2019 Hyundai Santa FE

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2020· AIR BAGSCrash

  IT'S A RENTAL CAR. IT WAS A SNOW DAY AND HIT ON THE CONCRETE WALL BUT THE AIRBAG DIDN'T DEPLOY. COMPARED TO THE DAMAGE TO THE CAR, IT IS A SAFETY CONCERNS.

• 12/27/2019· ENGINE

  TL* THE CONTACT OWNS A 2019 HYUNDAI SANTA FE. WHILE DRIVING 17 MPH, THE BCA BRAKING SYSTEM ENGAGED, THE VEHICLE LOST POWER, AND ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON, WHICH RETURNED IT BACK TO NORMAL. THE VEHICLE WAS TAKEN TO O'BRIEN HYUNDAI FT MYERS (2850 COLONIAL BLVD, FORT MYERS, FL 33966, (239) 880-8631) WHERE IT WAS TEST DRIVEN FOR APPROXIMATELY 77 MILES; HOWEVER, THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED THE CONTACT WITH CASE NUMBER: 16693618 AND A LOANER VEHICLE. THE CONTACT REFERENCED NHTSA ID NUMBER: 10167260. THE FAILURE MILEAGE WAS APPROXIMATELY 16,000.

• 12/23/2022· VISIBILITY

  •What component or system failed or malfunctioned, and is it available for inspection upon request? When ambient temperature is at or below 32 degrees Fahrenheit, sufficient heat is not produced from the vehicles defroster to keep the windshield from icing. Also, sufficient heat is not produced to keep vehicle occupants warm. A Hyundai dealership confirmed the problem and replaced the thermostat, but the problem still persists. •How was your safety or the safety of others put at risk? Visibility through the windshield cannot be maintained. Also, the cabin temperature is insufficient for safe transport of young children. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has been inspected and confirmed by a Hyundai dealership. The problem persists and has been an issue since the vehicle was purchased in 2019. The first winter that the vehicle was operated during (2020) was when the problem first presented. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The water temperature gauge on the dash board “bounces” back and forth while driving the vehicle when the ambient temperature is at or below 32 degrees Fahrenheit. This has been reported to Hyundai corporate –Hyundai case # [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

• 12/22/2023· ENGINE

  Oil Pan leaks after an oil change. Oil pan has a hairline crack just below the drain plug after normal tightening of the plug. Excessive oil was found on my driveway. No obvious engine damage, considering the vehicle was only moved from one spot to the other. The dealer stated the oil pan isn't covered under warranty. I simple internet search revealed there was a high number of complaints. It was a "Do It Yourself repair." The cost to fix was to replace the oil pain, new tools and 5 quarts of oil.

• 12/20/2023· STRUCTURE

  2019 Hyundai the white paint is peeling. It was not caused by road damage. I asked the dealership and was told I was past the warranty due to my mileage.

• 12/20/2019· ENGINEFire

  PREVIOUS HYUNDAI VEHICLE CAUGHT FIRE. AT THE TIME THE CAUSE WAS UNKNOWN. WAS FORCED BY HYUNDAI TO BUY BACK VEHICLE AND PURCHASED A BRAND NEW HYUNDAI VEHICLE. I WAS NEVER TOLD THAT THIS WAS A BRAND WIDE ISSUE AND THAT THE NEW VEHICLE I PURCHASED WOULD END UP UNDER THE SAME RECALL THAT CAUSED PREVIOUS VEHICLE TO CATCH FIRE. I AM TERRIFIED TO DRIVE THIS VEHICLE. I CONTACTED HYUNDAI TO EXPLAIN THE SITUATION AND HAVE BEEN DEALING WITH AN UNPROFESSIONAL CUSTOMER REPRESENTATIVE. I AM FEARFUL FOR MY LIFE IN THIS VEHICLE AND EXPLAINED WHEN I PURCHASED THE NEW ONE THAT I DID NOT WANT TO EVER GO THROUGH THIS SITUATION AGAIN.

• 12/18/2024· POWER TRAIN

  Transmission: yes, available upon inspection I own a 2019 Hyundai Santa Fe. I have brought it in for repairs on the transmission a couple of times. The check engine light has come on but the computer was not displaying the problem. I am aware that this is not uncommon for the year, make, and model. Recently, I was driving my car on a high-speed highway when the transmission went out. While suppressing the gas, the transmission slipped and would not accelerate. As cars were passing me on either side, my car decelerated and cars behind me came close to rear-ending me. Again, this was at high speeds and put my safety in jeopardy. I was finally able to find a gap in the cars and able to get to the shoulder but not after several minutes of unsafe conditions. After this incident, I brought it back to the service center and the computer analysis did display that it is an internal transmission problem. The service center has inspected the transmission. Yes, the warning lamps were displaying, first about 8 months prior. As stated previously, the actual problem was not displaying. Attached document is previous work done for transmission due to incorrect computer diagnostics.

