2021 Ford Expedition EL

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/27/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  The “handless” rear hatch opening activates when not intended. This has caused a concussion to a driver while loading a vehicle. While this is not a “driving” system, it causes injuries to occupants immediately prior to driving. It is entirely possible that a driver could suffer a head injury without knowledge, then begin driving. This causes a dangerous driving environment. In particular the system is supposed to operate when the key is in a persons pocket and the foot is waived in the air by the hitch receiver area. The issues exists because it activates even if an object moves under the vehicle when key is in the correct proximity. This can even pin a driver down with the door over thier back while loading. Again this causes injuries and issues that may not be discovered until driving. In this particular incident the driver was loading the cargo area, when the door activated to close unknown to driver. At the same time the driver was leaning back and standing back up hitting his head on the door while it was closing on him. Approximately 10 to 15 minutes later after finishing loading, the driver drove away (sole occupant). After another 10 to 15 minutes later driver was feeling dizzy and un able to focus. The driver stopped the vehicle and sought medical attention. The driver was diagnosed with a minor concussion. While this had a good result, it could have easily escalated or caused a serious accident. It is recommended that a safety advisory about the potential risks of automatic door opening/closing is released. In addition it is recommended that the manufacturer enable the ability to disable the automatic function in the vehicle system in a manner where it only comes back on after a user turns it on.

• 12/26/2024· STRUCTURE

  The right tail lamp on my 2021 Ford Expedition was loose, and the tail lamp completely fell off while I was driving. My safety and the safety of other drivers was put at risk when the tail lamp fell off because my tail lamp was not visible to other drivers. The vehicle was not involved in any accident, and the tail lamp is in perfect condition. My car is at the dealership currently to get it fixed, and the technician stated that the tabs are broken on the backside of the tail lamp so it is not able to lock into place. The tail lamp has to be completely replaced. There were no warning lamps, messages, or any other type of indication that the tail lamp was loose. I believe this was caused by a manufacturer defect.

• 12/25/2022· ENGINE

  My intake manifold has been experiencing corrosion. I took it to the dealership for inspection. They said they couldn't determine what was causing it but confirmed it was a process of corrosion. After my own investigation, I have realized there is a design flaw in the gutter area where the bottom of the windshield meets the hood. When it rains or when I get a car wash, the fluid/water is channeled toward the center of the windshield and drains onto the intake manifold and other various surrounding engine parts underneath the hood. I have never seen this happen in other cars. It's a bad design that will eventually corrode the engine. Furthermore, it may be affecting some electrical components under the hood near the intake manifold. This is bad. Please look at the design on the 2021 Ford Expedition XLT. Not sure if this is how they have designed it on other model years, etc. It's a real problem that will cause some serious problems of the engine down the road.

• 12/18/2025· POWER TRAIN

  During highway operation, vehicle transmission makes very loud and angry sound and then loses ability to move , almost caused us to get hit at an intersection. Vehicle often jumps violently when shifting to reverse, and often loses propulsion when going uphill and shifting. No issues have been identified by mechanics but I have found several forums on line with drivers reporting similar occurrences. This is very dangerous and if not addressed will result in loss of life. We purchased this vehicle certified by the dealer with 92000 miles on it and it began doing this less than a week after purchase. We took it in for recall work and reported it and they said nothing was wrong with it. Manufacturer failure to rectify this very common problem is going to cause may citizens to be injured or killed.

• 12/16/2022· POWER TRAIN

  What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission slams down into gear from 9th to 8th gear. It also slams in stop and go traffic from 4-5, 5-6. It is available for inspection. How was your safety or the safety of others put at risk? The transmission jerks hard enough to move you in your seat and could cause accidental breaking or acceleration. In stop and go traffic it could cause you to rear-end someone because it lags shifting. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has been back to the dealer 4 times for this issue. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there are not warning messages. It has done this since 17,000 miles.

• 12/13/2022· FORWARD COLLISION AVOIDANCE

  I have just found out that my pre-collision assist system has never worked in my vehicle since the day I purchased it brand new from the Ford dealership. My vehicle is 1 1/2 years old now and I never knew I had this function. Recently, I got a chip in the center of my windshield and I got it fixed. I asked how much a new windshield was and I was told a price and to make sure I get OEM glass and to have the camera in the front where the rearview mirror is calibrated correctly so the pre-collision assist will work correctly. I was somewhat confused and was like ok. I searched for the settings in my vehicle and sure enough there is a pre-collision setting which has been ON since who knows when because I never touched that setting before. Well, it has never worked because I have had countless encounters with vehicles and pedestrians cutting me off right in front of me while in operation. This is not good. And I read that 2020 Ford Expeditions have been recalled because of this. I believe it's happening to 2021 models as well. I expect to take my vehicle in for service ASAP.

