2019 Ford Ecosport

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2023· ENGINE

  Oil pressure drop with noticeable loss of power. Loss of Turbo. Engine is full of oil and has been maintained but engine is not being lubricated. Engine parts are grinding.

• 12/29/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact stated while driving at approximately 35 MPH, the low oil pressure warning light illuminated and flickered. The contact stated that the vehicle started vibrating. The contact was able to drive the vehicle to a local dealer. The contact was aware that the VIN was included in NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact advised the dealer of the recall; however, the dealer informed the contact that the part to complete the recall was on national back order. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 53,713.

• 12/29/2023· ENGINE

  Low Oil Pressure. I had to get a whole new engine with only 95,000 miles.

• 12/29/2022· ENGINE

  The contact owns a 2019 Ford Ecosport. The contact stated that the vehicle stalled after starting. The check engine and low oil pressure warning lights were illuminated. The vehicle was not yet diagnosed or repaired by an independent mechanic or a local dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 81,420.

• 12/28/2023· POWER TRAIN,ENGINE

  On the evening of 12/20/2023 suddenly the loss of engine oil pressure with an illuminated oil pressure warning lamp came on and the engine started knocking loudly. Then as we pulled out of traffic into a parking lot spot it died and would not restart. We were in heavy traffic and if we were not able to exit as quickly as we did our family would have been stranded and blocking in the heavy traffic. Was able to start it after it cooled but the engine continued to knock and within 1 minute the oil pressure warning lamp came on. We have not taken it to a repair shop as it is at 61k miles. I had to have it towed home and are currently in a out of pocket rental. It will have to be towed for any type of service.

• 12/28/2023· ENGINE

  The contact owns a 2019 Ford EcoSport. The contact stated that while his daughter was driving at an undisclosed speed, the low oil pressure warning light illuminated, and the engine made an abnormal sound. The vehicle was towed to the dealer, where it was diagnosed that the engine needed to be replaced. The dealer replaced the engine. The manufacturer was made aware of the failure. The failure mileage was approximately 61,000. The VIN was not available.

• 12/28/2022· ENGINE

  The contact owns a 2019 Ford Ecosport. The contact stated that while driving 60 MPH, the oil warning light illuminated. After pulling over, the vehicle lost motive power and stalled. The contact was unable to restart the vehicle. The vehicle was towed to the dealer; however, the vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

• 12/27/2023· ENGINE

  Oil pressure dropped and motor locked up. Only has 130,000 miles on it. Only car I own and now I'm walking.

• 12/26/2024· ENGINE

  My car is at risk it has a powertrain and a w d failure when I am driving in the middle of the street or the expressway it stops in the middle of the expressway and loses power loses everything where me and my family could be at risk for a very serious accident leading to death in the middle of the highway or in the middle of the road as I am driving the car loses power and stops in the middle of the road. The manufacturer should be responsible for this because this is obviously something that needs to be fixed where it could be causing my death or my family's death while on the road. My car stops more than six times from the moment that I leave my house even as I am on the road it will literally stop 5 to 6 times losing power in the middle of the street that could cause a potential situation or deathly this needs to be fixed as soon as possible. I should not be responsible for these damages because it is obviously a malfunction of the manufacturer.

• 12/26/2023· ENGINE

  Motor failure when low oil pressure sensor came on. car had plenty of oil . up to date on oil changes and service. 69457 miles.

• 12/25/2023· ENGINE

  My car drove fine up until the 12th. I hoped in my car to go get some medicine at target which is 8 minutes away from them. My car began to make really loud noises and my oil light came on. I knew it was within the time for me to get another routine oil change. I bought one quart of oil just to hold me over for two days. I started my car to go home and my engine light and oil light and maintenance light all came on and my car would not drive over 45mphs. When you would press the gas, it would stall for a second. Thursday, I went for my oil change and was turned away due to the sound of my car and also the man smelled my dipstick and gas was in my oil. I was told to immediately take my car to the shop. The car shop has had my car for about a week and half and reached out at first saying that my problem was my camshaft and also turbo with a few other codes. I receive a class earlier this week saying I need a new engine. My car is a 2019 ecosport with 55k miles on it. They are working on an appraisal and so far it’s already 6k. Still waiting for the final estimate to replace my engine

• 12/22/2024· UNKNOWN OR OTHER

  When I drive this vehicle, sometimes it will lose all power even at 55 miles an hour. It comes up ...power reduced brake applied. I can't give it gas or anything. It lasts about 10 seconds.

