2016 Ford Transit Medium Roof 8 10 12 Pass

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2025· ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL

  The contact owns a 2016 Ford Transit. The contact stated that while driving at various speeds, the vehicle stalled. During the failure, the warning message "Reduced Power" was displayed. The contact stated that after restarting the engine, the vehicle operated as intended; however, the failure reoccurred later. The vehicle was taken to the local mechanic who replaced the fuel injector, but the failure reoccurred. The vehicle was later towed to the local dealer, where it was diagnosed that there were metal shavings in the fuel system. The dealer determined that the entire fuel system needed to be replaced, including the fuel pump, the fuel valves and the fuel injector. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 16V618000(Fuel System, Diesel, Engine and Engine Cooling), which the contact related to the failure. The vehicle was not yet repaired. The failure mileage was 165,000.

• 12/29/2019· UNKNOWN OR OTHER

  THE OVERALL NOISE LEVEL WHILE DRIVING IS WAY ABOVE NORMAL. HUMMING SOUND WHILE DRIVING AT 40 TO 50 MPH PLUS. THE **DECIBEL** LEVEL IS HIGH. NOISE COMING THROUGH ALL THE DOORS AND DOOR SEALS, THE FLOOR, ETC., NOISE FROM THE TIRES. I MEASURED THE DECIBEL LEVELS ON THE LOCAL EXPRESSWAY DOING 65 TO 70 MPH. THE DECIBEL LEVEL AT THE *DOG HOUSE* WAS RUNNING BETWEEN 75 AND 80 DECIBELS. I HAVE BEEN TRYING TO PUT ADDITIONAL SELF STICKING DOOR SEALS ON ALL DOORS, 100% AROUND, COMPLETE, ETC. THIS HAS BEEN HAPPENING FOR THE PAST SEVERAL YEARS. SHORTLY AFTER I BOUGHT THE VEHICLE.

• 12/27/2021· POWER TRAIN,STRUCTUREFire

  The contact owns a 2016 Ford Transit. The contact stated that there was a rubbing burning order coming from inside the front end of the vehicle. The vehicle also had a vibration sensation whenever the vehicle was being driven. There were no warning lights on the vehicle. The contact contacted the dealer who stated that the flex disc had failed. The contact stated that this was a known issue for the vehicle. There was a recall and lawsuit involving the vehicle's rubber cupper between the transmission and driveshaft was made of plastic was causing severe failures. The manufacturer was made aware of the matter and had since been looking into the matter and informed the contact that their research was being furthered along regarding parts before something was to be done. The contact stated that the manufacturer had failed to provide a permanent fix or the guaranteed maintenance at replacing the part at every 30,000 40,000 miles. The approximate failure mileage was 71,000.

• 12/26/2020· UNKNOWN OR OTHER

  SYNC 3 SYSTEM FREEZE AND DOES NOT LET YOU UP DATE. THE GPS FREEZE , PHONE CALL ARE DROP, BLUETOOTH DO NOT CONNECT AND SOME TIME WHEN IS CONNECTED DISCONNECT CASE.

• 12/19/2025· POWER TRAIN

  The contact owns a 2016 Ford Transit. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the engine revved, and the vehicle lost motive power. The vehicle was driven to the shoulder of the roadway. No warning lights were illuminated. The vehicle was turned off; however, while the contact's wife was attempting to restart the vehicle, the vehicle failed to restart. In addition, the contact stated that the failure had occurred while his wife was driving with children inside the vehicle. The vehicle was towed to the dealer where the failure was associated with an unrepaired recall. The contact was notified of NHTSA Campaign Number: 19V767000 (Power Train). The VIN was associated with the recall. The dealer submitted the repair request to the manufacturer. The manufacturer was made aware of the failure, and a case was file,d but the repair was denied. The contact was informed that the repair was not covered under warranty. The contact then submitted a copy of the recall to the manufacturer and was informed that the repair was not covered because the recall was not performed in the required time frame. The failure mileage was approximately 160,000.

• 12/15/2020· STRUCTURE,FUEL/PROPULSION SYSTEM

  FUEL DOOR BROKEN AT UPPER HINGE. COMMON PART FAILURE FORD REFUSES TO ACKNOWLEDGE.

