2018 Alfa Romeo Stelvio

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/23/2022· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER

  Body control module While driving in rain, received multiple incorrect messages on dash screen, horn began to beep. Unable to turn horn off until parking and disconnecting the negative battery cable. Had body control module replaced. Two weeks later, driving in rain: multiple warning lights appeared. Monitor said passenger and driver doors were open-they were not. Gas gauge became 'unavailable,' displaying only empty tank. Lights flickered on and off in cabin. Dealer said this was never a recall issue. Alfa says it was but the recall 'expired, so not eligible to fix' This is recall number U36. Obviously still a problem.

• 12/21/2023· STEERING,ELECTRICAL SYSTEM,ENGINE

  Driving on highway lost full power of engine. Throttle body control message came on . Then steering wheel started to stiffen up . Terrible experience and scary lucky was able to gain control on vehicle and pullover . Reading reviews after getting this vehicle 2 years later that it’s common in most car of this make and very unsafe . Dealer doesn’t help and warranty is crap leaving you going to the dealer several times spending dollars on the same safety issue .

• 12/17/2019· SERVICE BRAKES

  ALPHA ROMERO WHEN DRIVING IN HEAVY TRAFFIC AT HIGHWAY SPEEDS, ACCELERATING AND BRAKING OCCUR TOGETHER AND OFTEN, THE ENGINE WILL CUT OFF AND ALL SYSTEMS BECOME INOPERABLE. STOP/START SYSTEM FAILURE SYMBOL APPEARS ON SCREEN. THIS WILL OCCUR WHEN STOP/START SYSTEM DESPITE HAVING DISENGAGED BY PRESSING BUTTON ON DASHBOARD. IT TAKES SEVERAL SECONDS FOR THE ENGINE TO COME BACK ON. DURING THIS INTERVAL, THE CAR CAN NOT BE CONTROLLED. CAR IS MOVING BUT CAN;T BE CONTROLLED BY DRIVER. ALPHA ROMEO CUSTOMER CENTER IS AWARE OF PROBLEM BUT SAYS THERE IS NO FIX AVAILABLE AT THIS ALTHOUGH THEY HAVE KNOWN ABOUT IT FOR SOME TIME. IN MY OPINION IS THIS AN EXTREMELY DANGEROUS SITUATION AND AN IMMEDIATE RECALL IS NEEDED TO PREVENT SERIOUS INJURY/DAMAGE. RECALL IS NECESSARY TO FIT THIS PROBLEM IMMEDIATELY. THIS HAS HAPPENED MORE THAN ONCE.

• 12/12/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

• 12/09/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, parts to do the recall repair were not yet available. The contact stated that the vehicle failed an inspection and would not pass due to the open recall and the parts not being available to repair the vehicle. The local dealer was contacted, and the dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

• 12/06/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  At a red light in a busy city, my car auto-stopped the engine. When trying to auto-start as the light turned green, the car started smoking and wouldn't move. When towed away and taken to the dealership, they said that the ground strap of the vehicle had corroded, shorted out, and melted a number of wires within the wiring harness. It is available for inspection upon request. This easily could have been a full electrical fire within the car, putting us in further mortal danger had we not shut the car off immediately. We also were in a highly congested area, and could have been hit while jumping out of the car for fear of smoke/fire. We could have been rear ended by traffic behind us as well. The dealership said that this is a common problem that I did not cause nor could have anticipated or prevented. I did my own research and have found many accounts of this exact same issue happening with this make and model of the car (2018 Alfa Romeo Stelvio). There are accounts online that Alfa Romeo has since switched out the part in later makes of the car for one that is more protected and not prone to corrosion - it is clear that they know and have quietly acknowledged the issue. This is a common and reproducible problem. The car has only been inspected by the mechanics at a local repair shop and then at an Alfa Romeo dealership. The insurance representatives said that because this is a mechanical failure, it is not covered by insurance and therefore they have no need to inspect it. There were no symptoms prior to the failure of the ground strap and melting of the wires within the wiring harness. The car was functioning as normal up until this incident. It was well taken care of with regular maintenance and only had 48,000 miles on the odometer. It had never had any prior issues, mechanical or otherwise.

