2021 Chevrolet Blazer

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2025· ENGINE

  Radiator failure caused power steering assist to not function properly and insufficient vehicle heat function. Engine electric fan would run continuously after vehicle shutdown.

• 12/19/2024· ENGINE,FUEL/PROPULSION SYSTEM

  On [XXX], I was driving my Blazer up to our local Museum to grab some information. The Museum is about a mile and a half from my house. When I had left my house, the car was driving like normal. I pulled into a parking spot at the Museum, and I went to shut the vehicle off, and I thought maybe the check engine light had come on but wasn't completely paying attention to the dash. About 10 minutes later I went to restart the vehicle to leave and I noticed the check engine light on. Since the vehicle seemed to be driving okay I thought I could make it home and check the car's computer to see what the issue was. As I was leaving the parking lot I stopped at the end of the parking lot to look before pulling out onto the road and the Blazer said shift to neutral and restart the vehicle. When I did that the vehicle would not start. It would just crank and crank and then it would finally start for a few seconds. I was going to back my vehicle up out of the road but each time I would try the car would die. I am very thankful this did not happen on the highway or even on the freeway. A friend and myself had to push my vehicle back into a parking spot. The DTC code is a P023F. When this happens, you can't technically shift the vehicle into neutral to push it out of the way because the car has to be running to shift. I was able to force it into neutral, however. I made an appointment with Awesome Chevrolet in Chehalis WA and had to have it towed to the dealer. They stated it was the fuel pump module. I had at that time 18,388 miles on the odometer. Unfortunately, I no longer feel safe with this vehicle in case it happens again. Where I am hours from home or on a 2-lane road or freeway. The fuel pump module failure appears to be a known issue with GM vehicles. The fuel pump module was replaced and was able to be replaced under warranty. I hope that it does not happen again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/15/2025· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  For about a week and a half my car had made a high pitched wheezing/hubbing sound when started cold. This occurred at all temperatures cold and warm. Yesterday December 13th I went to run some errands and about a mile into my drive my 2021 3lt 3.6 V6 Chevrolet Blazer lost the ability to power itself. There was no electrical problem however the power train lost power all gears drive and reverse. I was able to get off the roadway without incident. I scan my check engine light and had several check engine lights including a P 0796.

• 12/13/2022· TIRES

  The contact owns a 2021 Chevrolet Blazer equipped with Continental Tires, Tire Line: Crosscontact LX Sport, Tire Size: 235/65/R18, DOT Number: A3LMWD304920. The contact stated that the tread on all four tires were worn. The vehicle was taken to the dealer and the contact was informed that the tires needed to be replaced. The contact was informed that the VIN was not included in NHTSA Campaign Number: 20T018000 (Tires). The tires were not replaced. The manufacturer was contacted and confirmed that the tires were not included in the recall. The contact was advised to contact the NHTSA hotline to file a complaint. The failure mileage was 20,000.

• 12/09/2025· ELECTRICAL SYSTEM

  "Steering assist reduced" message was displayed. At the same time the temperature gauge stopped working and after I shut the car off, the motor fan ran full force for 10+ minutes. Shows no check engine light.

• 12/07/2025· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  My 2021 Chevrolet Blazer experienced a radiator failure at approximately 42,000 miles. The radiator and cooling system malfunctioned, causing coolant loss and triggering a warning light on the instrument panel. The failed radiator is available for inspection upon request. This defect put my safety and the safety of others at risk because a compromised radiator can lead to engine overheating, sudden loss of power, or even steering assist reduction while driving. These conditions increase the likelihood of an accident, particularly at highway speeds. The problem was confirmed by my Chevrolet dealer, who diagnosed the radiator as needing replacement. They initially quoted $1,800, later reducing the cost to $915.90 after acknowledging that approximately 20 customers per month at their dealership alone are experiencing the same issue. This indicates the defect is widespread, at least regionally, and may be systemic across the model. The vehicle has been inspected by the dealer service department, which is an authorized GM representative. No police or insurance inspection has occurred. Prior to the failure, a warning lamp illuminated on the instrument panel, alerting me to a cooling system issue. This was the first symptom I noticed before bringing the vehicle in for service. I believe this premature radiator failure represents a systemic defect in the 2021 Chevrolet Blazer’s cooling system. It occurred well within the 5‑year/60,000‑mile warranty period, yet the dealer claimed the radiator is not covered. I am requesting NHTSA investigate this issue, as it appears to affect many owners and poses a significant safety risk.

