2016 Toyota Tundra

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2019· AIR BAGS,SEAT BELTSCrash

  2016 TOYOTA TUNDRA. CONSUMER STATES THAT AIR BAGS DID NOT DEPLOY AND SEAT BELTS DID NOT LOCK DURING COLLISION. *LD *JS

• 12/22/2019· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  ON MY 2016 TOYOTA TUNDRA 1794 EDITION, WITH HEADLIGHTS IN "AUTO" POSITION, WHEN I USE TURN SIGNAL, THE HEADLIGHTS, TAILLIGHTS AND DASH LIGHTS ALL OCCASIONALLY TURN OFF. ONCE TURN SIGNAL SHUTS OFF, LIGHTS COME BACK ON . IT TYPICALLY HAPPENS AT NIGHT WHEN IT'S COLD OUT. IT HAS NOW HAPPENED PROBABLY HALF A DOZEN TIMES IN THE LAST SIX MONTHS. WHILE PROBLEM IS INTERMITTENT, IT'S VERY SCARY, AS I'M DRIVING BLIND ON A RURAL ROAD UNTIL THE LIGHT COME BACK ON. ON THE TUNDRAS.COM OWNERS WEBSITE, THIS APPEARS TO BE A COMMON ISSUE. HELP! BEFORE SOMEONE GETS HURT.

• 12/21/2016· SUSPENSION,STRUCTURE

  2016 TOYOTA TUNDRA , PURCHASED BRAND NEW , AFTER 3000 MILES TRUCK START LEANING TOWARDS THE PASSENGER SIDE. I EXPRESSED ISSUE TO THE DEALER, TECHNICIAN TOOK FOR A DRIVE TEST AND NOTICED THE SAME ISSUE , I DROPPED MY VEHICLE WITH DEALER FOR A COUPLE OF DAYS AND NOTHING WAS DONE TO IT DUE TO THERE IS NO RECALLS TO IT, BUT I PERSONALLY BELIEVE THIS IS A SAFETY CONCERN AND SHOULD BE PREVENTED .

• 12/16/2025· STEERING

  The power steering went out during routine around-town driving. One moment it was steering fine, the next moment it became extremely difficult and sluggish. There were no warning lights or warning of any sort until the steering wheel started jerking unevenly as I tried to turn. I was able to get control of the vehicle and pull it to the side of the road. There was no difference in the engine noise, and I couldn't see any noticeable fluid leak. I was able to drive the vehicle home, make an appointment with the Toyota dealer, and get the vehicle to the dealership for inspection. The dealership told me after inspection, that the rack and pinion steering was binding internally, and that there was seepage from the right boot. Initially, they told me that the pump should be fine. I authorized them to replace the rack and pinion steering. After which, they told me that the problem seemed to still persist some, and that the pump would have to be replaced also. My total bill came to $3,200, which seemed not unfair. But this whole issue seemed like something that should be noticed as part of a recall. I found the NHTSA recall number. 21V-920, and my truck seemed to match exactly the symptoms spelled out is this recall , but Toyota refused to acknowledge it. My VIN number did not fall within the specified VIN for this recall. I've driven several Toyotas, including another Tundra, a Tacoma, 2 Highlanders and a Sienna, and have been pleased with each vehicle. This Tundra is 10 years old with 95,000 miles, and I've only done expected maintenance and a couple of occasional minor repairs. Those being: - Having the brakes resurfaced - Changing out the alternator In the end, it wasn't a devastating amount of money, but it was an issue that I felt Toyota should have taken care of. I did reach out to them, but because I had already paid for the repairs on the vehicle I needed to drive for work, they refused to talk to me any further. I have the estimate and final bill.

• 12/14/2021· SUSPENSION

  What component or system failed or malfunctioned, and is it available for inspection upon request? Answer - Front and rear wheel bearings. How was your safety or the safety of others put at risk? Answer - wheels could have locked up while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer - Yes. Milton Martin Toyota in Oakwood, GA has confirmed that 3 wheel bearings are bad and need to be replaced. 1x front left wheel bearing replaced on 12/06/21 and both rear wheel bearings are being replaced on 12/14/21. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer - Yes, if a dealership qualifies as the manufacturer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Answer - Yes, noise from the wheels while driving. No warning lamps or messages. I noticed the "roaring" noise around 11/12/2021.

• 12/11/2015· EXTERIOR LIGHTING

  BOUGHT NEW 2016 TUNDRA LIMITED 11/16/2015 AND NOTICED THAT DASH LIGHTS DO NOT COME ON DURING DAYLIGHT HOURS UNLESS PARKING LIGHTS OR HEADLIGHTS ARE ON. IN THE OFF/DRL POSITION OR THE AUTO POSITION NO DASH LIGHTS. WHEN I CALLED TOYOTA HELP LINE I WAS TOLD THAT THIS CHANGE WAS MADE BECAUSE IF THE DRIVER CAN SEE THE OUTLINE OF THE NUMBERS ON THE GAUGES THEY DO NOT NEED TO BE ILLUMINATED. HE COULD NOT OFFER ANY REASON FOR CHANGING THIS STANDARD FEATURE. OTHER THAN NOT SEEING THE GAUGES SHARPER AND CLEARER ONE SAFETY DEFECT IS PRESENT. THE TUNDRA HAS GAUGES INSTEAD OF WARNING LIGHTS FOR ENGINE OPERATIONS AND THEY ARE SMALLER THAN THE SPEEDOMETER/TACHOMETER . THE TEMP GAUGE IS LOCATED ON THE LOWER LEFT OF THE DASH AND CANNOT BE SEEN CLEARLY WITHOUT THE DASH ILLUMINATED BECAUSE THAT CORNER IS DARK IF IT IS CLOUDY OR EARLY OR LATE . IF THE ENGINE OVERHEATS ONE WOULD NOT SEE THAT PROBLEM ON THE GAUGE WHICH MIGHT LEAD TO ENGINE FAILURE ,ETC. I HAVE NEVER OWNED A VEHICLE THAT REQUIRED TURNING ON THE PARKING LIGHTS OR HEADLIGHTS TO ILLUMINATE THE DASH..DEALER SAYS THAT SWITCH CANNOT BE CUSTOMIZED. TOYOTA SHOULD ISSUE A FIX FOR THIS MISTAKE.