• 12/13/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  I was not made aware of the recall. The driveshaft separated while I was driving, causing significant damage to other parts of the vehicle, including the transmission, motor and transmission mount, cooling, electrical and brake and transmission lines, oil and fuel parts, and much more underneath the van. This happened after a very brief hard vibration moments before it “exploded” and sent me flying into the air and coming to a very quick stop, which also caused medical issues. Ford is refusing to repair all that their recalled part damaged claiming they “notified me” but I haven’t received such notice. I stay up on all maintenance and repairs for my van, and the dealership acknowledged that when looking at the vehicle history reports.

• 12/13/2017· ELECTRONIC STABILITY CONTROL (ESC),ENGINE

  WE PURCHASED 14 FORD TRANSIT VANS FROM THE U.S. FOUR OF THE 14 ARE NOT IN DRIVING CONDITION NOW DUE TO A PROBLEM LOSING SPEED [MORE DETAILS FOR EACH VEHICLE ARE NEEDED]. THE FAULT IN ALL OF THEM SHOWS CODE P2111. THE VINS ARE: [XXX] BROKEN IN JAN/FEB 2017 WITH LESS THAN 4500KM; [XXX] BROKEN IN MARCH 2017 WITH LESS THAN 5200KM ; [XXX] BROKEN IN AUGUST 2017 WITH LESS THAN 3000KM ; [XXX] BROKEN IN NOVEMBER 2017 WITH LESS THAN 4600KM. AT THIS RATE, WE EXPECT THAT OUR ENTIRE FLEET OF LARGE VANS WHICH ARE FORD TRANSITS TO BE INOPERABLE. WE HAVE RECEIVED THE SERVICE FROM ONE OF LOCAL TRANSIT DEALERS [XXX] , BUT IT SEEMED THE PROBLEM IS NOT INCLUDED IN "RECALL NOTICE" FROM FORD . WE WOULD GREATLY APPRECIATE ALL ASSISTANCE IN REPAIRING OR REPLACING THESE VEHICLES AS SOON AS POSSIBLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/13/2017· ELECTRONIC STABILITY CONTROL (ESC),ENGINE

  WE PURCHASED 14 FORD TRANSIT VANS FROM THE U.S. FOUR OF THE 14 ARE NOT IN DRIVING CONDITION NOW DUE TO A PROBLEM LOSING SPEED [MORE DETAILS FOR EACH VEHICLE ARE NEEDED]. THE FAULT IN ALL OF THEM SHOWS CODE P2111. THE VINS ARE: [XXX] BROKEN IN JAN/FEB 2017 WITH LESS THAN 4500KM; [XXX] BROKEN IN MARCH 2017 WITH LESS THAN 5200KM ; [XXX] BROKEN IN AUGUST 2017 WITH LESS THAN 3000KM ; [XXX] BROKEN IN NOVEMBER 2017 WITH LESS THAN 4600KM (BROKEN DOWN IN THE MOTORCADE FOR POTUS VISIT!). AT THIS RATE, WE EXPECT THAT OUR ENTIRE FLEET OF LARGE VANS WHICH ARE FORD TRANSITS TO BE INOPERABLE. WE HAVE RECEIVED THE SERVICE FROM ONE OF LOCAL TRANSIT DEALERS IN BEIJING CALLED [XXX] , BUT IT SEEMED THE PROBLEM IS NOT INCLUDED IN THE "RECALL NOTICE" FROM FORD . WE WOULD GREATLY APPRECIATE ALL ASSISTANCE IN REPAIRING OR REPLACING THESE VEHICLES AS SOON AS POSSIBLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/13/2017· ELECTRONIC STABILITY CONTROL (ESC),ENGINE

  WE PURCHASED 14 FORD TRANSIT VANS FROM THE U.S. FOUR OF THE 14 ARE NOT IN DRIVING CONDITION NOW DUE TO A PROBLEM LOSING SPEED [MORE DETAILS FOR EACH VEHICLE ARE NEEDED]. THE FAULT IN ALL OF THEM SHOWS CODE P2111. THE VINS ARE: [XXX] BROKEN IN JAN/FEB 2017 WITH LESS THAN 4500KM; [XXX] BROKEN IN MARCH 2017 WITH LESS THAN 5200KM ; [XXX] BROKEN IN AUGUST 2017 WITH LESS THAN 3000KM ; [XXX] BROKEN IN NOVEMBER 2017 WITH LESS THAN 4600KM. AT THIS RATE, WE EXPECT THAT OUR ENTIRE FLEET OF LARGE VANS WHICH ARE FORD TRANSITS TO BE INOPERABLE. WE HAVE RECEIVED THE SERVICE FROM ONE OF LOCAL TRANSIT DEALERS [XXX] , BUT IT SEEMED THE PROBLEM IS NOT INCLUDED IN "RECALL NOTICE" FROM FORD . WE WOULD GREATLY APPRECIATE ALL ASSISTANCE IN REPAIRING OR REPLACING THESE VEHICLES AS SOON AS POSSIBLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/09/2024· STEERING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  •What component or system failed or malfunctioned, and is it available for inspection upon request? Unknown •How was your safety or the safety of others put at risk? Van completely shuts down, lights on dashboard shut off, can’t not accelerate or brake, and hazard lights do not turn on. •Has the problem been reproduced or confirmed by a dealer or independent service center? Problem could not be reproduce at Ford the second time. The first time this happened, the Van was serviced at Ford for over 2 months for the same issues. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been serviced by Penske & Ford. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights or messages, these issues comes up randomly and shuts the vehicle down completely.

