2020 Toyota RAV4

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2024· ENGINE

  Check engine light came on and noted a malfunction in the electronic control of the engine, throttle or transmission. When taken to the dealer they found code P012807 related to engine cooling and suggested a replacement of the thermostat. This part should have a life of 100k or 8-10 years and car currently has less than 60k miles and 4 years old. Asked the dealership about known recall 20TA04 - for engine cooling recall but they insisted my car was not impacted. This is a safety issue as it could result in overheating of the engine leading to fire hazards.

• 12/30/2024· POWER TRAIN

  Coolant bypass valve needs to be replaced per Toyota. Many people are having this problem.

• 12/30/2024· ENGINE

  What component or system failed or malfunctioned, and is it available for inspection upon request? The Engine Coolant Bypass Valve B failed. The check engine light comes on and disables All-Wheel-Drive, Radar Cruise Control, Lane Keep Assist and interrupts functionality of the infortainment system. I am also worried that it could have a negative effect on the operation of the engine. How was your safety or the safety of others put at risk? My safety or the safety of others was not put at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The problem has been confirmed by an independent service center. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No

• 12/30/2023· ENGINE

  Engine bypass coolant valve… Engine maintenance required pops up intermittently. Per dealer there is a short circuit in valve/ bypass part. The dealer had already known this was issue prior to car being diagnosed. They stated they are aware and this is a known issue.

• 12/30/2019· FUEL/PROPULSION SYSTEM

  VEHICLE INDICATES FUEL EMPTY (GAS GAUGE AND WARNINGS) AFTER APPROX 350 MILES. FUEL TANK SUPPOSED TO BE 14.5 GAL., BUT TANK ONLY ACCEPTS 9-10 GALLONS FUEL BEFORE SHUTOFF. 1 FULL TANK FROM DEALER PLUS 1 FILL-UP WITH SAME RESULT. VEHICLE ALSO ONLY AVERAGING 36 MPG AFTER 2 TANKS MOSTLY HIGHWAY & NOW INTO 1 TANK MIXED CITY/HIGHWAY (TOYOTA INDICATES 38 HIGHWAY/40 CITY). EITHER FUEL TANK IS DEFECTIVE/CAPACITY IS INACCURATE, GAUGES/COMPUTER/WARNINGS ARE DEFECTIVE, OR BOTH?

• 12/28/2022· UNKNOWN OR OTHER

  -Windshield cowl not properly screened from manufacturer in order to protect from rodents entering . Mouse/rodent infestation found in various compartments, including nests, droppings, and "other material" that made its way into the engine and HVAC, and even a dead mouse in the main cabin- all resulting from entering through windshield Cowl. Service report available if needed -Breathing in mice droppings, urine, and decomposing animals is a major health risk that can cause severe illness. -Service department performed removal, cleaning, disinfecting, and replacements of components. Service Department stated this has been happening much more frequently with the newer Toyota's as the wires used attract these rodents. This one service department in particular has even created a "Rodent Pro Service" for rodent infestation which includes cleaning and disinfecting of affected areas, and also installing a steel mesh screen to avoid future entrance from windshield cowl -Only warning was a dead mouse found inside main cabin

• 12/28/2019· FUEL/PROPULSION SYSTEM

  GAS LIGHT COMES ON AFTER THE CAR HAS CONSUMED ~10 GALLONS. THE VEHICLE IS ADVERTISED HAVING 14.5 GALLON TANK WITH 580 MILE TRIP.

• 12/27/2024· AIR BAGS

  This recall has been in place for over a year and Toyota cannot tell us when there will be a remedy for it meanwhile, driving a passenger in my only vehicle is unsafe.

