2016 Ford Cmax HEV

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/12/2019· POWER TRAIN

  TL* THE CONTACT OWNS A 2016 FORD C-MAX. WHILE DRIVING APPROXIMATELY 15 MPH DOWNHILL, THE "STOP SAFELY NOW" AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE STALLED AND THE CONTACT CRUISED DOWN A HILL INTO A NEARBY PARKING LOT. THE VEHICLE WAS TOWED TO FORMULA FORD INC (LOCATED AT 265 RIVER ST, MONTPELLIER, VT 05601, 802-223-5201) WHO STATED THAT THE SOBD MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE; HOWEVER, THE CONTACT WAS STILL AWAITING APPROVAL ON THE PART FOR THE REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

• 11/21/2023· VISIBILITY/WIPER,BACK OVER PREVENTION

  The backup camera doesn't regularly function, ranging from 15% to 75% of the time. A tire man with prior experience in a Ford dealership recommended checking for an electronics update to the system. There may be a worsening functionality when the weather is wet, but that's not a clear correlation.

• 10/04/2017· ELECTRICAL SYSTEM

  THE CAR WENT INTO "LIMP" MODE WHILE GOING 70 MPH. TOOK THE CAR IN AND WE WERE TOLD IT HAD A RECALL ON THE ELECTRONIC THROTTLE BODY. WE NEVER RECEIVED A RECALL NOTICE AND IT ISN'T LISTED ON THE NHTSA SITE.

• 09/23/2020· AIR BAGS,VISIBILITY/WIPER

  THE PASSENGER-SIDE BOTTOM CORNER OF THE WINDSHIELD HAS BECOME UNGLUED. A GLASS REPAIR SHOP INFORMED US THAT THE FRONT PASSENGER AIR BAD DEPLOYS OFF OF THE WINDSHIELD. IN THE EVENT OF AN ACCIDENT, THE PASSENGER SIDE FRONT AIR BAG MAY NOT FUNCTION PROPERLY, RESULTING IN INCREASED RISK OF INJURY TO THE FRONT SEAT PASSENGER. WE NOTICED THE RIGHT BOTTOM CORNER OF THE WINDSHIELD LIFTING UP WHEN WE WERE CLEANING THE WINDSHIELD FROM THE INSIDE. THE VEHICLE IS BEING TAKEN TO FORD FOR A DIAGNOSTIC EVALUATION, BUT ALL WARRANTIES HAVE EXPIRED.

• 09/07/2021· UNKNOWN OR OTHER

  Rear backup camera intermittently does not show any image on the screen. When this happens the screen is either blue or black and camera image either flashes in and out or never shows up at all. This happens approximately 10% of the time the vehicle is put in reverse - the rest of the time the camera works normally.

• 06/22/2021· ELECTRICAL SYSTEM

  The contact owns a 2016 Ford C-Max Hybrid. The contact stated upon starting the vehicle, the display screen would not display any images and not allow the contact to use any of the functions. The contact also stated that sometimes it would take up to 5 minutes for the display screen to engage. The vehicle was taken to a local dealer where it was diagnosed with nothing needing to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure and referred the contact to the NHTSA. The failure mileage was approximately 85,000.

• 06/16/2021· SERVICE BRAKES, HYDRAULIC,SERVICE BRAKES

  Component Failure The ABS system failed with only 14,500 miles on the odometer. Symptom The brake pedal became soft, Allowing more brake pedal travel than normal. Taken to Ford dealer Symptom described to service Representative and was told after several hrs that the brakes were normal. I told them that the brake pedal was always taut and the current behavior could become a danger to others and myself. It's after I provided my own OBD11 scan report ( Using a BlueDriver scan tool ) that indicated there is an Anti-Lock Brake module Code Failure That convinced them and Was told to leave the vehicle overnight. Dealer confirmed, that there is a definite problem and that it could be the brake master cylinder and brake booster. There were no warning lamps indication or lights except for the brake pedal losing pressure. The brakes did function, but the pedal almost when to the floor. Currently My Ford Cmax Sel Hybrid has been sitting in their service center for 7 days just waiting for Ford warranty service approval and was just notified that it was okayed and I would have to wait for parts to be ordered.

