2015 Ford Expedition

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2022· ELECTRICAL SYSTEM,VISIBILITY

  The contact owns a 2015 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the climate control fan failed to cause the windows to become foggy due to the lack of proper airflow. The manufacturer was not made aware of the failure. The failure mileage was unknown. Parts distribution disconnect.

• 12/27/2023· POWER TRAIN,VEHICLE SPEED CONTROL,LANE DEPARTURE

  The vehicle dashboard goes blank while driving, followed by the vehicle transmission slipping out of gear. This vehicle can be made available; however, it does not transfer gears. The problem has not been satisfactorily reproduced or diagnosed. The Ford service department simply stated that I needed a new transmission. The dashboard goes blank.

• 12/19/2022· ELECTRICAL SYSTEM

  The contact called on behalf of his wife who owns a 2015 Ford Expedition. The contact stated that while his wife was driving at an undisclosed speed, the heat intermittently operated, and his wife started to smell a burning odor throughout the vehicle. The contact also stated that on a separate occasion while driving, he started to smell a burning odor. The contact then stated that he pulled the vehicle off the road to inspect the vehicle. The contact stated that upon inspecting under the dashboard on the front passenger’s side of the vehicle, he noticed that the wires had melted with a gray cloud of smoke. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that the blower motor resistor melted and melted the wires and wiring harness. The wire assembly and module needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 155,000.

• 12/15/2017· VEHICLE SPEED CONTROL

  2015 EXPEDITION WENT INTO ' LIMP MODE' NO THROTTLE RESPONSE WHILE DRIVING ON THE FREEWAY. RUNS AND STARTS FINE POSSIBLE ETB

• 12/13/2022· ELECTRICAL SYSTEM

  When the heater is operated for 15-20 minutes a burning tire or skunk smell issues from the heater. The heater blower is currently of recall concern. No immediate safety issues, but we are concerned and the smell is bad. None of the components have been inspected by anyone. We are waiting on recall notification. No warning lamps or vehicle messages have occurred. The problem was first noticed as the winter weather made outside conditions much cooler and the heater fell into common usage. When heater is turned off the smell goes away.

• 12/08/2024· ENGINE

  Engine lack of power and excessive noise during acceleration.

• 12/05/2023· ELECTRICAL SYSTEM,VISIBILITY,STRUCTURE

  The contact owns a 2015 Ford Expedition. The contact stated that the doors rocker panels were corroded. Additionally, the contact stated that the front blower motor was intermittently inoperable. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The vehicle was taken to the dealer, where the recall repair was performed; however, the failure persisted due to the blower motor resistor connection failure at the wiring harness plug. The dealer was notified of the failure and informed the contact that he would be charged a repair fee because the additional repair was not included in the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 124,000. The VIN was unavailable.

• 12/03/2015· ENGINE

  TL* THE CONTACT OWNS A 2015 FORD EXPEDITION. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. IN ADDITION, THERE WAS A SUDDEN LOSS OF SPEED AND THE SERVICE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS INFORMED THAT NUMBER FIVE ENGINE CYLINDER IGNITION COIL FAILED. THE VEHICLE WAS THEN TAKEN TO THE DEALER FOR THE REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.

• 11/25/2025· UNKNOWN OR OTHER

  When accelerating from a complete stop making a left turn vehicle starting shaking and I could not accelerate. I was not on a safe road to pull out of the roadway. I had to turn the car off and back on again thankfully I was able to safely get the car home but this happened with no warning at all. This could have easily ended in an accident.

• 11/23/2023· ELECTRICAL SYSTEMFire

  Smelled smoke, then a small amount of dark smoke was noted to be coming from A/C vents I pulled over & turned off car The smoke stopped. I exited the car & called my husband. I opened the car hood to inspect. There was nothing suspicious. No source of the smell or smoke was identified. I re-entered the car, turned on the engine, and lots of dark smoke exuded from of A/C Vents & the engine. I turned off the engine, left the car & moved away. I called 911. A passer by went into the Post office, returned with a fire extinguisher & sprayed the engine. This seemed to temporize things for a very short time. while on the phone with 911 the car fire started and rather quickly the car became nearly totally engulfed in flames. Then the Police arrived first, followed by the Fire engine. Essentially, "everything that could burn did" (except the gas tank). Known recall (manufacturer #22S56, NHTSA #22V648

