2019 Hyundai Sonata Plug IN

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2025· ENGINE

  The engine is burning oil around 1 quart every 700 miles. I check the car oil level around every 10 days. I have experienced when I didn't check the oil and the low oil engine light would come on in the instrument panel. Hyundai shows no recall for this 2019 Hyundai Sonata Limited edition. I believe that this type of incident occurred back around 2011 with Hyundai's models for that time

• 12/27/2024· ENGINE

  The part in question is the oil pan. An oil leak was identified at the place where I get my oil changed. The service center at the dealership informed me that there was a crack in the oil pan due to overtightening of the drain plug. I am not sure how they made that connection. The risk of this oil leak could lead to engine failure if oil levels drop below a certain level. There were no warning lights or messages from the car about the oil leak.

• 12/23/2024· ENGINE,FUEL/PROPULSION SYSTEM

  What component or system failed or malfunctioned, and is it available for inspection upon request? Since april 2025 i’ve been having low oil readings in my vehicle despite regular oil changes I took it into the dealer since my vehicle was still under warranty, which they stated only one part was under warranty. I had to pay $800 after this was replaced. I started having engine light come on. This engine light when I paid a diagnostic fee I learned that the cylinder three was misfiring. It was suggested that I have an oil change and get the oil level checked again within a week. This was done and it was determined that it was burning too much oil. I submitted this to the insurance and was told that this was not covered that there must be another reason why this was not working the way it should. 3 weeks ago Then I was asked to replace the spark plugs and coils. These were replaced for an additional cost of approximately $300. After replacing this, the check engine light gave the same condition of third cylinder damage.. And the oil level continue to decrease The vehicle was left with the dealer for approximately 10 days. They stated that the engine needed to be cleaned due to possible carbon buildup for about $800 then they stated that the spark plugs and coils needed to be replaced with a specific brand and not the type that Was previously used. Then my vehicle was returned to me, performing sluggishly with the check engine light returning with the same condition of third cylinder misfire. An inspection is available. How was your safety put at risk? The possibility engine failure away from hom Has the problem been reproduced or confirmed by a dealer or independent service center? Yes twice Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes frequently over the last 2 months

• 12/20/2022· STEERING,ENGINECrash

  The car was stolen, one of the vehicles that Hyundai manufactured without an Engine Immobilizer, making it very easy to steal. Consumers didn't know about this defect, because the corrupt automaker kept us in the dark. I'm fairly certain that by breaking the steering column to expose the port to start the car, that driving the speed limit or having control of the vehicle was on the thieves mind. The safety of my neighbors and anyone they were driving would have had their safety compromised. The vehicle is currently being repaired cosmetically. The Engine Immobilizer will not be installed by the body shop. It was inspected by a certified repair shop of State Farm. No warning lights were illuminated.

• 12/19/2025· ENGINE

  My vehicle has an oil consumption problem. I put in 5 quarts of oil last week after changing the oil three weeks before this. I am down today December 19, 2025 2 1/2 quarts when I put in 5 quarts last Friday. Hyundai motor Corp. says I have to pay for the $90 oil change to do the oil consumption test then I have to go back 1000 miles later and pay $600 for an oil combustion cleaning and drive it another thousand miles and come back and see the oil level to see if I need an engine. I think this is absolutely a safety hazard and needs to be taken very seriously for all customers that drive a Hyundai that are having these issues.

• 12/17/2025· ENGINE

  Hyundai replaced my engine under warranty due to their oil consumption in mid October. About 2 weeks later all warning lights came on and they said need new battery. They put in new battery in November. 15 miles after new battery a burning smell and smoke came from under hood with visible smoke. Took to dealer following day and no smoke. Got car back and next day it’s smoking and burning smell. Got it back to dealership and they had it a while and said no smoke and I got car back. They can’t find a reason and it’s not smoking .About a week later (tonight) burning smell and smoke from under hood at the engine.

• 12/17/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Hyundai Sonata. The contact stated that the vehicle was experiencing excessive oil consumption. The vehicle was taken for an oil change, and the contact was informed that the vehicle required an oil change every 10 days. Additionally, the contact stated that the vehicle was taken to the dealer after driving 1,000 miles after an oil change, and the dealer informed the contact that a combustion cleaning was needed. The dealer performed the combustion cleaning, but the failure persisted. The check engine warning light was illuminated. The contact stated that an independent mechanic and the dealer had diagnosed the vehicle and had determined that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and declined to cover the cost of the repair. The failure mileage was unknown.