• 12/26/2020· FUEL/PROPULSION SYSTEM

  VEHICLE GAS TANK WILL NOT FILL TO CAPACITY.. I AM STOPING AT GAS STATIONS ALL THE TIME BECAUSE I AM FLYING THROUGH GAS ..AND IT'S A HYBRID ..WON'T FILL MORE THAN 9 OR 10 GALS .. THE VEHICLE HAS NO RANGE FOR A HYBRID WHICH IS THE EXACT OPPOSITE OF WHAT THEY SAY WHEN THEY'RE TRYING TO SELL YOU ONE.. HAD I KNOWN I WOULD BE AT A GAS STATION EVERY 3 DAY'S WITH A HYBRID I WOULD HAVE NEVER BOUGHT IT

• 12/26/2020· UNKNOWN OR OTHER

  WITHIN A WEEK FROM THE DATE OF PURCHASE ,THE VEHICLE DID NOT START , HAD TO BE TOWED BACK TO THE DEALER, DEALER SAYS THE VEHICLE STARTED NORMALLY THE PROBLEM DID NOT DUPLICATE AT THEIR END. NO FAULT DETECTED. 9 MONTHS LATER WHEN THE VEHICLE HAD A MILEAGE OF 6066 AGAIN IT FAILED TO START, HAD TO BE TOWED BACK TO THE DEALER, DEALER AGAIN STARTED THE VEHICLE NORMALLY NO FAULT WAS DETECTED, LATER WHEN THE VEHICLE HAD THE MILEAGE OF 7079 THE VEHICLE STALLED WHILE IN QUE IN A GAS STATION. FLASHING NOTIFICATION IN THE DASH BOARD INDICATED "DIRT IN THE ENGINE" THE VEHICLE WAS TOWED BACK TO THE DEALER FOR THE THIRD TIME IN A YEAR NEXT DAY DEALER SAYS THEY DID NOT FIND ANY ISSUE IN THE VEHICLE. MY CONCERN IS NOT ONCE BUT THRICE THE VEHICLE STOPED WORKING BUT THE THE SERVICE DEPARTMENT JUST COULD NOT DIAGNOSE THE PROBLEM. I AM FRUSTRATED - 3 BREAKDOWNS IN THE 1ST YERAR OF THE PERFORMANCE WITHIN 7100 MILEAGE. I THINK THE MECHANICS OF THIS DEALER"S SERVICE DEPARTMENT ARE NOT EXPERIENCED TO DETECT THE PROBLEM IN A NEW VEHICLE. HELP

• 12/26/2020· ELECTRICAL SYSTEM,ENGINE

  CAR BATTERY COMPLETELY DRAINED AFTER NOT BEING DRIVEN FOR 24 HOURS LEAVING ME STRANDED. CAR WOULD NOT START AND HAD TO BE JUMP STARTED. THERE IS AN ELECTRICAL ISSUE CAUSING QUICK AND SIGNIFICANT BATTERY DRAIN. CAR WAS PURCHASED IN SEPTEMBER 2020 AND HAS LESS THAN 10,000 MILES.

• 12/25/2022· SERVICE BRAKES

  Squealing noise when stopping or braking under 3 mph.

• 12/21/2020· SEATS

  TETHER ANCHORS ARE MISSING OR NOT VISIBLE. THE LABELS ARE MISSING AS WELL. I'M TRYING TO USE A CARSEAT FORWARD FACING AND NEED TO USE THE TETHER ANCHORS. COULDN'T UPLOAD THE PICTURES.

• 12/20/2024· ELECTRICAL SYSTEM,STRUCTURE

  The Rear Hatch started to get stuck. It is automatic so you would normally press a button to open and close and it would slowly move up or down and close shut on its own. When the issue started, it would "pop open" but stay stuck to a point where I would need to manually lift it open. (hitting my head on it often) Right before I took it to the dealership service, it would not close properly. While it seemed close, the notification showed it open therefore, not allowing me to lock my car and the lights on the car would need to stay on while car was parked and off. Driving home, the "open door" notification was beeping non-stop. Once again I had to open and close manually until it was considered "closed" Brought the car into the Toyota Dealership to assess. They found that the power lift gate hinges on the door were coming off and it needs to go to an Auto Body for realignment. I performed research online and found this to be a very common issue with the Toyota RAV4's. I have had leased 2 RAV4's prior to this one and never had a problem (those were manual hatches) [XXX] [XXX] My car has 33k miles on it although this issue (not as severe) started a while ago. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/20/2024· POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  Wire harness failure according to the Toyota dealership representative I spoke with after inspection on 12/18/24. Rep said this is a known issue with certain years and they will cover cost of replacement. Previously, I had received a message stating, "Hybrid System Malfunction, Visit your Dealer" but could not get an appointment until 12/18. The dealer rep said they needed to order parts to fix the wire harness issue and that I would be okay taking the car and bringing it back when parts were in. The day after the inspection (12/19) I was in a Walmart parking lot and my car started but I could not get it to drive or reverse. A message stated "Vehicle not ready to drive" and "No power to rear brakes". If I put the car into drive or reverse and stepped on the gas, the car interior lit up and the dinging sound (usually associated with unbuckled safety belt) was heard. I had my safety belt fastened. My car could be put into neutral and had to be towed to the dealership. After looking into the issue, I found out that the car could had died while I was driving it resulting in loss of power brakes, etc. I live in a more rural area and could have been stuck with out cell reception, etc. This should be a RECALL and they never should have let me leave the dealership in my car. Note: As of today (12/20) the dealer rep stated they will cover all towing costs and cover a loaner vehicle for me. My dealership is very helpful BUT this could be a serious issue for someone else. Google "Rav 4 Cablegate" for more information.