• 12/05/2019· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  THERE'S A PROBLEM CALLED ETC ERROR. IT HAS HAPPENED 5 TIMES SINCE 9500 MILEAGE. AND NOW CAR HAS 15900 MILEAGE. EVERY TIME IT HAPPENED WHEN I WAS ON HIGHWAY TRYING TO ACCELARATE. WHEN THAT PROBLEM OCCURED, I SUDDENLY LOST POWER AND HAD TO PULL OVER IN THE MIDDLE OF TRAFFIC. THEN I NEEDED TO SHUT DOWN THE ENGINE AND RESTARTED, AFTER THIS ACTION POWER WAS BACK ON WITH ENGINE CHECK LIGHT ON, TOO. AND CAR WAS DRIVEABLE WITH AUTO START/STOP AND REMOTE START UNAVAILABLE. I WENT TO DEALSHIPS 3 TIMES. FIRST DEALSHIP CAN'T NOT LOCATE THE PROBLEM AND JUST RESET COMPUTER. SECOND DEALSHIP FOUND ONE PROBLEM AND REPLACED A PART. BUT AFTER A COUPLE THOUSANDS OF MILES, THE PROBLEM HAPPENED AGAIN. I HAVE TWO VIDEOS, BUT THEY ARE TOO BIG TO UPLOAD.

• 12/04/2018· UNKNOWN OR OTHER,ENGINE

  11/10/18 PICKED UP NEW CAR FROM THE DEALER 11/12, 11/13,11/14, 11/15, 11/19 CAR STARTED & HAD NO ISSUES. 11/20/18 CAR DID NOT START, ENGINE LIGHT INDICATOR IS ON. HAD ROAD SIDE ASSISTANCE BOOST BATTERY. UNSUCCESSFUL. CAR TOWED BACK TO DEALER 0N 11/21/18 11/23 CAR RETURNED, DROVE CAR 11/26/18 WITHOUT ISSUES. 11/27/18 CAR DID NOT START, ENGINE LIGHT & OIL LIGHT INDICATOR ON, CAR TOWED BACK TO DEALER. 12/4/18 CAR RETURNED TO ME AND WORKING. DROVE CAR ABOUT 10-15 MILES, WHILE DRIVING I NOTICED THE ENGINE LIGHT INDICATOR WAS ON WHILE DRIVING. CALLED DEALER WHILE IN CAR, AND DEALER INSTRUCTED TO RETURN CAR SAME DAY. I DID NOT STOP OR TURN OFF THE CAR UNTIL I ARRIVED AT THE DEALER ( SAME DAY) I DROVE UP TO SERVICE DEALER PARKING LOT AND TURNED OFF THE CAR. WHILE WAITING,AT DEALER THE STAFF INFORMED THAT THE CAR DID NOT START, AND THEY HAD TO PUSH THE CAR INSIDE OF THE SERVICE AREA. AS OF THIS REPORT, I DO NOT HAVE A WORKING CAR.

• 11/24/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that several dealers were contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

• 11/21/2025· ELECTRICAL SYSTEM,ENGINE

  My 2018 Alfa Romeo Stelvio experienced a complete electrical failure and will not start at all. The vehicle suddenly lost all functionality and remains fully inoperable. The dealership has had the vehicle for an extended period and has been unable to diagnose or repair the defect. This appears to be related to known electrical issues in 2018 Stelvio models, including BCM (Body Control Module) failures, wiring faults, and fuel system defects reported in recalls and TSBs. A no-start electrical failure is a serious safety concern because similar defects in this model have been linked to unexpected engine shut-offs. The vehicle has been out of service for over 30 days. This is a major safety and reliability issue. I am requesting that NHTSA review this defect, because the manufacturer has not provided a resolution.

• 11/20/2025· FUEL SYSTEM, GASOLINE,ENGINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while his daughter was driving approximately 60-75 MPH, the vehicle shuddered and lost motive power. The driver was able to pull over to the side of the road. The check engine warning light and other unknown warning lights were illuminated. The vehicle failed to restart and was towed to the residence. The contact stated that the vehicle was able to be restarted the following day, but the check engine warning light remained illuminated. The vehicle was taken to an Auto Parts Store, where it was scanned, and a DTC for low fuel volume was retrieved. The contact received notification of NHTSA Campaign Number: 25V586000( Fuel System, Gasoline), which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

• 11/13/2018· ENGINE

  ON SEPTEMBER 21, 2018 WHOLE COOLER ENGINE FLUID WAS FLUSHED INSIDE IN THE PASSENGER SIDE CAR. THE CAR WAS PURCHASED ON 09-19-2018. THE RECALL HAD BEEN SEEN SINCE 09-14-2018. THE CAR WAS SOLD TO US WITH A SAFETY RECALL WITH SAME VIN NUMBER