• 11/19/2019· SERVICE BRAKES,ENGINE

  THE DAY AFTER WE BOUGHT THIS VEHICLE USED HAD 78,000 MILES ON IT WE WERE DRIVING ON A 4 LANE ROAD ABOUT 60MPH WHEN THE CHECK ENGINE LIGHT CAME ON AND IT PUT ITSELF INTO NEUTRAL. THE GAS PEDDLE WOULD NOT ENGAGE. AFTER WE TURN IT OFF AND ON A COUPLE TIMES WE WERE ABLE TO DRIVE IT AGAIN. THIS HAS HAPPENED AT LEAST THREE TIMES SINCE WE HAVE OWNED IT. WE BOUGHT IT 4 MONTHS AGO. ON THREE OTHER OCCASIONS THE CHECK ENGINE LIGHT CAME ON WHILE RETURNING HOME FROM A 3 HOUR DRIVE ON A HIGHWAY GOING 60MPH DOWN A HILL AND IT WAS UNDER POWERED BUT STILL DRIVABLE. WE HAD ONE TURBO REPLACED HOWEVER THE LIGHT HAS COME ON AGAIN BUT THE DEALER COULDN'T FIX IT BECAUSE THE CHECK ENGINE LIGHT CLEARED AND THEY CAN'T FIND ANYTHING WRONG WITH IT. LAST WEEK WE WERE DRIVING IN TOWN THANKFULLY UNDER 30MPH AND THE BREAK PEDDLE GOT HARD AND COULDN'T BE PRESSED DOWN. A LIGHT CAME ON THAT SAID BREAK FAILURE WE HAD TO ENGAGE THE EMERGENCY BREAK TO STOP. WE HAD IT TOWED NO LIGHTS WERE ON WHEN IT GOT TO THE DEALERSHIP THEY PUT 30 MILES ON IT TRYING TO RECREATE THE PROBLEM AND COULDN'T GET IT TO DO IT AGAIN. THIS VEHICLE IS VERY UNSAFE IT'S A MATTER OF TIME BEFORE IT EITHER SHUTS DOWN IN THE MIDDLE OF A BUSY HIGHWAY OR THE BREAKS WON'T WORK AND CRASHES INTO SOMETHING OR SOMEONE. WE HAVE A VEHICLE NOW THAT WE CANNOT DRIVE AND CANNOT FIX AND IF WE TRADE IT IN WE WILL BE OUT A LOT OF MONEY AND THIS UNSAFE VEHICLE WILL BE PUT BACK ON THE LOT.

• 11/16/2024· ELECTRICAL SYSTEM

  The backup camera intermittently won't turn on when shifting into reverse and instead says to contact the dealer for service.

• 11/16/2018· ELECTRICAL SYSTEM,ENGINEFire

  TL* THE CONTACT OWNED A 2015 FORD EXPEDITION. AFTER PARKING AND EXITING THE VEHICLE, A FIRE STARTED UNDER THE HOOD NEAR THE ENGINE COMPARTMENT. THE FIRE SPREAD TO THE FRONT WINDSHIELD. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES, BUT HAD NOT DETERMINED WHAT HAD CAUSED THE FIRE. THE POLICE DEPARTMENT TOWED THE VEHICLE TO A YARD AND THEN THE INSURANCE COMPANY TOWED THE VEHICLE TO A FACILITY FOR DIAGNOSTIC TESTING. LANDERS FORD (19501 I-30, BENTON, AR 72015, 1-(501) 315-4700) WAS NOTIFIED AND DID NOT ASSIST. THE CONTACT CALLED THE MANUFACTURER ON NOVEMBER 2, 2018 AND WAS INFORMED THAT THEIR OFFICE OF COUNCIL WOULD RESPOND BACK WITHIN FIFTEEN BUSINESS DAYS TO INVESTIGATE THE CAUSE OF THE FIRE. THE CONTACT WAS WAITING ON THEIR RESPONSE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. *TT*JB

• 11/13/2024· STEERING

  The contact owns a 2015 Ford Expedition. The contact stated there was vibrating coming from the vehicle that had progressively worsened over time. The contact stated that while driving over 50 MPH, the vibration becomes worse. No warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed that the vehicle experienced electrical problems. The dealer replaced the bushings on the vehicle, however, the vehicle continued to experience vibration while driving. The manufacturer was not notified of the failure. The failure milage was 89,000.