• 12/08/2020· STEERING

  TL* THE CONTACT OWNS A 2016 FORD TRANSIT VAN. THE CONTACT STATED THAT HE HAD A TEMPORARY FIX FOR A RECALL REPAIR FOR A DRIVE SHAFT FLEXIBLE COUPLING DONE BACK ON 11/2017. THE REPAIRS WERE DONE AT THE DEALER WYATT JOHNSON FORD 646 THOMPSON LN, NASHVILLE, TN 37204 (615) 244-3615. THE ISSUE RECURRED AGAIN IN 09/2018 WHEN THE PART WAS DISCOVERED TO BE CRACKED. THE VEHICLE WAS TAKEN TO ANOTHER UNKNOWN DEALER TO DO ANOTHER TEMPORARY REPAIR SINCE THE PERMANENT RECALL REPAIR PARTS WERE STILL NOT AVAILABLE YET. THE TEMPORARY REPAIRS WERE COMPLETED. THE ISSUE HAPPENED AGAIN YESTERDAY 12/07/20 AND THE DEALER STATED THAT THE RECALL REPAIRS WERE SHOWN TO BE COMPLETED AND THEY WOULD NOT COMPLETE THE REPAIRS AT NO COST. THE PERMANENT REPAIR SOLUTION CAME OUT IN 10/2019 BY THE MANUFACTURER AND THE CONTACT'S CASE WAS CLOSED OUT. THE MANUFACTURER STATED THAT THE RECALL WAS COMPLETED AND WOULD NOT ASSIST IN THE PERMANENT REPAIR FOR THE VEHICLE. THE VEHICLE WAS UNREPAIRED AS A RESULT. THE FAILURE MILEAGE WAS 40,412.

• 12/06/2023· POWER TRAIN

  My ford van has vibrations between 20-40 miles. Many other ford transits has recalls for this. The issues is with the drive shaft and the drive shaft yoke.

• 11/30/2020· POWER TRAIN

  DEALERSHIP (WICKSTROM FORD LINCOLN) IN BARRINGTON IL REFUSES TO REPAID MY VEHICLE SAFETY RECALL (CODE: GEUXOIM). I SCHEDULED AN APPOINTMENT ON 9/22/2020 AND THE DEALERSHIP SENT ME HOME BECAUSE THE PART NEEDS TO BE ORDERED. THE DEALERSHIP SAID THEY WOULD CALL WHEN PARTS ARRIVE. DEALERSHIP NEVER CALLED, I CALLED TWICE ON 11/25/2020 AND LEFT A MESSAGE. THE DEALERSHIP HAS NOT CALLED.

• 11/23/2018· UNKNOWN OR OTHER,ENGINE

  ELECTRICAL THROTTLE BODY FAILED DURING DRIVING. LOST ALL POWER.

• 11/23/2018· POWER TRAIN,SERVICE BRAKES

  TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V408000 (POWER TRAIN) BY AUTONATION FORD BELLEVUE (411 116TH AVE NE, BELLEVUE, WA 98004, 425-243-5203), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. WHILE DRIVING 25 MPH, THE ENGINE MADE AN ABNORMAL NOISE. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL, THE VEHICLE SEIZED AND THE BRAKES FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.