• 12/03/2025· FUEL/PROPULSION SYSTEM

  Driving along vehicle shut down in middle of road replace fuel pump, fuel module control in August 2025. Now both top and bottom fuel hose needs replacing. On Nov 2025 I smelled gas and vehicle shut down

• 12/02/2022· POWER TRAIN,ENGINE

  The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving approximately 10 MPH and attempting to make a left turn, the vehicle stalled. The contact depressed the accelerator pedal aggressively several times to get the vehicle to start moving again. The failure reoccurred while the contact’s daughter was driving and attempting to make a left turn at a green light when the vehicle stalled. The contact stated that the failure persisted while driving and attempting to turn to the left. The failure occurred intermittently. The contact stated that only the rear tires would move. The contact took the vehicle to the dealer who was unable to find the cause of the failure. The dealer was not able to duplicate the failure. The failure persisted. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 28,000.

• 11/28/2023· ENGINE

  The contact owns a 2021 Chevrolet Blazer. The contact stated that the check engine warning light was illuminated. The contact was unable to use the electrical features in the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the purge pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case. The approximate failure mileage was 36,000.

• 11/26/2024· STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  P0128, AC not working, Steering Assist Reduced, and Temp Gauge not working. Problem caused by faulty ECT wiring. First the problem is the ECT is a two wire (signal + and -) 26 gauge wire running through the ignition coil wire harness. Ignition coil signals are very high voltage and fairly fast frequency which causes a lot of EMI which is easily picked up on a 2 wire voltage based wire set. The ECT wiring should have been a twisted shielded pair if running next to Coil wiring or they could have used a single wire resistance thermistor, but they should have just routed the signal a different way to begin with. This is a design issue and it should be a recall...maybe a class action lawsuit is needed to force them to fix it correctly. The FSB (field service bulletin) fix blames loose connector terminals and it patches the computer software to not include ECT wire failures in the Steering, AC, and temp gauge inhibit logic (overtemp readings will still fail off these functions). Also the P0128 code can come back occasionally.

• 11/26/2024· ELECTRICAL SYSTEM

  Upon driving my vehicle twice it shut off on the roadway once on an incline when a message of 2 keys detected and flashed on the dashboard prior to the vehicle shutting off. Vehicle would not restart until 15 minutes later it restarted but the dashboard kept flashing 2 keys detected. There was only one key in the vehicle at the time and the key fob has had the battery replaced upon the first incident which was on 11/14/2024 and the second incident was on 11/16/2024.

• 11/24/2025· STEERING,ENGINE

  In September 2023, when getting my vehicle serviced for a routine oil change, I was told there was a leak in my radiator. They replaced the entire thing under warranty. On November 15th, 2025, while driving on the highway heading home from out of town with my children, an error flashed up saying “steering assist is reduced – drive with care” Upon arriving home, the fan on my car was running on high for a solid 10 minutes after turning the car off. No recall but Special Coverage N252508350 covers the thermostat replacement. Upon inspection by a mechanic, I was informed that the radiator is also leaking again in the exact same spot as it was previously. It should be noted I have never seen leaking fluid in my garage/driveway. I’ve driven less than 10,000 miles since the radiator was replaced previously. If there is a known problem with the coolant system which can cause overheating and steering assist issues, why isn't the faulty radiator and thermostat recalled. The radiator is cased in plastic to aluminum. Plastic can easily catch fire if a car overheats. The casing also prevents an owner from even knowing if there is a leak since the plastic is catching leaks - the mechanic informed me that's why I didn't know about both times it leaked. This is a 4yr old car with 46k miles, twice replaced radiator and thermostat. A recall should be issued since both problems could potentially cause a fire from an overheated engine & loss of steering assist while driving. A google search quickly showed me thousands of other Chevy Blazers from 2019-2021 with reoccurring thermostat and radiator issues. I feel unsafe driving in my vehicle but still owe too much to even trade it in for something else. I've owned dozens of vehicles in my lifetime, used and new and keep them 8-10yrs and have never had to replace a thermostat and radiator. This vehicle is dangerous due to GM/Chevy's cheap radiator model and thermostat which could overheat and catch fire