• 12/08/2015· POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  THE DRIVETRAIN ON MY 2016 TOYOTA TUNDRA ARE NOT ALLOWING THE WHEELS TO ROTATE FREELY. ADDITIONALLY, THE WHEELS ARE LOCKING UP ON THE TRUCK. ON 6 DEC, I PICKED UP MY TUNDRA FROM THE DEALERSHIP'S SERVICE DEPART AFTER HAVING THE REAR DIFFERENTIAL REPAIRED. THE VEHICLE STARTED TO DRIVE SLUGGISH. AS I NEARED MY HOME, I TRIED TO TEST THE 2WD AND 4WD FUNCTIONS OF THE VEHICLE. I ATTEMPTED TO TEST THE REPAIR THAT WAS DONE. THE WHEELS ON THE VEHICLE STARTED TO HAVE PROBLEMS ROTATING FREELY AND LOCKING UP. WHILE IN 4WD THE VEHICLE WOULD NOT MOVE. IT APPEARED AS IF THE BREAKS WERE LOCKED ON THE VEHICLE. FOUR DAYS LATER, THE VEHICLE STILL DRIVES SLUGGISH. WHILE DRIVING AT SPEEDS OF 45MPH, I WOULD TAKE MY FOOT OFF THE ACCELERATOR AND THE VEHICLE WOULD ALMOST COME TO A COMPLETE STOP ON ITS OWN. CURRENTLY THE VEHICLE ACTS LIKE IT WANTS TO DRIVE IN 4WD LOW AND HIGH MODE. ADDITIONALLY, THE WHEELS ARE ACTING LIKE THEY DO NOT WANT TO ROTATE FREELY. AS OF 6AM ON 8 DEC, I CANNOT DRIVE THE VEHICLE OVER 25 MPH. THE VEHICLE IS IDLING OVER 4000 RPM AND NOT CHANGING GEARS. THE VEHICLE IS REGISTERING BEING IN 4WD LOW BUT THE SELECTOR SWITCH IS ON 2WD MODE.

• 12/07/2020· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  MY HEADLIGHTS SHUT OFF WHEN USING MY TURN SIGNAL

• 12/07/2015· FUEL/PROPULSION SYSTEM

  I PURCHASED TOYOTA TUNDRA ON 6 NOV 2015. SINCE OWNING THE VEHICLE I HAVE BEEN GETTING 460 MILES TO A FULL TANK OF GAS (38 GALLON TANK). THOSE NUMBERS EQUATE TO 12MPG IN FUEL ECONOMY ESTIMATES. I PICKED THE VEHICLE UP ON 6 NOV2015. THE TRUCK HAD A FULL TANK OF GAS. THE FUEL EFFICIENCY READ 570 MILE FOR A FULL TANK OF GAS. ON 13 NOV I DROVE THE VEHICLE TO FLORIDA. EVERY TIME I FILED UP THE TRUCK WITH FUEL THE FUEL EFFICIENCY READING STARTED TO DECLINE. ON THE FIRST THREE FULL TANK OF GAS, THE READING WAS 540 AND 520 MILES FOR A FULL TANK OF GAS ON 15 NOVEMBER. I TOOK THE VEHICLE TO THE DEALERSHIP ON OR ABOUT 17 NOV. THE SERVICE DEPARTMENT PLUGGED THE VEHICLE UP TO A COMPUTER. THE COMPUTER SENT OUT A REPORT THAT SHOWED THAT THE VEHICLE WAS GETTING 18 MPG. THE SERVICE PERSONNEL TOLD ME THAT I WOULD BE DOING WELL IF I GOT 14MPG. BASED ON THEIR COMMENTS I WAS NOT TO EXPECT ANYTHING OVER 15MPG OVER THE HIGHWAY. ON 25 NOV, I DROVE THE VEHICLE TO FLORIDA. I DECIDED TO MANUALLY TRACK THE MILEAGE IN REGARD TO A FULL TANK OF GAS WITH THE USE OF THE TRIP COUNTER. I TOOK PICTURES OF THE VEHICLE ONLY REGISTERING 12MPG ON A FULL TANK OF GAS. ON A FULL 38 GALLON TANK, I WAS ONLY ABLE TO DRIVE 460 MILES PER TANK. THAT EQUATE TO 12MPG. THE DRIVING CONDITION WAS 74-78 DEGREES; DRIVING ON I95; THERE WAS ONLY THREE PASSENGERS IN THE VEHICLE. I USED 89 OCTANE GRADED GAS.

