2016 Toyota Highlander Hybrid

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2015· UNKNOWN OR OTHER

  WHEN I PURCHASED THIS 2016 TOYOTA HIGHLANDER LE IN MID DECEMBER, I DID NOT REALIZE UNTIL I GOT IT HOME, THERE WAS NO INTERIOR REAR DOOR RELEASE. NO RELEASE BUTTON ON THE DASH AND NO INTERIOR DOOR HANDLE. I WENT BACK TO THE DEALERSHIP, FOUND MY SALESMAN AND ASKED HIM IF THERE WAS AN INTERIOR DOOR RELEASE. HE TOLD ME THERE WAS NOT AND "THAT'S WHY THEY OFFER THE LE PLUS MODEL WHICH HAS A POWER REAR DOOR WITH INSIDE RELEASE". EVERY VEHICLE I'VE OWNED SINCE 1998 HAS HAD AN INSIDE TRUNK OR REAR DOOR RELEASE. IT SEEMS LIKE A HUGE SAFETY ISSUE TO ME, HOW WOULD ANYBODY ESCAPE FROM THE BACK IN CASE OF FIRE OR OTHER TRAGEDY? AREN'T PASSENGER VEHICLES REQUIRED TO BE MANUFACTURED WITH AN INSIDE RELEASE/DOOR HANDLE?

• 12/26/2023· ELECTRICAL SYSTEM,ENGINE

  2016 toyota highlander le model v-6 cylinder. The FUEL PUMP runs after engine has been turned off for several hours, even up to as many as 8 hours. This situation can be heard in a closed in garage, in the completely quiet of night time, and at multiple times during the same time period. It happens intermittently with various levels of gas in the tank. The length of time FUEL PUMP can run can be as little as 10 minutes to over 60 minutes.

• 12/23/2016· ELECTRICAL SYSTEM,ENGINE

  MY CAR ENGINE STARTED ON ITS OWN AFTER BEING TURNED OFF. I WENT SHOPPING AT WALMART AND PARKED MY 2016 TOYOTA HIGHLANDER XLE IN THE PARKING LOT. I PUT THE CAR IN PARK AND PUSHED THE ENGINE START/STOP BUTTON TO TURN OFF THE CAR. MY FAMILY AND I EXITED THE CAR AND I USED THE KEYLESS ENTRY PAD TO LOCK THE DOORS. WE SHOPPED FOR APPROXIMATELY 45 MIN. WHEN WE RETURNED TO THE CAR, I USED THE KEYLESS ENTRY PAD TO UNLOCK THE DOORS SO I COULD PUT OUR PURCHASES IN THE TRUNK. AS I GOT CLOSE TO THE VEHICLE I HEARD AN ENGINE RUNNING, BUT THOUGHT IT WAS THE CAR NEXT TO US. I BENT DOWN AND LISTENED UNDER THE FRONT END OF MY HIGHLANDER AND TO MY SURPRISE, I REALIZED MY CAR ENGINE WAS RUNNING. WHEN I OPENED THE DRIVER SIDE DOOR AND LOOKED AT THE DASHBOARD, I NOTICED A SMALL TRIANGULAR YELLOW CAUTION LIGHT WAS FLASHING BUT I DON'T REMEMBER WHAT THE MESSAGE SAID OTHER THAN CAUTION. IF MY CAR RANDOMLY STARTS ON ITS OWN WHILE ITS IN A GARAGE, IT COULD CAUSE TOXIC FUMES TO FILL MY GARAGE IF LEFT ON LONG ENOUGH, AND COULD CAUSE HARM OR DEATH TO SOMEONE WHO BREATHES IT IN. AFTER READING ABOUT THE BRAKE/HYDRAULIC RECALL ON SOME 2015-2016 HIGHLANDERS, COUPLED WITH THE RECENT ISSUE I HAD AT WALMART, I AM NERVOUS ABOUT DRIVING MY CAR. I WISH I HAD READ ABOUT THESE ISSUE BEFORE BUYING MY CAR 30 DAYS AGO. I THOUGHT I HAD DONE MY HOMEWORK AND READ SEVERAL WEBSITES BEFORE BUYING THE CAR, BUT I WILL READ RECALL REPORTS BEFORE BUYING A CAR FROM NOW ON.