• 11/20/2025· AIR BAGSCrash

  The contact owned a 2021 Chevrolet Blazer. The contact stated that while driving at 30 MPH, a 2012 Mazda CX-7, allegedly going at 70 MPH traveled through an intersection and crashed into her vehicle. The Mazda later crashed into another unknown vehicle. All the air bags deployed; however, the driver's side air bag exploded in her face. The air bag dust was in the vehicle. The contact was rendered unconscious due to the incident. All the warning lights illuminated after the crash. OnStar was activated and disabled the vehicle. There were unknown fluids leaking from the vehicle. There was no reported fire. A police report was filed. The contact sustained a severe brain injury, and medical attention was provided at the hospital. The vehicle was towed to her residence. The insurance company later towed the vehicle on a flatbed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The vehicle was deemed a total loss by the insurance agency. The failure mileage was approximately 36,463.

• 11/17/2024· SERVICE BRAKES

  The brakes failed on my SUV as I was driving on a city street. Yes it is available for inspection. Losing my breaks almost caused a collision with the car in front of me but due to the distance between the cars and the low speed at the time, I was able to avoid collision and detour into a parking lot where I cruised to a stop with the help of a parking lot space concrete stop. The problem was not reproduced by me but the service center computer diagnostics confirmed break issues. The service center says that the cause was low voltage of the car battery which affected the brakes. This is a very dangerous situation if the vehicle can lose complete braking ability due to a low voltage battery. This is the reason for reporting the issue. They replace the battery and said that should fix the issue. They said the only recourse to avoid this happening again is to replace the battery around every 2 years. The issue was inspected by a service center owned by the manufacturer of my SUV. The warning lamps only occurred as the brake system failed. A message of "Brake System Failure" appeared and the "Check Engine" light came on. Within the previous week of the issue the SUV also had other electrical issues such as the Climate Control interface went out and the rear camera also went out.

• 11/16/2025· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  Car was running fine yesterday, today does not want to start. Thought it was the battery, bought anew battery. Still wouldn't start. Rest of cat is getting great power. Code reader is reading its a fuel pump control moduler which just so happens to be in an open recall for my exact year of vehicle yet my vin number does not pop up on the GMC website under active recall. I have a 2021 chevy blazer .

• 11/03/2025· ELECTRICAL SYSTEM,ENGINE

  Action Required "Steering Assist Warning" drive with caution, Temp gage reads cold, A/C stops working, engine cooling fan runs on high speed (even after the engine is shut off), pending P2018 code, with no Check Engine Light (CEL). Replaced Engine coolant Temperature (ECT) sensor, problem did not go away. Several reviews suggest to replace the thermostat, check fuses for proper insertion, reroute ECT wiring, and possibly replace radiator. Most of these repairs can be very expensive. Chevy Blazer Forum states that the issue is a out of range detection of ECT sensor reading. GM needs to determine a true solution and stop guessing at owner expense/frustration.

• 10/29/2025· ELECTRICAL SYSTEM,EQUIPMENT

  See attached document for complaint.

• 10/26/2025· FUEL/PROPULSION SYSTEM

  I was driving at approx 45 mph when my car lost all ability to accelerate and shut down in the street. Flashing check engine light and esc warning on the screen. It would try to start but wouldn't. I had it towed to a mechanic who diagnosed and informed me that it is the Fuel pump power control module. Upon review he I formed me that there was a recall posted in September 2025 for 2021 Blazer on this exact issue. My car has now been unusable for a week as my mechanic recommends it be repaired via recall at dealership.

• 10/24/2024· STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Steering assist reduced message comes on and temperature guage goes down to cold not working and after you shut car off fan runs full force for 10 minutes. Shows no check engine light or no codes.