• 12/07/2015· POWER TRAIN,SERVICE BRAKES

  WHILE DRIVING BACK FROM FLORIDA ON 30 NOV, I HEARD A HUMMING NOISE COMING FROM THE REAR OF MY TOYOTA TUNDRA. ON 2 DEC 2015, THE DEALERSHIP DID SERVICE ON THE TRUCK TO ADDRESS THE NOISE. THE DEALERSHIP REPLACED THE REAR DIFFERENTIAL ASSEMBLY AND DID SOMETHING TO THE LSD. I PICKED THE VEHICLE UP ON 6 DECEMBER 2015, THE REAR WHEELS STARTED LOCKING UP AND MADE IT DIFFICULT TO DRIVE THE VEHICLE. I LET THE VEHICLE SET OVER THE WEEKEND. ON 7 DEC 2015, I ATTEMPTED TO DRIVE THE VEHICLE AGAIN, THE WHEELS WERE STILL LOCKING UP AND THE VEHICLE HAD A BURNING SMELL. I HAVE AN APPOINT TO RETURN THE VEHICLE ON 9 DEC 2015.

• 11/28/2020· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  MY 2016 TOYOTA TUNDRA 1794 CREWMAX, DURING WINTER MONTHS IN MIDWEST - THE HEADLIGHTS AND AND INTERNAL INSTRUMENTATION WILL TURN OFF WHEN TURNING LEFT OR RIGHT WITH TURN SIGNAL ENGAGED. THE AUTOMATIC LIGHTS ARE ENGAGED ON COLUMN STALK AND THE ISSUE OCCURS AT NIGHT. THE VEHICLE IS IN MOTION

• 11/27/2017· TIRES

  TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA EQUIPPED WITH KUMHO ROAD VENTURES TIRES, SIZE: 275/65R/20 (NA). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE SHAKING DUE TO THE STEERING COLUMN WHILE TRAVELING APPROXIMATELY 65 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE TREAD SHIFTED ON THE PASSENGER SIDE TIRE. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE DOT NUMBER AND TIRE AND VEHICLE FAILURE MILEAGE WERE NOT PROVIDED.

• 11/15/2016· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL

  I HAVE A SERIOUS SAFETY CONCERN REGARDING THE LACK OF DAYTIME VEHICLE INSTRUMENT ILLUMINATION ON MY NEW 2016 TOYOTA TUNDRA (WHILE DRIVING, STATIONARY AND ON ALL ROADS) DURING THE DAY. AS AN ELDER ADULT WHO WEARS SUNGLASSES TO PROTECT THEIR EYES (ON THE RECOMMENDATION OF THE MEDICAL PROFESSION) THE DASH BOARD (SPECIFICALLY THE SPEEDOMETER INDICATOR) IS BARELY DISCERNIBLE. EVEN WITHOUT SUNGLASSES THE INSTRUMENT PANEL IS VERY DARK. I AM SURE THERE ARE THOUSANDS OF OTHERS WHO WOULD LIKE TO SEE THE INSTRUMENTS AND OPERATE THEIR VEHICLES IN A SAFE AND LAWFUL MANNER DURING THE DAYTIME OR WITH SUNGLASSES ON. I AM SURE THE DECISION, BY TOYOTA, TO NOT ILLUMINATE THE DASH IN THE DAYTIME SAVES A FEW PENNIES AND ADDS UP FOR THE MANUFACTURER WHEN YOU SELL THOUSANDS OF VEHICLES? BUT. . . NOT BEING ABLE TO SEE A DARK INSTRUMENT PANEL IS BOUND TO CAUSE MORE THAN A FEW ACCIDENTS.

• 11/14/2024· ENGINE

  Problem Parts?? At around 70,000 miles I was told that there was an engine oil leak ... camshaft area... and the engine needs to pulled out with a repair cost of about $5,000 dollars. (Reseal both cam towers, replace gaskets, etc.) A bit ridiculous. Is there now a possible engine fire risk? At 70,000 miles there was obviously a manufacturing mistake or a defective part used during assembly.

• 11/13/2019· EXTERIOR LIGHTING

  IF THE HEADLIGHTS ARE SET TO AUTO AND I SIGNAL A LEFT TURN AND TURN TO THE LEFT, THE HEADLIGHTS SHUT OFF AND THE INTERIOR LIGHTS SWITCH TO "DAY MODE". THE ISSUE SEEMS INTERMITTENT. IT SEEMS TO OCCUR IN COOLER TEMPS (<50F).

