2019 Lincoln MKC

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2024· UNKNOWN OR OTHER

  On my 2019 Lincoln MKC, which has 53,000 miles, the weather adhesive on one side of the moon/sunroof has come loose. The entire assembly is nearly detached, and I suspect this is a manufacturing defect, considering the car is relatively new and has low mileage. While I was driving on the highway, the roof could have come completely loose and potentially hit someone, which raises significant safety concerns regarding this manufacturer issue.

• 12/21/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact stated while driving at an undisclosed speed, the vehicle overheated. The contact allowed the vehicle to cool down and restarted the vehicle; however, the temperature level immediately registered from cold to hot. The contact stated that the failure reoccurred three times and the process was repeated; however, the vehicle remained inoperable. The vehicle was towed to the dealer where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The contact stated that when the temperature level was hot, coolant was leaking into the oil, which caused the engine to fail. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to pay a portion of the cost to repair the vehicle. The failure mileage was approximately 74,000. The VIN was unavailable.

• 12/16/2025· ENGINE

  2019 Lincoln MKC with 96K mileage suddenly started running rough around 30mph and I was losing power as I was entering a highway on a ramp. RPM needle was fluctuating between 2K and 3K. Immediately drove back home and towed it to Lincoln shop. They said its an issue with Coolant Intrusion into the engine compartment and would have to replace the engine block. Estimated at $11K. Extended warranty company said claim is likely to be denied as these Ecoboost 2.0L engines are notorious for these issues. It is a faulty manufacturing and there is no recall. Costing consumers thousands of dollars and also putting lives of passengers at risk.

• 12/08/2020· STRUCTURE,LATCHES/LOCKS/LINKAGES,INTERIOR LIGHTING

  TL* THE CONTACT LEASED A 2019 LINCOLN MKC. THE CONTACT STATED THE TRUNK FAILED TO OPEN. THE CONTACT STATED THAT THE INTERIOR LIGHTS WERE ILLUMINATED. THE LIFTGATE AJAR MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO PREMIER LINCOLN (5001 GLENWOOD RD, BROOKLYN, NY 11234, (888) 643-4603) AND THE CONTACT WAS INFORMED THAT THE DEALER WOULD NOT SERVICE A LEASED VEHCILE NOT PURCHASED OR LEASED FROM THE DEALER. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE ISSUES. AN APPOINTMENT WAS SCHEDULED WITH AN UNKNOWN AUTHORIZED DEALER. THE FAILURE MILEAGE WAS UNKNOWN.

• 12/03/2025· ENGINE

  My car misfired, then the heat wouldn't work then started to overheat. The car is 2019 MKC 2.0L engine. Only 64k miles on it. I am the original owner. Took it to the dealership and they said the coolant has back up into the engine. I read that this has been a known issue with these engines and was never notified. It is going to cost 10k to replace this engine.

• 12/02/2025· ENGINE

  My initial reason I took the car to the dealership, was because the vehicle would not want to start or stay running after fuel was put in. I aIso had a check engine light on. After the dealership performed diagnostics on it, they said the purge valve was bad which was the cause of it not starting. The check engine light was on because it was low on coolant. So I scheduled another appointment with Wyatt Ford in Manistee MI 49660 on Dec 1, 2025. They performed a coolant pressure test and determined that it is losing pressure after shutdown. They cannot find a leak. They removed the spark plugs, but #3 spark plug is "stuck" and they are attempting to remove it. If the spark plug breaks, they will take more of the engine apart to access it and attempt to "tap" out the threads of it. The technician (Sherman) told me that the cause of it being stuck could be due to the fact of the coolant leaking into that cylinder. Sherman was able to remove the #3 spark plug and found coolant in that #3 cylinder. They are now saying that the engine does need replaced and it is not safe to drive. The service department (Ava) gave me Ford Customer Service number to call to start a case. I called 800-392-3673 and spoke with Alex. She told me she will do some further research and call me back in about two hours. It is now 12:30 pm east coast time. After returning a call from her, she said that there are no programs at this time with Ford to assist with replacing the engine. Only if there is a recall on this is when they would be able to replace it for us.

• 12/01/2025· BACK OVER PREVENTION

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera had become inoperable while reversing. The local dealer was contacted, but the contact was informed that assistance could not be provided because the part needed for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,500.

