later discovered rear axle bolt on road. Vehicle was towed to dealership, which originally completed recall repair in July of this year, for this known issue. Repairs have been completed after 2 weeks, and was informed by dealership it was roughly 6 thousand in damages.

  • 12/30/2023· ELECTRICAL SYSTEM

    11/9/23 our still under warranty, 2021 Ford Explorer Platinum with 20,152 miles on it died at stop sign and would not start. Locked in park and had to be towed to dealer who worked on it for one week and claimed it was fixed. Same problem second time a few days later and dealer claimed it was lose wires and returned to us on 11/28. This last time (happened at a very dangerous onramp location and I thought I was going to get hit by another car while waiting for the police to arrive) they have had it since 12/4 and can not diagnose or fix the problem despite claiming to have done numerous things. Ford (Detroit) CS has been of zero help and will not loan us a car or rent one for us to use. We are supposed to be leaving in a few days for our Florida residence for 4 months without our car being fixed. We have had the car a total of 10 days out of the last 51 and with the holiday weekend being tomorrow and Monday it will be 53 days. I have read about numerous Ford Explorers having this same problem and never getting fixed correctly, only to have repeated software issues. How much is enough for a consumer to finally have protection. Lemon Law has expired and I can not find any information for consumers in our current situation. Please advise. We are [XXX] and this is very stressful to say the least. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • 12/29/2025· UNKNOWN OR OTHER,VISIBILITY/WIPER

    The fabric from the moonroof has come loose on the sides and blocks rear visibility if open. This is apparently an issue with many vehicles.

  • 12/28/2024· SUSPENSION,UNKNOWN OR OTHER

    Recently brought my 2021 Ford Explorer with 100,000 miles in for what I thought was a wheel bearing issue. The mechanic reports the entire rear end is gone and needs to be replaced. I’ve owned at least 4 Explorers all driven well over 170,000 without ever having this issue. This car also spent the first 3/4 months I owned it at the Ford garage getting the electrical replaced and “brains”. The crash alert system malfunctioned as did the locking system.

  • 12/27/2022· PARKING BRAKE

    The contact owns a 2021 Ford Explorer. The contact stated that he recently had a manufacturer recall performed on the vehicle for Ford Customer Satisfaction Program Number 22N06 (Rear Axle Bolt Replacement). The contact stated that the dealer re-programed the E-brake to engage automatically when the vehicle was placed in park(P). The contact stated while reversing out of his driveway the vehicle would not move. The contact had been instructed to tap on the accelerator to release the E-brake. The contact stated that the RPM was raised to approximately 2,000 RPM, and only then would the high RPM release the E-brake; however, the vehicle would lurch into motion at approximately 10 MPH. The contact stated that the E-brake warning light was illuminated and then switched off once the E-brake was disengaged. The contact stated that the failure was more pronounced while reversing on a slope. The contact stated that the failure recurred while placing the vehicle in drive(D) however, the vehicle lurched and jumped forward. The contact stated that the motion was not as aggressive as while the vehicle was in reverse(R). The contact had taken the vehicle back to the local dealer where it had been reprogrammed. The contact was advised that all that could be done was to reprogram the E-brake. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 23,000.

  • 12/25/2024· UNKNOWN OR OTHER

    The class three hitch receiver is well above an acceptable tolerance causing the hitch to move within the receiver and cause damage to the receiver. This abundance of "play" in the receiver was duplicated with a brand new hitch as well. My safety as well as others was put at risk through the risk of excessive torque being applied to the hitch/receiver through it's overly large size potentially causing it to break. This problem has not been reproduced or confirmed by a dealer nor been inspected. The part has not failed, but is likely to fail through continued use. ***Plastic deformation has occurred within the hitch receiver because of its excessive size.

  • 12/20/2021· AIR BAGSCrash

    The contact owns a 2021 Ford Explorer. The contact stated that he was driving approximately at 55 MPH when a deer jumped out in front of his vehicle. As a result, the contact crashed into the deer and the air bags did deploy, however when it did it was very aggressive. The contact stated that he and his wife were both sustained multiple injuries caused by the airbags. The contact stated the passenger suffered injuries to both her eyes causing blindness and isn't certain if it would be permeant. The contact stated that he sustained injuries to his wrist, neck, and leg. The contact stated the ambulance was called and took them to the hospital where they received treatment. The contact stated the vehicle was towed to a junkyard service, and from there towed to the dealer where it remains currently. The contact was advised that his vehicle may be totaled and that he should await further details. The failure mileage was 3,000.