• 12/15/2024· UNKNOWN OR OTHER

  rear camera malfunction just like other models

• 12/15/2021· FORWARD COLLISION AVOIDANCE

  "FCA" system disabled radar blocked" error came on while test driving on 3 separate occasions but no diagnostic code recorded, prior to taking possession they replaced a camera they thought to be the cause 11 days later during a snowy morning I got the same error again. Again it didn't register a code and I was told by the dealership no code, no problem. Spoke with Hyundai customer relations and was told I have to take it back to the dealership for them to diagnose it, and the condition has to be reproduced for them to note the error but We have not had snow since that morning therefore the system error has not reappeared. The likelihood of being able to reproduce the circumstance during business hours and be able to get it to them to witness the situation is minuscule at best. If this safety feature is deactivated when something as simple as a snowflake blocks the sensor then it isn't really a safety feature. The safety features contributed to my decision to purchase this vehicle (Nov 1st) but all I am told was the radar was blocked and therefore caused the deactivation, but again how can something as simple as a snowflake cause this error and the manufacturer not address this as a safety concern.

• 12/14/2018· VISIBILITY/WIPER

  WHILE DRIVING MY NEW 2019 SANTA FE I NOTICED THE FIRST TIME IT RAINED I HAD SEVERE REDUCED VISIBILITY IN THE LEFT PORTION OF THE WINDSHIELD WHERE THE WIPERS DON'T REACH. THE RAIN POOLS THERE AND DOES NOT GET ANY BETTER THAN PICTURED. THIS IS A SAFETY ISSUE AS YOU CAN NOT SEE OUT OF 15% OF THE WINDSHIELD AND COULD CAUSE AN ACCIDENT.

• 12/13/2025· ENGINE

  Vehicle is consuming oil at an exceptionally fast rate. In October 2025, when taken in for an oil change and my complaint of a burning smell upon quick acceleration, the technician documented no oil was found on the dipstick. Just a month later, in November 2025, the oil level was already extremely low, the vehicle was taken back to the dealer, and an oil consumption test is currently being administered. The vehicle is scheduled for an engine replacement in January 2026 after the consumption test is concluded.

• 12/13/2023· ELECTRICAL SYSTEM

  At various times the vehicle will not start. It takes multi times to to start the vehicle. The starter and battery have been tested and both are in excellent condition. Both key phob batteries have been replaced and the vehicle at times won’t start but the dash lights turn on. After twice of trying to start the breaks get really stiff. I’ve learned if I get out of the vehicle and open the hood and close it the car will start then any other time getting out and back in it does not start. I even placed the key phob in the designated location of the battery died and still won’t start. The check engine is not on either.

• 12/10/2018· FUEL/PROPULSION SYSTEM

  GAS TANK LEAK UPON DELIVERY. AFTER INSPECTING THE LEAK, TECHNICIANS WERE ABLE TO IDENTIFY THE MANUFACTURER HAD ISSUED REPAIRS ON GAS TANKS THAT WERE TOO THIN AND AS A RESULT, THE VEHICLE WE PURCHASED WAS NOT PROPERLY REPAIRED AND LEAKED FUEL.

• 12/08/2024· POWER TRAIN

  Upon going for an oil change at Express Lube in Newton , NJ I was advised that there are multiple widespread & ongoing problems with a crack that forms in the oil pan next to the drain/fill plug. My vehicle was diagnosed with that very problem. I believe a a recall to should be done by Hyundai to replace these oil pans. Thank you

• 12/05/2024· UNKNOWN OR OTHER

  I have unusable camera in my 2019 Sante Fe, that is not included in a recent recall. Tried to find what “Problem” actually is on current recall to compare to mine. My picture is too bright and contrast ruins ability to identify objects behind me. Is the recall based on a similar problem? As your current Hyundai recall states: "An inoperative rearview camera will reduce rearward visibility while driving in reverse, increasing the risk of injury to bystanders." Local dealership has tried to fix, but after almost a month has not. Question is should recall be extended beyond current model years?

• 12/04/2020· UNKNOWN OR OTHERCrash

  MY 2019 HYUNDAI SANTA FE HAD SUDDEN UNINTENDED ACCELERATION WHILE I WAS TRYING TO PARK THE CAR IN THE PARKING LOT. IT SUDDENLY CROSSED OVER THE PARKING CEMENT BLOCK AND JUMPED INTO THE SIDEWALK LANDSCAPE AND THEN STOPPED. THE AIRBAG ALSO DEPLOYED DUE TO THIS INCIDENT. I DID NOT STEP ON THE GAS PEDAL.

• 12/02/2024· UNKNOWN OR OTHER

  Rearview cameras are unusable due to high brightness and contrast issues. Seems same problem possibly as recent recall even though not in same model years. Hyundai dealership has been unable to resolve since November 6 and as recall highlights "increasing the risk of injury.." Attached photo of condition, usually worse than this photo in bright sunlight.

• 12/02/2021· ELECTRICAL SYSTEM

  The contact owns a 2019 Hyundai Santa Fe. The contact stated that while operating the vehicle there were multiple warning messages displayed on the instrument panel and the vehicle would not accelerate to exceed 10 MPH. The vehicle was towed to an independent mechanic who disconnected the battery and reset the computer and the failure was remedied. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was 42,000.

