2014 Hyundai Veloster

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/13/2021· ENGINE AND ENGINE COOLING

  The contact's son owns a 2014 Hyundai Veloster. The contact's son received notification of Manufacturer Service Campaign: 966 (Engine Monitoring Logic). The contact stated that while his son was driving at an undisclosed speed, the vehicle made abnormal sounds and hesitated to accelerate. The vehicle was taken to the dealer. The dealer performed the Engine Monitoring Logic software update and diagnosed that the catalytic converter needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 128,000.

• 12/11/2019· ELECTRICAL SYSTEM,VISIBILITY/WIPER

  THE AC/HEATER BLOWER MOTOR CONTROLLER IN THIS VEHICLE AND EVERY MODEL THAT SHARES THE SAME STYLE KNOB HAS A SERIOUS DEFECT. ALONG WITH THE FIRE HAZARD THIS PRESENTS IT ALSO EFFECTS THE USE OF DEFROST WHICH CAN BE A SERIOUS ISSUE IN SOME CLIMATES AND THE SWITCH MAY FAIL COMPLETELY RENDERING THE DEFROST FUNCTIONALLY UNUSABLE. ATTACHED YOU WILL SEE IMAGES OF THE INSIDE AND OUTSIDE OF THE SWITCH IN QUESTION AS WELL AS THE CONNECTOR FOR THE SWITCH WHICH HAVE SUFFERED SERIOUS HEAT DAMAGE. THIS IS A FIRE HAZARD. HYUNDAI CHOSE TO USE THE SWITCH ITSELF AS THE CURRENT PASSING CONDUCTOR INSTEAD OF A RELAY AS USED BY MOST MANUFACTURERS. THIS DECISION IS CLEARLY REFLECTED AS A NEGLIGENT ONE WITH REGARDS TO THE STRUCTURE OF THE SWITCH AND INCORRECT GAUGE OF THE WIRING USED FOR SAID SWITCH. WITH NORMAL USE IN ANY POSITION ON THE DIAL, THIS ISSUE WILL CAUSE THE WIRING OF THE CONNECTOR, AND THE INSIDES OF THE SWITCH TO OVERHEAT. THIS IS NOT A MATTER OF FUNCTIONALITY, THIS IS A MATTER OF SAFETY. WITH THESE LOW GAUGE WIRES BEING USED FOR THIS IT POSES A SERIOUS RISK OF FIRE. PLEASE SEE THE ATTACHED PHOTOS FOR EVIDENCE OF THE SWITCH AND CONNECTOR DEFORMATION CAUSED BY OVERHEATING. PLEASE BARE IN MIND THAT THE SWITCH COMPONENTS AND CONNECTOR APPEAR TO BE MADE OF PA6, A GLASS FIBER REINFORCED NYLON WHICH IS INTENDED TO STAND UP TO A GREAT DEAL OF HEAT. ADDITIONALLY THE WIRE WRAP (PICTURED BELOW) MEANT TO PROTECT THE WIRING ON THIS CONNECTOR FROM RATTLING IS MADE OF A CLOTH/COMPOSITE MATERIAL, WITH THE ABILITY TO MELT AND CATCH FIRE. THIS ISSUE IS A CONSTANT BEING DOWN TO THE WIRING. IN MOTION, STATIONARY, OR OTHERWISE HAS NO BEARING SO LONG AS THE CLIMATE CONTROLS ARE BEING USED. THANK YOU FOR YOUR TIME.

• 12/10/2025· ENGINE

  The second cylinder is not firing. The car stalled when on highway.

• 11/30/2020· STEERING

  TL* THE CONTACT OWNS A 2014 HYUNDAI VELOSTER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL CLUNKING SOUND COMING FROM THE STEERING WHEEL. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE SHE WAS INFORMED THAT THERE WAS A FRACTURED COUPLING WITHIN THE STEERING COLUMN THAT NEEDED TO BE REPLACED. THE CONTACT THEN SPOKE WITH CLAY COOLEY HYUNDAI OF MESQUITE (16230 LYNDON B JOHNSON FWY, MESQUITE, TX 75150) WHERE SHE WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT REACHED OUT TO THE MANUFACTURER VIA EMAIL HOWEVER, THERE WAS NO RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

• 11/27/2018· ELECTRICAL SYSTEM

  THE ACA CONTROLLER KNOB GETS EXTREMELY HOT , THE INSIDE HAS MELTED AND NO LONGER WORKS SO THE AC AND OR HEAT DOES NOT BLOW OUT OF THE VENTS,

• 11/18/2020· STEERING

  CLUNK AND LAG IN THE STEERING CAUSED BY WORN RUBBER COUPLER MDPS - AFTER 48000 MILES - APPEARS TO BE A KNOWN ISSUE WITH NO RECALL/WARRANTY

• 11/13/2023· SERVICE BRAKES, HYDRAULIC

  The contact owns a 2014 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/04/2025· ENGINE

