2018 Alfa Romeo Giulia

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/22/2019· VEHICLE SPEED CONTROLCrash

  I WAS DRIVING MY 2018 ALFA ROMEO GULIA QUADRIFOGLIO IN HOUSTON, TX. I WAS HEADING ON I-45 SOUTH TOWARDS THE RAMP TO MERGE ON GRAND PARKWAY 99 WEST. ONCE I WAS ON GRAND PARKWAY 99, I PLACED THE CAR ON CRUISE CONTROL. IT WAS RAINING VERY HARD AND THE CRUISE CONTROL WAS SET TO 75MPH. SUDDENLY, THE CAR HYDROPLANED AND SKIDDED SLIGHTLY TO THE LEFT AND THEN IT SPUN RIGHT 180 DEGREES FACING THE ONCOMING TRAFFIC. NOW THE CAR IS GOING IN REVERSE FROM THE FASTEST LANE, TO THE SLOW LANE, THEN THE EMERGENCY LANE, AND FINALLY; THE CAR SLID OFF INTO THE SLOPING WET GRASS DOWN THE SIDE OF THE FREEWAY AND CAME TO A STOP WHEN THE SLOPE SUBSIDED INTO A FLAT GRASS SHOULDER. IT WAS ALMOST 200-300+ FEET AWAY FROM THE INCLINING CONCRETE FREEWAY WHERE I SLIPPED OFF ONTO THE WET GRASSY SLOPING SHOULDER. THE CAR CAME TO A STOP AT THE FLAT PART OF THE GRASSY SHOULDER AFTER AN ESTIMATED 200-300+ FEET. I HAVE ATTACHED THE IMAGE SHOWING THE START OF THE SKID TO THE FINISH WHERE THE CAR STOPPED FACING BACKWARDS. I WAS ABLE TO DRIVE THE CAR OFF THE GRASS ONTO THE SERVICE ROAD AND WENT TO AN EXXON GAS STATION (22207 KUYKENDAHL RD, SPRING, TX 77379) TO CHECK THE DAMAGE. LUCKILY I WAS NOT HURT AND I DID NOT NOTICE ANY DAMAGE TO THE CAR. IN MY EXPERIENCE, I FIRMLY BELIEVE THAT THE CRUISE CONTROL IN THE CAR DISABLED ALL TRACTION CONTROL AND ANTI-SLIP CONTROL IN THE CAR BECAUSE NON OF THOSE SYSTEMS INTERVENED. WHEN THE CAR STARTED TO HYDROPLANE, I DID NOT FEEL THE TRACTION CONTROL STOP THE FASTER WHEEL FROM SPINNING, AND BEFORE I COULD DO ANYTHING THE CAR SKIDDED 180 DEGREES WITHOUT ANY ANTI-SKID CONTROL INTERVENTION. A POSSIBLE CONCLUSION IS THAT THE WHEEL SPEED SENSORS ARE DEDICATE TO THE CRUISE CONTROL AND NOT SENDING ANY DATA TO THE SAFETY SYSTEMS SUCH AS ANTI-SLIP, ANTI-SKID, OR YAW AND PITCH SENSORS THAT KEEP A MODERN CAR ON THE INTENDED PATH.

• 12/18/2024· FUEL/PROPULSION SYSTEM

  Vehicle has a known issue with fuel pump which causes it to randomly turn off. Mine stopped in the middle of a busy service road and I had to get towing and police to help with getting the car off the road and diverting traffic. The car has turned off several other times as well, but the incident on 8/8 was documented via tow receipt.

• 12/11/2018· VISIBILITY

  TL* THE CONTACT OWNS A 2018 ALFA ROMEO GIULIA. WHILE DRIVING 40 MPH, A LOUD ABNORMAL NOISE WAS HEARD COMING FROM THE VEHICLE. THE CONTACT NOTICED THAT THE SUN ROOF WAS SHATTERED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO HERITAGE ALFA ROMEO (11216 REISTERSTOWN RD, OWINGS MILLS, MD 21117, (855) 529-3222) WHERE THE SUN ROOF WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 2,900.

• 12/10/2024· ELECTRICAL SYSTEM

  Alfa Romeo Giulia (and Stelvio) models have an exposed powertrain ground strap under the vehicle body. Because of the exposed position of the ground strap it is prone to corrosion which causes the fine wire braid of the ground strap to become brittle and break. Breaking of the strands of wire is further accelerated due to the acute 90 degree bend in the ground strap routing resulting in wire fatigue. When the ground strap fails it is typical the vehicle may not start. With continued attempts to start, alternate grounding paths may be sought by the current from the starting circuit. This results in substantial and expensive damage to other wiring and electrical components within the engine bay. Alfa Romeo is aware of design flaw of exposed ground strap and the resulting damage from their choice of placement (and lack of protection of the ground strap). Both my 2018 Giulia nd 2023 Stelvio Quadrifoglio have this exposed ground strap design. My 2018 Giulia has failed ground strap. Alfa Romeo will advise that washing the underside of the vehicle is required to keep ground strap free of corrosion. This is not a solution and underbody rinses are typically one spray bar in the car wash and this is insufficient to clean the woven ground strap braid. Alfa Romeo should be forced to issue a recall and remedy this design oversight.