• 11/25/2025· SERVICE BRAKES,ENGINE,FORWARD COLLISION AVOIDANCE

  Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of them will suddenly illuminate and the vehicle shuts off. alternator and battery replaced. Have not used cruse control since. Airbags never inflated in a front end crash at 45mph Most recently I started experiencing I intermittent trouble staring the car. Then one day it didn't start at all and smoke was coming from under the hood. Towed to mechanic , starter burnt up 155,000. $ 900 to replace then a couple days later I lost power on the freeway and the car started jerking and vibrating. Stopped Vehicle cut off and would not start. After 1hr I started and limped home. Vibration under 2000 RPMs and when stopped. Knocking noise under hood. Brand new spark plugs. Mechanic stated Cylinder 3;missfire was identified as a hole in a valve due to weak material now I have to replace engine. Oil consumption and excessive friction and heat is to blame. My car has been cared for like a baby it's all I have. I should not have to be responsible for this very cheaply made engine that was doomed to fail.

• 11/16/2021· UNKNOWN OR OTHER

  truck, not speeding up at times when gas peddle is pushed.

• 11/16/2018· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  MY NEW 2019 HYUNDAI SANTE FE FROM THE TIME I BOUGHT IT HAD THE YELLOW CHECK ENGINE LIGHT COME ON. IT SAID THE BSM SYSTEM WASN'T WORKING. THEN THE ENGINE WOULD NOT START ON 4 SEPARATE OCCASIONS. I HAD TO WAIT TO GET IT TO START. THERE HAVE BEEN 3 OCCASIONS WHEN IT DID START IT SOUNDED LIKE IT WAS GOING DIE, VERY SLUGGISH AND DIDN'T WANT TO ACCELERATE. THE RPM WOULD NOT INCREASE. IT ALSO STARTED 2 SEPARATE OCCASIONS IT LOST STEERING WHEEL POWER AND THE A/C STOPPED BLOWING COLD AIR. I HAD TO TURN IT OFF AND WAIT TO RESTART IT. IT IS CURRENTLY AT THE DEALERSHIP WAITING FOR THE BLIND SPOT MONITORING MODULES. THE FIRST TIME THEY REPLACED THE MODULE IT STILL SHOWED IT NOT WORKING. SO NOW IT IS UNDRIVABLE AT GENE MESSER HYUNDAI IN LUBBOCK TEXAS, THEY SAY IT'S NOT SAFE TO DRIVE SO I AM DRIVING A LOANER. THEY SAY THEY CAN'T DETERMINE WHY THE ENGINE DID THE DESCRIBED THINGS ABOVE. THESE THINGS HAPPENED WHILE IN MOTION AND PARKED.

• 11/12/2025· ENGINE

  Engine oil consumption issue. I have taken the vehicle in 4 times due to this they have. Changed hoses and even the oil pan but the engine still runs out of oil. On several occasions the oil light comes on within 1000 miles of a oil change and when I check it the system is completely out of oil. This means the lubrication system is running with no oil and likely has metal particles in it. I have contacted Hyundai corporate and the issues still has not been resolved. There needs to be a recall on these engines before they start blowing up. I uploaded files of thw most recent service nov 5th and the current odometer reading and oil level. 7 days later the oil level is low.

• 11/08/2024· STRUCTURE

  The paint is failing, it is coming off in sheets, there is no damage to the car where the paint is coming off.

• 11/07/2024· Other/I am not sure

  The seat is able to forward face up to 40 lbs with a seatbelt install and 35 lbs with a latch install. When trying to install this seat with the seatbelt the instruction manual states not to lock the seatbelt after install however if the seatbelt inst not locked the seatbelt moves easily with some pressure (i.e. child pushing legs against back seat) and then becomes so lose that is can fall over. ALternately, i have tried the install with locking the seatbelt and this solution only lasts 1-2 car rides longer. (i.e. i would need to reinstall my seat every other time my child rode in the car). Currently the seat is installed with the latch system as this is the only way to get a safe install however my son is currently 34lbs and it will soon be unsafe to ride rear facing with the latch system which will then force me to turn him front facing before I or my son are ready.

• 11/07/2021· UNKNOWN OR OTHER,ELECTRICAL SYSTEM

  The dome lighting, lights do not go off when the doors are closed. I check repeatedly to make sure that all doors are closed. The dome gets extremely extremely hot. I believe this could very easily be a fire hazard. This has happened 3 times this year 2021.

• 11/06/2025· ENGINE

  This vehicle requires 1-2 quarts of oil to be added to it weekly. It's all over the internet that many different models of Hyundais consume excessive amounts of oil. This puts others at risk due to damaging the engine and the possibility that the car will just stop completely while driving it. We have records to show how often and how much we have to add more oil every week.

• 11/01/2024· UNKNOWN OR OTHER

  Peeling paint as a result of manufacturing issue (no primer was ever added prior to paint). I have spoken with Hyundai twice and both times they have refused to repair since vehicle is no longer in warranty. I would like for Hyundai to take accountability for this for myself and all other 100’s of people who are dealing with this. They show no honor to those of us who have invested multiple thousands into their business.