  • 12/18/2025· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 23V675000 (Power Train); however, the repair failed to prevent a failure shortly after the vehicle was serviced. The contact stated that after shifting from reverse(R) to drive(D), there was an abnormal grinding sound coming from the vehicle before the vehicle lost automotive power. The vehicle was towed back to another local dealer, Sutton Ford (21315 Central Ave, Matteson, IL 60443); where it was diagnosed with a fractured rear axle bolt. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 77,000.

  • 12/17/2025· EXTERIOR LIGHTING

    Adaptive Headlamps keep going out causing a safety issue.

  • 12/16/2025· ENGINE

    The contact owns a 2021 Ford Explorer. The contact stated that the VIN was included in NHTSA Campaign Number: 24V598000 (Engine). The local dealer was contacted and declined to complete the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.

  • 12/16/2025· UNKNOWN OR OTHER

    The sliding roof mechanism for the sunroof failed and droops into the backseat impairing vision. This can be triggered accidentally while driving causing zero rear visibility. This is part of the sun roof that is the shade keeping the sun out of the car. With extremely little use on my 2021 ford explorer this mechanism has failed causing this dangerous malfunction. I found may posts in Facebook describing this same issue. [XXX] There’s just one example of many people having this issue. There’s component was taken to the Ford dealership where I was provided a verbal quote of more than $4,000 to fix, which is not feasible. There were no warning signs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • 12/15/2025· UNKNOWN OR OTHER

    The sunroof shade is sagging. It broke from one day to the next, and it’s blocking my rear view.

  • 12/15/2023· POWER TRAIN,FORWARD COLLISION AVOIDANCE

    The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the vehicle suddenly shifted into park, after which the vehicle went into LIMP mode. After restarting the vehicle, the vehicle was unable to shift out of park and displayed the "Automatic Emergency Braking Unavailable" message. The traction control, start-to-stop, and hill start assist warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,500.

  • 12/14/2023· EQUIPMENT,BACK OVER PREVENTION

    The contact owns a 2021 Ford Explorer. The contact stated that the screen display was blue and black and became inoperable. While reversing, the screen was blue. The contact was unable to use the GPS feature. There were no warning lights illuminated. The contact called the local dealer, and the contact was informed that the vehicle could be repaired under warranty. The system showed that the screen had connected and disconnected. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 23V342000 (Back Over Prevention). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 42,000.

  • 12/14/2021· POWER TRAIN,VEHICLE SPEED CONTROL

    The contact leased a 2021 Ford Explorer. The contact stated while driving approximately 25 MPH, the vehicle accelerated independently. The contact stated that five minutes later the vehicle went into safety mode and the vehicle failed to move. The low battery message was displayed. The vehicle was towed to the residence. The contact called the local dealer but, the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 7,600.

  • 12/14/2021· SEATSCrash

    The vehicle was involved in a rear-end collision. When the collision occurred, both front seats dropped into a fully reclined position and locked fully reclined.

  • 12/13/2021· AIR BAGS

    On 11/25/2021, I started the vehicle and drove about 2 miles when I noticed that the airbag light was illuminated on the dash. Knowing that this is a safety concern, I pulled into a parking lot and shut off the vehicle. I let the vehicle sit for about 30 seconds and restarted the car. When restarted, the light did not come back on. Took the vehicle in to have a recall performed and told the service advisor that the light had come on. They confirmed that there was a "stored code" but "not something that made sense". The dealership has had the vehicle for 9 days with no resolution. They say that a wiring pigtail harness needs replaced but also that there is a fault in the driver's seat airbag. The replacement airbag is not available due to a backorder (told 3-4 weeks). I feel that this is a large safety concern as I was told I could pick up the vehicle until the parts become available knowing that there is a fault in the airbag. The failure occurred with 3410 miles on the odometer.

  • 12/12/2023· ENGINE

    The oil crank case is getting fuel inside. In approximately 1000 to 1500 miles there is a 1 quart and a half of fuel in the oil making the oil level overfill. This oil diluting the fuel issue. Seems like it could be a safety issue if it continues to pour gasoline into the oil crank case. My local Ford dealer, Gary Yomans Ford in Daytona Beach Florida. Verified the concern and told me there’s no repair available yet. The technician further stated that it will eventually destroy the engine from the inside. This issue only started this year. There is at this time 30,959 miles on the vehicle.

