2020 Ford Fusion Energi

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/27/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not yet available. Additionally, the contact stated that his vehicle was also not included in Customer Satisfaction Program Number: 21B09 for 4G Program Upgrade. The contact stated that his vehicle was still in 3G configuration with no chance to be upgraded by the manufacturer to 4G.

• 12/25/2019· WHEELS

  THE MICHELIN ENERGY SAVER A/S HAD TWO FAILED TIRES ONE WITH A BLOW OUT AND THE OTHER WITH A SIDE WALL BUBBLES. TIRES ONLY HAVE 1800 MILES ON THEM ON A BRAND NEW CAR. DEALERSHIP CLAIMED ROAD HAZARD BUT NOTHING WAS HIT AND THERE WERE NO PUNCTURES.

• 12/15/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The contact stated that while attempting to start the vehicle, the vehicle was not responsive. The contact attempted to recharge the battery despite the recall instructions and was unable to start the vehicle. The failure mileage was approximately 35,000. VIN tool confirms parts not available.

• 12/10/2023· ELECTRICAL SYSTEM

  Although there is an existing recall in place by Ford Motor Co, a solution is not expected for another year. In the mean time, I am worried about a vehicle fire or vehicle going dead everyday. In addition, by not using the battery charger, my mileage has dropped from 54 mpg to 32 mpg. This past summer, I had three instances where my check engine light went on and the car would not start.

• 11/20/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion Hybrid. The contact was unable to charge the vehicle. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Ford of Smithtown (440 Middle Country Rd., St. James, NY 11780). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer offered a buyback. The failure mileage was approximately 45,541. Parts distribution disconnect.

• 11/17/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/16/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/25/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/25/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/18/2022· ENGINEFire

  The contact stated their son owned a 2020 Ford Fusion. The contact stated that their son was driving at approximately 35 MPH, when the vehicle's instrument panel illuminated all possible warning lights. Then there was smoke emitting from the vehicle near the driver's feet. The driver pulled to the side of the road where they turned off the vehicle. The vehicle then caught on fire under the hood of the vehicle. The fire department was called and distinguished the fire. A fire report was filed. The vehicle was towed and deemed totaled. There were no injuries. The manufacturer was made aware of the failure and then opened a case regarding the failure. The approximate failure mileage was 30,000.

• 10/12/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/14/2023· ELECTRICAL SYSTEM

  car can catch on fire due to hybrid battery issue.

• 09/08/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 09/08/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at undisclosed speeds, after the electrical charge had diminished, the vehicle lost automotive and electrical power instead of switching over to fuel. The contact was informed not to charge the vehicle making the vehicle undriveable. The manufacturer was made aware of the failure. The approximate failure mileage was 62,000. VIN tool confirms parts not available.

• 08/28/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted, and the contact was informed that the part for the recall repair was not yet available. The contact stated that the manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was not provided.

• 08/23/2023· UNKNOWN OR OTHER

  Purchased the hybrid fusion to save on gas . Received a recall with no time as to when they will have a fix. The car is now only able to be used as a gas car because we Were advised you cannot charge the vehicle as it may go on fire. I now have to fill up every week as opposed to every 4-6 weeks. Gas is very high now and the car is not what I wanted without the hybrid mode . Car is lackluster in gas mode and my gas bill is not 5-6 times what I was paying and want to pay .

• 08/07/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 07/31/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 07/24/2026· ELECTRICAL SYSTEM

  I am filing a complaint regarding Ford Safety Recall 23S33 (NHTSA Campaign 23V440) for my 2020 Ford Fusion Energi. I brought my freshly purchased vehicle to my local authorized dealer, Sheehy Ford, to fix the high-voltage battery replacement recall. The dealership told me they had to order the part before they could schedule the repair. They have since stated that Ford corporate is experiencing low stock and is not allocating the necessary remedy parts to the dealer network, and referred me to call Ford corporate. Purchased this vehicle on 21 March 2026; took it to dealer to get the recall fixed on 23 March. Dealer said it would be delayed due to the recall being started in [XXX] (where the vehicle was shipped from via carmax, and sold to me in [XXX]). After a month, the dealer opened a case with Ford corporate (XXX). I called to check status, was put on hold for 20 minutes, then transferred, and was then disconnected. It has been 4 months since I took it in to get the recall repaired. The manufacturer is failing to provide a timely safety remedy as required by federal law, leaving me to drive a vehicle with a documented risk of fire and sudden loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 07/20/2023· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that while operating the A/C, the fan motor started to increase in speed and the battery became hot. The contact stated that she unplugged the battery to allow for the battery to cool down before reconnecting the battery. The vehicle was taken to an undisclosed dealer however, the failure could not be duplicated. The contact was informed that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

• 07/10/2023· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  In my 2020 plug-in Fusion, Stop Safely Now appeared on the screen as I drove on the freeway. While driving 70 mph, I suddenly had difficulty accelerating, and my air conditioner stopped working and began blowing hot air. By using hazard lights, I was able to slowly exit the freeway. The system disabled the engine and prevented the vehicle from starting. After being stranded on the off ramp, we were towed home. The cost of which exceeded $100. Without displaying any warning messages when we arrived home, the car started right up. After letting it sit for a few days, I tried to drive it again. In my attempt to accelerate, I reached 50 mph, but again the same warning appeared and I was unable to accelerate. It is ridiculous to not be able to trust a car that is less than five years old to drive safely and confidently. I paid too much for this luxury brand from Ford to cause this kind of issue. It clearly is related to the active recall that Ford doesn’t have a solution for.

