2015 Ford Flex

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Flex. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that while in reverse(R), the rearview camera would display a blank or distorted image. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Neither the dealer nor the manufacturer was made aware of the failure. The failure mileage was unknown.

• 12/28/2022· STEERING

  I was exiting the interstate and an error message came up in mid turn and I lost my power assisted steering causing me to almost hit the concrete divider.

• 12/14/2017· FUEL/PROPULSION SYSTEM

  I WAS DRIVING APPROXIMATELY 45 MPH UPHILL WHEN SUDDENLY, AND WITHOUT WARNING, THE FLEX DECELERATED TO A COASTING SPEED. I WAS ABLE TO PULL INTO A TURN LANE BUT UNABLE TO ACCELERATE. THE WRENCH LIGHT CAME ON. I TURNED OFF THE CAR AND TURNED IT BACK ON. THE WRENCH LIGHT WAS ON AND THEIR WAS ABILITY TO ACCELERATE BEYOND CRAWLING. I TURNED THE CAR OFF AND BACK ON AND WAS ABLE TO DRIVE NORMALLY TO WORK.

• 12/10/2019· SUSPENSION

  I WAS DRIVING MY 2015 FORD FLEX AND I MADE A RIGHT TURN GOING LESS THAN 5MPH. ONCE I STRAIGHTENED OUT MY STEERING WHEEL, ALL WITHIN 2 SECONDS, I SUDDENLY HEARD A GRINDING NOISE THEN MY REAR TIRE BENT OUTWARD AT AN ANGLE. I WAS TOLD BY THE REPAIR SHOP THAT IF I WAS GOING AT LEAST 25MPH, THE WHOLE TIRE WOULD OF FLOWN OUT AND CAUSED WORSE INJURY. THE REPAIR SHOP INFORMED ME THAT THE REAR LEFT TOE LINK IS GOING BAD AS WELL AND IT LOOKS LIKE THIS IS POSSIBLY BE A DEFECTED PART FORD IS USING. FORD IS REFUSING TO HELP OR CARE ABOUT THIS PROBLEM. THERE WAS NO WARNING THAT THE PART WAS BAD AND THE CAR NEVER DROVE BAD. THIS ALL HAPPENED OUT OF NO WHERE. THIS IS VERY UNSAFE AND NEEDS TO BE INVESTIGATED. THIS PART WAS RECALLED IN CANADA IN JUNE 2019. IT NEEDS TO BE RECALLED IN USA AS WELL.

• 12/09/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Flex. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while in reverse, the back-over prevention camera went black or displayed a message to the driver to see the dealer. The dealer was contacted and confirmed that parts had been ordered; however, parts were not received, and the contact was still waiting for parts to be provided. The manufacturer was not made aware of the issue. The failure mileage was approximately 123,000.

• 12/07/2016· ELECTRICAL SYSTEM,ENGINE

  TL* THE CONTACT OWNS A 2015 FORD FLEX. WHILE BOTH THE ENGINE AND AIR CONDITIONING WERE ACTIVATED FOR A SHORT PERIOD OF TIME, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED WITHOUT WARNING. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT IT WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 24,000.

• 12/06/2018· STEERING

  WAS STOPPED AT LIGHT VEHICLE STEERING WOULD NOT TURN I PUT THE CAR IN PARK TURNED OFF ENGINE THEN ON. STEERING WORK OK FOR TIME BEING. DEFINITELY A SAFETY ISSUE

