2016 KIA RIO

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2023· ENGINE

  Was told that my car was consuming too much oil and I’ve been doing oil consumption test for the past year I even did the chemical that was run through my motor which I had to pay for and it was over $800 I feel like they’re giving me the runaround one of the employees at Dick Hanna Kia also told me at one point that I could actually replace the motor myself but my car is still under warranty at 92,000 miles. I just want it resolved either they replaced my motor or do something I have two more oil consumption test and then at that point they will send the information to Dick Hanna Kia dealerships or wherever they send it and then tell me what to do next actually getting frustrated. I have to go every 1000 miles and it takes time out of my day to do this.

• 12/22/2023· ENGINE

  The contact owns a 2016 Kia Rio. The contact stated that there was an abnormal odor in the vehicle. While driving at an undisclosed speed, the vehicle slowed down and stalled. The check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 126,000. VIN tool confirms parts not available.

• 12/15/2023· SERVICE BRAKES, HYDRAULIC,ENGINE

  The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed or repaired. The approximate failure mileage was 60,000. VIN tool confirms parts not available.

• 12/13/2022· UNKNOWN OR OTHER

  Trunk will not close. This happened in 2017 and the car was repaired under warranty. It happened again yesterday. Kia has an active recall on some vehicles for this issue mine is not included...however it is the EXACT same issue. I live in Florida and the recall is an issue with heat damaging the safety latch. Kia needs to extend the recall to cover ALL impacted vehicles.

• 12/13/2022· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  on 08.30.22 while driving on the interstate I75 going approx. 75 mph my vehicle just lost speed and I barely made it to the side of the road. it did not shut off just had no power, this was at 63,000 miles and had to have the catalytic converter replaced. total cost $1800. fast forward to 12.10.22 same thing happened and was told once again need a new catalytic converter. also have had all maintenance done and this GDI engine burns approx. 1 quart of oil every 2 weeks. also make not that the engine light never came on with either event

• 12/05/2024· ENGINE

  I got an oil change right after the car overheated and I believe the engine is blown now. I don’t understand how all this can happen after an oils change.

• 12/01/2023· SERVICE BRAKES, HYDRAULIC

  The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/30/2018· AIR BAGSCrash

  ON NOVEMBER 18, 2018 AT APPROXIMATELY 6:30PM, I WAS INVOLVED IN A CAR ACCIDENT WHERE I REAR ENDED A CAR IN FRONT OF ME WHILE MOVING AROUND 30 MPH IN THE MERGING RAMP OF HWY 57 TO HWY 210 NEAR SAN DIMAS, CA AND I FILED A POLICE REPORT. THE AIRBAG DID NOT INFLATE/DEPLOY.

• 11/29/2023· LATCHES/LOCKS/LINKAGES

  My trunk latch wasn't working. I couldn't close my trunk. I contact Kia service and since I still have a platinum warranty with them, asked them if they could repair it free of charge. They said no. So I had to use tape to keep the trunk shut which kept getting wet from the rain while I had to wait for my kia truck latch part to arrive through mail so my husband could install it. I am not sure if this was right before they knew of the issue or not, but I feel like I deserve a refund for the part.

• 11/29/2023· ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINEFire

  I was driving down the road and suddenly my check engine light starts flashing and the vehicle starts surging. I pull over and shut the car off. I get outside to the hood to open it, as there is steam coming out, and as I put my hand on the hood release, a fire erupts from the engine going over my windshield and driver window. Burning my entire car and $2500 worth of belongings to the ground.

• 11/27/2023· POWER TRAIN,VEHICLE SPEED CONTROL

  The contact owns a 2016 Kia Rio. The contact stated that while attempting to accelerate, the vehicle failed to respond as needed. The accelerator pedal was depressed, but the vehicle was slow to respond. There were no warning lights illuminated. The vehicle was taken to several independent mechanics, who were unable to identify the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 34,000.

• 11/22/2025· ENGINE

  My car is experiencing excessive oil consumption. Upon inspection, it was determined that the issue lies with my catalytic converter. I have discovered that this problem has been reported in other Kia vehicles. The information I found suggests that the oil I am using is being bypassed by the catalytic converter, which indicates a potential issue with the Kia car’s design. Engine light won’t go off

• 11/18/2023· EXTERIOR LIGHTING

  When i purchased this vehicle, I had to replace all 4 rear led tail lights. Now 2 years later I have to replace the right rear led side tail light. These led lights should not be going out this soon. Why can't Kia recall this part. This is a safety issue that i should not be replacing this soon.