• 12/16/2023· STRUCTURE

  The paint of my 2019 Pearl White Sonata is peeling off on the hood. I see that there was an extended warranty extension on the same car of 2017 and 2018. I would like to know why not including 2019 of the same color on the same car.

• 12/12/2022· AIR BAGS

  The contact's uncle owns a 2019 Hyundai Sonata. The contact stated while his uncle was driving approximately 20 MPH and going over a speed bump, the driver's side front and side air bags deployed. The contact stated that the passenger’s side air bags did not deploy. The contact stated that his uncle saw the air bags warning light illuminated, but only after the air bags had deflated. The contact had taken the vehicle to a local dealer who did not want to diagnose the vehicle. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 27,000.

• 12/07/2024· FUEL/PROPULSION SYSTEM

  Fuel pump went out

• 12/07/2023· ENGINE

  There is excessive oil consumption with the engine in my car. Hyundai says 1qt per 1000 miles is “acceptable” however this is not acceptable and can lead to catastrophic engine failure and oil slick on roadways if not caught in time. This is a know problem with Hyundai/Kia at this time. In many cases Hyundai/Kia owners are left with a “lemon” of a new car that is currently in warranty. Some have been granted replacement engines that have not lasted 3000 miles. A recall must be issued in the name of safety on these cars. The manufacturer must be held accountable for the lack of quality that has been put out over the last decade.

• 12/04/2025· UNKNOWN OR OTHER

  Factory paint on my 2019 Hyundai Sonata (white Z05 warranty) is peeling on metal panels. Hyundai acknowledges paint failure under the Z05 warranty extension and directed me to authorized repair shops. When I contacted these Hyundai-referred shops, they stated they do not blend horizontal panels such as hood/roof/deck lid and would instead tint or use trim to disguise color differences. Hyundai corporate confirmed in writing that tinting alone does not meet Hyundai OEM repair standards, and that blending should be used when needed for proper color matching. Independent body shops also confirmed blending is required for a proper repair, with documented estimates ranging from $3,064 to $10,378.92 for OEM-level refinishing. Being offered tint-only/spot repairs without blending leaves exposed primer and will lead to corrosion and metal degradation over time. This raises a potential safety concern due to loss of corrosion protection on structural panels. Documentation from Hyundai corporate, repair quotes, and shop responses are available upon request.

• 12/03/2019· UNKNOWN OR OTHER

  I PURCHASED THIS VEHICLE BRAND NEW WITH ONLY 18 ACTUAL MILES ON THE CAR AROUND 6/14/19. DURING A CALL TO DEALERSHIP CUSTOMER SERVICE CALL I WAS ADVISED THERE WAS A SOFTWARE UPDATE THAT NEEDED TO BE COMPLETED (SERVICE CAMPAIGN 953 - ECM & CLUSTER UPDATE-ENGINE MONITORING LOGIC PRODUCT IMPROVEMENT). SERVICE WAS COMPLETED WITHIN 4-5 DAYS BEFORE SERVICE CAMPAIGN WAS CLOSED. WITHIN ONE WEEK LATER WAS DRIVING VEHICLE AND BELL WENT OFF AND DISPLAYED TWO MESSAGE ON THE INSTRUMENT CLUSTER. THREE INDICATOR LIGHTS WERE FRONTAL COLLISION AVOIDANCE, WARNING INDICATOR AND EPB INDICATOR ACTIVATED. AFTER ARRIVING AT DESTINATION I WAS GOING TO BACK VEHICLE INTO A PARKING SPOT AND NOTICED THE REAR CAMERA NOT WORKING. AFTER GETTING BACK IN CAR AND LEAVING, THE INSTRUMENT CLUSTER AND CAMERA WAS BACK TO NORMAL OPERATION. NEXT DAY RETURNING HOME FROM WORK THE SAME INCIDENT OCCURED A SECOND TIME. THIS TIME NOTICED AFTER PUTTING THE VEHICLE IN PARK AND NOT TURNING VEHICLE OFF, THEN TRYING TO PUT VEHICLE IN DRIVE, THE GEAR SHIFTER WOULD NOT COME OUT OF PARK UNTIL VEHICLE IS TURNED OFF. TOOK TO DEALERSHIP AND VEHICLE WAS SHOWING SEVERAL CODES. HYUNDAI WAS CONTACTED AND WAS ADVISED TO HAVE SOFTWARE REBOOT. THIS WORKED FOR CLOSE TO A WEEK THEN HAPPENED A THIRD TIME WITHIN 403 MILES SINCE SERVICE CAMPAIGN WAS COMPLETED AT 7514 MILES.

