2014 Hyundai Sonata

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2021· Chest Clip, Buckle, Harness

  Chest Harness slips off of the metal TClip in the back of the seat

• 12/31/2017· STEERING,ELECTRONIC STABILITY CONTROL (ESC),ENGINECrash

  THE ENGINE STALLED ON SEVERSL OCCASIONS AND THE DEALERSHIP COULD NOT DUPLICATE. ON 7/21/2014 IT STALLED AGAIN WHILE IN GEAR.,CLOSING DAMAGE TO FRONT BNKER STERLING LOSS CONTROL WHILE BACKING OUT OF HNDICAP SPOT. THERE IS AN INSURANCE CLAIM, TOWING, BODY SHOP REPAIR AND RENT A CAR COSTS.

• 12/30/2025· UNKNOWN OR OTHERFire

  I was driving my 2014 Hyundai Sonata in a rural area when smoke suddenly entered the cabin from the engine compartment. Two bystanders waved me down, alerting me that they could see fire underneath the engine compartment. I immediately stopped the vehicle, turned it off, and exited safely. I attempted to contact 911, but reception was poor. The fire spread from the engine compartment and engulfed the vehicle, producing thick smoke that created a serious safety risk. Emergency services arrived approximately 15 minutes after being notified and extinguished the fire. The vehicle burned for approximately 30 minutes in total resulting in total loss. There were no warning lights or messages prior to the fire. The vehicle has not yet been inspected by the manufacturer, police, or insurance representatives beyond the fire report. It was towed and is being stored on private property awaiting investigation.

• 12/30/2021· ENGINE

  I’ve had my car for a year and I change the oil faithfully. Well I now have a rod knocking and not sure why? My car has 138,000 miles on it. And I’ve changed my oil and filter as I should so now my car is sitting in the yard it cranks but when you crank it you wouldn’t think anything was wrong with it. You give it gas and it starts knocking. Why is this happening?

• 12/30/2019· ENGINE

  ENGINE OVER HEATS AND WON'T START FOR SEVERAL HOURS. IT DOESN'T MATTER IF THE ENGINE HAS BEEN RUNNING FOR 5 MINUTES OR AN HOUR OR MORE. WHEN TURNING THE KEY THE ENGINE CLICKS AND WON'T START. YOU HAVE TO TURN THE KEY ON SEVERAL TIMES (WHEN THE ENGINE IS COOL) TO HAVE THE ENGINE START RUNNING. I HAVE READ THIS PROBLEM HAS BEEN UNDER RECALL BY HYUNDAI, BUT MY VIN NUMBER IS EXCLUDED ACCORDING TO ONLINE INFORMATION. I HAVE RECEIVED RECALL NOTICES ON ISSUES AND BELIEVE MY CAR'S VIN SHOULD HAVE ALSO BEEN ON THE ENGINE RECALL LIST.

• 12/28/2022· ENGINE

  Hyundai Theta Engine Recall/Repair/ Replace 2G Blue Link Telematics Deactivate Safelite Repair-Rear Windshield Defrost and Sat Radio Antenna Array replacement... Reporting to Federal Agency because of Federal Contract OFCCP occupational problems and to see if vehicle can be replaced applying California Lemon Law...

• 12/27/2023· STRUCTURE

  Door will not open from inside or outside of the vehicle and it is a safety issue. There are forums of the same issue with this make and models

• 12/27/2021· ENGINE

  The contact owns a 2014 Hyundai Sonata. The contact stated that while the son was driving approximately 40 MPH, the vehicle suddenly would not accelerate before the engine stalled. The vehicle was later towed to the local dealer who diagnosed that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified, but no assistance was offered. The failure mileage was 130,000.

• 12/27/2018· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  ENGINE BEGAN TO SLOW DOWN...I PULLED OFF THE FREEWAY SAFELY AS THE CAR BEEPED AND DISPLAYED A WARNING: 'HYBRID DRIVE FAILURE. PLACE CAR IN P. DO NOT DRIVE' THEY SHOULD ALSO ADD, CALL A WRECKER, IN ALL FAIRNESS. WAITING ON HYUNDAI'S ANSWER. AFTER TRACTOON ISSUES IN ICE AND SNOW IN ADDITION TO THIS...WHEN I GET THIS CAR BACK, SHE'S A GONER! I NEED A REAL VEHICLE.