• 11/11/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  I received a manufacturer recall notice (Recall 93C / NHTSA 25V-586) for my 2021 Alfa Romeo Giulia concerning a defective rear fuel line quick connector that may leak fuel and cause an engine compartment fire. I contacted Alfa Romeo of Brandon (FL) several times to schedule an inspection and request a temporary vehicle as recommended by FCA. My service advisor, Lenny Patram, confirmed that the remedy is not yet available and advised me to wait for further notice. Despite expressing safety concerns, I was told that no loaner or temporary vehicle could be provided. This situation puts my safety and the safety of others at risk. The recall notice specifically warns that a fuel leak could lead to a fire, yet I have been advised to continue parking the vehicle outside and avoid driving it if possible. I rely on this vehicle for daily transportation and have not been offered any safe alternative or clear timeframe for repair. In addition to the recall, my check engine light has been on for several weeks, and the “A!” warning light appears intermittently. These indicators began appearing after I received the recall notice and may be related to the same underlying defect. The dealer has not inspected the vehicle because parts are unavailable. The issue has not been reviewed by the manufacturer, insurance, or any third party. The vehicle is currently at my residence and available for inspection upon request. Warning lights prior to failure: Yes — check engine light and “A!” warning. Reproduced/confirmed by dealer: No — recall acknowledged but not inspected. Component available for inspection: Yes.

• 11/03/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while the vehicle was parked and shut off, the contact attempted to start the vehicle, but the vehicle failed to start. The contact stated that the vehicle lost motive power, and the fuel warning light was illuminated. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to complete the recall repair was not yet available. A local independent mechanic arrived at the residence to inspect the vehicle, but the vehicle was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 41,000.

• 10/24/2020· POWER TRAIN,VEHICLE SPEED CONTROL

  WHILE ON A HIWAY, WITH CRUSE ON, STOPPED FOR A RED LIGHT. WHILE STOPPED THE ENGINE SHUT OFF. I PUSHED THE STOP-START DISABLE BUTTION. THE CAR ACCLERATED INTO THE INTERSACTION BEFORE I BRAKED IT TO A STOP. LUCKELY THERE WAS NO ONE INFRONT OF ME AND NO CROSS TRAFFIC OR WE WOULD HAVE WRECKED. THE CAR THEN WENT BACK TO IDLE AND HAS BEEN FINE SINCE.

• 10/23/2025· FUEL SYSTEM, GASOLINE,AIR BAGS,SEAT BELTS

  The contact owns a 2018 Alfa Romeo Stelvio. The contact received notifications of NHTSA Campaign Numbers: 24V510000 (AIR BAGS, SEAT BELTS) and 25V586000 (FUEL SYSTEM, GASOLINE). However, the part to do the recall repair was not yet available. The contact stated that while her daughter was driving 55 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle decelerated from 50 MPH to 40 MPH. An unknown warning light was illuminated. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

• 10/21/2025· FUEL SYSTEM, GASOLINE,ENGINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. In addition, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was taken to an Auto Zone, where it was diagnosed, and DTC: P008A (Low-pressure fuel system pressure is too low) was retrieved. The vehicle was not repaired. The dealer was made aware of the failure. The contact was waiting for an available service appointment. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

• 10/21/2020· ELECTRONIC STABILITY CONTROL (ESC)

  THE CAR WON'T GET UP TO SPEED LIKE IT POST TO. IT TAKES FOREVER FOR THE CAR TO GET UP TO 30MPHS. THEY SAY IT'S A OIL SENSOR PROBLEM.

• 10/15/2024· AIR BAGS,SEAT BELTS

  Sept. 9, 2024 - called local dealer to schedule repair. Parts were not yet available. Placed on a list for them to call when the parts were available. October 15, 2024 - called dealer again. No parts have been received. ETA unknown. Confirmed I was still on the list.

• 10/13/2025· UNKNOWN OR OTHER,ENGINE

  I’m having fuel pump issues which it came to my knowledge there was a recall with no remedy

• 10/11/2019· FORWARD COLLISION AVOIDANCE

  TL* THE CONTACT OWNS A 2018 ALFA ROMEO STELVIO. THE CONTACT SATED THAT THE FORWARD COLLISION DETECTION SYSTEM FAILED. WHILE DRIVING OVER A BRIDGE, THE AUTOMATIC BRAKING SYSTEM ENGAGED INDEPENDENTLY WITH NO HAZARD AHEAD. THE CONTACT ALSO STATED THAT THE ADAPTIVE CRUISE CONTROL DETECTION SYSTEM ACTIVATED INCORRECTLY. THE SYSTEM DETECTED A VEHICLE ON THE PASSENGER SIDE AND ENGAGED THE BRAKING SYSTEM AS IF THE VEHICLE WERE IN FRONT OF THE CONTACT'S VEHICLE. THE CONTACT STATED THAT THE FAILURES OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THOMPSON MASERATI ALFA ROMEO (303 SWAMP ROAD, DOYLES TOWN, PA 18901, (215)348-0056) TO BE DIAGNOSED, BUT NO ERROR CODES COULD BE FOUND. THE DEALER REALIGNED THE SENSORS, BUT THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 11,500.

