2014 Ford Expedition

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/23/2022· SEAT BELTS

  Both my third row seat belts, driver and passenger side, have come unstitched. Luckily we were not needing them, my son was buckling up at the time of failure. I have an extended warranty on the car from Ford and was told they cover the second row seat belts but not the third row.

• 12/23/2019· ELECTRICAL SYSTEM

  THE POSITIVE BATTERY TERMINAL KEEPS CORRODING CAUSING THE TERMINAL TO MELT. THE TERMINAL MELTS AND VEHICLE DOESN'T CRANK. I'VE HAD TO REPLACE THE ENTIRE TERMINAL SYSTEM TWICE WHICH IS VERY COSTLY.

• 12/23/2019· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2014 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE'S BATTERY TERMINAL FAILED. THE CONTACT STATED THAT THE BATTERY TERMINAL POSITIVE SIDE MELTED DUE TO ACID OR FAILED WIRES. THE CONTACT HAD TO REPLACED THE BATTERY TERMINAL SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER SEVERAL TIMES FOR THE TERMINAL FAILURE. THE DEALER REPLACED THE BATTERY TERMINAL POSITIVE AND NEGATIVE CABLE BRACKET TWICE. THE REPAIRS DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 92,000. *DT*JB

• 12/09/2024· POWER TRAIN

  The key to start/stop the vehicle engine could not be removed from the ignition steering column due to a problem with the gear shifter. The gear shifter (on the floor, not the column) thought the car was not in park even though the engine was off and IN park. The auto is available for inspection and I took it to Christian Brothers and they are replacing the shift assembly, FORD part number BL1Z-7210-CA. The vehicle only has 75,500 miles on it and I am the original owner and bought it new. The key not being able to be removed when the car is off and in park causes confusion for the driver and concern that the car could be stolen, even with a spare key to access the locked vehicle with the other key in the ignition. Two days prior to the key being locked in the steering column, the shifter began to have a mushy feel to it. My other concerns were the steering wheel to be placed in a locked position while driving the car due to problems with the shifter. The vehicle has not be inspected by the manufacturer or insurance company, just Christian Brothers who is replacing the entire shift assembly, with a cost around $945.

• 11/27/2024· ELECTRICAL SYSTEM,VISIBILITY,STRUCTURE

  The contact owns a 2014 Ford Expedition. The contact stated that while at the car wash, the running boards extended downward and fractured. The contact stated that the running boards failed to retract as intended. The contact stated that while driving at various speeds, the running boards were extending and retracting independently. The contact engaged the running boards to extend down. The contact stated that the front driver's side window became inoperable. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who repaired the window motor. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was opened. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

• 11/27/2017· SUSPENSION

  ALL 4 OF OUR STRUTS HAVE A SLOW LEAK AND NEED TO BE REPLACED. I HAVE NEVER ONCE OWNED A VEHICLE THAT ALL 4 STRUTS LEAKED AT THE SAME TIME.. ESPECIALLY WHEN THE ONLY DRIVING IS HIGHWAY. JUST FOUND OUT TODAY

• 11/23/2018· STRUCTURE

  PAINT BUBBLING ON THE REAR LIFT GATE. THIS ISSUE IS RELATED TO CONTAMINATION OF THE ALUMINUM BEFORE PAINTING. FORD IS AWARE OF THIS ISSUE, BUT IS IGNORING IT, CLAIMING IT IS NO LONGER COVERED UNDER THE WARRANTY AND OR THE WARRANTY DOES NOT APPLY. THERE ARE MANY PEOPLE HAVING THE SAME ISSUE ON HOOD AND TAILGATE ON MULTIPLE FORD MODELS. FORD HAS ISSUED A TSB: 17-0062 ABOUT THIS ISSUE:. HTTP://WWW.REVBASE.COM/BBBMOTOR/TSB/DOWNLOADPDF?ID=201136 THERE ARE NO ACCIDENTS TO THIS CAR. THE CAR HAS ALWAYS BEEN IN THE SOUTH EAST, SO NO ISSUES WITH SALT. SEE ALSO: HTTPS://WWW.GOOGLE.COM/SEARCH?Q=FORD+PAINT+BUBBLING+TSB&OQ=FORD+PAINT+BUBBLING+TSB&AQS=CHROME..69I57.28698J0J4&SOURCEID=CHROME&IE=UTF-8 HTTPS://FORD.OEMDTC.COM/1349/ALUMINUM-BODY-PANEL-CORROSION-APPEARING-AS-BUBBLED-OR-PEELING-PAINT-2000-2016-FORD-LINCOLN-MERCURY

• 11/21/2023· POWER TRAIN

  P0722 code stored in power train control module. Intermittent output shaft speed sensor failure.