• 12/27/2018· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  MOTOR BEGAN TO FAIL ON THE HIGHWAY. PULLED OVER. 'HYBRID DRIVE FAILURE. PLACE IN PARK AND DO NOT DRIVE.' THE WARNING SHOULD ALSO HAVE ADDED 'CALL A WRECKER.' DEALER SAYS HYUNDAI IS LOOKING AT PICTURES. CAR WAS SERVICED TWICE AND OIL CHANGED REGULARLY. WAITING TO SEE WHAT HYUNDAI SAYS.

• 12/27/2018· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  TAIL LIGHT BULBS MELTED INTO SOCKET. HAD TO GET BOTH REPLACED. FIRE HAZARD AND A DEFECT IN DESIGN.

• 12/27/2018· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  THE BACK LIGHTS ARE GOING OUT EXTREMELY TO OFTEN. I HAVE TO CHANGE THEM OUT AT LEAST ONCE A MONTH AND WHEN CHANGING THEM I NOTICE THAT THE BULB IS BLACK, ALMOST LIKE THEY ARE BURNING OUT. WHEN I REPLACE ON SIDE, A WEEK OR TWO LATER I HAVE TO CHANGE THE OTHER SIDE. IT SEEMS TO BE A WIRING ISSUE.

• 12/24/2023· ENGINE

  My engine is burning through oil and also smoking while driving and has a burn smell coming through air vent. I scheduled to have it repaired and have a screenshot of the recall but when I took it to get repaired they stated there are no recalls on my vehicle and I would have to pay. I then called Hyundai customer service and was told they see the recall in one system but not the other and that they will give me a call back. I then never received a call back so I called again and was told that they cannot fix the engine recall and that I would need to get a diagnostic and pay for it myself.

• 12/23/2024· ENGINE

  There was no warning, engine seized on main Hwy at night driving approximately 45mph. Couldn’t even pull off to the side. My child and I were stuck on a main road with no warning anything was wrong. Car stopped driving completely. This was my forth engine. Hyundai has always replaced it. 4 in 27k miles. This time they denied it.

• 12/23/2021· ELECTRICAL SYSTEM,ENGINEFire

  The contact owns a 2014 Hyundai Sonata. The contact stated that the accelerator pedal was depressed while he was at a complete stop at the stoplight, but it failed to respond. The battery warning light and several unknown warning lights were illuminated. The contact turned off and attempted to restart the vehicle however, the vehicle would not start. The contact noticed smoke coming from underneath the driver’s side hood. The contact was able to push the vehicle to the side of the road with some assistance. The vehicle was towed to the dealer who diagnosed that the engine had seized and needed to be replaced. The manufacturer was made aware of the failure and a case was opened. The manufacturer called the contact and advised that he would be responsible for the cost of the repair as he failed to complete an unknown recall repair. The vehicle was not repaired. The approximate failure mileage was 50,100.

• 12/23/2019· UNKNOWN OR OTHER

  THE AC ACTUATOR BLENDER DOOR KEEPS GETTING STUCK AND CAUSES KNOCKING IN MY DASH BOARD EVERY TIME I TURN ON CAR. IT MAKES THE NOISE FOR FEW MINUTES AND THEN STOPS.

• 12/22/2023· UNKNOWN OR OTHER

  The two struts that hold the engine hood in the upright position fail abruptly without warning causing the hood to randomly slam shut that can result in a traumatic brain injury, amputation, etc. that may result in an injury or death. Some other vehicles with engine hoods that are held up by two struts have a metal prop to ensure the hood is held in the upright position in the event the hood struts fail. This safety issue put me at risk as I narrowly avoided severe injury and potential amputation of my hand and/or fingers when the hood randomly slammed down. This problem has not yet been confirmed by a dealership or independent service. This vehicle component has not yet been inspected by the manufacturer, police, insurance representatives or others. There were no warning lamps, messages or other symptoms of the problem prior to the failure.