• 11/18/2023· ENGINE

  I took my car in and kia is stating that my upper catalytic converter manifold is bad. That should not be happening under 100,000 miles. Of course kia would cover it if it was under 80,000 miles. That's not the case with my car and of course my car had a little over 80,000 miles. So that comes out of pocket when it should not be happening.

• 11/18/2023· SERVICE BRAKES,ENGINE

  From what I understand kia has no fix for manufacturer recall # SC284UB and NHTSA recall# 23V652. That is unacceptable and unprofessional. Kia is a hugh car dealer and they are saying there is no fix yet! I can't believe kia would put people and families at risk. Kia's action plan to put your car outside and not in your garage , is ridiculous. I was never contacted about this recall, that's unacceptable. Kia needs a fix NOW!

• 11/18/2023· UNKNOWN OR OTHER

  Hydraulic electronic control

• 11/14/2022· AIR BAGSCrash

  Airbags didn’t deploy in a accident which caused whiplash

• 11/13/2024· VISIBILITY

  The contact owns a 2016 Kia Rio. The contact stated while driving at various speeds, the interior rearview center mirror failed to remain in place after manually being positioned. The local dealer was contacted; however, the contact was informed that the warranty had expired after 5 years from the manufactured date. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.

• 10/30/2017· UNKNOWN OR OTHER

  WHEN I TURNED MY RIGHT SIGNAL LIGHT ON THE FRONT AND REAR WINDSHIELD WIPERS CAME ON AND THE HIGH BEAM LIGHT ICON STARTED FLASHING ON THE DASHBOARD.

• 10/25/2018· UNKNOWN OR OTHER

  VEHICLE HAS UNEXPECTEDLY SHUT OFF WHILE DRIVING. THE VEHICLE ALSO SHUT OFF WHILE IN LINE AT A DRIVE THRU LOCATION IN CORPUS CHRISTI

• 10/23/2022· UNKNOWN OR OTHER

  The trunk of my car will not open. Upon further inspection, the trunk latch is broken. When we accessed the trunk from the back seats, we tried to open it with the emergency release and it does not work. Nothing opens the trunk. This is a KNOWN issue to Kia and they've recalled other years, but not 2016. So I guess if a person were to get locked in the trunk of a 2016 Rio, it's somehow not a safety issue, even though it is one in later years??

• 10/23/2018· ELECTRICAL SYSTEM,STRUCTURE,ENGINEFire

  TL* THE CONTACT OWNED A 2016 KIA RIO. A MINUTE AFTER THE CONTACT EXITED THE VEHICLE, IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE DEALER (DYER KIA, 21280 US-27, LAKE WALES, FL 33859) WAS CONTACTED AND ADVISED THE CONTACT TO CALL THE MANUFACTURER. THE MANUFACTURER WAS CONTACTED AND WAS UNABLE TO ASSIST. THE VEHICLE WAS NOT DIAGNOSED. THE CAUSE OF THE FIRE WAS UNKNOWN. THE FAILURE MILEAGE WAS 16,003. *LN*JB

• 10/23/2017· SUSPENSION

  TL* THE CONTACT OWNS A 2016 KIA RIO. WHILE DRIVING 15 MPH AND MAKING A LEFT TURN, AN ABNORMAL SOUND WAS PRESENT. THE CONTACT HEARD SOMETHING DRAGGING IN THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO BOB SIGHT INDEPENDENCE KIA (1700 S. NOLAND ROAD, INDEPENDENCE, MO 64055) WHERE IT WAS DIAGNOSED THAT THE REAR AXLE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE FAILURE WAS LIKELY CAUSED BY THE OWNER. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. THE VIN WAS NOT AVAILABLE.

• 10/22/2021· UNKNOWN OR OTHER

  The trunk latch is broken and does not open with safety latch. Why is my car not on the list for the recall on this particular problem?

• 10/21/2016· ENGINE

  TL* THE CONTACT OWNS A 2016 KIA RIO. WHILE DRIVING 35 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED INDEPENDENTLY AFTER A FEW MOMENTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 14,600.

• 10/18/2023· ENGINE

  At first I thought I was leaking oil. on my next oil change I asked them about the oil consumption. they had me do an oil consumption study. this was around 95,000 miles. at my next oil change they suggested I talked with Kia. before my next oil change my car shut down while my mom was driving on the highway. and I had it towed to kia to find that the catalytic converter was clogged and need to be replace. whats worse is the Kia soul with the 1.6 engine has the exact same problem but that has a recall for it. but not the Rio.