• 11/17/2023· POWER TRAIN

  On 17 November, 2023, at approximately 12 PM, I was traveling down the highway at approximately 55 mph. I suddenly heard a loud pop coming from directly under the cab and a subsequent rattling. It lasted for about 15 seconds, went away, and then lasted for another five seconds before completely stopping. Upon parking the vehicle, I crawled underneath and noticed that the flex coupling between the transmission and drive axle was missing two big chunks, and it appeared that a part of that material was lodged into the fire wall above the transmission underneath the floorboard. Also, present was a lot of strands of fiberglass from the coupling material. I immediately searched the Internet for some information regarding this and came upon an active recall that was published in 2019 for certain Ford transits manufactured 2015 to 2017. My vehicle is a 2016 Ford transit 250. It is my belief that this coupling issue that Ford published for recalls was not caught on my vehicle, and I have a concern that my vehicle may have fallen under that safety recall. Would like to know if an inspection could be done and some research to determine if my vehicle, in fact, falls within that recall.

• 11/17/2020· FUEL SYSTEM, GASOLINE,POWER TRAIN

  TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V767000 (POWER TRAIN) HOWEVER THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE LOCAL DEALER FULLERTON FORD LOCATED AT 1044 U.S. ROUTE 22 EAST, SOMERVILLE, NJ 08876 WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE EXPERIENCED THE FAILURE LISTED IN THE RECALL CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. PARTS DISTRIBUTION DISCONNECT.

• 11/16/2020· POWER TRAIN,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

  THE DRIVELINE BROKER FROM IT'S HOLDING MOUNT WHILE DRIVING AND TANGLED UP THE FUEL LINE AND BRAKE LINES GOING TO THE REAR OF THE VAN. MAKING THE VAN LOSE POWER AND NOT BE ABLE TO BE DRIVEN ANYMORE. THIS HAPPENED WHILE DRIVING ON THE FREEWAY. THIS IS EXTREMELY DANGEROUS. ALSO THEY HAVE A RECALL ON THE REAR FLEX JOINT WHICH THE FORD DEALERSHIP HAS RECOGNIZED BUT ARE REFUSING TO PAY FOR THE TOTAL REPAIR. HOW IS THAT FAIR? IT IS FORD'S DESIGN FLAW THAT MADE THIS HAPPEN.

• 11/15/2023· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  Vehicle goes into "limp" mode while on highway losing the ability to control the acceleration. The van has to coast to a stop, turn off the engine, then restart. The throttle body was replaced twice (3/2/21 and 11/21/22). This causes a major safety risk for the driver, passenger and all other drivers on the road. Losing control of the vehicle mechanically without warning and in such a sporadic fashion is unacceptable at this age and mileage. 170,245 miles & 219,118 miles.

• 11/14/2018· ELECTRICAL SYSTEM

  ELECTRICAL, WIRING HARNESS CORRODED AND SHORTED OUT DASHBOARD INDICATORS. VAN WAS PURCHASED 10/26/2016 LOOKED AT DIFFERENT WEB SITES SAYING THERE IS A RECALL BUT FORD IS SAYING THAT IT DOES NOT PERTAIN TO THIS VAN, THE DESCRIPTION ON THE WEB SITE IS THE SAME AS DEALER REPAIRED.THE WIRING HARNESS REPAIRED WAS IN THE DRIVERS FOOTWELL, IN THE RECALL NOTICE POSTED IT SAID THE WIRING HARNESS SHOULD BE REPLACED NOT REPAIRED AND THAT A DRAINAGE HOLE BE MADE IN THE FOOTWELL PLUS INSTALLATION OF A FUSE TO PREVENT FIRES. NONE OF THAT WAS DONE.

• 11/10/2022· POWER TRAIN

  The contact owns a 2016 Ford Transit. The contact stated while driving at various speeds, the vehicle started shaking abnormally. The contact had to wait for the shaking to stop independently. The contact had taken the vehicle to a certified mechanic who diagnosed that the drive shaft needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that the failure was related to an unknown recall; however, the vehicle year was not included. The approximate failure mileage was 102,000.

• 11/08/2018· POWER TRAIN,SEAT BELTS,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

  WE ARE A TRANSPORTATION COMPANY . AND HAVE BOUGHT 4 OF THESE VEHICLES REGRETFULLY WE ARE SO OVERWHELMED WITH ALL THE ISSUES THEY HAVE HAD , A NUMBER OF MAJOR ISSUES LIKE SPEED SENSORS GOING BAD THROTTLE BODY HAVE BEEN REPLACED TRANSMISSION REPLACEMENT WITH ONLY 60,000 DRIVEN... LOSS OF POWER WHILE ON THE ROAD YOU NAME IT. CURRENTLY HAVE 2 OF THE VEHICLES AT THE DEALERSHIP WAITING ON TRANSMISSIONS WE HAVE CONTACTED FORD FOR SOME SORT OF ASSISTANCE , WE ARE LOSING MONEY BY HAVING OUR VEHICLES SIT AT THE DEALERSHIP WAITING TO GET SERVICED ALL THE TIME, IS ONE ISSUE AFTER ANOTHER ITS GOTTEN TO THE POINT THAT WE CROSS OUR FINGERS EVERYDAY HOPING FOR OUR DRIVERS TO MAKE IT BACK WITH NO ISSUES AND ALWAYS THINKING WHERE IS THE NEXT VAN GOING TO BREAK DOWN AND HOW WE ARE GOING TO DEAL WITH IT. VERY FRUSTRATING HAVING TO DEAL WITH THIS EVERYDAY HEADACHE.