• 11/10/2019· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  ALL LIGHTS (HEADLAMPS AND TAIL LAMPS AND INSTRUMENT PANEL) TURN OFF WHEN USING TURN SIGNAL. THIS TYPICALLY HAPPENS WHEN CHANGING LANES AT HIGHWAY SPEED. I AM NOT THE ONLY ONE EXPERIENCING THIS PROBLEM. SEEMS TO OCCUR IN 2015-2017 TOYOTA TUNDRAS (1794 & PLATINUM EDITIONS). SEE THREAD. HTTPS://WWW.TUNDRAS.COM/THREADS/AUTO-HEADLIGHTS-SHUT-OFF-WITH-TURN-SIGNAL.22968/PAGE-3

• 11/10/2019· EXTERIOR LIGHTING

  WHEN ENGAGING TURN SIGNAL, ALL LIGHTS EXTINGUISH MOMENATARILY. THIS IS AN INTERMITTEN AND HAPPENS AT RANDOM, BUT NOT CONSTANT. THE FIRST TIME I NOTICED WAS EARLY MORNING BEFORE SUN RISE I WAS IN A TURNING LANE AT A RED LIGHT STOPPED, ENGAGED LEFT TURN SIGNAL AND ALL LIGHTS WENT DARK. THE NEXT TIME I WAS ATTEMPTING TO MERGE AND ENGAGED TURN SIGNAL IN TRAFFIC ALL LIGHTS WENT DARK. I SEARCHED THE INTERNET FORUMS TO FIND THIS IS A COMMON OCCURENCE WITH TUNDRA PLATINUM AND 1794 MODELS. MY VEHICLE HAS NO MODIFICATIONS AND ALL LIGHTING IS FACTORY INSTALLED.

• 11/05/2024· STRUCTURE

  Peeling paint. White paint is separating from primer on hood, and adjacent to windshield on a pillars and the leading edge if the roof.

• 10/29/2018· SERVICE BRAKES

  REAL SAMPLE THE BRAKE CONTROLLER DOESN'T WORK NO MATTER IF YOU SET IT UP TO 9.5 OR 10 DOESN'T DO ANY BRAKE APPLIED.

• 10/18/2016· SERVICE BRAKES

  INTEGRATED TRAILER BRAKE CONTROLLER NOT FUNCTIONING CORRECTLY. IN ELECTRIC MODE, NO POWER SETTING (1-10) IS ABLE TO GET THE TRAILER BRAKES TO LOCK UP WHEN THE TRUCK BRAKES ARE APPLIED. THIS IS A CRUCIAL TEST TO CALIBRATE THE TRAILER BRAKES BEFORE GOING ON THE ROAD, AND DEMONSTRATES THAT THE OUTPUT SIGNAL FROM THE BRAKE CONTROLLER ISN'T SUFFICIENT TO STOP THE TRUCK/TRAILER COMBO IN AN EMERGENCY SITUATION. THE TRAILER BRAKES ARE ABLE TO LOCK UP WITH CERTAIN SETTINGS IF YOU MANUALLY ACTIVATE THE TRIGGER, DEMONSTRATING THAT THE CONTROLLER NOT ONLY HAS THE ABILITY TO LOCK UP THE BRAKES, BUT THAT THE TRAILER ITSELF ISNT THE PROBLEM. THE PROGRAMMING OF THE CONTROLLER IS SUSPECT.

• 10/17/2016· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES

  THE INTEGRATED ELECRIC BRAKE CONTROLLER INCLUDED IN MY PLATINUM EDITION OPTIONS FOR TOWING A TRAILER DOES NOT WORK. ACCORDING TO DEALER, THERE IS NO FIX FROM TOYOTA ALTHOUGH THEY ARE AWARE OF THE ISSUE.

• 10/04/2016· ELECTRICAL SYSTEM

  I BOUGHT A 2016 TUNDRA IN MAY OF 2016. I OWN SOME RANCH PROPERTY IN WEST TEXAS. I HAVE TAKEN THE TRUCK THERE TWICE AND BOTH TIMES I HAVE HAD WIRING DAMAGED BY RODENTS. SO FAR IT IS UP TO OVER 800 DOLLARS. TOYOTA WILL NOT WARRANTY IT.

• 10/03/2016· SERVICE BRAKES

  INTEGRATED BRAKE CONTROLLER (IBC) ON A 2016 TOYOTA TUNDRA FAILS TO ADEQUATELY STOP A TRAILER FITTED WITH ELECTRONIC DRUM BRAKES. WHEN THE BRAKE CONTROLLER IS IN THE ELECTRIC BRAKE MODE, I GET VERY LITTLE BRAKING WITH THE IBC MAXED AT LEVEL 10 ON THE GAIN CONTROL. I CAN MANUALLY STOP THE TRAILER USING THE MANUAL SQUEEZE LEVERS AND THE BRAKES STOP THE TRAILER AND TRUCK, BUT PROVIDES VERY LITTLE BRAKING WHEN USING THE BRAKE PEDAL. THE TRAILER PUSHES THE TRUCK CREATING A VERY DANGEROUS SITUATION. IF I PUT THE BRAKE CONTROLLER IN THE ELECTRIC OVER HYDRAULIC BRAKE MODE, THE BRAKES WORK BY THE BRAKE PEDAL BUT GRAB INSTANTLY AT ONLY A GAIN LEVEL OF (1.5). THE TRAILER BRAKES HAVE BEEN TESTED AND WORK AS EXPECTED WITH AN AFTERMARKET BRAKE CONTROLLER. TOYOTA'S IBC, AS NOTED BY SEVERAL OTHER OWNERS, ON MANY WEBSITES ARE NOT PERFORMING AS EXPECTED WHEN TOWING A TRAILER. IF ROAD SURFACES ARE WET OR ICY THE TRUCK BREAKS WOULD HAVE LITTLE CHANCE TO STOP A LOADED TRAILER AT MAX CAPACITY.

• 10/02/2016· ELECTRICAL SYSTEM

  THE INTEGRATED ELECRIC BRAKE CONTROLER FOR TOWING A TRAILER DOES NOT WORK.