• 10/21/2019· FUEL/PROPULSION SYSTEM

  ON OCTOBER 18, 2019, WHILE ENTERING A PARKING SPACE AT THE IKEA PARKING LOT, MY CAR EXPERIENCE A LOSS OF POWER, CAUSING THE ENGINE TO STALL. I TRIED TO START IT UP ABOUT 10 TIMES, AND NOTHING HAPPENED - IT FAILED TO START EVERY TIME. AFTER ABOUT 2 HOURS OF TRYING, I FINALLY HAD TO HAVE IT TOWED TO MY HOUSE. WHEN I PERFORMED A OBD-II SYSTEM SCAN, WITH MY SCANNER, I GOT A FAULT CODE OF P0627 (FUEL PUMP A CONTROL CIRCUIT) I TOOK THE CAR TO THE FORD DEALER, AND EXPLAINED THE PROBLEM. AFTER TWO HOURS, THEY CALLED ME AND SAID THEIR TESTS REVEALED NO FAULT CODES. BASED ON THE ISSUE I DESCRIBED, THEY SAID THAT IF I WANTED, THEY CAN CHANGE THE FUEL PUMP, BUT I WOULD HAVE TO PAY $100 DEDUCTIBLE UNDER THE EXTENDED WARRANTY PLAN. THE THINK THAT MAY FIX THE ISSUE OF STALLING, OR NOT STARTING. MY ISSUE IS THAT IF THE PROBLEM IS NOT FIXED, IT MAY INCREASE THE RISK OF A CRASH, AT ANY GIVEN TIME, AND WITHOUT NOTICE. GIVEN THE FACT THAT THERE ARE OTHER COMPLAINTS ABOUT THIS SAME ISSUE, I THINK THAT A GENERAL RECALL FOR THIS MAKE/MODE/YEAR CAR SHOULD BE INITIATED, BEFORE SOMEONE LOSES THEIR LIFE OVER IT.

• 10/19/2020· POWER TRAIN,ENGINE

  WHEN VEHICLE IN MOTION ON MAJOR ROADWAY, LOSS OF POWER AND GOES INTO LIMP MODE. YELLOW WRENCH LIGHTS UP. VEHICLE DOES NOT RESPOND TO THROTTLE. I HAVE TO SHUT OFF VEHICLE AND TURN IT BACK ON . THERE IS NO DTC CODE WHEN CHECKED. I WAS ALMOST REAR ENDED WITH MY CHILDREN IN THE VEHICLE AT TIME OF INCIDENT. CAR LOSES POWER AND RAPIDLY DECELERATES WITHIN 5 SECONDS. THERE IS ZERO TIME TO PULL OFF THE ROAD WHICH PUT US AT HIGH RISK OF BEING REAR ENDED. THIS IS A LIFE/ROAD SAFETY HAZARD

• 10/19/2017· UNKNOWN OR OTHER

  EXHAUST LEAK INTO VEHICLE WHEN GOING UP HILLS OR ACCELERATING. DEALER TESTING SHOWED HIGH LEVELS OF CARBON MONOXIDE IN VEHICLE. AFTER BEING IN THE SHOP FOR 9 CONTINUOUS WEEKS THEY HAVE REDUCED BUT NOT ELIMINATED THE EXHAUST LEAK

• 10/15/2024· UNKNOWN OR OTHER

  Rearview camera issues- Camera does not come on 90% of the time. Will get an error that camera requires service. I brought this ford's attention when a similar recall went out on the Bronco, as I also own a Bronco. I was advise a there was no details available

• 10/08/2020· FUEL/PROPULSION SYSTEM

  VEHICLE SUDDENLY SHUT DOWN CAUSING THE VEHICLE TO STALL AND NOW WON'T START. SEEMS LIKE OUR VEHICLE HAS NO POWER GOING TO THE FUEL PUMP. THIS HAPPENED WHILE DRIVING DOWN THE ROAD. VEHICLE NOW WILL NOT START BUT DOES STILL HAVE LIGHTS COME ON. ACTS LIKE ITS NOT GETTING FUEL.

• 10/02/2018· ELECTRICAL SYSTEM

  FALSE AND PERSISTENT DOOR AJAR WARNING AND RELATED TRANSMISSION NOT IN PARK WARNING (WHEN IN MOTION) .