• 10/18/2022· ENGINE

  As related to the Kia Soul recall on their 2.4 GDI (same engine I have) the motor is blown. Extreme oil consumption and clogging components. All issues recalled on Soul are the same issues my engine is faced with.

• 10/17/2022· ENGINE

  Car began burning oil excessively at 102,000 miles.

• 10/08/2016· AIR BAGSCrash

  ON SEPTEMBER 16, 2016 AT APPROXIMATELY9:12PM, I [XXX] , HAD JUST PICKED UP A PASSENGER WAS INVOLVED IN A CAR ACCIDENT . WHERE AS I WAS REAR ENDED WHILE AT A COMPLETE STOP AT A SIGNAL LIGHT AT THE INTERSECTION OF SOUTHWESTERN AND MOCKINGBIRD WITH THE PASSENGER IN THE CAR. THERE WAS A POLICE REPORT FILED THE NUMBER IS [XXX] THE AIRBAG DID NOT DEPLORE .....UPDATED 10/26/16 *BF INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 09/29/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2016 Kia Rio. The contact stated that while inspecting the vehicle, it was discovered that there was no oil on the dipstick. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. An oil consumption test was performed; however, the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.

• 09/24/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2016 Kia Rio. The contact stated that upon driving from a complete stop, the vehicle failed to exceed 2-3 MPH. There was no warning light illuminated. The contact was able to drive to the residence. The Ford dealer where the vehicle was purchased arranged for the vehicle to be picked up at the residence. The Ford dealer informed the contact that the mechanic and the Kia dealer where the vehicle was taken could not determine the cause of the failure. The contact then took the vehicle to an independent mechanic, where it was determined that the catalytic converter was clogged and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 126,000.

• 09/05/2023· STRUCTURE

  Trunk stopped opening off and on then stopped latching caused me not to be able to see behind me it popped open when was driving and would latch had to tie shut with a. String no don’t have money to put in shop no hasn’t been inspected no no lamps no warnings symptoms

• 09/05/2023· POWER TRAIN

  Ignition getting stuck in acc car can’t go anywhere can’t turn key off steering wheel won’t lock no don’t have money to put in shop arm no hasn’t been inspected no lamps no warning just started doing it has done a few times now

• 08/25/2023· ENGINE

  At about 90000 mile brought car into dealership because it was consuming oil. Was told there was no leak found. Oil consumption was not covered. At about 110,000 miles had to bring car into shop because catalytic converter ended up being blocked and had to replaced. Less than a year later at 129,000 miles had vehicle towed back to shop again. Mechanic stated lower bearing had failed and engine would need to be replaced. Contacted junkyards for replacement and there were two he found but we're very expensive. He called Kia and they don't make that engine any longer. Guessing because of all the problems they have with it.

• 08/17/2022· ENGINE

  While driving on the expressway my engine started to get extremely loud and I lost mph, and rpms. I was able to make it home going 35mph the whole way. After having it towed to my nearest kia store I was informed that my Cadillac converter will need to be replaced as well as my engine because all of my pistons had broke. I was up to 106,000 miles and have been up to date on all my oil changes and engine checks. Now I have to pay 10,000 dollars to get it fixed over something that should not have happened so soon

• 08/05/2019· ELECTRICAL SYSTEM,ENGINE,VISIBILITY/WIPER

  PROBLEMS: 1) AC STOPS WORKING AND ONLY BLOWS WARM AIR, 2) WINDSHIELD WIPERS DOES NOT WORK. BOTH FRONT AND BACK 3) FRONT LIGHTS DOES NOT WORK

• 07/15/2022· ENGINE

  I need a new engine but cant find one because they all keep catching on fire. This is a issue they should refund me for my car or fit it.

• 07/13/2024· ENGINE

  Vehicle burning through excessive amounts of oil. Check engine light came on and car was making a loud ticking noise and knock. Dealership confirmed the vehicle will need a new engine. Kia Corporate denied replacement because vehicle is out of warranty. Reported problem to Kia before warranty expired and was still denied.