• 12/21/2023· ENGINE

  The contact owns a 2019 Ford EcoSport. The contact stated that while his wife was driving at an undisclosed speed, the check engine warning light and low oil pressure warning light illuminated. The contact stated that an abnormally loud sound coming from the engine compartment. The contact's wife described the noise as a metal-on-metal grinding. Additionally, the vehicle was shaking erratically. The vehicle was towed to the dealer where it was diagnosed with catastrophic engine failure and that the engine needed to be replaced. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 81,111.

• 12/21/2023· ENGINE

  oil pump failure and now motor failure.

• 12/21/2023· ENGINE

  My daughter was driving on the highway and her oil light warning came on, followed by her car suddenly not allowing her to accelerate. This was followed by her check engine light coming on. She was able to make it to a Ford dealership in Lubbock, where they told her she needs a new engine. She seems to be one of many with similar issues. The vehicle has just over 80k miles.

• 12/19/2023· ENGINE

  The contact owns a 2019 Ford EcoSport. The contact stated while driving approximately 80 MPH, the engine made an abnormally loud pop, and smoke came up from underneath the hood. The vehicle then lost motive power. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic and was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was then towed to the dealer, where it was diagnosed that the piston had exploded, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 68,000.

• 12/16/2024· FUEL/PROPULSION SYSTEM

  My vehicle has 19,800 miles on it and is now facing 1100 in repairs for a fuel pressure sensor that has failed. The dealership, Lafayette Ford Lincoln of Lafayette, Indiana, claims this is a normal wear and tear item. Despite the fact that I have the Platinum extended coverage they say that it is normal for fuel system parts to fail with such little use. This is the third major item on this vehicle to need repair. I currently have a recall that the manufacturer has not contacted us for a solution and we had the thermostats go out at 15,000 miles. Nearly causing damage to the engine. When speaking to corporate service they say that these items are also wear and tear despite there being so little tear. In the platinum package brochure they make mention of "it being easier to say what is not covered" and do not exclude sensors or tubes in the brochure. After a quick Facebook search for issues with EcoSport's it seems that this has many reports from other owners. I tried to speak with corporate supervisor and was placed on hold where they then hung up on me. It seems that when I pointed out that this might be a car issue they became defensive. I believe this is a bigger issue for this vehicle and this engine. If my car fails at 19,000 miles what is to say other failures are not related.

• 12/15/2023· UNKNOWN OR OTHER,ENGINE

  Low engine oil pressure light came on and engine clanking noises occurred while I was traveling on the interstate. I immediately pulled the vehicle over to a safe location. Vehicle was towed to local Ford Dealership Service Center. Was told by the service manager that Ford has been having issue with oil pump not sending oil to the engine and that I would likely need a new engine. Due to backlog of service requests, Ford has not inspected my vehicle to verify the specific issue.

• 12/15/2023· ENGINE

  Low engine oil pressure

• 12/14/2023· ENGINE,FUEL/PROPULSION SYSTEM

  Oil flow light came on and I went to Walmart to have oil changed and to make sure oil filter was good. went to leave Walmart and oil flow light came on again. they took back in to take another look at it and could find anything noticeable. I was then told I should take it to a mechanic cause to him it seemed like the fuel pump wasn't flowing oil properly. I started home and while on the interstate I started smelling gas and the car started making a very loud whistling noise, like a teacup whistle. I was going 70mph and all of a sudden, the car jerked and quickly went to 30mph with all lights coming on. Had a tractor and trailer quickly coming upon me that had to serve to the next lane to keep from hitting me and almost hitting yet another car in that lane. Could get the car to get up past 30mph so I pulled off to the side of the road and once coming to a complete stop vehicle shut off and wouldn't restart. Had vehicle towed to a garage where I was informed that I need a engine replacement.