• 12/20/2020· STRUCTURE,UNKNOWN OR OTHER

  AIR CONDITIONING STOPPED WORKING TWICE, FIRST TIME REPAIRED AT MY EXPENSE AND NOW IT'S OUT AGAIN LESS THAN 2 MONTHS LATER. REPAIR WAS 1500.00 FIRST TIME. SECOND CONTINUES TO RATTLE FROM MIRRORS, FRONT END AND CARRYING RACK. MY RIGHT FRONT FOG LIGHT OUT AND SERVICE SAID FRONT END WAS VERY LOOSE.

• 12/19/2023· ENGINE

  2020 RAV4 with 47,589 miles. The engine maintenance light came on. It turns off once I shut off the vehicle and start it up again. It only comes back on when I put the air conditioner or heater on. I was told it's the heater control valve/coolant bypass valve and would cost around $900+ to repair. I did some research and see that this problem is occurring alot.

• 12/18/2024· ENGINE AND ENGINE COOLING

  Bypass Coolant Valve malfunctioned resulting in Engine Maintenance Required triggered. Because I do distance driving at high speeds, any potential engine issue poses a risk to safety. The problem has been confirmed by a dealer/service center. The component in question has not been inspected by the manufacturer. The warning sign that states "Engine Maintenance Required" appeared on the dashboard and remains.

• 12/17/2020· STEERING

  STEERING IS TOO LOOSE TO CONTROL. I BROUGHT TO DEALER 3 TIMES THEY SAID IT OK EVERY TIMES. I FEEL ARE NOT SAFE, ESPECIALLY WHEN ON HIGH WAYS. LAST WEEK ALMOST SLICED FROM THE ROAD. WHAT SHOULD I DO?

• 12/16/2020· ELECTRICAL SYSTEM

  BATTERY DIED LESS THAN 24 HOURS AFTER LAST USE. PARKED IN ENCLOSED GARAGE.

• 12/13/2021· ELECTRICAL SYSTEM,ENGINE

  In the sring of this year, i lightly drove through a water filled pothole in a parking lot when all of the displays went dark for a split second and then came back on like the car had just started. I called my dealership right away and was told that maybe some water had gotten into some wiring and caused the glitch but to call again ASAP if it happened again. On Dec 9, 2021 under dry and even surfaces while making a left turn the vehicle went dark again while driving but this time took a touch longer to re-engage. I called the dealership again to report this to be looked at during a maintenance appointment. They found nothing wrong, but suggested it was a feature the car does not have was turned on and they turned it off. I was then shown the button responsible for this ... it was for automatic high beams, NOT some engine efficency button. On Sunday, 12 12 2021 i went to start the car to go to work and it was completely dead, just a small clicking sound to be heard within the cabin. i had to get the car jumped to get it started on the second turn of the key after i removed it from the first attempt. I drove it to the dealership that day and i am still waiting for results. This needs to be adressed ASAP because its a potentially dangerous if not deadly situation if it conks out at highway speeds in front of a semi.