  While driving at approximately 70MPH on the highway, my 2014 Hyundai Tucson Limited suddenly locked up with no warning lights, no noise and no prior symptoms. The engine completely seized, causing immediate loss of power. I was barely able to coast off the highway exit to a final stop on the feeder shoulder, in a desolate area. The vehicle has always been properly maintained and is in excellent condition. Upon research, I learned that Hyundai has known of internal engine defects caused by metallic debris left from manufacturing since 2010, which can cause bearing failure and engine seizure. My Tucson's failure matches the same pattern described in Hyundai's Theta II engine recall and warranty extension campaigns. This sudden failure created an extremely dangerous situation at highway speed and possibility of injury while being stranded on an open road. Many owners, myself included, were never properly notified of the risks. I am filing this report because this incident represents a serious safety defect and potential recurrence among similar vehicles that may not yet be covered by recall. I respectfully request that the National Highway Traffic Safety Administration investigate this issue and ensure Hyundai expands its recall and warranty coverage to include affected 2014 Hyundai Tucson Limited vehicles exhibiting this defect that was well-known to the Hyundai Corporation. Date of Incident: October 23,2025 in Houston Texas. Vehicle towed to Hyundai dealer which diagnosed Engine Seized and currently awaiting Warranty Extension Approval (TXXC/TXXI)

• 11/01/2020· ENGINE

  VEHICLE STOPPED DRIVING UNDER ITS OWN POWER AFTER DRIVING FOR SEVERAL MILES ON A COUPLE OCCASIONS. USUALLY AFTER DRIVING AT ABOUT 60MPH FOR 30 MILES OR MORE. IT EITHER BOGS DOWN GIVING TIME TO PULL OF THE ROAD OR STOPS COMPLETELY AFTER TRYING TO ACCELERATE AFTER A COMPLETE STOP. VEHICLE IS GIVING A P420 ERROR CODE BUT EXHAUST TECHNICIANS SAY IT IS NOT THE CATALYTIC CONVERTER. VEHICLE WILL DRIVE AFTER EXHAUST SYSTEM HAS BEEN GIVEN TIME TO COOL. COMPRESSION IS BEIN LOST IN ONE CYLINDER AS DETERMINED BY HYUNDAI DEALERSHIP. DEALERSHIP CLAIMS A NEW ENGINE AND CONVERTER IS REQUIRED. RESULTS APPEAR TO BE THE SAME CONDITIONS AS LISTED IN SC176 FOR THE KIA SOUL 1.6L GDI ENGINE. HIGH EXHAUST GAS TEMPERATURES MAY DAMAGE THE CATALYTIC CONVERTER, POSSIBLY RESULTING IN ABNORMAL ENGINE COMBUSTION AND DAMAGE TO ONE OR MORE OF THE ENGINE'S PISTONS AND POSSIBLE PISTON CONNECTING ROD FAILURE.

• 10/26/2020· ENGINE

  WE WERE DRIVING ON THE NEW JERSEY TURNPIKE DOING ABOUT 60 OR 65 MPH AND ALL OF THE SUDDEN THE CAR STARTED MISFIRING CAR JERSEY AND STARTED VIBRATING INWAS CLOSE TO EXIT 12 SO I GOT OF EXIT 12 AND FOUND A PARKING LOT WHERE THERE WAS A PEP BOYZ AND TOWED THE CAR TO MY SISTER IN LAWS HOUSE. TOOK IT TO THE SHOP AND THEY SAID THAT THE CAR DOES NOT HAVE COMPRESSION IN CYLINDER 2 THE CAR NEVER SHOWED ANY SYMPTOMS OF ANY SORT CAR ALWAYS RAN FINE OIL CHANGED ON TIME ALWAYS CARED FOR.

• 10/20/2022· ELECTRICAL SYSTEM

  The contact owns a 2014 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and hesitated to accelerate. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that the wiring harness connector needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 106,000.

• 10/20/2020· UNKNOWN OR OTHER

  PASSENGER REAR DOOR FAILS TO OPEN (FROM THE INSIDE OR OUTSIDE) RESULTING FROM DEFECTIVE DOOR ACTUATOR MECHANISM. THIS PROBLEM IS AN OBVIOUS SAFETY CONCERN AS PASSENGERS CANNOT EXIT THE VEHICLE IN CASE OF AN EMERGENCY.