• 11/27/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 11/21/2025· ENGINE

  The 2019 Lincoln MKC model made prior to April 2019 is part of a variety of Ford/Lincoln manufactured models that are known to have a coolant intrusion issue. This causes various issues within the engine system such as head gasket failure, cracked cylinders, and cracked engine block causing the coolant to leak and potential for fire risk. Although check engine light warning will be present, the code is presented as a misfire and the suggested fix is to replace spark plugs and coils. This will be completed, and seem to resolve this issue however, it is temporary and problems continue to persist. The car will loose power while driving and be unable to accelerate or continue to keep consistent speed such as when driving on freeway. Despite having a TSB 22-2133, customers are not made publicly aware of this issue and if they do not fit within warranty timeframe the dealer will not complete recommended service of the issue. Therefore, the customer is not at fault for the unsafe, known manufacturing issue and therefore Ford/Lincoln should make the effort in correcting this prior to serious customer injury/death.

• 11/17/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the temperature gauge started to indicate that the engine was overheating, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that there was a misfire in cylinders #2 and #3. The contact was informed that the spark plugs needed to be replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was not repaired. After investigating the failure, the contact related the failure to the Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 58,555.

• 11/14/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 11/14/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was not available.

• 11/07/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

• 11/04/2023· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  Recall 23S28 on my vehicle has never been repaired. have contacted dealership several times and have been told I would have to wait for part. Three months is not acceptable . I have tried to call 888-327-4236 and line does not connect. Also tried to email NHTSA.gov and will not go through.

• 11/03/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue but referred the contact back to the dealer. The contact had not experienced a failure. Parts distribution disconnect.

• 11/01/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 10/31/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

• 10/31/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. Parts distribution disconnect.

• 10/30/2022· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

  I purchased this vehicle less than 30 days. It had 29,257 miles. From day one, the vehicle came with no heating. When you push for heat, the cold AC blows. The part is in national back order. Secondly, when driving car at 20- 45 miles there is vibration, like a window is down when on a highway, but I'm driving in my neighborhood with all windows up. The vibration is unbearable. Thirdly and most importantly, when I slow to break, the car revs up, as if it won't stop. This is very unsettling. I'm never at ease because of this. This is a newer vehicle. There's a Toyota Camry 2011 and a Mitsubishi Outlander 2018 outperforming my newer Lincoln MKC 2019. I'm now afraid to drive the MKC because of the safety concerns. I just bought the car in October 5, 2022. I've reported this to corporate Lincoln. I don't understand why there hasn't been a recall. I do notice a flood of these vehicles in the market for sale. I'm afraid to drive this vehicle.

• 10/29/2024· ENGINE

  vehicle shaking when trying to start with me and my children in vehicle. Error code misfire of cylinder 1 and then smoke from exhaust. Just had it repaired in July

• 10/29/2024· ENGINE

  Misfire of Cylynder 1 and then had it replaced. Still losing coolant and rough start intermittently. White smoke from exhaust

• 10/28/2019· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINECrash

  VEHICLE SHUT DOWN COMPLETELY WHILE DRIVING ON THE HIGHWAY. THE ERROR MESSAGE "THE VEHICLE HAS SHUT DOWN" APPEAREDIN ON THE DASHBOARD. HAD THERE BEEN A TRANSPORT TRAILER BEHIND US, WE COULD HAVE BEEN KILLED. FORD CUSTOMER SERVICE IS DOING NOTHING FOR US. VERY DISAPPOINTING AS MY MOTHER NOW HAS TO DRIVE A VEHICLE THAT SHE IS AFRAID TO DRIVE. THIS CAR IS UNSAFE!

• 10/27/2025· ENGINE

  Total Engine Failure due to coolant leak into the 2.3L Ford motor. This is a KNOWN issue with the Ford motors and it is not covered. This eventual coolant leak makes the owner have to buy and replace the engine with one that has similar issues and costs $8300+. This is unacceptable and Ford needs to cover and address. Never had an engine do this to me before and it’s horrible. Please hold Ford accountable. Navy AD and with the shit down, this will be an expense I can not cover with 3 children, one in college. Was planning on keeping this car till the filter falls off… not anymore I guess.

• 10/26/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 10/22/2024· ENGINE

  engine misfires, using up antifreeze PO302 PO316 Took to dealer, wanted to replace engine but I am 3 months out of warranty

• 10/20/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact stated that she had disconnected the battery. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 10/20/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

• 10/19/2025· ENGINE

  There’s a cracked block/head gasket causing coolant to leak into the cylinders and now my engine needs to be replaced.