• 07/13/2022· UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEMFire

  On June 29, 2022, I was driving on I-5 southbound when I heard a loud sort of tapping sound coming from my engine. About 30 minutes later, before I had time to get to a gas station, there was a loud "BOOM!" sound and all of a sudden, the catalytic converter light and some other dash lights started to flash and I started to lose power. I pulled over to the left shoulder of the highway and before I could even pop the hood, I noticed flames immediately licking from the underside of the hood. I grabbed my phone and pulled my rabbit in her cage from the back seat of the car and called 911. My car continued to burn, starting a small brush fire, until the fire department finally came and put the fire out. The whole front of my car was completely incinerated and it had made its way to the back hatch in less than hour. I don't know for certain what caused this as the only indication of a problem was the loud tapping sound- zero dash lights were flashing until the boom. I had just taken the car in for an oil change and general check up less than a week before, and they saw nothing amiss. Geico, my insurance company, has inspected it to determine that it is, in fact, a total loss, but I'm sure they didn't do a sort of diagnostic to determine what happened to cause the incident. I am beyond lucky that I was able to escape my car with my pet and my life, but had the fire moved any faster through the car, we would be dead. It all happened within an hour.

• 07/12/2024· STEERING,SERVICE BRAKES,ENGINE

  What component or system failed or malfunctioned, and is it available for inspection upon request? Complete engine lockup during operation at speed which caused steering and braking to be greatly hampered. How was your safety or the safety of others put at risk? The engine failed on a 4-lane highway in traffic which could have easily caused a high-speed accident since the car extremely decelerated and lost power steering and braking in order to get out of traffic. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes confirmed by an independent service center which told me it was either a cylinder rod or a lower engine bearing failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, the manufacture KIA has a recall on other models in this year range but not the RIO. The other models have a similar engine failure caused by a faulty cylinder rod bearing. The RIO has never been added to this recall list, but it should be because it looks like the engine issues are also on this model in the same time frame. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, they only came on when the engine failed. Then every warning light appeared.

• 07/07/2021· ENGINE

  The contact owns a 2015 Kia Rio. The contact stated while driving 10-15 mph, he heard an abnormal loud clicking sound coming from the engine. There were no warning lights illuminated. The contact was able to drive to a nearby gas station, where he noticed the engine oil had spilled and the piston and the connecting rods had fractured. The vehicle was towed to the residence. The vehicle was not diagnosed nor repaired. The dealer was made aware of the failure and informed the contact that he would be responsible for the cost of the repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 75,000.

• 06/26/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINEFire

  I was driving when my Kia stalled and shut off but was still playing music and driving. So I pulled over and then my Kia caught on fire and went up in flames.

• 06/21/2021· UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEMFire

  On May 29th 2021 my 2016 Kia Rio engine caught on fire after multiple attempts of letting Kia know that my engine had a possible recall/detect. I was told that my car wasn’t apart of the recall list of considered on the list of the 1.6 million or billion others who’s engines have blown up as well. I have paper work/trail of recent mechanical work/mechanics informing me with “possible recall issues as well”. Paid for an oil change May 21st, visited the mechanic and 8 days later my car was in flames at an EXXON gas station pump, literally traumatized.

• 06/17/2024· UNKNOWN OR OTHER,ENGINE

  I was parked in ghe parking lot and went into the store and came back to my car and starting then it was not getting started i tried many times even though it was like battery dead and i call my insurance company and asked for roadside assistance amd they tried using jump start evne though it was not starting so with the help of other sources i tried to rotate crankshaft manually it was stucked and not rotating so i thought it was engine sezied.

• 06/17/2019· EXTERIOR LIGHTING

  WHEN HAEDLIGHTS ARE ON AUTOMATIC AND TURN ON TURN SIGNAL AND MAKE TURN WHEN TURN SIGNAL GOES OFF AFTER MAKING TURN IT TURNS OFF HEAD LIGHTS WHEN MOVING

• 06/13/2021· AIR BAGS,SEAT BELTSCrash

  The air bags malfunction they didn’t go off and seatbelt didn’t lock on impact. Yes my safety was at risk. I keep calling them and they not do pick up the phone I get transferred back to the receptionist. The insurance company is doing their inspection the police as well. No warnings.

• 06/11/2020· UNKNOWN OR OTHER,ENGINE

  AT 148,000 MILES ON THE FREEWAY THE GAS PEDAL WOULD NOT GIVE ANY POWER, STILL RUNNING BUT WOULD NOT GO, STALLED A FEW TIMES. HAD TO PULL OVER AND WAIT, RESTART AND GO A FEW MILES, PULL OVER AND WAIT, THEN GO, ETC. COME TO FIND OUT THERE WAS NOT A DROP OF OIL LEFT. AFTER REPLENISHING, STILL HAD ISSUES, THEN NOTICED THE ANTI-FREEZE WAS LOW. REPLENISHED IS NOW DRIVABLE BUT CONTINUES TO BURN OIL. NO LEAKING & I CHANGED THE PCV VALVE WITH NO RESULTS. I'M STILL ADDING CLOSE TO A QUART OF OIL EVERYDAY. HAVE REASON TO BELIEVE THE PISTON RINGS AND VALVES ARE SHOT AND OIL IS CIRCULATING THROUGHOUT/INTO CYLINDERS. NOW IT'S ON ITS LAST LEG, 152,000 MILES. IT'S BEEN A GOOD RIDE BUT TIME TO GO. NOTE* A/C STOPPED WORKING AT 66,000 MILES *TR