• 10/15/2014· STEERING,ELECTRICAL SYSTEM,ENGINE

  I PURCHASED MY 2014 VELOSTER TURBO RIGHT OFF OF THE SHOWROOM FLOOR. WHEN I WAS DRIVING HOME , 90 MILES FROM THE DEALERSHIP, I NOTICED IT WAS REALLY HARD TO KEEP MY CAR STRAIGHT IN THE ROAD. I PHYSICALLY HAVE TO FORCE MY CAR TO STAY STRAIGHT ON THE STRAIGHTEST HIGHWAYS. I TOOK IT TO THE DEALERSHIP THE NEXT DAY AND IT WAS FOUND TO BE OUT OF ALIGNMENT . THEY ALIGNED IT, ONLY TO EXPERIENCE THE SAME ISSUE DRIVING BACK HOME. I HAVE NOW HAD MY VEHICLE IN TO 3 DIFFERENT HYUNDAI DEALERSHIPS AND HAVE RECORDS OF THE ADJUSTMENTS. IT IS STILL NOT ALIGNED MAKING IT VERY DIFFICULT TO DRIVE SAFELY . AT 5K MILES WE WERE DRIVING ON A ROAD TRIP AND HAD BEEN DRIVING ALL DAY. WE WERE GETTING BACK ON THE INTERSTATE AND MY CHECK ENGINE LIGHT STARTED FLASHING AND MY CAR STARTED SLOWING DOWN EVEN THOUGH I WAS TRYING TO ACCELERATE . IT CLEARED UP AND I DROVE A FEW MORE MILES WHEN IT ACTED UP AGAIN, THIS AT 65 MPH. SAME ISSUES FLASHING LIGHTS, SLOWING FROM 65 TO 30 AS MY CAR FELT IT WAS NOT GETTING ANY POWER. I WAS ABLE TO REPORT IT TO MY BLUELINK, ALTHOUGH IT DID NOT SHOW ON THEIR END. THIS HAS BEEN CHECKED SEVERAL TIMES BY HYUNDAI , ALTHOUGH THEY ARE NOT ABLE TO DETECT OR DUPLICATE THE ISSUE. IT CONTINUES TO HAPPEN TO ME. I AM TO THE POINT WHERE I AM FRIGHTENED TO DRIVE IT ANYMORE. NOT ONLY FOR MY SAFETY BUT FOR OTHERS AS WELL. I HAVE A TOTAL OF 7 SERVICE RECORDS WITH NO ANSWERS EXCEPT , IF IT HAPPENS AGAIN COME RIGHT IN AND HOPEFULLY THE COMPUTER WILL TELL US. THE ALIGNMENT WAS DONE 5 TIMES AND TOOK IN 6, ALTHOUGH IT IS STILL ALL OVER THE ROAD. THE ANSWER I GET FOR THE ALIGNMENT NOW IS, " CUSTOMER MAY ALSO NOT BE USED TO ELECTRONIC STEERING SYSTEM". I AM A 43 YEAR OLD MAN THAT HAS BEEN DRIVING FOR ALMOST 30 YEARS. I HAVE ANOTHER VEHICLE WITH ELECTRONIC STEERING THAT DRIVES STRAIGHT ON THE SAME ROADS. THANKS FOR YOUR TIME... *TR

• 10/08/2019· STEERING

  OUT OF THE BLUE MY STEERING WHEEL SEEM TO BECOME LOOSE AND STARTING MAKING A CLICK SOUND WHEN TURNED TURNED TO THE RIGHT OR LEFT. ALTHOUGH OTHER HYUNDAI VEHICLES HAVE RECALLS FOR THE SAME PROBLEM, MY VELOSTER IS NOT. IT IS A KNOWN PROBLEM FOR THIS CAR MAKER AND THEY WILL NOT COVER THE HUGE BILL TO REPAIR IT UNLESS YOU ARE STILL UNDER A WARRANTY. IT IS NOT SAFE!

• 10/05/2019· STEERING

  MY STEERING WHEEL WAS DRAMATICALLY CLUNKING WHENEVER I TURNED IT. AFTER TAKING IT TO A MECHANIC, HE INFORMED ME THAT IT WAS THE STEERING COUPLER ISSUE, WHICH IS APPARENTLY A PROBLEM ON MULTIPLE VEHICLES WHICH ARE BEING COVERED UNDER AN EXTENDED WARRANTY, BUT NOT MINE. I DON'T UNDERSTAND WHY THIS PART, WHICH HAS OBVIOUSLY FAILED IN THE PAST, IS BEING COVERED UNDER WARRANTY ON OTHER VEHICLES. I HAVE PROVIDED A PICTURE OF THE PART ONCE IT WAS REMOVED. IT IS QUITE CLEARLY A SAFETY ISSUE WHICH COULD HAVE HAD FATAL CONSEQUENCES. AFTER BEING CHARGED ROUGHLY $250 IN LABOR, I FOUND OUT THE PART WAS $1.53. IT IS SICKENING THAT A 2014 VELOSTER WITH 56,000 MILES ON IT SHOULD HAVE THIS PROBLEM.

• 10/01/2020· ELECTRICAL SYSTEM

  BACK UP CAMERA IS FLICKERING WHEN CAR IS PUT IN REVERSE, CAMERA GOES BLACK AT TIMES.THIS CAR HAS LESS THAN 40,000 MILES ON IT. THE CAMERA SHOULDN'T BE GOING BAD.