• 11/21/2022· VISIBILITY

  The contact owns a 2014 Ford Expedition. The contact stated while driving 60 MPH, the passenger’s side windshield wiper seized in the upright position. There was no warning light illuminated. The vehicle was taken to a dealer and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 166,000.

• 11/15/2021· POWER TRAIN

  Transmission will suddenly shift gear while driving. On one occasion it downshifted to 1st gear as I was travelling down the highway at 70 mph with my family in the vehicle. Tires locked up and vehicle slid but I was able to regain control and did not hit anything. In addition, in multiple occasions the Instrument Panel shuts off all the gauges for the exception of the RPM's and shows a wrench and loosing some power. Also while driving at low speeds the transmission disengages and slips but no sign of transmission issues. On all instances above I parked the vehicle, shut off for a minute, restart and drove away like nothing happened. No codes, no warnings. Brought it to several mechanics and they are not able to tell me whats wrong. Spoke to Ford and they said is nothing they have seen on the Ford Expedition but the symptoms are similar to an issue on a F-150. I'm very concerned as this can happened at any time and I know if it happens on snow It will probably cause a major accident. Don't feel safe driving the vehicle.

• 11/13/2018· ELECTRICAL SYSTEM,STRUCTURE,ELECTRONIC STABILITY CONTROL (ESC)

  FORD RECALL ON EXPLORER MODEL REGARDING THE VEHICLE NOT RECOGNIZING THAT THE SHIFT GEAR IS IN THE PARKING SETTING,THEREFORE THE KEY IS UNABLE TO BE REMOVED...ALSO RENDERING THE VEHICLE UNSAFE CONSIDERING THAT SINCE PARKING ISN'T ENABLED THE VEHICLE MAY ROLL RESULTING IN INJURY OR DEATH.I WOULD ALSO LIKE TO ADD TO THE RECORDS THAT THIS IS THE THIRD TIME I'VE EXPERIENCED THIS MALFUNCTION IN 3 DIFFERENT MODEL YEARS INCLUDING 2012 AND 2008. I WOULD ALSO LIKE TO REPORT THAT THE AUTOMATIC RUNNING BOARDS HAVE BECOME DIS ENGAGED IN THE MOTOR AND ONLY WORK RANDOMLY WHICH IS ALSO DANGEROUS WHEN ENTERING VEHICLE.

• 10/31/2023· SERVICE BRAKES, AIR,POWER TRAIN

  The contact owns a 2014 Ford Expedition. The contact stated while driving 65 MPH, the RPM increased rapidly, and the contact became aware that the vehicle had downshifted unintendedly, prompting the contact to pull over to the shoulder. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the wheel speed sensor. The vehicle was not repaired. After investigating the failure, the contact related it to Customer Satisfaction Program 19N01. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 106,000.

• 10/28/2015· AIR BAGSCrash

  TL* THE CONTACT OWNED A 2014 FORD EXPEDITION. WHILE AT A STOP, ANOTHER VEHICLE CRASHED INTO THE REAR OF THE CONTACT'S VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED SHOULDER INJURIES AND A CONCUSSION THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 16,000.

• 10/25/2019· AIR BAGSCrash

  TRAFFIC ON HWY CAME TO A SUDDEN STOP FROM AROUND 60 MPH. I APPLIED THE BRAKES VERY HARD AND CAME TO A SAFE STOP. THE VEHICLE BEHIND ME DID NOT STOP AND REAR ENDED ME AT A HIGH RATE OF SPEED. THERE WERE 3 PASSENGERS IN MY VEHICLE, ALL WEARING SEATBELTS, AND NOT A SINGLE AIRBAG WENT OFF!!! THE SENSORS TO PREVENT CAR FROM STARTING AFTER AN ACCIDENT ACTIVATED AND CAR WOULD NOT START. BECAUSE MY FOOT WAS FIRMLY ON THE BRAKE STILL AT TIME OF IMPACT, THERE WERE NO LIFE THREATENING INJURIES, BUT WERE SOME INJURY. THE NYS POLICE AT THE SCENE WERE SURPRISED THE AIRBAGS DID NOT GO OFF.