• 10/10/2025· ELECTRICAL SYSTEM

  Battery has had repeated failures which have resulted in leaving driver stranded. Battery has been replaced 5 times since purchase in January 2021. Cause has yet to be determined.

• 10/09/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while exiting a gated community at a slow speed, the vehicle started jerking while depressing the accelerator pedal. The battery warning light was displayed on the instrument panel when the vehicle lost all power. A tow truck driver attempted to jumpstart the vehicle, but the vehicle failed to restart. The vehicle was towed to an independent mechanic, where the battery was recharged; however, the failure returned within two hours after leaving the mechanic. The vehicle was towed to another independent mechanic, where the vehicle was diagnosed with a defective fuel pump. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, parts for the recall repair were unavailable. The vehicle was not repaired. The dealer was notified of the failure, and the contact was scheduled for an appointment for a diagnostic test. The manufacturer was made aware of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 60,000.

• 10/01/2020· POWER TRAIN,ENGINE

  TL* THE CONTACT OWNS A 2018 ALFA ROMEO STELVIO. THE CONTACT STATED THAT THE VEHICLE HAD BEEN TO THE DEALER FIVE TIMES SINCE IT WAS PURCHASED. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE OVER 40 MPH AND FREQUENTLY WENT INTO LIMP MODE. THE CONTACT STATED THAT THE ELECTRONIC THROTTLE CONTROL AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE FULLERTON ALFA ROMEO DEALER LOCATED AT 1034 US-22, SOMERVILLE, NJ 08876, WHERE IT WAS DIAGNOSED THAT THE TURBO CHARGER NEEDED TO BE REPLACED. THE PART WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED TO RETURN THE VEHICLE BACK TO THE DEALER. THE CONTACT WAS NOT SATISFIED AND REQUESTED A TRADE, WHICH THE MANUFACTURER REJECTED. THE CONTACT STATED THAT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 30,500.

• 09/26/2023· ENGINE

  Engine blew at a bit over 40000 miles. There were regular oil changes and service done. The car of this quality and price should never have the engine blown at this amount of miles. It happened right after oil change and inspection, which confirmed everything was fine with the vehicle.

• 09/25/2018· POWER TRAIN,ELECTRICAL SYSTEM,ENGINEFire

  AFTER FUELING UP THE FUEL TANK, THE VEHICLE WAS DRIVEN ON THE HIGHWAY AND SMOKE BEGAN TO EMIT OUT FROM THE VEHICLE'S HOOD. THE DRIVER WAS NOT ALERTED THERE WAS ANY ISSUE FROM THE VEHICLE'S DASHBOARD INDICATOR/WARNING LIGHTS. THE DRIVER PULLED OVER ON THE HIGHWAY SHOULDER AND THE VEHICLE WAS ON FIRE UNTIL THE FIRE/POLICE DEPARTMENT ARRIVED ON SCENE. *DT UPDATED 10/22/18*JB

• 09/24/2025· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  1. What component or system failed or malfunctioned, and is it available for inspection upon request? The low-pressure fuel pump (fuel delivery module) appears to be failing, consistent with Recall 25V-586 / Alfa Romeo Campaign 93C. This causes fuel starvation and loss of motive power. 2. How was your safety or the safety of others put at risk? The vehicle has experienced loss of motive power (LOMP) while driving. At times it jerks or hesitates when accelerating from a stop, and while climbing a hill it suddenly lost power, displayed a Service Electronic Throttle warning, and went into limp mode. This created a risk of being unable to accelerate safely in traffic, increasing the chance of being rear-ended or unable to merge. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. I described the symptoms to Alfa Romeo Service dept, and they told me it is related to the recall and that other customers have reported the same symptoms and warning lights. However, they advised that there is currently no remedy available, and I must wait for the fix before scheduling an appointment. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. Alfa Romeo advised that no remedy is available at this time, so the vehicle has not been formally inspected by the dealer or manufacturer. Advised not to drive long distances until fix determined. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Check Engine Light and Service Electronic Throttle came on as car lost power and entered limp mode with code P0299. Alfa Romeo Service Dept tech said these warnings match the recall. Rep said this shows how loss of motive power from fuel starvation manifests electronically & ECU interprets fuel starvation as underboost, which then triggers limp mode.