• 11/29/2025· ENGINE

  My oil light came on after driving it about 4700 miles from purchase date. I checked the oil and there was no oil on the dipstick. 200 miles and 2 days later the check engine light came on and put it into limp mode. It was about a half quart low. I was put at risk for having to go slow on a main highway to get back home. I took it to a local Hyundai dealership they did a diagnostic and bearing clearance test for 572.00. They said it passed. Then I did a 1000 mile oil consumption test. They over filled my oil and it passed. The 2nd 1000 mile oil consumption test they did not over fill my oil and it failed. They told me they would submit a PA to Hyundai corporate and as long as the maintenance was done they would most likely replace the engine. He also told me my engine could blow anytime. They never called me back so when I called the dealership they said they denied it needed a new engine. They wanted me to pay another 800 to run a combustion test. I am not paying for anymore testing when they clearly have engine problems with many of their engines. I had warning signs and that’s when I called the dealership I purchased it from and went on this path. I was also told that this was covered under an extension warranty of 120, 000 miles. Only to be told by Hyundai corporate that it is not covered. This is an issue Hyundai is well aware of and they refuse to fix it.

• 11/22/2023· ELECTRICAL SYSTEM,LANE DEPARTURE

  Blind-spt warming system inoperable. When malfunctioning, cannot disengage the key from the ignition. Problem has been confirmed by dealer. Vehicle has not been inspected by manufacturer, police, insurance representatives or others. Blind-spot warning light has been illustrated on the dash intermittently since 10/5/22.

• 11/10/2022· ENGINE

  4500 miles after an oil change the oil drain plug fell out and oil leaked out resulting in an engine stalling. An oil warning light came on 7 minutes before the vehicle stalled on the highway.

• 11/08/2024· ENGINEFire

  I started the car and smoke came from the engine compartment I didnt think anything of it but the smoke keep getting worse . So I pulled over and open the hood to find fire come from on top of the Engine the flames got higher so I asked an local restaurant for an fire extinguisher I put it but know these cars this could of been an big problem if I had parked in the garage or park next to other cars or even if I keep driving . It would of not been good! By this time the Shelby Twp. fire dept showed up and sprayed more water on it.

• 11/08/2019· EXTERIOR LIGHTING

  CATEGORY: POTENTIAL FATAL. LOW BEAM HEADLIGHTS ON DRIVERS SIDE HAS A BLIND SPOT APPROXIMATELY 30 FEET FROM FRONT OF VEHICLE OBSCURING PEDESTRIANS AND ON COMING TRAFFIC FROM THE OPERATOR. BLIND SPOT IS APPROXIMATELY 5 FEET WIDE BY 15 FEET LONG AND ALSO WITH A MINOR BLIND SPOT AT APPROXIMATELY 40 FEET AND TO RIGHT OF ORIGINAL STATED BLIND SPOT AND IS APPROXIMATELY 1/5 THE SIZE OF ORIGINALLY STATED BLIND SPOT. THIS IS A TOTAL OF 2 BLIND SPOTS, CREATING AN UNSAFE DRIVING ENVIRONMENT WITH POTENTIAL FATAL CONSEQUENCES.

• 11/06/2024· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  Failed Component: Engine - Burnt Valve/ Snapped Piston/ Piston Scrapping Internally; available for inspection - Risk of safety: Car sputters/jerks upon acceleration, takes a long time to gain speed, STALLS when slowing or stopping, may or not start after stalling, violently shakes while driving - Problem has been confirmed by Hyundai dealer/repair - Component has not been inspected by the manufacturer, police, insurance representative; only Hyundai repair - Warning lamp, messages, and symptom PRIOR to failure, NO, after the failure, YES; check engine light and all symptoms listed above; all appeared approximately September 15, 2024. Since the purchase of the vehicle in January 2024, I have made complaint regarding the performance of the vehicle. Have had multiple oil changes/fill ups within the last 7 months, due to excessive oil consumption. Vehicle has had scheduled maintenance, several diagnostics, and too many trips to the dealership/repair for a 5 year old vehicle, with regular maintenance, and 3 owners. I have owned the vehicle for less than a year and I am UNABLE TO DRIVE IT DUE TO HYUNDAI STATING IT NEEDS A NEW ENGINE. It stalls when slowing and stopping, which it may or may not start back up - this happened a few times in the middle of traffic. It will not gain speed appropriately when moving from a complete stop, inhibiting me from keeping up with traffic. It shakes violently while accelerating, causing mishandling and ability to steer effectively.