• 10/01/2018· FUEL/PROPULSION SYSTEM

  I WAS TRAVELING WESTBOUND ON INTERSTATE 265 AT APPROXIMATELY 4 A.M. SUNDAY MORNING SEPTEMBER 30TH. THE VEHICLE STALLED OUT AND CAME TO A COMPLETE STOP ON THE INTERSTATE. A WRENCH LIGHT WAS SHOWN ON THE DASH AND THE VEHICLE WOULD NOT MOVE FORWARD. THE INCIDENT WAS CAUSED BY A SAFETY BULLETIN NUMBER 17 B28. LUCKILY I WAS ABOUT THE ONLY ONE ON THE ROAD AT THAT HOUR, BECAUSE I AM CERTAIN THAT HAD THIS HAPPENED IN RUSH HOUR TRAFFIC THERE WOULD HAVE BEEN AN ACCIDENT.

• 10/01/2018· STEERING

  I WAS DRIVING AT 70MPH AND STARTED RECEIVING WARNINGS ABOUT MY ADVANCE TRAC. I THAT POINT I SLOWED DOWN AND PULLED OVER AND LOST ALL POWER STEERING.

• 09/29/2020· SUSPENSION

  TL* THE CONTACT OWNS A 2015 FORD FLEX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V072000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED HERITAGE FORD (2100 SISK RD, MODESTO, CA 95350; 1-844-362-2226) WHERE IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT STATED THAT THERE WAS A CLUNKING SOUND COMING FROM THE FRONT AND REAR OF THE VEHICLE WHILE DRIVING. THE CONTACT STATED THAT WHILE DRIVING 55 MPH OR ABOVE, THERE WAS LITTLE TO NO STABILITY IN THE VEHICLE'S PERFORMANCE. THE CONTACT STATED THAT STEERING THE VEHICLE WAS DIFFICULT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 09/24/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Flex. The contact stated that the back-over prevention camera image was displayed upside-down. There were static lines on the screen, and the camera became inoperable. The message to “Contact Dealer” was displayed. The local dealer was contacted, and it was determined that the camera needed to be replaced. The dealer informed the contact that parts were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.

• 09/23/2020· SUSPENSION

  TL* THE CONTACT OWNS A 2015 FORD FLEX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V072000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT SPOKE WITH REINEKE FORD LINCOLN OF LIMA (1360 GREELY CHAPEL RD, LIMA, OH 45804; (419) 223-3673) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 09/19/2016· VEHICLE SPEED CONTROL

  I WAS DRIVING IN THE HIGHWAY GOING ABOUT 65 MPH WHEN WITHOUT WARNING I STARTED LOOSING SPEED AND ENDED GOING 20MPH. I WAS ABLE TO PULL OF TO THE SHOULDER AND NOTICE A WRENCH ICON APPEAR IN THE DASH BEFORE THE CAR LOST POWER. IT WAS AN EXTREMELY SCARY SITUATION AND I WAS THANKFUL I WAS ABLE TO GET TO THE SHOULDER OF THE HIGHWAY WITHOUT ANY INCIDENT. I TOWED IT TO MY FORD DEALER WHICH IS STILL THERE BEING DIAGNOSE. I DON'T KNOW WHAT HAPPEN BUT I BELIEVE ITS A DEFECTION BECAUSE NOTHING WAS DONE TO CAUSE IT. THESE IS A VERY DANGEROUS DEFECTION AND CAN CAUSE THE LIFE OF THE DRIVER AND PASSANGERS. I WANT TO MAKE THE FORD COMPANY AWARE OF THIS SITUATION AND DEMAND IT TAKES ACTION BEFORE A TRAGEDY HAPPENS. I HOPE MY FORD FLEX IS FIXED BUT I WILL NEVER FEEL FULLY SAFE IN THIS VEHICLE AGAIN. I NEVER KNEW THAT MANUFACTURES WOULD BE CARELESS ENOUGH TO PLACE THESE DEFECTIVE CARS ON THE ROAD AND NOW I AM STUCK WITH ONE. PLEASE HAVE A RECALL OF THESE FORD VEHICLES BEFORE LIVES ARE LOST.