• 09/23/2024· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  The engine has shut down in traffic on the following occasions: 1) July 2023 in The Woodlands, Texas. 2) Later that same day on [XXX] in Plantersville, Texas. 3) In August 2024, on [XXX] and 4) on [XXX] . My vehicle is available to the NHTSA upon request. On each occasion, except one, I was fortunate to be in the right hand lane and was able to pull over onto the shoulder before any could hit me. On [XXX] , near Richards, there was no shoulder and I was stopped within the single lane of westbound traffic. I was fortunate that traffic was light at that time and that it was daylight. After the first two incidents in 2023, I took it to Northside Imports in Spring, Texas (XXX) They were unable to duplicate the problem or determine what was the cause. On [XXX], I took the car back to Northside Imports and they determined that it needed a new fuel pump, seal and control module. (I was informed on Friday, [XXX] that the parts have been received and can be installed on [XXX].) Between the time that the fault was identified and the time the parts were available the car has failed on the highway twice, once on [XXX] and once on [XXX] . The vehicle has not been inspected by anyone but Northside Imports in Spring, Texas. There were no warnings in advance of the shutdown. I was able to restart the vehicle after a short period of time after disconnecting the battery. Each time, it restarted in "limp" mode. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 09/21/2025· FUEL/PROPULSION SYSTEM

  With temperatures around 90 degrees and engine is up to temperature the engine just stopped in the middle of the road blocking traffic This also happened 2 additional times and wouldn’t start for about 45 minutes. Recently paid $2,000 to replace the fuel pump and controller at a dealership. They told me there was no recall Had to wait 4 weeks for parts and didn’t know if they fixed the problem as there have not been any 90 degree days since the repair was done

• 09/20/2025· FUEL/PROPULSION SYSTEM

  2018 Stelvio Quad 7/2025 Taking off from a red light with multiple cars behind and beside me, my car lost power throwing multiple warning lights, swapped itself from "D" to "N" driving mode and had to be limped off the road and restarted. It would not swap modes from "N". Displayed "check engine light. Contacted my service manager, completed 10 restarts, issues cleared. Car would drive in all modes without issue. 2 weeks later having had no issues and assuming bad fuel, at the same light I was nearly rear ended because it did the same thing as before. There is a barrier to the left lane and I could not get my car out of the road. People were flying around, honking and yelling. After traffic cleared I was able to restart the vehicle. Called my service manager. 10 restarts cleared it and scheduled to bring it to Knoxville the next day. Obd reading indicated fuel starvation and delivery issues. The next day the dealership could not find an issue with the car. I took it home and drove it 2 more weeks without any issues until unfortunately, traveling about 70mph on the highway the lights came on again, same issue and lost power nearly causing an accident. Called the service manager. 10 restarts to clear it and drove it to the dealership about 100 miles away the next day using back roads to avoid the freeway. About 40 miles from the service center, it died while traveling about 30mph but thankfully, there were no other vehicles near me at that time and I was unfortunately prepared for the possibility. Once at the service center, it was determined that the fuel pump needed to be replaced and I paid significant money to have this part ordered and installed. I was without my car for about a week however this dealership does provide a loaner. I had the car back since mid August without any further issue - until last week, on start giving me the same dash warning lights, unable to swap from "N" mode. Called the service center and the coil pack was replaced yesterday.

• 09/17/2025· ELECTRICAL SYSTEM,ENGINE

  Description of the Problem: While operating the vehicle, multiple warning lights illuminated including the Electronic Stability Control (ESC) warning light, the check engine light, and other unknown warning indicators. In addition, several warning messages were displayed, including “Service Engine Soon” and other unknown messages. When this occurs, the vehicle begins to overheat, the auto start/stop function becomes disabled, and the vehicle loses power and will not accelerate as expected. Component or System Failed / Malfunctioned: The exact component is unknown at this time. The failure appears to be related to the engine, powertrain, or electronic control systems. The vehicle and components are available for inspection upon request. Safety Risk: The vehicle’s failure to accelerate and overheating while in motion creates a serious safety hazard. This puts the driver and passengers at risk, especially if the loss of acceleration occurs in high-speed traffic, intersections, or on highways. Reproduction of the Problem: The issue has recurred multiple times. It has not yet been officially reproduced or confirmed by a dealer or independent service center. Inspections: At this time, the vehicle has not been formally inspected by the manufacturer, police, or insurance representatives. Warning Lamps, Messages, and Symptoms Prior to Failure: The problem is preceded by the illumination of the ESC light, the check engine light, and other unknown warning lights. The messages “Service Engine Soon” and others appear immediately prior to or during the failure. These warnings occur before the loss of acceleration and overheating. Additional Notes: The failures are ongoing and have occurred more than once, raising concerns about reliability and safety.