• 11/04/2019· ENGINE

  I PURCHASED A 2019 SONATA DEMO VEHICLE WITH 5,020 MILES IN JUNE 2019. I REMOVED THE TEMPORARY TAG AND REPLACED WITH PERMANENT TAG ON JULY 16. ON JULY 20, WHILE DRIVING ON THE EXPRESSWAY AT APPROXIMATELY 65MPH, THE ENGINE OVERHEATING ALERT CAME ON AND THE TEMPERATURE GAUGE WAS ON HOT. I PULLED OVER ON THE SIDE OF THE EXPRESSWAY AND WAITED FOR HOURS (IN NEARLY 100 DEGREE SUMMER HEAT) TO HAVE A NEW VEHICLE TOWED TO THE DEALERSHIP. THE SERVICE DEPARTMENT ADVISED ME THAT THE WATER PUMP MALFUNCTIONED AND CAUSED THE BELT TO TEAR. THE SERVICE DEPARTMENT COULD NOT PROVIDE A REASON FOR WHY THE WATER PUMP/BELT MALFUNCTIONED ON A NEW VEHICLE. THE WATER PUMP AND THE BELT WERE REPLACED AFTER THE SERVICE DEPARTMENT HAD MY VEHICLE FOR A ABOUT A WEEK. THE SERVICE DEPARTMENT ADVISED ME THAT I SHOULD NOT HAVE ANY FURTHER ISSUES WITH THE VEHICLE. THE REPAIRS WERE COMPLETED ON 7/29/19. ON AUGUST 16, I TOOK MY VEHICLE BACK TO THE DEALERSHIP BECAUSE IT APPEARS THAT THE REPLACED/NEW BELT IS SPLITTING/TEARING. THE SERVICE DEPARTMENT ADVISED ME THAT THERE IS NOTHING WRONG WITH THE BELT, HOWEVER, THERE IS CLEARLY VISIBLE EVIDENCE THAT THE NEW BELT IS SPLITTING ALSO. I HAVE ATTACHED A PHOTO OF THE VEHICLE PRIOR TO THE REPAIRS; A PHOTO OF THE NEW BELT THAT IS CURRENTLY SPLITTING; THE ORIGINAL SERVICE REPAIR DOCUMENT AND THE DOCUMENT OF THE SERVICE DEPARTMENT ADVISING ME THAT NOTHING IS WRONG WITH THE NEW BELT. FROM THE PHOTO, YOU CAN CLEARLY SEE THAT THE NEW/REPLACED BELT IS SPLITTING ALSO AND IT IS JUST A MATTER OF TIME BEFORE THE ENGINE WILL OVERHEAT AGAIN AND I WILL BE ON THE SIDE OF THE ROAD WAITING FOR A TOW. AGAIN, THE SERVICE DEPARTMENT DID NOT HAVE AN EXPLANATION AS TO WHAT CAUSED THE WATER PUMP/BELT TO MALFUNCTION AND NOW THEY ARE DENYING THAT THERE IS AN ISSUE WITH THE REPLACED BELT.

• 11/04/2019· EQUIPMENT

  2019 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO DEFECTIVE KEY FOB. *LD THE CONSUMER STATED THE ELECTRONIC FOB EASILY AND UNITENTIONALLY DETACHES FROM THE EMERGENCY KEY. *JS

• 10/29/2023· ENGINE

  I bought this car 1 year and 2 months ago from a Hyundai dealership. The car was close to 73,000 miles. A few days after I got the car I started hearing this noise that sounded like a rattle coming from the front while accelerating to about 2,000 RPM. Due to my work, I went back to the dealer after 1,000 miles and explained to them about the noise and they duplicate it. The engine was consuming oil when I bought the car, I went back to the dealer and never did any testing on oil consumption. The problem got worst and worst. I started a claim with Hyundai Corp and I waited for 4 months to the an approval and they are only covering 50% of the engine. Dealer says I have to pay $3,200 to start engine replacement process, with no payment plan. Now I have a debt of $17k and no car. Engine has no compression on cylinder 3, which causes a misfire and makes the car unsafe to drive and leaves me unemployed with a child and bills to take care of. Thank you Hyundai, nice job .

