2019 Ford Explorer

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2022· SEAT BELTSCrash

  2nd row seat belt malfunctioned during when rear ended recently. Seat belt came unlatched on my niece throwing her towards the front passenger seat. Car has been totaled. Injury was to driver.

• 12/29/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver's side door exterior B-Pillar trim clip attachment detached. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 24V031000 (Structure); however, the dealer informed the contact that the driver's side door exterior B-Pillar trim failure was not listed in the recall. The contact was informed that the B- Pillar Trim needed to be replaced at the owner's expense. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 125,000.

• 12/29/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

• 12/27/2020· UNKNOWN OR OTHER

  LAST 2 TIMES I HAVE DRIVE THE VEHICLE MORE THAN SEVERAL HOURS, A BURNT ODD SMELL HAS COME FROM THE ENGINE HOWEVER THERE HAVE BEEN NO CHECK ENGINE LIGHTS, ONLY AN ODOR OR CHALKY BURNT SMELL. I HAVE 3 YOUNG KIDS AND THEY SMELLED IT AS WELL. IT HASNT HAPPEND ON SHORT TRIPS I NOTICED AFTER LONGER TRIPS OF DRIVING

• 12/26/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the driver’s side of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer where it was diagnosed that the A-pillar trim retention clips failed and needed to be replaced. The vehicle was not repaired. The contact was informed that the remedy was not available for the failure of the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 59,000. VIN tool confirms parts not available.

• 12/25/2022· POWER TRAIN

  The torque converter on my 2019 Explorer is messing up. Causing a stutter while driving and an extremely rough idle when trying to stop at a stop light/sign. This stutter happens intermittently and unexpectedly weather driving at a high rate of speed or low. A light never came on and no codes were able to be read. The last day I was able to dive my car the idle suddenly dropped so low mid driving. Thankfully I was going at a low rate of speed and able to get my vehicle off the road. I took my vehicle back to the Ford dealership and asked that they re-evaluate as the problem had gotten worse. That’s when I was informed my torque converter had malfunctioned. Not only did the dealership provide me with that information, but they also informed me that this is a known issue and has affected so many Explorers in this way, Ford had issued multiple TSBs to their service departments notifying them of this issue. I have attached screenshots of TSB 20-2271 and 22-2287, showing Ford is aware of these issues being reported on the 2016-2019 model Explorers. In my research, I’ve also found that the NHTSA has had a previous case, 17S16, showing Fords directive to replace faulty Torque Converters back in June of 2018. It is clear that Ford has not taken this issue seriously and continues to produce and sell vehicles with this bad part. This stutter and sudden decrease in idle could cause a wreck. Thankfully it did not with me, but it is an ongoing issue that could in the future. Ford has acknowledged there’s a problem but has not yet issued a recall on this part, for my VIN or cars like mine. I urge the NHTSA to investigate and encourage Ford to make this right and improve the quality of the torque converters they’re producing and selling to consumers.

• 12/22/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the windshield exterior A-pillar trims were loose, and there was a noticeable windy sound coming from the windshield while driving. The vehicle was taken to the dealer, where the contact was informed that the parts to do the recall repair were ordered. The vehicle was not yet repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.

• 12/19/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact noticed an abnormal buzzing sound coming from the windshield. The dealer was made aware of the failure. The contact stated that a technician arrived at the residence and inspected the vehicle, and placed duct tape around the front windshield. In addition, the contact was informed that the vehicle would fail an inspection with duct tape around the front windshield. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts were not yet available. The vehicle was taken to the dealer several times; however, the contact was informed that parts were not yet available. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was unknown.

• 12/19/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on both sides of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 98,000. VIN tool confirms parts not available.

• 12/17/2020· UNKNOWN OR OTHER,ENGINE

  VERY LOUD NOISE FROM THE ENGINE WAS TOLD IT WAS THE SUPERCHARGER BUT IT SOUNDS LIKE A CONSTANT CLICKING. WE TOOK IT BACK AND DEALERSHIP TOLD US IT WAS FIXED. STILL MAKES A LOUD CLICKING WHEN DRIVING , MORE SO WHEN ACCELERATING. CALLED DEALERSHIP, THEY SAID THEY FIXED IT. TO US ITS STILL DOESNT SOUND LIKE A 2019 VEHICLE SHOULD

• 12/13/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side and passenger's side windshield exterior A-pillar trims had detached and were making an abnormal sound while driving. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 39,000. VIN tool confirms parts not available.

