2013 Ford Flex

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2017· ELECTRICAL SYSTEM

  CAR BATTERY DYING. SAID SYNCH LINE IS IN, BUT IT'S NOT. DOOR AJAR LIGHTS FOR BOTH DRIVER AND PASSENGER SIDE ARE ALWAYS ON. WHEN COME TO A STOP, BEEPS AND SAYS ENGINE ON, SHIFT TO PARK. CAN'T LOCK DOORS. HAVE TO MANUALLY LOCK DOORS, OTHERWISE THE ALARM ALWAYS GOES OFF. SO CANNOT LOCK THE HATCH. THIS IS A SAFETY AND THEFT PROBLEM. INTERIOR LIGHTS STAY ON FOR HOURS AT A TIME. CANNOT SEE WHEN BACKING OUT OF PLACES AT NIGHT BECAUSE THE INTERIOR LIGHT IS ON. THIS IS GOING TO CAUSE AN ACCIDENT.

• 12/28/2016· ELECTRICAL SYSTEM

  3 OUT OF THE 4 DOORS ON THE FLEX WILL NOT LOCK, I CALLED FORD AGAIN TODAY AND WAS TOLD WE ARE NOT A PART OF THE 2.4 MILLION CARS RECALLED. MY CHILDREN CANNOT LOCK THE DOORS WHILE WE ARE TRAVELING AND IT IS VERY CONCERNING TO US, FORD SUGGESTED I PAY FOR NEW LOCKS AND IF WE ARE RECALLED THEY WILL REIMBURSE ME.

• 12/27/2023· ELECTRICAL SYSTEM

  While driving, the radio turns off and the climate control system malfunctions causing the heater to engage to high with no way to turn the system off. All controls are disabled and there is no way to turn the system off. Unplugged the battery for 30 minutes as suggested, removed fuses to the radio and climate control module which temporarily fixes the issue, but issue happens randomly and creates excessive heat in the cabin. This is the 5th time this has happened. It is the 3rd time while on long trips (3hrs or longer). Others online have mentioned the same. We had to ride with the windows and moonroof open to let the heat escape. First time occurred in 2019 in early December. Navigation still worked, but all other systems would not function.

• 12/27/2017· UNKNOWN OR OTHER

  2013 FORD FLEX SE PURCHASED IN DECEMBER 2012 WITH 60,000 MILES IS EXPERIENCING FRONT AND REAR PASSENGER DOOR LATCHING PROBLEMS. THE FRONT PASSENGER DOOR 'DOOR AJAR' LIGHT IS TRIGGERED AFTER THE DOOR HAS BEEN CLOSED. WHEN THIS PROBLEM BEGAN, OPENING AND CLOSING THE DOOR WOULD BE ENOUGH TO ENGAGE THE SENSOR BUT OVER THE PAST MONTH IT HAS NOT BEEN EFFECTIVE. THIS IS A PROBLEM FOR A FEW REASONS: FIRST, IT DOES NOT AUTOMATICALLY LOCK THE DOORS WHEN THE CAR IS IN MOTION WHICH IS A POTENTIAL SAFETY HAZARD UNDER NORMAL DRIVING CONDITIONS OR IF THE VEHICLE WAS TO BE IN AN ACCIDENT. THE DOOR COULD POSSIBLY FLY OPEN DURING A COLLISION LEAVING THE PASSENGERS VULNERABLE TO BEING THROWN FROM THE VEHICLE OR OBJECTS COMING INTO THE VEHICLE. SECOND, THE CABIN LIGHT REMAINS ON WHILE DRIVING WHICH CREATES A GLARE ON THE WINDSHIELD MAKING IT IMPOSSIBLE TO SEE OUTSIDE THE VEHICLE. THIRD, THE CABIN LIGHTS STAY ON AFTER THE VEHICLE IS LOCKED WHICH CAUSES AN UNWARRANTED STRAIN ON THE VEHICLE BATTERY. AS FOR THE BACK RIGHT PASSENGER DOOR, IT IS NOT LATCHING. I FEAR THAT AT ANYTIME THE DOOR MAY COME UNLATCHED WHILE DRIVING. IF THIS PROBLEM CONTINUES AND THE DOOR DOES NOT LATCH, THE VEHICLE WILL BE INOPERABLE. SINCE MY WARRANTY EXPIRED AND THERE ARE NO RECALLS, I AM EXPECTED TO PAY THE PRICE TO MAINTAIN DOOR LATCHES ON A VEHICLE.

• 12/27/2016· STRUCTURE

  TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT THE DOOR AJAR WARNING INDICATOR ILLUMINATED EVEN WHEN THE DOORS WERE CLOSED. THE CONTACT STATED THAT DUE TO THE FAILURE, THE INTERIOR LIGHTS DID NOT CEASE TO FUNCTION, THE DOORS WOULD NOT LOCK, AND THE HORNS WOULD FUNCTION INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INTERIOR DOOR LATCHES WOULD NEED TO BE REPLACED. IT WAS UNKNOWN IF THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 39,000.

• 12/26/2023· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  The contact owns a 2013 Ford Flex. The contact stated that the vehicle had experienced several electrical failures, including that door erroneously locking and unlocking and the Lane Departure safety feature malfunctioning. The vehicle was taken to the local dealer who determined that the electronic body control module was faulty. After removing and reinstalling the module, the vehicle was repaired. Additionally, while the vehicle was in for service, the mechanic discovered that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.