• 12/12/2024· AIR BAGS,SERVICE BRAKESCrash

  I was in an accident on December 9 at 2 pm it was slightly wet out & 51 degrees i was making a left turn out of a business went into the middle lane and gave some gas to merge into the lane and the back end of the vehicle locked up and swung into a tail spin to the right as I applied the brakes it locked up worse and the vehicle spun around twice. Went into oncoming traffic and was hit. Had to exite the vehicle on the passenger side because i could not open the drivers door. When the police and tow truck came the both could not believe the airbags did not deploy . The car was found to be totaled by my insurance Co. AAA The fact that not one of the airbags didn’t deploy is very disturbing to me!!! This was my first Ford and dont think i will ever own anther.

• 12/11/2024· STEERING

  The contact owns a 2021 Ford Expedition. The contact stated that the vehicle was difficult to steer and was pulling to the left and to the right. There was no warning lights illuminated. The EPAS system was turned off by the owner. The vehicle was taken to an independent mechanic for an alignment. The vehicle was repaired but the failure recurred. The contact received notification of NHTSA Campaign Number: 24E055000 (Steering); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact requested a buy back, but the vehicle failed to meet the requirements. The approximate failure mileage was 24,000. VIN tool confirms parts not available.

• 12/09/2024· POWER TRAIN,ENGINE

  The contact owns a 2021 Ford Expedition. The contact state while driving 55 MPH, there were abnormal sounds coming from the engine and the transmission. The temperature gauge warning light was illuminated. The vehicle was taken to a Chevrolet dealer twice to be diagnosed. The contact was informed that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. After the second repair the contact noticed that the engine was overheating. The vehicle was taken to a Ford dealer and the transmission was replaced another time. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 89,035.

• 12/05/2025· POWER TRAIN,ENGINE

  The contact owns a 2021 Ford Expedition. The contact stated that while driving at 45 MPH, the engine overheated. The message “Drive Mode Inoperable” was displayed. The contact pulled over for 20 minutes, and the vehicle was restarted. The vehicle was towed to the local dealer, who confirmed that parts were on back order for NHTSA Campaign Number: 22V346000 (Engine). The vehicle was diagnosed, and it was determined that the failure was due to the transmission. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 99,130.

• 12/03/2025· POWER TRAIN

  Have had jerky shifts and hard down shifts while driving 2021 Ford Expedition. Told dealership and was told it was normal. Then went in for oil change told the dealership about lose of power while shifting and hard shifts they advised to have transmission fluid changed. Not even 3 weeks later while pulling out onto a busy road my vehicles engine revved very high but the transmission never engaged past 2nd gear. I was almost hit by a car coming at me on the 2 lane road. After letting off the gas and then reapplying gas the transmission engaged. I drove to the dealership. Today they informed me that the transmission has multiple failures at the shift point between 1-2 and 7-8 along with hard down shifts between 4 and 3 gears. Was informed that the transmission would need to be replaced. I never got any error or warning codes that anything was wrong. I told the dealership that I felt unsafe driving the vehicle due to the transmission. The first instance happened less than a month ago. My vehicle is at the shop now waiting to have a replacement at my expense when Ford knew what the transmission is like.

• 12/01/2025· POWER TRAIN

  While attempting to pass a slower moving vehicle and changing from the right lane to left, I attempted to accelerate past the vehicle when the check manual light appeared on the vehicle display dashboard and I lost all power. I had no acceleration and no power from the gas pedal, after gliding past the slower vehicle and completely taking my foot off the gas pedal, the truck reset itself and power came back to the vehicle and was able to accelerate again, as if nothing happened.

• 11/25/2025· ELECTRICAL SYSTEM

  In the fordpass app, we get a notification that the vehicle has turned off certain function due to inactivity in order to reserve power. However, we will have just driven the vehicle. This message should only populate when the vehicle is inactive for 14 days. It can also populate when the battery drops below 9V or due to extremely hot or cold conditions. It is 70 degrees F outside, so this reduces the reason to only one problem, and that is the battery less than 9V. We just spent over $700 at the dealership on a new battery and service charges because they said it was a battery problem. We spent over $100 the first attempt to find the problem with a sync update. Now, with a new battery and updated sync, out vehicle is still draining the battery. Low and behold, when the message populate in the app, the vehicle will not start, leaving us stranded on multiple occasions in town. The dealership at Long Lewis Ford in Muscle Shoals cannot find the problem.