• 11/06/2019· POWER TRAINCrash

  I OWN AND OPERATE A FORD F 250 TRANSIT VAN. TASK IS THE EXPEDITE OF AUTO & AEROSPACE PARTS THROUGH OUT THE COUNTRY. HAVE LEARNED THERE IS A SAFETY RECALL PER OEM AND NHTSA REGARDING DRIVETRAIN COUPLERS ( UNOINTS ). MY PARTICULAR VEHICLE HAS INCURRED DAMAGE AS RESULT OF COUPLER(S) FAILING. DAMAGE INCLUDING; NOT LIMITED TO DRIVESHAFT BECOMING DETACHED, SEVERANCE OF FUEL & BRAKE LINES, BREACH OF TRANSMISSION BELL HOUSING, OTHER. CATASTROPHIC FAILURE LEFT ME STRANDED IN DESERT FOR 2 DAYS, LOSS OF BUSINESS, LOSS OF INCOME, HEALTH RELATED ISSUES. THE RUBBER / POLYMER LIKE MATERIAL THESE COUPLERS ARE MADE OF ARE A SEVERE SAFETY HAZARD; ESPECIALLY IF VEHICLE IS OPERATED UNDER LOAD. FURTHERMORE, CUSTOMERS OPERATING THESE HAZARDS ARE NOT BEING NOTIFIED UNTIL NOVEMBER 11TH, 2019. SOMEONE NEEDS TO TAKE INITIATIVE BEFORE SOMEONE IS SERIOUSLY HURT. I WILL BE HAPPY TO FORWARD ANY ADDITIONAL INFORMATION/DOCUMENTS PERTAINING TO THIS MATTER. THANK YOU.

• 11/02/2023· ENGINE

  Freeway driving at rush hour, engine light came on suddenly, no other previous warning, with catastrophic engine failure, pull over immediately. I was able to coast to shoulder. No injuries. Could have caused an accident. Van is now at dealer, diagnosis unknown.

• 10/31/2022· STRUCTURE

  Sliding door jumps track, opening and or closing. Have driven home with door open because it wouldn't shut.

• 10/28/2025· POWER TRAIN

  The car has the same problem it had before the recall. The dealer who supposedly fixed it says it's no longer under the recall warranty.

• 10/19/2023· TIRES

  The contact owns a 2017 Winnebago Fuse RV built on a 2016 Ford Transit chassis and equipped with Hankook Tires, Tire Line: Dynapro HT, Tire Size: 195/75/R16, DOT Number: T7W7HUH. The contact stated that while inspecting the RV it was discovered that all four tires had developed cracks that extended around the outer walls of the tires. The cause of the cracks was not yet determined. The manufacturer and dealer were not yet notified of the failure. The failure mileage was 38,068.

• 10/19/2023· POWER TRAIN,SERVICE BRAKES, HYDRAULIC

  The contact owns a 2016 Ford Transit. The contact stated that while driving at 40 MPH, she heard an abnormal sound coming from an unknown location prompting her to attempt to slow the vehicle after which she became aware that the brake was not functioning properly. The contact stated that with the brake pedal depressed all the way to the floorboard the vehicle failed to slow as intended; violently coming to a complete stop on the shoulder of the roadway where the vehicle stalled and failed to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who determined that the driveshaft assembly had failed, damaging the brake lines, resulting in a loss of the hydraulic brake functionality. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number: 19V767000 (Power Train), and the VIN was included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 125,000.