• 09/26/2017· STRUCTURE

  WHILE BACKING UP, I TAPPED A POLE STICKING OUT OF THE GROUND AND DENT MY PLASTIC BUMPER. I TOOK THE VEHICLE INTO A BODY SHOP WHERE THEY HAD TO ORDER THE BUMPER AND ASSEMBLY. SEVERAL DAYS LATER WHILE DRIVING DOWN THE STREET, THE RIGHT REAR PORTION OF THE BUMPER FELL OFF. WHAT HELD IT IN PLACE WAS THE ELECTRICAL FOR THE BACKUP SENSOR. I ENDED UP USING TAPE TO HOLD THE BUMPER TO THE PICKUP AND WENT BACK TO THE BODY SHOP THE NEXT DAY.AS THE PARTS HAD COME IN. TOYOTA SAID THAT SINCE I BACKED INTO THE POLE THERE WAS NO COVERAGE FOR THE BRACKET OR BUMPER EVEN THOUGH THERE WAS A RECALL ON THE BUMPER BRACKETS I LATTER LEARNED.. THE BUMPER BRACKETS THAT HELD THE BUMPER IN PLACE WAS PURCHASED FROM A TOYOTA DEALERSHIP. IF I WAS TAPPED IN A REAR END ACCIDENT AND THE BUMPER FELL OFF IT NOW BECOMES A SAFETY ISSUE WITH THIS VEHICLE. PHOTOS OF THE DAMAGE PRIOR AND THE BUMPER DID NOT FALL OFF. THE BUMPER FELL OFF BECAUSE OF SAFETY DEFECT OF THIS VEHICLE WHILE DRIVING DOWN THE STREET IN THE CITY.

• 09/21/2016· ELECTRICAL SYSTEM,SERVICE BRAKES

  TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHILE TOWING A TRAILER, THE BRAKE PEDAL WAS DEPRESSED; HOWEVER, THE TRAILER BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTEGRATED BRAKE CONTROLLER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 500. THE VIN WAS NOT AVAILABLE.

• 09/13/2017· SERVICE BRAKES

  FRONT ROTORS WARPED IN UNDER 15,000 MILES VIN#[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 09/10/2019· STRUCTURE

  TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHILE THE CONTACT WAS SERVICING THE VEHICLE, THE BUMPER DETACHED WHEN A FRIEND STEPPED ON THE BUMPER. PRIOR TO THE FAILURE, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 17V051000 (STRUCTURE). THE CONTACT DROVE TO AUTONATION TOYOTA SOUTH AUSTIN (4800 S IH 35 FRONTAGE RD, AUSTIN, TX 78745, 512 518-6900) AND WAS INFORMED THAT SINCE THE VEHICLE WAS PREVIOUSLY INVOLVED IN A CRASH, THEY WOULD NOT REPLACE THE BUMPER. THE MANUFACTURER WAS CONTACTED AND SIDED WITH THE DEALER; HOWEVER, THEY FELT THE RECALL SHOULD STILL BE REMEDIED. THE MANUFACTURER REFERRED THE CONTACT TO SAN MARCOS TOYOTA (5101 I-35, SAN MARCOS, TX 78666, 512-392-1999) WHERE THEY POINTED OUT DAMAGE TO THE SIDE AND REAR OF THE VEHICLE AND ALSO REFUSED TO SERVICE THE RECALL. THE CONTACT CALLED THE MANUFACTURER BACK AND FILED A COMPLAINT REGARDING THE REFUSAL OF SERVICE. THE CONTACT DROVE TO UNIVERSAL TOYOTA (12102 I-35, SAN ANTONIO, TX 78233, 726-444-6959) WHERE THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 76,000. THE VIN WAS UNKNOWN.

• 09/08/2017· STRUCTURE

  I PURCHASED A BRAND NEW TOYOTA TRUCK. I STEP ON THE REAR BUMPER WHEN THE TRUCK WAS STATIONARY AND NEARLY BROKE MY LEG, I NOTICED THAT THE REAR BUMPER APPEARED TO HAVE BEEN ALREADY BROKEN. WHEN I TOOK THE NEW TOYOTA TRUCK TO THE PARKER TOYOTA COEUR D'ALENE IDAHO DEALERSHIP THEY SAID THAT THE REAR BUMPER WAS UNDER RECALL. A "...EQUIPPED WITH RESIN REAR STEP BUMPERS AND RESIN REINFORCEMENT BRACKETS AT EACH CORNER." YET THEY DID NOT HAVE THE PARTS. THIS I HAD TO DRIVE AROUND WITH THIS CRACKED BUMPER. THE BUMPER EVENTUALLY CAME OFF ON THE FREE WAY AND BROKE APART. I RETURNED AFTER PARKER TOYOTA IN COEUR D'ALENE, IDAHO HAD THE PARTS AND I HAD THE TIME. BOB TOLD ME THAT TOYOTA WOULD NOT PAY FOR THE BUMPER. THEY TOLD ME THAT IT WAS MY FAULT THAT I STEPPED ON THE PICKUP TRUCK'S BUMPER. I CALLED TOYOTA AND MY CASE NUMBER IS CASE NUMBER: 170-906-0652 JEREMY. THEY SAID PARKER TOYOTA REPORTED THAT THERE WAS SOME DAMAGE TO THE BODY OF THE TRUCK, AND ALSO SINCE I STEPPED ON THE BUMPER THEY WOULD NOT REPLACE THE BUMPER. IF THERE IS ANY DAMAGE TO THE TRUCK, IT IS TINY AND IT HAD TO HAPPEN AFTER THE BUMPER WAS OFF THE TRUCK. TO HAVE ANY DAMAGE TO THE BODY AN ACCIDENT WOULD HAVE HAD TO GO "THROUGH" THE BUMPER. I HAVE DRIVEN AROUND WITH THE CAR FOR NEARLY 1 YEAR AFTER THE BUMPER FELL OFF A NEW TOYOTA TRUCK. STEPPING ON A BUMPER, WHICH IS A VERY NORMAL THING TO DO WITH A PICKUP TRUCK SHOULD NOT VOID THE RECALL. IT IS NOT MY FAULT THAT A BRAND NEW TRUCK HAD A RESIN BRACKET THAT GAVE WAY, INJURING ME, AND BECOMING A ROAD HAZARD. TOYOTA DOES NOT WANT TO PAY TO FIX THEIR PROBLEMS.