• 12/20/2017· STRUCTURE

  I LOADED A KAYAK THAT IS ABOUT 13' LONG AND WEIGHS 60 LBS. ONTO MY TOYOTA FACTORY CROSSBARS. WHEN DRIVING ON THE FREEWAY WE HEARD CRACKING AND POPPING NOISES. THINKING IT WAS THE STRAPS IN THE WIND, I PULLED OVER ONLY TO FIND THE STRAPS SECURE. WE WERE ON A TRIP AND KEPT GOING. AFTER HEARING THE NOISE ON AND OFF WE GOT TO OUR DESTINATION AND FOUND A WARPED ROOF AND DENTS IN THE ROOF. THIS SHOULD NOT HAPPEN TO A ROOF OF A VEHICLE. I WOULD EXPECT THE CROSS BARS TO FAIL BEFORE THAT WOULD HAPPEN. AFTER A FEW ATTEMPTS, TOYOTA FINALLY HAD AN AREA REP. LOOK AT IT. THEY OFFERED TO HAVE PAINLESS DENT REMOVAL OR $1,000 OFF OF ANOTHER TOYOTA. I DIDN'T WANT EITHER OPTION. THE PDR WOULD HAVE DONE NOTHING AND THE DAMAGE WOULD COME RIGHT BACK. THEY WERE NOT BELIEVING ME THAT CARRYING A LOAD ON THE CROSSBARS DID THAT. WELL, I SWEPT IT UNDER THE RUG FOR A FEW MONTHS AND THIS FALL I HAD TO CARRY A 2X10 BOARDS ON TOP AND AGAIN, WITH FREEWAY SPEEDS DID IT AGAIN. NOW AT CHRISTMAS TIME, WE CUT A TREE DOWN AND LOADED IT ON TOP AND AGAIN, MORE NOISES AND NOW THERE IS MORE DAMAGE THAN THE FIRST PICTURES I TOOK THE FIRST TIME IT HAPPENED AND THE CREASES AND DENTS ARE DEEPER. SOMETHING IS STRUCTURALLY NOT RIGHT WITH MY 16' TOYOTA HIGHLANDER AND TOYOTA WILL DO NOTHING TO HELP. I'M OUT OF OPTIONS AND I HOPE SOMEONE AT NHTSA CAN HELP! I HAVE A $40K SUV THAT I CONSIDER A LEMON. (SEE ATTACHED FOR MORE INFORMATION AND MY ATTEMPTS TO ASK TOYOTA FOR HELP) THANKS! [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

• 12/16/2024· ENGINE

  The water pump on my 2016 Toyota Highlander XLE disintegrated while I was driving in heavy traffic. The pulley came loose from the water pump shaft. I have the water pump. Our safety was at risk because this happen in heavy traffic and it could have effected my control of the vehicle if it had came off completely. The pulley was wedge between the wheel well and fame. I sent a claim to Toyota and it was rejected due to the vehicle be out of warranty. I'm saying this is a manufacturing defect. No warning before it happen.

• 12/14/2017· VISIBILITY/WIPER

  THE BULKY SIDE MIRRORS ON THE TOYOTA HIGHLANDER BLOCK THE DRIVER'S VIEW OF ONCOMING TRAFFIC WHEN MAKING A LEFT HAND TURN. I HAVE ON AT LEAST THREE OCCASIONS BARELY MISSED A COLLISION BECAUSE OF VISIBILITY ISSUES RELATED TO THE BULKY SIDE WINDOW ON THE DRIVER'S SIDE. MY ELDERLY AUNT DRIVING A 2017 TOYOTA HIGHLANDER WAS RECENTLY INVOLVED IN A SERIOUS COLLISION BECAUSE OF VISIBILITY ISSUES RELATED TO THE BULKY SIDE MIRROR, I WILL LET HER FILE HER OWN COMPLAINT

• 12/11/2020· ENGINE

  CRANKSHAFT POSITION SENSOR INOPERATIVE DURING NORMAL USE

• 12/03/2018· UNKNOWN OR OTHER

  VEHICLE REAR WINDSHIELD EXPLODED FOR NOT REASON. VEHICLE WAS PARKED FOR TWO DAYS SAME SPOT IN HOME FENCE AREA AND I STARTED IT AND SHUT THE DRIVER DOOR AND IMMEDIATELY HEARD A SOUND AND LOOKED THE REAR MIRROR AND IT WAS GONE MEANING COMPLETE SHATTERED IN PIECES. I HAVE PICTURE TO CLARIFY THE DAMAGE AND TOYOTA COURTESY DEALER DECLINE TO REPAIR IT SINCE THERE IS NO RECALL. I USUALLY HAVE MY GRANDCHILDREN WITH ME IN THE VEHICLE SO YOU COULD IMAGING HOW DESPERATE IT WOULD HAVE BEEN FOR MY FAMILY AT THAT MOMENT IF THEY WERE WITH ME. PLEASE ASSIST ME WITH THIS ISSUE AS SOON AS POSSIBLE. THERE ARE SOMETIME THAT THIS CAN BE EXPEDITED WHEN IT IS A SAFETY HAZARD AND THIS ISSUE IS ONE OF THEM. THANK YOU!

• 12/02/2024· SERVICE BRAKESCrash

  The contact owned a 2016 Toyota Highlander. The contact stated that while driving at an undisclosed low speeds on a decline, the brake pedal depressed all the way to the floorboard. As a result, the vehicle rolled downhill into a busy intersection and was struck by another vehicle on the passenger side door. The air bags did not deploy. No warning lights were illuminated. The vehicle was towed to a tow yard and deemed at total lose by the contacts insurance provider. A police report was filed with no injuries reported. The manufacturer was notified of the failure; a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 62,000.