• 10/17/2019· VISIBILITY,ENGINE

  TL* THE CONTACT OWNS A 2016 FORD TRANSIT. WHILE DRIVING 65 MPH, THE CONTACT BEGAN TO SMELL A BURNING ODOR AND FELT THAT THE SPEAKER AND CD THAT SHE EJECTED FROM THE RADIO WERE WARM. ALSO, WHEN THE DEFROSTER WAS ACTIVATED, STEAM BEGAN TO ACCUMULATE ON THE WINDOWS. AS THE CONTACT CONTINUED TO DRIVE, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT PULLED OVER AND ALLOWED THE VEHICLE TO COOL OFF. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE CONTACT TOOK THE VEHICLE TO AUTOFAIR FORD (1475 S WILLOW ST, MANCHESTER, NH 03103, 603-634-1001) WHERE IT WAS DISCOVERED THAT WATER WAS ACCUMULATING ON THE AIR FILTER. THE CONTACT STATED THAT WATER WAS ALSO DRIPPING ONTO THE BLOWER MOTOR HEATER, WHICH CAUSED AN ELECTRICAL SHORT. THE DEALER REPLACED THE BLOWER MOTOR AND INSTALLED A WATER DEFLECTION KIT. THEY ALSO REPLACED THE AIR FILTER AND THE AIR FILTER BOX COVER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND THERE WAS NO RECALL. THE MANUFACTURER OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 86,000.

• 10/16/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2016 Ford Transit. The contact stated while driving 40-45 MPH, the message "High Temperature - Pull Over Safely" was displayed. The contact stated that upon decelerating, the temperature gauge dropped, then started fluctuating from normal to high temperature. The contact was able to drive to the nearby residence. The contact stated while driving to the dealer the following day, the check engine warning light illuminated. The dealer diagnosed that the EGR was fractured. The vehicle was not repaired. The dealer informed the contact of Ford Campaign Number: 18M06; which the contact related to the failure. The manufacturer was notified of the failure and informed the contact that the campaign had expired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 150,000.

• 10/13/2021· SUSPENSION,WHEELS

  The contact owns a 2016 Ford Transit. The contact stated that while the vehicle was being driven at a low rate of speed, the rear passenger's side wheel suddenly detached from the vehicle. The vehicle was towed to the local dealer who diagnosed that the rear axle bolts snapped off causing the wheel to detach from the vehicle. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 76,000.

• 10/12/2019· POWER TRAIN

  I WAS AWARE OF THE RECALL 17S15 IN REFERENCE TO THE DRIVING SHAFT COUPLING, EVERY 30,000 MILES I CHECK THIS COUPLING AND EACH TIME THEY WOULD TELL ME THAT IT WAS CRACKED AND NEEDS TO BE CHANGE. AS SOON THE CALLED FIXED CAME OUT, IT WAS INSTALLED, BUT JUST LAST MONTH IT WAS CHECKED AGAIN AND THEY NOTICED THAT THE FAMOUS FIX ALSO WAS CRACKED AND THIS TIME THEY (LEVITTOWN FORD LONG ISLAND)TOLD ME THAT IT WAS NOT COVERED UNDER RECALL AND I HAD TO PAY OVER $800.00 DOLLAR'S FOR A NEW FIX. THAT IS THE REASON I AM PUTTING THESE COMPLAINT. THE IS REALLY DANGEROUS

• 10/11/2023· SERVICE BRAKES, HYDRAULIC,POWER TRAIN,SERVICE BRAKESCrash

  The involved individual was found with altered mental status on a highway on 8/13/2023. The vehicle he had been driving was found in the highway median a few hundred feet away. He was admitted to a local hospital, diagnosed with blunt force injuries of the head, and pronounced brain dead on 8/14/2023. Autopsy examination revealed fractures of the skull, subdural and subarachnoid hemorrhage, and cerebral cortical contusions. Mechanical vehicle inspection revealed that the driveshaft flexible joint failed while the vehicle was in motion, with resulting driveshaft uncoupling and severe damage to surrounding vehicle components including the brake and fuel lines. Investigation was consistent with the decedent exiting the moving motor vehicle.

• 10/10/2025· ELECTRICAL SYSTEMCrash

  Rear view camera either goes out or is upside down. Went out so hit something. Luckily no real damage. Went to dealer and they said it’s not part of recall

• 10/07/2022· EQUIPMENT

  The contact owns a Winnebago RV built on a 2016 Ford Transit chassis equipped with the original Cummins Onan generator with Model: 2.5HGJBB-1126A. The contact stated that while in use, the generator stalled. The contact then stated that he smelled a fuel odor throughout the RV. The RV was taken to the dealer where it was diagnosed that the fuel hose failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure however, no assistance was provided. The failure mileage was approximately 47,000. The contact stated failure mileage to be 27,000.