• 06/24/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

• 05/22/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

• 05/18/2024· ELECTRICAL SYSTEM

  The center console display unit acts as though "ghost fingers" (internet term) are continuously exercising the display, since at least December 2023. If on climate, it will turn the climate controls on and off, and if on phone, it will attempt to delete phone contacts. The only screen that is safe to leave the display at, is navigation, so that it continually flickers and moves the map around the state, country and world. I cannot turn off the steering heater, or change climate direction to vent or floor without accessing the climate screen while driving. I have had to unpair my phone, and so 911-assist is no longer available. Periodically while driving, the screen will switch over to climate controls, and then I have to switch it back, pressing navigation multiple times until it responds, while driving. These actions make driving the vehicle UNSAFE. The dealer acknowledged an internal bulletin in January, that said a software update was needed to address this known issue, but none was available. They have been unwilling to provide any of that in writing. Please contact me for a 165Mb video of the the screen, which includes my attempts to access screen functions.

• 05/09/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 04/29/2024· ELECTRICAL SYSTEM,ENGINE

  I am aware of the recall on the ford fusion plug in hybrid and for that reason I do not plug it in. We are supposed to use this as a regular hybrid until the fix comes out. That said, my car turns off randomly in traffic. All the warning lights turn on and the car fully shuts down and has to restart. This happens without warning, while in traffic. Last week it happened 3 times on one single drive home from picking up the kids from school. This is not supposed to happen if we aren’t plugging it in, but it’s happening and ford said they think it’s related to the recall (they’re holding on to it for the next five days and I’m on my own for car rental fees). Totally unsafe to just stop working in traffic, even when not using EV mode. This is going to hurt someone.

• 04/25/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electric System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 04/04/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 04/03/2024· ELECTRICAL SYSTEM

  Five months after buying our 2020 Ford Fusion Energi plug-in hybrid, Ford issued a recall stating that it was unsafe to plug it in. Now, going on 10 months later, Ford still has not corrected this safety issue. They continually say they're working on it, but I paid for a car that I didn't get. This car is not a plug-in hybrid if life-threatenting risk of fire or "loss of motive power" means I can't plug it in.

• 04/01/2024· ELECTRICAL SYSTEM

  This is a PHEV Fusion. Prior to the recall I noticed a red light coming from the "box" that is part of the charging cord. I disconnected the charging cord from the wall outlet. Upon a closer inspection I found that there had been a fire inside the receptacle box that had burnt a hole in the box and destroyed the receptacle. I replaced the receptacle and box and continued charging the battery and suspected that there had been a fault in the receptacle. However, I received recall 23S33 in July 2023 and now think the fire I experienced might have been due to the Battery Energy Control Module as referenced in the recall. I no longer am charging the battery as suggested in the recall. It has been 8 months since I received the recall and the only thing I have heard from Ford is a check for $250.00 to help with the added fuel cost due to not being able to use the plug in capability.

• 03/22/2024· SERVICE BRAKES, HYDRAULIC

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. 

• 03/12/2024· ELECTRICAL SYSTEM

  See attached document for complaint

• 03/11/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 02/28/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

• 02/22/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

• 02/18/2025· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 02/15/2024· ELECTRICAL SYSTEM

  Battery recall was sent out 6/2023, unable to charge vehicle and use as intended hybrid . $250 gas compensation in 8 months . Not being addressed in a reasonable timeframe .

• 02/05/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was made aware of the issue and confirmed that the parts were not yet available. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool confirms part not available.

• 01/30/2024· ELECTRICAL SYSTEM,ENGINE

  This car is a plug-in hybrid. Ford told owners NOT to charge their cars as of June 16, 2023, and they still don't have a solution. It's January 30, 2024. That's 228 days or 62% of a year or 7.6 months. I don't consider that a timely recall. Jun 16, 2023 Manufacturer Recall Number23S33 NHTSA Recall Number23V440 Recall Status Recall Incomplete, remedy not yet available

• 01/30/2024· ENGINE,FUEL/PROPULSION SYSTEM

  Ford has issued a recall for which they have offered no remedy. The recall recommends not using the DEFINING feature of the vehicle; the entire purpose for which it was purchased: i.e. the short but meaningful electric range. Ford say the vehicle should not be charged due to an engineering fault that may lead to a fires. The issue has led to thousands of dollars in extra fuel cost and, in my state at least, Ford is refusing to buyback the vehicle.

• 01/09/2024· ELECTRICAL SYSTEM

  The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 01/08/2026· ELECTRICAL SYSTEM

  PLEASE SEE ATTACHMENT

• 01/04/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Ford reached out in June 2023 with a recall stating to not charge the vehicle and provided a small check to "help with gas." It has now been 7 months with no resolution. I have had no issues in the past from charging my vehicle even though my standard battery did just need to get replaced.