• 12/22/2021· ENGINE

  The contact owns a 2014 Hyundai Sonata. The contact stated while driving 40 MPH, there was an abnormal knocking sound coming from the engine. The accelerator pedal was depressed; however, the vehicle failed to respond. The contact was able to continue to drive to her residence. There was no warning light illuminated. The vehicle was taken to a local dealer who diagnosed the failure as a rod bearing failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000.

• 12/22/2016· UNKNOWN OR OTHER

  CARFAX IS SHOWING AN OPEN RECALL FOR THIS VEHICLE THAT WAS POSTED ON 11/8/16. THE RECALL NUMBER IS 946. WHEN I PULL THE VIN NUMBER ON YOUR WEB SITE, IT STATES 0 RECALLS REPORTED. I KNOW THE RECALL HAS NOT BEEN COMPLETED YET BECAUSE I WORK AT A HYUNDAI DEALER AND I JUST PURCHASED THIS VEHICLE FROM AUCTION. WHICH AM I SUPPOSE TO GO BY? CARFAX OR YOUR WEB SITE. WHICH IS SHOWING THE CORRECT INFORMATION? PLEASE HELP. *TR

• 12/22/2015· POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

  MY VEHICLE HAS FOR THE LAST YEAR SHOWED SIGNS OF THE RECALL AND WE HAVE GOTTEN A HYUNDAI TO FIX IT WITH A RING BUT THE NEXT DAY THE VEHICLE SHOWED THE SAME THINGS. THE SYMBOL IN THE MIDDLE THAT DISPLAYS DRIVE WHEN IT DISAPPEARS THE CAR STRUGGLES TO ACCELERATE AND DRIVE , AND WHEN I COME TO A COMPLETE STOP WITH IT DISAPPEREARED THE CAR TAKES ALOT OF GAS TO ACCELERATE. WHICH I BELIEVE IS FROM THE TRANSMISSION AND THE CAR NOT BEING ON THE SAME PAGE.. WHICH IS TERRIBLE AS IT CAN COST A LOST OF LIFE DUE TO THE CAR SUDDENLY STOPPING AND IT IS A EXTREME HAZARD TO MYSELF AND MY FAMILY. AND I WISH THAT HYUNDAI WOULD DO SOMETHING OR REPLACE THE VEHICLE.

• 12/21/2021· UNKNOWN OR OTHER

  I brought my 2014 Hyundai Sonata Hybrid in for the 964- AUXILIARY CANISTER INSTALLION & 966- ENGINE MONITORING LOGIC Service recall campaigns on 12/08/21. Today, 12/21/21, in heavy traffic on the highway, my car engine abruptly shuts off, immediately decelerating, completely losing any ability to accerate while the engine light, parking break light come on along with an "electric motor warning - safely pull over and do not drive" message on the dashboard. All this happens while a high pitch alarm goes off. All happening simultaneously without warning on the highway with vehicles surrounding us driving 70 mph! This has never happened prior to today and should never happen. How we managed to avoid an accident or worse was a miracle. This was life threatening and should not be taken lightly!

• 12/21/2016· STEERING

  WHEN DRIVING THE VEHICLE MY STEERING WHEEL FEELS LIKE IT GETS STUCK IN ONE AND I HAVE TO SNATCHED IT TO POSITION IT RIGHT AGAIN. *TR

• 12/20/2022· ENGINE

  Sounds like engine is gonna blow and the oil is where it needs to be.

• 12/19/2022· ENGINE

  In the GDI engines, the fuel is injected into a camshaft-driven high-pressure pump and use a higher than normal compression ratio for increased power as well as “dished” pistons for increased combustion in the cylinder. But GDI engine defects allegedly cause oil consumption, restricted oil flow, sudden stalling, engine failures and non-collision fires. The plaintiff says Hyundai ramped up production and got in a rush which caused the workmanship to suffer when the GDI engines were created. Engine blocks, pistons, connecting rod bearings and other components are defective due to the workmanship. By failing to fit together, the engine components allegedly fail prematurely which causes metal debris to travel through the engine oil. Contaminated oil then causes a lack of engine lubrication which damages the GDI engines