• 12/26/2016· STRUCTURE

  PASSENGER DRIVER SIDE DOOR ALWAYS SAYS AJAR, DOORS DON'T LOCK, DOME LIGHT ALWAYS STAYS ON. DRIVING, AND STATIONARY. *TR

• 12/24/2015· ELECTRICAL SYSTEM

  WE HAVE A 2013 FORD FLEX LIMITED AND WE BOUGHT IT USED WITH 50000 MILES AND WHEN WE BOUGHT IT THE DOOR SENSOR WAS BAD THE DEALER SHIP SAID THEY WOULD FIX IT 7 MONTHS OF FIGHTING THEM AND THEN THEY DECIDED TO FIX IT SO HERE I AM SITING IN THE DEALER SHIP READY TO PICK UP MY CAR AND NOW THEY TELL ME ANOTHER DOOR SENSOR IS BAD THIS IS DANGEROUS DO TO THE LIGHT STAYING ON AT NIGHT THIS NEEDS TO BE RECALLED BY FORD AND FIXED RIGHT.

• 12/23/2024· FUEL SYSTEM, GASOLINE

  The contact owns a 2013 Ford Flex. The contact stated while driving approximately 35 MPH, there was an abnormal gasoline odor inside the cabin of the vehicle. The contact stated that the odor of gasoline was constant. There was no warning light illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 15V812000 (Fuel System, Gasoline). The failure mileage was approximately 100,000.

• 12/23/2018· UNKNOWN OR OTHER

  TAKATA RECALL , I TOOK MY CAR TO MEL HAMBELTON FORD, FOR A VEHICLE HEALTH INSPECTION AND NEVER WAS INFORMED ABOUT THE FSA TITLE SYNC WITH MYFORD MYLINCOLN TOUGH WZARRANTY EXTENSION COVERING ACCESSORY PROTOCOL INTERFACE MODULE APIM , BUT WAS UNDER PRIMARY CONCERNS DIAG. AND REPLACE APIM FOR BLANK SCREEN, YET WHEN I GET ON FORD PASS I LEARN OF THIS ISSUE, NEVER THE DEALER THAT SOLD MY THE CAR OR THE FORD DEALERSHIP OFFER TO ASSIST ME ARE CHECKED THE RECALLS ON THIS VEHICLE12/13/18

• 12/22/2025· STEERING

  While driving, the power steering warning light illuminated and steering assist was lost. The steering became extremely hard, especially at low speeds. The vehicle makes grinding/whining noises when turning, and the car vibrates while in Drive. This creates a serious safety concern, especially during turns and parking maneuvers. Issue appears to be electric power steering (EPAS) failure.

• 12/22/2016· ELECTRICAL SYSTEM

  THE ISSUES ARISES WHEN THE DOOR LATCH AND INTEGRATED SENSOR FAIL TO RECOGNIZE THE DOOR BEING CLOSED PROPERLY. A DISPLAY ON THE DASH WILL INFORM THE DRIVER OF THE WHICH DOOR IS "AJAR". THE VEHICLE WILL NOT CHIME AND INTERIOR LIGHTS WILL TURN OFF IF THE VEHICLE IS PUT IN DRIVE AND DRIVEN. THE SAFETY CONCERN IS THAT THE VEHICLE WILL NOW NOT ALLOW THE DOORS TO LOCKED WHILE PARKED OR IN MOTION. AN INVITED PERSON COULD ENTER THE VEHICLE AT A LIGHT OR AN THE EVENT OF A SERIOUS COLLISION THE DOOR MAY COME AJAR. A SEARCH OF THE INTERNET WILL REVEAL THIS IS A COMMON ISSUE AND FORD HAS EVEN REDESIGNED THE PART BECAUSE IT IS AWARE OF THIS FLAW.

• 12/21/2021· UNKNOWN OR OTHER

  My 2013 Ford Flex had the same issues as many that have been recalled. Ford states that the vehicle is not covered under the recall. My electronic power steering assist is no longer working and the service traction control is on. This has been reported from many other Ford Flex owners but it seems like ford is trying to skimp on by with this by saying it’s not covered. All Ford Flex’s 2013 year model should be recalled to replace / inspect the power steering rack assembly

• 12/21/2018· FUEL/PROPULSION SYSTEM

  THIS IS THE 3RD TIME THIS HAS HAPPENED IN THE PAST MONTH. AFTER DRIVING THE CAR TO A LOCATION, TURNING THE CAR OFF THEN RETURNING TO THE CAR TO LEAVE, THE ENGINE WILL TURN OVER, BUT WILL NOT FIRE. THE INDICATORS SHOW THE CAR RUNNING, I.E. DASH LIGHTS ON EVEN AFTER GETTING OUT OF THE CAR. THE SMELL OF GASOLINE IS PRESENT.

• 12/21/2017· STEERING

  TL* THE CONTACT OWNS A 2013 FORD FLEX. AFTER STARTING THE VEHICLE, THE STEERING WHEEL WAS VERY DIFFICULT TO TURN. MOMENTS LATER, WHILE DRIVING, THE "CHECK CHARGING" INDICATOR ILLUMINATED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 109,000.

