2012 Toyota Tacoma

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2019· ENGINE

  FAILURE OF THE SECONDARY AIR INJECTION SYSTEM P2440 AND P2442, WHILE THE VEHICLE WAS MOVING ONTO A CITY STREET FROM A PARKING LOT. WHEN ACCELERATING IMMEDIATELY THERE WAS A DECREASE IN POWER AND THE CHECK ENGINE LIGHT ALONG WITH THE "TRAC OFF" LIGHT ILLUMINATING SIMULTANEOUSLY. THE VEHICLE HAS A NOW MAXIMUM SPEED OF AROUND 55 MPH AND EXTREMELY SLOW TO ACCELERATE BEING ALMOST DANGEROUS ON BUSIER ROADS. AFTER BEING CHECK OUT BY A THE DEALER IT WAS FOUND TO BE THE SECONDARY AIR INJECTION SYSTEM WHICH IS COVERED BY AN EXTENDED WARRANTY BUT PARTS ARE ON BACK-ORDER.

• 12/30/2016· ENGINE

  I GOT THE ENGINE LIGHTS ON IN THE MORNING STARTING THE TRUCK ON NOV 3, AND TRUCK WENT INTO LIMP MODE. GOT IT HOME AND LET IT SIT FOR A BIT AND THEN IT SEEMED TO BE OKAY ACCELERATING BUT THE ENGINE LIGHTS WERE STILL ON. TOOK IT TO TOYOTA AND WAS READING THE DREADED P2442 SECONDARY AIR INJECTION SYSTEM CODE. THEY CLEARED THE CODE AND DROVE IT AROUND; CLEARED AGAIN THEY DEEMED IT OKAY AND CHARGED ME $60 FOR THE CODE READ. LEAVE TO DRIVE TO WORK AGAIN THIS MORNING AND BAM, THE LIGHTS BACK ON AND THE THING IS BACK INTO LIMP MODE WITH BARELY ANY POWER TO THE ENGINE. HAD TO DRIVE THIS TRUCK IN THIS UNSAFE CONDITION BACK TO MY HOUSE. I READ SO MUCH ONLINE ABOUT HOW MANY PEOPLE ARE AFFECTED WITH THIS SAME DEFECTIVE PART AND TOYOTA QUOTED ME $2300 CAD + 13% TAX TO FIX IT AND REPLACE THE SECONDARY AIR INJECTION PUMP/VALVE. NOT COVERED UNDER ANY WARRANTY NOR MY EXTRA CARE PROTECTION PLAN I PAID FOR.

• 12/30/2016· ENGINE

  AIR INJECTION PUMP AND DIVERTER VALVE ASSEMBLY FAILED CAUSING VEHICLE TO ENTER LIMP MODE. VEHICLE WAS MOVING AT LOW SPEED FROM A FRESH START UP. TOYOTA HAS RECOGNIZED THE ISSUE ON THE TUNDRA TRUCK AND EXTENDED 150K MILE WARRANTY ON THE PART. THEY HAVE NOT EXTENDED THE SAME CONSIDERATION ON THE TACOMA. BASED ON RESEARCH AND DISCUSSION WITH DEALER IT IS A KNOWN ISSUE ON THE 2012 TACOMA. COST TO REPAIR I WAS $1484.14. *TR

• 12/29/2016· UNKNOWN OR OTHER,ENGINE

  HEADED TO WORK TO FIND CHECK ENGINE LIGHT ILLUMINATED. TRUCK HAS LESS THAN 41,000 MILES. WENT TO AUTOZONE, CODE READER PROVIDED P2442 AND P2440 ERRORS RELATED TO THE SECONDARY AIR INJECTION SYSTEM VALVES. FOLLOWED UP WITH LOCAL TOYOTA DEALER. DEALER RAN DIAGNOSTIC AND FOUND SECONDARY AIR INJECTION SYSTEM VALVES STUCK OPEN IN BANKS 1 AND 2. DEALER WANTS TO REPLACE PARTS 17600-0P040: PUMP ASSEMBLY; 25710-31022: VALVE ASSEMBLY; AND THE 4 RELATED GASKETS, PART 17377-31010. QUOTE WAS FOR ALMOST $2400. AGAIN, THE VEHICLE IS 2012, LESS THAN 41K MILES! RESEARCHING THE TACOMA FORUMS ONLINE, THIS APPEARS TO BE A COMMON PROBLEM WITH THIS GENERATION MODEL AND MORE EVEN MORE SO WITH 2012'S. ONE OF THE DEALER'S SERVICE ADVISORS INFORMED ME THAT THIS IS ALSO A COMMON PROBLEM WITH TUNDRAS. FURTHERMORE, WHILE DRIVING, THE VEHICLE WOULD GO IN AND OUT OF "LIMP MODE" AND I HAD NO WARNING AS TO WHEN IT WOULD OR WOULD NOT BE IN THIS MODE, OTHER THAN BY THE WAY THE VEHICLE WAS HANDLING. LIMP MODE WOULD ONLY ALLOW TRANSMISSION TO SHIFT INTO 2ND OR 3RD AND NO MORE THAN 30 MPH, LESS IF CLIMBING AN INCLINE. AT OTHER TIMES, VEHICLE WOULD DRIVE NORMALLY. THE SWITCHING IN AND OUT OF THIS PROTECTIVE MODE SEEMS PARTICULARLY DANGEROUS. *TR