• 09/28/2017· VISIBILITY/WIPER

  ON 09/23/2017 I WAS DRIVING ON THE HIGHWAY ON A SUNNY DAY, AROUND 80 DEGREES WITH MY SUNROOF CLOSED, AND THE SUNROOF COVER OPEN TO ALLOW THE SUNLIGHT IN. WHILE DRIVING ON THE HIGHWAY ABOUT A MILE FROM MY EXIT, I HEARD A LOUD BANG THAT STARTLED ME (SOUNDED LIKE GUNSHOT), ALL OF A SUDDEN I FELT STUFF HITTING MY HEAD, FACE, AND SHOULDERS. I LOOK UP AND SAW MY SUNROOF EXPLODED WITH SHATTERED GLASS FLYING ALL OVER MY CAR AND REALIZED GLASS IS WHAT WAS HITTING ME FACE AND BODY. LUCKILY, THE SOUND OF THE SUNROOF EXPLODING AND GLASS FLYING ALL OVER THE PLACE, I WAS ABLE TO STILL KEEP CONTROL OF MY CAR. I SLOWED DOWN TO EXIT THE HIGHWAY AND PULL INTO A PARKING SO I COULD GET OUT OF THE VEHICLE AND LOOK IT OVER. I NEVER SAW ANYTHING FLY UP AT MY CAR, OR AT MY CAR WHEN THIS HAPPENED. THERE WERE NO VEHICLES CLOSE TO ME WHEN THIS HAPPENED. AS I LOOKED OVER THE CAR, I SAW HOW BADLY THE THE SUNROOF LOOKED AND GLASS ALL OVER MY CAR SEATS. I PICKED PIECES OF SHATTERED GLASS FROM MY HAIR, SHIRT AND PANTS. I IMMEDIATELY CALLED MY INSURANCE COMPANY TO FILE A CLAIM, AND TOOK PICTURES OF THE SUNROOF. THE CAR WAS TOWED TO A STORAGE LOT UNTIL THE BODY SHOP WAS OPEN ON MONDAY. I REQUESTED FOR A LOCAL HYUNDAI DEALERSHIP TO LOOK AT IT FIRST BEFORE THE AUTO-BODY SHOP BECAUSE MY CAR IS STILL UNDER WARRANTY. A GENTLEMAN FROM DEALERSHIP'S SERVICE DEPARTMENT TOOK PICTURES OF SUNROOF AND SUBMITTED TO HYUNDAI ON 09/26 TO INVESTIGATE THE CLAIM. ON 09/28, THAT SERVICE ADVISOR FROM THE DEALERSHIP LEFT ME A VOICEMAIL THAT THE CLAIM WAS DENIED. I CALLED AND SPOKE TO THAT SERVICE ADVISOR TO OBTAIN A REASON FOR THE CLAIM BEING DENIED. HE SAID HYUNDAI'S INVESTIGATION REVEALED AN OUTSIDE INFLUENCE CAUSE THE GLASS TO BREAK, BUT I WAS PROVIDED WITH NO REPORT OR ANY OTHER EXPLANATION ON HOW THEY CAME TO THIS CONCLUSION. I SAW SOME 2012 VELOSTERS WERE RECALLED FOR SUNROOFS EXPLODING. IT'S A HUGE LIABILITY.

• 09/27/2024· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE

  The car lost power gradually ;when I was driving ; We were on the freeway and I couldn’t continue driving 60 miles per hour , therefore I turned on the turn signals cause I just could drive at 35 miles per hour and the car just start shaking ; I just look for the next exit by the time We were on risk on the emergency lane for along time cause the next exit was to far from there .and the car was too slow ,when we finally got exit I call and I stop my car and call the mechanic to ask for help and he help me plug in the scanner machine to my car and there was a problem with some cylinders and one valve and I decided to called to the dealer to get an appointment:. My Vehicule already was checking for Hyundai but they just text me a message ; they said my car needs to replace a motor ,turbo ; some broken valves causing zero pounds of compression on cylinder 4-long block repair-new intake and exhaust manifolds (including turbo)required due to broken valve sending metal through the entire system -quote long block/intake and exhaust manifolds /turbo /all necessary gaskets and fluids for repair : I just was noted my car was consuming too much oil, cause the car board showed me 3 weeks ago and I need to add oil ,and the mechanic plugged in the scanner; but it doesn’t showed something else ;therefore 3 weeks ago I added 1/4 or more ; then was 2 week ago; I added 1/4 of oil again and then just last week I added 1/4 or more oil again ;I just was checking the oil constantly.; and it should be noted that the car was not leaking oil but I didn’t understand why it was running out so quickly .

• 09/27/2022· UNKNOWN OR OTHER,ENGINEFire

  Driving on cruise control on interstate , the 2014 Hyundai Veloster felt like it lost power .The engine light flashed a few times . White smoke came out of rear as started to merge it made a low clank noise from the engine compartment . Pulled over off of interstate and popped hood to check the engine and realized there was fire coming from all over the engine . 2014 Hyundai Veloster financed not even made the first payment either. Had 120,043 miles on it . Dealership claimed that they did a recon on it before they turned it over to us . We did take it back in because the engine turned off as he was idling at stop lights. It was harder and harder to get started , it got to the point where it would stop running while moving . The dealership could not Replicate the problem and therefore turned it back over to us . Codes P0302 and P0335 came on . There were no recalls on the 2014 models but the year before and after . Doesn’t make sense , since they all had engine problems , catching on fire .

• 09/25/2019· STEERING

  CLACKING NOISE WITHIN STEERING WHEEL (DEFECTIVE COUPLER) VEHICLE MAKES NOISE WHILE IN MOTION DURING ANY TRAFFIC SITUATION AND INCLUDING TURNING.

• 09/22/2022· ENGINE

  While driving down I95 south at 10:30 at night my car made a noise like I ran over a cardboard box. Then smoke started to come out of the hood. I I went to the emergency lane hoping it was a flat tire. There was oil all over the ground and car. No warning lights or car acting funny. Cruise was set and driving home with my mom. Took car to dealership and verified the block had cracked. I asked why, the car only had 65800 miles on it. They said my last oil change looked good, they have no idea. Not covered under warranty. Only 2015 and 2016 are covered for motor failure. Mine is a 2014 I checked the recalls. They charged me $9100 to replace the motor. When I picked up the car I asked again why it cracked. They said sometimes they just don't know why. My mom and I were stranded on the freeway for over two hours waiting for a tow truck and it decide to rain on us 3 times.