• 10/30/2020· STEERING

  WAS DRIVING ABOUT 30-35 MPH ON CURVY BACK ROAD WHEN SUDDENLY THE STEERING WHEEL COMPLETELY LOCKED UP. I SLAMMED ON THE BRAKES AND THE CAR WENT INTO THE ONCOMING LANE. LUCKILY THERE WAS NO TRAFFIC OR IT WOULD HAVE BEEN A HEAD ON COLLISION. AFTERWARDS THE STEERING WHEEL EXHIBITED A POPPING/THUD NOISE WHEN TURNING THE WHEEL. THE DEALERSHIP REPLACED THE STEERING COLUMN ASSEMBLY. DIDN'T FIX THE ISSUE. THAT TOOK ALMOST A MONTH. THEN THEY REPLACED THE RACK AND THE INTERMEDIATE SHAFT. THAT STILL DIDN'T FIX THE SOUND. NOW THEY ARE REPLACING A CLOCK SPRING. THEY HAVE NO IDEA WHAT'S WRONG AND ARE JUST THROWING PARTS AT THE CAR HOPING IT'S FIXED. IT'S BEEN 44 DAYS AND GOING ON 3 REPAIRS. HYUNDAI SAYS I DON'T MEET THE REQUIREMENTS FOR A BUYBACK OR EXCHANGE AND HAVE FRANKLY BEEN EXTREMELY RUDE. I WILL NEVER TRUST THIS CAR WITH HOW THIS HAS BEEN HANDLED AND WILL NEVER BE GIVING MY BUSINESS TO THEM AGAIN.

• 10/24/2025· STEERING,ELECTRICAL SYSTEM,ENGINE

  I purchased my 2019 Hyundai Santa Fe on October 29, 2021. Since then, I’ve experienced a series of mechanical and electrical failures that I believe are far beyond normal for a vehicle of this age. - The remote start has never worked. - On October 20, 2023, the hatch latch failed. The only way to open it now is by climbing into the back and manually pulling the latch. - On October 27, 2023, the electric power steering failed. I had to replace the entire steering column at a cost of $4,000. - The paint began deteriorating prematurely and required a full repair. Hyundai covered this under warranty, but the cost was $8,000. - In early spring 2025, all coil packs had to be replaced due to misfires, costing approximately $500. - September 4, 2025, The car stalled while I was driving on a main road and I had to pull over. There were no warning lights and I started home. About a mile from home check engine light came on so contact mechanic. Ended up towing to a dealership and was told the engine must be replaced because the oil had burned off without any warning from the oil light indicator. The turbo also needs replacement. - The combined cost is $14,000. These failures have caused significant financial hardship and stress. I am currently $17,000 underwater on the loan, and the repair costs are overwhelming. The lack of warning before catastrophic engine damage is especially concerning. I believe these issues reflect systemic defects in the vehicle’s design and manufacturing. The repeated failure of critical components—especially the steering system and oil monitoring—make this the worst automotive experience I’ve ever had. I respectfully request that the NHTSA investigate these failures and determine whether Hyundai should be held accountable. Consumers deserve protection from vehicles with such extensive and costly problems.

• 10/24/2022· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  2019 Hyundai Santa fe first owner after each use of the Auto Stop/ Start feature is guaranteed that in 24-48 hrs the car will stall at stop lights and take anywhere from 15-20 min to restart. The power to the electronics continues but the engine can't restart from the stop. It appears as of the feature takes the power from the alternator, starter and battery and drains it until the car can be restarted. Once it starts it drives well until the system is engaged again. I have chosen to not use the system and the car has not stall however once the use of the Auto/ Start Stop system is engaged for a day or two it will stall the vehicle from a stop mostly at stop lights after so much time on standby mode while using the Auto Start / Stop system. Dealer can not recreate the issue.