• 12/29/2016· ELECTRICAL SYSTEM

  SECONDARY AIR INJECTION VALVE STUCK CODES P2440,P2442. TRUCK GOES INTO LIMP MODE AND YOU CAN ONLY GO A MAX OF 40 MPH.TOYOTA KNOWS ABOUT THESE ISSUES AND DOES NOTHING ABOUT IT

• 12/28/2024· POWER TRAIN

  My truck started having a vibration when driving around 45-55 mph. This problem first became noticeable when it had about 115,000 miles on it. Over time the speed that the vibration became noticeable at gradually increased. By 125,000 miles on the truck, it was vibrating hard between 60 and 70 mph. The dealership determined that the problem was that the drive shaft was out of balance and that it had to be replaced. They replaced the drive shaft, but this doesn't seem like a problem that should creep up with that relatively few miles on the vehicle, and I have read that if the drive shaft actually fails, it can severely damage the vehicle and potentially cause injury.

• 12/28/2016· ENGINE

  MY 2012 TOYOTA TACOMA CHECK ENGINE AND TRACTION CONTROL LIGHT CAME ON. TRUCK WENT IN LIMP MODE, WHICH WAS VERY UNSAFE. TOOK MY TRUCK TO AUTO ZONE TO HAVE THE CODES READ. MY TRUCK CODE WAS P2442. AIR INJECTION SYSTEM SWITCH VALVE STUCK OPEN. THIS IS A KNOWN ISSUE TO TOYOTA TUNDRA TRUCKS BUT NOT FOR THE TACOMA.

• 12/28/2016· ENGINE,FUEL/PROPULSION SYSTEM

  DRIVING ON THE STREET TO WORK ONE MORNING, THE TRAC OFF AND CHECK ENGINE LIGHTS BOTH SUDDENLY APPEARED. I THEN NOTICED THAT MY TRUCK WAS NOT ABLE TO ACCELERATE PAST ~40 MPH. GOING UPHILL, MY TRUCK WAS LIMITED TO ONLY ~20 MPH. MY TRUCK WENT INTO THIS "SAFE MODE." I CONNECTED AN OBD DEVICE AND THE CAME UP WITH THE FOLLOWING TWO CODES: P2440 AND P2442. THE CODES REFER TO "SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN" FOR BANKS 1 AND 2, RESPECTIVELY. I DID SOME FURTHER RESEARCH ON THE CODES, AND IT TURNS OUT THIS IS A COMMON ISSUE ON 2012 TACOMAS. APPARENTLY, THE VALVE FOR THE SECONDARY AIR INJECTION SYSTEM IS STUCK OPEN DUE TO MOISTURE AND/OR CARB BUILD UP. I BELIEVE THIS IS A DESIGN/ENGINEERING ISSUE. PART REPLACEMENT COSTS ~$480 FOR EACH VALVE ASSEMBLY. LABOR CAN RANGE ANYWHERE BETWEEN $200-$500. IF THIS IS A KNOWN ISSUE THAT IS COMMON TO A LOT OF 2012 TACOMAS, THEN I BELIEVE TOYOTA SHOULD BE PROACTIVE SUCH AS RELEASING AN OFFICIAL RECALL OR EVEN IMPLEMENT SOME TYPE OF REIMBURSEMENT. NOTE THAT MY TRUCK HAS ~80,000 MILES ON IT. AS AN OWNER, I SHOULDN'T SUFFER FROM AN ENGINEERING DESIGN FLAW AND I SHOULDN'T BE FINANCIALLY RESPONSIBLE TO REPAIR/FIX THE ISSUE. ANY ASSISTANCE WOULD BE HELPFUL. THANK YOU AND HAPPY HOLIDAYS! *TR

• 12/28/2012· WHEELS

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THERE WAS A LOUD NOISE HEARD FROM UNDER THE VEHICLE. THE CONTACT LOOKED IN HIS REAR VIEW MIRROR AND SAW THAT THE SPARE TIRE WAS ROLLING DOWN THE STREET. THE CONTACT IMMEDIATELY PULLED OVER AND RETRIEVED THE TIRE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THEY WERE UNSURE AS TO WHY THE TIRE SEPARATED FROM THE VEHICLE. THE VEHICLE WAS REPAIRED BY RE-INSTALLING THE SPARE TIRE UNDER THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 9,700.