• 09/20/2019· UNKNOWN OR OTHER,ENGINE

  THE FIRST ISSUE WAS THE CLUTCH. I WAS DRIVING IN CHARLOTTE, NC CITY TRAFFIC AND THE CLUTCH STUCK TO THE FLOOR AND MADE MY CAR STALL. I WAS ABLE TO PULL IT UP WITH MY FOOT AND RESTART THE CAR. I HAD NO INDICATION THAT THE CLUTCH WAS BAD. IT WASN'T SLIPPING AT ALL AND I HAD NO DIFFICULTY SHIFTING GEARS PRIOR TO THIS HAPPENING. THE NEXT ISSUE WAS THE ENGINE. I WAS DRIVING ON THE HIGHWAY AND IT LOST POWER. IT WOULDN"T ACCELERATE PROPERLY. I TOOK IT TO THE DEALER AND THEY SAID THE TURBO WENT FIRST AND THEN METAL FROM THE TURBO WENT INTO THE ENGINE AND RUINED THE ENGINE. THEY SAID THE CLUTCH NEEDED REPLACING. THE CAR DOESN'T EVEN HAVE 71,000 MILES ON IT. I WOULDN'T EXPECT AN ENGINE TO BE RUINED AT LESS THAN 71,000 MILES. I WAS TERRIFIED BEING IN TRAFFIC IN THIS UNSAFE VEHICLE WONDERING IF I WAS GOING TO BE HIT. THE ENTRANCE BELOW ASKS FOR A SPECIFIC DATE, HERE ARE THE OCCURRENCES AND DATES: JUNE 2019 CLUTCH STICKS TO THE FLOOR AND STALLS IN TRAFFIC SEVERAL TIMES. TAKE TO AAA AUTO SERVICES AS SOON AS IT HAPPENS AND THEY CAN FIND NOTHING WRONG. CONTINUES TO HAPPEN APPROX. ONCE A WEEK. SEPT 12 THE ENGINE STARTS WHINING, REVVING AND LOSING POWER ALL AT THE SAME TIME WHEN THE GAS PEDAL IS PRESSED WHILE IN TRAFFIC ON THE HIGHWAY SEPT 13 CHECK ENGINE LIGHT COMES ON AND NAV SCREEN STOPPED RESPONDING AND DOESN'T HAVE MUCH POWER SEPT 14 EVEN FURTHER POWER LOSS, SMOKE COMING FROM EXHAUST, CAR STALLS AND STOPS WHILE IN CHARLOTTE CITY TRAFFIC. TAKE TO DEALER. DIAGNOSED WITH STATED ABOVE.

• 09/18/2019· UNKNOWN OR OTHER

  TAMARA RECALL: THE DRIVER AND REAR PASSENGER DO NOT OPEN FROM THE OUTSIDE AND INSIDE. THE CAR WAS NOT IN MOTION, PARKED WITH THE ENGINE OFF.

• 09/17/2023· ELECTRICAL SYSTEMFire

  The climate control switch on my vehicle as well as many others has burned up the wiring that plugs into it behind the dash and started smoking and actually almost burned my car to the ground.

• 09/16/2019· ENGINE

  SO IBOUGHT. MY VOLSTER OCT 11TH 2018 NOT QIUTEA YR AGO. AND IM DRIVING MY CAR ALL OF A SUDDEN I HEAR A VERY ODD NOIS I THOUVHT MY TURBO WAS GOING OUT .I TAKEIT TO DEALERSHIP THEY AND I ASKED FOR A LOANER CAR WHILE THEY WERE CHECKING IT OUT .IT WAS SOME WHAT DRIVABLE RPM REVED UP HIGH I COULD. ONLY GO 30 MAYBE MILES A HOUR THE CHECK ENGINE LIGHT ON STATED ON. THEY SAID THEY DIDNT HAVE A LOANER CAR . SO I DRIVE MY CAR HOME WELL I HAD TO GO TO WORK SO OF COURSE IM HAVING TO DRIVE MT CAR LIKE THIS IT STARTS POORING BILLOWING OUT WHITE THIK SMOKE FROM BACK N ENGINE TEMPS GOES SKY HIGH. I ENED UP HAVING MY CAR TOWED TO HYUNDAI DEALERSHIP. ITS THERE NOW I THINK MY CAR ENGINE HAS SEIZED OR BLOCK IS CRACKED .

• 09/08/2023· UNKNOWN OR OTHER

  The sunroof spontaneously shattered. I was driving on an interstate highway with the sunroof tilted forward for ventilation.

• 08/29/2020· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  WHEN DRIVING THE CAR DURING DAY OR NIGHT THE HEADLIGHTS WILL CUT OFF AND THEY WILL ALSO FLICKER ON AND OFF, THIS HAS BEEN HAPPENING FOR THE LAST 3 MONTHS. THE STEREO ALSO WON'T CUT ON WHEN I CUT MY CAR ON I HAVE TO OPEN TO PASSENGER SIDE DOOR FOR IT TO COME ON.