• 10/05/2021· POWER TRAIN

  I received a safety recall via mail for a driveshaft coupling malfunction. I had no noticeable problem with my vehicle safety nor did I have a warning light or message on the instrument panel. I turned in the vehicle to the local "Gosch" Ford dealership to perform the inspection. My vehicle was turned in on 07/21/2021 and the dealership has yet to receive the part. However, it has not been returned to me with the dealer citing the fact that it is unsafe to drive without the repair. I continue to receive the same statement that I need to wait and check back each week.

• 10/03/2018· TIRES

  TL* THE CONTACT OWNS A 2016 FORD TRANSIT 350XLT EQUIPPED WITH FOUR CONTINENTAL VANCO FOURSEASON TIRES, SIZE: 285/65/R16C (NA). WHILE DRIVING, ALL FOUR TIRES EXPERIENCED TREAD SEPARATION AND CHIPPING. THE CONTACT NOTICED THAT RUBBER TREAD PIECES WERE VISIBLY SEPARATED FROM THE TIRE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE LOCAL DEALER (NORM REEVES FORD, 18900 STUDEBAKER RD, CERRITOS, CA) WAS ALSO NOTIFIED OF THE FAILURES. THE VIN AND DOT NUMBER WERE UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 10,000.

• 10/02/2019· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  RIGHT SIDE BRAKE LIGHTS AND DIRECTIONAL ARE NOT WORKING. THEY DON'T WORK AT ALL IN ANY SITUATION. COULD BE THE BCM MODULE. THIS MIGHT BE THE RECALL NUMBER 17S34

• 09/30/2025· UNKNOWN OR OTHER

  The vehicle back up camera goes out when reversing. Not every time, but intermittently, maybe 50% of the time. The screen goes blue, followed by the message "Rear View Camera Not Available." This makes it incredibly challenging to see pedestrians or cars directly behind the vehicle. It has not had it confirmed by a dealer; the local dealer said there was nothing yet in their system stating a recall on the vehicle. The NHTSA Advance Notice Safety Recall 25S89 specifically calls out the vehicle as being potentially affected, based on assembly plant and build dates. I have not had it inspected by the manufacturer, police, insurance representatives, or others. There have been no warning lamps. Just the screen going blue, followed by the message "Rear View Camera Not Available"

• 09/28/2023· ELECTRICAL SYSTEMFire

  The contact owns a 2016 Ford Transit. The contact stated that while the vehicle was parked unattended, it spontaneously caught fire. There were no warning lights illuminated prior to the failure. The doors failed to open. After the fire, the owner noticed that the wires were hanging from the door panel. The owner was able to extinguish the fire. There were no reported injuries. The fire department was not contacted. The air bags were deployed. A police report was not filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred to the NHTSA Hotline. The failure mileage was unknown. The contact referenced the failure of Ford recall number 17S34.

• 09/24/2019· POWER TRAIN

  TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE VEHICLE WAS TAKEN TO PALLOTTA FORD LINCOLN (4199 CLEVELAND RD, WOOSTER, OH 44691, (330) 345-6600) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V408000 (POWER TRAIN); HOWEVER, THE REMEDY FAILED. WHILE DRIVING 25 MPH, THE VEHICLE VIBRATED VIOLENTLY. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FLEXIBLE COUPLING WAS FRACTURED. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,500. *TT *AS

• 09/20/2021· ENGINE

  While on a road trip with my 6 kids, I had a brake issue with my 2016 Ford Transit. The first time it happened, I was driving about 55 mph, hit the brakes and the engine revved & accelerated. I pumped the brakes, engine stopped revving. Honestly thought I did something wrong. Same thing happened again two days later. I stopped and cleaned the sensors hoping that would resolve the issue. The next day the same thing happened making it hard to stop. I went straight to Ford and had two Ford dealerships tell me the vehicle was fine. Brakes were checked and was told no problems. I asked if it could be a leak in brake booster and was told no. No lights were coming on. I took the van to Les Schwab and was told the same thing. Unsure what to do, my brother came to the rescue and took the van. He started driving it home to California from Colorado. I rented an RV and continued our road trip. 80 miles later, the engine on the van made a loud bang and ceased. No engine lights. My brother said the engine started having acceleration problems so he stopped and checked all of the fluids. Everything was fine and engine was not overheated. But, complete engine failure at 79,000 miles. This was July. Since then, we paid to have a new engine installed. My husband flew out to pick up the van and new engine started having problems. He had to fly back home. Ford has said that the new engine is bad so they are paying for rental car and getting another new engine installed. Still do not have van. It's been three months. My concern is something else is going on...just seems extremely strange. I am still worried about the braking and revving bit and wonder if anyone else has had a similar issue.