• 11/30/2018· VISIBILITY/WIPER

  SINCE PURCHASING THE CAR IN JAN 2018, I'VE HAD TO REPLACE THE WINDSHIELD TWICE DUE TO CRACKING. I HAVE DRIVEN THE SAME ROUTE FOR 10 YEARS IN VARIOUS CARS AND NEVER HAS THIS HAPPENED SO IT'S NOT AN ENVIRONMENTAL ISSUE. THE CRACKS APPEAR SUDDENLY AND TRAVEL ACROSS THE WINDSHIELD QUICKLY (FROM THE BOTTOM UPWARD OR FROM THE EDGES) WHEN THE CAR IS STATIONARY OR THERE'S A CHANGE IN WEATHER.

• 11/27/2023· STEERING

  Temporarily loas power steering (or so it seemed) during highway speed driving. The car steering wheel jerked in my hands and an ATV fault code illuminated on the dash. I managed to keep the car in control, but it required a lot of physical effort. I was decelerating when it happened (brakes were being applied).

• 11/12/2025· UNKNOWN OR OTHER

  After towing my vehicle to Alfa Romeo of Mariettea on November 4th for recall 82B (seatbelt), my car immediately developed throttle hesitation, check-engine light, and start/stop warning light. These issues were not present before the service. Recall 93C (fuel delivery module) remains open, but the timing of these new problems indicates they arose from the 82B service. The dealership and Alfa Romeo have refused interim assistance, leaving my car unsafe to drive. Requested Actions: 1. Inspection and repair of the post-service throttle and engine issues. 2. Interim transportation (loaner or reimbursement) while 93C is pending. I have documented all communications with the dealership and Alfa Romeo Customer Care. The problems appeared immediately after the 82B recall service and were not present before.

• 11/10/2024· FUEL/PROPULSION SYSTEM

  The vehicle has a CEL, takes longer than normal to start and shakes at idle. It has also lost motive power while idling and stalled a few times while on the road. I believe this is related to a low-pressure fuel pump failure. The car was taken to the dealership where they confirmed a failing fuel pump. Alfa Romeo released a Technical Service Bulletin but the dealership quoted over $2,000 for the repair with no ETA on the part which should be a recall. Please add this complain to the ongoing investigation and hope to have a resolution soon for my own safety.

• 11/06/2018· POWER TRAIN,SEAT BELTS

  AFTER SEVERAL ISSUES WITH PADDLE SHIFTERS THE RIGHT REAR SEAT BELT FAILED. IT WOULD NOT RETRACK PROPERLY AND THEN TOTALLY LOCKED IN THE MID POSITION MAKING IT TOTALLY UNUSABLE TO SECURE MY 8 YEAR OLD CHILD. THE CAR IS ABOUT THREE WEEKS OLD WITH APPROX. 700 MILES

• 11/05/2025· ENGINE

  This is a follow up for complaint #11693742 issued on October 16, 2025. I picked up my car from the dealership (Jim Ellis Alfa Romeo Atlanta) after the nearly $5k repair that they stated was due to an Oil Pump failure not the Fuel Pump failure as indicated by the Stellantis Recall, only to find that they falsified information on the paperwork description. They left out the information that I gave them when I told them that the dashboard displayed the following warning lights: ETC, Auto Start-Stop Unavailable, and Check Engine. They wrote only the Check Engine light was reported. They falsely stated that only the Check Engine light was illuminated, when in reality all three of the aforementioned warning lights were displayed the very morning that I had the car loaded on the tow truck. Please investigate Stellantis/Alfa Romeo for possibly misleading and falsifying information in order to have consumers foot the bill for repair for a fix for power loss due to a Fuel Pump failure when in actually it is an Oil Pump failure, or an Oil Pump failure that they are falsely claiming a Fuel Pump issue. This repair cost me about as much as the cost of a used 2018 Alfa Romeo, and the company is making enough money of this repair such that when they do honor the recall repair, then it won't cost them anything. It seems easy to me that if they is a Fuel Pump failure that is resulting in a recall, then the easy fix (that Stellantis should cover the cost) is to replace the fuel pump.

• 11/02/2023· ENGINE

  Head Gasket blew/failed well before it should have. This caused oil to leak under the car and in the entire engine, creating a safety hazard and environmental hazards. Engine is subject to overheating. (Engine needs full replacement due to this faulty equipment).