• 08/24/2024· ELECTRICAL SYSTEM

  I have not "yet" had an incident but, because of the safety recall, I have been parking my vehicle outside for almost a year (since October 2023). It is now August 2024 and a part for my Hyundai Veloster 2014 is still not available. For an issue that may cause a fire, or indeed any recall issue, this is way too long for a remedy to become available! This has caused considerable inconvenience: scraping frost and cleaning off snow, constant dirt, and inability to park in parking garages. Additionally, the additional wear will reduce the value of the car when I sell it.

• 08/16/2019· STEERING

  POWER STEERING COUPLER IS DEFECTIVE AND MAKES A RATTLING SOUND WHEN VEHICLE IS IN MOTION. SEVERAL OTHER MODELS HAVE BEEN ISSUED RECALLS ON THIS PART BUT NOT THE VELOSTER. I'M WONDERING HOW MUCH SAFER IT IS TO DRIVE VELOSTER THIS WAY AS OPPOSED THOSE HUYNDAI MODELS THAT WERE RECALLED.

• 08/11/2025· ENGINE,FUEL/PROPULSION SYSTEM

  Knock sensor code p1326

• 08/06/2023· ELECTRICAL SYSTEM

  My ac unit switch melted due to the wires getting too hot and causing the unit to no longer work. I believe this is a safety issue due to possible fire with the wires getting burned. After doing some research this is a common issue in my car and I believe hyundai should be required to replace my unit before it causes more damage inside the unit.

• 07/30/2026· SERVICE BRAKES

  OFFICIAL REPORT: FRANCHISE FALSIFICATION OF MANDATORY SAFETY RECALL REMEDY I am filing this formal safety complaint because a licensed factory franchise, Causeway Hyundai (Manahawkin, NJ), officially documented and signed off that a mandatory federal safety campaign (NHTSA Recall 21V303 / Hyundai Recall 251: ABS Multi-Fuse Block Replacement) was successfully completed on my vehicle.This official safety record is completely falsified. The service department closed out the repair order and logged it into the manufacturer network as a finished repair. However, I have opened the under-hood engine junction box and taken photographic evidence proving that no physical labor was performed. The original, 12-year-old factory multi-fuse block assembly (Part #91ZZ9-42705 / F18 150A) is still physically inside my engine bay, completely covered in thick, undisturbed road dust and grime.The dealership returned my vehicle to me with a falsified "all clear" safety invoice while leaving a known, severe electrical fire hazard completely active inside my vehicle's engine compartment. I request that federal regulators audit this franchise location for fraudulent safety recall logging and systemic non-compliance with NHTSA safety remedy mandates.

• 07/28/2023· ENGINE

  The contact owns a 2014 Hyundai Veloster. The contact stated that while driving approximately 50 MHP, there was a loud knocking sound coming from the engine compartment before the vehicle lost motive power and stalled. The vehicle was towed to the local dealer who diagnosed that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 94,000.

• 07/26/2019· ELECTRICAL SYSTEMFire

  MY AC KNOB HAS MELTED AND IT IS BECAUSE A SHORT WITHIN THE KNOB ITSELF

• 07/23/2019· STEERING

  STEERING WHEEL WHEN STATIONARY MAKES A CLUNKING NOISE WHEN TURNING LEFT TO RIGHT AT THE STEERING COLUMN. WHEN DRIVING IT FEELS LOOSE AND ALSO MAKES A CLUNKING NOISE WHEN STEERING ON THE ROAD, WHEN REACHING HIGHER SPEEDS ON THE HIGHWAY IT WOULD VIBRATE THE STEERING WHEEL. I STOPED BY A LOCAL AUTO MECHANIC AND HE TOLD ME THAT HYUNDAI'S HAVE THIS PROBLEM AND I SHOULD TAKE BACK TO DEALERSHIP TO HAVE FIXED. HE TOLD ME IT WAS THE STEERING COUPLER. I PURCHASE 2 HYUNDAI VELOSTER IN 2014 AND BOTH VEHICLES HAVE NOW HAD THIS REPLACED BOTH UNDER 35,000 MILES. BUT THIS ONE WAS OUT OF WARRANTY WHEN IT HAPPENED BUT WAS UNDER 35,000 MILES. THIS SHOULDN'T BE HAPPENING AT THIS MILAGE.

• 07/21/2026· ELECTRICAL SYSTEM

  The HVAC manual heater control unit in my 2014 Veloster Turbo failed, causing extreme electrical resistance that melted, blackened, and discolored the factory wiring harness connector plug behind the dashboard. This caused an active thermal incident and a direct fire hazard inside the cabin. Hyundai is aware of this exact safety defect and is running Service Campaign TY6 (TSB 16-01-070) to fix it, but they are using narrow VIN filtering to deny coverage to identical vehicle configurations. I had to pay out of pocket for a genuine Hyundai replacement part to mitigate this fire risk. Hyundai Corporate (National Case #42974992) has formally denied my reimbursement claim on a technicality, actively ignoring the physical thermal damage and fire risk to my vehicle.