• 12/14/2023· ENGINE

  The contact owns a 2019 Ford EcoSport. The contact stated that while driving approximately 35 MPH, the low oil pressure warning light illuminated, and the vehicle started to lose motive power. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the engine needed to be replaced due to the oil pump failing and the belt being loosened which caused engine failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 65,000.

• 12/13/2024· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,BACK OVER PREVENTION

  The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the main control screen had blacked out and the safety features including the back-over prevention camera was inoperable. The contact stated while driving 60 MPH, the message that the vehicle was overheating was displayed on the dashboard and the vehicle decelerated to 9 MPH. The contact was able to exit the highway and pull over. The vehicle was towed to the dealer and the contact was informed that the recall repairs would begin in 2025. The manufacturer was made aware of the issue. The failure mileage was 73,000. VIN tool confirms parts not available.

• 12/13/2023· ENGINE

  While driving out of state on highway with my children on 12/8/2023, oil light came on out of nowhere and no motor oil pressure warning came on. Car started losing power immediately and I had to pull off the road. Motor started knocking and I had to have the car towed to a local firestone as no ford dealers were open. There were no warning lamps on prior to this happening. We were stranded and had to have someone drive 2 hours to pick us up and rent a vehicle to get back to Texas. The ford dealership got the car on Monday, 12/11/2023, and is replacing the motor at their cost, but they told us that we have to go back to Tennessee to get a rental vehicle and we cannot do that. The motor is not going to ship until 12/27/2023 and as of today we are out of pocket over $1000 for this incident for food, lodging, rental car, tow and diagnostics and we have no car to drive. My children and I were left stranded for over 4 hours and were almost hit by a semi truck when my car started losing power.

• 12/12/2023· STEERING,VEHICLE SPEED CONTROL,ENGINE

  A “ engine oil pressure” message popped up on the dashboard of the vehicle while I was driving. The vehicle won’t not accelerate fast enough to keep up with traffic and when it did accelerate it was impossible to slow it down. The engine is defective and failed in this vehicle.

• 12/12/2022· AIR BAGSCrash

  The contact owned a 2019 Ford Ecosport. The contact stated that while her daughter was driving at approximately 30 MPH, a van crashed into the passenger side. No warning lights were illuminated, and all air bags failed to deploy. The contact's daughter sustained unknown injuries and required medical attention. A police report was filed. The vehicle was towed to a tow yard. The insurance company sent an investigator and the vehicle was deemed totaled. The manufacturer was not made aware of the failure. The approximate failure mileage was 17,200.

• 12/12/2022· ENGINE

  Driving down interstate and car indicator/ warning light came on low engine oil pressure. Car started running rough. Was able to get car to a repair shop by tow truck only to be told car needs entire engine replacement at only 71,000 miles. No warning of any issues that would require such an expensive fix at such a low mileage. Known flaw in these vehicles yet Ford isn’t being forced to recall and fix the issue that is clearly their fault not customers. Unacceptable! Should be mandatory recall to replace this garbage engine that conveniently needs replace 10,000 miles AFTER warranty runs out. Dangerous to have engine power issues at 55 mph!

• 12/11/2023· ENGINE

  THE LOW PRESSURE OIL LIGHT CAME ON AND THE VEH. SLOWED DOWN SUDDENLY, I TURNED ON THE FLASHERS TO ALERT THE VEH BEHIND ME THAT I WAS HAVING A MECHANICAL PROBLEM, THEN A RATTLING NOISE IN THE ENGINE, WE STOPPED VEH AND HAD IT TOWED TO THE FORD DEALER, AFTER THEIR INSPECTION THEY SAID THE OIL PUMP HAD STOPPED PUMPING CAUSE A BELT HAD FAILED INSIDE THE MOTOR. THEN QUOTED A $9000.00 DOLLAR REPAIR FOR A NEW MOTOR

• 12/06/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available.