• 10/23/2018· UNKNOWN OR OTHER

  I BOUGHT THE VEHICLE AUGUST 1 AND DROVE IT HOME, 50 MILES, AT 75+ MPH. IMMEDIATELY I NOTICED A HIGH VIBRATION IN THE RIDE AS WELL AS LOOKING IN THE REARVIEW MIRROR THE CARS BEHIND ME WERE BLURRY FROM THE VIBRATION UNTIL I PLACE A FINGER ON THE MIRROR. I RETURNED TO THE DEALER THE NEXT DAY RELATING TO THE VIBRATION. THEY BALANCED THE FRONT TIRES. I RETURNED HOME AND THE VIBRATION WAS STILL THERE. THE VEHICLE HAS BEEN AT THE DEALER 4 MORE TIMES WITH NO SOLUTION. I HAVE BEEN SUPPLIED WITH A RENTAL FOR A FEW DAYS AND WAS TOLD THE SUV WAS READY. I PICKED IT UP ON A SATURDAY AND ASKED FOR SOMEONE TO GO FOR A RIDE TO SEE IF THE VIBRATION WAS STILL THERE. NO ONE WAS AVAILABLE SO I DROVE IT HOME AND THE VIBRATION WAS STILL THERE. I RETURNED IT TO THE DEALER AND AN HYUNDIA ENGINEER TOOK IT FOR A TEST DRIVE UP TO 70MPH WHICH WAS IN THE CITY AND NOT HIGHWAY DRIVING. I HAD A CONFERENCE CALL WITH THE GM AND WAS TOLD THAT THE ENGINEER SAID ALL OF THE SUVS VIBRATED AND THIS ONE WAS MORE "PRONOUNCED" WHICH WAS NOT IN HIS REPORT TO HYUNDIA WHO I'VE BEEN IN CONTACT. I BELIEVE THIS VIBRATION IS NOT IN THE WHEELS, ONE TIRE WAS REPLACED, BUT MECHANICALLY ELSEWHERE. IT HAS BEEN AT THE DEALERSHIP SINCE 9/25/2018. I BELIEVE THIS SUV TO BE UNSAFE AND THAT OTHER COMPONENTS WILL FAIL. THIS IS MY 3RD SUV AND I'VE NOT HAD ANY PROBLEMS WITH THE FIRST 2. ANOTHER ENGINEER IS SCHEDULED TO INSPECT IT 10/23/2018. I AM A HELICOPTER PILOT AND KNOW WHAT VIBRATIONS CAN DO TO MECHANICAL AND ELECTRICAL COMPONENTS.

• 10/22/2019· STEERING

  AS I WAS DRIVING ON CURVES, THE WHEEL GOING OUT OF CONTROL PULLING TO LEFT TOWARD EMERGENCY LANE AND GETTING EXTREMELY HARD TO CONTROL BY HANDS. THE CAR WAS DRIVING GOOD UNDER 50 MILES, HOWEVER WHEN I SPEED UP TO 65 OR 70, I WAS NOT ABLE TO CONTROL THE STEERING WHEEL. DRIVER ATTENTION WARNING SETS TO HIGH" WHICH WILL CAUSE THE STEERING WHEEL TO ACTS HAPTIC TO SHAKE STEERING AS DESIGNED". I CONTACTED THE HYUNDAI CUSTOMER SERVICE WITH CASE # 16268782 ADDRESSING THE ISSUE AND REQUESTED THE COMPENSATION FOR $4,500 EACH FOR MYSELF AND MY OTHER FAMILY MEMBERS OF TWO IN THE CAR FOR EMOTIONAL STRESS, FEAR, ANGER AND ANXIETY DURING THE TRIP . THEY SEND ME A RESPONSE THAT HYUNDAI IS ONLY ABLE TO OFFER REIMBURSEMENT FOR HYUNDAI OWNERS WHICH IS ENTERPRISE RENT A CAR. TODAY, I RECEIVED A PHONE CALL FROM ENTERPRISE RENTAL CAR, INDICATING THAT I SHOULD NOT CALL, EMAILS REGARDING THIS ISSUE TO ENTERPRISE RENTAL CAR AREA MANAGER, AS THEY DONE THEIR PART TO TAKE THE CAR TO DEALERSHIP AND MY FUTURE EMAIL WILL BE CONSIDER AS HARASSMENTS TO THEM. WE HAVE BEEN SUFFERING FROM EMOTION STRESS, FEAR, AND ANXIETY DURING THE TRIP, AND HYUNDAI WOULD SEND A COMPENSATION TO ENTERPRISE RENTAL CAR AND ENTERPRISE RENTAL CAR ASKING TO NOT TO FURTHER CONTACT THEM REGARDING THIS ISSUE. PLEASE FOLLOW UP THE ISSUE WITH HYUNDAI DEALERSHIP, ENTERPRISE RENTAL CAR AND MAKE SURE THE COMPENSATION MAKE TO PEOPLE WHO SUFFER FROM INCIDENT NOT THE ENTERPRISE RENTAL CAR, AND IF THEY SEND A COMPENSATION TO OWNER (RENTAL CAR), THEY WILL FORWARD IT TO ME.