• 10/31/2018· SERVICE BRAKES

  AUTOMATIC EMERGENCY BREAKING OCCURRED WITH NO WARNING ON A ROAD, THAT WHILE LANES WERE CLOSED DUE TO CONSTRUCTION, HAD NO OBSERVABLE OBSTRUCTIONS INCLUDING STEEL PLATES, ETC. THE WARNING OCCURRED A FRACTION OF A SECOND PRIOR TO THE BRAKING AND I ONLY NOTICED IT IN RETROSPECT. THE CAR WAS TRAVELING 25 - 30 MPH ON A CITY STREET THAT HAD ITS RIGHT LANE BEING RESURFACED. THERE WERE NO CARS IMMEDIATELY IN FRONT OF ME AND THE CAR BEHIND ME WAS SEVERAL CAR LENGTHS BACK. THERE WERE TEMPORARY LANE MARKERS DIVINGING THE NORTH AND SOUTH BOUND LANES. I'M UNSURE IF THESE ARE MADE OF METAL OR PLASTIC BUT THEY ARE NO MORE THAN 10 IN^2.

• 10/28/2024· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  Fuel pump issues have caused my car to create unsafe driving. My etc system kicks on and off while driving which causes massive loss of power then accelerates to the point of red line. it's like I'm putting my pedal to the floor in traffic when trying to inch up. Fuel lump is on order for me but has been on back order for more than 3 months with no date of shipment. Dealership said car was OK to drive but could ultimately cut off and not start back up till this part is replaced.

• 10/22/2024· ENGINE,FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE

  My fuel pump has been failing multiple times over the last 4 months. It has left me stranded in the middle of intersections, freeways, and highways on multiple occasions that has cause back up traffic and areas of the road completely closed until I can move my car. I have had this car diagnosed twice with a certified mechanic shop and a master tech with these issues and it is confirmed both times that I need a new fuel pump. When contacted Alfa Romeo/ Mike Ward dealership for review, diagnostic scans, and part replacement they told me it could be a couple of weeks until my car can even be looked at. Both my shop and the dealership have told me that this part is on back order with no ETA and no possible way of getting that part so my car can be functional. These issues first appeared when I would accelerate from a complete stop and it would take a few seconds for my car to begin moving. This slowly progressed into my check engine light, auto start/ stop error light, electric throttle error light, and front crash detection light have all turned on and remained on for about 2 months until the car began dying in the middle of the street. This had come to be so servers that the car is now no longer drivable and each time it is driven it dies within a few minutes of driving.Again since there is no ETA there is no way for me to fix my car, this is my only mode of transportation and it has left me ain multiple dangerous situations and now with no transportation now that Alfa Romeo is refusing to make the parts needed for repair.

• 10/21/2025· EXTERIOR LIGHTING

  At night, with headlights set to AUTO, the headlights (right and left) will randomly turn of and on while driving. This could render my vehicle momentarily invisible to other drivers around me. Dealer confirmed the issue is the headlights. 70,000 mile service was just completed prior the the issues fist occurrence. No warnings or messages before the first incident.

• 10/19/2022· ELECTRICAL SYSTEM

  My BCM was shorted out from water damage from outside the car. The dealer says he can't repair it under warranty because Alfa Romeo will not authorize him to. I have to pay 1200 out of pocket for something that should be covered by warranty. The car will start, but the front headlights won't go out, the turn signals won't work, brake lights don't work right. Check engine light comes off and several functions are disabled. I'm not sure the backup camera, blindspot monitoring are working correctly.

• 10/18/2025· ENGINE

  On multiple occasions over last 3 years, vehicle has lost power while driving. Each repair service has credited it to batteries needing replacement and losing power. Have replaced batteries and kept them plugged in when car is parked at home. No longer driving car as it is not safe.

• 10/16/2025· ENGINE

  While driving 15-20mph, warning lights: Check Engine, Auto Start-Stop Unavailable, and ETC, all began to sequentially cycle. The car's ability to accelerate significantly decreased, even achieving 30-40mph was laborious. Once on the highway, the car was significantly slower and the power was obvious. The car took a long time to reach 55mph and was going over that speed. I had the car towed to dealership the next day, for I was afraid that it was the fuel pump failure and felt the car wouldn't make the 75mi drive. After a few days, the dealership said that the ETC Code wasn't the fuel pump, but the oil pump causing the power loss. They said that Alfa Romeo had many models have oil pump failures, and it requires engine tear down to replace the oil pump and cost about $5000. Alfa Romeo Customer Care stated there is no recall for this problem, so one has to pay the $5k for the repair. I think Alfa Romeo knows the true cause of the power loss problem and the remedy, and using the oil pump as a loophole to make the consumer pay for a problem that they should cover the cost of repair. My car is at Jim Ellis Alfa Romeo in Atlanta, Georgia.

• 10/04/2024· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Giulia. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that the failure had occurred twice. In addition, the contact stated that the failure occurred while driving on the highway. The vehicle was taken to the dealer where it was diagnosed with a fuel pump failure. The contact was informed that the fuel pump and the fuel pump module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 29,000.

• 10/03/2023· ELECTRICAL SYSTEM

  The contact owns a 2018 Alfa Romeo Giulia. The contact stated while attempting to start the vehicle, the vehicle failed to start. The vehicle was jumpstarted. The vehicle was taken to the dealer, where the battery was replaced; however, the failure recurred. The contact stated that upon pressing the Start button, the instrument panel lights illuminated, but the vehicle failed to start. The contact then pressed the Off button to turn off the vehicle, but the vehicle failed to turn off until the battery was completely drained. The vehicle was jumpstarted and taken to the dealer, where it was diagnosed but the cause of the failure could not be determined. The battery was recharged. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the vehicle failed to start the following day. The vehicle was taken to the dealer, where it was diagnosed but the cause of the failure could not be determined. The dealer informed the contact that the battery needed to be recharged. The failure mileage was approximately 38,000.