• 12/05/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 12/03/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford Eco Sport. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine and the powertrain malfunction warning lights illuminated. The contact pulled over to a family member’s residence. The contact was not able to restart the vehicle. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was not available. VIN tool confirms parts not available.

• 12/02/2024· FUEL/PROPULSION SYSTEM

  RECALL 23S64 OIL PUMP DRIVE, OIL PUMP DRIVE GEAR , BRAKE BOOSTER VACCUM PUMP. ENGINE FAILURE HAS MADE THIS CAR A SAFETY RISK AND CAN NOT BE DRIVEN. FORD HAS STATED THEY DO NOT HAVE PARTS TO REPAIR TILL Q1 2025. OFFERED NO SOLUTION AS A INTERREPAIR OR A RENTAL CAR UNTIL PARTS ARE AVAILABLE

• 12/02/2019· POWER TRAIN

  WHEN SHIFTING FROM REVERSE INTO DRIVE THE TRANSMISSION SLIPS RESULTING IN THE CAR JUMPING FORWARD. SOMETIMES IT ONLY STUMBLES AND IS BARELY NOTICEABLE. OTHER TIMES IT JUMPS FORWARD SEVERAL FEET. I TOOK IT BACK TO THE DEALERSHIP WHERE I BOUGHT IT AND WE DROVE ANOTHER BRAND NEW CAR THAT HAD THE SAME ISSUE. THEIR MECHANIC SAID IT WAS NORMAL. THIS MAKES TURNING AROUND IN A PARKING LOT OR SMALL SPACE VERY DANGEROUS.

• 12/01/2023· ENGINE,FUEL/PROPULSION SYSTEM

  Fuel pump failure has caused low engine oil pressure and now the engine in the vehicle has to be replaced

• 12/01/2023· ENGINE

  While driving, the vehicle displayed "Low Oil Pressure, Stop Engine" and we experienced a loss in power. Luckily, we were near our home at the time. We were traveling at approximately 65mph on a busy highway and the vehicle lurched as if it were going into a power-limited mode. We were able to get off of the roadway safely, but we were lucky in doing so. After dodging traffic and getting to a safe location, the vehicle was towed to a local Ford dealership. Upon inspection, they advised that the oil pump/belt/belt tensioner had gone out. This had caused a number of other issues within the engine (timing, bearings, etc) and the entire engine would have to be replaced in reference to SSM 49918. Researching online, there appears to be a large number of drivers experiencing the same issue with a failed oil pump that leads to a failed engine, some of which have seized completely while traveling. Luckily, ours did not seize completely, but the vehicle did drop drastically in power, causing other vehicles to swerve to miss us as we had an uncontrollable loss in speed. The vehicle is currently at the Ford dealership still as I call around to get additional quotes for repair. Ford estimates the cost of repair to be approximately $8,700. Ford customer service also refused any financial assistance due to our "CLV Score" not being "high enough", even though this is a known issue with this engine specifically. When I asked for a copy of the repair order for the quoted repairs from the Ford dealership, they provided me with a repair order with no diagnosis, quote, estimate, or any other information regarding the repairs needed. All information has been by phone with no written documentation on the issue from the service department.

• 12/01/2023· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the low oil pressure waring light illuminated, and the vehicle lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. The vehicle was towed to an independent mechanic, who diagnosed the vehicle with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was then towed to the dealer, who confirmed the diagnosis. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: PE23015 (Engine and Engine Cooling). The manufacturer was not notified of the failure. The failure mileage was 77,000.