• 12/02/2017· WHEELS

  ON NOVEMBER 27 2017 THE RIGHT REAR TIRE SUFFERED A MAJOR BLOWOUT CAUSING THE VEHICLE TO GO OUT OF CONTROL. I WAS ABLE TO STABILIZE THE VEHICLE. AAA PLACED THE SPARE ON THE VEHICLE AND WE DROVE IT TO LAKELAND TOYOTA IN LAKELAND FLORIDA. THEY GAVE US A RENTAL VEHICLE AND SAID THEY WOULD REPLACE THE TIRE IN A COUPLE OF DAYS. WE WERE ON OUR WAY TO PORT CANAVERAL TO GO ON A CRUISE. ON FRIDAY WE RETURNED TO THE DEALERSHIP AND WAS ADVISED THAT THEY WOULD NOT HONOR THE WARRANTY ON THE TIRE AND CHARGED US $327.09 FOR A NEW TIRE. I REQUESTED. THE OLD TIRE SO I COULD HAVE IT EXAMINED AND THEY SAID THEY HAD TURNED IT OVER TO WASTE DISPOSAL. I ADVISED THEM THAT VIOLATED THE SPOILATION DOCTRINE IN THIS STATE. THE VEHICLE AND TIRE HAD 6805 MILES. AT THE TIME OF THE BLOWOUT THE VEHICLE WAS IN MOTION DRIVING THE SPEED LIMIT OF 70MPH ON INTERSTATE 4 ON THE WAY TO PORT CANAVERAL. I HAVE THE RECORDS OF LAKELAND TOYOTA FOR YOUR REVIEW...THE TIRE WAS A BRIDGESTONE DUELER HL 422 P245/55R19. I TOLD THE CUSTOMER SERVICE REPRESENTATIVE THAT IT WAS WRONG FOR THEM TO NOT HONOR THE WARRANTY ESPECIALLY IN LIGHT OF PRIOR PROBLEMS WITH BRIDGESTONE/FIRESTONE TIRES..AND THEY SHOULD REPORT THE MATTER TO YOUR AGENCY

• 11/29/2017· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, IT AUTOMATICALLY TURNED ON WITHOUT WARNING. THE CONTACT HAD TO PUSH THE IGNITION SWITCH TO STOP THE VEHICLE. THE CONTACT ALSO STATED THAT THERE WAS A LOUD NOISE WHEN THE IGNITION SWITCH WAS TURNED ON. THE CONTACT TURNED OFF AND TURNED ON THE VEHICLE, AND THE LOUD NOISE STOPPED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

• 11/20/2024· ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

  The contact owns a 2016 Toyota Highlander. The contact stated that while the vehicle was parked, the trunk power switch failed to function as intended. The contact stated that the trunk power switch was enabled to unlock, however the trunk door did not unlock. The contact stated that the trunk power switch failed to unlatch the trunk door and the trunk door was stuck. The vehicle was taken to an independent mechanic where it was diagnosed with battery failure due to a lack of voltage. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the failure reoccurred intermittently. The manufacturer was made aware of the failure. The contact stated that a Representative provided remedy options over the phone. The contact stated that the failure reoccurred intermittently. The failure mileage was approximately 48,000.

• 11/15/2022· STRUCTURE

  DRIVING ON HIGHWAY AND SUNROOF EXPLODED. SOUNDED LIKE A GUN SHOT.

• 11/15/2018· EXTERIOR LIGHTING,UNKNOWN OR OTHER,SERVICE BRAKES

  BRAKES HAVE A SLIGHT VIBRATION WHEN TRAVELING AT HIGH SPEEDS IN THE CITY AND SOMEONE IS STOPPED ON THE FREEWAY. MY LIGHTS HAVE DIMMED DRAMATICALLY SINCE I FIRST PURCHASED NEW. THE PASSENGER SIDE DAYTIME RUNNING LIGHT IS FULL OF MOISTURE. MOST IMPORTANTLY, THE TEMPERATURE SENSOR AND/OR AC FAN/MOTOR IS HALFWAY FUNCTIONING AT 38K! BY THIS, I MEAN THAT THE AC IN THE FRONT OF THE CAR KICKS ON AND OFF IN THE MIDDLE OF COOLING AND IT BLOWS 50% OF WHAT IT DID WHEN I BOUGHT THE CAR. CONVENIENT TOYOTA?

• 11/11/2021· UNKNOWN OR OTHER

  After shopping, we went to open the trunk of our Highlander by pressing the button. As it opened, we heard a crunching sound from the top but the trunk continued to open. It then reached the point where suddenly the top spoiler was dislodged and the back window's glass exploded outward in a thousand small pieces all over my husband. At no point did a safety mechanism turn on to stop the trunk from opening. We had a few prior experiences with the trunk failing to stop if something was in its way, demonstrating that there is an issue with the sensor or there is no sensory system in the car that would prevent it from crushing something or someone. After contacting Toyota, they stated that this was not covered under the warranty of the vehicle.

• 11/06/2023· VISIBILITY/WIPERCrash

  The side view mirrors are positioned in a way that completely blocks visibility on the sides of the car, especially when making a left-hand turn. After owing the vehicle for several weeks, I collided with another car when making a left-hand turn. I couldn't see the car when turning until it was too late. I've been driving for 30+ years and have never had an accident before. I had another close call several weeks ago, and my husband almost didn't see a pedestrian because of the visibility issue. I looked up the problem online and see that many other have had this same problem. Please look into it. I called Toyota but they don't have a recall and said they couldn't help. I plan to change out my side view mirrors but wanted to bring this to your attention so that no one gets hurt by this issue. Thank you.