• 12/18/2020· POWER TRAIN

  THERE HAVE BEEN PREVIOUS RECALLS FOR HYUNDAI VEHICLES REGARDING THE NEUTRAL SAFETY SWITCH/TRANSMISSION RANGE INHIBITOR FAILING TO WORK PROPERLY, BUT IT APPEARS THAT THIS PROBLEM EXTENDS TO VEHICLES OUTSIDE OF THE PREVIOUS RECALL WINDOW. THE 2014 HYUNDAI SONATA SE EXPERIENCES A SIMILAR DEFECT, AS SEARCHES ONLINE WILL INDICATE A HIGH NUMBER OF FORUM POSTS AND OTHER RESOURCES WHERE DRIVERS OUTLINE THEIR CONCERNS. SPECIFICALLY, ON AN INTERMITTENT BASIS, THE CAR WILL FAIL TO DISPLAY A GEAR WHEN STARTING, SHOWING A BLANK SYMBOL ON THE DASH AND NOT ILLUMINATING THE GEAR SHIFT COLUMN. THIS LEAVES THE CAR UNABLE TO BE SHIFTED INTO ANY GEAR. IT APPEARS THAT A WIDE RANGE OF HYUNDAI VEHICLES HAVE BEEN EFFECTED BY FAULTY NEUTRAL SAFETY SWITCHES, AND AS I MENTIONED SOME VEHICLE YEARS NEED TO BE RECALLED THAT WERE NOT PREVIOUSLY DONE SO IN THE LAST 'BATCH' OF RECALLS FOR THE SIMILAR ISSUE.

• 12/17/2025· AIR BAGS

  The contact owns a 2014 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle before the front passenger's side air bag independently deployed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The contact was advised not to take the vehicle for a diagnostic test until contacted by the manufacturer. The contact had no additional communication with the manufacturer. The failure mileage was approximately 160,000.

• 12/17/2022· ENGINE

  Car has an oil consumption issue. I noticed noise coming from the engine, checked my oil and found its was empty. I brought my car into the dealer and was told about the oil consumption suit, I was out of warranty and that hyundai won't do anything for me because I am not the original owner. I was told later from another auto shop that I was given false information because this is a campaign. I am the 2nd owner of this vehicle.

• 12/16/2025· ENGINE

  The vehicle experienced a sudden engine failure and loss of power while traveling at freeway speed. Two days earlier, the vehicle had been taken to an authorized dealership for factory recall service. During that visit, concerns were raised about known engine issues associated with this model, but the vehicle was returned to service. While driving on the freeway, the engine abruptly stalled without warning, causing immediate loss of propulsion and power. This created a dangerous situation in moving traffic, requiring rapid maneuvering to avoid a collision and safely exit traffic lanes. The vehicle became inoperable and could not be restarted. The failed component appears to be the engine or related internal engine system. The vehicle was towed back to the dealership following the incident and has remained inoperable since that time. The vehicle is currently available for inspection. The failure placed the driver at significant risk due to the sudden loss of power at highway speed. No collision occurred, but the risk of serious injury or death was present. The problem has not been reproduced because the vehicle has remained disabled since the incident. The dealership and manufacturer have inspected the vehicle after the failure. The manufacturer is reviewing the incident under an internal process. There were no prior warning lights, messages, or symptoms indicating imminent engine failure before the stall. The failure occurred suddenly and without advance notice.

• 12/16/2021· ENGINE

  Vehicle died while driving on the highway had to pull over and have the car towed. Hyaundai dealership diagnosed it as a bad engine bearing which was part of an open and active recall which they confirmed. Hyaundai advised it is part of a recall that is still open but stated we didn’t come soon enough so they refuse to fix it. We never received the recall notice and the recall is still open and active.

• 12/16/2019· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER

  TL* THE CONTACT OWNS A 2014 HYUNDAI SONATA. EVER SINCE THE VEHICLE WAS PURCHASED BRAND NEW, THE CONTACT EXPERIENCED ISSUES WITH THE AIR CONDITIONER BLOWING THE WRONG TEMPERATURE DURING THE SEASONS. THE BRAKE LIGHTS WERE ALSO MALFUNCTIONING. THE VEHICLE WAS TAKEN TO RAY BRANDT HYUNDAI (1700 WESTBANK EXPY, HARVEY, LA 70058, (504) 684-8039), BUT THEY COULD NOT DUPLICATE THE FAILURES AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE CONTACT TOOK HIS VEHICLE BACK TO THE DEALER NUMEROUS TIMES, BUT THE AIR CONDITIONER FAILURE CONTINUED. FOR EXAMPLE, THE DEFROSTER WOULD BLOW OUT COLD AIR IN THE WINTER. THE MANUFACTURER STATED THAT THERE WERE NO FAILURES WITH THE VEHICLE SINCE THE DEALER COULD NOT DUPLICATE THE FAILURES. THE FAILURE MILEAGE WAS 500.