• 12/11/2024· VISIBILITY

  The contact owns a 2019 Ford Explorer. The contact stated on several occasions while the vehicle was parked or while driving at various speeds, the side mirrors failed to tilt left or right but tilted up and down. The contact manually moved the mirrors for proper visibility. The vehicle was taken to a dealer where it was determined that the switch on the driver’s door was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 43,000.

• 12/10/2025· ENGINE,FUEL/PROPULSION SYSTEM

  Blown engine due to ecoboost fuel issues. Vehicle quit and shut off on highway. Multiple issues with 2019 ford explorer that does not get resolved.

• 12/09/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the passenger’s side B-pillar trims blew off the vehicle by the slip stream. The contact stated that the vehicle was taken to a local dealer who replaced the trim. The contact stated that the trim on the driver's side B-pillar was now loosened. The contact called the dealer and was informed that the B-pillar trim was not included in NHTSA Campaign Number: 24V031000 (Structure); and would be an out-of-pocket expense for the repair. The contact was concerned that the B-pillar trims should also be recalled due to the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 76,000.

• 12/08/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The vehicle was serviced under NHTSA Campaign Number: 24V031000 (STRUCTURE), but the failure persisted. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the windshield. The local dealer was contacted; however, the vehicle was not inspected or diagnosed. The manufacturer was not made aware of the issue. The failure mileage was unknown.

• 12/08/2024· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  Code P0301 can’t pin point issue

• 12/05/2025· FUEL/PROPULSION SYSTEM

  The catalytic converters for the Ford Explorer Utility Police Interceptor fail prematurely, degrading the emissions from the vehicle and causing the vehicle to fail emissions testing. Although Ford has implemented a Customer Satisfaction Campaign 22M06, they do not inform owners of the campaign or potential problem. My car was inspected by two Ford dealerships who simply cleared the error code (P0430) and made no mention of Campaign 22M06. The error code persisted as I replaced numerous other components (spark plugs, purge valve, oxygen sensors, Mass air flow sensor) trying to alleviate the problem over the last year. Only if you mention the campaign specifically will they inspect the vehicle for the purpose of replacing the the catalytic converters under warranty. Replacing these failing catalytic converters should be a recall because failure creates substandard emissions for thousands of vehicles.

• 12/04/2020· ELECTRICAL SYSTEM,STRUCTURE,VISIBILITY/WIPER

  ROOF RAIL COVERS ON LEFT AND RIGHT SIDES OF 2019 FORD EXPLORER COME LOOSE AFTER DEALERSHIP REPAIRED FORD TSB-20-2154, STILL COMING LOOSE, THEY CAN FLY OFF VEHICLE AND CAUSE AN ACCIDENT ELECTRICAL WIRES ARE CODED WITH SOY CAUSING SQUIRRELS / RODENTS ETC.TO EAT ENGINE WIRES AND TRYING TO BUILD A NEST IN ENGINE CAN CREAT A FIRE

• 11/27/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the driver side of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 60,292. VIN tool confirms parts not available.

• 11/26/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/24/2019· ELECTRICAL SYSTEM

  THIS CAR WILL NOT START AFTER BEING TURNED OFF AND LEFT FOR CERTAIN TIME. THE CAR CRANKS BUT WILL NOT START. THE BATTERY HAS BEEN CHECKED AND IS FUNCTIONING. THE CAR WAS TAKEN TO FORD DEALER AND FOUND THE GAS MODULE BAD. AFTER 4 MONTHS THE ISSUE HAS OCCURRED AND THE CAR WILL NOT START.

• 11/22/2024· POWER TRAIN

  2019 Ford Explorer XLT with FWD Transaxle transmission and 46,107 miles on odometer, purchased in November 2018 and now 5 years old this month. Way too early for a transmission failure to occur. Normally drive the posted speed limit unless changes in the traffic patterns slower or a little faster.8 Heard a noise from left front wheel area when accelerating and slowing/re-accelerating in traffic. Extended service plan expired (5 year, 60,000 miles, Nov 2018-Nov 2023). Took car to local garage, did a test drive and checked by mechanic. It was determined that problem came from transmission. There have been NO warning lamps, messages, etc. prior to me noticing the problem and nothing since mechanic checked the vehicle. Sounded like the right front wheel area made a noise when turning around in a parking lot this morning. Mechanic estimated cost to repair with parts, labor, etc., will be $6,245.90 out of pocket.