• 05/07/2021· WHEELS

  REAR TIRES REPEATEDLY WEARING OUT. THIS COULD CAUSE A BLOWOUT CAUSING HARM TO MYSELF AND OTHERS

• 04/30/2019· SUSPENSION

  2017 CMAX CLUNKING SOUND COMING FROM UNDERCARRIAGE OF VEHICLE. STRUT BRACE FAILURE ON ONE SIDE OF VEHICLE AT AROUND 12,000 MILES. THEN THE OTHER SIDE STRUT BRACE FAILED A FEW THOUSAND MILES LATER.

• 04/12/2016· UNKNOWN OR OTHERCrash

  HEAD IMPACT - PREVIOUSLY RECALLED IN JULY 2013 BY FORD MOTOR COMPANY FOR HEADLINER DESIGN ISSUES. STRUCK WHEN TURNING VEHICLE ONTO HIGHWAY.

• 02/27/2022· BACK OVER PREVENTION

  Both this 2016 and my 2013 ford c-max hybrid have the backup cameras failing. Sometimes they work, and sometimes they have a black or blue screen than pops up and it says camera unavailable. I know there is a recent recall for other fords with backup camera issues, but the c-max sells much lower volumes so it is harder to get the same exact problem recalled.

• 02/18/2025· ENGINECrash

  The contact owned a 2016 Ford C-Max. The contact stated that while coming to a stop in a parking lot attempting to obtain mail from a mailbox; the vehicle independently accelerated and it was unknown what gear the vehicle was stationed in. In addition, it was unknown if the brake pedal was depressed or the gear the vehicle was in at the time of the failure. The vehicle had struck and knocked 3 mailboxes down and crashed into the front passenger side corner panel of a Mail Van coming to a stop as it was revving. The vehicle traveled 26 feet from its original stationed position. The vehicle was deemed a total loss. Both front wheels were severely bent outwards after the crash. The air bags did not deploy. The mail delivery employee sought medical attention for cuts and bruises. The contact did not seek medical attention or sustained any injuries. A police report was filed. The vehicle was towed to a tow lot by AAA where it was later taken by the insurance provider for further investigation. The local dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 44,530.

• 01/15/2022· UNKNOWN OR OTHERFire

  I was driving slowly leaving a supermarket parking lot. There was no one else around. There was a sudden loud bang, the car lurched upward and to the right, coming to rest over a curb hanging down a ditch. The front end started to smoke and then caught fire. The car was a total loss. There had been no impact. I was able to escape down the ditch with the help of police and the fire department put out the fire. The first 2 pictures are on the scene; the remainder in the tow lot. Friends have suggested that perhaps the hybrid battery exploded.

• 01/04/2022· SEATS

  We drove from Cincinnati, OH to Wray, Co for Christmas. We drove 15 hrs straight back home ( gas and potty breaks). I drove the last 9 hrs. I have fibromyalgia and osteoarthritis. So the heated seats are wonderful - usually. Yes, I used the heated seats almost all the way. I’m always hurting so I didn’t notice a problem. On our last gas stop I told my husband I must have been sweating because I felt like I had a heat rash. We got home at 3 am and my husband said it looked more like a burn. It was painful and when I looked at it I saw blisters. Next morning it was more painful and red and ugly looking. I called Ford Corporate to give them a heads up that there was an issue with their heated seats. They stated they couldn’t help. Sorry I got hurt. Take it to local service and let them know. Called Ford service - they can get me in on Jan 17 and I have to pay for it. I just want someone aware that their heated seats can cause severe burns. Btw. The burn is on my upper right thigh.