• 11/03/2020· STEERING

  MONDAY 2, 2020 AND ON THE FRIDAY BEFORE AND 2 OTHER TIMES ,THE STEERING WHEEL ICON WOULD SHOW ON DASH. AND ON AT LEAST TWICE WHILE DRIVEING STEERING WOULD LOCK UP SO BAD ,IT REQUIRED YOUR WHOLE BODY WEIGHT TO TURN A SMALL AMOUNT . THOUGHT I WAS GOING TO BE KILLED! PULLED OVER AND SHUT OFF ENGINE AND RESTARTED ENGINE AND THAT PUTS SEERING BACK TO NORMAL FOR A LITTLE WHILE. TOOK TO DEALERSHIP 11/02/2020 THEY SAID NOT UNDER WARRANTY, { 56125 MILES} BY THE WAY! TOLD ME 1400.00 PLUS TAX! THEY SAID THEY NEVER SEEN THIS BAD TOLD I SHOULDN'T DRIVE IT HOME, HAD TO FIND A RIDE HOME. THE Y WILL REPLACE THE ECU WHICH IS 700.00 BY ITSELF ON 11/03/2020. IM NOT SURE TOYOTA IS WHAT THEY USED TO BE. AND WE HAVE OWNED 5 TOYOTA'S!

• 11/01/2018· STEERING

  I WAS JUST PROCEEDING FROM A STOP AT A 4 WAY INTERSECTION GO VERY SLOWLY WHEN I RECEIVED A WARNING ON MY DASHBOARD SAYING "EPS FAILURE, STEERING WHEEL HARDER TO TURN". I WAS THEN PHYSICALLY UNABLE TO TURN THE STEERING WHEEL, ALMOST AS IF THE POWER STEERING WAS DISABLED. THIS WAS AT AN EXTREMELY BUSY INTERSECTION AND I ALMOST HIT A TELEPHONE POLE. EVEN WHEN TRYING TO BACK UP AND TURN, MY VEHICLE WAS UNABLE TO STEER OTHER THAN GOING STRAIGHT FORWARD AND BACK. AFTER TURNING THE VEHICLE OFF AND RESTARTING IT, THE ERROR WENT AWAY AND MY STEERING RESUMED AS NORMAL, BUT I SMELLED A BURNING SMELL. THIS WAS A VERY SCARY INCIDENT AND I COULD HAVE BEEN SERIOUSLY INJURED IF I HAD HIT THE TELEPHONE POLE, IF I HAD BEEN GOING FASTER, OR SOMEONE IN THE INTERSECTION COULD HAVE HIT ME. THERE WAS A RECALL FOR THIS EXACT ISSUE IN THE 2015 MODEL AND IT SHOULD PROBABLY BE EXPANDED AS THIS ISSUE SEEMS TO EXIST WITH THE 2016 MODEL AS WELL.

• 10/30/2023· SUSPENSION

  Had cv boot and control arm work at 30k miles caught it in time in 2021 and dealer fixed it. 2 years later same issue if i had bot taken it to dealer and just did oil changes myself cv boot and control arm would break during operation. Seems like they have serious issues with cv boots and control arms at low miles. I only have 50k miles to have a second replacement.

• 10/30/2019· SERVICE BRAKES

  I'VE HAD TWO SERIOUS INCIDENTS INVOLVING THE CAR'S AUTO BRAKING SYSTEM WE BOUGHT AS PART OF A SAFETY PACKAGE. BOTH WERE IDENTICAL. EACH TIME I WAS DRIVING ON A MAJOR HIGHWAY AND THE CAR DETECTED A POTENTIAL SIDE IMPACT CRASH. BOTH TIMES, I SAW THE HAZARD IN TIME AND GIVEN THE CLOSE PROXIMITY OF TRAFFIC BEHIND BE AND THE HIGH RATE OF TRAFFIC FLOW SPEED I DETERMINED MY BEST CHANCE AT AVOIDING THE CRASH WAS TO ACCELERATE PAST THE SIDE IMPACT HAZARD. THE CAR DISAGREED AND SLAMMED ON THE BRAKES. THIS CAUSED ME TO ALMOST LOSE CONTROL OF THE CAR BECAUSE MY SPEED BOTH TIMES WAS >70 MPH. AND IT WOULD HAVE CAUSED A SERIOUS MULTI-CAR COLLISION FROM BEHIND. THE FIRST TIME IT OCCURRED I WENT STRAIGHT TO A TOYOTA DEALER AND ASKED HOW TO 'TURN OFF' THE SYSTEM. THEY SAID THEY CAN'T WITHOUT DISMANTLING EVERY ASPECT OF THE CAR'S SAFETY FEATURES. AFTER WATCHING ANOTHER TOYOTA GO THROUGH WHAT I BELIEVE WAS A SIMILAR INCIDENT WHILE DRIVING THROUGH A TUNNEL RECENTLY, I AGAIN VISITED A TOYOTA. THEY SEEMED INTERESTED IN THE COMPLAINT BUT HAD NO IDEAS FOR ME AS TO WHAT TO DO ABOUT IT. SAID THEY'D RECEIVED NO OTHER COMPLAINTS, WHICH I FIND DIFFICULT TO BELIEVE.

