2017 Lincoln MKZ HEV

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2021· UNKNOWN OR OTHERCrash

  2017 Lincoln MKZ had the "Auto Hold" on and the car came to a complete stop at an intersection with a red traffic light. One other vehicle was in front of me and we had been stopped for at least 30 seconds. Without notice the Lincoln MKZ quickly lunged forward and struck the vehicle in front of me. I kept applying the brake but the car would not stop, it kept hitting the car in front 3 times before it stopped. Auto Hold button was still illuminated. The car was then turned off. The person in the car in front of me stated that they thought I was hit from behind and pushed into their car. I also thought that I was hit from behind and pushed into the car in front. There were no injuries. If I would have been the first car at the light, chances are my car would have been T-boned. I have not driven the car since the incident. No warning signals were given prior to the incident. I would like to have the EDR , black box, evaluated to determine why the Auto Hold malfunctioned. Air bags did NOT deploy. The car is scheduled for service on January 10, 2022.

• 12/12/2024· STEERING

  There was a recall for a loose steering wheel bolt . The recall was repaired at the dealership but now the steering wheel is loose again. I feel like this issue is grounds for a second recall. Not sure what is going on . Please advise before something bad happens

• 11/16/2023· EQUIPMENT,ENGINE

  The contact owns a 2017 Lincoln MKZ. The contact stated that the Navigation System was providing inaccurate information. The contact stated that the Navigation System became inoperable. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the gas cap was loose. The vehicle was taken to the dealer, where it was diagnosed that the Navigation System needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 20,000. The VIN was not available.

• 11/16/2021· ELECTRICAL SYSTEM

  Navigation fails to locate correct GPS location rendering all navigation functions useless. APIM module replaced once under warranty, now 1 year later the issue has returned.

• 11/15/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2017 Lincoln MKZ The contact stated while driving 35MPH, the check engine light illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant was in the number two cylinder and the engine needed to be replaced. The vehicle was not repaired. The contact was relating the failure to TECHNICAL SERVICE BULLETIN 19-2172 (Coolant In Cylinders, White Exhaust Smoke, And/or Illuminated MIL)  however the VIN was not included in the service bulletin. The manufacturer was notified of the failure and offered no assistance informing the contact that the VIN was not included in the service bulletin. The failure mileage was 7,500.

• 11/13/2019· STEERING,WHEELS

  TL* THE CONTACT OWNS A 2017 LINCOLN MKZ. WHILE DRIVING 25 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE PULLED TO THE RIGHT OR LEFT INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GRAND LEDGE FORD LINCOLN (6080 E SAGINAW HWY, GRAND LEDGE, MI 48837, (517) 627-8100) WHERE IT WAS TEST DRIVEN. THE DEALER DID NOT FIND ANY FAILURES. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO LAFONTAINE FORD OF LANSING (5103 S CEDAR ST, LANSING, MI 48911, (517) 394-7000) WHERE IT WAS TEST DRIVEN. THE DEALER CONFIRMED THAT THE ALIGNMENT WAS UNEVEN. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V167000(STEERING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND PROVIDED CASE NUMBER: 24864137. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000.

• 11/05/2020· AIR BAGS,SEATSCrash

  I WAS STATIONARY BEHIND A CAR TURNING LEFT ON HWY 154 S IN COWETA CO, GA, WHEN I WAS HIT FROM BEHIND BY ANOTHER AUTOMOBILE GOING APPROXIMATELY 50+ MPH. THE DRIVER WHO HIT ME NEVER APPLIED HIS BRAKES, WHICH PUSHED MY CAR INTO THE SUV IN FRONT OF ME. THE CAR I WAS PUSHED INTO WAS SHOVED 30+ YARDS DOWN THE ROAD. MY AIRBAGS DID NOT DEPLOY AND MY DRIVER'S SIDE SEAT BROKE.

• 11/04/2024· ENGINE

  The contact owns a 2017 Lincoln MKZ. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

• 11/03/2025· UNKNOWN OR OTHER,ENGINE

  I am paying on a 2017 Lincoln MKZ with total engine failure due to coolant leaking into it. I am aware that NHTSA in early October 2023 there was an investigation into more than 700000 late model Ford due to catastrophic engine failure. Why was people not informed on this matter, or a recall established.