• 10/23/2024· POWER TRAIN

  The contact owns a 2014 Ford Expedition. The contact stated while driving 65 MPH, the transmission downshifted to first gear unexpectedly, causing the rear tires to lock-up. The vehicle drove off the road into a ditch. The check engine warning light was illuminated. The contact had not sustained any injury and was able to drive to the nearby residence. The contact is an independent mechanic. The contact scanned the vehicle and retrieved DTC code: P1500, indicating a rear output speed sensor failure. The contact determined that the TCM needed to be replaced. The contact purchased the TCM from the dealer and replaced the TCM. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 150,000.

• 10/22/2025· STRUCTURECrash

  Minor side impact. All repairs were make and no issues noted

• 10/21/2022· ELECTRICAL SYSTEMFire

  Air conditioner stopped working; we pulled to side of street and shut engine off. Restarted engine and smoke started coming out of air conditioner vent on passenger side then out of front dash. Shut engine off again and called AAA for tow truck. Tow truck came about an hour and a half later. Tow truck driver turned ignition key to put car in neutral and began pulling it up onto flat bed. Smoke started coming from front area of dash and out through vents at bottom of windshield. Tow truck driver rolled car back down onto street. Smoke got extremely thick. My husband opened front passenger door and saw fire in the floor under the glove box. He tried to pick up this piece of equipment to throw it out of the car thinking it would save the rest of the vehicle, and this is how he got burned fingers. The fire quickly started spreading and we tried to get some belongings out of car while tow truck driver called 911. Fire Department came and put out fire. Vehicle was totally burned up. There were no warnings of any kind before the incident. Husband had third degree burns on fingers of right hand. If we hadn't been stopped and engine shut off, we possibly could have been killed because the vehicle was totally engulfed in flames within three minutes after fire began.

• 10/13/2017· WHEELS

  LOW TIRE SENSOR KEPT GOING OFF. KEPT TAKING VEHICLE TO NORTH CASCADE FORD AND LES SCHWAB TIRE CENTERS TO HAVE SENSORS RESET AND TIRES CHECKED. DIFFERENT TIRES AT DIFFERENT TIMES WERE LOW. STARTED AT APPROXIMATELY 41000 MILES. ON OCTOBER 7,2017 FRONT DRIVER TIRE WAS COMPLETELY FLAT. AIRED IT UP AND WENT TO LES SCHWAB. AFTER CHECKING ALL 4 TIRES AND NOT FINDING ANY PROBLEM WITH THE TIRES, WHICH WERE PURCHASED AT LES SCHWAB THE TIRE TECHNICIAN FOUND THAT THREE OF THE FOUR WHEELS THAT CAME ON THE VEHICLE WHEN PURCHASED (PURCHASED NEW FROM NORTH CASCADE FORD) WERE CRACKED AND ALLOWING AIR FROM THE TIRES TO LEAK OUT. CALLED THE SERVICE DEPARTMENT AT NORTH CASCADE FORD AND THE ONLY RESPONSE WAS THE WARRANTY HAS EXPIRED, SUGGESTED A CALL TO FORD CUSTOMER SERVICE WHICH RESULTED IN A CONVERSATION WITH A PERSON WHO DID NOT DPEAK ENGLISH VERY UNDERSTANDABLY SAYING THEY WOULD FOCUMENT THE PHONE CALL. LES SCHWAB TIRE CENTER DID DOCUMENT THE CRACKED WHEELS ON THE INVOICE OF THE NEW WHEELS THAT WERE PURCHASED FROM THEM.

• 10/10/2015· ELECTRICAL SYSTEM,AIR BAGS,SEATS

  OWN A 2014 FORD EXPEDITION. WHEN A PASSENGER IS SEATED IN THE FRONT PASSENGER'S SIDE SEAT, THE WARNING CHIME DOES NOT ACTIVATE WHEN THE PASSENGER'S SEAT BELT IS NOT LATCHED. THE VEHICLE WAS DIAGNOSED AND ROCHESTER FORD DEALER SERVICE STATED A PART WAS NOT PUT IT WAS OPTIONAL AND THEY DID NOT REPAIR IT. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN BUT REPORTED AT 12,000 MILES.