• 11/29/2024· ENGINE AND ENGINE COOLINGFire

  The contact owns a 2019 Ford Ecosport. The contact stated that while the daughter was driving approximately 20 mph the check engine and oil pressure warning lights had illuminated, a burning odor was present inside the vehicle and white smoke was coming from the exhaust pipes. The daughter was alerted by another motorist that the vehicle was on fire. After parking and exiting the vehicle flames and smoke were present coming from the engine compartment. A nearby police officer used a fire extinguisher to extinguish the flames and the fire department was called to the scene. A police report was taken and the vehicle was towed away to a nearby lot. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet contacted. The contact had previously received a recall notice regarding the NHTSA Campaign Number: 23V90500(ENGINE AND ENGINE COOLING). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 54,000.

• 11/29/2023· ENGINE

  Low oil pressure light came on. Pulled over right away. No rough idle or any odd noises. Had it towed to the ford dealership. Was told it was an oil pump retention belt that broke and the engine had no compression. The belt pieces were found in oil. Was told the engine had catastrophic failure due to the belt breaking. And would need to replace the whole engine. The car is a 2019 and only had 70000 miles on it. 10000 miles out of warranty. So I would have to pay for the entire thing. Ford would not take any responsibility. Called the ford costumer service assistance and was told no recalls were put out for that. I know there is a NHTSA investigation going on so I wanted to add my name to the list of people this has happened to.

• 11/28/2022· ENGINE

  The contact owns a 2019 Ford Ecosport. The contact stated while his daughter was driving 30 MPH, the oil pressure warning light illuminated, and the vehicle lost motive power. The contact was able to pull over and the vehicle was towed to the dealer. The vehicle was diagnosed, and the mechanic stated there was damages to the engine, turbo charger, and vacuum pump. Additionally, the long block needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 61,120.

• 11/25/2023· ENGINE,FUEL/PROPULSION SYSTEM

  Engine stalling. White smoke, clicking noise bb

• 11/22/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact stated while driving at various speeds on several occasions, the vehicle stalled. The vehicle was able to be restarted immediately after the first failure; however, the vehicle failed to start immediately after all other failures. The contact stated that the vehicle was no longer able to be restarted. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced due to coolant intrusion. The vehicle was then towed to a dealer where it was determined that there was coolant intrusion in the cylinder and damaged the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 64,000.

• 11/21/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The local dealer was made aware of the recall and confirmed that parts were available for the recall repair. The contact scheduled an appointment for the repair, and the vehicle was dropped off for service. The vehicle remained with the dealer despite the dealer's insistence that the parts for the repair were available. The contact was not provided a loaner vehicle and had not been given a reason for the delay in service. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact had not experienced a failure.

• 11/20/2023· ENGINE AND ENGINE COOLING

  The contact's husband owns a 2019 Ford EcoSport. The contact stated that while driving 45-50 MPH, the low oil pressure warning light illuminated. The vehicle was taken to an independent mechanic, where an oil change was performed; however, the failure persisted. The vehicle was taken back to the independent mechanic, where it was diagnosed and determined that the oil pump had failed. The vehicle was not repaired. The dealer was not notified of the failure. The contact stated that the engine and the oil pump were previously replaced by the previous owner of the vehicle. The contact related the failure to NHTSA Action Number: PE23015 (Engine and Engine Cooling). The manufacturer was notified of the failure and advised the contact to replace the engine. Additionally, the manufacturer referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 180,000.

• 11/19/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/19/2023· ENGINE

  LOSS OF OIL PRESSURE. Loss of engine power. machanic said that the oil pump is bad.

• 11/18/2023· ENGINE

  I got up to get to work on 11/11/23 and my check engine light came on. Then my engine oil light came on. I had just gotten my oil changed not even a full week prior to this. I was driving and my car started to make a knocking noise and started to decelerate while I was coming up a hill. I got it towed to a Ford dealer that confirmed my oil pump went bad and I would need to replace my engine. My car only had 73000 miles on it. I called ford and they said there was nothing they could do. The denied knowing anything about an investigation into the oil pumps on these cars and said they won’t help pay or discount the price. The only option they gave me was to write a letter to some ford department in Michigan and wait on them to write me back as that’s the only way they communicate. Even with me replacing my engine it’s still the same oil pump as the last one so it’s just a matter of time before this one goes out as well. 5600 for a new engine and only a 2 year warranty and no advice on how to prevent this from happening again. They said keep my receipt and keep hoping for a recall. Ford is a joke.