• 12/13/2020· UNKNOWN OR OTHER,VISIBILITY/WIPER

  I BOUGHT MY 2020 RAV4 LE VIN: [XXX] LAST JAN.2020 I NOTICED THE BACK DOOR GLASS HAS A LOT OF CIRCLES COMING FROM EFFECT OF SUCTION GLASS HANDLER THESE CIRCLES BECOME VERY VISIBLE WITH HUMIDITY AND CAUSE DECREASE IN MY VISION TO THE BACK OF MY CAR SPECIALTY AT NIGHT I CAN'T DECIDE HOW FAR IS CAR BEHIND ME AND TOTALLY UNSAFE. WHEN I TRIED TO COMPLAIN TO DEALER THEY ARE SO RUDE AND NOT COOPERATIVE, STORE MANAGER HIS NAME [XXX] SAID YOU CAN COMPLAIN TO TOYOTA NOT US INSISTING ON ITS NOT A DEFECT IN MY CAR . JUST FYI I RECORDED MY COMPLAIN AT DEALER OFFICE 2 TIMES. THEN I CONTACTED TOYOTA AND THEY FILE CASE NUMBER [XXX] ASKING ME TO GIVE THEM TIME TO INVESTIGATE ON 12/11/ 2020 AT 6:20 PM EST I RECEIVED PHONE CALL FROM CASE MANAGER HER NAME IS [XXX] THE PHONE CALL IS RECORDED SHE SAID AFTER INVESTIGATIONS ALL RAV4 2020 HAS SAME PROBLEM OF CIRCLES IN HATCHBACK GLASS DOOR AND IT COMES FROM THE WAY HOW THE CAR BUILT AND THIS MAKES THE GLASS CONTAINS A LOT OF CIRCLES I TOLD HER THIS DEFECT IN THE CAR BECAUSE IT DECREASES MY VISION SHE SAID TOYOTA DOES NOT CONSIDER THESE CIRCLES A DEFECT ITS JUST BECAUSE THE WAY THE BUILT THE CAR. PLEASE HELP ME I PAID A LOT OF MONEY TO BUY BRAND NEW CAR THEN SURPRISED WITH THIS PROBLEM AND TOYOTA CONSIDER THIS NOT A PROBLEM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/11/2020· FUEL/PROPULSION SYSTEM

  WHEN I FILL MY GAS TANK, IT DOES NOT SHOW FULL. I BOUGHT THIS SUV 4/17/2020. ALSO, BURNS THROUGH GAS QUICKLY. I SEEM TO GO GET GAS OFTEN AS IT QUICKLY BURNS THROUGH HALF A TANK, THEN STAYS THERE FOR A WHILE THEN QUICKLY DOWN TO 1/4 TANK. I WAS SENT FROM TOYOTA THAT THEY KNEW THIS IS A PROBLEM BUT DON'T KNOW HOW TO FIX. NOW WHEN I CALL THEM, THEY TELL ME THEY KNOW NOTHING ABOUT THIS PROBLEM. YET IN THEIR LETTER SAID DO NOT TOP OFF AND DO NOT WAIT UNTIL THE FUEL LIGHT OR WILL RUN OUT OF GAS.

• 12/10/2022· STEERING

  Power steering would not work. Warning lights on dash came on which was a steering wheel with an exclamation point.

• 12/09/2022· ELECTRICAL SYSTEM,AIR BAGS,UNKNOWN OR OTHER

  when car is subject to rain or car washed, the headliner gets saturated at the "A" pillar and the "C" pillar. This water seems to be coming from under the roof rails. I have tested sunroof drain and they are open leaving the only other area to leak at the insertion of the roof rails. I have never had anything attached to them to add excess weight but have also hearing and finding many other reports of this happening. My concern is having the headliner ruined AND malfunction of the airbags. This has been reported to my Toyota dealer twice and I have been told that they are unaware of any issues with the seals on the roof rails.

• 12/08/2025· AIR BAGS

  I received recall notice December 2023 for defect in front passenger seat airbag that could cause the airbag to fail to deploy in the event of a crash. I have contacted the dealer several times and have been told each time that there is no remedy (yet). It has been two years and the risk to passengers in my vehicle has not been remedied. Fortunately, I have not had any collisions but the danger and safety concerns remain, and there has been NO ACTION BY TOYOTA ON THIS SERIOUS RECALL NOTICE The Recall Notice stills says “no remedy” and it has not been updated in the past year. This is a serious, potentially dangerous and life-threatening defect, a recall has been issued, and yet NOTHING has been done to remedy the defect FOR TWO YEARS. What remedies are available to me as a customer? Will action be taken on this complaint? Please let me know when I can expect a response.