• 10/07/2020· WHEELS

  WHEEL NUTS WERE SWOLLEN AND HAD TO BE REPLACED. JUST A WEEK PRIOR I HAD A FLAT TIRE AND THE NUTS WERE REMOVED WITHOUT INCIDENCE. HAD THEY BEEN SWOLLEN AT THE TIME I WOULD HAVE BEEN STRANDED ON THE SIDE OF THE ROAD OUT OF TOWN FROM FAMILY/FRIENDS ALONE. THE TOW COMPANY, DUE TO COVID, COULD NOT TAKE ME TO WHERE MY CAR WOULD HAVE BEEN TOWED. LUCKILY, THE NUTS WERE ABLE TO BE REMOVED AT THE TIME OF FLAT.

• 09/19/2020· ENGINE

  HEATER HOSE TO REAR COMPARTMENT UNIT FOUND DAMAGED AND LEAKING DURING ROUTINE INSPECTION, POSING THREAT OF SUDDEN MASSIVE COOLING LEAK WITH NO WARNING. HOSE HAD TO BE REPLACED BY A LABOR INTENSIVE PROCESS OF 5 HOURS SO JOB COST $1,143.

• 09/19/2020· SUSPENSION

  IN 2015 LEFT FRONT STRUT FOUND TO BE LEAKING AT 3/3/2015 AT APPROX 10,00 MILES REPLACED UNDER WARRANTY BUT ONLY THAT STRUT.. IN 2016 BOTH REAR STRUTS FOUND LEAKING AT 25,000 MILES. BOTH REPLACED UNDER WARRANTY. 3/3/2019 AT 45,00 MILES RIGHT FRONT STRUT FOUND LEAKING. MECHANIC NOTED OK TO GO TO NEXT OIL CHANGE. (/16/20 RT FRONT STRUT STILL FOUND LEAKING BUT LITTLE PROGRESSION. DECIDED TO WAIT UNTIL 20121 AS NO ACCELERATED TIRE WEAR NOTED OVER THE LAST YEAR. FORD SHOULD HAVE REPLACED ALL STRUTS UNDER WARRANTY WHEN THE LEFT FRONT AND BOTH REARS WERE FOUND LEAKING.. PHOTOS NOT CLEAR TO ME.

• 09/18/2024· POWER TRAIN,ENGINE

  The contact's father owns a 2014 Ford Expedition. The contact stated while his father was driving at an undisclosed speed, the speedometer was fluctuating. The vehicle was taken to an unknown dealer, where it was diagnosed that the valve body needed to be replaced. The vehicle was repaired. Additionally, the contact stated while his father was driving 60 MPH, the transmission unexpectedly downshifted to 1st gear. The check engine warning light was illuminated. The driver pulled over to the side of the road temporarily. The driver was able to continue driving; however, the vehicle failed to exceed 40 MPH. The contact who is an independent mechanic diagnosed the vehicle. The contact determined that the failure was related to an unstated recall. The contact stated that the failure fractured the rocker arms, causing the needle bearings to intrude into engine. The contact determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 212,000.

• 09/17/2018· ENGINE

  HEADACHES AND GENERAL I'LL FEELINGS OF SICKNESS WHILE DRIVING/RIDING IN VEHICLE. CARBON MONOXIDE PRESENT IN FRONT CABIN OF VEHICLE AT 1-14PPM UNDER NORMAL DRIVING CONDITIONS. READINGS NOT TESTED IN 3RD ROW. NOT TESTED IN EXTREME PASSING OR WITH AIR CONDITIONER ON. I DO NOT FEEL THIS VEHICLE IS SAFE.

• 09/15/2025· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  Was driving 80MPH down the highway when instantly the rear wheels locked up, green wrench came on dashboard and my car came to a screeching halt. Complete loss of power, and am VERY lucky it did not create a major pile up on the highway! Had to "bunny" hop it over 4 lanes of traffic and barely survived the most terrifying experience of my life. Had it towed and the mechanic shop said the throttle body/actuator had magnetic problem which is VERY common, ARE YOU KIDDING ME?! But there are no recalls on it, and they had to replace the entire unit, and now I am scared to death to drive the vehicle ever again. I am also very lucky it did not happen on snow, ice, or rain!!!!! SO DANGEROUS and SO SCARY!!!! And I could barely hop it out of oncoming traffic.... How can a vehicle go from 80MPH to ZERO in .02 seconds due to a faulty part and there is no recall???? SO GRATEFUL TO BE ALIVE!!!! Ford needs to take some responsibility before there are deaths from a very simple preventative measure due to a part completely failing. After looking it up online I read hundred's of people having the same issue.