• 10/30/2024· POWER TRAIN

  The contact owns a 2017 Lincoln MKZ. The contact stated while driving at an undisclosed speed, there was a whining sound coming from under the hood. The vehicle was driven to the residence. The contact stated that on the following day, the vehicle was started; however, while driving 30 MPH, the accelerator pedal was depressed but the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to exceed 30 MPH. The vehicle was driven to the place of employment. The contact stated that after work, the vehicle was started, and the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The vehicle was driven to the residence. The contact stated that on the following day, the vehicle was started; however, the vehicle failed to move forward. The contact stated that the vehicle instead rolled backward. In addition, the contact stated that the vehicle became undrivable. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced NHTSA Campaign Number: 18V390000 (Power Train); however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 127,000.

• 10/30/2017· AIR BAGS

  AIRBAG LIGHT

• 10/29/2018· STRUCTURE,LATCHES/LOCKS/LINKAGES

  TL* THE CONTACT OWNS A 2017 LINCOLN MKZ. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE HOOD AJAR WARNING LIGHT ILLUMINATED. THE CONTACT PULLED TO THE SIDE OF THE ROAD SEVERAL TIMES SINCE JUNE OF 2018 TO CHECK IF THE HOOD OF THE VEHICLE WAS OPEN AND/OR UNLATCHED. THE CONTACT STATED THAT THE HOOD WAS NOT OPEN OR UNLATCHED SEEMINGLY. IN ADDITION, THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. CLASSIC FORD LINCOLN (8540 TYLER BLVD, MENTOR, OHIO 44060 (440) 266-3000) WAS MADE AWARE OF THE FAILURE BUT THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS MADE AWARE OF THE REOCCURRENCE TWICE BUT COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO ANOTHER DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000. *DT *JB

• 10/25/2023· ENGINE

  Coolant leaked into cylinders causing my engine to regularly overheat, forcing me to replace the engine at about 78,000 miles. Although I didn't realize it at the time, the first indication of a problem was at 72,737 miles (just 2,737 miles out of warranty), which is when I had the first overheating incident. According to my research, Ford has known about this problem for many years, and it affects many models over many model years, but they have yet to address the problem with the public. I was fortunate in that I didn't have a fire or an accident due to this known problem. Ford has issued several Technical Service Bulletins about it, the most recently being 22-2229, which is attached. Lincoln assisted me with covering the engine replacement, but in total, I am out $3,864.80 due to this problem.

• 10/21/2024· STEERING

  Loose steering wheel issues as described in existing recall Safety Recall 18S08 Dealer repaired at a cost, and was informed that the vehicle was not eligible for the recall. Bolt replaced and retorqued to sped. Service performed by Fiesta Lincoln 1720 S Mesa Dr, Mesa, AZ 85210 on 10/21/2024 with approx cost of $240 (final invoice not available at this time.)

• 10/21/2019· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  I WENT TO START MY VEHICLE NO POWER AT ALL.. WEIRD NOTHING EVER HAPPENED LIKE THAT BEFORE. SO I GET AAA TO GIVE ME A BOOST. I GET TO MY DESTINATION. GO TO GET BACK IN MY CAR AND LEAVE. CAR DEAD NO POWER AT ALL. GET TOWED TO THE DEALER. BATTERY CHECK WAS GOOD. THEY COULDN'T FIND OUT THE PROBLEM. THEN THE CAR WOULD GET JUMP STARTED BUT WOULDN'T TURN OFF WHEN YOU PRESS THE BUTTON ONLY THE AUXILIARY THINGS WOULD POWER OFF. THE DEALER IS TELLING ME IT'S WATER DAMAGE BUT HOW? IT'S GARAGE KEPT..