• 11/25/2024· ELECTRICAL SYSTEM

  My car continues to have electrical problems since 14 months after my purchase. I have reported it to Ford service multiple times as well as Corporate. Each time the same problem happens, I report it here as well. This is the 5th time that this has happened. Each time it has happened, I am at a red light and while waiting, my car just shuts off completely. In the beginning I could press my start button after 1-2 minutes and my car would restart. However, the 4th time it took 9 minutes before my car would start up. It happened again this past week. It took no longer than a minute for my car to start up again. I went to my local dealership and after they took a look, they just think the button with the "A and an arrow circling it" just triggered something and thats why it shut off. They told me there was nothing that they could do. My battery looked fine. This has happened so many times to my vehicle and its the same response, "my car is fine," it just triggered because it's "cold outside." Just tired of the Ford Corporation not fixing this problem in the Expedition. I have read stories on here with the same issue. Be aware if you drive this vehicle because one day someone will seriously get hurt.

• 11/24/2021· ELECTRICAL SYSTEM,ENGINE

  The contact owns a 2021 Ford Expedition. The contact stated that upon starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the soy-based electrical wires had been damaged by rodents. The manufacturer was notified of the failure and informed the contact that they would cover the cost of the repair. The vehicle was repaired. The approximate failure mileage was 3,100.

• 11/22/2022· UNKNOWN OR OTHER

  The contact owns a 2021 Ford Expedition. The contact stated while driving 70 MPH, the vehicle decelerated without warning. The vehicle was taken to the dealer but no cause for the failure was found. The contact stated that the failure persisted. The manufacturer was contacted but offered no assistance. The contact was referred to the NHTSA Hotline for assistance to file a complaint. The failure mileage was 21,000.

• 11/18/2024· EXTERIOR LIGHTING

  Passenger side front headlight failure. The LED turns purple. Appears this is a common problem on vehicle with this type of headlight assembly F series as well. Dealers claim they don't know about it but a quick search to find its a common issue. Available for inspection. Light failure, confirmation is it is now always that way. Was inspected at the dealership and informed it was $3000 to replace the light assembly. No warning driver in front of me informed me to the issue.

• 11/17/2023· POWER TRAIN

  The transmission is a major issue. I have had it in the shop 3 or 4 times now and still experiencing issues. The vehicle goes in and out of gear, doesn’t always accelerate when giving it gas, jerks when slowing down/downshifting. Makes a loud noise during downshifting at times, and the list goes on. Ford knows there are problems and refuses to address the issue, applies a computer update to bandaid the issue, and sends customers on their way to only be faced with the issue a short time later.

• 11/14/2024· POWER TRAIN

  The contact owns a 2021 Ford Expedition. The contact stated that while driving at various speeds, the vehicle would hesitate upon the depression of the accelerator pedal without warning. During one failure, the contact shifted the vehicle from drive(D) to park(P) and the vehicle began to roll backward as though the vehicle were in neutral(N). The contact then shifted the vehicle back to drive(D) and the vehicle resumed normal operation. The vehicle was taken to a dealer where the contact was informed that the only way to diagnose the problem would be to duplicate the failure. The manufacturer was also notified of the failure and the contact was given the same information as the dealer. The contact was then referred to the NHTSA Hotline to file a complaint. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 41,000.

• 11/13/2022· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Issues started after the under the hood fire recall. When driving the vehicle the car will shut down and throw all lights on the dash. This vehicle has been in the shop for repairs, but not fixed. This is a safety issue due to the fact the the vehicle will shut down while driving leaving you stranded when it happens.

• 11/10/2025· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  Vehicle stalls out upon driving when trying to accelerate. Has popped up error which states to check fuel pump.

• 11/09/2023· BACK OVER PREVENTION

  The contact owns a 2021 Ford Expedition. The contact stated that after shifting into reverse, she became aware that the rearview camera was not functioning as needed and failed to display an image. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number: 23V022000 (Back Over Prevention) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 50,000.