• 06/09/2018· STEERING,ENGINE

  THE ISSUE HAS OCCURRED FOUR TIMES SINCE PURCHASING THE CAR AT THE END OF DECEMBER 2017 (LESS THAN 6 MONTHS AGO). THE DASHBOARD WILL LIGHT UP WITH A NUMBER OF ICONS AFTER THE CAR IS TURNED ON (SEE PHOTO FROM DECEMBER). THE FIRST TIME THIS HAPPENED, IT WAS A BITTERLY COLD DAY AND THE ICONS POPPED UP AS I WAS DRIVING. I FELT THE STEERING BECOME TIGHT, BUT LUCKILY I WAS TURNING INTO A PARKING LOT TO SAFETY. THE ICONS WENT AWAY AFTER RUNNING THE CAR FOR A LONG TIME (I WAS TOLD IT WAS JUST THE COLD WEATHER). BUT WHEN I CHECKED ON MY CAR LATER BEFORE DRIVING, THE ICONS RETURNED. I HAD TO GET THE VEHICLE TOWED LATER THAT DAY BECAUSE THE ICONS DID NOT GO AWAY AND THE POWER STEERING DID NOT RETURN. THE ISSUE STOPPED AS SOON AS IT REACHED THE DEALERSHIP, SO THEY SENT ME ON MY WAY. I TURNED THE CAR ON THE FOLLOWING MORNING (STATIONARY, DID NOT MOVE IT YET) AND THE ICONS RETURNED, THE POWER STEERING WAS GONE. I GOT IT TOWED AGAIN. AFTER DAYS OF TESTING, THEY DETERMINED IT WAS AN ISSUE WITH THE ENGINE CONTROL MODULE AND SOMETHING WAS FIXED WITH WIRING. NOW IT IS JUNE 2018, AND THE ISSUE HAPPENED AGAIN (ON A WARM DAY - SO IT IS NOT COLD RELATED AS I WAS ORIGINALLY TOLD). I COULD NOT STEER AFTER TURNING THE VEHICLE ON IN THE EARLY MORNING ONCE AGAIN. I GOT IT TOWED TO THE DEALERSHIP AND THE ISSUE IS BEING INVESTIGATED. I BELIEVE THIS IS A MAJOR SAFETY ISSUE AS THE STEERING IS AFFECTED, AND WITH HOW MANY ICONS LIGHT UP RELATED TO THE AIR BAGS AND BRAKES, I AM NOT SURE WHAT ELSE COULD BE AFFECTED BY THIS ISSUE.

• 06/06/2024· SERVICE BRAKESCrash

  We were doing a lot of stop and go driving in warm weather. I noticed braking seemed to be normal at first but just before the accident I press the brake and the pedal went to the floor and the vehicle wouldn’t . I hit the car in front of me. My vehicle was presumably totaled. There was lots of fluids on the floor.

• 06/04/2026· EXTERIOR LIGHTING

  I am filing this complaint regarding a persistent low beam headlight failure on my 2016 Kia Rio that has not been resolved after a paid repair at an authorized Kia dealership. The low beam headlights on my vehicle stopped functioning. I brought the vehicle to Car Pros Kia in [XXX] for diagnosis and repair on XXX.. The dealership diagnosed the issue as a faulty Body Control Module (BCM) and replaced it on XXX. The dealership released the car to me with a 25-point inspection reading that all exterior lights were functional. The repair did not fix the problem — my low beams remain non-functional. I returned the vehicle on May 15th, 2026 so they can remedy the repair. They released my vehicle to me a second time with no functioning low-beam headlights. On XXX, the dealership is now quoting $3,205.01 for a wiring harness replacement as a third repair attempt, with no acknowledgment that the original diagnosis was incorrect. My vehicle was returned to me in an unsafe condition following a paid repair. Non-functional low beams are a safety hazard, particularly for nighttime driving. I am aware that Kia has a documented history of headlamp low beam connector wiring harness failures across multiple models, including extended warranty coverage and TSB ELE179 issued for similar issues in other Kia vehicles. I am requesting this complaint be added to the record for the 2016 Kia Rio. If other owners are experiencing similar issues, I believe this warrants investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)