• 10/22/2025· POWER TRAIN

  I PURCHASED MY 21 CHEVY BLAZER IN 2024 AND HAD A FEW PROBLEMS WITH A TRANSMISSION PROBLEM. THE VEHICLE WOULD STOP AND JERK WHENEVER I DROVE IT. I TOOK IT TO THE DEALER A FEW TIMES FOR REPAIR. THEY CLAIMED TO HAVE FIXED THE PROBLEM, BUT IT STARTED AGAIN SEVERAL MONTHS LATER. THE VEHICLE HAS APPROX 82,000 MILES ON IT. I HEARD THAT THERE WERE SOME RECALLS ON THESE VEHICLES, BUT NOT SURE IF MINE IS ONE OF THEM. I FEEL THERE ARE OTHER VEHICLE LIKE MINE THAT HAVE THE SAME PROBLEM.

• 10/18/2025· FUEL/PROPULSION SYSTEM

  Car wouldn’t crank

• 10/17/2024· ENGINE

  The Radiator has a crack in the upper left front of the core causing the fluid to leak and lose pressure causing the engine to overheat. This is a manufacture defect that has not been addressed as of 10/16/2024. The leak was discovered by a certified GM mechanic at a dealership when doing routine maintenance and inspection. The vehicle has never had any indication or advisory light that would alert the operator. As the engine overheats it can cause many of the other components of the vehicle to disable, including but not limited to the ADAS systems as well as power steering and/or collision safety components. This is a manufactures defect with the aluminum radiator that needs to be addressed immediately. Given the information from multiple GM dealerships the amount of newer low mileage Blazers that have been confronted with this problem is unprecedented. This not only creates a danger for the passengers of the vehicle but also every other vehicle on the road.

• 10/15/2025· ELECTRICAL SYSTEM

  In March after a short drive, 24 miles, the car temp was pegged at Cold. After turning off the car, the fan continued to run several minutes. After a quick internet search several posts commented on a similar issue with their vehicle. Two potential issues were identified - thermostat failure or programming issue. With less than 40,000 miles on the car, I purchased a diagnostic tool. Running the tool program two errors were identified. After resetting the sensors, the problem went away. In September, yesterday and today the problem occurred again - and the error reset fixes the issue. I believe Chevy needs to fix the issue with a recall to either update programming or replace the thermostat. [Several posts state the thermostat replacement didn't fix the issue and is very expensive.]

• 10/14/2025· ELECTRICAL SYSTEM

  Odometer Fraud. The contact purchased a 2021 Chevrolet Blazer. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 9,967, and at the time of registration, it was discovered that the mileage was approximately 38,000.

• 10/09/2025· STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Request for Recall Review – 2021 Chevrolet Blazer Steering Assist and Cooling Fan Issue Hello, I am writing to report a recurring issue with my 2021 Chevrolet Blazer and to request that this concern be reviewed for possible recall or warranty coverage. The vehicle frequently displays an “Action Required: Steering Assist is Reduced. Drive with Care” message while driving. Additionally, after shutting off the vehicle, the engine cooling fan continues to run for up to 20 minutes, as if the vehicle is overheating. This issue has occurred multiple times and raises concerns about potential problems with the steering assist system, cooling system, or electrical sensors. I’ve noticed that other Blazer owners have reported similar experiences online, which suggests this could be a broader issue. Could you please confirm whether there are any existing recalls, technical service bulletins (TSBs), or warranty programs addressing this condition? I would also appreciate guidance on the next steps for inspection or documentation. Vehicle Information: Year/Model: 2021 Chevrolet Blazer

• 10/07/2021· UNKNOWN OR OTHER

  When I am accelerating it seems like my car hesitates to get up to speed, at times feels like it is slipping to get traction. I put my car in AWD and didn't seem to notice the issue, when put back into 2WD, the issue happens, it is not an every time thing, but enough that my husband, who doesn't drive my car a lot noticed it and a coworker who has the same year as mine also has the issue. Of course when I took it into the dealership to have it looked at the car didn't do it, so as far as they are concerned there is nothing wrong with it, which is NOT the case. My husband has a 2020 Blazer and it doesn't have this issue. I understand that it is a different year, but if it has the same engine and transmission I would think there shouldn't be much of a difference in how they both drive. It's very frustrating to spend this much on a vehicle that I leased in May of 2020 and it has been in twice for this issue and the parking break issue (which GM's reasoning as to why this turns on by itself and does not turn off is BS, there is still an issue with this as well) and when serviced there is never anything wrong with it. So could it be an issue with the transmission, traction control or possibly the engine?