• 09/17/2018· ELECTRICAL SYSTEM,STRUCTURE,SERVICE BRAKES

  I GOT MY ALFA ROMEO STELVIO IN NOVEMBER 2017 AND LESS THAN A YEAR, IT GOT TOO MANY PROBLEMS, SOME OF WHICH ARE SERIOUS N GOOD HELP FROM DEALERS. PROBLEMS: 1.FROM MONTHS, I WAS GETTING ALL LIGHTS OUT INDICATIONS WHERE ALL LIGHTS WORK, WHEN I PUT INDICATOR ON IT GIVES ANNOYING SOUND IN CAR. (THIS HAPPENS WHILE VEHICLE IS IN MOTION & STATIONARY) 2.WHEN IT RAINS OUTSIDE, WATER LEAKAGE IN CAR NEAR FRONT SIDE PASSENGER LEGS ' (THIS HAPPENS WHILE VEHICLE IS IN MOTION & STATIONARY) 3.VOLUME IN CAR RAISES AND HIT MAX AUTOMATICALLY. (THIS HAPPENS WHILE VEHICLE IS IN MOTION) 4.IF I TURN OFF CAR AND GET DOWN WHILE I WAS ON CALL, STILL MEDIA DOES NOT GO OFF UNLESS I MANUALLY DISCONNECT MY PHONE FROM CAR BLUETOOTH. 5.PARKING BREAK GETS AUTO RELEASE WHEN I PRESS ON ACCELERATOR. 6.ONE MORE HUGE STUPID ISSUE FROM ALFA ROMEO. WHILE I WAS DRIVING, I GOT INDICATOR SAYING ENGINE ON/OFF BUTTON NOT AVAILABLE AND WAS HONKING BY ITSELF AND THAT TOO WHEN I WAS DRIVING. WHEN I PULLED OVER FROM TRAFFIC & TURN OFF VEHICLE THEN IT GOES INTO PANIC MODE. THIS IS SO STUPID N SERIOUS. (THIS HAPPENS WHILE VEHICLE IS IN MOTION & STATIONARY) IMPORTANT NOTE: I UNDERSTAND MOST OF THE ABOVE STATED ISSUES WERE PART OF RECALLS (U34 & U36). STRANGE THING IS WHEN I CHECKED WITH DEALER & ALFA ROMEO PREMIUM CARE, AS PER DOCUMENTATION THE RECALL FIXES WERE DONE ON MY CAR. WHICH MEANS THE RECALL FIXES WERE NOT GOOD ENOUGH TO FIX THE ISSUES, WHICH CAUSED FOR RECALL AND AS STATED BY THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THESE ISSUES WILL INCREASE THE RISK OF A CRASH. SUCH A DISAPPOINTMENT WITH MOST RATED MOTOR TREND OF THE YEAR ALFA ROMEO. AM JUST GIVING RECENT DATE WHEN HAPPENED, BUT THIS IS HAPPENING FROM LONG AND NOT PROPER SUPPORT FROM DEALER TO FIX IT. WHEN LAST TIME IT HAPPENED I WENT TO DEALER AND LEFT CAR WITH THEM. VISIBILTY WIPER/OTHER PARTS AFFECTED TOO.

• 09/11/2022· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE

  Water discharge on the passenger side whenever the AC is switched on and the car is driving. The water leak led to electrical malfunction with electrical lights switching on even when the car is switched off or the lights switching off when the car is in motion. The water on the passenger side was a nuisance for a long time but when the electrical system went haywire, it became a safety risk especially during night driving when the lights may switch off abruptly. The water leak incident was first reported to the dealership on March 6th, 2021. We did not drive the car around much in the year due to covid. We subsequently reported the problem to dealership in March and May of 2022 (start of the summer months). The water leak continued to happen and we ignored it for a while until Aug 6th 2022 when we took a long trip and the passenger side was completely soaked. The electrical malfunction started happening sometime after. Eventually, on Sept 6th 2022, the car battery died as the lights were running throughout the night. The water leak incident has been looked by dealership and they did found dampness on the passenger side but could not recreate the issue. The car has been with dealership since Sept 7th 2022 for them to check for electrical and water leak issue. The videos of the incidents could be found here: https://www.dropbox.com/sh/plin71ez82sflh3/AADR4qOJ744_dtoInw0y108Ha?dl=0

• 09/02/2025· FUEL SYSTEM, GASOLINE,SEAT BELTS,ELECTRICAL SYSTEM

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that the instrument cluster was inoperable. The vehicle was taken to an unknown local dealer, and it was confirmed that there was no warranty coverage on the vehicle for the failure. The dealer informed the contact about a seat belt recall that was completed, but the initial failure was not repaired. The contact stated that after refueling, the fuel light illuminated two days later. The contact stated that the vehicle also stalled while driving. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 44,000.