• 10/29/2016· AIR BAGSCrash

  I HAD AN ACCIDENT ON MY CAR GOING 50 TO 60 MPH I THE ROAD CURVED AND I DID NOT I WENT INTO THE TOP OF THE DITCH HIT FRONT END AND WENT AIRBORN 30 TO 50 FEET IN THE AIR OVER THE PERSONS DRIVWAY. I LANDED ON MY BACK BUMPER WHICH THEN PROPELLED ME BACK INTO THE AIR AND I FLIPPED END OVER END LANDED ON MY TIRES. NOT ONE OF THE AIRBAGS DEPLOYED IN THIS ACCIDENT. THE OFFICER AT THE SCENE WAS SHOCKED. I HIT MY HEAD ON THE STEERING WHEEL THE HEAD REST BROKE I HET IT SO HARD AND THE B PILLAR OF THE CAR. I WAS ON A HIGHWAY.

• 10/25/2020· STEERING

  2016 TOYOTA HIGHLANDER 30,000 MILES EPS FAILURE STEP ON THE BREAK IN THE MORNING EPS FAILURE WITH THE FLASHING LIGHT SHUT IT OFF STEP ON THE BREAK AGAIN START IT AND SOMETIMES IT'S BACK TO NORMAL READ ABOUT THE 2015 HAVING THIS PROBLEM TRULY THING THIS TRUCK WAS BUILT TOWARDS 2015 MORE THAN INTO 2016 THINK IT SHOULD BE LOOKED INTO I KNOW THEY HAD PROBLEMS IN 2015 WITH IT FOR A 2016 WITH 30,000 MILES YOU SHOULD HAVE NO PROBLEMS. TRULY WOULD LIKE TO RESPOND IN SOME SORT INVESTIGATION TO SEE IF IT WAS BUILT TOWARDS THE TAIL END OF 2015. STATIONARY ALWAYS HAPPENED STARTING IT UP HAPPENED TWICE IN DECEMBER2019 DIDN'T THINK ANYTHING OF IT STARTED HAPPENING FREQUENTLY SEPTEMBER 2020

• 10/24/2018· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE DRIVING 50 MPH, THE BRAKES MALFUNCTIONED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER (PRIORITY TOYOTA SPRINGFIELD, 7601 LOISDALE RD, SPRINGFIELD, VA 22150, (703) 269-1400) TO BE DIAGNOSED, BUT NO FAILURE WAS FOUND. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 30,000.

• 10/24/2016· AIR BAGSCrash

  I OWN A 2016 HIGHLANDER LIMITED PLATINUM AND AFTER A MAJOR ACCIDENT I HAVE A SERIOUS CONCERN ABOUT THE SAFETY CLAIMS. YESTERDAY MY WIFE WAS IN A ROLLOVER (2 FULL ROTATIONS) ACCIDENT IN HER 2016 HIGHLANDER PLATINUM. CAR WAS DESTROYED, HER HEAD HIT BOTH THE STEERING WHEEL AND THE B-PILLAR, BOTH HAVE AIRBAGS. NOT A SINGLE AIRBAG WAS DEPLOYED. DRIVER AND FRONT PASSENGER SEAT-MOUNTED SIDE AIRBAGS, DRIVER KNEE AIRBAG, FRONT PASSENGER SEAT-CUSHION AIRBAG AND ALL-ROW ROLL-SENSING SIDE CURTAIN AIRBAGS = ALL A TOTAL FAIL, NONE OF THAT WORKED. THE ONSTAR LADY DID HOWEVER SENSE THE ACCIDENT AND DISPATCH AN AMBULANCE AND POLICE, THAT WAS EXCELLENT. WHATEVER CAR I GET AS A REPLACEMENT WILL DEFIANTLY HAVE THAT. NOT REAL HAPPY ABOUT THE SAFETY ON THIS VEHICLE. ONE OF THE REASONS THAT WE PURCHASED THIS VEHICLE WAS THE IIHS RATING ON THE VEHICLE. RIGHT ON THERE SITE IT TALKS ABOUT THE SAFETY AND THE AIRBAG ROLL SYSTEM BUT THE REALITY IS IN A ROLLOVER THIS DID NOT WORK I WILL HAVE THE ACCIDENT SCENE PICTURE LATER TODAY. I CURRENTLY ONLY HAVE SOME OF THE VEHICLE AFTER IT WAS TOWED.