• 12/08/2024· STRUCTURE

  The hinges on the lift gate are detaching causing my trunk not to close all the way.

• 12/07/2024· UNKNOWN OR OTHER

  This issue involves the lock/unlock system: Front passenger door does not respond to lock/unlock command by either approaching the door and/or pressing the remote button. This is a constant problem and is not random. Front drivers door has started doing the same thing but randomly.

• 12/07/2023· ENGINE

  Coolant bypass valve failed vehicle warning lights came on for this 2020 Toyota Rav4 at 31,641 miles. This is absolutely available for inspection on request. Safety as this can potentially cause overheating, coolant leaking, a cracked cylinder. The manufacturer (Local Toyota dealership - "Ed Morse Delray Toyota" inspected and suggested replacement of the coolant bypass valve for this 2020 toyota rav4 for a price around 800$. the technician say they see a load of these newer model Rav4's needing new coolant bypass valves. I opted not to immediately replace the valve due to it being a vehicle model-wide issue that should likely be a recall. These appeared the day before I brought it in to the dealer so withing 5-10 miles of the 31,641 miles for this 2020 Toyota Rav4. Warning just says "error please take in to dealership for service".

• 12/07/2020· UNKNOWN OR OTHER

  DRIVING DOWN I-40 IN OKLAHOMA AROUND 70-75 MPH ON 12/4/20 AROUND 1:00 PM CT, OUT OF NOWHERE, THE SUNROOF EXPLODED. MOST OF THE GLASS WENT OUT AND BEHIND THE CAR, BUT SOME GLASS ENDED UP ON DRIVER AND 2 PASSENGERS. THERE WAS NOT ANY OTHER CARS (IN FRONT OR BEHIND) AT THE TIME THIS OCCURRED. SOME GLASS DID NOT COME OFF AND YOU CAN SEE BY MY PICTURES THAT THE GLASS IS CURVED UP, SHOWING THE DIRECTION THE GLASS EXPLODED UPWARDS AND OUT OF THE CAR. THE ROOF OF THE CAR, YOU CAN SEE THE PAINT CHIPS CAUSED BY THE EXPLODING GLASS GOING BACKWARDS, PLEASE SEE INCLUDED PHOTO. I WAS HEADED TO ARLINGTON TX FOR A WEEKEND TRIP, SO I CALLED A TOYOTA DEALER IN ARLINGTON AND TOLD THEM WHAT HAD HAPPENED. THEY SAID THEY HAVE NEVER SEEN THIS HAPPEN. THEY CONTACTED THEIR TOYOTA REPRESENTATIVE AND THEY SAID THEY HAVE NOT SEEN AN EXPLODING SUNROOF BEFORE AND THAT IT HAD TO BE A ROCK HITTING THE SUNROOF. THIS DEALER DID GET A SUNROOF DELIVERED ON THE NEXT DAY AND WAS ABLE TO INSTALL ON SATURDAY 12/5/20. TOYOTA DID NOT BELIEVE THIS WAS DEFECTIVE SUNROOF, BUT I DO BELIEVE SOMETHING WAS DEFECTIVE, BECAUSE THERE WAS NOT ANY VEHICLE IN FRONT OF ME AT THE TIME THIS HAPPENED AND I DO NOT RECALL A ROCK HITTING THE SUNROOF PRIOR TO THE EVENT. THIS SEEMS ODD THAT THE SUNROOF WOULD JUST SUDDENLY EXPLODE AND SHATTER UPWARDS AND OUT OF THE CAR. PLEASE SEE ATTACHED PICTURES. VANDERGRIFF WAS ABLE TO GET IN A SUNROOF AND REPLACE IT, BUT IT WAS AT MY EXPENSE. PARTS AND LABOR $1,121.86

• 12/07/2020· ELECTRICAL SYSTEM

  THE VEHICLE SAT IN THE GARAGE 3 DAYS AND WHEN I TRIED TO START THERE WAS NO POWER TO THE ENTIRE VEHICLE. I TRIED TO JUMPSTART THE VEHICLE WITHOUT AVAIL. CALL TOYOTA THEY SENT SERVICE VEHICLE THAT JUMPSTART THE VEHICLE AND HAD IT RUN FOR @ 10 MINUTES. SHUT CAR OFF AND IT WOULD NOT RESTART. VEHICLE WAS TOWED TO THE TOYOTA DEALERSHIP. PER THE DEALERSHIP THEY HAD TO REPLACE THE BATTERY. I REFUSE TO BELIEVE THAT WAS THE ISSUE. THE BATTERY IS BEING DRAINED BY SOME OTHER ISSUE. TOYOTA NEED TO RECALL THESE VEHICLES AND FIX THE ISSUE PROPERLY.