• 09/14/2025· BACK OVER PREVENTIONCrash

  Backup camera intermittently blacks out or becomes distorted.

• 09/13/2021· POWER TRAIN

  I was driving down the street at 40mph when all of a sudden the transmission down shifted into first gear. Because this happened on its own, there were no brake lights to warn the car behind me that I was slowing down at a rapid rate. The wrench symbol flashed on the dashboard and went away, so I took the vehicle to a Ford dealer the next morning when they opened up.

• 09/13/2021· POWER TRAIN

  I was sitting sat a stop light, when the light turned green, I stepped on the gas pedel but the car did not move. I took my foot off the gas, let the engine rpm go down, then stepped on the gas again. As the engine rpm went up, the transmission dropped into gear with a loud, jerking cluck sound. The dashboard flashed and then went dead. I had no speedometer, fuels, coolant, voltage gages, the only thing that worked was the tacometer. I pulled over and turned the car off, but when I started the car again, all the gages worked as normal and drove fine until the next incident.

• 09/02/2026· TIRES

  The contact owns a 2014 Ford Expedition equipped with Cooper Tires, Tire Line: Discoverer AT, Tire Size: 275/55/R20, DOT Number: UTV11R9 4221. The contact purchased four new tires. The contact called Walmart for assistance. The contact became aware that there were large blisters on the sidewalls of the tires. The tire was 80 percent worn. The second and third tires were at 50 and 80 percent worn. The blister was about six inches long. The blister was located on the passenger’s side rear tire; the driver’s side rear tire and the driver’s side front tires had blisters. The contact was able to stick a finger between the blister and the ball joint. The contact was concerned about a blowout. An attempt was made to contact the tire manufacturer, but there was no response. The tire failure mileage was unknown. The vehicle failure mileage was approximately 162,749.

• 09/02/2014· SEAT BELTS

  TL* THE CONTACT OWNS A 2014 FORD EXPEDITION. THE CONTACT STATED THAT WHEN A PASSENGER WAS SEATED IN THE FRONT PASSENGER'S SIDE SEAT, THE WARNING CHIME DID NOT ACTIVATE WHEN THE PASSENGER'S SEAT BELT WAS NOT LATCHED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80.

• 08/29/2019· POWER TRAIN

  TL* THE CONTACT OWNS A 2014 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE TRANSMISSION EXPERIENCED A HARD GEAR SHIFT AND SEVERAL UNKNOWN WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE TRANSMISSION SHIFTED INTO SECOND GEAR AND REMAINED IN SECOND GEAR. THE VEHICLE WAS TOWED TO FORD LINCOLN OF FRANKLIN (LOCATED AT 1129 MURFREESBORO RD, FRANKLIN, TN 37064, (615) 800-6500) WHERE IT WAS DIAGNOSED THAT THE OSS SENSOR CIRCUIT FAULT-P0722 FAILED AND NEEDED TO BE REPLACED. THE MECHANIC WAS ALSO ABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

• 08/20/2023· SERVICE BRAKESCrash

  Two incidents resulting in minor collision. No injuries. Approaching traffic light applying brakes and accelerator is also engaged. I could not stop the vehicle. Repair man denied it could happen after first incident. No inspections made as far as i know. There is usually no warning lights or indicators on with this vehicle. I am terrified of this vehicle now. I have owned it for less than 2 months. I understand it was in a major (front and rear) accident in Atlanta area by a previous owner. Police report to be filed Monday morning. Both parties have Geico insurance. 1st incident at 46th and Division, Kentwood, MI doing test drive. 2nd incident at corner of Perryville and State, Rockford, IL returning to hotel.

• 08/15/2023· POWER TRAIN,ENGINE

  The contact owns a 2014 Ford Expedition. The contact stated while driving 60 MPH, the vehicle unintendedly downshifted. The contact turned on the hazard lights and shifted into neutral(N) and coasted to the side of the roadway. The contact restarted the vehicle however, the vehicle failed to exceed 20 MPH. The failure was self-corrected but returned intermittently. The check engine warning light illuminated, and the failure became more persistent. The contact stated that while idling, the transmission was downshifting. The vehicle was taken to a certified mechanic who diagnosed the vehicle and determined that the TCM and engine had failed. The mechanic had stated the TCM needed to be flushed, and the computer system needed reprogramming. The vehicle was in the process to be repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 149,000.