• 10/19/2017· VISIBILITY

  TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE DRIVING 60 MPH, THE CONTACT HEARD AN ABNORMAL EXPLOSION SOUND. ONCE THE CONTACT EXITED THE HIGHWAY AND PULLED OVER, SHE OBSERVED THAT THE SUN ROOF HAD FRACTURED. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THEY WERE AWARE OF THE FAILURE, BUT THERE WAS NO RECALL IN PLACE. THE CONTACT WAS ADVISED TO SCHEDULE AN APPOINTMENT AND THAT THE SUN ROOF WOULD BE REPLACED FREE OF CHARGE. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (LIA TOYOTA OF WILBRAHAM, 2145 BOSTON RD, WILBRAHAM, MA, 01095) WHERE THE SUN ROOF WAS REPLACED FOR FREE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.

• 10/12/2017· UNKNOWN OR OTHER

  PANORAMIC SUNROOF EXPLODED

• 10/05/2018· SERVICE BRAKES

  I WAS STOPPED AND IN PARK WITH THE VEHICLE RUNNING WHEN THE "CHECK VSC SYSTEM," "CHECK ABS, BRAKE MALFUNCTION" WARNING LIGHTS CAME ON. THEY HAVE SINCE GONE AWAY AND RETURNED INTERMITTENTLY. FORTUNATELY, THERE WAS NO FAILURE WHILE IN MOTION, BUT DEALER ESTIMATED $4600 FOR REPAIR. IF THIS IS THE SAME PROBLEM FOR WHICH WARRANTY COVERAGE WAS EXTENDED FOR 2006-07 MODELS, THIS APPEARS TO BE AN ONGOING ISSUE.

• 09/28/2017· AIR BAGS,SERVICE BRAKESCrash

  TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 20 MPH, THE BRAKES MALFUNCTIONED AND THE CONTACT'S VEHICLE REAR ENDED ANOTHER VEHICLE. THE CONTACT STATED THAT THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT'S VEHICLE SUSTAINED SIGNIFICANT FRONT END DAMAGE, BUT THE AIR BAGS DID NOT DEPLOY. THE FRONT PASSENGER SUSTAINED CHEST INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (KENNY KENT TOYOTA IN EVANSVILLE, IN) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,600.

• 09/24/2019· SERVICE BRAKES

  BRAKES DID NOT WORK AND CAR WENT THROUGH A 4 WAY STOP SIGN. DATES WENT OUT: SEPTEMBER 2019, OCTOBER 2019. BRAKES FAILED ON A NORMAL DAY DRIVING UNDER 30 MPH IN RESIDENTIAL AREA.

• 09/20/2020· UNKNOWN OR OTHER

  HAS THERE BEEN ANY RECALLS IN MY VEHICLE THAT I HAVEN'T ADDRESSED OR TAKEN CARE OF? I AM ON THE ROAD QUITE A BIT AND WAS NOTED OF SEVERAL PAST RECALLS. THANK YOU . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 09/19/2020· UNKNOWN OR OTHER

  MY SUV S SUNROOF SHATTERED WHILE DRIVING ON A SUBURBAN STREET WITH TWO KIDS IN CAR SEATS BEHIND ME . IT SOUNDED LIKE AN EXPLOSION . GLASS IS ALL OVER THE CAR , IT HAS TO BE TOWED AND I NEED A RENTAL CAR AND I HAVE TO FILE A CLAIM FOR MY INSURANCE NOW.

• 09/15/2016· SUSPENSION

  TOWING CAPABILITIES ARE NOT CONGRUENT WITH THE SPECIFICATION PER MANUAL... REAR SUSPENSION IS VERY WEAK AND CANNOT HANDLE THE WEIGHT OF THE CABIN CARGO AND THE WEIGHT OF TRAILING UP TO 5,000 LBS SAFELY... MULTIPLE PICTURES (1 ATTACHED) TAKEN BUT DID NOT DRIVE ON THE ROAD FOR SAFETY REASONS FOR IT PASSENGERS

• 09/12/2019· ELECTRONIC STABILITY CONTROL (ESC)

  WHEN DRIVING, PERIODICALLY, UNDER NO PARTICULAR ROAD OR WEATHER CONDITION, THE "CHECK AWD SYSTEM," "ABS," "BRAKE" AND "STABILITY CONTROL" WARNING LIGHTS LIGHT UP. WHEN WARNING LIGHTS ARE ON, ONLY THE FRONT WHEELS WILL DRIVE AND STABILITY CONTROL IS INACTIVE. REAL WHEELS ARE NOT ACTIVE. THIS CONDITION MAY LAST FIVE TO TEN MINUTES, THEN RETURN TO NORMAL. THIS HAS OCCURRED 10 TO 15 TIMES IN THE LAST SIX MONTHS.

• 09/06/2018· UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  STOPPED IN INTERSECTION WAITING TO MAKE A LEFT TURN. WHEN ATTEMPTING TO ACCELERATE ENGINE DID NOT START HYBRID WARNING STATED HYBRID SYSTEM FAILURE STOP IMMEDIATELY. GLIDED TO A PARKING SPACE. ATTEMPTED TO RESTART ENGINE CONTINUE TO GET SAME WARNING. AFTER THREE ATTEMPTS CALLED AAA AND TOYOTA DEALERSHIP. I WAS URGED TO TOW THE VEHICLE. AFTER APPROXIMATELY 20 MINUTES, ATTEMPTED TO START AGAIN THE VEHICLE TURNED ON AS IF NOTHING HAPPENED. ALL WARNING LIGHTS AT THAT TIME WERE EXTINGUISHED. DEALERSHIP FOUND A GENERAL WARNING ON VEHICLE COMPUTER. DEALERSHIP COULD FIND NOTHING WRONG WITH THE VEHICLE.