• 10/15/2024· AIR BAGS,SEATS

  I have called Leith Lincoln in Raleigh twice in less than 30 days to report an alert that continues to come through on my Lincoln app about the airbags. The airbag light comes on-on the dashboard even when there is not a passenger in the seat. The Restraints Indicator Lamp Warning comes on and remains on for an ample amount of time. The alert on the app states that "your airbag warning is on due to a fault with the passenger airbag detection indicator." It also tells me to contact the dealer. This is a safety concern for me.

• 10/11/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact stated that the vehicle was experiencing a rough start. Additionally, the contact stated that while driving at various speeds, the vehicle hesitated to respond upon depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that they could not assist because the vehicle was out of warranty. The failure mileage was approximately 70,000.

• 10/10/2025· BACK OVER PREVENTION

  The contact owns a 2019 Lincoln MKC. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image was distorted. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention). The dealer was contacted and confirmed that parts were not yet available for the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 51,000.

• 10/10/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000(Engine) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. Parts distribution disconnect.

• 10/05/2023· ELECTRICAL SYSTEM

  Received recall notice and advised in AUG in letter that parts were available . Made appt with Nick Mayer Lincoln Mayfield Hts Ohio for 9/6 8:00 am. While on the way they called to say they cant do it because they didn't have the parts. I visited on 9/11 and discussed with the service manager that I was on the list and they would contact me////// Watching the Cleveland news tonight I see that there was a fire of a 2019 MKC3 . I will be 81 years old very soon and really don't need this [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 10/04/2025· ENGINE

  The engine light came on. It was inspected and there is a coolant intrusion. Apparently, this was a known issue for this engine. There is an existing Technical Service Bulletin (TSB) 22-2229 and a Ford Customer Satisfaction Program (CSP) 21N12 related to this issue The program indicates up to 7 years or 84k miles, which I believe this falls under (my mileage is 42k) providing a one-time repair program providing a no-cost short block replacement. Ford is not cooperating.

• 10/03/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time to remedy the recall repair. The manufacture was notified of the issue. The VIN tool confirmed parts are now available.

• 09/27/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact attempted to jumpstart the vehicle however, the battery failed. The vehicle started getting hot and the battery terminal was disconnected. The vehicle was towed to the residence and remained their inoperable. The contact called the dealer and was informed that the manufacturer only provided 2 parts per week per dealer for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 32,000. Parts distribution disconnect.

• 09/20/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue but referred the contact to the dealer. The contact had not experienced a failure. Parts distribution disconnect.

• 09/19/2024· ENGINE

  My Lincoln MKC 2019 2.0 EcoBoost with just 37k miles show and engine light. Dealership diagnostic was PC0301. Misfire on the cylinder number 1. The solution? Engine replacement with a cost of $9,000 USD. Due to a well know problem. Coolant leak. I can not afford to pay this amount, and unfortunately the vehicle is not under warranty. Ford Motor Company knows this issue and still isn’t doing anything to help owners that are out of warranty. Surely is not a problem cause by the user, is a defect from factory. This problem also affects Canadian market and Mexico.

• 09/16/2025· ENGINE

  My car has been in and out of the shop since I purchased it, while still under the company’s warranty. I have went months without my vehicle at times. I feel these issues were directly related to a known engine failure/faulty engine by the manufacturer. My car was in a shop for nearly two months due to a rough idle without any diagnosis because it wasn’t producing a code. I brought the vehicle back in around a month later due to the same rough idle and was told the vehicle needed a new purge valve. Currently, my vehicle is at a Ford dealership waiting for a new engine to be installed. My vehicle was misfiring at start up, but my check engine light never illuminated. My coolant reservoir was completely empty. I found out that coolant was leaking into the engine compartment. I have been without my vehicle for a month now. At minimum Ford/Lincoln should be reimbursing the cost of my replacement engine since this is a known issue. Overall, I feel this should fall under a recall. I have a two year old daughter and driving this vehicle was a safety risk. Had I known about these issues I would not have purchased the vehicle. Ford/Lincoln failed to disclose that these vehicles have a defect that causes coolant to leak into the engine’s cylinders, which can cause corrosion, oil dilution and contamination, and engine failure. Ford/Lincoln failed to disclose these defects create a safety risk, because the lack of coolant created by the leaks causes overheating and can result in the cylinder head cracking, total engine failure, and/or engine fires.