• 10/06/2022· ELECTRICAL SYSTEM,ENGINE

  I went out to start my car and the light said that it was not reading the key fob because of low battery. I went and got the other key fob which had never been used and had the same result. The car was towed by Chevrolet to the dealer and it has been there for over 3 weeks. They found that it wasn't a faulty key fob but it was the receiver that gets the signal and allows the door locks to open and the engine to start. I tried moving the shift lever, stepping on the brakes, trying the remote start on the key fob and nothing would start the car nor would it lock/unlock the doors. It just kept giving me the notice that it couldn't read the key fob. I called ONSTAR and tried the actions they told me but that did not work either and they said to contact my selling dealer. ONSTAR contacted the Chevy warranty number for a tow truck but at 9PM it was too late for them to make a service call. What if I was out in a parking lot or in a remote area and experienced the same problem with no assistance. I have been trying to find out what the dealer is doing to repair my vehicle but I have to call the GM complaint line in order for them to try and contact the dealer about my car. They finally gave me a rental vehicle since the vehicle is less than 1 year old and only has about 6,000 miles on it.

• 09/30/2025· POWER TRAIN

  The contact owns a 2021 Chevrolet Blazer. The contact stated that while her husband was driving 60 MPH, the "Service Engine Soon" message was displayed. The contact's husband pulled over to the side of the road. The contact's husband used his personal FIXD machine to diagnose the vehicle. The contact’s husband retrieved DTC: P023F (Powertrain Control Module Detected a problem in the Electrical Pathway supplying power to the Fuel Pump). The vehicle was towed to an independent mechanic who diagnosed the vehicle and determined that the fuel pump had failed. The vehicle was then towed to the dealer. The vehicle has not been diagnosed. The contact related the failure to Manufacturer's Recall Number: N252516900. However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was 90,493.

• 09/25/2025· ENGINE

  Radiator leak, leaking antifreeze

• 09/23/2025· POWER TRAIN

  Steering assist reduced warning came on with engine light. When car turned off , radiator fan continued running for a few minutes before turning off. AC would also not work during this time. Issue has been intermittent. Was told the thermostat was getting stuck open and needs replaced.

• 09/21/2023· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  Receiving 3 different errors on dash display. 1) Action Required- No Remote Detected 2) Action Required- No Remote Detected Press Brake to Restart 3) No Remote Key Wa Detected Place Key In Transmitter Pocket Then Start Your Vehicle. All of these errors are intermittent and have appeared with using 2 different Remotes. Batteries have been replaced also. This in itself is not so much a safety hazard (annoying), but what is intermittently happening is the car shuts down while in drive and in reverse. So far it has not shut down on the freeway but has shut down while on City streets. We have taken it to 2 different GM Dealers a total of 7 times in the last 3 months(currently at the dealer now). Each time the dealer is saying they cannot duplicate the errors. We get it back and within 1 (usually the same day)day it is right back with the errors. Clearly these errors are a nuisance and dangerous if the vehicle shuts down. I have additional service documents and photos and videos but due to the maximum I can provide they are not uploaded.

• 09/20/2025· SERVICE BRAKES

  Brake booster failed after 50k miles needing repair. Brake became very still, prolonging the time it takes to stop the vehicle

• 09/19/2025· ENGINE

  Was informed at today's oil change that my radiator is leaking and it's something that they are seeing a bunch.