• 10/28/2019· EXTERIOR LIGHTING

  WHILE DRIVING MY 2019 HYUNDAI SONATA AFTER DARK I SUDDENLY VIEWED A RATHER LARGE BLACK MASS AND THINKING IT COULD BE A PERSON I JAMMED ON THE BRAKES. WITH THE CAR NOW IN PARKED STATUS I REALIZED THAT THE BLACK MASS WAS CREATED BY THE HEADLIGHTS A FRIGHTENING EVENT AND IF A CAR WAS IN BACK OF ME A SEVERE ACCIDENT COULD HAVE

• 10/21/2025· ENGINE

  Engine is burning oil at an excessive rate. Burning a liter every 1,000 miles and Hyundai refuses to do anything about it.

• 10/21/2025· ENGINE

  Problem with the valve cover gasket. Dealer said replaced. Engine oil smell has been entering into the cabin and making me ill. Causing chest pain, headache, dizziness, nausea.

• 10/21/2025· ENGINE

  My car has been with Priority Hyundai in Chesapeake Va since September 23rd. They have advised me that I will definitely need a new engine however, Hyundai is requiring them to do 2750.00 worth of work on my engine before they can submit a claim to have my engine replaced. They explained to me that one of the piston rings in my engine needs to be replaced. The service technician reassured me “the failure was nothing that I could have caused”. I have gotten my oil change regularly, and I have paperwork that shows that. The car is five years old. I’ve only had the car for 3 years and I’m the first owner. I have never driven my car long distance. I work from home. The most I do is take my boys to and from school which is at the most 5.1 miles away from my home. The dealer recommended that I call Hyundai my self and start a case. Which I did. Two days later Hyundai Canada called to tell me their decision is final and my case was denied because the warrant is 5 years/60,000 miles I told them the car was over the 60,000 mileages when I bought it and I’m still well within the 5-yr mark. She then says, basically that the piston failure is not included in the extended warranty. However the class action suit states differently. The dealership advised me that their system shows a 99 yr warranty on the engine, which they took that to mean lifetime. They priced me a new engine at 7111.00 in addition to the 2750.00 of engine work they told me I must get done before hyundai would approve me for a new engine. I have been in contact with the lawyers handling the Hyundai/Kia 2.0L and 2.4L Theta II GDI Engine Class Actions. They have added me to the data base and provided me some direction. which have led me to you, the NHTSA.

• 10/19/2024· ENGINE

  In April of 2024 initially the car was under warranty. I took my vehicle to the Edmond Hyundai dealership to see why I kept having to put oil in the car in between oil changes. The dealership said iI needed an oil consumption test to determine if the loss of oil amount was excessive. They changed the oil and i drove it 1000 miles and returned it to the dealership. They said it was was around 1 quart low, which is acceptable and "normal". This isn't normal. I tried to get them to check the engine again and do other tests but they wouldn't. It is now October of 24' and I am still putting oil in between oil changes because the light comes on. I took the car back to the dealership on 10/19 and they said the only thing they could do is another consumption test to determine if the oil loss is excessive. I asked them to do a more thorough check of the engine and cited the previous time I brought the car in for the same issue that was not resolved. The mileage is now just over the warranty threshold, but they are still wanting me to pay for whatever service needs to be done to the vehicle, whether it's a combustion cleaning or a new engine. The safety of the car is of concern now and since this car is driven by the three drivers in the family, I do not want them put at a risk on the road if something fails because of oil loss and engine seize. Hyundai needs to be held accountable and honor warranty, safety, and service. The dealers need to help the customer and go above and beyond. The staff at Edmond Hyundai kept going back to the consumption test and all the steps they need to follow before they could send in a submission for doing a combustion cleaning when clearly there was an issue. I am beyond frustrated with the lack of concern for safety and customer satisfaction.