• 12/15/2023· ELECTRICAL SYSTEM,SERVICE BRAKES

  Vehicle displaying "hybrid system warning! Safely stop and do not drive!" And "check brake" car will not drive over 15 mph. Also draining has And 12 volt battery. Took it to hyundai dealership and was told that the brake module was damaged and needed replacement. We are aware of the current ABS recall. And waiting for remedy

• 12/15/2021· ENGINE

  Engine needs to be replaced, engine light, brake light and loud ticking sound in engine

• 12/15/2019· STRUCTURE

  THE LEFT REAR DOOR DOES NOT OPEN FROM THE OUTSIDE OR INSIDE. WHEN YOU ENGAGE THE DOOR LOCK/UNLOCK FOR THE REMOTE OR INSIDE THE VEHICLE, THE DOOR LOCK/UNLOCK MOVES BUT DOES NOT DISENGAGE THE LOCK. THE DOOR CANNOT BE OPENED AND THIS IS A HUGE SAFETY ISSUE. THERE ARE SEVERAL PEOPLE ON VARIOUS MESSAGE BOARDS HAVING THE SAME ISSUE. THE DEALER WANT TO CHARGE ME $1000 TO FIX.

• 12/15/2019· EXTERIOR LIGHTING

  I HAVE HAD TO REPLACE ALL OF THE EXTERIOR LIGHTS MULTIPLE TIMES DUE TO SPORADIC BLINKING, DIMNESS OR TOTAL OUTAGE. THIS INCLUDES ALL HEADLIGHTS, TAILLIGHTS AND TURN SIGNALS. THIS IS QUITE TERRIFYING WHILE TRAVELING AT NIGHT. THIS HAS OCCURRED IN FRONT HEADLIGHTS THE MOST. I'VE CHANGED THESE MANY TIMES AND WAS EVEN WARNED BY POLICE IN ONE INSTANCE. THE LOCAL HYUNDAI DEALERSHIP WANTS $175 JUST TO LOOK AT IT. I HAVE SPOKEN TO OTHER SONATA OWNERS, AND READ ABOUT MANY MORE, WHO HAVE SIMILAR ISSUES. THIS IS DANGEROUS AND SOMETHING NEEDS TO BE DONE.

• 12/13/2022· POWER TRAIN,UNKNOWN OR OTHER,ENGINECrash

  I bought my car at 97k miles in June 2022. From the 2nd day of having it, my car was shaking horribly. I sent it back to the dealership they said the front motor mount was collapsed. They repaired it but said there is still shaking but they don't know why. About 2 months later, I get in with Universal Hyundai and they only say that I need my axels and spark plugs replaced along with the air filters. They do a balance and alignment on my car as well as an oil change. The balance and alignment was either not done properly or my car just needs it done super regularly. Not too long after while I'm driving out of a friend's neighborhood my car is in drive and I'm going around 5 mph, my car stops with all of the lights on. I turn my car off and back on and carefully drive it home. Also, my car key always gets locked up in the ignition. One day I go to turn my car off and my ignition locks and I had to get my car towed and my ignition replaced with new car keys. Later, I take it to my mechanic to see what he can do and to get another oil change. He said he doesn't think it's my axels but my motor mounts and other things. Then my check engine light goes off a week later and it's my power train and anti-lock brake system. The next day on the way back to the mechanic my car slows down, I was only going 40ish mph, and all of the lights are shown. I turn my car off and on and I get it to my mechanic (my mechanic only down minor stuff btw). I start hearing a woodpecker noise from the engine and my mechanic tells me to get it to the shop asap. The next morning, I call my warranty to see if it's covered and they tell me that my engine will blow if I drive on it. And now my car will be in the shop for a month. And I can't find out the service done to my car prior to me owning it. And every time I take it somewhere they don't know what's up with it completely.