• 10/19/2024· WHEELS

  Factory Rim cracked causing tire to not stay inflated

• 10/19/2024· ENGINE

  Coil head caked in oil causing misfire due to valve guideseals in left side cylinder head leaking see attached documentation

• 10/11/2022· ENGINE

  I haven’t had any issues but there are many online that have had to have the engine replaced and charged out of their pocket for the defect the manufacturer KNOWS is their own fault and refuses to do a recall on

• 10/05/2021· ENGINE

  I took car in to get oil change found coolant leaking. Car has 32000 miles. I went to ford store and they said coolant is leaking out side of engine and cylinders no 3 and 4 have coolant inside Ford replaced engine. 2.0 Eco bost Engine

• 09/30/2019· POWER TRAIN,ENGINE

  OIL PAN LEAK RTV LEAK. THIS MKZ IS LEAKING UP TO 1/4 QUART OF OIL A DAY.

• 09/30/2019· ENGINE

  POWER LOSS WHEN ACCELERATING HARD ON THE FREEWAY (65MPH+). POWER IS SIGNIFICANTLY REDUCED, MAKING ME A HAZARD ON THE ROAD! THE VEHICLE CONTINUES TO 'LIMP' UNTIL CAR IS TURNED OFF AND RESTARTED. WHEN I TOOK IT TO THE GARAGE, THE VALVES WERE FOUND TO HAVE MAJOR CARBON BUILDUP AND THE #1 CYLINDER HAD A CRACKED SPARK PLUG.

• 09/28/2023· ENGINE

  There are numerous reports of engines needing to be replaced due to coolant intrusion on the engine which causes overheating due to coolant loss. It eventually causes engine misfire a=in cylinder #2 or 3. Ford/Lincol does not want to cover engine replacements cut issued a TSB stating that engined need to be replaced.

• 09/21/2020· SERVICE BRAKES

  COLLISION MITIGATING BRAKING DOES NOT ENGAGE THE BRAKES. WHEN A TRUCK SUDDENLY CUT ME OFF, THE AUDIBLE AND VISUAL WARNING INDICATE OBJECT IN THE WAT BUT NO BRAKING OCCURS. BRAKE PEDAL DOES NOT PUMP UP (AS IT DOES WHEN THE RADAR CRUISE CONTROL SLOWS THE CAR). CAN REPRODUCE BY FOLLOWING TURNING VEHICLE TOO CLOSELY.

• 09/19/2023· ENGINE

  September 2023, 2017 MKZ showed misfire cylinder 3. Had a rough idle started back up and got a puff of white smoke from tailpipe. Towed to dealer who told me I needed new engine. 10k. Car has 64k miles. Dealer says I missed power train warranty by 1 month and 8 days. Contacted headquarters who initially said I had 11 months left. Headquarters recommended a local Ford dealer who told me it wasn't covered. I'm stuck with 20k debt and ford knows about this coolant engine flaw.

• 09/13/2022· ENGINE

  I was driving and started smelling toxic fumes come inside my car, steering wheel started jerking. I didn’t think much of it until my 2 year old daughter in the backseat was looking as if she was about to pass out. Her eyes started rolling and her words were slur, more slur than normal. I immediately pulled over and saw the fumes were coming from my tail pipe. It was a huge cloud of smoke. It was my car that was the problem. I had to leave my car on the side of the road and get someone to take us home. It wasn’t safe to drive in the condition it was in. The next day I got it towed to the mechanic and he said my car lacked coolant and the engine needs to be replaced. I looked online and saw that this was an ongoing problem for the make and model of my vehicle and Ford is aware of it. The mechanic quoted my thousands of dollars to get it repaired. Ford won’t help. This incident could’ve killed my daughter and me. PLEASE HELP MAKE MY CAR A RECALL ON THE ENGINE! I have no transportation.

• 09/12/2022· ENGINE

  My engine is overheating, causing my steering wheel to jerk while on the highway. Took to dealership and they said loss of coolant and could potentially cause a fire if not treated. Looked online and saw that Ford is aware of the problem but will not correct it. The dealership is asking me to pay $8,000 to fix it for Ford initially putting in a faulty engine. I had to stop my car because smoke was coming out the tailpipe. The car isn’t safe to drive.