• 10/12/2025· ENGINE

  Burning oil

• 10/08/2022· ENGINE

  The dates are backwards because of the most serious incident which put my safety at risk. On October 3, 2022, while driving on a busy interstate, in rush hour traffic all of a sudden my car began to stall, there was a rattling/knocking sound emitting from the car, I lost power, could not accelerate and my check engine light began to flash. This leads me to believe it was an engine malfunction or failure involving the engine after viewing various ?online complaints. This was a safety risk not only to myself but to others because there is a posted speed limit that must be maintained on major highways. Other drivers began honking their horns, which added more fear to the anxiety I was already experiencing. In retrospect, had a car not realized I had slowed could have hit my car, which could have resulted in fatal injuries to my infant son and I. There was a recall service campaign update 953, which is related to the knock sensor detection system, which was performed on my car in February 2020. Furthermore, on October 1, 2022 while driving a red oil lamp began to flash on my car. I pulled over on the side of the road, called my personal mechanic who then informed me to get someone to bring oil before driving from the location. Once my friend brought the oil, it took 5 quarts before the light stopped blinking and I was able to drive home. The next day, I saw what appeared to be dark colored oil on ground where my car was parked overnight. Subsequently, I took the car to inspect the leak, because Hyundai informed me nothing would be covered because I was just outside of my 60,000 mile warranty. While at the mechanic it was found that I had an oil leak emitting from a crack in my oil pan. Again, my personal mechanic advised I take my car to the dealer, which I had the car towed on October 5, still waiting for a response on the status of my car(10/8/2022) from Hyundai while paying for a rental out of my own pocket.

• 10/01/2024· ELECTRICAL SYSTEM,ENGINE

  Around the 70,000 to 80,000 mile range, I began to notice that I needed more frequent oil changes. Additionally, when making turns, the oil pressure light would illuminate. I reported these concerns to the service manager, Steve Purvis, at Noblesville Hyundai, who advised that the light simply indicated the need for an oil change. Due to the ignorance of Steve Purvis, I took my vehicle to Hyundai of Carmel, where the issue was not addressed until I reached 97,000 miles. During this time, the valve covers were replaced twice, yet there were no active leaks, and the problem persisted. Hyundai subsequently denied my request for an oil consumption test to further diagnose the issue. I then took my vehicle to a different shop, where a mini oil consumption test revealed that my car burned over 2 quarts of oil from Friday to Monday. Additionally, my start/stop system has ceased functioning, preventing me from starting the vehicle. I have also noted that there are open recalls for Hyundai vehicles, yet my VIN is not recognized under these recalls. I have incurred significant expenses related to these ongoing issues. My safety has been put to risk because the oil can burn completely out and cause the car to break down in the middle of traffic like it has before. Hyundai dealership has confirmed the car has an oil burning issue, as well as an independent shop by the name of Auto Tech in Indianapolis. Auto Tech has also confirmed that the start/stop system is causing my car to not start. The oil pressure light is not consistent when my oil gets low. Some times it comes on, other times it does not.

• 09/28/2020· EXTERIOR LIGHTING

  THE LED DYNAMIC BENDING HEADLAMPS PROJECT 2 BLACK VOIDS ONTO THE ROADWAY OR STATIONARY OBJECTS IN FRONT OF THE VEHICLE. THESE VOIDS DO NOT ILLUMINATE THE AREA ON THE PAVEMENT AND ARE A DRIVING DISTRACTION. THE VOIDS CAN BE OBSERVED CONSISTENTLY DURING USE OF THE LOW BEAMS WHETHER THE VEHICLE IS IN MOTION OR STATIONARY. THESE DARK VOIDS ONLY APPEAR WITH LOW BEAM USE AND DO NOT APPEAR WHILE USING THE HIGH BEAMS. AT THE TIME I PURCHASED THE VEHICLE, OCT 21, 2019, THE SALES REP INFORMED ME THIS FLAW COULD BE FIXED BY A MERE HEADLAMP ADJUSTMENT AND AFTER 3 HEADLAMP ADJUSTMENTS BY THE DEALER (ONGOING INTO FEBRUARY 2020 AND HAVING HYUNDAI DIRECTLY TELL ME TO WORK OUT ISSUE WITH DEALER) BECAUSE IT COULD NOT BE FIXED AND THERE WAS NO WAY OF CHANGING THE HEADLAMP ASSEMBLY, THE DEALERSHIP FOUND A TECHNICAL BULLETIN FROM HYUNDAI ABOUT THIS ISSUE DATED DECEMBER 2018 DESCRIBING THESE VOIDS AS AN ANTI GLARE MECHANISM AND TO NOT PERFORM ANY HEADLAMP ADJUSTMENTS.

• 09/22/2025· ENGINE

  Excessive oil consumption leading to no or low oil levels. Piston ring design flaw allowing oil to leak into combustion chamber, damaging the spark plugs. No warning lights until failure posing a significant crash risk for my family. Engine failure at 134K miles without warning, rings need replaced, per mechanic. I am shocked as I just paid the car off and thought Hyundai was a good brand.

• 09/20/2023· UNKNOWN OR OTHER

  I have the White Pearl paint and it started peeling on the hood and drivers side door.