• 11/12/2024· ENGINE

  Driving 45mph the stuttered quickly and the wrench symbol appeared on the dashboard. I had to put the car in Neutral and tranisted to the shoulder of the road, stopped and turned the vehicle off. This is not the first time this has happened. It happened to my wife and my daughter at separate times also.

• 11/12/2024· POWER TRAIN

  I was driving and going around 45mph when the wrench warning light came on and I lost the ability to accelerate. The car could only coast. I was able to coast to a parking lot. I turned off the car and restarted it. It seemed fine so I drove home. The same thing happened again a couple of days later. We checked the codes and it had a p2112 error code. We replaced the throttle body and it seems fine now. However this is the second time we have had to replace the throttle body. The same thing happened in 2018 with about 74000 miles on the car. We replaced the throttle body then also. From internet searches this seems to be a common problem. It is a big safety issue since the car loses the ability to accelerate unexpectedly. I was lucky I was able to coast out of the way each time without causing an accident.

• 11/07/2020· ENGINE

  2015 EXPEDITION 3.5 ECOBOOST STALLS OUT WHILE DRIVING DUE TO DEFECTIVE THROTTLE BODY (CODE P2112). THIS SHOULD BE A SAFETY RECALL.

• 11/06/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention). The contact stated that while in reverse(R), the camera displayed a black screen with a message "Camera Unavailable - Contact Dealer", and the vehicle hit an elderly woman's shopping cart. There were no injuries. The vehicle was taken to a dealer, and the contact was informed that the parts were not yet available. The contact stated that while in reverse(R), the camera displayed a black screen with the message "Camera Unavailable - Contact Dealer", and the vehicle almost struck a toddler walking with his parents behind the vehicle. The vehicle was taken to the same dealer however, parts were still not available. The manufacturer was notified of the failure. The failure mileage was 115,000.

• 11/06/2023· ELECTRICAL SYSTEM,VISIBILITY

  Blower motor assembly system problems. Have had multiple times replaced/fixed. Issue is ongoing and per dealer is no longer covered my recall. Blower motor does not work. Burnt control box. And per dealer not covered by previous recall

• 11/04/2025· ELECTRICAL SYSTEM,BACK OVER PREVENTION

  The contact owns a 2015 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION). However, the part to do the recall repair was not yet available. The contact stated that the rearview camera failed to activate while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle, especially during hot weather. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that on a separate occasion, the contact stated that while the vehicle was stopped at a traffic light or stop sign, the running boards moved independently. Occasionally, while exiting the vehicle, the running boards opened halfway. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 124,000.

• 11/04/2024· ENGINE

  During cold starts the engine has a loud rattling sound. The sound goes away after about a minute.

• 10/31/2023· ELECTRICAL SYSTEM

  The contact owns a 2015 Ford Expedition. The contact stated that while the vehicle was started, the A/C system was inoperable. The contact stated that he observed wires hanging down that were melted. The vehicle was taken to a dealer where it was diagnosed that the blower motor speed control connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 138,000.

• 10/28/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Expedition. The contact stated that the rearview camera image was distorted while reversing. The contact received notification of NHTSA Campaign Number: 25V270000 (Back Over Prevention). The local dealer was contacted, and an appointment was scheduled for the recall repair; however, the dealer later informed the contact that the part was not yet available to do the recall repair. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 100,000.