• 09/05/2018· SERVICE BRAKESCrash

  WHILE PARKING IN A PUBLIC PARKING LOT, AT IDLE SPEED, THE BRAKES DID NOT STOP FORWARD PROGRESS. CAR STRUCK THE CURBING, CLIMBED ONTO THE DIVIDER, CROSSED THE DIVIDER AND BUMPED A PARKED CAR ON THE OTHER SIDE. WHILE THE CAR WAS IN MOTION, I PUMPED THE BRAKES, AND PUSHED THE GEAR SHIFT LEVER INTO THE PARK POSITION. AFTER VEHICLE STOPPED, I REVERSED CAREFULLY, WHEN THE VEHICLE CAME OFF THE DIVIDER, I SET THE FOOT BRAKE. AFTER TURNING OFF THE ENGINE, I OPENED THE HOOD AND MY SON AND I CHECKED THE BRAKE FLUID IN THE MASTER CYLINDER. IT WAS FULL. RESTARTED THE VEHICLE, PRESSED THE BRAKE PEDAL AND HAD MY SON CHECK THE DISTANCE OF THE PEDAL TO THE FLOOR OF THE VEHICLE. IT WAS ALMOST ON THE FLOOR. I CALLED AAA AND HAD THE VEHICLE TOWED TO THE DEALERSHIP. HAVE CONTACTED TOYOTA AND FILED A CLAIM WITH TOYOTA.

• 09/02/2018· TIRES,WHEELS

  2016 TOYOTA HIGHLANDER WITH OEM TOYO 245/55R19 OPEN COUNTRY M&S 103T TIRES AT ABOUT 70 MPH ON I95 SOUTH BOARD NEAR BRUNSWICK GA (EXIT 38?) , A LOUD BANG WAS HEARD AND THEN THE BUMPING MADE IT OBVIOUS A TIRE HAD FAILED SO THE VEHICLE WAS STOPPED WELL OF THE ROAD NEAR AN EXIT. THE LOCAL STATE HIGHWAY ASSISTANCE TRUCK (CHAMP) STOPPED AFTER ABOUT 20 MINUTES AND THE TOYOTA RESPONSE SERVICE TRUCK SHOWED UP ABOUT 20 MINUTES LATER - THE TIRE WAS CHANGED AND WE PROCEEDED ON OUR WAY - MANY THANKS TO THE "ROAD RANGER" AND HIS TRUCK AND EXPERTISE! THE TIRES HAD ABOUT 28,500 MILES ON THEM - ESTIMATE ABOUT 55%OF ORIGINAL TREAD AND ARE MARKED: DOT 78HH CND 1016. THERE APPEARS TO HAVE BEEN A HOLE IN THE SIDEWALL THAT CAUSED SUDDEN LOSS OF PRESSURE.

• 08/31/2020· EXTERIOR LIGHTING

  WATER INSIDE LEFT TAILLIGHT ASSEMBLY AS PURCHASED USED FROM DAVE EDWARDS TOYOTA, AS CERTIFIED PRE-OWNED

• 08/28/2019· UNKNOWN OR OTHER

  WINDSHELD CRACKED OVERNIGHT WHEN PARKED IN THE GARAGE WITH NO REASON. I CONTACTED THE COMPANY AND DIDN'T GET A SOLUTION FROM THEM. THIS MUST BE SOMETHING THING RELATED TO THE COMPANY. FINALLY, I REPLACED IT WITH MY INSURANCE

• 08/24/2024· STRUCTURE

  The driver side rear passenger door can not be opened,either by remote or manually. This poses a threat to the safety of passengers in the rear seat area in the event of a crash. First responders would need to take other measures to tend to any injured passengers.

• 08/23/2023· AIR BAGS,SERVICE BRAKES,FORWARD COLLISION AVOIDANCECrash

  I have had problems with the brakes since I bought the vehicle new in 2016. I have the brakes checked every year and when I had problems but they never found the problem why the brakes do not work. The worse accident was on November 19, 2022 when my wife was using the car. She was in the car alone. She went to brake and the brakes did not engage, she slammed on the brakes 4 times and the car did not even slow down and she rear-ended the car in front of her. The air bags did not engage and she was injured. The brakes do not always work, I have gone through stop signs and red lights but the dealership says there is no problem.

• 08/20/2018· SERVICE BRAKES

  DRIVING DOWNHILL OR AT SPEEDS OVER 70 MPH, THE BRAKES WERE NOT EFFECTIVE TO STOP THE VEHICLE SAFELY. THE VEHICLE VIBRATES AND WAS DIFFICULT TO MANEUVER WITH CONFIDENCE. THE VEHICLE HAD DONE ONLY 25,000 MILES AND UNDER MANUFACTURER'S WARRANTY. THE DEALER SIMPLY MACHINED THE ROTORS AND PUT THEM BACK. HOPING IT WILL FIX THE PROBLEM AND NOT DUE TO DEFECTIVE ROTORS. SHOULDN'T TOYOTA LOOK INTO THIS MORE AND PERHAPS SUGGEST REPLACING THE ROTORS INSTEAD OF INSTALLING THE SAME ROTORS?