• 10/01/2018· UNKNOWN OR OTHER

  DURING A HEAT WAVE I WAS PUTTING MY 4 WEEK OLD SON IN HIS CARSEAT IN THE BACK OF THE CAR, AND PRESSED THE REMOTE START BUTTON TO START THE AIR CONDITIONING. I HAD ALSO PLACED MY KEY FOB INSIDE THE DOOR OF THE CAR TEMPORARILY, AND FORGOT ABOUT THIS AS I CLOSED THE DOOR. THIS SERIES OF EVENTS TRIGGERED ALL THE DOORS OF THE CAR TO LOCK - WITH MY KEY AND BABY INSIDE, REQUIRING US TO BREAK THE WINDOW (NO SMALL FEAT - MY HUSBAND SUFFERED A HAND LACERATION AS HE BROKE THROUGH THE WINDOW) TO SAVE OUR SON. FORTUNATELY I DID NOT ALSO LOCK MY CELL PHONE IN THE CAR, WHICH WOULD HAVE CAUSED ME TO HAVE TO LEAVE MY SON UNATTENDED INSIDE THE VEHICLE TO GO GET HELP. THIS INCIDENT IS REPRODUCIBLE ON MY AND OTHER ALFA ROMEO GIULIA'S, AND I HAVE VIDEO FOOTAGE OF THIS MECHANISM, WHICH I AM TOLD BY THE FCA REGIONAL TECHNICAL ADVISOR IS COMPLETELY SAFE AND NORMAL. THERE IS NO DISCLAIMER ANYWHERE ON THE VEHICLE OR THE KEY TO ALERT DRIVERS OF THIS POTENTIALLY CATASTROPHIC RISK. THIS COULD RESULT IN SERIOUS INJURY OR DEATH OF PETS, CHILDREN OR DISABLED PERSONS TRAPPED INSIDE THESE VEHICLES WAITING FOR HELP TO ARRIVE. *DT CONSUMER STATED WHEN SHE PRESSED THE REMOTE START BUTTON THE DOOR LOCKS. UPDATED 12/06/18 *JB *DT*JB

• 09/30/2025· SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

  The contact's husband owns a 2018 Alfa Romeo Giulia. The contact stated that while her husband was driving 60 MPH, several braking system warning lights illuminated on the instrument panel, including the ABS warning light. Upon depression of the brake pedal, the brake pedal depressed to the floorboard, and the braking system failed to operate as needed. Due to the failure, the contact's husband activated the hazard lights and coasted the vehicle to the residence. Upon exiting the vehicle, the contact saw brake fluid leaking underneath the passenger’s side of the vehicle. Due to the failure, the vehicle was towed to the dealer; the contact was informed that the hydraulic braking system had failed and needed to be replaced. The dealer also informed the contact that the vehicle was previously serviced under NHTSA Campaign Number: 18V828000 (Engine and Engine Cooling, Service Brakes, Hydraulic); however, the vehicle was no longer covered under the recall. The manufacturer was not notified of the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 66,000.

• 09/27/2023· VISIBILITY/WIPER

  When attempting to close an open sunroof, something failed and the sunroof will no longer move. I had to drive 2 hours at highway speeds with the open panoramic sunroof, which caught a lot of air and which I was worried would blow off or be damaged by debris since it was now raised up and exposed. A mechanic has looked at the sunroof and is unable to operate it manually or electronically. Alfa Romeo does not have a manual method to close the sunroof in case of failure, and the electric motor only makes a flapping sound when used, as if the cable connecting the motor and the sunroof had snapped. There were no warnings or indications that anything was wrong or that any issues were developing. I normally do not use the sunroof and opened it for the first time when this happened. The cost to repair this issue seems excessive, on par with a full turbocharger replacement.

• 09/25/2024· AIR BAGS,SEAT BELTSCrash

  I was in an accident with another vehicle where my car rear ended theirs. It a pretty bad damage because my car is totaled. The seatbelt never locked and my airbag never deployed, causing me to go headfirst into my wheel and followed my chest. I was escorted to the hospital due to those injures. I was never notified of a recall from either dealership, which they have failed me because there was nothing there to support my body. There were no warning signs or anything of that sort to let me know there was an issue. I never heard anything from Alfa Romeo or Reed Nissan after they did an inspection on my vehicle. I am highly disappointed and suffering from traumatic pain and injury from this.

• 09/24/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Giulia. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The check engine and service electric throttle warning lights were illuminated. The contact stated that the failure had occurred while it was hot outside. The contact was stranded and sat in the inoperable vehicle. In addition, the contact was pregnant and very uncomfortable sitting in an inoperable vehicle. The contact waited in the vehicle while waiting for the tow truck. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,500.