• 08/27/2026· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  I am reporting an authorized manufacturer franchise dealer for actively refusing to remedy a federal safety recall and unlawfully withholding my vehicle. My vehicle is a 2019 Alfa Romeo Stelvio (VIN: [Insert VIN]), which is subject to the active Fuel Pump Safety Recall (NHTSA Campaign 25V586000 / Manufacturer Recall Code 93C). The vehicle has been physically located at Southern Alfa Romeo of Norfolk ([XXX]) for approximately 18 months. The dealership service management has explicitly stated that they will not perform the mandatory safety recall remedy, nor will they release my vehicle to a flatbed towing company, until an unrelated $5,000 civil dispute involving a loaner car is paid out of pocket. By conditioning a federal safety mandate and the physical custody of my vehicle on a separate civil debt, this dealership is violating the National Traffic and Motor Vehicle Safety Act (49 U.S.C. Chapter 301). The 1.5-year delay also completely violates the federal requirement to provide a safety remedy within a reasonable timeframe. I request federal intervention to force compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/25/2025· ELECTRICAL SYSTEMFire

  I own a 2018 Alfa Romeo Stelvio (VIN: [XXX] ) with approximately 102,000 miles. The vehicle recently experienced an electrical issue caused by a failed ground strap — a known problem in these vehicles that is widely reported by other owners. After the vehicle became inoperable, I observed smoke and visible signs of burned or heat-damaged wiring in multiple areas under the hood, including ground wires not located near the main strap and crumbling insulation on the ABS wiring in the front wheel wells. The vehicle was towed to an authorized Alfa Romeo dealership, where the ground strap was replaced. However, the dealer did not inspect or document the other visibly damaged wiring, despite my specific request and description of the safety issue. They claimed the vehicle showed no error codes and was safe to drive. My concern is that the failed ground strap caused additional electrical damage to safety-critical components like the ABS system, which may result in electrical fire, loss of braking, or other failures. Alfa Romeo appears to have updated the design of the replacement ground strap (now rubber-insulated), which suggests they are aware of the issue, but they have not issued a recall or TSB. I am filing this report to document the issue and request that NHTSA investigate. I believe this is a systemic problem that affects vehicle safety, and that Alfa Romeo and its dealerships are failing to address it adequately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/23/2021· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  During the recent rainfall the front passenger side suffered a massive water leak, causing that side of the cabin to flood possibly causing water damage as well. This happened while the car was stationary and also while in motion. This also cause electrical failure to multiple components of the car including the infotainment system, headlights, indicators, engine stop/go among others.

• 08/18/2026· ENGINE AND ENGINE COOLING

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving 30 MPH and depressing the accelerator pedal, several unknown warning lights were illuminated, before the vehicle went into LIMP Mode. The contact stated that there was a rattling sound coming from the turbo charger. A dealer was contacted. The vehicle was diagnosed, and it was determined that the turbo charger needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.

• 08/16/2024· ELECTRICAL SYSTEM,AIR BAGS,ENGINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated while driving 40 MPH and attempting to accelerate, the accelerator pedal travelled down to the floorboard, and the vehicle stalled. The ESC warning light, the check engine warning light, and other unknown warning lights were illuminated. Additionally, the message “Service Engine Soon" and other unknown messages were displayed. The contact was able to pull to the side of the road. The contact was able to restart the vehicle, and the contact drove to the residence. Additionally, the contact received notification of NHTSA Campaign Number: 24V510000 (Air Bags, Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact that the repair could not be covered because the vehicle was out of warranty. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

• 08/14/2025· UNKNOWN OR OTHER

  Odometer fraud car titled with 63789 when ecu reflect 81111 in computer of car and dealer selling it

• 08/10/2026· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle lost drive power. The message "Service Electronic Throttle" was displayed, and the check engine warning light was illuminated. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The dealer was contacted; however, the part to do the recall was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to state when parts would be available. The failure mileage was approximately 82,000.