• 09/16/2016· SEATS

  TL* THE CONTACT OWNS A 2015 FORD FLEX. WHILE AS A PASSENGER IN THE VEHICLE, THE MIDDLE ROW SEAT ON THE RIGHT INADVERTENTLY MOVED FORWARD. AS A RESULT, THE SEAT COLLAPSED AND THE HEAD REST STRUCK THE CONTACT IN THE BACK OF THE HEAD. THE CONTACT SUSTAINED INJURIES TO THE HEAD AND EYES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.

• 09/16/2016· ENGINE

  TL* THE CONTACT OWNS A 2015 FORD FLEX. WHILE DRIVING APPROXIMATELY 60 MPH, THE SPEED SUDDENLY REDUCED TO 20 MPH AND THE CHECK ENGINE INDICATOR ILLUMINATED. AFTER RESTARTING THE VEHICLE, THE FAILURE OCCURRED A SECOND TIME BEFORE STALLING. THE VEHICLE WAS TOWED TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 8,200.

• 09/14/2021· UNKNOWN OR OTHER

  We were on the way back from the grocery store on September 4th, 2021. We were traveling on the freeway at about 60mph when the car suddenly lost power. The only warning light was a wrench on the display. All electrical power remained on but there was no engine power and no acceleration. We were fortunate there was a shoulder where I was able to pull over. I coasted the car down the exit and onto a street away from traffic. I waited about 10 minutes, turned the car off and turned it back on and it started. The wrench light on the display was off. I called the local Ford Dealership and the Service Advisor said there were no recalls and that I would need to pay for a diagnostic check. The issue has not reoccurred.

• 09/12/2025· UNKNOWN OR OTHER

  I am having the same issues that were recalled in the 2019 Ford Flex backup camera. My 2015 Ford Flex backup camera is malfunctioning, going black, flipping the image and flashing randomly. It has progressively gotten worse.

• 09/11/2025· UNKNOWN OR OTHER

  I contacted Ford about my issue when I learned that recalls on other Ford products were issued for my fault. I was told that there was no recall for this issue and they would only fix it if I paid for it. Since then a recall for 2015 Ford Flex has finally been issued. My 2015 Ford Flex is experiencing backup camera issues the same as reported in the 2015 Flex recall issued earlier this year. I have talked to local Ford dealers as well as Customer Recall Support. They all say that since it is not included in the recall list they will not fix it. I will have to pay for diagnosis plus any repair costs. Since this is already stated to be a Safety Issue, I feel that it should be fixed by the manufacturer. Just because they did not include my VIN in their recall list should not be an excuse for not fixing the Safety Problem. I asked for a list of the serial number range of the recall but they would not provide. When I requested to speak to higher management they also declined to give me that information as well. I have been involved with high volume manufacturing for over 50 years and know that although every attempt to quantify a range of products with a certain defect may be made, it is not possible to 100% guarantee that there is not an outlier in the distribution. As the watchdog for defective automotive product (especially Safety Issues) I feel that NHTSA should be involved and assist me in getting Ford to correct this Safety issue.

• 09/10/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  back up camera works intermittently. black screen, camera not available, works for short period of time then goes blank, and upside down camera have all been exhibited .

• 09/10/2020· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  I TOOK IT TO RUSSELL AND SMITH FORD IN HOUSTON, TX. THEY SAID THE BATTERY WAS THE ISSUE. A WEEK LATER SAME PROBLEM, IT CRANKS BUT WONT TURNOVER. IT IS NOW AT STERLING MCCALL FORD IN HOUSTON WITH THE SAME PROBLEM. I WILL ATTACH THEIR DIAGNOSIS. I HAVE 57, 000 MILES ONLY ON THIS VEHICLE. I HOPE THAT THIS WILL ALL GO OUT TO ALL FORD DEALERSHIPS..THANK YOU