• 09/16/2025· UNKNOWN OR OTHER

  my vehicle is roughly 40k miles. The temp gauge was stuck on C the cooling fan was running continuously even when the car was off and the checked engine appeared. The mechanic at the dealership said the thermostat is stuck in open position causing the computer not to know if the engine is cooling properly. For a vehicle less then 5 years old with upkept maintenance and doing a bit of research... This is a common occurrence in Chevy vehicles. Therefore, the manufacturer needs to look into recalling this issue costing people thousands of dollars. This was my first Chevy and probably my last.

• 09/12/2023· SERVICE BRAKES

  The breaks make a squealing noise all the time which is concerning. I was told by Beaver Chevrolet that this is normal as the breaks were changed in newer car models. They have made a squealing noise ever since I bought the car brand new. I took the car into Beaver Chevrolet approximately 4 months ago and was told that they were unable to replace the breaks because they "weren't squealing bad enough". They did spray my breaks down, however they told me that once I hit 36,000 miles if the issue was still occuring (which it will be) that I would have to pay to have the breaks sprayed. The issue persisted and the spray they used only lasted a few days. Typically breaks should not squeal unless they have gone bad, which isn't the case here. I find this issue to be a safety hazard as how are customers supposed to know when their breaks actually do go bad if they squeal all the time. The issue was reproduced, but it is unclear what their standard is for determining the actual noise to breaking ratio.

• 09/09/2025· FORWARD COLLISION AVOIDANCE

  Auto braking system went off when I was at stop light & began to move forward (was 2nd in line of cars) and I accelerated. On the roadway, there are construction 'steel plates' laying on the ground in the area that all cars must drive over (I have driven over them in my same Blazer before) because we have no choice. One I pressed on gas & began moving over those plates, the Blazer stopped itself VERY abruptly & jerked my head forward & dash said I had to press on brake let off or something in order to move again - it was all very fast & I had a line of traffic behind me at 5:15 pm on a Friday (9/5/25). I'm very luck I did not get hit from behind & car behind me paid attention! That is the 3rd time my car has stopped suddenly; 2 times before it was when going up my very steep driveway so I had no one behind me & I wasn't as shook up - Chevy needs to REALLY look at this! It is a hazzard!!

• 09/03/2025· FUEL/PROPULSION SYSTEM

  I was driving down 776 (a busy highway)Blazer completely shut off, so scary almost got hit by a semi, I don’t know how he managed to get around me , I jumped out of car! Sure thought it was my day to die! Called police for help! Had it towed home then to garage , was told it was the electrical fuel modular! Haven’t slept right in 3 days ! I’m still so shaken up!

• 09/02/2026· ELECTRICAL SYSTEM

  The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving 40 MPH, the vehicle stalled and was unable to be restarted. The vehicle was towed to the residence. The husband was a mechanic and discovered the 350-amp fuse failure. The fuse was replaced, and the vehicle was repaired. The dealer was not contacted. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 68,400.

• 08/24/2026· ENGINE

  My 2021 Chevrolet Blazer RS equipped with the 3.6L LGX V6 experienced catastrophic engine failure at approximately 90,200 miles. The vehicle had no prior warning. The dealer diagnosed the timing chain / lift/ cam damage. I am requesting investigation into whether this represents a safety or durability defect affecting other vehicles

• 08/23/2026· ENGINE,FUEL/PROPULSION SYSTEM

  Car will not crank, stalled while cranked, throws code P023F

• 08/23/2025· UNKNOWN OR OTHER

  The temperature gauge or thermostat has been replaced 3 times and continues to fail

• 08/21/2026· ENGINE

  While idling in my driveway, the engine started to shake and the check engine light came on. Got it diagnosed and was told by a private repair center that we had lost compression in cylinder 4 and that it was not worth the repair and we needed to replace the engine. Got it towed to the dealership, Bill Fox Chevrolet, for a 2nd opinion and they confirmed what the private shop had said. Because the vehicle was well maintained with regular preventative maintenance, it was deemed the failure was not the fault of the owner. GM extended a goodwill warranty to help cover the cost of the engine replacement (70% coverage. We were 1 month and 2,000 miles past our warranty). They never told us root cause, only that it would have cost more money to repair it than it would be to get a new engine. The Blazer had been running fine up to that point and was my wife's main mode of transportation. The Blazer only had 62,000 miles on it when the failure occured.