• 12/21/2015· ELECTRICAL SYSTEM

  INTERIOR LIGHTING HAS NO MANUAL OFF SWITCH AND REMAINS ON DURING DRIVING DUE TO INCORRECLTY REPORTED "DOOR AJAR"

• 12/19/2019· STEERING

  WHILE DRIVING I LOST ALL POWER STEERING AND ALMOST LOST CONTROL, THANKFULLY IT DIDN'T HAPPEN WHILE MY WIFE WAS DRIVING WITH THE KIDS. I WAS ABLE TO PULL OFF THE ROAD AND SHUT THE VEHICLE OFF. I RESTARTED AND THE POWER STEERING WAS RESTORED. THIS OCCURED SEVERAL TIMES OVER THE NEXT FEW DAYS UNTIL THE POWER STEERING JUST STOPPED WORKING ALL TOGETHER. I CHECKED FOR RECALLS AND FOUND THAT THERE WAS A RECALL THAT INCLUDED MY MAKE, MODEL AND YEAR FOR THE LOSS OF POWER STEERING ASSIST (RECALL #15S18) I MADE AN APPOINTMENT WITH THE SARASOTA FORD DEALERSHIP AND WAS TOLD UPON CHECK IN THAT MY VEHICLE WAS NOT COVERED UNDER THIS RECALL. THE RECALL STATES THAT IT COVERS MODEL YEAR 2013 FORD FLEX WITH ANY ENGINE. WITH A KNOWN, EXTREEMLY DANGEROUS ISSUE, I CANT UNDERSTAND HOW MY VEHICLE (EXPIERIENCING THE EXACT ISSUE DESCRIBED) IS NOT COVERED.

• 12/19/2015· ELECTRICAL SYSTEM

  ON THE EVENING OF 12/18/15 (10:00PM), AFTER STARTING UP THE CAR, NONE OF THE CONTROLS LOCATED ON THE STEERING WHEEL AND STEERING WHEEL COLUMN WOULD OPERATE. I HAD NO TURN SIGNALS AND NO WIPERS AND NO CRUISE CONTROL. A MINOR INCONVENIENCE WAS THAT I COULD NOT OPERATE ANY SYSTEMS NOR THE RADIO FROM THE STEERING WHEEL. AFTER TURNING OFF THE VEHICLE AT HOME THE CAR ACTED AS THOUGH THE KEY WAS STILL IN THE IGNITION EVEN THOUGH IT HAD BEEN REMOVED AND THE HEADLIGHTS WOULD NOT TURN OFF. I HAD TO DISCONNECT THE BATTERY TO KILL THE HEADLIGHTS. WHEN I RECONNECTED THE BATTERY THE FOLLOWING MORNING ALL SYSTEMS WERE WORKING AGAIN.

• 12/18/2016· ELECTRICAL SYSTEM

  THE DRIVER DOOR ALWAYS SAYS ITS OPEN AND THE LIGHT ON THE INSIDE TO THE CAR STAY ON UNTIL THE VEHICLE IS DRIVEN AT A CERTAIN SPEED, THE ALARM ALSO RANDOMLY COMES ON. THE CAR BATTERY STAYS DEAD BECAUSE OF THIS PROBLEM. THE CAR WILL BE OFF AND THE ALARM WILL BE SET THE ALARM WILL SOUND SO I CANNOT LOCK MY DOORS.

• 12/18/2015· ELECTRICAL SYSTEM

  THE DOOR AJAR LIGHT COMES ON WHEN THE DOOR IS CLOSED CAUSING THE INTERIOR LIGHTS TO TURN ON. AT NIGHT THIS IS A PROBLEM. THE ALARM GOES OFF AT RANDOM TIMES DURING THE DAY & NIGHT. THIS HAS BEEN GOING ON FOR OVER A MONTH AS OF 12/18/15.

• 12/12/2016· STEERING,SUSPENSION

  STEERING SUDDENLY STOPPED! A SENSOR THAN CAME UP STATING SERVICE ADVANCE TRAC AND NOT EVEN 2 SECONDS LATER ANOTHER SENIOR COMES UP STATING POWER STEERING ASSIST FAULT! I WAS ABLE TO PULL OVER! I THEN READ CAR MANUAL STATING THAT THE SENSORS THAT WERE SHOWN HAVE TO DO WITH AN ELECTRIC POWER STEERING THAT CAN BE RESET BY SHUTTING OFF CAR AND RESTARTING 10 SECONDS LATER! I THEN BROUGHT IT TO KELLY FORD AND THEY ARE STATING THAT THE ENTIRE POWER STEERING RACK MUST BE REPLACED! THEY STATED THAT THERE ARE NO RECALLS ON MY VIN AND THAT I HAD NO WARRANTY! I BEGAN RESEARCH AND THERE HAVE BEEN OVER 500,000 CARS RECALLED FOR THE SAME EXACT REASON BUTVFORD INSIST THAT MINE IS NOT COVERED! I ALSO CONSTANTES FORD MOTORS AND THEY HAD ME FILE A CASE WHICH DID ABSOLUTELY NOTHING! THE DEALER QUOTED ME THAT THIS WAS A 2,000 DOLLAR JOB! MY ARGUMENT IS THAT THIS IS THE SAME EXACT THING THAT EVERY OTHER FORD HAS THAT HAVE BEEN RECALLED WHAT IS SO DIFFERENT ABOUT MINE! MY CAR WAS ALSO MANUFACTURED IN THE SAME AREA... I JUST DON'T UNDERSTAND! THIS WILL BE MY ONE AND ONLY FORD AND I WILL NEVER PURCHASE ONE AGAIN! FORD DEALERSHIPS ARE ALSO HORRIBLE TO VISIT! EVERY SINGLE TIME I HAVE BEEN IN ANY OF THE 3 DEALERS CLOSE TO ME HAVE ALWAYS BEEN UNCOMFORTABLE SITUATIONS! I NEVER FEEL AS IF THEY ARE BEING HONEST AND CAN NEVER HELP COME UP WITH A SOLUTION! AS SIMPLE AS MY CAR BEING DIAGNOSED! THE MAN MARK THAT WORK THERE QUOTED ME $159.00 AND THE WOMAN QUOTED ME $124.00 WHEN SHE QUESTIONED HIM IN FRONT OF ME! HE STATED OH THAT'S JUST AN EXTRA FEE SO THEY HAVE MORE TIME TO LOOK AT THE CAR AND WORK ON IT BUT IF SHE CHOOSES TO FIX IT HERE IT WILL BE WAIVED! THE WOMEN THEN STATED WELI HAVE NEVER SEEN THAT CHARGE BEFORE! MIND YOU I WAS JUST DROPPING OFF FOR DIAGNOSTIC TESTING AND THEY COULDN'T BE HONEST AM I SUPPOSED TO BELIEVE THE SHEET OF PAPER THAT ONLY HAS WHAT I CLAIMED TO SEE ON THE CARE SENSORS. *TR