• 09/17/2024· SUSPENSION,VEHICLE SPEED CONTROL

  The contact owns a 2016 Ford Transit. The contact stated while driving at an undisclosed speed, the vehicle was vibrating abnormally. The contact stated that there was a loud squeaking noise while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 72,419.

• 09/16/2019· POWER TRAIN

  THE VEHICLE HAS HAD THE FORD'S FINAL FIX FOR 17V408000. I PERIODICALLY INSPECT THE FLEXIBLE COUPLING AND DURING THE INSPECTION TODAY I OBSERVED A CRACK IN THE FLEXIBLE COUPLING. CRACKED FLEXIBLE COUPLINGS ARE A SAFETY ISSUE, AS EVIDENCED BY 17V408000. IT IS DISAPPOINTING THAT FORD IS UNABLE OR UNWILLING TO REPAIR THIS PROBLEM.

• 09/14/2022· POWER TRAIN

  The contact owns a 2016 Ford Transit. The contact stated that when the vehicle was shifted into drive(D), the vehicle would shudder and shake until the vehicle accelerated to 30 MPH. The contact stated no warning light was illuminated. The contact stated that the failure had become constant. The contact drove the vehicle to an independent mechanic, where it was diagnosed that the driveshaft coupling had failed and needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 17V408000 (Power Train). The manufacturer had been informed of the failure. The failure mileage was approximately 86,000.

• 09/12/2019· ENGINE

  I HAVE A 5 TRANSIT VANS AND ALL OF THEM ARE GIVING ME CATALYST PROBLEMS , I CAN UNDERSTAND MAYBE ONE VEHICLE WITH A PROBLEM BUT WHEN ALL HAVE THE SAME SYMPTOMS SOMETHING IS NOT WORKING RIGHT,MY TRANSIT 3.5 HAS GONE THROUGH 2 OF THEM ALREADY, THEY HAVE ISSUES WITH THE CATALYST SYSTEM AND IT'S VERY EXPENSIVE TO FIX I JUST PAYED $2,500 TO REPLACE THE SECOND ONE ON MY TRANSIT 350 3.5 . THIS HAS TO BE LOOKED AT

• 09/10/2025· UNKNOWN OR OTHER

  The rear back up camera is very hit and miss….. works sometimes and not other times. Shows blue screen color,black screen color when it does not work.

• 09/07/2023· STRUCTURE

  The contact owns a 2016 Ford Transit. The contact stated that while the vehicle was parked, the interior door handle detached, trapping the contact inside the vehicle. No warning light was illuminated. The vehicle had been diagnosed by an independent mechanic and determined that the failure was with the door handle bracket and switch. The door handle was replaced. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 145,561.

• 09/05/2017· STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  FORD TRANSIT IS DESIGNED TO ALLOW THE IGNITION KEY TO BE TURNED OFF WHILE IT'S IN ANY GEAR INCLUDING WHILE IT'S IN DRIVE ON THE HIGHWAY. TURNING THIS KEY WHILE ON THE HIGHWAY WILL CAUSE THE POWER STEERING TO GO OUT CAUSING A DANGEROUS SITUATION FOR THE DRIVER. MY VAN HAS TURNED ITSELF OFF WHILE I WAS DRIVING ON THE HIGHWAY AT 60 MILES AN HOUR FOUR TIMES BECAUSE MY KNEE TOUCHED THE KEY. TO MAKE MATTERS WORSE, THE STEERING COLUMN IS ADJUSTABLE BUT IT ADJUST ITSELF WITHOUT ACTIVATING THE LEEVER CAUSING THE STEERING COLUMN WITH THE IGNITION KEY TO CONSTANTLY COME CLOSER TO MY KNEES. TWO FORD DEALERSHIP SAID THAT IT'S WORKING AS DESIGNED. THE DESIGN NEEDS TO BE CHANGED BECAUSE IT'S UNSAFE. *TT *DT CONSUMER STATED DESIGN FLAW WITH NOT HAVING AN INTERLOCK INSTALLED. UPDATED 11/7/18*JB*BF VIN NUMBER INVALID UPDATED 11/20/18*JB UPDATED 11/20/18 *DT *JB *DT *DT*JB *DT VIN INVALID *JB