• 09/10/2015· FUEL/PROPULSION SYSTEM

  I WAS ENTERING AT CARPOOL LANES WHEN A DEBRIS HIT THE UNDERBODY OF THE VEHICLE, I JUST HEARD A BIG HIT UNDERBODY AND CONTINUE DRIVING AFTER TWO MILES ANOTHER DRIVER NOTICE FLUIDS WERE DRAINING FROM THE BOTTOM OF THE VEHICLE AND URGE ME TO CHECK WHEN I STOPPED I FIND OUT THE DEBRIS HAD MAKE A HEAVY DAMAGE TO THE GAS TANK AND GASOLINE WAS IN EFECT DRAINING FAST. I STOPPED AND TURN OFF THE ENGINE AND A FRIEND OF MINE HELP ME TAKE THE DAMAGE VEHICLE TO MY HOUSE WHERE THE THE REST OF THE GASOLINE DRAIN OUT. I PUT SAND INTO THE DRAIN GASOLINE AND TRY TO CATCH THE MORE I COULD INTO A SMALL BUCKET, I WAS AFRAID THE CAR COULD CATCH FIRE SO I PUT UNDER A SHADOW THE TEMPERATURE WAS 97 FRTH NEITHER THE GAS GAUGE STARTED MARKING IT WAS GETTING EMPTIER OR A CHECK ENGINE LIGHT SHOW UP AT THE DASH BOARD

• 08/29/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Flex. The contact stated that while reversing, the back-over prevention screen failed to function as intended. Additionally, the message “Camera not Available” was displayed. The contact stated that the failure was intermittent. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,000.

• 08/29/2024· STEERING

  The contact owns a 2015 Ford Flex. The contact stated while driving 45 MPH, the message "Steering Assist Loss - Service Now" was displayed. The contact stated that the vehicle lost power steering functionality while driving 20 minutes later. The contact pulled over to the side of the road. The vehicle was towed to an independent mechanic, where it was diagnosed, but the cause of the failure could not be determined. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the dealer for diagnosing testing. Additionally, the manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 183,000.

• 08/26/2018· STEERING

  POWER STEERING SUDDENLY FAILED. SYSTEM WARNED OF VSC FAULT, THEN STEERING ASSIST FAULT, THEN THERE WAS NO POWER ASSIST, AT 50MPH. I WAS DRIVING STRAIGHT ON AN AIRPORT ACCESS ROAD. THE PROBLEM PERSISTED FOR A 2 MILES OR SO, WHEN I WAS ABLE TO GET IT OFF THE ROAD SAFELY. WHEN I TURNED OFF THE IGNITION AND RE-STARTED A FEW MINUTES LATER, THE PROBLEM WAS GONE, AS WERE THE WARNINGS.

• 08/25/2025· STEERING,ELECTRICAL SYSTEM

  Steering Service Fault and Avancetrac Service popped up while driving, vehicle has 110k miles. Lost all power steering, so we pulled off into the closest parking lot. Code U3000 pulled up with a code reader, waiting to have vehicle towed to Ford for a solution.

• 08/17/2018· VEHICLE SPEED CONTROL,ENGINE

  TL* THE CONTACT OWNS A 2015 FORD FLEX. WHILE DRIVING APPROXIMATELY 5 MPH ATTEMPTING TO MERGE ONTO A HIGHWAY, THE VEHICLE STARTED TO LOSE ACCELERATION AND HESITATED. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE THROTTLE BODY WAS CLOGGED AND NEEDED CLEANING. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED AT LEAST TWENTY TIMES DURING THE PAST EIGHTEEN MONTHS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

• 08/10/2020· STEERING

  MY WIFE WAS DRIVING STEERING FAULT SERVICE NOW WARNINGAPPEARED NEXT DAY I WAS LEAVING WORK & POWER STEERTNING WENT OUT WAS ON HYWAY ( NOT MANY TURN ) MADE HOME LUCKLY MY WIFE NOT DRIVING STEERING WENT OUT WITH NO WARNING TOWED TO FORD DEALER THEY REPLACED STEERING GEAR ASSMBLY $ 2600

• 08/09/2021· STEERING

  A Ford Lincoln dealer installed a new Battery Cable Assembly (Part DA8Z*14300*BA) in my 2015 Ford Flex on 8/5/2021. After 20 miles of driving in two trips the power steering failed at the start of a third trip on 8/6/2021. I struggled to get the vehicle to a parking lot and turned it off. The yellow image of a car skidding had appeared on the information display. I turned the vehicle back on and the steering operated as normal. I drove the vehicle again on 8/8/2021 and it operated as normal. It is necessary for Ford to inform all owners of this issue as it could result in an accident if a driver is not aware of the potential for a power steering failure.