• 08/04/2021· POWER TRAIN

  Transmission will suddenly shift gear while driving. One on occasion it downshifted to 1st gear. Luckily we were only going 45 mph, so I was able to maintain control of the vehicle. In a separate instances it downshifted 1 gear while driving 60 mph, remained in the lower gear and appeared to be stuck in that gear, because after coming to a complete stop it was very slow to pick up speed and didn't shift gears. Same thing happened within a 1 1/2 weeks, driving 70 mph, feel a slight jerk, transmission gets stuck in lower gear (noticeable higher RPM) and then magically clears itself up a few minutes later. Took it to 2 different Ford Dealers. Both say, the Molded Lead Frame/Valve Body assembly has gone bad. There is no recall for this, yet we had the exact same issue on a 2013 F-150. There had been a recall for model years (up to 2012) but not 2013. Then a few months later, the 2013 model year as included (I guess enough people complained). Now Ford claims that recall doesn't cover the 2014 Expedition with the 5.4L engine. Utter nonsense, same problem, same part that is failing/needs replacing.

• 08/01/2017· SEATS,UNKNOWN OR OTHER

  WHEN I PURCHASED THE CAR WE NOTICED THAT THE CARPET IN THE DRIVER WHEEL WELL WAS CUT SHORT. AT THAT TIME IT DID NOT CAUSE A HAZARD BUT OVER TIME AND MANY VISITS TO THE DEALER IT HAS FOLDED OVER IT ITSELF AND IS BECOMING DANGEROUS. FORD HAS LOOKED AT IT SEVERAL TIMES AND ACKNOWLEDGED IT AS A PROBLEM BUT SAID THAT SINCE IT IS AFTER THE WARRANTY PERIOD, THEY WILL NOT FIX IT. THIS CAN POSE A VERY DANGEROUS SITUATION AND ASKING THAT FORD MAKE THE REPAIR. ALSO THE PANEL ON THE SIDE OF THE CHAR IS FALLING OFF AND IS POSING A HAZARD TOO. THE DEALER SAID HE HAS SEEN THIS OFTEN AND SEEMS TO BE A PROBLEM. FORD IS NOT WILLING TO FIX IT EITHER.

• 07/19/2022· SEAT BELTS

  The contact owns a 2014 Ford Expedition. The contact stated the front passenger’s side seat belt sensor and rear seats seat belt sensors were inoperable. The contact stated that the seat belt warning light failed to illuminate with a passenger seated in the front passenger’s seat without the seat belt securely fastened. The driver's side seat belt alarm operated correctly. The contact had taken the vehicle to a local dealer who could not duplicate the failure with the alarm. The contact was informed that the vehicle was not equipped with a front passenger’s side seat belt sensor alarm. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 51,519.

• 07/01/2024· POWER TRAIN,ENGINE

  The contact owns a 2014 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission shifted independently. In addition, the contact stated that the brakes engaged independently. The contact stated that the failure occurred while driving on an icy road during winter. The vehicle was towed to the dealer where it was diagnosed with failure of the O2 sensor. The contact was informed that the O2 sensor needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was 131,000.

• 07/01/2024· POWER TRAIN

  While driving it would hard downshift and speedometer would glitch, speedometer wouldn't work, all power would go out. I had the work fixed at Ford. They have confirmed that it is the same part that was recalled on the 2014 F150s but the Ford Expeditions are not included. This almost killed me and my daughter driving on icy roads.