• 10/18/2019· POWER TRAIN,ENGINE

  I HAVE A BRAND NEW 2019 SANTA FE ULTIMATE 2.0T LEASED IN AUGUST WITH 1600 MILES AND I HAVE ALREADY HAD THE CAR IN TWICE WHERE THEY HAVE HAD TO RECALIBRATED THE TRANSMISSION. WHENEVER I WAS AT A STOP OR WAITING TO MAKE A TURN I WOULD PUT MY FOOT ON THE GAS PEDAL AND THE RPMS WOULD GO UP BUT THE CAR WOULDN'T MOVE. I WAS ALMOST REAR ENDED A COUPLE OF TIMES BECAUSE THE CAR WOULDN'T GO INTO GEAR AND MOVE WITH THE GAS PEDAL PUSHED ALL THE WAY DOWN TO THE FLOOR AND THEN ALL OF SUDDEN THE TRANSMISSION WOULD SHIFT INTO GEARS. THIS SHOULD NOT BE HAPPENING TO A BRAND NEW CAR! LOOKING AT DIFFERENT MODELS THIS SEEMS TO BE AN ON GOING PROBLEM WITH HYUNDAI. I HAVEN'T BEEN ABLE TO ENJOY MY CAR BECAUSE IT'S BEEN IN THE SHOP. THEY FIX IT AND IT WORKS FOR A WEEK OR SO AND THEN IT HAPPENS AGAIN. SOMETHING IS DEFINITELY WRONG! I WAS TOLD IF IT HAPPENS AGAIN THEN THEY WILL CALL THE MAIN HEADQUARTERS. THEY SHOULD BE DOING THAT ALREADY TO FIND OUT HOW TO FIX IT ONCE AND FOR ALL SO I DON'T HAVE TO KEEP COMING BACK. I HOPE YOU WILL LOOK INTO THIS MATTER.

• 10/16/2019· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2019 HYUNDAI SANTA FE. WHILE DRIVING 80 MPH, THE BRAKES APPLIED ON THEIR OWN AND THE BCA BRAKE SYSTEM ACTIVATED WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE RECURRED TWO WEEKS LATER. THE VEHICLE WAS TAKEN TO PUENTE HILLS HYUNDAI (LOCATED AT 17621 GALE AVE, CITY OF INDUSTRY, CA 91748, (626) 581-5300), BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 1,656.

• 10/15/2025· ENGINE

  The car is burning oil and Hyundai advises to change the oil every 7500 miles. The car holds 5.1 qt of oil and is currently burning about 1 qt of oil for every 5,000 miles. How is this not a forced recall? People are blowing up their motors all over the country. They knew it was an issue and bought their way out of a class action lawsuit. This endangers any driver if it happens on the interstate. Hyundai/Kia are being allowed to skirt accountability with these motors.

• 10/15/2024· SEATS

  The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving at approximately 22 MPH, the vehicle struck a pot-hole which caused the driver seat to move out of place. The contact stated that while accelerating, the front driver seat would shift backward and while shifted into reverse the seat would move forward.  The vehicle was taken to a local dealer where it was diagnosed that the seat rail was damaged and the seat rail and seat needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 92,000.

• 10/14/2024· ENGINE

  CRANK SHAFT SEAL LEAK ON A 44700 2019. HOWEVER THERE IS A RECALL ON THE CRANKSHAFT SENSOR. THEREFORE WHY WOUL THIS CAR NEED A SEAL WITH THIS YESR AN LESS MILEAGE. SOMEONE NEEDS TO LOOK INTO THIS. BECAUSE THE DEALER WANTS 2448.00 TO FIX THIS.

• 10/12/2024· STEERING,LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

  The Forward Collision Assist would intermittently disable during driving. The Lane Keeping Assist light illuminated and would not allow me to disable it causing the vehicle to drive straight only and to make left or right turns extremely hard to turn the vehicle. This incident occurred on [XXX] and was dropped off at Johnson Hyundai in Wake Forest on that date. After a week of no contact of a diagnosis, I had to visit the dealer and was told the steering column was the issue and needed to be replaced. I contacted Hyundai America to report this issue and currently waiting on a response from their warranty to see if they will cover all or a percentage of the replacement of the steering column since my mileage is over their 100k (113k to be exact) coverage. While I appreciate their efforts, I also feel this could have resulted in a very serious incident had my daughter been driving on the highway when this occurred. Thankfully, she was picking me from home and it happened as we drove off from our house in our neighborhood. A steering column should outlast any other part(s) of a vehicle. If not, this is a huge safety concern. My [XXX] was also in the car at the time and I cannot even imagine how I would recover if something worse were to happen while he's on board. Hopefully this reporting will keep something bad from happening to others who own this type of vehicle but failed to report it. Thank you for your time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 10/09/2022· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  For the duration of the vehicle's ownership, it has underperformed and operated unpredictably under hard braking, specifically with relation to the vehicle's ABS system. The conditions have caused meto never drive the car in snow, as this weather condition in particular exacerbates the braking issues and makes the car unsafe. Issues with the braking/ABS include: The ABS activating at slow speeds in all conditions, even on dry roads The ABS activating and preventing the vehicle from being emergency stopped in adverse conditions The ABS activating and exponentially extending the braking distance until it disnegages The ABS, once activated, does not stop unless the brake pedal is lifted from its initial activation position The vehicle doesn't appear to have any mechancial braking issues. Everything seems to be related to the ABS system, wheel-speed sensors and/or vehicle-management systems. The overall braking experience in this vehicle with the ABS on is that it simply will not stop within a safe braking distance window. The only way to stop this vehicle is without ABS. There is no other way to safely stop this vehicle with ABS. I have reached out to my Hyundai dealer and Hyndai corporate directly, both times being dismissed without anyone attempting to recreate the braking issues. I have a life's worth of experience driving in snow and multiple ABS activations in a range of vehicles. This is abnormal based on all of the experiential knowledge I possess, as well as a lifelong interest in cars. While I am not an engineer, I possess enough firsthand and academic vehicle experience to recognize the abnormality of this vehicle braking operation.