• 10/25/2025· ELECTRICAL SYSTEM

  Purchased 12/2023 2015 Ford Expedition April of 2024 we began to have issues with the Sync System and Climate Control. We took it back to the original dealer and a second Ford dealer and neither was able to diagnose the issue. As they could not get it to duplicate while there. However it has happened numerous times since. The symptoms seem to have no rhyme or reason as to when they will happen, but they do follow the same pattern each time. The Sync screen will turn itself off completely and randomly. Screen goes Black System shuts down as if the power button was pushed. When you do push the power button to turn the system back on the temperature display in the left hand corner will no longer be displayed. This is the indication the system is still not working properly. The Air Conditioner will then turn itself off. Then the blower will switch to defrost and high heat, all in its own. You cannot adjust the setting or turn the heat off. It continues to blow on high heat in defrost mode until it decides to switch back to AC. This could last 2 seconds could be 20 minutes It will also read the gas gauge wrong, registering 20 miles left of gas even if you just filled up. This has all happened in the summer months causing extreme heat in the vehicle even with all the windows down. We replaced the Blower motor resistor and its wiring harness. Checked the blower at the same time, it is running smoothly. We also replaced the relay #3 responsible for climate control. We attempted the replace the intake manifold temperature sensor, but have been sent the wrong sensor twice, and it does not fit correctly. Now we have a fan running so loudly it sounds like out engine is idling high when it is not. We also now have no heat at all in the vehicle. When I checked the recalls the dates for the 2023 (22S56) are within the recall years but our vin says it's not. Manufactured 9/2014 Recall is for 1/2014-6/2017 No heat in the winter and extreme uncontrollable heat in the summer

• 10/21/2025· UNKNOWN OR OTHER

  Rear back window blew out spontaneously. If my kids had been in the car it could have injured them with flying glass. No warnings prior. It had not been inspected prior because there had not been an issue before this. This is the second time it has happened in the same vehicle. First time was June 2023 and happened again 10/20/2025.

• 10/21/2022· ELECTRICAL SYSTEM,VISIBILITY

  The contact owns a 2015 Ford Expedition. The contact stated the front vents were not blowing air, but the rear vents were operable. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 109,000. Parts distribution disconnect.

• 10/21/2015· UNKNOWN OR OTHER

  I WAS SITTING IN A WAL-MART PARKING LOT WITHOUT THE CAR RUNNING. THE TEMPERATURE WAS APPROX 35-40 DEGREES WITH LIGHT RAIN/SNOW. WHILE SITTING THERE I HEARD A REALLY LOUD POP. AFTER LOOKING OUTSIDE AND AROUND THE VEHICLE TO SEE WHAT WAS OVERHEAD (NOTHING), I NOTICED THAT THE MOONROOF HAD SHATTER AND MADE THE BACK PART OF THE GLASS BUBBLE UPWARD TOWARD THE SKY WITH A SMALL HOLE AND THE ENTIRE GLASS SHATTERED. OF COURSE I HAD TO DRIVE THE VEHICLE HOME (APPROX 22 MILES) AND THEN TO THE DEALER (ANOTHER 25 MILES). AT THIS POINT MOST OF THE GLASS FELL INTO THE MOONROOF SLIDE COVER AND THUS DID NOT SHOW THE BUBBLE IN THE GLASS. FORD WILL NOT COVER STATING IT WAS BROKE BY FORCE. WE HAVE OWNED THE CAR LESS THAN TWO MONTHS (PURCHASED ON 8/22/15 - DAY BROKE 10/18/15) AND THE VEHICLE HAS ONLY 3,700 MILES ON IT. ALL PICTURES TAKEN WERE DONE BY THE DEALER.

• 10/18/2024· ELECTRICAL SYSTEM,VISIBILITY

  The contact owns a 2015 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact stated while driving 65 MPH, with the A/C activated, the vents stopped blowing air. The contact unplugged the pig tail off the resistor under the passenger’s side dashboard. The contact stated that the pig tail was red hot and burned. The vehicle was taken to a dealer where it was diagnosed that the motor blower needed to be replaced; however, the failure persisted. The failure mileage was 244,000.

• 10/18/2023· AIR BAGSCrash

  The contact owns a 2015 Ford Expedition. The contact stated that while driving at approximately 60 - 65 MPH, another vehicle struck the contact's front driver's side, causing the contact's vehicle to spin. The vehicle then crashed into the side embankment wall. The air bags did not deploy. The impact caused the contact's chest to hit the steering wheel. The contact suffered a fractured sternum as well as neck and shoulder injuries. The contact's passenger suffered bruising on her neck, shoulder, and chest. The contact and her passenger were transported by ambulance to the hospital. A police report was filed. The vehicle was towed to the tow yard but was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was 56,300.