• 07/01/2019· POWER TRAIN,ENGINE

  TL* THE CONTACT OWNS A 2014 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 60 MPH, THE TRANSMISSION SEIZED WITHOUT WARNING. THE VEHICLE BEGAN TO SKID AND THE CONTACT WAS ABLE TO SHIFT INTO NEUTRAL. THE CONTACT PLACED THE VEHICLE INTO DRIVE AND ACCELERATED OFF THE HIGHWAY. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND RESUME NORMAL DRIVING. THE VEHICLE WAS DRIVEN TO AMES FORD LINCOLN (123 AIRPORT RD, AMES, IA 50010, (515) 233-1913)WHERE IT WAS DIAGNOSED THAT THE GASKETS, CONNECTORS, AND TRANSMISSION FLUID NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. THE CONTACT WAS PROVIDED CASE NUMBER: CAS-21938912. THE FAILURE MILEAGE WAS 146,000. *BF *TR

• 06/30/2026· POWER TRAIN

  I bought this 2014 ford expedition. I didn't know at the time the Triton 5.4 had a transmission Lead Frame defect. I asked them to cover it under NHTSA 26V237 but they refused because they dsaid it wasn't part of the recall although this vehicle shares the same exact components. I also asked them to cover it under Safety Recall 26S28. I ended up having to pay $1842.00 to get this fixed.

• 06/29/2016· ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

  TL* THE CONTACT OWNS A 2014 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND THE ELECTRONIC STABILITY CONTROL LIGHT FLICKERED ON AND OFF REPEATEDLY. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000.

• 06/18/2025· POWER TRAIN

  While driving at highway speeds very quickly the speedometer went to 0 , the fuel low warning came on , the transmission locked up dragging the rear wheels and engine goes to high rpm , this has happened numerous times , I’ve checked with local ford dealership and they tell me there are no updates for my vehicle , when this situation happens I pull over to the side of the road and shut vehicle off , count to ten and restart , drive away and wait for the next instance. I have read where earlier ford products have had this same issue. One additional item on this unit , it has a sporadic 1.5 amp drain that will kill the battery sometimes , very sporadic. Myself and two others have tried to find this drain but unsuccessfully , took to dealership and $500 later still same issue so I found a electronic battery shutoff with a key fob that disconnects the battery to prevent battery draw , but doing this prevents codes from storing , I have recently started leaving vehicle hooked up to automatic tricle charger to prevent battery from being drained so I can get codes stored up for dealership to troubleshoot at a cost to me off $150 to plug up and read codes. Does that come with lube or will that cost extra ?

• 06/06/2023· POWER TRAIN,VEHICLE SPEED CONTROL

  My mother in law contacted me and stated her 2014 ford expedition’s transmission felt like it was failing. I drove same the next day. As I was test driving the vehicle at approximately 60mph down a U.S. highway, I hear a “clunk” noise and then immediately the RPMs went up and the vehicle downshifted into 1st gear causing the vehicles’s wheel to lock up. I went sliding down the highway and luckily didn’t not collide with another vehicle. I had the vehicle scanned and same displayed PO722 output speed sensor codes. After further research, I discovered that her transmission is the same model and design as the 6R80 transmissions that were installed from 2011-2017. The 6R80 transmission lead frames were recalled for years 2011-2013 for the exact same safety issue that I encountered. For some reason Ford has done nothing for the 2014 models. This is a huge safety concern. Myself as well as my child could have been seriously hurt or worse as well as the other innocent motorists that were driving around me. Now we are forced to pay $1500 to have a safety issue fixed that in my opinion should be covered due to the safety concern as well as the fact that Ford is already aware of this lead frame issue that occurs in the previous year model. I understand that things happen and parts break but there is no excuse for a vehicle to downshift into 1st gear while traveling 60 and 70mph down the highway and nothing be done to fix the issue from the manufacturer.

• 06/04/2021· POWER TRAIN,VEHICLE SPEED CONTROL

  As I was driving on the freeway my transmission downshifted and my rear wheels locked up and I lost control of my vehicle with all 4 of my children in the car with me! After this happened the check engine light came on and I had the code read at my local auto parts store and the error code was P0720 for the output shaft sensor which is located on the lead frame inside my transmission. I called my Ford dealer to get a quote to fix my car and was told based on my VIN the part number for the faulty part is AL3Z7G276D. When I looked up this part number on the internet I found that this part was recalled for the same exact thing that happened to me except that the current recall didn’t include my model year and build. I’m confused as to why if the recalled part number is in my truck and I almost died along with all 4 of my children because of it that my car is not covered in this safety recall.

• 06/03/2023· ELECTRICAL SYSTEM,UNKNOWN OR OTHERFire

  Fire while engine on /off exactly as described in NHTSA campaign 22V648000, Ford Recall Campaign 22S56. Car destroyed damaging adjacent property. No injuries.