• 09/07/2023· STRUCTURE

  The contact owns a 2016 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the vehicle ran off the road during a thunderstorm, causing the driver's and passenger's side curtain air bags to deploy. The vehicle was towed to the dealer, who informed the contact that the headliner needed to be replaced; however, the part to complete the repair was not available. The manufacturer was made aware of the failure and confirmed that parts were not yet available. The failure mileage was approximately 99,000.

• 09/06/2023· ELECTRICAL SYSTEM

  Seat heater stopped working. Turns out there is a burnt connector leading to part number 87501-0C020, which appears to be a seat heater amp. One pin of the connector is completely melted. I've purchased this truck brand new from Toyota. Nobody has ever touched this part. Scared that it could have caught fire.

• 09/06/2017· EXTERIOR LIGHTING

  WHILE DRIVING AT NIGHT TIME, THE WHOLE LIGHTING INCLUDE HEADLIGHT AND INSIDE LIGHT LIKE ODOMETER SCREEN, NAVIGATION SCREEN COMPLETELY BLACK OUT FOR FEW SECOND SOMETIME NEAR A MINNUTE. ITS ONLY HAPPEN WHEN THE BLINKERS ITS USED.

• 09/02/2016· AIR BAGS

  THE TUNDRA WITH A FRONT BENCH SEAT HAS NO AIR BAG FOR THE CENTER PASSENGER.

• 08/28/2017· STRUCTURE

  TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V051000 (STRUCTURE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED (TOYOTA OF EASLEY, EASLEY, SC, 864-855-2233) AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 08/26/2016· SERVICE BRAKES

  I RECENTLY PURCHASED A 2016 TUNDRA TO PULL MY SMALL TRAVEL TRAILER. ON A RECENT TRIP I HAD TO STOP QUICKLY AND REALIZED THAT THE TRAILER BRAKES WERE NOT ACTIVATING. I THEN DID SOME TESTS TO SEE WHAT IT WOULD TAKE TO GET IT TO ACTIVATE AND WAS SURPRISED TO DISCOVER THAT IT WAS NOT BRAKING THE TRAILER AT ALL. I BROUGHT IT TO MY LOCAL TOYOTA DEALER AND THEY TOLD ME THAT THERE WAS A TON OF COMPLAINTS ABOUT THIS ISSUE BUT THEY HAVE NO FIX FOR IT.

• 08/16/2016· SERVICE BRAKES

  THE BRAKE CONTROLLER (IBC) NEEDS TO FUNCTION PROPERLY

• 08/11/2022· STEERING

  The contact owns a 2016 Toyota Tundra. The contact stated while doing a routine check that it was discovered that the power steering assembly was leaking. The vehicle was diagnosed by an independent mechanic, and he stated that the power steering assembly needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were contacted, and they stated that the VIN was not included in NHTSA Campaign Number: 21E103000(Steering). The failure mileage was 53,437.

• 08/09/2023· STEERING

  I was stopped at a turn light to merge left onto freeway and the truck steering went out when trying to turn, it led me into oncoming traffic that was just coming to a stop light, I was able to crank my wheel with all my strength to get to the side of the uphill freeway merge ramp. There were no warning signs. It was so scary and thank goodness I hadn't merged onto the freeway. The component that failed was the power steering assembly, rack and pinion with inner and outer tie rods. I don't believe the parts will be available for inspection since the truck was towed to repair shop. Overall, I was lucky to be alive. My safety was put at risk being unable to properly steer, if I had been going any faster, or even on the freeway there would be no way to control the vehicle. Initially, I was put into oncoming traffic that was coming to a stop. It put myself and everyone around me in danger. The problem has been confirmed by an independent repair shop that truck was towed to. They immediately saw the problem and took several days to fix. Even questioned what I was doing at the time of this event, because something like this just doesn't typically happen. It concerned them so much, that United Wheels and Tires suggested I reach out to Toyota. The vehicle has not been inspected by anyone but the dealer and the tow truck services. Insurance was notified of situation and services dispatched, since the truck was not drivable. There were NO warming lamps, messages or anything on truck. Truck is in perfect condition and drove only on roads (no off-roading or towing, etc.).