• 12/12/2014· ELECTRICAL SYSTEM

  DOOR LATCH SENSORS ARE VERY PROBLEMATIC. HAVE HAD MY VEHICLE IN 4 TIMES IN 2014 FOR SAME ISSUE. COMPUTER CLAIMS DOORS ARE AJAR WHEN THEY'RE CLOSED. HAVE HEARD THIS IS A PROBLEM WITH THE EDGE AND OTHER MAKES AS WELL. WARRANTY EXPIRES AT ~36,000 MILES. I JUST HIT 40,000 MILES AND AM NOW HAVING TO PAY FOR PRE-EXISTING CONDITION. *TR

• 12/11/2019· EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM

  NOW REPLACING THE FUEL MODUAL SENSOR FOR THE 3RD TIME IN 5YRS. THIS IS A KNOWN ISSUE FOR OTHER FORD VEHICLES. CAR WILL NOT START AND NEEDS TO BE TOWED EACH TIME. FRONT PASSENGER DOOR SENSOR DOESN'T WORK AND INTERIOR LIGHT REMAINS ON UNTIL VEHICLE REACHES 10MPH. INTERIOR LIGHT WILL NOT TURN OFF AND BATTERY DRAINS.

• 12/10/2017· ELECTRICAL SYSTEM

  MY 2013 FORD FLEX HAS DOOR LATCH SENSOR ISSUES. WHEN I AM DRIVING ANYWHERE (CITY, HIGHWAY, INTERSTATE) MY INTERIOR LIGHTS WILL RANDOMLY TURN ON AND I GET A 'DOOR AJAR' NOTIFICATION WHEN THE DOORS ARE CLEARLY CLOSED. IT IS ALARMING AND HAS ALMOST CAUSED ACCIDENTS. WHEN I RESEARCHED THE PROBLEM ONLINE, IT IS AN EXTREMELY COMMON PROBLEM THAT HAS CAUSED NUMEROUS ACCIDENT AND COST FLEX OWNERS THOUSANDS UPON THOUSANDS OF DOLLARS,ONLY TO HAVE THE PROBLEM REOCCUR IN 6 MONTHS TO A YEAR. I RECENTLY CONTACTED MY FORD DEALERSHIP AND THEY TOO ARE AWARE OF THE PROBLEM AND STATED THAT IT IS A VERY COMMON PROBLEM IN FLEX'S AND I WILL PROBABLY HAVE TO REPLACE THE LATCH SYSTEM EVERY 2-3 YEARS. AT $350-500 A LATCH THIS IS A VERY DANGEROUS AND COSTLY PROBLEM TO BE SO COMMON. THE SOLUTION MOST SUGGEST IS TO GROUND THE WIRE GOING TO THE LATCH, WHICH WILL TOTALLY DEFAULT THE SENSOR ALL TOGETHER AND MAKE THE VEHICLE THINK THAT THE DOORS ARE CLOSED AT ALL TIMES, WHICH IS ALSO VERY UNSAFE.

• 12/08/2017· STEERING

  "FORD FLEX POWER STEERING ASSIST FAILURE AND TRAC CONTROL MALFUNCTION. THE EPAS MOTOR ON MILLIONS OF VEHICLES ARE FAILING AND VERY DANGEROUS FOR FLEX OWNERS. I HAVE FOUND THAT FROM RESEARCH ON THIS ISSUE THAT THE EPAS MOTOR IS ACTUALLY OVERHEATING AND BURNING UP THE ELECTRIC MOTOR. FORD MANUFACTURER HAS DELIBERATELY LIED TO NHTSA ABOUT WHAT THE ACTUAL PROBLEM IS. THIS IS A VERY UNSAFE CONDITION FOR WHICH THEY PRESENTED A RECALL ON CERTAIN 2013 VEHICLES. I SPOKE WITH MY LOCAL DEALERSHIP ABOUT THE ISSUE AND THEY RESPONDED THAT MY VIN NUMBER DOES NOT FALL IN THE CAMPAIGN OR TECHNICAL SERVICE BULLETINS. CAMPAIGN FOR THE RECALL IS EXACTLY WHAT IS GOING ON WITH MY VEHICLE BUT YET FORD WANTS TO CHARGE ME MONEY FOR THE REPAIRS AND DIAGNOSTIC WHEN THEY ARE WELL AWARE THAT THIS IS A MANUFACTURER ISSUE. IT IS A VERY UNSAFE CONDITION WHICH HAS KILLED AND INJURED PEOPLE. THEY JUST HAVEN'T GOTTEN TO THE POINT TO WHERE THEY ADMIT THAT IT IS ON WAY MORE VEHICLES THAN THEY ARE ADMITTING TO. I AM VERY DISAPPOINTED THAT NHTSA IS NOT FORCING FORD TO REPAIR THE VEHICLES THAT HAVE THE SYMPTOMS OF THE EXACT RECALL ON A CASE-BY-CASE BASIS AT VERY LEAST. I WAS TRAVELING AROUND 70 MILES AN HOUR DOWN INTERSTATE I-40 WHEN SYSTEM FAILED AND ALMOST FLIPPED MY VEHICLE. HOW CAN A DEALERSHIP NOT BE RESPONSIBLE FOR THIS OR HOW MANY PEOPLE HAVE TO DIE BEFORE THEY DO TAKE RESPONSIBILITY? RECALL NUMBER IS 15 S18 OR 15V340000.