• 07/19/2022· POWER TRAIN,ELECTRICAL SYSTEM,ENGINEFire

  I purchased my 2014 Hyundai Veloster as a CPO back in January of 2018 with approximately 37k miles. Currently it has 95,637 miles. Within the first couple months of ownership, I noticed that the vehicle was sporadically acting up during acceleration (specifically when shifting between 2nd and 3rd gear). During this process it acts as if all of its power is shut off momentarily and then comes back on, which can potentially be dangerous when accelerating into high traffic areas, or busy intersections because not only does it lose acceleration power but steering as well. I brought it to the dealership right away, but because it never throws any trouble codes, nor does it happen on command - they cannot pin point the issue. Initially they changed the alternator. The second time, I believe, they changed the knock sensor or the Camshaft position sensor. In short, I’ve brought it to the dealership several times and have filed numerous complaints to Hyundai Consumer Affairs, but to no avail. Most recently (March 2022), it happened when both of my stepchildren were in the car while we were returning from the beach. I accelerated from a traffic light and was going around a bend when it happened causing me to slam into the curb and caused nearly $1700 in damage, which I had to pay for out of pocket because at this point it is out of Warranty- even though it’s been an ongoing issue pre-warranty lapse. Then to top it all off, I was leaving work this evening to go to an appointment and all of a sudden it began smoking from underneath the steering column. I quickly pulled into the turning lane and popped the fuse box lid open. Instantly I noticed that a wire harness was on fire, which luckily I was able to blow out after several attempts. I’m at my wit’s end with this car, with the dealership, and with Hyundai….. I need help and don’t know what to do!

• 07/04/2019· STRUCTURE

  TAKATA INFLATORS - FRONT AND READ DOOR LATCH MALFUNCTIONS, IE.: FRONT AND REAR DOOR OUTSIDE AND INSIDE LATCHES NOT RELEASING (OPENING) MANUALLY AND/OR ELECTRONICALLY WITH FOB RESULTING IN POTENTIAL SAFETY ISSUES. THE AUTO WAS PARKED AND DOORS LOCKED USING FOB. WHEN I RETURNED TO CAR, I PRESSED THE UNLOCK BUTTON ON FOB, HEARD THE CLICKING SOUND THE FOB MAKES WHEN THE UNLOCK BUTTON IS PRESSED; WE PULLED THE DRIVER SIDE AND BOTH PASSENGER DOOR LATCHES, THE DRIVER AND REAR PASSENGER DOORS DID NOT OPEN. MY GUEST TRIED TO ENTER THE REAR PASSENGER DOOR BY PULLING THE INSIDE LATCH, IT STILL DIDN'T OPEN. NEXT I PULLED THE DRIVERS SIDE DOOR LATCH FROM THE INSIDE, IT OPENED. I LEANED INTO THE CAR, TURNED ON THE ENGINE TO ROLL DOWN THE DRIVERS WINDOW TO ENTER THE CAR. I'VE TRIED REPLACING FUSE AND FOB BATTERIES, RESETTING THE LOCK/UNLOCK CODE AND NOTHING SEEMS TO WORK. CRAWLING OVER SEATS, ROLLING DOWN WINDOWS THE RUNNING AROUND CAR, AND LEAVING WINDOW OPEN ARE SAFETY HAZARDS. TWO NON-WORKING DOORS ARE SAFETY ISSUES AND NEGATIVELY IMPACTS MY CUSTOMER EXPERIENCE.

• 06/30/2022· STEERING

  Power steering rubbler coupler defective..making a clunking sound with turning sterring wheel left and right. This is a very common problem with Hyundai.

• 06/30/2021· ENGINE

  Since Nov/Dec 2020 low oil warning lite started flashing at 2 separate svc intervals for oil change maintenance. At service visit in Jan 2021 requested dealer to inspect for oil leaks. None were found but since then I began checking oil level regulary & found out the car was consuming excessive amount of oil…about half a qt every 250-300 miles. At next service appt to have oil change I informed dealer of my findings which he advised performing the 1000 mile consumption test & wait till after to change oil. He advised if vehicle fails consumption test Hyundai’s guidelines suggest a Combustion Chamber Cleaning (at a cost of over $400)! My complaint is if the cleaning is part of Hyundai’s Repair Guidelines & there’s no other alternative to this step, (as referenced in TSB# 21-EM-003H) why does the customer have to pay the $400+ to have it done if the customer’s vehicle has less than 100000 miles so it should still be covered under the 10 year/100000 mile powertrain warranty.

• 06/28/2025· ELECTRICAL SYSTEM

  The connector that connects to the air conditioning temperature knob melted this is the second time in the 4 years I have owned the vehicle

• 06/27/2024· ENGINE

  The contact owns a 2014 Hyundai Veloster. The contact stated while driving at an undisclosed speed and coming to a stop light, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The dealer stated that no failures were found after the vehicle was inspected. The contact also stated that the vehicle was consuming an excessive amount of engine oil. The manufacturer was notified of the failure. The failure mileage was approximately 89,000.