• 11/04/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES

  I was on my way to my daughter's school. We got off the on ramp to her school and while waiting at the red stop light, my car stalled. The wheels locked. My brake pedal and gas pedal were not working when the stop light turned green. The car dashboard was showing the power to be on but nothing was working. After a minute, the battery light and the a light with the arrow that kind of circles around it started blinking. I put my hazards and waved people behind me to go around me. After a few minutes, my car started to go backwards on the on-ramp. I looked back and could feel and see my car going backwards toward the cars behind me. The traffic behind me on the on-ramp started to honk at me. They could see what was happening too. I put the car from drive to park and put my emergency brake and the car stopped. I called 911 and explained what was happening. After a few more minutes, two men in two different vehicles came and offered to help push my car. One of them asked me to put my car in neutral but my car was not allowing me to turn to the different shifts. All of a sudden my car starts blinking again. One of the guys told me to try to press the power again. All of a sudden my car starts powering up again. I thanked the two men and finished dropping off my daughter to school. From the time my car stalled and turned back on was about 8-9 minutes. This car has shown problems over and over with Ford. I have had 3 new car batteries since owning this vehicle in the 3 years I've had it. I've reported all the different car issues on the NHTSA website. I just had my oil changed a few months ago. My car just had a few things fixed in June. I have never been so shaken up like this before. My legs and hands could not stop shaking. I couldn’t stop crying. I’ve never been so scared in my life in this vehicle. This was the first time my kid was with me when my car has stalled like this. For my car to lose complete function was the scariest moment in my life with my kid.

• 11/03/2022· POWER TRAIN,AIR BAGSCrash

  The contact owns a 2021 Ford Expedition. The contact stated that as his wife had attempted to park the vehicle, she placed the gear shifter into park(P) and let her foot off the brake pedal. Once she released her foot off the brake, the vehicle abruptly accelerated forward and hit a storage shed. The contact depressed the brake pedal multiple times during the failure but the brakes failed to engage. No warning lights appeared on the instrument panel during the failure. The air bags did not deploy upon impact. The police were not called and no medical assistance was needed. The storage shed was destroyed as a result of the impact. The contact called the dealer and made an appointment for a diagnostic. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was unknown.

• 11/02/2022· POWER TRAIN

  The contact owns a 2021 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle briefly lost motive power with several unknown warning lights illuminated. The vehicle was able to accelerate shortly after losing motive power. Additionally, the transmission experienced rough shifting into the intended gear. The vehicle was taken to the dealer, where it was diagnosed with transmission valve body failure and the transmission valve body was replaced. The failure recurred while the contact’s wife was driving with the vehicle jerking. The vehicle was taken back to the dealer, and the dealer reset the transmission. The manufacturer was not made aware of the failure. The failure mileage was 13,722. The contact has stated that the vehicle's issues has caused multiple occurrences that could have resulted in an accident.

• 10/23/2024· VISIBILITY

  The contact owns a 2021 Ford Expedition. The contact stated that while the vehicle was parked, the contact noticed a puddle of blue windshield washer fluid on the ground underneath the vehicle. In addition, the contact stated that the washer fluid was also coming into the front floorboards of the vehicle. The contact stated that due to the failure, the interior of the vehicle had an awful odor and mold. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact stated that he had not refilled the windshield washer fluid reservoir in 6 months due to the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 27,000.

• 10/21/2024· POWER TRAIN

  When stopped, the auto start stop comes on and the engine turns off. Suddenly a warning comes on and says that the vehicle has to be put in park and push the start button to start the engine again. It will not start automatically when the brake pedal is released. This has happened a number of times. I have not been to the dealer.

• 10/21/2021· BACK OVER PREVENTION

  The reverse camera system does not display any images, i.e., the screen is black/blue (depending on night/day) and provides no view of what is behind the vehicle. The motion and parking sensors are still providing input, but the driver cannot see what the sensors are detecting. Since this is a large SUV with multiple blind spots, this creates a hazard when trying to back up the vehicle.

• 10/20/2025· POWER TRAIN,ELECTRICAL SYSTEM

  Nn 9/15/2025 While the car was running but parked, we began to smell burnt plastic/electrical. Upon trying to shut off the vehicle several service lamps came on advising to go immediately to a service center and that there was a powertrain issue. Vehicle would also not shut off. Upon arrival at dealership they diagnosed that the battery box had corroded and would need replaced under the 1time battery Junction box replacement campaign (22N19). Upon repair they discovered that the wiring harness was badly melted and would need replace part [XXX] . The problem lies here. This part is backordered with no date for availability. Ford refuses to acknowledge this as a problem, and will not help with rental or loaner assistance, as that repair shouldn't take more then a few hours to complete. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 10/19/2022· VISIBILITY

  The contact owns a 2021 Ford Expedition. The contact stated while driving approximately 80 MPH, the sunroof inadvertently exploded. No warning light was illuminated. The vehicle was taken to the dealer where the cause of the failure could not be determined. The vehicle was repaired. The manufacturer was notified of the failure and a case number was provided. The contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 18,000.