• 09/19/2025· UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

  There were several code error messages describing a fuel pump issue that also creates other engine components to fail. For my concern of the safety my life, I paid to tow my vehicle directly to the car dealership service department to be inspected and am currently waiting to be contacted of their findings. In order to be able to move my car from blocking traffic and out of harm's way, the error codes had to be erased. I took pictures of the error codes prior to erasing and provided them to the service department for their review. Warning lamps and messages flashed simultaneously when my vehicle ceased to function. While driving my 2018 Alfa Romeo Giulia Quadrifoglio September 16, 2025, the engine ceased to function under legal normal driving conditions for no apparent reason. The engine immediately turned itself off, and both the steering wheel and vehicle was locked in place (unable to move). This event jeopardized me, and other affected drivers' lives. It was only due to the quick reaction of defensive driving attentiveness that prevented the potential collision of multiple vehicles including loss of life/lives. I had taken my vehicle to the same service department previously in November 2024 for the exact same type of issue (ceased vehicle, locked in place steering wheel and vehicle). However, because error messages were erased, the service department would not be able to know what steps were needed to fix the problem and that I should bring back my vehicle with error codes intact should this occur again. I have this in writing on my invoice. No police report involved as no physical accident/damage occurred, and everyone who was involved including myself left without further incident, and very traumatized.

• 09/19/2024· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Giulia. The contact stated while driving approximately 15 MPH, the vehicle lost motive power and stalled and failed to immediately restart. The vehicle was eventually restarted; however, while driving approximately 50 MPH on a freeway, the vehicle stalled again. The vehicle was towed to the local dealer who diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not yet repaired. The contact was informed of the NHTSA Action Number: PE24003 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 19,200.

• 09/18/2025· FUEL SYSTEM, GASOLINE

  The contact owns a 2018 Alfa Romeo Giulia. The contact stated that while driving 60 MPH, the vehicle lost automotive power, and the contact pulled over. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the vehicle needed to be taken to the dealer to be diagnosed. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 63,000.

• 09/17/2025· STEERING,ENGINE,FUEL/PROPULSION SYSTEM

  UNKNOWN, driving down a busy road and check engine light popped up and service electronic throttle system as well car stalled in the middle of the road and would not start when I tried to it would crank but not start. I noticed this incident was occurring in the past when I was close to half a tank of gas but now it’s occurring when I’m at 3/4 tank. I already addressed the possible issue of being a weak battery as I had to spend $250 on a new battery and the next day it happened again. After going through the forums and speaking with dealers they all have the same diagnosis that the fuel pump is going out. I would buy a fuel pump and replace it myself but you have to replace the module with it and have to have a very expensive scanner to sync the two together.

• 09/04/2021· ELECTRICAL SYSTEM,SERVICE BRAKES

  Components that failed were both the rear brake warning sensor, rear brake rotors and on further inspection by Benson Alfa Romeo dealership, the front brake rotors had failed even though the front sensors triggered the visit to the dealer for routine service. The full failure of the rear brake rotors that is occurring (as I live in the mountains) would have been catastrophic. The dealership diagnosed the problem and replaced all four rotors, pads and sensors. The event was reported to Chrysler and filed as a warranty issue but ask that I pay as Chrysler declines to cover these items. The system alerted and I called the dealer Benson Alfa and took the first available appointment as it appeared as a routine warning, not a catastrophic failure. Even under full warranty for another two years, Chrysler declined to cover this event citing their worn part warranty provision of 12 months and 12,000 miles.

• 09/04/2020· SERVICE BRAKES

  I WAS ADVISED BY THE ALFA ROMEO DEALERSHIP THAT THE REAR BRAKE PADS AND ROTORS WILL NEED REPLACEMENT, WHILE THE FRONT BRAKES ARE FINE. THIS OCCURRED AT 31,500 MILES. ACCORDING TO THE DEALERSHIP, THIS IS COMMON AND REAR BRAKES ON THIS CAR TYPICALLY NEED REPLACEMENT AT 20,000 MILES. ALFA'S CUSTOMER SERVICE CONFIRMED THIS. THE DEALER ALSO STATED THAT THIS IS RELATED TO THE ELECTRIC PARKING BRAKE. IN MY OPINION, THIS IS A SAFETY ISSUE AS A TYPICAL DRIVER DOES NOT EXPECT BRAKE REPLACEMENT AFTER SUCH A SHORT PERIOD OF TIME. IF THIS IS RELATED TO THE ELECTRIC PARKING BRAKE, AS ADVISED BY THE DEALER, THE REAR BRAKE PADS MAY BE DRAGGING AND HEATING THE ROTORS WHILE THE CAR IS IN MOTION, THEREFORE REDUCING THE STOPPING POWER WHEN NEEDED. I BELIEVE THIS IS EITHER A POOR DESIGN, POOR MATERIALS AND WORKMANSHIP OR A DEFECT IN THE PARKING BRAKE AND SHOULD BE ADDRESSED. CHECKING THIS ONLINE, I FIND THIS IS A COMMON ISSUE AND I FEEL IT SHOULD BE INVESTIGATED BEFORE IT LEADS TO AN ACCIDENT.