• 11/15/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check engine warning light recently appeared on the instrument panel. The manufacturer was made aware of the issue. The failure mileage was approximately 40,00. The VIN was not available.

• 11/15/2023· ENGINE,FUEL/PROPULSION SYSTEM

  The low oil level indicator light went on while I was driving in my 2019 Ford EcoSport. I stopped at an auto parts store and had them add oil. The light did not go off when we tried to clear the sensor. I drove it home (about a mile) and it struggled to pick up speed and the engine started to knock. I did some research on the model and the government is currently looking into to this issue and there are several lawsuits. All have indicated they were just out of the warranty and the entire engine needed to be replaced. It is going to cost me thousands of dollars to fix this. I was told that there is not indication that there are any issues with the engine or fuel pump until it is too late. There is an open case with the NHTSA (SSM 48093) so this is a very well known issue and will continue to get worse with other EcoSport drivers as they near 60,000 miles. It is HORRIBLE business practice to do this to customers. I now have to pay thousands of dollars for a problem I did not know about it was too late. Ford needs to take responsibility for this.

• 11/14/2025· ENGINE

  Our engine seized due to a safety recall while traveling on a major interstate. We received notice of the safety recall from Ford and asked to have it fixed by our local dealership. This was August 20, 2025. We were told by the dealership’s service manager that there were 2 or 3 cars ahead of us and call back the first of September. We again asked to get scheduled and were told there were cars ahead of us. We once again asked about the recall and having it repaired on Oct. 21, 2025. We was told it couldn’t be scheduled at the time and it should be okay for us to go on our scheduled 8 hour trip. The car seized on Oct. 26, 2025 and we were 4 hours away from home. At that time, we had to have it towed to local dealership there and were stranded. The low oil light came on just minutes before it seized. We contacted the state police to be there with us as we waited for help and had to pay to stay overnight. Our car is still 4 hours away and is supposed to be fixed as soon as the engine comes in. This was a safety recall and we were advised to travel in a car which was not safe and Ford knew it. We do not have any paperwork except the safety recall as it has not been repaired.

• 11/14/2023· ENGINE

  I had my 2019 Ford Ecosport serviced to have a new battery and brakes installed on it by my local Ford dealership. Approximately 5 days after I picked it up from the dealership, I was on my way to work and driving down I-75 (going approximately 70 mph). I received a sudden notification on my dash that I had low oil engine pressure. I made my way over to the right lane, and started to slow down so I could pull over. I made it to about 30 MPH when my car turned off, my brakes locked, and my steering wheel locked. I had to push with excessive force on the brakes to completely stop the vehicle, and pull with excessive force to make it turn off to pull over. I checked the oil, and it was not low. So, I had it towed to the dealership. Here they told me that a belt had slipped in my engine and caused significant bearing damage. The base estimate that I was given for repairs was 9,000 dollars, and that if my car was manufactured less than a month sooner that these repairs may have been covered by Ford because it is a known issue with this make and model car. I was very concerned that I would not be able to stop my car safely on the highway and now I don't see how I can pay for the repairs.

• 11/14/2023· ENGINE,FUEL/PROPULSION SYSTEM

  Car started stalling out then not starting every time filled up with gas, Ford service center took 2 months saying it wouldn't harm the car and then had to replace the purge valve on 10/5/23. On 11/11/23 the low oil pressure light came on without any issues beforehand, oil life at 36%, oil on dipstick. The car lost power when trying to accelerate and started making ticking noise from under the hood. Determined to be failed oil pump and engine, engine has to be replaced.