• 09/09/2022· SERVICE BRAKES

  On Tuesday, March 1 2022, as I was attempting to stop at a stop sign, I noticed loss of pressure on the brake pedal. As I accelerated and applied my brakes again there was no pressure feedback on the brake pedal and my vehicle took a prolonged time and distance to stop. After a few minutes, a warning message appeared on the dashboard to let me know of low brake fluid. After I got the vehicle home, I noticed a lot of brake fluid in the driver's front wheel well. Upon further inspection, a rupture in the line at the metal crimping was evident. The event happened as I was coming home from ice hockey practice with my 5 yr old and 8 yr old in the vehicle. The roadway that the failure occurred at was a service road to I-35E in Farmers Branch which at that time of day has moderate traffic moving at high speed. Had the brake blown out a few minutes later, I would have been on I-35E with my children. The speed limit on that road is 70 MPH and it was the tail end of rush hour which means a mix of slow traffic and high speed traffic requiring the ability to brake at a moments notice. I still have the faulty brake line in case anyone needs it for inspection.

• 09/04/2024· ENGINE AND ENGINE COOLING

  See attached document for complaint.

• 09/03/2024· ENGINE

  2017 Lincoln MKZ with 53k miles check engine light comes on and dealership diagnostic shows leaking coolant in cyl #2/needs motor. Car out of warranty so cost of repair is out of my pocket. Lincoln has known about this since 2016...they leased the car out in 2017 and then sold it to me in 2019 KNOWING there was a defective engine in the vehicle but didn't do or say anything about it...NEVER any recall. How is it that there are 100k 2021-2022 trucks and suv's being recalled due to engine issue that could "lead to catastrophic engine damage resulting in a loss of power". I could of suffered a loss of power as well with the defective engine that was in my car. How is this sudden recall on these trucks and suv's any more important or severe than all of the Ford/Lincoln vehicles that had engine issues? This could have been easily rectified early on seeing they knew about this issue from the beginning. I want my money back I paid to get my engine repaired.

• 09/03/2020· ENGINE

  PURCHASED CPO WITH 38K MILES ON IT. A WEEK AFTER OWNING SMOKE EMITTED FROM EXHAUST, CHECK ENGINE LIGHT CAME ON AND CAR WAS ROUGH TO START, IDLING HARD. CAR MELTED STRONGLY OF ANTIFREEZE BUT NO VISIBLE LEAKS. LINCOLN DID INSPECTION AND SAYS NEEDS A NEW ENGINE DUE TO COOLANT LEAKING INTO CYLINDERS AND PISTONS FAILING. ENGINE IS ON BACKORDER FOR TWO MONTHS. THIS SEEMS TO BE A KNOWN PROBLEM. WE ARE EXTREMELY UNHAPPY. HAVEN'T EVEN HAD THE CAR TWO WEEKS BEFORE THIS STARTED HAPPENING. WE WANT OUT OF THIS CAR!

• 09/02/2017· STEERING

  WITH THE V6 TWIN TURBO EQUIPPED FRONT WHEEL DRIVE MKZ YOU GET AN EXTRA TRILL IN ADDITION TO THE FAST ACCELLERATION . THE TORQUE STEER PROBLEM IS SO BAD THE STEERING WHEEL SNAPS OUT OF YOUR HAND AND JUMPS INTO THE ON COMMING LANE ! IF YOUR LOOKING FOR AN EXCITING CAR TO DRIVE, THIS IS IT !!!!

• 09/01/2022· ENGINE AND ENGINE COOLING,ENGINE

  The contact owns a 2017 Lincoln MKZ Hybrid. The contact stated that while driving at an undisclosed speed, the message "Engine Overheating" was displayed. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the engine was misfiring, the coolant level was extremely low, and coolant had intruded into cylinder #4. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure. The contact indicated that TSB (22-229) regarding the failure had previously been issued by the manufacturer but the VIN was not included. The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 90,000.

• 08/31/2023· SERVICE BRAKES, HYDRAULIC

  The contact owns a 2017 Lincoln MKZ. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 08/30/2023· SERVICE BRAKES, HYDRAULIC

  The contact owns a 2017 Lincoln MKZ. The contact stated while driving 30-40 MPH and depressing the brake pedal, the vehicle failed to respond immediately. The contact stated that the vehicle responded when the brake pedal was depressed down to the floorboard. The contact stated that as she continued driving, the message "Brake Fluid" was displayed. The contact drove to the residence, where she noticed that brake fluid was leaking onto the ground. The contact later became aware that the VIN was included in NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer and a second dealer Ford of Latham (637 Columbia St Ext, Latham, NY 12110) were contacted. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000. Parts distribution disconnect.