• 12/13/2021· ENGINE

  I purchased this car on November 17th, it started giving me trouble on November 25th so i parked it. The problem was it started making a really loud noise and started to slow down in mid traffic while i was driving. i had to bear to the side of the road to avoid a car crash. i think it’s the motor , i’ve purchased a brand new battery and starter and neither of those was the problem. my car have been sitting every since the 25th i need to know what’s wrong with my vehicle beside the recalls i have on it!

• 12/13/2018· ENGINE

  CAR STALLED WHILE DRIVING ON THE HIGHWAY AND ENGINE LOCK

• 12/12/2023· ENGINEFire

  With the 2014 Hyundai Sonata GLS off and onto a tow truck, it spontaneously burst into flames and the eventual total loss of the vehicle. The 2014 Hyundai Sonata GLS need to be added to the notice to Hyundai consumers in the Hyundai 251 recall.

• 12/12/2022· ENGINE

  MY CAR HAS BEEN DRIVING IN LIMP MODE FOR ALMOST TWO YEARS. I HAVE TAKEN IT TO THE DEALERSHIP OVER 8 TIMES FOR THE SAME PROBLEM WHILE IT WAS STILL UNDER WARRANTY. THE REPLACED THE KNOCK SENSER TWICE AND IT PASSES THE BEARINGS TEST. MY CHECK ENGINE LIGHT BLINKS AND IT HESISTATES WHILE DRIVING. I ONLY HAD THE CAR FOR ONE MONTH SINCE THIS STARTED AND EVERYONE IS GIVING ME THE RUN ARAOUND AND NOT FIXING THE PROBLEM. NOW MY WARRANTY IS EXPIRING BECAUSE I HAVE OVER 100,000 MILES ON IT BUT NOTHING IS FIXED.

• 12/12/2022· EXTERIOR LIGHTING

  Headlights need to be replaced every three months. Brake lights turnt out and melted the plastic around it. Had to replace the entire light unit. Now, the breaklight doesnt work at all. Even after replacing the entire light unit and bulbs.

• 12/12/2016· EXTERIOR LIGHTING

  POTENTIAL SONATA FIRE HAZARD INFO.........CAR PURCHASED NEW IN MAY 2014. CAR IS 2 1/2 YRS. OLD WITH 42 K MILEAGE. WHILE REPLACING CAR'S OEM REAR BURNED OUT BRAKE LIGHT INCANDESCENT BULB AT HOME DURING STATIONARY, OWNER DISCOVERED BOTH REAR BRAKELIGHT BULBS ON RT/ LFT SIDES HAD BURNED OUT AND MELTED WITH NORMAL USE, SMELL OF PLASTIC MELTING AND MELTED BOTH SIDE BULB HOUSING, BRAKELIGHT TAIL LIGHT ASSEMBLY AND CONNECTOR WIRES. BOTH MAIN BULBS COULD NOT BE EXTRACTED FOR ROUTINE MAINTENANCE DUE TO MELTED HOUSING. OWNER TOOK CAR TO LOCAL DEALERSHIP WHO HAD TO "CRACK OPEN" BOTH LIGHT BULB HOUSINGS TO REPLACE BULBS FOR TAIL & BRAKE LIGHTS DUE TO MELTED FUSING OF PLASTIC PARTS. CAR UNDER OEM WARRANTY; SUGGEST YOU HAVE NEW LED TAIL LIGHTS & ASSEMBLY INSTALLED FOR LESS HEAT AND POTENTIAL MELTING OF ASSEMBLY.

• 12/11/2023· ELECTRICAL SYSTEM,ENGINE

  The car warning lights turn on and the car shuts down. The problem is with the Hybrid battery that is malfunctioning. This is a serious life and death problem. After the vehicle stops it goes in neutral and rolls .

• 12/10/2020· ENGINEFire

  THE CAR DIED WHILE EXITING THE INTERSTATE ONTO THE TURNPIKE. PULLED OVER AND ATTEMPTED TO START THE VEHICLE WITH NO SUCCESS. SMOKE BEGAN COMING FROM UNDER THE HOOD AND SOON THE CAR WAS ON FIRE.