• 12/07/2022· LATCHES/LOCKS/LINKAGES

  The contact owns a 2013 Ford Flex. The contact stated that she attempted to close the rear passenger’s side door however, the door failed to latch. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the latch failed and needed to be replaced. The vehicle was repaired. The contact then stated that while closing the front driver’s side door, the door failed to latch securely. Due to the failure, the contact had to drive holding the door closed. The vehicle was taken back to the dealer where it was diagnosed that the latch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided the number to call the NHTSA Hotline. The failure mileage was approximately 84,000. The VIN was unavailable.

• 12/07/2017· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE ENTERING THE VEHICLE AND INSERTING THE KEY INTO THE IGNITION, THE VEHICLE WOULD NOT START. THE CONTACT HAD THE VEHICLE TOWED TO REDLANDS FORD INC (1121 W COLTEN AVE, REDLANDS CA 92374) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS AT THE DEALER BEING REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 34,000.

• 12/06/2018· STEERING

  TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE ATTEMPTING TO PULL OUT OF THE DRIVEWAY AT APPROXIMATELY 3 MPH, THE POWER STEERING ABILITY BECAME DIFFICULT AND "SERVICE POWER STEERING ASSIST" ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO SMART FORD (1103 MARTIN LUTHER KING BLVD, MALVERN, AR 72104) WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR FAILED AND NEEDED REPLACEMENT. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

• 12/06/2018· UNKNOWN OR OTHER

  2013 FORD FLEX - DOOR SENSOR KEEPS THINKING IT IS OPEN. IT PREVENTS US FROM LOCKING THE DOORS, BOTH PARKED AND IN MOTION. IT ALLOWS OUR CHILDREN TO OPEN THE DOOR WHILE IN MOTION BECAUSE THE DOORS WILL NOT LATCH. ISSUE IS STILL OCCURRING. IT STARTED A MONTH AGO (START OF NOVEMBER 2018), HOWEVER NOW DOES IT EVERY TIME WE ARE GETTING INTO OR OUT OF THE VEHICLE. ISSUE WHILE DRIVING: WHEN THE SENSOR IS SENSING THE DOOR AS "OPEN", THE LIGHTS IN THE VEHICLE STAY ON FOR OVER 3 MILES OF DRIVING BEFORE THEY WILL TURN OFF - DAY OR NIGHT CAUSING A BACK LIGHT (GLARE) ISSUE DURING NIGHT TIME DRIVING. ISSUE WHILE STOPPED, BOTH SITTING IN AND OUTSIDE OF THE VEHICLE: THE LIGHTS DO NOT TURN OFF AND RUNS DOWN THE BATTERY OF MY VEHICLE. I TIMED THE LIGHTS AFTER GETTING HOME AND AT 30 MINUTES I STOPPED THE TIMER - AS IT WAS TOO COLD TO CONTINUE. I HAD TO SHUT THE DOOR 12 TIMES BEFORE THE SENSOR FINALLY SENSED A "CLOSED" DOOR AND SHUT THE LIGHTS OFF.

• 12/06/2016· POWER TRAIN

  MY FLEX PTU SYSTEM HAD TO BE REPLACED BECAUSE IT FELL APART WHILE DRIVING. THERE WAS A LOUD BOOM THEN SEVERE GRINDING WHEN I TRIED TO ACCELERATE. THE MECHANIC SAID THIS PROBLEM HAPPENS SO OFTEN WITH FORD AWD SYSTEMS THAT THEY KEEP THEM IN STOCK. I CONTACTED FORD DIRECTLY TO COMPLAIN AND FIND WHAT THEY WERE DOING ABOUT IT. I WAS ADVISED THERE WAS NOTHING THEY COULD DO AND THAT I SHOULD FILE A COMPLAINT WITH YOU. THE COST TO REPAIR MY VEHICLE WILL BE $1500. THAT IS NOT A MINOR FIX AND I BELIEVE FORD SHOULD BE DOING SOMETHING ABOUT THIS. *TR

• 12/06/2016· ENGINE,FUEL/PROPULSION SYSTEM

  WHEN I PUT GAS IN THE GAS EITHER FILL UP OR EVEN JUST A CAP OFF ON THE GAS TANK, STARTING THE ENGIN IS DIFICULT. IT HESITATES, WHEN TRYING TO START, AND HAS A ROUGH VERY ROUGH IDLE. ACCELARATION IS NOT A PROBLEM ONCE WE GET GOING, BUT IT IS THE INITIAL STARTING OF THE VEHICLE THAT IS A PROBLEM.