• 08/24/2023· SERVICE BRAKES

  The contact owns a 2017 Lincoln MKZ. The contact stated that upon depressing the brake pedal, the brake pedal made an abnormal squeaking sound. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, where it was determined that the brakes had failed. The contact stated that the brakes had been replaced twice, including the rotors; however, the failure persisted. The contact stated that the vehicle had been taken to the independent mechanic several times for repairs. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not made aware of the failure. The approximate failure mileage was 80,000.

• 08/23/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2017 Lincoln MKZ. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment with excessive smoke coming from the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that coolant intrusion had damaged the engine, resulting in a misfire in cylinder #2, and the long block was cracked. The contact was informed the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

• 08/23/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2017 Lincoln MKZ. The contact stated that while the vehicle was parked, the vehicle was started and there was an abnormal antifreeze odor coming from the exhaust pipe. The contact stated that the check engine warning light was illuminated. The vehicle was driven back to the residence. The contact self-diagnosed the vehicle with a coolant leak into the cylinder. The contact had spoken to an independent mechanic, but the vehicle was not diagnosed. The contact was informed that the head gasket on the cylinder or the engine might need to be replaced. The contact was occasionally adding coolant to the vehicle to drive the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 134,000.

• 08/19/2024· ENGINE

  Coolant leak into the engine, causing white smoke, decreased coolant level and a rough start

• 08/19/2022· ENGINE AND ENGINE COOLING

  The contact owns a 2017 Lincoln MKZ. The contact stated while driving approximately 50 MPH, there was smoke coming from the exhaust pipe, and the steering wheel was vibrating. There were no warning lights illuminated. The contact safely pulled over and exited the vehicle. The vehicle was towed to her residence. The next day the vehicle started; however, the failure reoccurred and the check engine warning light illuminated. The vehicle was towed to the local dealer and diagnosed with no coolant and a faulty engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 75,489.

• 08/16/2024· ENGINE

  I took my 2017 Lincoln MKZ vehicle into my local Lincoln dealership on the morning of 8/13 due to check engine light which came on the previous week. The results of the diagnostic test that was performed which showed P0303 coolant leaking in cylinder #2 needs motor per tsb 22-2229 at a cost $7103.60 plus tax. My 2017 MKZ with 53k miles needs a new motor…how is this??? This issue is a result of a “known” defect in the motors of certain Lincoln and Ford vehicles where coolant seeping into the engine. I call the Lincoln Care/Customer Relations Center department to advise of my situation and the representative I spoke took my information Vin #, address, phone number and said she would call me back once she has looked in what resources or programs available that could possibly assist me with this very expensive repair. She calls me back and advises that because my vehicle is out of the warranty period there is no assistance or resources available to assist me. Now, if my vehicle was still under warranty I would be covered and I wouldn’t need assistance because it would be a covered repair. So, if this is the Lincoln Care /Customer Relations Center that “supposedly” have resources to assist customers in situations such as this, who are you assisting??? not the customer under warranty because they don’t need the assistance and obviously not the customer (myself) that need the assistance but can't get any. I have a long history with this company and I have invested a lot of money with this company to be told there is no assistance for a “known” defect issue which has now become my issue. Unbelievable that you all are treating customers in this manner. I will never support this company ever again after being a repeat customer and getting treated this way. I can only hope all of the other vehicle owners with this “known” defect that are having to pay for the repair does the same. I want my money back that I now have to pay out to get my vehicle repaired.

• 08/12/2023· ENGINE

  2017 lincoln mkz 2.0L ecoboost engine Coolant intrusion into cylinder due to cracked engine block from factory defects in water jacket design. This will cause engine to fail, over heat, potential fire risk. Issue identified by certified dealer and lincoln refuses to fix due to out of warranty. Issue is known by lincoln and is same as 1.6L ecoboost recall. Check engine light indicated misfire in cylinder, however light is intermittently illuminated and does not identify the actual issue.