• 10/18/2022· ENGINE

  The contact owns a 2021 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V346000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/11/2021· BACK OVER PREVENTION

  Backup camera does not always work and cuts out. Also, the 360 view cameras cut out. It is hard to see in the back during low light conditions with tinted back window. Afraid would hit someone or something when backing out in public parking spaces etc. or from home driveway. Yes, it was brought to dealer's attention in April 2021 right after vehicle was purchased and then again followed up July 2020 with no updates or repairs. Dealer acknowledged the issue and said the part is on back order.

• 10/09/2025· POWER TRAIN

  The contact owns a 2021 Ford Expedition. The contact stated that while stopped at a red traffic light and attempting to accelerate, the vehicle briefly lost motive power. Additionally, the contact heard an abnormal thumping sound coming from the transmission, and the vehicle experienced a hard shift before returning to normal functionality. The contact stated that the failure had been recurring while driving, nearly causing the vehicle to be rear-ended on several occasions. No warning lights were illuminated. The vehicle was taken to the dealer, where DTC: 10R80 was retrieved, and the vehicle was diagnosed with transmission failure. The vehicle was not repaired due to cost.  The contact stated that the transmission was struggling to shift into the intended gear while driving recently. The manufacturer was notified of the failure, but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

• 10/08/2024· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  At 40,000 miles Transmission skips gears going from 3-4 4-5 and 7-8. Transmission jolts hard when put into reverse. Valve body was replaced which fixed the issue for a couple of months and now the same issues are occurring.

• 10/07/2025· POWER TRAIN

  10R80 transmission jerky shifting and failing to engage correctly leading to loss of power and unsafe driving/ jerky acceleration.

• 10/06/2022· VISIBILITY,ENGINE

  The contact owns a 2021 Ford Expedition. The contact received notifications of NHTSA Campaign Number: 22V250000 (Visibility) and 22V346000 (Engine) however, the parts to do the recall repairs were unavailable. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact had not experienced a failure. Parts distribution disconnect.

• 10/04/2024· ELECTRICAL SYSTEM,ENGINE

  The Engine is shutting off completely. I am getting the message "Shift to P. the Restart Engine" This happened as the light changed to green. Heavy morning work traffic was behind me and I had never seen this before and called Ford Service manager and he had no answer. This is very dangerous especially during traffic.

• 09/27/2022· POWER TRAIN,ENGINE

  I am concerned about the shifting or transmission in my new 21 expedition. Purchased new less than a year ago, currently less than 20k miles but the vehicle shifts gears hard, sometimes it seems it wants to up shift while in park or braking. The shift is shaky at times and I now put in park when stopped at a drive through because the last time I went to the bank while waiting with brake applied the car felt as if it was going to just drive off, I immediately put in park. This is scary because my kids rode with me and I dont want the gears to shift incorrectly and cause us to wreck. Dealer asked me to schedule a time when I can leave my vehicle for an unknown amount of time. In order to get a loaner the first available date to drop it off is November 17,22 which is over a month away.

• 09/25/2023· ELECTRICAL SYSTEM,BACK OVER PREVENTION

  Back up camera stays lit after putting the car in Drive. After 30 seconds or so it goes off and the screen goes black. You cannot push any buttons on the screen, related to the radio or climate controls. Ford doesn't know how to fix it because its not a "Major Issue" What a joke.

• 09/24/2022· POWER TRAIN

  Transmission routinely goes out of gear making a weird grinding sound, loses power and decelerates without warning. This has occurred at speeds from 10 mph to 70 mph. Neighborhood streets, roads, highways, and interstates. Very dangerous situation. The vehicle has approximately 22000 miles and this has occurred 20 times at minimum. I have been extremely lucky that this has not caused an accident or crash. The vehicle was purchased new from the dealership. I informed the dealer after numerous occurrences. The dealer inspected the vehicle in August. They said the vehicle computer time stamped the issue but they could determine the issues??? The same transmission problem has occurred 5 times since August.