• 10/10/2025· BACK OVER PREVENTION

  The contact owns a 2015 Ford Expedition. The contact stated that while reversing, the back-over prevention camera screen displayed a black screen. The contact stated that because of the failure, the bumper on the rear passenger's side and the passenger's side mirror were damaged. The vehicle was taken to an independent mechanic; however, the vehicle was not inspected. The contact was advised to take the vehicle to the dealer for assistance. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, parts for the recall repair were not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 152,000.

• 10/07/2021· VEHICLE SPEED CONTROL

  65mph, without warning,motor dies. Motor idles, shut off and restarted, back on interstate approximately 100 yards and motor dies again. Google closest Ford garage, 2 more times died and now showed check engine light. Ford showed defective throttle body and replaced

• 10/04/2016· SERVICE BRAKES

  STARTED TO NOTICE VIOLENT SHAKING IN THE FRONT OF THE VEHICLE WHEN THE BRAKES ARE APPLIED AT INTERSTATE SPEEDS. THE 2015 EXPEDITION 4WD HAS 19,000 MILES ON THE ODOMETER. AT VERY LOW SPEEDS THERE IS THE SAME SHAKING OF THE FRONT BRAKES---BUT MUCH LESS NOTICEABLE APPARENTLY DUE TO THE LOW SPEED. TRYING TO SCHEDULE WARRANTY INSPECTION AT LOCAL FORD DEALER.

• 10/02/2017· ENGINE

  ENGINE GOES INTO LIMP MODE NO PROBLEM RESPONSE NO POWER CANNOT MOVE OUT OF ITS WAY VERY DANGEROUS HAPPENED TO ME WAS PULLING OUT INTO MIDDLE OF AN INTERSECTION VEHICLE JUST COASTED. WRENCH LIGHT CAME ON HAD TO COAST OUT OF THE WAY SHUT VEHICLE OFF RESTARTED IT WAS FINE THIS IS HAPPENED TO ME FOUR TIMES TOOK THE DEALER NOT WARRANTABLE

• 09/29/2016· AIR BAGS,STRUCTURE,UNKNOWN OR OTHERCrash

  I WAS INVOLVED IN A MAJOR FRONT END COLLISION YESTERDAY THAT IS MOST LIKELY RESULTING IN TOTALING MY BRAND NEW CAR. MY ENTIRE FRONT END IS DEMOLISHED AND FRAME WAS DEFINITELY EFFECTED AS CAR DOORS COULDN'T EVEN BE OPENED. WITH ALL THAT SAID MY AIR BAGS DIDN'T DEPLOY, THE SAFETY FEATURE THAT IS SUPPOSED TO PROTECT MY FAMILY AND I GOD FORBID WE GET IN AN ACCIDENT WHICH WE DID AND I WANT TO KNOW WHY! I CONTACTED FORD LAST NIGHT AND THEY REFERRED MY TO MY DEALERSHIP AND WHEN I CALLED MY DEALERSHIP THEY TOLD ME THEY DON'T MAKE THE CARS! I JUST WANT ANSWERS.

• 09/28/2017· FUEL/PROPULSION SYSTEM

  MY WIFE WAS DRIVING OUR KIDS HOME ON THE INTERSTATE WHEN THE CAR WENT INTO LIMP MODE. SHE WAS SCARED AND DIDN'T KNOW WHAT TO DO. WE BROUGHT IT TO THE FORD STORE AND THEY REPLACED THE THROTTLE BODY.

• 09/25/2020· FUEL/PROPULSION SYSTEM

  CAR IN MOTION, HESITATES AND SOMETIME GOES TO LOW POWER MODE WHERE YOU HAVE TO PULL OVER, TURN CAR OFF WAIT AND RESTART TO BE ABLE TO CONTINUE THIS HAS HAPPENED 3 TIMES IN 2 YEARS, DEALERSHIP DECODES AND REPLACE THE THROTTLE BODY, CHARGING EACH TIME TO FIX THE ISSUE

• 09/22/2025· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  My 2015 Ford Expedition needs to added to the recall 22S56. I just paid $1,200 to have that part fixed cause it burnt up. Replaced the front blower motor assembly. My husband burnt his hand on the wire exposed under the dash then the mechanic said the blower motor has burnt up the components around it. The fan, motor, control, and wire assembly all was burnt up. Ford needs to be made to include my vehicle in their recall as that vehicle year, model, plant made in and date made all match.