• 12/06/2020· ELECTRICAL SYSTEM

  OUR 2020RAV4 HYBRID HAS FAILED TO START TWICE (5/5/2020 AND 12/5/2020) AFTER SITTING ONLY 1-2 DAYS IN OUR GARAGE. IT REQUIRED JUMPING TO BE RECHARGED. FROM THE CARGURUS SITE, THIS SEEMS TO BE A COMMON PROBLEM WITH NO DEFINITE SOLUTION YET, PERHAPS A BAD BATCH OF BATTERIES, PERHAPS A SOFRWARE UPDATE NEEDED, OR SOMETHING ELSE? TOYOTA NEEDS TO FIGURE IT OUT AND FIX IT! WE DON'T FEEL LIKE A NEW, EXPENSIVE VEHICLE CAN BE DEPENDED ON.

• 12/06/2020· FUEL/PROPULSION SYSTEM

  THE 14.5-GALLON GAS TANK IN MY 2020 TOYOTA RAV4 HYBRID HAS A DEFECT THAT PREVENTS THE TANK FROM BEING FILLED TO CAPACITY. THIS DEFECT NOT ONLY FAILS TO COMPLY WITH FEDERAL AND STATE GAS TANK REGULATIONS, WHICH PROHIBIT THE SALE OF VEHICLES THAT CANNOT FILL 90 PERCENT OR WITHIN TWO GALLONS OF THEIR NOMINAL GAS TANK CAPACITY, BUT SUFFER FROM A SUBSTANTIALLY REDUCED DRIVING RANGE. THE FUEL TANK DEFECT PREVENTS ME FROM GETTING ANYWHERE NEAR THE VEHICLES' ADVERTISED 550-PLUS-MILE RANGE (I AVERAGE 400-425 GALLONS A TANK), WHICH WAS A MAJOR SELLING POINT AND FOR WHICH I PAID A PREMIUM PRICE FOR; THIS HAPPENS AT EVERY INTERVAL I HAVE TO FILL UP ON GAS. I FEEL THIS IS A SAFETY HAZARD AS WELL, I MAY RUN OUT OF FUEL WHICH MAY RESULT IN AN ACCIDENT OR LEAVE ME STRANDED ON THE SIDE OF A BUSY OR DESERTED ROAD AND WITH A NY WINTER, IT IS JUST NOT SAFE TO BE STRANDED IN THE COUNTRYSIDE WHEN IT IS FREEZING COLD OUTSIDE. RUNNING OUT OF FUEL MAY ALSO DAMAGE MY VEHICLES FUEL SYSTEM TOO! THE OWNER'S MANUAL WARNS THAT IF MY VEHICLE RUNS OUT OF FUEL OR THE FUEL IS TOO LOW, THE HYBRID SYSTEM MAY NOT BE ABLE TO START.

• 12/04/2023· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Engine bypass valve sensor is faulty. Many users have reported this past 40k miles on RAV4 2019-2021

• 12/03/2024· ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

  •August 19, 2022: All emergency/error code lights came on the dash while driving on highway. The vehicle was taken to Don McGill Toyota for service. In that time, all error codes came back and went away a few times on their own. Vehicle was taken on 08/20/2022 (please refer to service records) in which it was originally deemed there were no issues with the vehicle. Toyota recommended that if the problem persists, bring the vehicle back in. •August 26, 2022: Vehicle emergency lights came back on while driving on the highway again. The vehicle was taken back to Don McGill Toyota for a service emergency. Was told the Vehicle needed a sensor replaced. Got the vehicle back on September 15, 2022. •September 6, 2023: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota. Another part was replaced (please refer to service records) and the vehicle was returned on September 9, 2023. •August 2024: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota for a break service as well as getting this emergency lights issue resolved. The vehicle was picked up 5 hours later, however upon driving a little in the dealership parking lot, emergency lights came back on. Immediately went back and brought it up to the service advisor, who then took the car back for another 1 hour and deemed the vehicle needed to be “recalibrated”. This recalibration was completed, then left the dealership. •September 3, 2024: Vehicle emergency lights come back on. This time the vehicle struggled to brake when the lights came on. The vehicle was taken into Don McGill Toyota for immediate service. Breaks were looked at and recalibration was completed. Vehicle returned on September 6, 2024. •September 14, 2024: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota for emergency service. Brakes were checked and the vehicle was driven around to bring the lights up. The vehicle was given back on October 1, 2024, after the ser