• 09/19/2022· EXTERIOR LIGHTING

  The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at night at various speeds with the low beam headlights activated, there was a shadow reflecting on the roadway. The driver’s side headlight illumination was distorted. Additionally, it was difficult to keep the vehicle on the highway. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 26,200.

• 09/18/2025· ENGINE

  Burning excess oil

• 09/12/2025· ENGINE

  The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at various speeds, there was a knocking sound coming from under the hood. The contact stated that the engine was consuming an excessive amount of engine oil. In addition, while attempting to drive, the vehicle failed to exceed 5 MPH. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with a blown piston and cylinder #2 failure. The vehicle was repaired; however, the failure reoccurred. The contact stated that while stopped at a stop sign, there was black smoke coming from under the hood, with an abnormal sound coming from the vehicle. The vehicle was taken to another local independent mechanic, where it was diagnosed, and determined that the catalytic converter needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

• 09/05/2026· FUEL/PROPULSION SYSTEM

  The low-pressure fuel pump module assembly, located directly beneath the rear passenger seat cushion, experienced a plastic housing failure. A stress fracture on the upper plastic fuel outlet nipple caused raw liquid gasoline to actively weep and pool on top of the module inside the passenger cabin. This component is retained and available for inspection upon request. RISK TO SAFETY: Raw liquid gasoline pooling inside the interior passenger compartment creates an severe, immediate fire and explosion hazard. Additionally, vehicle occupants were exposed to toxic fuel vapors while driving. INSPECTION & DEALER CONFIRMATION: An authorized Hyundai dealership inspected the vehicle and confirmed raw fuel leaking at the top of the fuel pump module assembly. This exact module had previously been removed and disassembled during a 2024 manufacturer recall service to replace the internal fuel filter and tank seal. Stress applied to the plastic fittings during that recall service appears to have caused the plastic top-hat to fracture over time under line pressure. Hyundai Corporate was notified of the safety hazard and prior recall history, but refused assistance. WARNING SYMPTOMS: The failure began with a strong, persistent fuel odor inside the vehicle cabin. No dashboard warning lights, check engine lights, or diagnostic trouble codes (DTCs) triggered prior to or during the failure. SUMMARY: A stress-fractured plastic fuel pump housing allowed raw fuel to pool in the passenger cabin following a prior manufacturer recall repair involving the disassembly of the same component.

• 09/05/2024· ENGINE

  The contact owns a 2019 Hyundai Sonata. The contact stated that after the vehicle was purchased, the vehicle was taken for an oil change. The contact stated that the very next day he checked the dipstick and became aware that there was no oil on the dipstick. There was no warning light illuminated. The dealer was called, and the contact was informed that there might be an oil consumption failure with the vehicle. The vehicle was taken to the dealer for an oil consumption test; however, the contact stated that he was not able to pay for the oil consumption test to be performed. The contact stated that the vehicle was not yet diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 118,000.

• 09/03/2019· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2019 HYUNDAI SONATA. WHILE DRIVING AT NIGHT, THE PROJECTOR BEAM HEADLIGHTS FAILED TO ILLUMINATE THE ROAD. THE VEHICLE WAS TAKEN TO NICHOLAS PARKS HYUNDAI KIA (1066 MARINA BLVD, SAN LEANDRO, CA 94577, (510) 347-3000) WHERE THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL ON THE VEHICLE AND REFEREED THE CONTACT TO THEIR REPAIR CENTER. THE VEHICLE WAS TAKEN TO THE REPAIR CENTER WHERE THE CONTACT WAS INFORMED THAT THE LIGHTS MET HYUNDAI STANDARDS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS OPERATING NORMALLY. THE FAILURE MILEAGE WAS 68.

• 09/02/2025· ENGINE

  I just had an Oil change twice on this car it burns oil like crazy..mine you only had car for5 months

• 08/31/2024· POWER TRAIN,ENGINE

  Car has a rod knock, has been looked at by a private mechanic, seen online there was a recall on Hyundai Sonatas for rod knock issues.

• 08/29/2024· ENGINE AND ENGINE COOLING

  See attached document for complaint.

• 08/24/2022· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

  Unknown. This has happened a couple times now. I am driving and the HEV light, engine light and battery light turn on, car won’t brake properly and almost cause me to hit other cars and will shut off on its own on the highway. It will accelerate on its own even when trying to brake. Extremely dangerous.