  • 12/09/2024· POWER TRAIN

    While driving on the freeway, the customer experienced a power train failure, which resulted in the vehicle stopping. Though the vehicle was able to continue driving, it would unpredictably jump gears and eventually became immobile. The "service engine" wrench light first appeared on [XXX], signaling the issue. The vehicle was inspected by Curt Service in Oak Park, Michigan, and no additional codes were identified beyond the service engine wrench light. The power train system is available for inspection upon request. This situation posed a safety risk to the driver and others on the road, as the vehicle's sudden stop and gear issues could have led to an accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • 12/09/2021· STRUCTURE,WHEELS

    On October 25, 2021; my wife and I were driving across country when we experienced a blow-out at 75 MPH in New Mexico (about 80 miles west of Amarillo. The blow-out was caused by body cladding, which came off the right rear door of our 2021 Ford Explorer - apparently attributable to 19+ MPH desert cross winds at highway speeds of 75 MPH. The trim lodged in the right rear wheel well; slicing the tire and cutting a gash from the aluminum rim. We had to get to California for a scheduled closing on our new home and were therefore unable to stay in Amarillo or Albuquerque for the three days required to receive a matching rim and tire, so I had a nearby tire store install a wheel of a different size with an offsetting tire size to approximate the circumference of the stock wheels and tires. Ford has thus far neglected to acknowledge the obvious defect that would allow a body part to blow off the car and has offered no assistance in repairing the car or reimbursing me for the wheel and tire I had to purchase to meet personal legal obligations. I've seen evidence in online forums indicating other incidents of body trim blowing off Ford Explorers at highway speeds. Ford must take responsibility for this defect and reimburse other owners and me for costs incurred to resolve implications of their defective body parts.

  • 12/07/2025· UNKNOWN OR OTHER

    Sunshade is sagging. For the 2nd time.

  • 12/07/2023· ENGINE AND ENGINE COOLING

    The contact owns a 2021 Ford Explorer. The contact stated while driving approximately 30 MPH, the contact heard an abnormal sound coming from under the floorboards. The contact slowed the vehicle to listen for the sound, when the contact depressed the accelerator pedal to move forward, he heard the abnormal sound and described it as the sound of a motorcycle exhaust. The contact stated that he drove forward for a few minutes more when the abnormal noise from under the vehicle was louder and he felt that some object was trapped underneath the vehicle and was hitting the underside causing a loud banging noise. The contact stopped the vehicle and looked underneath the vehicle and observed that the passenger’s side exhaust pipe had detached from the catalytic converter. The contact then checked the driver's side and saw that a crack had opened approximately one inch from where the exhaust pipe was connected to the catalytic convert. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the damage appeared to have been made during an attempt to steal the catalytic converter and referred the contact to a muffler specialist. The vehicle was not repaired. The contact took the vehicle to a muffler repair shop where it was diagnosed that the exhaust pipes had rusted, and the passenger’s side exhaust pipe had detached from the vehicle. The contact did not believe that the rust was the cause in the fracturing of the exhaust pipe from the catalytic converter. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21E11 Emission Recall (Engine). The manufacturer was informed of the failure. The failure mileage was 58,691.

  • 12/06/2024· ELECTRICAL SYSTEM

    The contact owns a 2021 Ford Explorer. The contact stated that while his wife was driving and was at a traffic light, the light turned green and the accelerator pedal was depressed; however, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the instrument cluster was dark, and the vehicle failed to restart. The contact stated that his wife waited for approximately 15 minutes in the middle of the road. The contact’s wife was able to restart the vehicle and drove a local dealer. The vehicle had experienced the failure in November 2024 and the same dealer replaced the battery and replaced all four tires. The contact stated that the vehicle was diagnosed, and the dealer determined that the 12-Volt battery needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 30,000.

  • 12/03/2025· UNKNOWN OR OTHER

    Panaromic sunroof blind became lose and is sagging, causing an unsafe driving experience, making it difficult to see out rear view mirrors.

  • 12/03/2024· FUEL SYSTEM, GASOLINE

    The contact owns a 2021 Ford Explorer. The contact stated that after parking the vehicle, there was an abnormal fuel odor inside and outside the vehicle. The vehicle was taken to the local dealer who diagnosed that the fuel hoses had ruptured due to the hoses making contact and rubbing together. The contact was informed that the fuel hoses needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but offered no assistance. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V859000 (FUEL SYSTEM, GASOLINE). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 44,000.