• 08/11/2022· SERVICE BRAKES

  Front left brake hose had an immediate large leak during driving causing vehicle to lose all braking during driving. There was no warning prior to this or during the failure, no lights on dashboard, brake pedal went all the way to the floor. Placed flashers on, and rolled to a stop. Vehicle needed to be towed. Vehicle is on the way (today August 11) to Apple Ford in Shakopee, MN to be fixed on August 16th.

• 08/07/2023· ENGINE

  While driving my 2017 Lincoln MKZ 3.0L in March 2023, I experienced a loss of power and then engine stalled, fortunately I was at a stop and was able to re-start the vehicle and limp home, (which was nearby). If this loss of power and then stall would have happened while I was moving in traffic the failure could have lead to a catastrophic outcome including loss of life. It was determined via OBDII analysis conducted by the Lincoln Service department that DTC P0302 was triggered. Upon further inspection by the service department it was revealed that the issue was related to TSB 19-2243, which reads "2.7L/3.0L - Oil Consumption With DTC P0524 And/Or P06DD, Rough Idle, Misfire And/Or White Or Blue Exhaust Smoke - Built On 1-Apr-2016 And Through 1-Jan-2017". Unfortunately, my vehicle was built during this known defect time frame. And the remedy required new cylinder head. The new cylinder head and subsequent parts and labor cost me $3,126.58. This was extremely unfair as my only because my vehicle did not fall within the warranty period or mileage. The vehicle was over 6 years old with 36,934 miles. This very serious failure mode could have resulted in a loss of life if experienced while driving on a highway or any other situation in which the vehicle was mobile and experienced a sudden loss of power in traffic. Further disappointing is that I would estimate that there were many vehicles that experienced the defect noted in the TSB but these were not reported publicly because they were "lucky enough" to fail during the warranty period. My costs should be reimbursed by Lincoln given this was a known defect during the build time frame. And at minimum there should be a safety recall for the vehicles built during the time period noted in the TSB. I will personally never purchase another Lincoln not to mention a Ford, of which I currently have 3 Ford/Lincoln.

• 08/07/2022· ENGINE

  In April 2022 my steering wheel started jerking and I felt my car starting to drive unusual. By the end of April my check engine light was on so I went and got it checked out. Code P0217, P0302, P0316 showed up. I thought this must be a mistake so I took it to the dealership for another look and they told me that this is a common problem with my vehicle and I got the short end of the stick with this vehicle. THE LONG BLOCK NEEDS REPLACING FOR COOLANT INTRUSION INTO CYLINDER 2. I need a brand new engine. The supervisor in the service department said there’s a technical service bulletin that reads that, TSB#22-2133, Issue: Some 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated malfunction indicator lamp (MIL). Diagnostic trouble codes (DTCs) may include P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To correct the condition, follow the Service Procedure steps to replace the long block engine assembly. Action: Follow the Service Procedure steps to correct the condition on vehicles that meet all of the following criteria: • One of the following vehicles: - 2015-2018 Edge - 2017-2019 Fusion/MKZ built on or before 8-Apr-2019 - 2017-2019 Escape built on or before 16-May-2019 - 2017-2019 MKC built on or before 18-Apr-2019 • 2.0L EcoBoost engine • Presence of coolant in the engine cylinders, white exhaust smoke and/or a runs rough condition with or without an illuminated MIL. I didn’t create this issue, it’s a know problem and I’m now without a car because I have to replace the engine before using the vehicle again.