• 08/09/2019· WHEELS,UNKNOWN OR OTHER

  REAR WHEEL OR AXLE BEARINGS MAKE A NOTICEABLE LOUD HUMMING SOUND WHEN DRIVING AT ROAD SPEED LIMIT, ESPECIALLY WHEN MOVING SLIGHTLY LEFT INTO A CURVE OR RIGHT INTO A CURVE.

• 08/07/2018· ELECTRICAL SYSTEM

  THE TRAILER BRAKES WILL NOT OPERATE CORRECTLY. THE TRAILER BRAKES WILL NOT LOCK UP EVEN WHEN SET ON 10. VERY DANGEROUS WHEN HAULING ANY TRAILER WITH BREAKS. I HAVE PUT MY OTHER TRUCK TO THE TRAILER AND IT OPERATES GREAT. IT IS ABSOLUTELY THE BREAK CONTROL FROM THE FACTORY NOT THE TRAILER

• 07/28/2017· STRUCTURE

  MY REAR PASSENGER SIDE BUMPER SCRAPED A CEMENT-BLOCK, CAUSING SOME MINOR COSMETIC DAMAGE TO THE BUMPER COVER IN AUGUST 2016. EVERYTHING ELSE WAS FINE, BUT LATER ON I DID STEP ON THE BUMPER AND HEARD A CRACK AND THE BUMPER COLLAPSED. LATER I FIND OUT THAT FROM THE RECALL NOTICE THIS IS A KNOW PROBLEM. AFTER CONTACTING LOCAL DEALER LANCASTER TOYOTA, CORPORATE 1 800 NUMBER, AND EMAIL CORPORATE ALL WERE NOT ABLE TO HELP ME. THEY ALL REFUSE TO FIX THE RECALL DUE TO DAMAGE, BUT THE DAMAGED AREA IS THE RECALLED REINFORCEMENT BRACKET. ALL THE DAMAGE WAS CAUSED BECAUSE I DID STEP STEP ON IT. I DID TRY TO WORK WITH THEM IN CAUSE THEY WANTED ME TO REPLACE THE OUTER BUMPER COVER THAT IS SCRATCHED, BUT THEY TELL ME I NEED TO PAY OUT OF POCKET TO FIX THE WHOLE THING BEFORE THE RECALL IS DONE. THE PROBLEM IS IF I FIX THE WHOLE AREA THERE IS NOT NEED FOR THE RECALL WORK TO BE DONE BECAUSE I WOULD HAVE ALREADY PAID FOR IT. THEY WILL NOT GIVE ME A CLEAR ANSWER IF I WOULD BE REIMBURSED FOR THE RECALLED WORK.

• 07/24/2021· FUEL/PROPULSION SYSTEM

  My truck is shutting off while driving,can be very dangerous.

• 07/23/2026· ENGINE,FUEL/PROPULSION SYSTEM

  2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump that will over heat and burn out connectors again. I called Toyota complaints and they told me they cannot make a dealer do any repairs.

• 07/20/2016· SERVICE BRAKES

  I RECENTLY BOUGHT A TRAVEL TRAILER AND, AFTER READING THE MANUAL, WAS SETTING UP THE INTEGRATED BRAKE CONTROLLER (HERETOFORE REFERRED TO AS THE IBS). I WAS FOLLOWING THE USER MANUAL SUPPLIED WITH MY TRUCK WHEN I PURCHASED IT NEW STEP-BY-STEP. I EVENTUALLY HAD THE GAIN SET TO "10" AND WAS STILL NOT GETTING PROPER BRAKING PRESSURE FROM THE TRAILER. I GOT OUT, CHECKED ALL CONNECTIONS, RESTARTED THE TRUCK AND TRIED AGAIN; SAME ISSUE. I CONNECTED A FRIENDS TEKONSHA P3 THROUGH MY TRUCKS IBC CABLE (USING HIS CABLE ADAPTER) AND TRIED AGAIN WITHOUT A PROBLEM. THIS CONFIRMS IT'S NOT A TRAILER OR WIRING ISSUE. I RECONNECT THE IBC AND RESTARTED THE TRUCK, TRYING AGAIN; SAME ISSUE. I TOOK IT TO THE DEALER AND THEY SHRUGGED THEIR SHOULDERS, SAID THEY SAW BEFORE WITH NO RESOLVE, AND SUGGESTED I BUY AN AFTERMARKET BRAKE CONTROLLER, TOO. I THEN LOOKED ONLINE AND FOUND SEVERAL HUNDRED OTHERS EXPERIENCING THE SAME PROBLEM, REQUIRING THAT THEY BUY AN AFTERMARKET BRAKE CONTROLLER TO COMPENSATE FOR THIS ONE (TWO LINKS ARE AT THE BOTTOM OF THIS COMPLAINT). THE DEALERS AND TOYOTA ARE UNABLE/UNWILLING TO DO ANYTHING. THIS NEEDS TO BE ADDRESSED. HTTPS://WWW.TUNDRAS.COM/THREADS/FACTORY-BRAKE-CONTROLLER-ISSUES.5103/ HTTP://WWW.TUNDRATALK.NET/FORUMS/TUNDRA-PROBLEMS-MAINTENANCE-REPAIR-DEALER-WARRANTY-ISSUES/562250-2016-BRAKE-CONTROLLER-PROBLEMS-9.HTML

• 07/16/2018· ELECTRICAL SYSTEM

  LOCK ACTUATOR WENT OUT ON TRUCK AFTER ONLY 2 YEARS. PER DEALER THIS IS A KNOWN ISSUE. FOUND ONLINE THAT IT IS VERY COMMON IN NEWER TOYOTA VEHICLES AND OFTEN OCCURS ON ALL 4 DOORS. COSTLY TO REPAIR AND SHOULD NOT GO OUT THAT QUICKLY.