• 11/22/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving 45 MPH, there was a rattling sound coming from the roof of the vehicle. The vehicle was stopped and inspected, and the contact observed the right and left roof rails, had separated in several areas. The vehicle was taken to a dealer where it was determined that the roof rails needed to be secured in place. The vehicle was repaired but the failure reoccurred. The vehicle was then taken to the same dealer where it was determined that the roof rails needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 79,000.

• 11/17/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated that after a visual inspection of the exterior of the vehicle, the driver’s side roof rack rail had detached. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V316000 (Structure). The VIN was included, but the vehicle was repaired in October 2025. The manufacturer was not notified of the failure. The failure mileage was 90,000.

• 11/17/2022· STEERING,POWER TRAIN

  When I took a left hand turn coming from a stop-sign the control arm on my front right passenger side busted. I did not hit anything or cause the damange instead this was in part of failure of the product. I was traveling approximately 3 mph on a flat surface with no traffic exiting an industrial park. Because the control arm broke, it caused significant other damage to my vehicle due to the inability to steer my vehicle and the wheel to no longer be controlled by the steering wheel. There were no warning signs and nothing to signal to me that my car was in fact having issues. If I would have been traveling on the hwy during this incident chances are I would have been severally hurt or even killed. I had just dropped off my husband and child at an event where we were traveling on a hwy. Luckily I was traveling at a slow speed during this incident and nobody was injured. The vehicle has been inspected and based on the significant damage (fender, door, mechanical) there has been nothing but challenges getting the issues fixed. My car is still covered under warranty because it's new however between my car insurance and the warranty nobody wants to help cover the cost of the damage that was cause at no fault of my own. Finally, this is a known issue with Ford vehicles. Research shows many, many other complaints just like mine where faulty control arms are breaking at no fault of the driver. As a matter of fact, 3 days ago there was the same incident at a round-about where another Ford Explorer was sitting in the middle with it's control arm broken. Same issue, same scenario.

• 11/15/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that both the driver's side and the passenger's side windshield exterior A-Pillar trims had separated from the vehicle. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,000. VIN tool confirms parts not available.

• 11/13/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

• 11/12/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side windshield trim detached and flew off. In addition, the contact stated that the passenger's side windshield trim had detached and was held in place with tape. The dealer was made aware of the failure; however, the contact was informed that the parts were not yet available. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 89,000. VIN tool confirms parts not available.

• 11/05/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/04/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving at approximately 55 MPH, there was an abnormal sound coming from the roof. The contact stated that it sounded like an object bouncing on the roof of the vehicle. The contact stated that the sound ceased after several minutes. The contact arrived at the destination, checked the roof, and became aware that the passenger’s side roof rail had detached from the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V316000 (Structure); however, the VIN was not included. The manufacturer was informed of the failure. The failure mileage was approximately 54,000.

• 11/03/2025· SUSPENSION

  Suspension issue causing premature inside tire wear which can be fatal, if not deadly. Multiple cases have been recorded and found among other owners for this same make and model yr. Even after parts replacement and 4 wheel alignment was completed.

• 10/29/2023· ELECTRICAL SYSTEM

  I purchased a Ford certified 2019 Ford Explorer recently. It is my 20th Ford. I could barely hear the horn and thought there was a problem with one of the horns. I researched it and found that the 2019 model year only came with one horn. The horn is at the front of the hood and when I checked there was a bracket for 2 horns but there was only one. You almost can not hear it when inside of the car and it makes me think that others may not hear it if there is an emergency. I have owned close to 70 cars and I have never had a car with one horn. A moped has a louder horn. In my opinion Ford should not have tried to save $5 that could cause an accident. I had to order Ford part number GB5Z-13832-A which are the dual horns found on the other model years. My safety and the safety of other 2019 Ford Explorer owners is at risk because of this.