• 08/20/2018· ELECTRICAL SYSTEM

  CAR'S AWD STARTED NOT WORKING, CHECK ENGINE LIGHT CAME ON. TOOK IT TO THE DEALER AND THEY STATED THE MAIN WIRING HARNESS WAS "CHEWED" UP BY RODENTS. THEY STATED THEY SEEN IT BEFORE DUE TO A ORGANIC BASED OIL ON THE HARNESS WIRES.

• 08/18/2019· FUEL/PROPULSION SYSTEM

  NOTED FUEL ECONOMY CONTINUES TO DROP AND NOWHERE NEAR ADVERTISED MILEAGE. LAST TRIP IN VEHICLE NOTED 20 MPG ON ADVERTISED 27MPG. AROUND TOWN MILEAGE DROPPING BELOW 19 MPG.

• 08/18/2019· SERVICE BRAKES

  AT LOW SPEEDS SUCH AS SLOWING FOR A STOP SIGN VEHICLE RANDOMLY BRAKES BY ITSELF WITH SUDDEN STOPPING OF VEHICLE. OCCUPANTS AND ITEMS IN VEHICLE ARE THROWN FORWARD. NORMAL BRAKE PRESSURE APPLIED. HAS HAPPENED TO BOTH MYSELF AND MY WIFE WHILE DRIVING. VEHICLE HAS BEEN TO SHOP MULTIPLE TIMES INCLUDING 1 REPLACEMENT OF 12V BATTERY AS A SOLUTION, HOWEVER VEHICLE CONTINUES TO HAVE ISSUES. LISTED DATE IS APPROXIMATE OF ORIGINAL OCCURRENCE. SOME INSTANCES CAPTURED ON DASH-CAM VIDEO.

• 08/18/2019· ENGINE

  WHISTLING/SQUEAKING NOISE FROM ENGINE WHEN TURNED OFF AFTER DRIVING. TOOK A VIDEO AND SHOWED DEALER WHO THOUGHT IT WAS UNUSUAL BUT NO DIAGNOSIS ON MULTIPLE VISITS.

• 08/18/2019· ELECTRICAL SYSTEM

  VEHICLE PRE-COLLISION SYSTEM ACTIVATING RANDOMLY WITH NO OTHER VEHICLES NEARBY. DASH DISPLAY LIGHTS UP WITH WARNING ACCOMPANIED WITH RAPID BEEPING WHILE DRIVING. MULTIPLE TIMES NOTED ON VIDEO FROM DASH-CAM. HAS COME ON WHILE CHANGING LANES AND CAN CAUSE AN ACCIDENT BY THE DISTRACTION. HAS HAPPENED ON FREEWAY AS WELL AS CITY DRIVING. WHILE COASTING AND ACCELERATING. DATE LISTED BELOW IS APPROXIMATE.

• 08/18/2019· ELECTRONIC STABILITY CONTROL (ESC)

  TRACTION CONTROL SYSTEM ACTIVATES RANDOMLY WHILE DRIVING ON SMOOTH ROADWAY, DRY ROADS. DRIVING DOWN ROAD AND TCS LIGHT FLASHES IN INSTRUMENT CLUSTER.

• 08/18/2019· ELECTRICAL SYSTEM

  TWO SEPARATE ISSUES: 1. RAIN SENSING WIPERS ACTIVATE RANDOMLY ON CLEAR DAYS, SUN SHINING. WIPERS WILL WIPE ON TIME WHILE DRIVING RANDOMLY. A SEVERE DISTRACTION. 2. CRUISE CONTROL DISPLAY ACTIVATING RANDOMLY WHILE DRIVING WITH NO VEHICLES NEARBY IN FRONT (ACTIVE CRUISE CONTROL VEHICLE). DISPLAY WILL BE NORMAL AND THEN GO BACK AND FORTH THE THE SET DISPLAY SCREEN. DISTRACTING WHILE DRIVING ON FREEWAY.

• 08/18/2019· ELECTRICAL SYSTEMCrash

  PARKING SENSORS AND PARK ASSIST RANDOMLY TURNS ITSELF OFF. WILL NOTICE THE SENSORS NOT DETECTING WHILE BACKING UP AND NOTICE DASH LIGHT IS NOT ILLUMINATED. NOT FUNCTIONING WHEN BACKING AND PARKING.

• 08/13/2019· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD METAL RUBBING ON THE FRONT BRAKES. THE FRONT BRAKE PADS, ROTORS, AND CALIPERS WERE REPAIRED BY ORLAND TOYOTA (8505 W 159TH ST, TINLEY PARK, IL 60487), BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ELMHURST TOYOTA (440 W LAKE ST, ELMHURST, IL 60126) WHERE IT WAS DETERMINED THAT THE BRAKE PADS WERE FINE; HOWEVER, THE ROTORS WERE NOT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.