• 08/06/2016· POWER TRAIN

  VEHICLE WAS IN MOTION AT HIGHWAY SPEED WHEN IT SUDDENLY DECELLERATED AND CHECK ENGINE LIGHT CAME ON. DRIVER WAS ABLE TO STEER/COAST TO SIDE OF ROAD. ENGINE WAS RUNNING, BUT VEHICLE HAD NO ACCELERATION. VEHICLE WAS TOWED TO A DEALER AND DEALER REPLACED THE THROTTLE BODY PART. DEALER INDICATED DEFECTIVE THROTTLE BODY PARTS WERE NOT UNCOMMON ON FORD VEHICLES. SUDDEN DECELLERATION COULD HAVE RESULTED IN SIGNIFICANT SAFETY RISK HAD TRAFFIC BEEN HEAVIER AND/OR LESS SKILLED DRIVER.

• 08/01/2017· POWER TRAIN,FUEL/PROPULSION SYSTEM

  DRIVING ON I75 HEADED SOUTH JUST N OF FORSYTHE GA 3 LANES OF TRAFFIC 75 MPH OR FASTER WRENCH LIGHT COMES ON AND NO POWER. WITH GODS LUCK THERE WAS LIKE A 10 SECOND WINDOW WHERE WE GOT OVER TO TO RIGHT BEEN AND OF THE ROAD. MY WIFE AND GRANDDAUGHTER WERE VERY FRIGHTENED. CAR WAS DEAD NO POWER! WAITED A COUPLE MINUTES AND THE CAR STARTED SO THE AIR WOULD WORK THIS IS JULY 1ST CALLED ROADSIDE ASSISTANCE FIRST OPERATOR WAS NOT GOOD AND HER ENGLISH WAS TERRIBLE NEXT LADY WAS GREAT BUT TOW WAS 2 HOURS AWAY.TOWED TO FORD DEALER CLOSED TILL MONDAY. MONDAY MORNING FORD DEALER SAYS ITS A THROTTLE ACTUATED STUCK HAVE TO REPLACE THROTTLE BODY. THEY DID A GOOD JOB ON THE ROAD COUPLE HOURS LATER. THIS A VERY SERIOUS SAFETY ISSUE.

• 08/01/2017· VISIBILITY/WIPER

  THE REAR WINDOW WASHER HOSE HAS BLOWN APART THREE TIMES. ONCE LAST WINTER SO I COULD NOT REMOVE SLUSH TO SEE OUT REAR WINDOW. TWICE THIS YEAR, AT THE CONNECTION TO REAR HOSE. NEW HOSE INSTALLED AT FORD DEALER MONTH OR SO AGO. SINCE THEN HOSE BLEW APART AT FIRE WALL. I PUSHED CONNECTION BACK INTO FIREWALL. SATERDAY 7-29-17 CAR WAS IN FOR OIL CHANGE I ASKED IF THEY COULD LOOK AT HOSE. THEY COULD NOT,SAID TO SCHEDULE AN APPOINTMENT. 8-1-17 FRONT WINDOW HOSE BLEW APART. I COULD NOT CLEAN BUGS FROM WINDOW. WILL SCHEDULE THIRD REPAIR APPOINTMENT TOMORROW. I WAS DRIVING ON EXPRESSWAY FOR ALL REAR HOSE PROBLEMS. 45 MPH CITY STREET WITH FRONT HOSE PROBLEM.