• 08/22/2023· ENGINE

  While driving on the interstate, the car triggered a check engine light, reported that start/stop was unavailable, and ETC throttle needed servicing. Error codes report a turbocharger underboost. This is a known issue experienced by Alfa Romeo Giulia owners involving the turbo wastegate actuator. The actuator arm gets worn at the linkage to the wastegate, introducing play and reducing turbo pressure. There was no prior warning that this would happen, dealer did not confirm this issue until the second time the car was serviced for this issue, and the only stated solution is to pay for and replace the entire turbocharger.

• 08/16/2024· FUEL/PROPULSION SYSTEM

  After a 3 hour drive I had parked curb-side on a busy street to go into a store. I returned within 10 minutes, started the car, and as I was pulling out into traffic the car stalled after moving about 20 feet. All the dash lights came on and it would crank but not start. The car is in the right lane of a busy 3 lane road at this time. Also, after it stopped rolling it put itself in PARK, and because it has electronic transmission selection, I could not get it into Neutral to push it out of the way without the engine running. . The situation was very perilous. A wrecker came and got the car home. Once home I pulled the OBD codes myself and found P0087 Low Fuel Pressure and P008A also Low Fuel Pressure. After researching I have found that this is a known defect in these cars going on several years now. What is the delay in requiring Alfa to issue a recall of these faulty fuel pumps and fuel modules? Had this pump failure happened on an interstate at highway speeds it could have been fatal.

• 08/14/2022· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  The light flashes warning ?? the whole time while it's driving

• 08/14/2022· ELECTRICAL SYSTEM,AIR BAGS

  The airbag light keeps flashing over and over like it was in an accident but the car is brand new

• 08/13/2024· FUEL/PROPULSION SYSTEM

  While in drive at speed the car would stall and all warning lights would indicate errors such as service engine, auto stop start fault, electronic throttle control, among others. The car could not be put into neutral, and would not restart for several minutes ( 30 minutes). This problem had occured previously (three times before).

• 08/12/2024· UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  On July 2, vehicle would not start. When pressing start button it continuously would try to crank but would not start. Check engine light, auto start on/off light, and ETC light came on. After 30-40 minute wait time, car started. Called dealer the following day but after multiple starts the lights/codes on dash went away. Dealer had no way to read the codes. On August 12, car started with the aforementioned lights turned on but after placing car in reverse and backing up some 10 feet it turned off. Car could not start again displaying the same symptoms as on July 2. This happened in a busy Costco parking lot blocking people from being able to get out of their parking spaces. No way to place car into Neutral to push out of way of traffic. After about 20 minutes or so, it managed to start. Drove to local Autozone to get codes read. P0087, P008A codes relate to low fuel pressure Next stop is dealership and hoping the lights do not turn off before dealer can look at. Both times this happened the car went on longer distance trips in hot weather in excess of 95 degrees Fahrenheit.

• 08/11/2021· SERVICE BRAKESCrash

  I was in the 10 East, in upland, 300 yard after Euclid exit, I just got into the freeway, there was a lot of traffic, we were going slow and my breaks totally stop working!!!! And I hit the car in front of me !!!

• 08/09/2021· SUSPENSION

  The drivers side front control arm failed. Had the control arm failed during operation it could have resulted in the loss of life. The issued has been confirmed by a dealer. The vehicle has been inspected by the dealer. See additional details below: The drivers side front control arm failed Sunday 08.07.2021 resulting in the car collapsing to the ground. An issue with left from driver side control arm (sounds of metal on metal rubbing from the control arm) was brought to the service center's attention on 07.09.2021 and the service center diagnosed my complaint as being related to a defective control arm ball joint on the right front passenger side and the car was returned to me while the replacement part arrived. Handling of the car deteriorated significantly on 08.06.2021 on my way to and from work. I called a tow truck to drop the car off as the service center on 08.07.2021. During movement in reverse gear to position the car onto the tow truck, the front control arm failed resulting in the car collapsing to the ground. Had this failure occurred during vehicle operation it could have resulted in the loss of life. The vehicle is currently at the service center for repairs.

• 08/06/2024· ELECTRICAL SYSTEM,AIR BAGS

  The contact owns a 2018 Alfa Romeo Giulia. The contact stated that while operating the vehicle, the horn was inoperable and there was no audible sound while depressed. The contact stated that the failure was intermittent. The vehicle was taken to the local mechanic who diagnosed that the horn failure was caused by an air bag clock spring failure. The vehicle was not repaired. The manufacturer and local dealer were not yet contacted regarding the failure. The failure mileage was 55,000.