• 06/25/2024· ELECTRICAL SYSTEM

  The Hyundai recall doesn't fix the problem, which is the ABS Module leaks brake fluid internally which can catch fire. The claimed "fix" puts in a low current fuse that supposedly electrically will lower the risk of a fire when the ABS leaks brake fluid internally and shorts out the electrical power to the ABS Module. The problem is that the ABS Module can develop an internal leak which causes a short that fries the ABS Module and can cause a fire by igniting the brake fluid. The lower current rated fuse can still cause a fire, so I don't see the NHTSA Recall No. 23V651000 as a real fix. I want a replacement of the brake fluid leak-prone ABS Module in my 2014 Hyundai Veloster Turbo so I can safely use and park my car indoors without the potential of a fire while parked or driving. I have not experienced a fire in the recalled vehicle, but I think I am entitled to a proper "fix". I am an electrical engineer with an MSEE degree and many US patents. I have been greatly inconvenienced by following the recall warning to "park the vehicle outside (outdoors) away from structures". The outside exposure to hot temperatures, harsh sunshine, and salt air degrades the finish and mechanicals of my vehicle by following the recall warning. So Hyundai's faulty ABS Module costs me money (value of the vehicle) besides the risk and inconvenience. Make Hyundai really fix the problem by replacing the ABS Module as a minimum.

• 06/21/2017· ENGINE

  THE CAR AS I WOULD DESCRIBE IT STALLS RANDOMLY WHILE DRIVING UNDER 40 MPH, THE ENGINE DOESN'T SHUT OFF BUT I LOSE DRIVE POWER AND THE RPM SHOOT UP. THE DEALERSHIP HAS NOT BEEN ABLE TO REPRODUCE THE ISSUE AND NO ENGINE LIGHTS COME ON WHEN THE PROBLEM HAPPENS. I FEAR THIS WILL END UP CAUSING ME TO GET REAR ENDED.

• 06/17/2020· ELECTRICAL SYSTEM

  HVAC FAN SWITCH NOT WORKING. *TR

• 06/15/2019· SUSPENSION,POWER TRAIN,SERVICE BRAKES

  SOLD A 2014 HYUNDAI VELOSTER WITH GRINDING BRAKES, ACCELERATION PROBLEM, AND VIBRATION ISSUES. I WAS TOLD EVERYTHING WOULD BE FIXED. I RETURNED THE CAR WITHIN 24HRS. THE CAR VIBRATES DANGEROUSLY AT 50MPH AND ABOVE. THE CAR HESITATES WHEN TAKING OFF, TRYING TO PASS, OR GET ON FREEWAY. THIS IS ALSO DANGEROUS BECAUSE CARS ALREADY GOING 70MPH COULD OF HIT US WHILE TRYING TO GET ON FREEWAY. SOMETIMES WHILE GIVING THE CAR GAS IT WOULD JUST REV UP THE RPMS WITHOUT DOING ANYTHING. THIS ALSO SCARED ME INTO RETURNING THE CAR. I WENT BACK TO TEST DRIVE THE CAR TO SEE IF PROBLEMS WERE FIXED, AND THE MI GENTE AUTO DEALERSHIP TOLD ME THEY JUST REPLACED TIRES AND THAT FIXED THE PROBLEM. I TOLD THEM THEY CAN KEEP THE CAR, BECAUSE I DON'T WANT TO KEEP COMING BACK FOR SAME ISSUES. I WAS THREATENED WITH REPOSSESSION WILL BE ADDED TO MY CREDIT.

• 05/29/2020· ENGINE

  CAR MAINTENANCE HAS BEEN WELL KEPT. ROAD IN DC, HIT POTHOLE SUDDENLY ENGINE STARTED TO MAKE HORRIBLE NOISE AND STALLED OUT IN THE MIDDLE OF TRAFFIC. NO TAPPING NOISE BEFORE THIS INCIDENT. ALL OF A SUDDEN METAL IN OIL AND WAS TOWED TO HYUNDAI DEALERSHIP. DEALERSHIP TOLD ME MY ENGINE SEIZED. AS A SINGLE MOM THIS IS NOT A RELIABLE OR SAFE. I WAS ONLY GOING 35MPG. IF THIS HAPPENED AT A HIGHER SPEED OR ON A HIGHWAY THIS COULD OF BEEN A FATAL INCIDENT. *TR

• 05/27/2026· ELECTRICAL SYSTEM,AIR BAGS,VEHICLE SPEED CONTROL

  My driver airbags have been deactivated for quite some time. My radio touchscreen doesn't work, and the electrical issue has drifted all the way into my steering wheel where I can't control any type of cruise control properly.

• 05/24/2016· WHEELS

  WHILE DRIVING AROUND 50 MPH ON A TEXAS HIGHWAY, THE TIRE SIDEWALL BLEW OUT ON THE FRONT DRIVERS SIDE WITH NO CAUSE, THE TIRES HAVE NEVER HIT A CURB, PROPERLY MAINTAINED. THIS ALMOST CAUSED AN ACCIDENT. THE VEHICLE ONLY HAS 29K MILES AND HAS ROUTINE MAINTENANCE, ORIGINAL NEXEN TIRES. THESE TIRES NEED RECALLED, THEY CAR IS IN PERFECT CONDITION ONLY 2 YEARS OLD. THE CAR NOW HAS ALL PIRELLI TIRES AS THE CAR WOULD BE A HAZARD WITH NEXEN

• 05/20/2019· STRUCTURE

  MY CAR WAS STATIONARY OVER NIGHT AND MY SUNROOF BUSTED. HAD GOTTEN HOME THE NIGHT BEFORE AFTER DRIVING FOR 6 HOURS AND PARKED THE CAR. I HAD BEEN NEAR IT SEVERAL TIMES AND NEVER SAW A CRACK OR ANYTHING. WENT TO GET IN THIS MORNING AND IT HAS GLASS EVERYWHERE.