• 10/06/2021· UNKNOWN OR OTHER

  This is the 2019 Santa Fe that this has occurred on (formally owned) as well as two 2020 Santa Fe that we now own within the last 2 years. The windshield does not take rock hits well. On all three vehicles a rock strike on the windshield not only left a large star impact, but the crack from the impact reaches all the way to the roof pillar. The crack is long. I believe the windshield glass is substandard and needs to be looked into closer as being a possible safety risk. Replacing the windshield and camera recalibration is expensive.

• 10/05/2022· ENGINE

  The contact owns a 2019 Hyundai Santa Fe. The contact stated that while at a complete stop with the auto engine Start/Stop feature activated, the vehicle would intermittently shut off upon depression of the accelerator pedal with several warning lights illuminated on the instrument panel. The contact would be forced to turn off the vehicle and open the driver’s side door to reset the vehicle; after multiple attempts, the engine would restart and resume normal operation. The contact had taken the vehicle to two separate dealers, Freehold Hyundai (4065 US-9, Freehold, NJ 07728) and Greg May Hyundai (1501 TX-340 Loop, Waco, TX 76712)] on multiple occasions but neither dealer was able to duplicate the failure. The manufacturer was also notified of the failure and provided a case number. The contact was referred back to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 40,000.

• 10/05/2020· UNKNOWN OR OTHER

  CAR LOCKS WITH A SYMBOL ON DASHBOARD OF CAR WITH A KEY THEN ANOTHER ISSUE WHEN DRIVING CAR SHUTS OFF. HAVE HAD THE CAR IN SEVERAL TIMES TOLD THEY CANNOT MIMIC THE ISSUE AND COMPUTER DOESN'T SHOW ANY CODES. CALL HYUNDAI CORPORATE TO COMPLAIN AND SAID WITH 35,000 AT THE TIME WE ARE BEYOND LEMON LAW FOR NJ. I HAVE NOW 41,000 MILES ON IT AND PROBLEM IS HAPPENING MORE AND MORE FREQUENTLY. I HAVE A HUSBAND ON OXYGEN WAITING FOR A DOUBLE LUNG TRANSPLANT AND THIS IS AN UNSAFE CAR. TODAY HAPPENED ON A BUSY HIGHWAY. I CALLED CIRCLE HYUNDAI IN SHREWBURY NJ SPOKE TO SERVICE MANAGER AND TOLD HIM THIS NEEDS TO BE CHECKED BEFORE I GET KILLED. OWNER OF DEALERSHIP TOLD ME A MONTH AGO THAT I HAVE EXHAUSTED ALL OF HIS TECHS. PLEASE HELP US.

• 10/01/2019· SERVICE BRAKES

  TL* THE CONTACT RENTED A 2019 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE CONTACT ATTEMPTED TO DEPRESS THE BRAKE PEDAL, BUT IT FAILED TO OPERATE AS NEEDED WITHOUT WARNING. THE CONTACT CONTINUED TO DRIVE THE VEHICLE, BUT THE SAME FAILURE OCCURRED AT 55 MPH. THE CONTACT MANAGED TO AVOID COLLIDING WITH A DOE IN THE MIDDLE OF THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME AND THEN TO THE RENTAL OFFICE. THE CONTACT INFORMED THE RENTAL AGENCY OF THE FAILURE AND THEY STATED THAT THEY WOULD NOTIFY HYUNDAI OF THE DEFECT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BY THE CONTACT. THE CONTACT DID NOT KNOW IF THE DEALER WAS CONTACTED. THE WHEREABOUTS OF THE VEHICLE WERE UNKNOWN. THE FAILURE MILEAGE WAS 33,000. THE VIN WAS UNKNOWN.

• 09/28/2022· STRUCTURE

  Liftgate is unable to be opened from outside, on button press it just beeps three times

• 09/27/2019· ENGINE

  THIS IS A REPORT ON A 2019 HYUNDAI SANTA FE 2.0L TURBO WITH LESS THAN 1600 MILES. THERE IS A SIGNIFICANT AMOUNT OF FUEL IN THE OIL. ALLOWABLE LIMITS ARE LESS THAN 2.0% FROM NORMAL CAUSES. THIS ENGINE HAS 3.3%, ENOUGH TO BE A PROBLEM.THE OIL LEVEL IS RISING ON THE STICK. THE 5W/30 OIL HAS BEEN THINNED TO THE CONSISTENCY OF 20W OIL. DEALER SHRUGGED IT OFF AND CLAIMED THAT DRIVING A 100 MILE TRIP WOULD RETURN ALL TO NORMAL.

• 09/22/2019· POWER TRAIN

  THE FIRST TIME IS WAS DRIVING IN THE HIGHWAY WHEN THE VEHICLE HESITATED SLOWED DOWN AND I EVENTUALLY HAD TO GET OFF THE HIGHWAY BEFORE IT COMPLETELY TURNED OFF. THE SECOND TIME THIS HAPPENED THE VEHICLE TURNED OFF AS I WAS MBV AKING A RIGHT TURN ON THE ROAD.