• 08/01/2023· ENGINE,FUEL/PROPULSION SYSTEM

  My son was driving the vehicle on I75 at 68-70 MPH yesterday around 5:45 pM. The car started stalling.I was driving my other vehicle Volvo XC 90 right behind. I noticed his vehicle slowed downs drastically and within 4 seconds he was on left shoulder and stalled completely and would not stop. The vehicle went from 70-40-20-0 all in 4 seconds. Something very similar happened back in May of 2022. The Alfa Romeo dealer replaced the fuel pump in September/October of 2022. Stalling happened again yesterday. This is a very dangerous and known issue and Alfa Romeo manufacturer is not doing any recall or addressing this issue. Yesterday’s incident would have custard an accident which would have lead to injuries or even worse fatality When I called Alfa Romeo manufacturer’s customer service all they had to say was that the vehicle is not under warranty and they won’t cover the repairs. Please do a major recall on Alfa Romeo vehicles and make the manufacturers be responsible for the issue and make them to do a recall & repair. This is a very serious issue with Alfa Romeo cars. Stalls in the middle of the road.

• 07/31/2025· FUEL/PROPULSION SYSTEM

  When driving on the highway, the car completely stalled. Without warning service engine and service transmission light illuminated on instrument cluster. P008a low fuel pressure. Safety was put at risk. Unable to move car safely away from traffic at night. The car was just serviced at an alpha romeo dealership three weeks prior with similar symptoms for the 3rd time. After brief research, this seems to be a common issue with these car.

• 07/24/2026· ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,ENGINE

  The contact owns a 2018 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The contact stated that while driving at various speeds on approximately five occasions, the vehicle went into LIMP Mode, lost motive power, and stalled on some occasions. The check engine warning light and the Electronic Throttle Control (ETC) warning light were illuminated twice. The contact stated that while attempting to accelerate, the vehicle failed to accelerate above 30 MPH. The vehicle was taken to an independent mechanic, where it was diagnosed and determined to have a Co pump module failure because the pressure was too high and the Co pump module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,100.

• 07/20/2018· UNKNOWN OR OTHER

  THE CAR HAD APPLE CAR PLAY AS A FEATURE IN THE BASE PRICE. THE CAR PLAY DOESN'T WORK, AND AFTER OVER A MONTH THE COMPANY HAS YET TO FIX WHAT I HAVE LEARNED IS A KNOWN ISSUE BY THE COMPANY. THIS IS A HARDWARE AND SOFTWARE FIX AFFECTING VEHICLES MANUFACTURED BEFORE 7/2017, WHICH MINE WAS. THE DEALERSHIP, ANAHEIM, CA, NOT ONLY DIDN'T INFORM ME OF THIS PROBLEM PRIOR TO MY PURCHASE, BUT HAS BEEN TERRIBLY UNHELPFUL IN CORRECTING IT. I HAVE BEEN IN CONTACT WITH AF CORPORATE FOR OVER A WEEK, WITH NO FORSEEABLE APPOINTMENT TO CORRECT THE PROBLEM. I HAVE FILED COMPLAINTS WITH THE FTC AND CA ATTORNEY GENERAL.

• 07/17/2024· FUEL/PROPULSION SYSTEM

  While driving at approximately 45mph, the car was suddenly dropped into "limp mode" which caused a rapid deceleration, loss of power, and required pulling onto the shoulder as the car refused to accelerate. In addition, the check engine light illuminated, along with warnings that the start / stop system was unavailable and to service the electronic throttle. Restarting the car did not fix the condition. It's also important to note the car had approximately half a tank of gas. When serviced, the technicians reported that the P008A and P062A were present, indicating an issue with the fuel pump. The fuel pump was replaced (see attached files).

• 07/17/2020· POWER TRAIN

  TL* THE CONTACT OWNS A 2018 ALFA ROMEO GIULIA. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE INSTRUMENT PANEL BECAME INOPERABLE AND THE VEHICLE DECELERATED INDEPENDENTLY WITHOUT WARNING. THE CONTACT WAITED FOR AN HOUR BEFORE RESTARTING THE VEHICLE AND DRIVING TO HIS DESTINATION. THE VEHICLE WAS TAKEN TO MASERATI OF ST. PETERSBURG LOCATED AT 3033 GANDY BLVD, PINELLAS PARK, FL 33782, (727) 374-4500, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE LOW-PRESSURE FUEL PUMP AND AN UNKNOWN WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO ALFA ROMEO FORT LAUDERDALE LOCATED AT 5730 N. FEDERAL HWY, FORT LAUDERDALE, FL 33308, (754) 238-0322 HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT STATED ON A SECOND OCCASION WHILE DRIVING 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. WHILE ATTEMPTING TO PULL OVER, THE VEHICLE INDEPENDENTLY RESTARTED. THE VEHICLE WAS AGAIN TAKEN TO MASERATI OF ST. PETERSBURG WHERE AN UNKNOWN WIRING HARNESS WAS REPLACED. THE CONTACT WAS ALSO INFORMED THAT THERE WAS ALSO AN UNKNOWN ISSUE WITH THE BATTERY. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS THEN TAKEN BACK TO MASERATI OF ST. PETERSBURG FOR SOME MINOR ELECTRICAL ISSUES. THE MECHANIC PERFORMED A SOFTWARE UPDATE AND RECONNECTED AN UNKNOWN WIRING HARNESS. THE CONTACT STATED ON JUNE 28, 2020 WHILE APPROACHING A TRAFFIC LIGHT, WHEN HE HEARD AN ABNORMAL NOISE AND WAS UNABLE TO SHIFT OUT OF PARK. THE CONTACT WAITED FOR AN HOUR, DISCONNECTED THE BATTERY, AND WAS ABLE TO RESTART THE VEHICLE AND DROVE TO HIS DESTINATION. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 5,596.