• 09/21/2015· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  01 JUNE 2015 DRIVING ON INTERSTATE 10 FROM BEAUMONT TEXAS I ENTERED A HEAVY RAIN STORM, TRAFFIC SLOWED DOWN TO ABOUT 50 M.P.H. IN A 70 M.P.H. SPEED ZONE. I PASSED A TRACTOR TRAILER, WHEN THE MIST FROM THE TRUCK AND THE RAIN HIT MY VEHICLE, MY ENGINE LOST POWER. I REMOVED MY FOOT FROM THE GAS, AFTER A FEW HUNDRED YARDS THE POWER CAME BACK BUT MY ENGINE LIGHT WAS ON. THE PROBLEM HAPPENED 4 OR 5 TIMES THRU LOUISIANA AND INTO FLORIDA.I TOOK THE VEHICLE BACK TO THE DEALER PALM BAY FORD WITH 3,000 MILE SINCE NEW THEY COULDN'T DUPLICATE THE PROBLEM SO I WAS TOLD THERE WASN'T A PROBLEM. 17 SEPT. 2015 WITH 12826 MILES I RETURNED TO PALM BAY FORD AGAIN, AFTER RETURNING FROM WEST VIRGINA IN ANOTHER HEAVY RAIN STORM THE SAME THING HAPPENED, THE ENGINE LOST POWER I WAS TOLD THE SAME THING THEY COULDN'T FIND A PROBLEM SO NO PROBLEM EXIST. THIS IS A SAFETY CONCERN AND NEEDS TO BE ADDRESSED.

• 09/20/2017· POWER TRAIN

  DEFECTIVE ELECTRONIC THROTTLE BODY CONTROL SYSTEMS THAT CAUSE THE VEHICLES TO SUDDENLY AND DANGEROUSLY LOSE POWER. WHILE TRAVELING 70MPH ON HIGHWAY, MY VEHICLE SUDDENLY LOST POWER, (ORANGE WRENCH LIGHT APPEARED ON DASH).

• 09/20/2017· FUEL/PROPULSION SYSTEM

  AT ABOUT 56000 MILES, WHILE DRIVING DOWN THE ROAD AT ABOUT 55 MPH, THE WRENCH LIGHT CAME ON AND THE TRUCK WENT INTO, WHAT I NOW KNOW AS, CRAWL HOME MODE. I HAD TO DRIFT TO THE SIDE OF THE ROAD AND RESTART THE TRUCK. ABOUT A WEEK LATER THE SAME THING HAPPENED. TO IT TO THE DEALERSHIP WHERE IS WAS PURCHASED AND WAS TOLD THAT IT IS A FAULTY THROTTLE BODY. I WAS TOLD THAT IT IS NOT COVERED UNDER ANY WARRANTY AND WOULD BE CLOSE TO $500.00 TO REPAIR. AFTER DOING SOME SEARCHES ONLINE I FOUND THAT THIS HAS HAPPENED WITH THOUSANDS OF LATE MODEL FORDS, SOME OF WHICH FORD AGREED TO REPAIR AND OFFER A LONGER WARRANTY.

• 09/15/2017· VEHICLE SPEED CONTROL,ENGINE

  TL* THE CONTACT OWNS A 2015 FORD EXPEDITION. WHILE DRIVING UNKNOWN SPEEDS, THERE WERE ABNORMAL FUMES INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO LOVELAND FORD (999 E. EISENHOWER BLVD, LOVELAND, CO 80537) WHERE IT WAS DIAGNOSED THAT THE UNDERCOATING AND MUFFLER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 18,000.