• 12/06/2015· ELECTRICAL SYSTEM,STRUCTURE

  DRIVER'S DOOR LATCH AJAR SENSOR MALFUNCTIONING. READS "DOOR AJAR" WITH DOOR CLOSED, HAVE TO REPEATEDLY OPEN AND CLOSE DOOR TO GET THE SENSOR TO READ CORRECTLY, AND IT STILL DOESN'T WORK RIGHT. ANTI-THEFT ALARM WILL RANDOMLY ENGAGE BECAUSE THE SENSOR IS TELLING IT THE DOOR IS OPENED AFTER BEING LOCKED.

• 12/05/2019· SUSPENSION

  WHILE DRIVING IN SNOW/ICE CONDITIONS ON CITY STREETS IN BIG BEAR CA, ICE BUILT UP IN THE RIGHT REAR TOE LINK CHASSIS POCKET CAUSING THE TOE LINK TO FLEX AND EVENTUALLY BREAK LEAVING US STRANDED IN BIG BEAR... THIS PART IS PART OF A RECALL IN THE CANADIAN PROVINCE S BASED ON THE SAME WEATHER CONDITIONS... THE LAST ATTACHED PHOTO SHOWS THE FORD OEM UPGRADED LINK THAT WE HAD TO GET AS A REPLACEMENT OUT OF OUR OWN POCKET

• 12/05/2015· UNKNOWN OR OTHER

  DOOR LATCH ASSEMBLY AND SENSOR. I HAVE REPLACE 2 ALREADY WITHIN 1 YR AND NOW NEEDING TO REPLACE ANOTHER ONE. THIS IS RIDICULOUS. I AM OUT OF WARRANTY BECAUSE OF MY MILES NOT BECAUSE OF THE YEAR OF THE VEHICLE.

• 12/03/2019· ENGINE,FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE DRIVING 30 MPH ON THE HIGHWAY, THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND HAD IT TOWED BACK TO HER HOME. THE CONTACT ATTEMPTED TO FILL UP THE FUEL TANK AND NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. THE FUEL INLET WARNING INDICATOR ILLUMINATED WHEN THE CONTACT ATTEMPTED TO RESTART THE VEHICLE ON THE SIDE OF THE HIGHWAY. RON CARTER FORD (8837 3005, FM 528 RD, ALVIN, TX 77511, (281) 715-7318) WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT JUST BOUGHT THE VEHICLE USED THREE MONTHS AGO. THE MANUFACTURER ALSO STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 93,000.

• 12/02/2025· STEERING,ELECTRICAL SYSTEM

  Power steering. While I was driving in my neighborhood the power steering went out and I could not make a turn. It locked up while driving. I could have got into a head on collision/accident becasue the road turns. Yes, I reported it to Ford and they told me my flex did not have a recall despite the ford website stating that some 2013 ford flex are affected. The description of 15s18 sterring recall matches my same issue and it poses a serious safety hazard. Yes, i took it to a mechanic at an auto shop and her is telling me that he can't fix recalls. At the time of the accident, i got No pre warning just the message that states: "Steering Lock Malfunction Service Now: The steering lock system has detected a condition that requires service." This happened on or around 11/23/25. I am requesting that Ford pay for my power steering to be fixed.

• 11/30/2018· STEERING

  THE STEERING IS OFF WHEN TURNING LEFT, RIGHT AND WHILE SWITCHING LANES. IT'S VERY HARD TO STEER. IT FEELS LIKE A MANUAL SHIFT DRIVING VEHICLE INSTEAD OF AUTOMATIC, HAVING TO USE BOTH HANDS JUST TO TURN THE VEHICLE. IT WASN'T AS HARD AT FIRST TO STEER. YOU COULD TELL THE STEERING WAS OFF BUT STILL MANAGEABLE. HOWEVER, NOW IT'S AT THE POINT IT'S A MUST TO GET FIXED. WE SCHEDULED AN APPOINTMENT TO GET IT FIXED NOW. I CALLED THE FORD DEALERSHIP BUT WAS INFORMED THERE ARE NO SPECIFIC RECALLS FOR MY VIN#. I THEN CALLED THE NUMBER ON OWNER.FORD.COM WEBSITE AND SPOKE WITH A REPRESENTATIVE WHO ALSO SAID MY VIN DOESN'T HAVE ANY RECALLS FOR STEERING. I REFERENCED THE RECALL# 15S18 AS IT RELATES TO MY PROBLEM. I WAS STILL INFORMED MY VIN# IS NOT A PART OF THE RECALL BUT TO HOLD ONTO MY RECEIPT FROM THE REPAIR SHOP IN CASE IT HAPPENS TO BECOME PART OF THE RECALL THEN WE CAN FORWARD THEM THE RECEIPT. *TR

• 11/30/2017· ENGINE

  TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT THE VEHICLE STALLED THREE TIMES WITHOUT WARNING. ADDITIONALLY, THE VEHICLE WOULD NOT START. THE CONTACT CALLED A LOCAL DEALER (MCDONALD FORD, 6790 MIDLAND RD, FREELAND, MI 48623) AND WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER A RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND OPENED CASE NUMBER: CAS13638921. THE MANUFACTURER STATED THAT IF THE VEHICLE FAILED, THE CONTACT SHOULD TAKE IT TO A LOCAL DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 75,000.