• 09/19/2022· STEERING

  Electric power steering failed after starting car and beginning drive. No power assist was present. Concurrent with this failure the instrument panel displayed warnings that Blind Spot Detection System and Lane Keeping System were not working and needed attention. Codes for the later 2 problems were sent to central computer, but no power steering error code was sent. Disconnecting battery from car nor turning car off and on had no effect on errors. Let car set idle for 3 days. Restarted car and all problems were gone. Taking car to dealer on 9/20/22 in attempt to prevent future reoccurrence.

• 09/17/2019· ELECTRICAL SYSTEM

  AFTER DRIVING MY SANTE FE FOR LITTLE OVER 1000 MILES, I WAS WAITING BEHIND SEVERAL VEHICLES AT A STOP LIGHT IN HYATTSVILLE AND MY VEHICLE SHUT OFF AND WOULDN'T START. AFTER TRYING TO RESTART THE VEHICLE FOR MORE THAN 15 MINUTES, IT FINALLY STARTED. I DROVE TO THE NEXT STOP LIGHT AND HAD TO STOP AND THE VEHICLE FAILED TO RESTART. THIS HAPPEN TWO MORE TIMES AND THEN FINALLY IT STARTED AND I DROVE BACK TO THE DEALERSHIP IN GAITHERSBURG (FITZGERALD AUTO MALL). I REPORTED THE INCIDENT AND THEY CLAIM TO BE UNABLE TO RECAPITULATE THE INCIDENCE. AT AROUND 5014 MILES, WHEN I CAME TO A STOP LIGHT IN DC, THE VEHICLE SHUT OFF AGAIN AND WOULD RESTART. THE COPS CAME AND PUSH ME OUT OF THE ROAD AND I WAS THEN ABLE TO RESTART. I DROVE TO THE NEXT STOP LIGHT AND THE VEHICLE SHUT OFF AGAIN AND WOULD START. EVENTUALLY, THE VEHICLE STARTED AFTER APPROXIMATELY 10 MINUTES. I DROVE THE VEHICLE BACK TO THE DEALER AND WAS TOLD THAT THERE WAS A PERFORMANCE RECALL ON THE VEHICLE. THE VEHICLE WAS SERVICE AND GIVEN BACK TO ME. THE FOLLOWING DAY DRIVING ON GERMANTOWN ROAD THE VEHICLE SHUT OFF AGAIN AT A STOP LIGHT. I CALL THE DEALER AND THEY ASKED THAT I TAKE IT BACK THE NEXT DAY. ON MY WAY TO THE DEALER IN BUMPER TO BUMPER TRAFFIC THE VEHICLE SHUT OFF AGAIN. I TOOK BACK THE VEHICLE TO THE DEALER AND TOLD THEM THAT I HAVE NO CONFIDENCE IN THE VEHICLE ANYMORE AND THEY SHOULD REPLACE IT. THE MATTER WAS REPORTED TO THE MANUFACTURER WHO REFUSE TO REPLACE THE VEHICLE AND OFFER $500 COMPENSATION FOR MY INCONVENIENCE WHICH I REFUSE TO ACCEPT. I AM SEEKING YOUR ASSISTANCE TO THIS ISSUE. P.S. I DO HAVE PICTURE OF THE INFORMATION THAT WAS DISPLAYED ON THE DASHBOARD AT THE TIME OF THE INCIDENCE AND MY NIECE WAS WITH ME ON TWO OF THOSE OCCASIONS.

• 09/16/2019· ELECTRICAL SYSTEM,SERVICE BRAKES

  TL* THE CONTACT OWNS A 2019 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE'S SMART SYSTEM CAUSED THE VEHICLE TO BRAKE ON ITS OWN. ALSO, THE LANE CHANGE WAS NOT READING CORRECTLY AND PUSHED THE VEHICLE INTO THE WRONG LANE INTO A BARRIER. IN ADDITION, WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO SLOW DOWN WHEN MAKING A RIGHT TURN. AFTER COMPLETING THE TURN, THE CONTACT WAS ABLE TO BRAKE. THE VEHICLE WAS TAKEN TO FITZGERALD HYUNDAI ROCKVILLE (11411 ROCKVILLE PIKE, ROCKVILLE, MD 20852, (301) 881-4000) TWICE WHERE IT WAS DIAGNOSED THAT THE SYSTEM WAS NOT CALIBRATING PROPERLY AND THE EASY PASS INTERFERED WITH THE SMART SYSTEM. THE EASY PASS WAS MOVED AWAY FROM THE CAMERA, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 16086926. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000. THE VIN WAS NOT AVAILABLE.

• 09/13/2025· ELECTRICAL SYSTEM,ENGINE

  This car has been cutting off for a month and no type of codes popping up alternator has been replaced two brand new batteries has been replaced which is dangers car cutting off while I am driving this vehicle is not safe at all needs to be recalled asap mechanic can’t even find the problem .