  • 12/02/2025· ENGINE

    My explorer is only 4 years old and it suddenly suffered catastrophic engine failure due to low engine oil. The engine started knokcing and clattering BEFORE any warning lights came on the dash. This could also be due to premature bearing failure which is common in the 3.0 ecboost engines.

  • 12/02/2024· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

  • 12/02/2024· POWER TRAIN

    Difficulty shifting gears, delayed shifting, slipping between gears, jerking motions during acceleration, and stalling when you move from a stop. Also leaking oil under transmission pan and makes noises in the transmission.

  • 12/02/2023· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

    I already having problem with the parking !When I set the packing bottoms it's turns automatically into rear I already have an issues with that!! almost kill my son an nephew I'm scared this happened again in the parking lot at store almost crash other vehicle! I need my car fixed as soon is possible I hope I hear from your side! Thank you!!!

  • 12/02/2023· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

    I haven’t been problem with the parking !When I set the packing bottoms it’s turns automatically into rear I already have an issues with that !! almost kill my son an nephew I’m scared this happened again in the parking lot at store almost crash other vehicle! I need my car fixed as soon is possible I hope I hear from your side! Thank you!!!

  • 12/01/2025· UNKNOWN OR OTHER

    The sunroof sunshade snapped a clip off and now hangs down blocking the rear view. It is impossible to see out the back window. I have read on multiple sites that this is happening to many of these SUVs and it's an extremely expensive and difficult fix. It's very dangerous and I won't even let my girlfriend drive it anymore.

  • 11/30/2023· POWER TRAIN

    The contact's daughter owns a 2021 Ford Explorer. The contact stated that while his daughter was driving from a complete stop in a parking lot, the vehicle stalled. A message indicating a transmission failure was displayed. The vehicle failed to restart and was towed to an independent mechanic. The vehicle was not diagnosed and was towed to the dealer to be diagnosed. The dealer informed the contact's daughter that a diagnostic test cost would be charged because the vehicle was out of warranty. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 46,000.

  • 11/30/2023· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact stated that while attempting to accelerate after coming to a complete stop, the vehicle briefly lunged forward. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V675000 (Power Train) the VIN was included but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 15,000.

  • 11/28/2023· BACK OVER PREVENTION

    The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the rearview camera image was blue. The vehicle was taken to the dealer, where an unknown software update was performed; however, the failure persisted. The contact later received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,000. VIN tool confirms parts not available.

  • 11/27/2024· FUEL/PROPULSION SYSTEM

    I have had this problem ever since we Purchased this automobile on [XXX], When the car gets to a Quarter tank of gas or a little less the dash monitoring system says there's 87 miles left till empty and you park this car on a hill or incline with the front end facing down the car will not start and everything shuts down. The only way to restart it is to put more gas from a can in it or go through a long process to takes two people to do to get the car on a level area then it will restart. I call the Dealer abut it and they said there is no problem. The car had to be towed twice in the first few months we had it for this and as soon as they got it off the truck it would start and they do nothing about it. I call Fords Hot line and they said they know about the Problem but can't do anything about it , I was told that its a fuel pickup Problem. Today [XXX] my wife when to the store this morning and the fuel gage said it had a quarter tank of gas in it and when she came out of the store the car would not start for her. I had to go and get a 5 gal. can of gas and drive to where she was and put the gas in the car and after that the car started, she drove to the nearest gas station to fill it up. All I have been told to do by Ford and the Dealer is to keep the gas tank full and fill it when it gets to half a tank. There is definitely a problem with this car and it needs to be Addressed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • 11/27/2022· VISIBILITY/WIPER

    Backup camera “blue screens” during critical times it is required. Software updates were updated but no resolution until Ford replaced the backup camera.

  • 11/26/2025· EXTERIOR LIGHTING

    vehicle low beam headlights went out all of the sudden. Would not come back on after car was turned off and restarted. Drove home with high beams on. Next day, just the driver side low beam came back on. Took to dealer, they reprogrammed and headlights worked for three days, then went passenger low beam went out again. Took back to dealer and now they are telling me both headlamp control modules on both sides need replacing. The cost is very expensive and I am doubting this is the problem. This is a safety issue and I am reading blogs and the Platinum version of the Explorer seem to have issues. This could cause an accident and Ford could be liable. This issue needs to be looked at, as this should not be an issue for a car with 50K miles on it.