• 11/30/2016· STRUCTURE,ELECTRONIC STABILITY CONTROL (ESC)

  SENSOR INDICATES ONE OF THE BACK SEAT DOORS IS AJAR, BUT IT APPEARS TO BE CLOSED. REPEATED CLOSING OF DOOR DOES NOT RESOLVE ISSUE. CAR ALARM SOUNDS WHEN VEHICLE THINKS DOOR IS AJAR. INSIDE LIGHTS STAY ILLUMINATED WHEN DRIVING. THIS PROBLEM HAS BEEN OCCURRING OVER THE LAST FEW WEEKS. I SEE THAT THERE HAS BEEN A RECALL ON OTHER MODELS, I'VE SEEN SIMILAR COMPLAINTS FROM FLEX OWNERS ONLINE, AND I BELIEVE THE FLEX SHOULD BE RECALLED AS WELL, ESPECIALLY SINCE THEY ARE FAMILY VEHICLES AND OFTEN (AS IN MY CASE) ARE USED TO TRANSPORT MULTIPLE CHILDREN. *TR

• 11/28/2023· STEERING

  2013 Ford Flex lost power steering, had to tow the vehicle home. Called Ford my vehicle was not covered under the recall, paid over $2000 to have it repaired.

• 11/28/2017· STEERING,ELECTRONIC STABILITY CONTROL (ESC)

  REPEATED STEERING FAILURES. INITIAL FAILURE (SPRING 2016) OCCURRED SEVERAL MONTHS AFTER COLLISION REPAIR (DECEMBER 2015) DONE AT DEALER SERVICE DEPARTMENT. REPAIRED VEHICLE CAME BACK WITH TIGHTER STEERING THAN PREVIOUSLY EXPERIENCED. FAILURE IN SPRING 2016 INVOLVED COMPLETE LOSS OF POWER STEERING UPON STARTUP OF VEHICLE. SHUT DOWN AND RESTART DID NOT RESTORE POWER STEERING OPERATION. STEERING GEAR REPLACED BY DEALER SERVICE DEPARTMENT. SECOND FAILURE (SPRING 2017) INVOLVED LOSS OF TRACTION CONTROL, STABILITY CONTROL, CRUISE CONTROL DUE TO FAILURE OF POWER STEERING CONTROL MODULE. POWER STEERING CONTROL MODULE REPLACED BY DEALER SERVICE DEPARTMENT. THIRD FAILURE (NOVEMBER 28, 2017) IS LOSS OF POWER STEERING GEAR UPON VEHICLE STARTUP. SHUT DOWN AND RESTART RESTORED POWER STEERING OPERATION.

• 11/28/2016· AIR BAGS

  THE AIRBAG LIGHT CAME ON AND I TOOK THE VEHICLE TO THE SERVICE DEPARTMENT AND WAS TOLD THAT THE INTERFACE MODULE PART # 18A812 NEEDED TO BE REPLACED. MY VEHICLE HAS NEVER BEEN IN A COLLISION WHERE THE AIRBAG DEPLOYED. MY VEHICLE HAS BEEN AT THE SERVICE DEPT FOR THE 2 1/2 MONTHS NOW AND NO ONE CAN TELL ME WHEN THE PART IS COMING AND WHY IT IS NOT INCLUDED IN THE RESTRAINT SYSTEM WARRANTY SINCE IT IS CONSIDERED AN AIRBAG MODULE. I CAN NOT DRIVE THE VEHICLE SINCE THE DEALERSHIP CAN NOT GUARANTEE THAT IT IS SAFE FOR ME TO DRIVE SINCE THEY DO NOT KNOW IF THE AIRBAGS WILL DEPLOY IF I AM IN A COLLISION OR JUST DRIVING AROUND. *TR

• 11/22/2014· STRUCTURE

  THE DRIVER DOOR IS SHOWING AJAR. IT YOU SLAM THE DOOR MULTIPLE TIMES, THE LIGHT WILL GO OFF. EVERY TIME YOU PUT ON BRAKES, THE CHIMING GOES OFF AND LIGHT COMES ON. I HAVE SEEN THIS HAS BEEN A RECURRING PROBLEM AND FORD WILL NOT ISSUE A RECALL. MUST REPLACE ENTIRE LATCH SYSTEM TO CORRECT THE PROBLEM. *TR

• 11/20/2020· ENGINE

  WATER PUMP FAILED IN THE INTERNAL ENGINE PART ON 2013 FORD FLEX. A KNOWN PROBLEM BY FORD MOTOR CO FOR YEARS AND FORD REFUSES TO ISSUE A RECALL. BECAUSE THE WATER PUMP IS AN INTERNAL PART OF THE MOTOR, THE COST TO REPAIR IS OVER $2000 .