• 09/12/2022· ELECTRICAL SYSTEM,VISIBILITY

  The contact owns a 2015 Ford Expedition. The contact stated while driving at approximately 30 MPH, the blower motor failed, causing the defroster to become inoperable. The contact stated no warning light was illuminated. The contact stated that the blower motor failed due to the wiring harness and resister overheating. The contact stated that the fuse did not blow which allowed the harness to melt, causing arcing and increased the potential of a fire. The contact stated that the blower motor was drawing too many AMPs causing the failure. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the blower motor needed to be replaced as stated in NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The vehicle had not been repaired. The contact stated that replacing the blower would not remedy the problem. The manufacturer had been informed of the failure. The failure mileage was approximately 145,000.

• 09/12/2018· FUEL/PROPULSION SYSTEM

  WHEN DRIVING ON HIGHWAY THE ENGINE GOES INTO LIMP MODE 3MPH MAX. DISPLAYS WRENCH SYMBOL ON INSTRUMENTATION PANEL.. NO POSSIBLE ACCELERATION POSSIBLE.. VERY DANGEROUS IF YOU WERE ENTERING AN INTERSECTION ON HIGHWAY. I COULD SEE POSSIBLE FATALITIES. IF YOU SHUT OFF ENGINE AND RESTART WILL RUN AS NORMAL FOR ABOUT A MILE THAN SAME SCENARIO. RAN CODE SHOWED "P2112" FAULTY THROTTLE BODY. IF YOU WERE CROSSING A HIGHWAY I COULD SEE GETTING T-BONED . PLEASE EDUCATE OWNERS TO SAVE LIVES.9.12.18

• 09/08/2016· VEHICLE SPEED CONTROL

  THE THROTTLE BODY HAD A COMPLETE FAILURE AT AN INTERSECTION, RESULTING IN THE INABILITY TO MOVE FORWARD. THE VEHICLE WENT INTO SHUTDOWN MODE AND EVENTUALLY LOCKED THE TRANSMISSION INTO PARK. A FAILURE LIKE THIS AT SPEED, OR OTHERWISE, PRESENTS THE POSSIBILITY FOR VEHICLE CRASHES AND INJURIES.

• 09/05/2024· POWER TRAIN

  Vehicle was placed in park and rolled down a driveway. Vehicle almost crashed through a house across the street if the owner did not jump in the vehicle and slam the brake. Problem has not yet been reproduced by a dealer. The part has not yet been evaluated by the dealer. Although, the dealer has done improper inspections of broken parts on the vehicle when it was under warranty in an attempt to get out of replacing them, so I do not trust the dealer to do a proper assessment.

• 09/05/2018· FUEL/PROPULSION SYSTEM

  55,000 MILES. ORANGE WRENCH WARNING LIGHT CAME ON DRIVING THROUGH TOWN ABOUT 25 MPH. LOST POWER AND COASTED ACROSS THE RAIL ROAD TRACKS IN TOWN. VEHICLE WAS STILL RUNNING, HOWEVER HAD NO POWER AND MINIMAL IDLE SPEED. I GOT PULLED OFF TO THE SIDE OF THE ROAD. DIAGNOSTIC SAID TO CHECK MANUAL. I TRIED TO DO THAT AND THE VEHICLE WASN'T IDLING THE BEST, SO I SHUT IT OFF. I WAS AT A BUSY INTERSECTION AND WAS ON MY WAY TO PICK UP MY DAUGHTER FROM HER FIRST DAY AT DAYCARE, SO IN A LITTLE DISARRAY. I TURNED THE VEHICLE BACK ON AND REGAINED FULL FUNCTIONALITY. THE NEXT DAY IT REPLICATED THE ERROR TWICE IN ABOUT A 4 MILE STRETCH. I GOT IT SHUT OFF AND RESTARTED THEN DIRECTLY OVER TO THE DEALERSHIP. THEY HAVE HAD IT FOR 8 DAYS AND CAN'T REPLICATE THE ERROR.