  • 11/24/2025· UNKNOWN OR OTHER

    SUNROOF SHADE HAS FALLEN OFF TRACKS WHILE DRIVING

  • 11/23/2021· UNKNOWN OR OTHER

    There is no way to securely lock the vehicle when someone with the key fob is near it. When fueling, someone can unlock the opposite side of the car, by pulling on the door handle, which unlocks it, enter and drive away. Not only does this open the possibility of easily stealing the car, but also abducting passengers, if any have the fob on them, or simply stealing contents, planting contents, etc. This is a serious security issue

  • 11/20/2025· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate. In addition, the vehicle jerked aggressively, and the engine idled roughly. No warning lights were illuminated. The vehicle was towed to the contact's residence. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train). The contact inquired if the failure was the result of the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,954.

  • 11/20/2023· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

  • 11/19/2025· AIR BAGS,STRUCTURE

    Dashboard not attached to frame. Clips intended to attach dashboard to frame are defective (cracked in half). Air bags may be affected (either won't deploy or will deploy on their own). Service Dept. at Ford dealership says this is the first case they've seen and repairing it would cost $$$. This vehicle has been regularly maintained and has 0 history of accidents. It is unknown if this defect has existed from the date the car was purchase(or earlier).

  • 11/18/2024· ELECTRICAL SYSTEM

    The contact owns a 2021 Ford Explorer. The contact's wife stated that while driving at an undisclosed speed, the vehicle lost motive power with a system shut-down message displayed. The contact also stated that the vehicle inadvertently shifted into park. The vehicle was able to restart after 30 minutes. The vehicle was taken to the dealer where it was diagnosed and determined that the tires had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 30,469.

  • 11/17/2025· UNKNOWN OR OTHER,ENGINE

    My vehicle is experiencing exhaust fume issue where the exhaust fumes are entering into the cabin for Explorer and Aviator models (Any model with the 3.0L Ecoobost). Upon inspection by 3rd party mechanic, it can be determined that the problematic catalytic converters that are not the one piece cast was installed on my vehicle from the factory. Speaking to other ST and Interceptor owners, the problem seems widespread to every 2021 model that Ford installed the multipiece welded catalytic converters. Apparently the cast part fairs better and is not subject to cracks. The recall originally covered the left side catalytic converter but the flawed design also affects the right side catalytic converter where many owners are experiencing this issue. This has affected all 3.0L Ecoboost engine vehicles. [XXX] I believe the recall should have extended to cover all 2020 and 2021 model year vehicles. There are forum posts where owners outside the recall have experienced the issue in addition to owners having to repeatedly replace the catalytic converters post warrant as Ford continued to reinstall bad catalytic converters as part of the repair process. I have driven this vehicle for several thousand miles with the issue and did not realize exhaust was leaking until notices of headaches and health issues as CO is odorless, causing CO2 levels to reach 3000+ inside the cabin at stop lights and blows in through the vents if A/C is on. I believe NHTSA should investigate this issue further and require Ford to replace both catalytic converters as this issue poses a serious health hazard, especially given the location of the exhaust leak and the commonplace occurrence. I am happy to forward to forums and provide evidence of this occurring. Ford considers lifetime of the vehicle to be ~150K miles and these exhausts do not last close to that, resulting in a massive expense and danger to US consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • 11/17/2023· WHEELS,TIRES

    Two TPMS sensors have failed on this vehicle. Although these sensors are required under the TREAD act, Ford has advised through their dealer that this is not a safety issue and the TPMS sensor batteries failing less than 3 years from date of vehicle manufacture falls in the category of normal wear and tear. Note that the vehicle has 27,243 miles on it, and these are the original TPMS sensors/wheels/tires that the vehicle came equipped with from Ford.

  • 11/15/2023· POWER TRAIN,BACK OVER PREVENTION

    The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V735000 (Back Over Prevention), 22V255000 (Power Train), and 23V675000 (Power Train) however, the parts to do the recall repairs were not yet available. The local dealer was contacted and determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

  • 11/15/2023· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

  • 11/13/2023· POWER TRAIN

    UNKNOWN My rear axle bolt may fracture. and this repair still has not been done. and Ford doesn't know. when the part will be in, I'm in fear. for my safety.

  • 11/13/2023· POWER TRAIN

    The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V635000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

  • 11/12/2021· UNKNOWN OR OTHER

    When vehicle is up to temperature, there is an overpowering burning smell coming through the vents into the cab. It only occurs at idle and dissipates when the vehicle is in motion. With the hood open, there is some small noticeable amount of smoke coming from the left side of the engine compartment. The smell is not plastic or rubber.