• 07/28/2017· STEERING

  MY POWER STEERING FAILURE INDICATOR CAME ON (WHILE I WAS DRIVING), INDICATING A NEED FOR IMMEDIATE SERVICE. UPON TESTING, IT WAS DETERMINED THAT THE STEERING GEAR WAS FAULTY...ON A 2015 VEHICLE!! THIS COULD HAVE CAUSED AN ACCIDENT IF THE GEAR FAILED WHILE I WAS DRIVING. I WOULD NOT EXPECT SUCH A FAILURE IN A 2015 VEHICLE. IT LOOKS LIKE PREVIOUS FORD MODELS HAVE BEEN RECALLED DUE TO A SIMILAR ISSUE. I THINK THERE MUST BE A DESIGN OR MANUFACTURING FLAW. GIVEN THAT THIS IS RELATED TO STEERING AND CREATES A HIGH RISK OF INJURY IN THE EVENT OF AN ACCIDENT, I RECOMMEND THAT THIS BE FULLY INVESTIGATED.

• 07/25/2022· STEERING

  The contact owns a 2015 Ford Flex. The contact stated while driving 65 MPH, the steering wheel seized. The vehicle was towed to the residence. The contact related the failure to a faulty steering control module; however, the vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.

• 07/24/2017· ENGINE

  VEHICLE LOST ENGINE POWER WHILE DRIVING ON 4 SEPARATE OCCASIONS, ONCE WHILE AT HIGHWAY SPEEDS. ONLY FAULT INDICATOR SHOWN IS "WRENCH" SYMBOL. UPON SHUTDOWN AND RESTART, ISSUE RESOLVES ITSELF UNTIL IT OCCURS AGAIN. THERE ARE NO SYMPTOMS LEADING UP TO POWER LOSS, AND IT SURPRISES DRIVER SINCE THERE IS NO DRIVELINE POWER, AS WELL AS REDUCED BRAKING AND STEERING CAPABILITY. THIS IS ESPECIALLY DANGEROUS ON THE HIGHWAY AND AT IN TRAFFIC. DEALER HAS STATED THAT SINCE IT CANNOT BE EASILY REPEATED, THAT THEY CANNOT FIX IT.

• 07/18/2023· ELECTRICAL SYSTEM

  Few months back the car stopped working. I took it to repair shop (#1), and they told me I needed to replace the battery. I had them install a new battery, and the car started again. Couple of days later, the car was dead again, so I jumped it. I jumped it about 3 more times, within 2 weeks, so I decided to take it back to the same repair shop, and they told me maybe I got a defective battery, so I exchanged battery for a new one, again. Few days later, the car was dead again, so I took it to another repair shop (#2), and explained the problem. They told they'll run a diagnosis and would let me know They kept it for 4 days, and the end result was; the car started every time they tried it. The car would run for few days, then the same thing wold happen - completely dead! I took it to a different repair shop (#3), and again, they told me they run it everyday, and they could not find anything wrong. All three repair shops said their machine did not come up with any code. All fuses and relays tested OK. It has been over six months, and I am still having the same issue. 2 or 3 days, and the car is completely dead. I don't drive it as much now, because I am afraid the car will die on me at any time, without notice. From what I've read, I think my car has a "parasitic drain" somewhere.

• 07/17/2022· STEERING

  My power steering failed with out warning while turning off of an off ramp. I have had the car repaired it needed and entire steering rack. It only had 60,000 miles on it at the time. I almost wiped out bad. It was all I had to continue to drive it to a safe place.

• 07/15/2021· SUSPENSION

  The contact owns a 2015 Ford Flex. The contact received notification of NHTSA campaign number: 20V072000 (Suspension) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 07/14/2025· STEERING

  The contact owns a 2015 Ford Flex. The contact state that while driving on two occasions at undisclosed speeds, the vehicle lost power steering functionality and the steering wheel became very stiff. The "Power Steering Assist Fault" message was displayed. During the first failure, the contact pulled over to the side of the road and the vehicle was towed to a dealer; however, failure was no duplicated. The contact stated that during the second failure, the vehicle was taken to the residence. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.