• 09/04/2017· VEHICLE SPEED CONTROL,ENGINE

  DRIVING ON A CITY STREET ABOUT TO GET ONTO A HIGHWAY CAR STARTED TO STUMBLE THEN DIED OUT. WE GOT IT STARTED BACK UP BUT NO THROTTLE. HAD IT TOWED BACK HOME. I HOOKED UP AN OBD2 CODE READER AND THE CODES WERE P2112 AND P2111 ELECTRONIC THROTTLE BODY. I FOUND SOME INFO ONLINE LIKE A RECALIBRATION TEST ( KEY ON, PRESS PEDAL DOWN SLOWLY THEN RELEASE SLOWLY, THEN TURN KEY OFF). STARTED BACK UP LIKE THERE WAS NO PROBLEM. THIS CAR HAS 38,000 MILES THIS SEAMS LIKE A SAFETY ISSUE, IF WE WERE TO TURN IN FRONT OF SOMEONE AND IT DIED OUT WE COULD OF GOT HIT!!! I WILL BE TAKING IT IN TO THE DEALERSHIP TO BE FIXED, CAR IS STILL UNDER WARRANTY

• 09/03/2025· ELECTRICAL SYSTEM,BACK OVER PREVENTION

  Rear backup camera works periodically, there is a recall on the 2015 Expedition for this problem, but I’m being told my vehicle (VIN) is not included. The repair cost is over $1000. Why ins’t my Expedition included in the recall - I’m having the exact problem as documented in the recall. How many others are being affected by this problem but being excluded in the recall. Please investigate, this problem seems to be larger then the current recall.

• 09/02/2025· UNKNOWN OR OTHER,LANE DEPARTURE,BACK OVER PREVENTION

  Back-up Camera, the BACK OVER PREVENTION: SENSING SYSTEM: CAMERA only works intermittently. I'm being told me vehicle is not part of the current recall in the 2015 Expedition that was issued in April 2025, yet my vehicle (a 2015 Expedition) is experiencing the problems detailed in the recall. Why isn't my vehicle part of this recall, shouldn't the recall be expanded to all 2015 Expeditions experiencing problems with faulty back-up cameras?

• 08/31/2018· POWER TRAIN

  WHILE TRAVELING IN THE PASSING (3RD) LEFT LANE ON INTERSTATE HIGHWAY WITH SPEEDS OF 65 TO 70 MPH, THE VEHICAL TOTALLY LOSS POWER, MOTOR STILL RUNNING BUT JUST AT AN UNEVEN POOR IDLE, STILL IN GEAR, I ATTEMPTED TO ACCELERATE, IT DID ABSOLUTELY NOTHING YET THE MOTOR WAS STILL AT THE POOR IDLE. ON THE DASH COMUPTER A WRENCH APPEARED WITH "SEE MANUAL" ALONG WITH A SMALL CHECK ENGINE LIGHT ABOVE THAT. I WAS FORCED TO GET OUT OF THAT DANGEROUS SITUATION WITH NO POWER, COASTING THROUGH 3 LANES WITH MY WIFE WAVING OUT THE PASSENGER WINDOW TO LET MY POWERLESS CAR DRIFT OVER. ONCE OFF THE HIGHWAY, THE MOTOR WAS STILL POORLY IDLING, GIVING IT GAS DID NOTHING, STILL JUST A ROUGH IDLE. I SHUT THE CAR OFF AND RESTARTED IT AND MIRACULOUSLY I ONCE AGAIN HAD CONTROL OF THE ACCELERATOR. I WAS STILL 3 HOURS FROM HOME WITH ALL HIGHWAY DRIVING AHEAD OF ME, WHICH I DID DOING 55MPH IN THE SLOW LANE & READY TO TURN OFF ROAD. I BOUGHT A NEW VEHICLE AS TO NOT HAVE PROBLEMS, LET ALONE THE MOST DANGEROUS EPISODE OF OUR LIVES. WHAT REALLY IS UNACCEPTABLE IS THAT I JUST HAD A 70K MILE CHECKUP AT A LOCAL FORD DEALER WHERE I WAS TOLD THEY RECCOMEND CHANGING MY TRANSFER CASE OIL ALONG WITH AN OIL CHANGE & TIRE ROTATION. I WAS GIVEN A CLEAN BILL OF HEALTH FOR A ROAD TRIP. I REFUSE TO PAY ANYTHING FOR A FLAW IN THEIR DESIGN, ESPECIALLY BEING A DANGEROUS SAFETY ISSUE.