• 08/20/2026· TIRES

  All 4 tires exhibit signs of dry rot impacting the inner sidewalls of each tire. The outer layer is showing significant signs of sidewall separation. There is no sign of damage visible on the exterior side walls, if an inspection was not done on this date 08/20/26 the driver and others would have been at significant risk of injury or death due to catastrophic failure. The worst separation occurred in the front drive / steering tires. While lesser damage was visible on the rear tire the damage was also significant. The driver side rear showed the least damage with only a 2 inch separation. The other 3 tires showed 12 inches or greater separation. Images are available for review.

• 08/17/2023· STEERINGCrash

  The contact owned a 2021 Chevrolet Blazer. The contact stated while driving 69-70 MPH, the steering wheel strongly pulled to the left side and into the roadway median. There was no warning light illuminated. The contact stated that the vehicle hit the median and bounced, facing incoming traffic. The contact slammed on the brakes and shifted into park (P). The air bags deployed. The contact was able to exit the vehicle with the assistance of bystanders. Emergency services arrived at the scene but the contact was not transported to the hospital at the time. The contact later received medical assistance and was informed she had sustained soreness on the neck, shoulders and bruises all over the body. Additionally, the contact was advised she had sustained post traumatic stress disorder (PTSD). A police report was filed. The vehicle was towed to a tow lot, where it was totaled. The dealer was not notified of the failure. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 24,000.

• 08/17/2023· SUSPENSION,FORWARD COLLISION AVOIDANCECrash

  The Esc display came up then sutbality sensor show and my back wheel went right. My car flipped twice and then landed on the guardrail.

• 08/16/2021· SERVICE BRAKES

  The contact owns a 2021 Chevrolet Blazer. The stated that upon depression of the brake pedal, an abnormal grinding noise would emit from the vehicle without warning. When the contact notified the dealer of the failure, he was informed that they were aware of the failure however, there was no fix for the failure. The contact then received a letter from the dealer where he was informed that a repair was under development. Recently, the contact called the dealer for an update and was informed that no update was available and that the repair remained unavailable. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 429. The VIN was not available.

• 08/08/2024· UNKNOWN OR OTHER

  Power Liftgate randomly opens when driving or parked. Even when the power switch is turned to off the liftgate will unlock randomly either parked or driving. I have contacted the dealer and GM no recall currently exists. Dealer recommended replacing the latch mechanism which I have ordered to replace myself.

• 08/06/2025· UNKNOWN OR OTHER,ENGINE

  At routine oil change dealer noticed radiator was leaking. 60,840 miles Took it to an independent repair shop who confirmed radiator needed to be replaced. Has also seen same on other 2021 Blazers. No visible signs of leaking (fluid on garage floor) or warning indicators. No recall issued on this, however, seems to be a common problem on 2021 Blazer based on Chevy forums. Due to safety issues, vehicle is currently in shop for the needed replacement repair.

• 07/30/2026· AIR BAGSCrash

  The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at approximately 50 MPH, the vehicle struck a deer, causing severe damage to the vehicle's front end. The contact stated that smoke was coming from the center of the steering wheel; however, the vehicle's air bags had not deployed. The contact was transported to the local hospital and treated for chest injuries. The vehicle was towed to a local collision center. No further information was available. A Police report was filed at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The failure mileage was 52,661.

• 07/30/2025· SERVICE BRAKES

  My name is [XXX] and I was a passenger in our 2021 Chevy Blazer with our young child in the back seat when the brakes suddenly failed while we were driving on the freeway. The brake pedal went stiff and wouldn’t respond. It was terrifying — we truly felt like we were going to crash. I was panicked, and my child was crying. Since then, I’ve been too afraid to drive or ride in this vehicle, even if it gets repaired. This isn’t the first issue with the car, and GM has not resolved it in a timely or helpful way. The vehicle is currently at the dealership and we are paying for a rental car out of pocket. I’m reporting this because I believe this vehicle poses a serious safety risk to families like mine. I’m asking NHTSA to please investigate this issue before someone gets hurt. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)