• 07/15/2019· POWER TRAIN

  I RECENTLY PURCHASED THIS 2018 ALFA ROMEO GUILIA USED. I WAS NOT TOTALLY FAMILIAR WITH THE FUEL SYSTEM WARNING, AND I BELIEVED I HAD AT LEAST 20-25 MILES OF FUEL REMAINING. I MAY HAVE MISCALCULATED MY MILEAGE, BUT IN ANY EVENT, I RAN OUT OF FUEL (I WAS CLOSE TO A GAS STATION AS WAS ABLE TO GET THE FUEL AND START THE CAR WITHIN 20 MINUTES OVERALL). THE CAR STOPPED, AND THE IT AUTOMATICALLY ENTERED PARK MODE, PREVENTING IT FROM BEING PUT INTO NEUTRAL AND PUSHED TO THE SIDE OF THE ROAD, AS REQUIRED BY LAW, OR PICKED UP FOR ROAD SERVICE UNLESS THE TOWER HAD A WHEEL DOLLY, TO HANDLE A 4-WHEEL DRIVE CAR. I THINK THIS IS A CRITICAL SAFETY HAZARD. I RESEARCHED THE ISSUE. THE ONLY SOLUTION I COULD FIND, NOT DOCUMENTED IN THE OWNER'S MANUAL, IS A LEVER ON THE TRANSMISSION, LOCATED UNDER THE CAR, WHICH CAN BE PUSHED UP ONLY WITH A PARTICULAR MACHINE SCREW. OBVIOUSLY THIS CANNOT BE DONE WITH A CAR STUCK ON THE ROAD. I CALLED ZF, THE MAKER OF THE TRANSMISSION, WHICH IS USED IN MILLIONS OF CARS. ZF ADVISED THAT I WAS CORRECT, AND THAT MANUFACTURERS CAN PUT IN IN-CAR ACCESS TO THE LEVER OR SOFTWARE SOLUTIONS TO PUT THE CAR IN NEUTRAL, BUT THAT IS THE RESPONSIBILITY OF EACH MANUFACTURER. I CALLED FCA, THE MANUFACTURER, AND THEY INDICATED THAT I HAD TO CALL A DEALER. I CALLED MY LOCAL DEALER, ALFA ROMEO WHITE PLAINS (NY). THE SERVICE MANAGER, WHO IS AN ALFA ROMEO MASTER MECHANIC, INDICATED THAT HE HAD ENCOUNTERED THIS SITUATION SEVERAL TIMES, AND HAD ASKED FCA TO FIX THIS. HE HAS RECEIVED NO USEFUL RESPONSE OR SOLUTION. ALTHOUGH THIS SITUATION MAY BE RARE (IT APPLIES NOT ONLY TO OUT OF FUEL, BUT MANY OTHER SITUATIONS OF ELECTRICAL OR OTHER FAILURES), IT IS A MAJOR SAFETY HAZARD. I WAS LUCKY. I WAS STOPPED IN THE MIDDLE OF A LITTLE TRAVELED LOCAL STREET. WHAT IF IT HAD BEEN ON A HIGHWAY? PLEASE ISSUE A RECALL TO REQUIRE DOCUMENTATION OR A FIX TO CORRECT THIS DEFECT.

• 07/14/2023· POWER TRAIN,FUEL/PROPULSION SYSTEM

  On 7/13/2023 while driving at about 40 mph with a half tank of gas the engine shut down and the car rolled to a stop. It took about 3 or 4 tries to restart the car over a span of 10 minutes. A scan of the codes at a repair shop indicated issues with the fuel pump. Check Engine Light came on when the incident happened. There are 11,000 miles on the car.

• 07/12/2024· FUEL/PROPULSION SYSTEM

  The fuel pump failed while driving the vehicle resulting in the car suddenly stopping while on a busy highway. We were nearly read-ended. After attempting to start the vehicle several times and witnessing several service lights go off, I called the police to have my vehicle towed and taken to the dealership. Their service department fixed the fuel pump, but charged me for the expense even though I've heard from others that this is a known issue (see [XXX] ), once resulting in an accident. I believe this should be a required recall item as it could have caused a serious accident. I would have expected this to be covered by the manufacturer. Contacted their customer care department led to an unacceptable result. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 06/30/2024· FUEL/PROPULSION SYSTEM

  While driving on the highway for about two hours, the engine lost power and went into neutral. The engine light and "Service Electronic Throttle Control" came on. The car stalled with vehicles behind me. I got to the shoulder and tried to restart the car. It would try to crank, but the engine would not start. I used a code reader and found codes related to engine misfires and low pressure fuel system (P0300, P0301, P0302, P0303, P008A, P0087).