• 08/24/2019· EXTERIOR LIGHTING

  THE LEFT HEADLIGHT HAS A LARGE BLACKOUT AREA THAT CREATES A SHADOW ON THE ROAD. WHEN DRIVING ON ANY STREET AND ESPECIALLY ON WINDING ROADS IT'S VERY DISTRACTING AND MAKES US THINK THAT THERE IS SOMETHING MOVING ACROSS THE ROAD. I AM DISTRACTED WHEN THIS HAPPENS AND SOMETIMES HIT THE BRAKES. THE RIGHT HEADLIGHT HAS A SIMILAR ISSUE BUT NOT NEARLY AS PRONOUNCED. IT'S AN ASYNCHRONOUS SITUATION WITH ONE HEADLIGHT DISTORTED LIKE THAT. IT'S DANGEROUS IN OUR OPINION. WE DON'T DRIVE AT NIGHT MUSH AND NOTICED THIS RECENTLY BUT WERE WAITING UNTIL THE FIRST OI CHANGE TO GET THIS ADDRESSED.

• 08/22/2025· ENGINE

  I took my car to the garage after purchase around 75,000 miles due to rattling noise 8n the front and the amount of oil that my car was requiring in between oil changes, did the oil consumption test it came back on the higher range but Hyundai offered no resolution

• 08/18/2026· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle experienced severe overheating and excessive oil consumption. The contact also stated that there was a misfire in the engine even though the spark plugs and ignition coils were replaced. Due to the failure, the vehicle could not be driven with the air conditioning activated. Additionally, the engine was knocking and shaking abnormally, causing an oil leak and a smoke odor due to the oil burning. The vehicle was taken to a dealer, where an engine replacement was recommended. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 140,000.

• 08/18/2026· ENGINE

  The oil is low, went to get looked at by another mechanic besides Dealer cause they want to hit you over the head with prices. Was told car burning oil. Took to dealer for Oil Consumption Test. Had to pay for oil change. Came back a little before 1,000 miles and car failed. They charging me 900.00 for next step because I can’t find ALL the oil changes. I just don’t get it, if this is a known issue with this model engine why do I have to pay.

• 08/15/2022· STEERING

  In September 2021 my power steering went out at highway speed making it unsafe and difficult to steer. The power steering ECU was replaced. The same thing happen again in June 2022 this time more parts were replaced position / torque sensors and wiring harness. The same issue happened again in 8/2022 the steering wheel was jerking and trying to make corrections (I don't have lane keep assist on any type of steering assistance in my vehicle. This in an ongoing problem and I can't trust that the vehicle is sage

• 08/14/2023· UNKNOWN OR OTHER

  This is not a safety issue but I feel it need to be recognized my vehicle is peeling paint from on top of roof and I see this happening on numerous amount of Hyundai Sonatas and Hyundai are not addressing the problems and I am still making payments on my car I want this displayed to make everyone aware this is a complete rip off on hyundia's behalf I hope to never purchase a vehicle from any Hyundai's company ever again they will have you going from one person to the next

• 08/13/2026· ENGINE

  On January 26, 2026, my 2019 Hyundai Sonata SEL suddenly became inoperable overnight. The vehicle had been operating normally with no warning signs—no check-engine or oil-pressure light, abnormal engine noise, overheating, loss of power, or other indication of an impending failure. The following morning, the engine would not start. The vehicle was towed to an independent mechanic on January 28, 2026, who determined that the engine was locked/seized. On February 11, 2026, it was towed to Wayne Hyundai for further diagnosis. The vehicle had only 51,533 miles and had received Hyundai’s Knock Sensor Detection System (KSDS) update. Hyundai denied warranty coverage, citing engine sludge, despite my providing a complete service history after resubmiting the missing receipts I had previously misplaced. My primary concern is safety, not the warranty dispute. A sudden engine seizure without warning could cause an unexpected loss of propulsion or create a dangerous situation if the engine fails while the vehicle is being driven. This concerns me because Hyundai Theta II engines have previously been associated with engine seizure and stalling, including issues addressed through The Hyundai Theta II Engine Settlement: and subsequent litigation involving certain 2019 Sonata vehicles. I respectfully request that NHTSA investigate whether a continuing or insufficiently addressed engine defect exists in affected 2019 Hyundai Sonata vehicles, particularly sudden engine seizure/no-start failures occurring without warning. I also ask NHTSA to examine whether existing recalls, campaigns, software updates, warranty extensions, and other remedies adequately protect owners when an engine fails suddenly before the KSDS system provides a warning.