• 05/17/2023· ENGINE

  My A/C went out, but began coming on and shutting off. I drove from my home to work, approximately 6 miles, and parked in the parking lot. In the parking lot, I began to smell burning and my SUV began smoking. I turned my SUV off and got out of the car. As I got out, coolant was pouring onto the pavement. When the hood was popped, we noted the coolant boiling which caused the cap to pop off and the coolant to pour out. I had my vehicle towed to Coconut Point Ford to be diagnosed. I was told there was a fuse blown, the control unit and wire harness was melted and the interior blower motor needed to be replaced. Upon research, I noted the 2015-2017 blower motors were recalled for this exact reason. I thought my truck was going to catch fire. I have videos of everything as it was happening and will share if needed.

• 05/16/2018· UNKNOWN OR OTHER

  PAINT BUBBLING ON HOOD AND REAR HATCH KNOWN DEFECT BY FORD CAR IS LESS THAN 4 YEAR'S OLD

• 05/12/2025· POWER TRAIN,ENGINE

  The contact owns a 2014 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. The contact stated that the check engine and Advancetrac warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission lead frame needed to be replaced. The contact researched and was became aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 148,000.

• 05/07/2019· POWER TRAIN

  100306-105660 MILES VEHICLE PURCHASED USED -FORD 2014 EXPEDITION WOULD STALL OCCASIONALLY AND DOWNSHIFT WHILE ON HIGHWAY AND GOT WORSE. 5 MECHANICS (ONE WAS FORD DEALERSHIP), $3000.00 OF GUESSING AND REPLACING PARTS (FUEL PUMP& FILTER, THROTTLE BODY), ALMOST GETTING REAR ENDED THREE TIMES AT HIGHWAY SPEEDS DOWN TO 10-20 MPH, NO CODES, 10 WEEKS OF IN & OUT OF REPAIR SHOPS, AND NO ONE CAN FIND PROBLEM. FINALLY GOT BAD ENOUGH LAST MECHANIC GOT CODE OF LEAD FRAME CONNECTOR WITH DECODER PLUGGED UNDER DASH DURING TEST DRIVE. RECALL DOES NOT INCLUDE MY VIN OR MODEL. FORD KNOWS THIS IS A PROBLEM AND SHOULD BE HELD RESPONSIBLE. THEY SHOULD REDESIGN THIS PART AND PAY FOR ALL REPAIRS DONE TO VEHICLES REGARDLESS OF WHERE REPAIRS DONE, YEAR OR MILEAGE AND HOW MANY TIMES THIS OCCURS UNTIL THE PROBLEM NO LONGER EXISTS. THIS PROBLEM SEEMS TO OCCUR AFTER WARRANTY PERIOD HAS EXPIRED AS NO CODES APPEAR IN DASH OR FULL VEHICLE SCANS.

• 04/30/2020· SUSPENSION

  OUR 2014 FORD EXPEDITION HAS DEFECTIVE SHOCK ABSORBERS WHICH LEAK OIL. ON 4/21/17, WITH 21,132 MILES ON THE ODOMETER, THE FORD DEALER REPLACED THE LEFT FRONT SHOCK ABSORBER, WHICH WAS LEAKING OIL, UNDER WARRANTY. ON 11/17/17 THE FORD DEALER, WITH 27,000 MILES ON THE ODOMETER, REPLACED THE RIGHT FRONT AND RIGHT REAR SHOCK ABSORBERS WHICH WERE BOTH LEAKING OIL. THIS WAS DONE BECAUSE THE VEHICLE DID NOT PASS VIRGINIA SAFETY INSPECTION AND WAS ALSO DONE UNDER WARRANTY. NOW, ON 4/30/20 WITH 49,851 MILES ON THE ODOMETER, THE RIGHT REAR SHOCK ABSORBER, WHICH WAS REPLACED BY THE FORD DEALER AT 27,000 MILES, IS LEAKING OIL. SINCE THE VEHICLE IS NO LONGER UNDER WARRANTY, A LOCAL GARAGE IS REPLACING THE RIGHT REAR SHOCK ABSORBER. THE FORD MOTORCRAFT SHOCK ABSORBERS USED ON THIS MODEL VEHICLE ARE OBVIOUSLY DEFECTIVE. THIS VEHICLE HAS ALWAYS BEEN USED HIGHWAY USE ONLY AND NEVER FOR ANY OFF-ROAD USE