• 12/03/2024· AIR BAGS

  The contact owns a 2020 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 12/02/2023· ELECTRICAL SYSTEM

  2020 RAV4 hybrid. Vehicle doesn't start; requires a jump, which is inconvenient or unsafe, depending on where it happens. Intermittent occurrence, ~ 3 times/year. Toyota checked 12V battery, pronounced OK, of course the car was driven to the shop for the check, so was operating at the time. I've checked the battery when the car wouldn't start and found it to be a little low (11.5V) but by no means fully discharged. Not associated with leaving components on (we are careful to turn everything off) or weather; the vehicle is garaged in the winter. I turned off the "Bluetooth" system which we never used and haven't had this issue over the past year. Suspect that the "Bluetooth" system was operating even when the vehicle was off?

• 12/02/2020· FUEL/PROPULSION SYSTEM

  THE FUEL TANK IS RATED AT 14.6 GAL BUT THE MOST I HAVE BEEN ABLE TO GET OUT IS 11 GAL. THE ISSUE IS CONSISTENT ACROSS EVERY FUELING PERIODS AND AFTER TAKING IT TO THE SERVICE CENTER TWICE, THE ISSUE HAS NOT BEEN FIXED AND THE RESPONSE HAS BEEN THAT THE FUEL TANK HAS NO ISSUES. I HAVE SHOWN THE PROOFS TO THE SERVICE CENTER AND YET THEY DENY CLAIMS.

• 12/01/2025· STRUCTURE

  The door lock actuators required repair on all my doors for the RAV4 2020. They stopped working after the 3 year warranty was up. This is a safety issue. I had to manually lock and unlock my doors, which left in a dangerous position at night. Over the course of a year all 4 doors needed to have the actuators replaced. This happrened in 2024.

• 12/01/2020· FUEL/PROPULSION SYSTEM

  I PURCHASED MY BRAND NEW 2020 RAV4 HYBRID ON 7/1/2020 AND WAS TOLD THE CAR IS IN PERFECT CONDITION WITHOUT ANY ISSUE. STARTED WITH 2ND TANK OF GAS FILL UP, I NOTICE THE METER READING IS NOT CORRECT. WHEN I DROVE THE CAR AWAY ON 7/1/2020, THE READING SHOW SOMETHING LIKE "520 MILES TO EMPTY". WITH THE 2ND TANK FILL UP, THE READING CHANGED TO "480 MILES TO EMPTY". WHEN COMES TO THE 4TH TANK FILL UP, THE READ IS NOW SHOWING "410 MILES TO EMPTY". ALSO, BASED ON THE CAR SPECIFICATIONS, THE TANK SIZE IS 14.5 GAL, BUT I CAN ONLY FILL UP AROUND 10 GALLONS OF GAS, THE TANK WOULD BE FULL. I BROUGHT THE CAR TO THE TOYOTA DEALER WHERE I PURCHASED IT TODAY. I WAS JUST TOLD THEY NEED TO REPLACE THE FUEL TANK ALONG WITH SOME OTHER PARTS ON THE ALMOST BRAND NEW CAR. THIS IS NOT RIGHT. TOYOTA SOLD THE CAR WITH MAJOR ISSUE TO ME AND WITHOUT DISCLOSE THE INFORMATION AT THE TIME OF THE SALE. THE ISSUE WAS LONG EXIST BEFORE I PURCHASE THE CAR AFTER GOOGLED THE ISSUE ONLINE. THEY SHOULD HAVE DISCLOSED THE FAULTY ISSUE OF THE CAR AT THE TIME OF THE PURCHASE.