• 08/06/2025· STEERING,POWER TRAIN,FUEL/PROPULSION SYSTEM

  Vehicle began to feel as if it was losing the ability to get any power to the engine. I would push the pedal to accelerate but even fully compressed the vehicle would not go above 30mph. I attempted to drive the vehicle in to be inspected at a dealership and while on the way the steering wheel completely locked and an Emergency Light appeared on the dashboard stating "Safely Park Vehicle". It was a Horrifying Experience to be driving In traffic and lose control of the vehicle but luckily I was able to coast the vehicle to the side of the road to safety without crashing! Although the vehicle was fully powered, it would not move and I had to call AAA in order to get the vehicle towed to the closest AAA Approved facility which was AutoWorks Diagnostics & Repair in Kittery, ME. They observed fluids had leaked out but were unable to locate where the leak was coming from and very Loud Noises that appeared to be coming from in between the Engine and Transmission . After researching online they found that there were Two Recalls involving the welds on the Torque Converter detaching from the engine. They also found a recall on the front brake hoses rupturing & leaking brake fluid as well as a Recall with the steering wheel retaining bolt loosening & detaching while driving which could also have contributed to the issues experienced with the vehicle and the safety concerns associated as I was driving in traffic and lost Total Control of the vehicle which could very likely have caused a Major Accident! Unfortunately None of these recalls have been associated with the VIN connected to this vehicle and the manufacturer; Lincoln, to this point has refused to discuss any of the issues having to do with the four recalls being associated to my specific 2017 Lincoln Hybrid Premier 2.0L gas engine with 6 speed transmission although this specific year, make & model has each of these reported recalls.

• 08/06/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2017 Lincoln MKZ. The contact stated that upon starting the vehicle, the check engine warning light remained illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the engine had failed due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.

• 07/28/2024· ENGINE

  Vehicle just started running rough and then the check engine light came on and almost immediately temperature indicated excessive heat. I looked in the rear view mirror and noticed excessive white smoke coming out of the tail pipes. I stopped the vehicle and opened the hood and notice there was no coolant in the reservoir. I had the vehicle towed to the Ford Dealer in Spring Hill, Florida ($125.00). While the vehicle was at the dealership I rented a vehicle for 1 and a half months ($ 2476.72). New engine long block installed and completed on July 26, 2024 and I picked up my vehicle after I paid. ($7786.12). During the time the vehicle was at the dealership I called Ford Motor and Lincoln Motor Company but was told vehicle has not been recalled and was out of warranty. See Ford TSB 22-2229

• 07/28/2023· ENGINE

  In September 2022, I began noticing issues with my 2017 Lincoln MKZ. Despite notifying Lincoln and the dealer, they delayed inspection due to their policy that a check engine light was not a sufficient reason for an early inspection without an appointment. It was only inspected in November. I also was told both by the dealer and Lincoln corporate customer service that I couldn't take my car to other dealers to get it inspected. In November 2022, it was finally inspected, but they were unable to diagnose the issue. By July 2023, the issues escalated - my car was now diagnosed as requiring a new engine due to coolant leakage into the engine. I was shocked and horrified at this outcome, given that I had only driven the car for 25k miles since its purchase in 2020. Over a third of submitted complaints to nhtsa regarding this vehicle model are related to engine failure due to coolant leakage. TSB reports and existing class action lawsuits indicate that the issue is a known design flaw in the engine affecting both Lincoln MKZ and certain Ford Fusion models. Technical Service Bulletin (TSB) 22-2134, indicates that the problem may present "with or without an illuminated malfunction indicator lamp (MIL)". A complete engine replacement is their proposed solution. Despite the urgent need for corrective action, Lincoln's response has been neither prompt nor transparent. They seem to be avoiding responsibility rather than addressing this critical defect, as evident in their decision to discontinue the MKZ and the Ford Fusion in 2020 a year after acknowledging these issues. This is a case of warranty and insurance fraud, not to mention a critical failure in maintaining public safety. I urge NHTSA to thoroughly investigate this defect affecting numerous vehicles and compel Lincoln to rectify it. For the past two weeks, I've requested multiple times my vehicle records from Lincoln but received none, leaving my car hostage in the shop. Please consider this plea for action.

• 07/27/2023· ENGINE

  Engine light would come on & off. Took my care in to be inspected - they determine i need a new motor -due to defect in motor design leaking antifreeze into cylinders. Not cover by warranty because i was 2 months out of the 6yr. period with only 47,000 miles on it. They will do nothing for me except charge for a new motor. My understanding is this 4 cylinder w/turbo motor in Ford/Lincoln has a known design flaw that they hope no one finds out about.

• 07/21/2023· WHEELS

  The contact owns a 2017 Lincoln MKZ Hybrid. The contact stated that while attempting to replace all four tires, the contact became aware that the lug nuts were swollen. The vehicle was taken to the dealer, who informed the contact that the lug nuts needed to be heated to remove from the wheel studs. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.