• 07/14/2016· FUEL/PROPULSION SYSTEM

  APPARENTLY MY "THROTTLE BODY" ELECTRONICS WENT BAD AND CAUSED MY ENGINE TO STOP WHILE I WAS IN FAST LANE OF FREEWAY...BARELY MADE IT TO THE SHOULDER. NO WARNING UNTIL AFTER CAR WAS OFF. DEALER WAS "AWARE" OF THIS PROBLEM WITH THIS 2015 FORD ENGINE ALTHOUGH FORD HASN'T DONE ANYTHING TO WARN CUSTOMERS OR RECALL TO FIX..IT IS NOTICED HOWEVER IN SAFETY ISSUES WITH ORGS. IT IS INEXCUSABLE THAT THE CARE WILL NOT WARN OF PENDING PROBLEM, AND TURNS OFF ON ITS ON (OR SLOWS DOWN TO CRAWL) AND FORD HAS NOT TAKEN ACTION ON PROBLEM THEY ARE AWARE OF.

• 07/13/2022· STEERING

  The contact owns a 2015 Ford Flex. The contact stated that after restarting the vehicle, the "Steering Assist" and "Advance Track" messages were displayed and the steering wheel was very difficult to turn in either direction. The vehicle was taken to the local dealer who diagnosed that the rack and pinion was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 80,000.

• 07/11/2020· STEERING,ELECTRONIC STABILITY CONTROL (ESC)

  MY CAR FORD FLEX 2015 LIMITED AWD (MADE IN CANADA) AND ITS OUT OF WARRANTY YESTERDAY ONLY WITHOUT ANY WARNING I USED MY CAR AT MORNING NORMALLY AND NO ISSUE I STOPED AT SUPERMARKET THE BACK TO CAR AND START THE ENGINE AND I SEE MESSAGE ALERT " STEERING ASSIST MALFUNCTION SERVICE REQUIRED" AND THE STEERING BECAME VERY HEAVY TOO MUCH POWER NEED TO MOVE IT RIGHT OR TO LEFT ..THEN AFTER THAT ONE WARNING MESSAGE CAME " SERVICE ADVANCETRAC"

• 07/10/2020· SEAT BELTS

  THE LOCKING MECHINISM HAS BROKEN TWICE ON THE REAR PASSANGER SEATBELT.

• 07/08/2018· STEERING,ELECTRICAL SYSTEM

  ON JULY 5, 2018 I WAS DRIVING AT 35 MPH ON A CITY ROAD WHEN A WARNING LIGHT WITH THE WORDS "STEERING ASSIST FAULT, SERVICE REQUIRED" SUDDENLY CAME ON AND THE STEERING STOPPED WORKING ALMOST ENTIRELY. THERE WAS VERY LITTLE MANUAL ABILITY TO STEER THE CAR. FORTUNATELY WE WERE ON A VERY WIDE, EMPTY ROAD, SO I WAS ABLE TO USE BOTH LANES AND GET THE CAR TO MY HOUSE. IF THIS HAD OCCURRED ON A BUSY CITY STREET OR NARROW LANE, WITH ANY KIND OF TRAFFIC, WE COULD HAVE EASILY BEEN IN A SERIOUS, EVEN FATAL COLLISION. I HOPE THAT OTHER FORD OWNERS WILL REPORT THIS PROBLEM IF THEY EXPERIENCE IT, SO THAT A RECALL CAN BE INITIATED IF NEEDED. THIS WAS A DANGEROUS SYSTEM FAILURE THAT SHOULD BE INVESTIGATED.

• 07/06/2021· STEERING

  The contact owns a 2015 Ford Flex. The contact stated while driving 25 mph, the power steering failed not allowing the contact to steer the vehicle. The contact stated that the power steering assist warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed with the power steering assist needing to be replaced. The vehicle was not repaired. The contact was relating the failure to an unknown recall. The manufacturer had been informed of the failure and referred the contact to the NHTSA for assistance. The failure mileage was approximately 96,000.