• 07/13/2017· UNKNOWN OR OTHER

  IBC DOES NOT FUNCTION

• 07/11/2016· SERVICE BRAKES

  BUILT IN BREAK CONTROLLER IS NOT WORKING PROPERLY. WITH FULL GAIN, IT DOES NOT APPLY THE CORRECT AMOUNT OF BRAKES TO MY TRAILER. THIS IS VERY DANGEROUS AND COULD LEAD TO AN ACCIDENT.

• 07/09/2020· POWER TRAIN,WHEELS

  REAR WHEEL BEARINGS FAILED (BUT STILL FUNCTIONAL) AT 17000 MILES. WHEELS STILL ROTATE BUT THERE IS A VERY LOUD DRONING NOISE AT HIGHWAY SPEEDS WITH A SLIGHT SQUEAL AT LOWER SPEEDS. NON-TOYOTA MECHANICS HAVE EXPRESSED CONCERNS ABOUT DRIVING THE VEHICLE AS BEARINGS CAN FAIL ALTOGETHER AND SEIZE THE WHEELS.

• 07/09/2019· UNKNOWN OR OTHER,SERVICE BRAKES

  INTEGRATED TRAILER BRAKE CONTROLLER INTERMITENT FAILURE. TRAILER BRAKES WORK FOR A FEW BRAKING CYCLES THEN FAIL COMPLETELY WITH AN ERROR MESSAGE ON THE TRUCK OF "TRAILER WIRING TYPE, OR CONNECTION FAULT". TURNING THE VEHICLE OFF AND ON RESETS THE CONTROLLER AND "FIXES" THE PROBLEM UNTIL ANOTHER FEW BRAKING CYCLES, THEN REPEATS.

• 07/06/2016· SERVICE BRAKES

  TRUCK IS RATED TO TOW 9100LBS, AND INCLUDES AN INTEGRATED TRAILER BRAKE CONTROLLER FOR USE WITH ELECTRIC TRAILER BRAKES (WHICH IS NEW FOR 2016 TUNDRA'S). THE FIRST TIME I HOOKED THE TRUCK UP TO THE TRAILER, I SET UP THE TRAILER BRAKES USING THE OWNERS MANUAL. AFTER PULLING OUT ONTO THE STREET I IMMEDIATELY NOTICED THAT WHEN I PRESSED THE BRAKES THE TRAILER BRAKES FAILED TO ENGAGE. MY TRAILER WEIGHS NEARLY 8000LBS. LUCKILY, THE MANUAL SLIDER WORKS TO ENGAGE THE TRAILER BRAKES, BUT EVEN ON A GAIN SETTING OF 10 (MAX) THE FOOT BRAKE FAILS TO ADEQUATELY ENGAGE THE BRAKES ON MY TRAILER. I HAVE TRIED 2 OTHER TRAILERS, AND TALKED TO MULTIPLE 2016 TUNDRA OWNERS ONLINE AND THIS PROBLEM IS CONSISTENT ACROSS ALL TUNDRA'S TOWING ANY TYPE TRAILER. UNDER HARD BRAKNG AT ANY SPEED MY TRAILER WANTS TO JACKNIFE AND PUSH THE TRUCK OUT OF IT'S WAY, BECAUSE THE BRAKES ON THE TRUCK ARE ENGAGING TO MAX AND THE TRAILER BRAKES ARE HARDLY ENGAGING AT ALL EVEN ON MAX GAIN SETTING. THIS IS A SERIOUS ISSUE THAT NEEDS TO BE RESOLVED AND TOYOTA IS NOT COMING FORWARD WITH A FIX. THEY CLAIM THE CONTROLLER IS "WORKING AS DESIGNED", BUT I TOW 8000LBS BEHIND ME AND WITHOUT ADEQUATE TRAILER BRAKES A SERIOUS ACCIDENT IS JUST WAITING TO HAPPEN. SOMEONE NEEDS TO STEP IN AND FORCE TOYOTA TO ADDRESS THIS SERIOUS ISSUE BEFORE SOMEONE IS HURT OR KILLED. LUCKILY THE MANUAL SLIDER STILL WORKS, BUT THAT IS A BANDAID SOLUTION EVERY TUNDRA OWNER CAN'T BE EXPECTED TO DRIVE AROUND MANUALLY APPLYING THE TRAILER BRAKES SEPARATE FROM THE FOOT BRAKE. IF I CAN STOP MY TRAILER FASTER WHEN MANUALLY APPLYING THE TRAILER BRAKES THAN THE TRUCK WILL STOP WITH JUST THE FOOT BRAKE, THAN SOMETHING IS OBVIOUSLY DEFECTIVE! IN WHAT SCENARIO WOULD TOYOTA EVER WANT MY TRUCK TO STOP LESS QUICKLY IN A MAX BRAKING SITUATION? IT DOESN'T MAKE SENSE, AND THEY NEED TO COME UP WITH A SOLUTION!