• 11/30/2023· UNKNOWN OR OTHER

  Coolant bypass valve less than 40k miles and there is hundreds of them going bad this needs to be a recall issue

• 11/27/2024· UNKNOWN OR OTHER

  I started receiving error message, “Engine maintenance required Visit your Dealer“. I contacted the dealership and spoke with someone in parts and service. They advised me that the issue is the coolant bypass valve and the cost to replace it would be approximately $800 with parts and labor. They also stated that unfortunately this is a known defect and they can’t guarantee how long the repair would last because they would just be installing the same defective parts. In addition to that, they don’t have the parts and don’t know when they will get them because they are on back order. They said not repairing the problem could cause permanent damage to my vehicle. This should be a recall.

• 11/27/2020· ELECTRICAL SYSTEM,ENGINE

  CAR DID NOT START AFTER 2 DAYS OF NOT USING IT.

• 11/27/2020· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  CAR WOULD NOT START AFTER SITTING OVERNIGHT IN MY GARAGE. ONLY HAS 2,200 MILES ON IT. DASHBOARD LIGHTS FLICKERING SAYING PARKING BRAKE MALFUNCTION AND CHECK ENGINE/ OTHER WARNING LIGHTS CAME ON. SEEMS TO BE A HUGE ISSUE FROM OTHER REVIEWS. TOYOTA NEEDS A RECALL OR WE NEED TO FILE A CLASS ACTION LAWSUIT! UNACCEPTABLE. LOOKING INTO CA LEMON LAW.

• 11/27/2019· VISIBILITY/WIPER

  SIDE VIEW MIRRORS ON BOTH DRIVER AND PASSENGER SIDE SHAKING WHEN ON HIGHWAY SPEED

• 11/24/2021· UNKNOWN OR OTHER

  On Sunday,11/21/2021, sitting in my Toyota Rav4 TRD Off Road with my wife in an outside parking lot to a medical office, when we heard a loud pop/bang. We got out of the vehicle and discovered that the sun roof had shattered. Nothing hit my car. We were parked in it it for 15 minutes. There was nothing around the vehicle. I taped the window with Gorilla Tape. Dealership inspected the car and told me the warranty does not cover glass. Dangerous situation! Potential for flying glass! There is no warning system for this type of incident.

• 11/24/2020· ELECTRICAL SYSTEM

  CAR WOULD NOT START AFTER SITTING UNUSED FOR A FEW DAYS. BATTERY IS FINE; CAR COMPLETELY DEAD.

• 11/22/2024· AIR BAGS

  Toyota sent a letter saying there would be a solution by end of Q3. There isn’t. I asked them for a replacement and they sent me a letter saying no. I do not feel safe driving my car with a safety recall. They also suggested I can get a loaner vehicle but the dealership says there would be some out of pocket expenses because Toyota pays up to $40 a day and the loaner vehicle is over $40/a day

• 11/22/2023· ENGINE

  My coolant bypass valve in the engine malfunctioned and shorted at a mere 27,300 miles on the vehicle and I had to bring it into the dealership to be replaced. A coolant bypass valve failing or malfunctioning can cause the engine to overheat, catch fire, or cause complete seizure. Can also cause the vehicle to stall and possibly cause a crash or wreck. Toyota has acknowledged the problem in the RAV4’s but no recalls have been issued. Dealer knew exactly what the problem was when I mentioned that the ‘engine maintenance required’ light came up on my dashboard BEFORE mechanic diagnosed it and confirmed which tells me they are aware of the issue in these cars.

• 11/21/2024· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  My Toyota 2020 RAV4 has a dangerous design flaw. It rolls when turned off and in drive mode. For example, my driveway is on an incline, and a couple times I have pulled into my driveway, gotten distracted, and I forgot to put the car in Park. When I hit the on/off button, the car rolls backwards, accelerating due to gravity. If you're not quick, you can end up rolling out into traffic, or running someone over that is behind your car. All the other cars I've ever owned didn't roll when the car was turned off unless you were in neutral. I believe this is a design flaw because I've spoken to a few other RAV4 owners that have experienced the same thing, and on one occasion, I tested it on another RAV4 and it was the same. I can see this being very dangerous. If you are standing outside of the car and hit the on/off button while it's in drive, you would get knocked down by the door, and your car would be rolling without you in the car.