• 11/20/2018· STEERING,AIR BAGSCrash

  THERE IS A RECALL ON THE ELECTRONIC POWER STEERING FOR CERTAIN 2013 FORD FLEX'S. RECALL 15S18. THE MANUFACTURER SAYS THAT MINE DOES NOT QUALIFY FOR THE BUT THE VEHICLE HAS THE SAME SYMPTOMS AS THE RECALL CAMPAIGN. THE POWER STEERING WAS OUT ON MY VEHICLE, IT LOCKED UP AROUND A CURVE WHEN I WAS DOING ABOUT 50 MILES AN HOUR. THE VEHICLE WOULD NOT TURN RIGHT, I CROSSED A LANE OF ONCOMING TRAFFIC AND HIT A TREE ON SUNDAY 11 18 18. I WAS ON HIGHWAY 70 IN KINGSTON TENNESSEE, HEADED EASTBOUND. THE STEERING WHEEL IS VERY LOOSE AND IN A BIND AS IF THE STEERING WHEEL WAS LOCKED WITH KEYS OUT OF THE IGNITION. I HIT THE TREE DOING ABOUT 35 MPH TO 40 MPH WHEN STEERING BECAME INOP AND THE AIRBAGS DID NOT EVEN DEPLOY. I WAS FORTUNATE ENOUGH TO BE ABLE TO SLOW THE VEHICLE FROM 50 MPH TO AROUND 35 MILES AN HOUR BEFORE STRIKING THE TREE OR COULD'VEBEEN MUCH WORSE. I SUSTAINED SHOULDER INJURY AND CAN ONLY HOPE THAT THIS VEHICLE BECOMES PART OF THE RECALL BECAUSE I COULD HAVE VERY EASILY HIT SOMEBODY HEAD ON AND KILLED SOMEONE OR MYSELF. VERY THANKFUL TO BE HERE BUT THIS COULD HAVE EASILY COST ME MY LIFE.

• 11/19/2013· STEERING,SUSPENSION,STRUCTURE,WHEELSCrash

  I WAS TURNING A CORNER AND SOMETHING POPPED AND THE CAR WOULD NOT STEER. THE ONLY THING THAT STOPPED THE CAR WAS THE CURVE, AS I WAS MAKING THE TURN, AND THAT CAUSED A LOT OF DAMAGE. SUTTON FORD LINCOLN IN MATTESON, IL SAID THEY WOULD NOT REPAIR THE DAMAGES CAUSED BY THE LEMON-FORD-FLEX THAT WAS SOLD TO ME BECAUSE THE VEHICLE WAS 300 MILES OUT OF THE WARRANTY. SUTTON FORD LINCOLN IN MATTESON, IL THAN SAID IT WOULD HAVE TO BE REPORTED TO INSURANCE. SO I REPORTED IT TO INSURANCE AND THE REPAIR SHOP, THAT WAS REPAIRING THE DAMAGES, SAID THEY FOUND DAMAGE TO THE RADIATOR (1,500 DOLLARS WORTH OF DAMAGES) WHICH COULD NOT HAVE BEEN CAUSED BY THE CAR HITTING THE CURVE. AND THAT IT LOOKED LIKE SUTTON FORD LINCOLN IN MATTESON, IL RAISED THE CAR INAPPROPRIATELY AND CAUSED THE RADIATOR DAMAGE. THE REPAIR COMPANY SAID, SINCE THE ORIGINAL PLACE WHERE THE FLEX WAS TOWED TO (SUTTON FORD LINCOLN IN MATTESON, IL) WAS LOCATED RIGHT BEHIND THEM (ACROSS THE ALLEY), SUTTON FORD LINCOLN IN MATTESON, IL CAUSED THE DAMAGE. AND OF COURSE, SUTTON FORD LINCOLN IN MATTESON, IL DENIED IT AND WOULD NOT PAY FOR THE DAMAGES. BUYER BEWARE - DO NOT DO BUSINESS WITH SUTTON FORD LINCOLN IN MATTESON, IL. BUYER BEWARE - DO NOT BUY A FORD AND IF YOU DO, DO NOT GO TO SUTTON FORD LINCOLN IN MATTESON, IL. *TR

• 11/18/2020· STEERING

  WHILE DRIVING, WARNING NOTICE CAME ON SAYING STEERING ASSIST FAULT, THAT VERY MOMENT THE STEERING LOCKED ON ME AND WAS UNABLE TO TURN.

• 11/18/2017· EXTERIOR LIGHTING

  MY INTERIOR DOME LIGHTS COME ON OFTEN WHEN I ATTEMPT TO DRIVE CAR AT NIGHT MAKING IT IMPOSSIBLE TO SEE. THEY DO GO OFF AFTER I DRIVE FOR A SHORT DISTANCE. THIS VERY DANGEROUS.

• 11/18/2016· ELECTRICAL SYSTEM,STRUCTURE

  TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE OPERATING THE VEHICLE, A WARNING INDICATOR ERRONEOUSLY ILLUMINATED, WHICH INDICATED BOTH THE REAR DRIVER AND PASSENGER SIDE DOORS WERE UNSECURED. THE INTERIOR LIGHTING REMAINED ILLUMINATED INSIDE THE VEHICLE. UPON INSPECTION, IS WAS ALSO DISCOVERED THAT THE BATTERY CABLE LINE WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. UPDATED 01/10/2017*CT CONSUMER STATED BOTH RIGHT AND LEFT PASSENGER DOORS IN BACK DOES NOT CLOSE RIGHT. UPDATED 7/9/18*JB *TR

• 11/17/2017· UNKNOWN OR OTHER

  THE DOOR AJAR SENSOR ALWAYS THINKS THE DOOR IS AJAR. THIS MEANS THE DOORS WON'T LOCK WHEN THE CAR IS RUNNING, AND THE DOME LIGHT STAYS ON WHEN DRIVING. IT CAN ALSO CAUSE THE ALARM TO GO OFF IF THE CAR IS LOCKED.