• 12/10/2017· AIR BAGS,SEAT BELTS,STRUCTURECrash

  VEHICLE IN MOTION, SEATBELT RETRACTOR DID NOT SAFELY PERFORM. AIRBAG DID NOT DEPLOY AT THE SCENE OF AN ACCIDENT WHERE I REARENDED A UTILITY TRUCK ON A RESIDENTIAL ROADWAY (TWO LANE). THERE WAS A CITY RECYCLE TRUCK IN FRONT OF THE UTILITY TRUCK WHICH. ABRUPTLY STOPPED. AS A RESULT, AUTO DAMAGE, PERSONAL INJURY TO MYSELF.

• 12/09/2024· ENGINE

  To Whom It May Concern, I am writing to express my concern regarding my 2014 Hyundai Sonata, Vehicle Identification Number (VIN): [XXX] , which is currently experiencing excessive oil consumption. I have recently become aware of Recall Campaign 162, which addresses a manufacturing defect that can lead to premature engine wear and related issues. Despite regular maintenance and proper care, my vehicle consumes an abnormal amount of oil, causing me to frequently top off the oil between oil changes. This not only increases my maintenance costs but also raises serious concerns about the safety and reliability of my vehicle. **A trusted service provider has confirmed that the oil consumption in my vehicle is abnormal and is likely related to the defects outlined in Recall Campaign 162.** As stated in the recall, the machining errors during the engine manufacturing process can restrict oil flow to the bearings, leading to premature bearing wear. Although my vehicle does not currently exhibit any visible oil leaks, the oil consumption issue suggests underlying damage that could potentially lead to engine failure. Considering the potential risks and the known issues with the Theta II engine, I kindly request that my vehicle be inspected and, if necessary, repaired under the terms of Recall Campaign 162. I urge you to address this matter promptly to ensure the safety and reliability of my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/09/2021· SERVICE BRAKES

  While driving the Warning in my dash appeared Check Brake Hybrid System Warning safely stop and do not drive. The front brakes sounded like they were rubbing against my tire. I stopped the car. Pushed emergency brake off and on (I’ve never had to use this before) turned car back on and it stopped. I’m worried it will happen again.

• 12/08/2020· FUEL/PROPULSION SYSTEM

  TOOK OUR CAR IN FOR THE FUEL LINE RECALL IN SEPTEMBER 2020. SINCE OCTOBER WE HAVE BEEN SMELLING GAS HERE AND THERE. THIS PAST WEEK IT HASN'T GONE AWAY. FUEL IS NOW LEAKING FROM THE FUEL LINE THAT THEY ZIP TIED BACK TOGETHER. THE DEALERSHIP SAID THEY ONLY INSPECTED THE LINE AND EVERYTHING WAS FINE.

• 12/08/2017· SERVICE BRAKES

  TOTAL CATASTROPHIC BRAKE FAILURE WILL DRIVING SLOWLY IN A PARKING LOT, BRAKE PEDAL WENT TO FLOOR, FOLLOWED BY A WARNING LIGHT TO STOP AND HAVE VEHICLE SERVICED, AND ANOTHER WARNING HYBRID SYSTEM FAILURE.

• 12/08/2016· EXTERIOR LIGHTING,UNKNOWN OR OTHER

  WHENEVER I PUT ON THE INDICATOR AT NIGHT THE HEADLIGHT TURNS OFF,I HAVE TO TAP THE SWITCH FOR THE LIGHT TO COME ON. TOOK IT TO THE DEALER AND WAS TOLD THAT THE MULTI FUNCTION SWITCH IS BAD,MY CAR IS ONLY 2 YEARS OLD,HOW CAN THE SWITCH BE BAD WHEN I'M THE ONLY DRIVER, I THINK ITS A FACTORY PROBLEM.THIS IS DANGEROUS WHENEVER I'M DRIVING AT NIGHTS. *TR

• 12/08/2015· ENGINEFire

  TL* THE CONTACT OWNS A 2014 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE VEHICLE STALLED AND SMOKE EMITTED FROM UNDER THE HOOD OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000. THE VIN WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.