• 10/28/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford Explorer. The contact stated that while driving approximately 65 MPH, there was an abnormal anti-freeze odor inside the cabin of the vehicle. The contact stated that the "overheat" and "temperature" gauge illuminated. The contact drove the vehicle back to the residence, parked the vehicle, and observed that anti-freeze was leaking onto the driveway. The contact had the vehicle towed to an independent mechanic and was informed that the water pump had failed and needed to be replaced. The contact was referred to a dealer for assistance. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

• 10/27/2021· ELECTRICAL SYSTEM

  The contact owns a 2019 Ford Explorer. The contact stated that there was water leaking into the headliner and sunroof. Additionally, the battery was leaking battery acid. The battery failure caused the contact's baby to be diagnosed with Intrauterine Growth Restrictions (IUGR). The first failure occurred when the contact detected an odor and checked under the hood of the vehicle. The contact saw that the battery was swollen and had exploded. The vehicle was towed to the dealer on October 21, 2020, and the dealer informed the contact that it was a faulty battery and replaced it with a new battery that the contact had purchased from Walmart. The dealer informed the contact, who was pregnant at the time, that the vehicle was safe to drive. The failure recurred, and the vehicle was taken to Darling's Brunswick Ford (262 Bath Rd, Brunswick, ME 04011) on May 17, 2021. The dealer informed the contact that the battery was actively leaking and covered in battery acid. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and first informed the contact that there was no recall associated with the VIN. The manufacturer later informed the contact that they would be buying back the vehicle from the contact under Florida's Lemon Law. The failure mileage was approximately 42,000.

• 10/24/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving 25 MPH, the exterior A-pillar trim detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, was unable to confirm when the part would become available. The failure mileage was 85,000. VIN tool confirms parts not available.

• 10/22/2023· POWER TRAIN

  coolant leaking into engine 2.3l eco boost

• 10/22/2019· UNKNOWN OR OTHER

  JUST RECENTLY PURCHASED A 2019 FORD EXPLORER LIMITED. WHILE DRIVING ON THE FREEWAY AND ALMOST NEARLY BEING SIDE SWIPED BY A BIG RIG WHO APPARENTLY DID NOT SEE ME OR HEAR MY HORN. I THEN PULLED OVER NEAREST EXIT AND PRESSED MY HORN TO HEAR THAT IT WAS LOW SOUNDING. I THOUGHT MAYBE IT WAS DEFECTIVE OR A RECALL ON HORNS. I SEARCHED ONLINE TO FIND OUT THAT FORD HAS ONLY INSTALLED 1 HORN FOR THIS YEAR MODEL. NOT SURE IF ITS TO BE CHEAP OR BY MISTAKE, BUT I HAVE READ MANY REVIEWS THAT THERE'S ONLY 1 HORN INSTALLED WHEN ALL PREVIOUS YEARS HAVE 2 HORNS INSTALLED. THERE ALSO HAS BEEN VIDEOS MADE ON YOUTUBE REGARDING CONCERNS OF THESE 2019 FORD EXPLORERS. I TRULY BELIEVE THIS IS A BIG SAFETY ISSUE.

• 10/20/2023· UNKNOWN OR OTHER

  Dec 2022- Windshield trim on passenger side ripped off while driving on the interstate. Sept 2023- noticed noise while driving. Checked driver side trim and noticed seal was gone. Trim was cracked along its entirety. Replaced before it also flew off

• 10/20/2021· STRUCTURE

  The contact owns a 2019 FORD Explorer. The contact stated that she initially received a recall notice for the roof rail covers under Manufacturer recall Number: 20N11. The contact took the vehicle to a dealer and had the recall serviced. Since the repair, the contact noticed that the roof rail cover had begun to detach from the vehicle despite the recall repair. The contact had taken the vehicle to the dealer where they acknowledged the failure and referred her to the manufacturer for assistance. The manufacturer was notified of the failure and referred her to NHTSA for assistance. Upon investigation, the contact discovered NHTSA Campaign Number: 21V316000 (Structure) however, the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 18,000.

• 10/18/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the upper part of the driver's side windshield exterior A-Pillar trim was fractured, causing the trim to detach. An unknown local dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

• 10/17/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that upon further inspection, the front driver’s and passenger’s side A-pillar trim seals had started to deteriorate. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

• 10/17/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated that while driving at 40 MPH, the trim piece detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure however was unable to confirm when the part was to become available. The failure mileage was unknown. VIN tool confirms parts not available.