• 09/23/2025· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  Wiring has soy based bioplastic insulation which apparently attract rodent damage. This damaged battery, caused spark plug to be damaged and need to be replaced. It has also caused voltage and computer performance problems affecting engine idling and shifting. Issues were extremely unpredictable and hard to diagnose leading to 5 visits to the shop and many failed attempts to repair.

• 09/22/2025· SEAT BELTS

  The contact owns a 2021 Ford Expedition. The contact stated that while driving at 20 MPH, the contact heard a loud banging sound coming from the driver’s side seat belt. An independent mechanic or a dealer was not contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 24V099000 (SEAT BELTS); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 85,000.

• 09/21/2025· UNKNOWN OR OTHER

  Vehicle panoramic sunroof shattered imploded while driving for no visible external cause.

• 09/21/2023· POWER TRAIN

  My car has stopped accelerating in the middle of a highway going 75 and wrench light pops up. Ford is looking into it but apparently it needs to be recalled. I hope they extend my warranty. This is so scary. My kids and I almost suffered an accident as our car stopped in the middle of passing on the freeway

• 09/20/2025· FUEL/PROPULSION SYSTEM

  The fuel pump failed without warning leaving the vehicle stranded in the express lane of a highway. This exposed the vehicle and occupants to serious risk of collision. The vehicle does not allow the transmission to shift to neutral to move the vehicle from live traffic lane when the engine is not running. This is the same fuel pump model at the heart of the ongoing recall on other ford vehicles.

• 09/20/2023· POWER TRAIN

  I own the 2020 Expedition. We were traveling on Interstate 287 yesterday. I was in the right lane and was stuck behind a slow moving semi-truck. I put on my blinker and waited for an opening in traffic to move into the middle lane. When an opening presented itself, I pressed down on the gas pedal to accelerate into traffic. While the truck should have down shifted and accelerated, instead the powertrain completely disengaged; a total loss of power. The RPM jumped way up to redline, over revving, but the truck was slowing down. I took my foot of the gas pedal and as the RPM came back down, the transmission slammed back into engagement with a loud audible clunk that jolted the whole vehicle. At this point, I was finally able to accelerate. While this was all happening, I had just moved into the middle lane of traffic, which was bearing down on us. All the vehicles behind us were slamming their brakes and honking their horns. I thought for sure we were going to die. Thank God it wasn’t an 80,000 lbs Peterbilt bearing down on us, or we would be dead, by the grace of God we’re not. Upon returning home I went onto the Ford truck owners website I belonged to. I came to learn this is a known issue with Ford’s 10-speed transmission that Ford has failed to address. That there are pending lawsuits and that the NHTSA is aware of the issue. One of the member suggested that I file a complaint with the NHTSA, that was my impetus for writing you today. This is a dangerous condition that Ford needs to remedy.

• 09/19/2025· POWER TRAIN,STRUCTURE,VISIBILITY/WIPERCrash

  While towing a rented trailer from Tractor Supply, the trailer detached because it was not properly secured by store staff. The trailer struck the rear bumper of my 2021 Ford Expedition, causing visible body damage and raising concerns about hidden damage to the drivetrain and transmission due to the sudden force of the impact. After the incident, the vehicle was taken to a Ford dealership for inspection. Documentation exists showing that additional drivetrain and transmission evaluation is needed to determine the full extent of damage. The rear-view camera is also under active NHTSA recall (25V048), and its poor image quality complicates safe reversing after the incident. The safety risk is significant: the trailer detachment created a roadway hazard and impact, while the rear camera defect reduces visibility and increases crash risk when backing. The vehicle has been inspected by a Ford dealership and is being reviewed under an insurance claim with Tractor Supply’s insurer. Full documentation of the service visit and inspection is available upon request.

• 09/18/2025· SUSPENSION

  See attached document for complaint.

• 09/18/2023· POWER TRAIN,ENGINE

  The contact owns a 2021 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the side of the roadway, and after restarting the vehicle, the vehicle returned to normal functionality. The contact stated that the failure had since become a persistent failure. No warning lights were illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 43,000.

• 09/17/2022· VEHICLE SPEED CONTROL

  For the 3rd time attempting to pass other vehicles our transmission revved up to almost 5000 rpms and would not shift after making a huge clunking sound into an obviously to low gear. We had no power and the vehicle would not accelerate. I do have a video after the clunk sound but can't upload it.