• 09/13/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and Camelback Lincoln (1400 E Camelback Rd, Phoenix, AZ 85014) were made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 09/13/2022· ENGINE

  My 2019 Lincoln MKC has a coolant leak internal the engine. It is a known issue listed on the TSB (Technical Service Bulletin), however, Lincoln does not want to knowingly issue a recall. It has been informed as well per a Lincoln Dealership Service Advisor that several Lincoln’s have been in the dealership with this specific issue In which they feel that Lincoln should issue a recall, however, has not due to them not wanting to be responsible for replacing multiple engines due to the financial expense. I have spoken to Lincoln corporate in which they agreed to assist with the expense, however, will not cover the full amount. I have researched as well as paid over $600 to have a Auto shop confirm that the issue being experienced is not something that one can cause themselves directly to a vehicle regardless of the mileage. This is a 2019 Lincoln MKC in which should absolutely not be taking place as well unsafe and concerning with having a minor traveling in the vehicle. TSB 19-2208

• 09/11/2025· ENGINE

  The vehicle has now been at the dealership for almost two weeks. I drove the car in under its own power and was shocked to learn that it needs a new engine (long block) due to a known issue described in a Technical Service Bulletin (TSB) 19-2346 After doing my own research, I discovered that this is a widespread problem with the Ford 2.0L engine, and the dealership confirmed this by stating they’ve replaced hundreds due to this defect. I then contacted Ford directly, but was told by customer service that the vehicle is out of warranty, and nothing could be done. The Ford case number is [XXX]. Let me be clear: this is not normal wear and tear. A major engine failure at only 63,000 miles is completely unacceptable — especially in a Certified Pre-Owned (CPO) vehicle, which I was sold as reliable transportation. I now realize that Ford and its dealers have been knowingly selling vehicles with a manufacturing defect, without taking responsibility when those vehicles inevitably fail. This is a documented defect in the engine block, as acknowledged by Ford in the TSB. Yet there is no recall. Why? This issue poses a serious safety risk, not to mention a massive financial burden for consumers who trusted Ford’s certification and quality standards. It is deeply concerning that Ford has chosen to avoid accountability, leaving owners like myself to pay for expensive repairs stemming from your own design flaw. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 09/08/2023· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  In June of 2023, a potential fire recall was issued. Contacted two dealerships, was told no parts available. In August 2023, a second notice regarding fire (whether car is running or parked). Called dealer and was told “no parts yet, out on wait list, no idea when parts will come in.” Called several times.

• 08/29/2025· ENGINE

  Coolant leak, no warning overheating car turned off,needs new engine,coolant leak into cylinder ,only 62000 miles on the car

• 08/23/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 08/14/2024· WHEELS

  wheel bearing on driver's side front had to be replaced. It is not available for inspection. vehicle started making a loud woomp woomp noise near the wheel.My wheel could have seized while driving. The problem was confirmed and resolved by an independent service center. The vehicle was inspected by an independent service center There were NO warning lamps or messages prior to the failure. Symptom first appeared July 27, 2024.

• 08/11/2023· ENGINEFire

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while the vehicle was parked at a gas station the vehicle caught on fire. The dealer was made aware of the issue. The manufacturer was made aware of the issue. Parts distribution disconnect.

• 08/09/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who informed the contact that coolant was leaking into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

• 08/07/2023· ENGINE

  The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 08/05/2025· ENGINE,FUEL/PROPULSION SYSTEM

  On or about July 29, 2025, the check engine light illuminated in my 2019 Lincoln MKC Sport with a 2.0L EcoBoost engine. A mechanic inspected the vehicle on August 4, 2025, and confirmed coolant is entering cylinder one, likely due to a blown head gasket or, less likely, an engine block crack. Symptoms include coolant loss, potential misfiring, and the check engine light activation. The issue was identified through diagnostic testing (e.g., borescope inspection or compression test, pending specific results). No external coolant leaks were observed, indicating an internal engine failure. The vehicle has 89,516 miles and was purchased three months ago on May 5, 2025, from Ford City in Champaign, Illinois. Safety Concerns: Coolant intrusion into cylinder one risks engine misfiring, rough idling, or sudden power loss, which could cause engine stalling or failure during operation. This poses a serious safety hazard, as it may lead to loss of vehicle control, particularly at highway speeds or in traffic, endangering the driver, passengers, and other road users. The defect compromises the reliability of the 2.0L EcoBoost engine and requires costly repairs. Additional Context: • No known history of severe overheating exists, but maintenance records prior to purchase are unavailable. • The vehicle has no aftermarket modifications. • No crashes or injuries have occurred, but the issue emerged shortly after purchase, suggesting a possible pre-existing defect. • Similar coolant intrusion issues have been reported in earlier 2.0L EcoBoost engines (e.g., 2013–2016 Ford models), and this may indicate a recurring defect in the 2019 MKC. • I urge NHTSA to investigate whether this engine issue warrants a recall due to its potential safety impact.