• 08/07/2024· AIR BAGS,SEAT BELTS

  The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 24V510000 (Air Bags, Seat Belts); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 08/07/2018· VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

  THE FORWARD COLLISION WARNING SYSTEM ACTIVATED FOR NO REASON. AS I WAS STARTING TO ACCELERATE FROM A TRAFFIC LIGHT ON A CITY STREET IT CAME ON SUDDENLY AND RAPIDLY DECELERATED THE VEHICLE. LUCKILY NO ONE WAS BEHIND ME.

• 08/05/2026· ENGINE,FUEL/PROPULSION SYSTEM

  Car stalled on highway leaving my life at risk and dealer has no date to repair fuel line

• 08/05/2026· ELECTRICAL SYSTEM

  The contact owns a 2018 Alfa Romeo Stelvio. While the contact’s wife was driving at an undisclosed speed, another motorist informed the driver that there was smoke coming from under the hood of the vehicle. The vehicle was immediately parked and failed to restart. The contact was called to the scene and inspected under the hood of the vehicle and discovered smoldering and melted wires. The vehicle was later towed to the local dealer, who diagnosed the vehicle and determined that the chassis-to-engine grounding strap had failed due to corrosion and needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer and dealer were made aware of the failure but offered no assistance. The failure mileage was 54,000.

• 08/05/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  I went to start my car to head to work and the car did not start so i tried to start it again all of a sudden smoke started billowing out from the engine bay. it scared me bad i thought the car was going to catch on fire. I proceeded to have the car towed to the dealer where i was told that a ground strap on the transmission has failed causing the wiring in the engine bay ti burn up. I'm still waiting on a estimate of how much it will cost to repair the vehicle. i believe this is also a safety issue the car could have easily caught fire or died at a stop light causing a crash or road hazard.

• 08/05/2024· AIR BAGS

  We use our vehicle not only for our business but also share it on the Turo platform for rentals. Because of this recall our vehicle as been unlisted until the recall is fixed. It has now been over a month and we have received no solution to the safety recall issue. It’s not only costing us peace of mind as we need to continue using the vehicle ourselves but it’s also costing us money as we havnt been able to rent out the vehicle due to the safety recall not being addressed . We find this delay to be unacceptable

• 07/31/2026· FUEL/PROPULSION SYSTEM

  There is no fix for this. The fuel pump foe the Stelvio is recalled almost a year ago. The engine light comes on and the car is undriveable. I have paid for 2 new fuel pumps and control module (out of pocket) , and the check engine light will come back after a few weeks. The car is basically inoperable and bricked because of this, and Alfa has not resolved it. They should not be allowed to drag a recall out for years while owners suffer, and are in danger. Please hold Alfa Romeo accountable. It just happened again today (7/31/26) while my wife was on the highway. This is after paying thousands and thousands to resolve this whole Alfa Romeo doesn’t do anything to fix it. We are out of options.

• 07/30/2018· PARKING BRAKE,POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES

  WHILE I WAS DRIVING 15 MPH ON A PRIVATE ROAD, I SUDDENLY LOST POWER STEERING AND POWER BRAKES. I MANAGED TO BRING THE CAR TO A STOP, BUT I COULDN'T ENGAGE THE PARKING BRAKE, SHIFT OUT OF DRIVE, OR TURN THE CAR OFF. THE ELECTRONIC SHIFTER, ELECTRONIC PARKING BRAKE, AND ELECTRONIC STARTER WERE ALL UNRESPONSIVE. I SAW NUMEROUS WARNING MESSAGES ON THE DASHBOARD. ONE OF THEM SAID "SERVICE SHIFTER. CONTINUE IN D. DO NOT SHIFT OR TURN ENGINE OFF", BUT IT DIDN'T TELL ME WHAT I COULD DO TO RETURN THE CAR TO A SAFE STATE. I KEPT MY FOOT ON THE BRAKE AND CALLED ROADSIDE ASSISTANCE. I ASKED THEM WHAT MY OPTIONS WERE, AND THEY TOLD ME THAT I COULD WAIT UNTIL THE CAR RUNS OUT OF GAS. I'M NOT SURE WHAT I DID, BUT I EVENTUALLY GOT THE CARE TO SHUT OFF, BUT IT STAYED IN NEUTRAL, SO I STILL COULDN'T TAKE MY FOOT OFF OF THE BRAKE. EVENTUALLY A TOW TRUCK ARRIVED AND GOT THE CAR IN TO PARK BY ENTERING THE CARGO AREA BY CLIMBING THROUGH THE BACK SEAT,DISCONNECTING THE BATTERY, AND RECONNECTING IT.

• 07/29/2026· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle lost power while accelerating. The check engine and throttle body warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the failure was related to the recall; however, the dealer confirmed that parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.