• 10/17/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while the vehicle was at the dealer for a routine oil change, it was discovered that the roof rack was loose and advised the contact to bring the vehicle to the dealer the following day to have it inspected. The vehicle was taken back to the same dealer the following day as instructed and it was advised that the roof rack needed to be replaced. The vehicle was previously serviced under NHTSA Campaign Number: 21V316000 (STRUCTURE) however it failed to prevent the risk. The vehicle was not repaired due to it being out of warranty. The manufacturer was notified of the failure. The approximate failure mileage was 32,000.

• 10/17/2023· UNKNOWN OR OTHER

  Doing 70 mph and trim along passenger windshield broke in half and flew off

• 10/16/2025· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving approximately 65 MPH, the driver’s side exterior A-pillar trim detached and flew off the vehicle. The vehicle was taken to a dealer, where it was determined that the part was under recall and that parts were not yet available for the recall repair. The manufacturer was not notified of the failure. The failure mileage was unknown.

• 10/16/2024· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 10/14/2024· POWER TRAIN

  For months, almost a year, my transmission could not properly accelorate. The car would not allow for the pick up in speed to happen. Each time I took it to the shop that cares for my car, Mike's More Miles, the problem would not duplicate. My special needs son, his service dog and I were all of the expressway traveling, the car slowed down on its own, I had not applied the brakes, the speed dropped from 65 to less than 35 in seconds. I pulled over and tried to regain speed after putting the car into park. No luck. the car would not go faster then 20-30 miles an hour, with me putting into neutral when coasting downhill, then back into drive manually to get it to the repair shop. This almost caused a terrible accident. This scared my son, who has brain disease. Our 85 lb. service dog was jolted from the back of the car slamming into the seat. I was also very scared and shaken. My son began to yell and scream what is happening, it was a scary and tense, literally jaw dropping experience. I drove to Enterprise Rental, called Austin the owner of the shop that has tried to duplicate the problem on a dozen tried and told him what occurred. I left my car at Enterprise, where Austin picked it up. The problem did duplicate. FINALLY a code came up to diagnose the problem. The transmission fluid was also black, with metal shavings in it as well. Please refer to all technical service bulletins that note this is a known problem by Ford. I have paid $7582.70 for a new transmission. The shop owner, Austin, told me the torque converter overheated, the transmission had failed. I also paid for the rental car an estimate of $490.00.

• 10/07/2021· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated that the roof rail had detached. The contact received notification of NHTSA campaign number: 21V316000 (Structure) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer where the roof rail was glued. The vehicle was repaired however, the failure recurred. The roof pins are unable to be attached. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified but, no further assistance was provided. The failure mileage was approximately 3,000. VIN tool confirms parts are not available.

• 10/05/2023· UNKNOWN OR OTHER

  OEM Ford Gen 4 SYNC 3 Nav APIM suddenly started sporadically functioning. Contacted Ford after viewing multiple recalls from previous years Ford vehicles with exact issue. After being told there was no recall on my 2019 Explorer, was given a quote of $170.00 to diagnose issue, $900 + for APIM module, plus installation and programming. We purchased a re-programmed APIM module and installed. Problem is now corrected. Recall needs entered on this unit. Attaching photos of front & back of bad unit: WY1W748K GR26A KB5T-14G370-DCA SERIAL NO. 205831 MFG - JANUARY 2019 ASSY NO. MAJ0673GX PANASONIC AUTOMOTIVE SYSTEMS MODEL FA-170-BCAR-HS IFT# RCPPAFA16-2032 FCC ID: ACJ-FA-170-BCARHS IC ID: 216B-FA170BCARHS ANATEL ID: 05008-16-09014 CMIIT ID: 2016AJ4795

• 10/05/2021· STRUCTURE

  The contact owns a 2019 Ford Explorer. The contact stated while driving 60 MPH, the driver’s side roof rail detached from the body of the vehicle. The vehicle was taken to a local dealer where it was diagnosed but not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 21V316000 (Structure) however, the VIN was not included. The manufacturer was informed of the failure and referred the contact to NHTSA. The failure mileage was approximately 55,000.