• 12/27/2018· STEERING

  MY STEERING SHAFT ROTTED AND SEIZED. I TOOK IT TO A DEALER AND THEY REPAIRED IT BUT CHARGED ME $536.02 TO FIX IT. WHEN I RESEACHED RECALLS THERE WAS ONE ON 5/12/12. I AM ASKING FOR MY MONEY BACK FOR THIS REPAIR

• 12/26/2017· UNKNOWN OR OTHER,ENGINE

  AT LESS THEN 50K MILES ON THE ODOMETER AND 900 MILES FROM HOME MY TRUCK DECIDED TO GET A CHECK ENGINE LIGHT AND TRAC OFF LIGHT CAUSED BY CODES P2440 AND P2442 AND P2445. MERRY CHRISTMAS TO ME. THESE CODES PUT ME INTO LIMP MODE WHILE ON THE FREEWAY IN SNOWY AND ICY CONDITIONS. I COULD NOT MAINTAIN SPEED WITH THE FLOW OF TRAFFIC AS I WAS TRYING TO GET TO THE SHOULDER WITH TRAFFIC ZOOMING ALL AROUND ME, DANGEROUS AND SCARY! TOYOTA WANTS $2000 TO REPAIR IT. INTERNET RESEARCH HAS SHOWN ME THAT IT IS A COMMON PROBLEM THAT TOYOTA FAILS TO RECOGNIZE FOR TACOMAS BUT HAS ISSUED A TSB AND EXTENDED WARRANTIES FOR TUNDRAS. SHAME ON TOYOTA. NOW I GET TO ENDURE THE COST OF REPAIR AFTER THE HOLIDAY SEASONS AND I'M SURE MY BOSS WILL LOVE TO HEAR I WONT BE RETURNING TO WORK ON TIME.

• 12/26/2016· ENGINE

  ENGINE CODE P2442 & P2440: SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE BANK 2. TRUCK ONLY HAS 40,000 MILES ON IT. DEALER WHAT $1800.00 TO MAKE REPAIRS. TOYOTA HAS A PROBLEM WITH THE PART AND THEY NEED TO FIX IT. NOTHING LIKE HAVING NUMEROUS FAILURES AND LEAVING THE CUSTOMER TO PAY FOR THE POOR ENGINEERED PART. *TR

• 12/24/2015· ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKESCrash

  BRAKES ON VEHICLE LOCK-UP AND ARE OVERLY SENSITIVE. ON MANY OCCASIONS WHEN DRIVING ON WET PAVEMENT AT SLOWS SPEEDS THE ABS ENGAGED AND LOCKED THE BRAKES WITH ONLY VERY LIGHT PRESSURE ON THE BRAKE PEDAL. ON ONE OCCASION WHEN DRIVING AT 10-15 MPH IN A PARKING LOT IN SNOW, A LIGHT TOUCH TO THE BRAKE LOCKED UP THE BRAKES CAUSING THE VEHICLE TO BECOME UNSTABLE AND CRASH. I HAVE HAD FOUR OTHER TOYOTA TRUCKS, THREE OF THEM TACOMAS AND NONE OF THEM HAD THIS BRAKING ISSUE. BARELY PRESSING THE BRAKES SHOULDN'T CAUSE THEM TO LOCK UP WHICH CAUSES THE VEHICLE TO BECOME VERY UNSTABLE. LUCKILY IT DOES IT MORE OFTEN AT LOW SPEEDS. IT'S A MAJOR SAFETY CONCERN AS THE VEHICLE BECOMES UNDRIVABLE.

• 12/23/2016· POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

  2012 TACOMA WITH 37,00 MILES: WHILE LEAVING A PARKING LOT AND TRYING TO ACCELERATE ON TO A BUSY HIGHWAY, (60MPH SPEEDS), TRUCK WOULD NOT ACCELERATE AND "CHECK ENGINE" AND "TRAC OFF" LIGHTS ILLUMINATED. VEHICLE WENT INTO "LIMP MODE" AND WOULD NOT GO FASTER THAN 35 MPH. I HAD TO QUICKLY PULL OFF THE ROAD AS TO NOT CAUSE AN ACCIDENT. IF THIS HAD THIS OCCURRED WHILE TRAVELING AT NORMAL HIGHWAY SPEED (60 MPH+), WOULD DEFINITELY BE IN A WRECK DUE TO THE SUDDEN DOWNSHIFT AND DECELERATION. I TOOK VEHICLE TO LOCAL AUTO PARTS STORE AND RECEIVED THE CODE P2442: SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN BANK 2. FROM RESEARCHING, THIS IS A KNOWN PROBLEM WITH 2012 TACOMAS, AND HAD PREVIOUSLY BEEN AN ISSUE WITH OLDER TUNDRAS, WHICH TOYOTA ISSUED A TSB FOR. TOYOTA REFUSES TO REPAIR THIS UNDER WARRANTY (EITHER POWERTRAIN OR FEDERAL EMISSIONS) EVEN THOUGH THE FAILED PART IS DIRECTLY TIED TO THE EMISSIONS SYSTEM! THE SYSTEM IS USED TO PUMP ADDITIONAL AIR INTO THE EXHAUST MANIFOLD UPON STARTUP TO DILUTE THE OVER-RICH CONDITIONS THAT LEAD TO INCREASED POLLUTION. (HOW IS THAT NOT AN EMISSIONS RELATED PART?) THE FAILURE OR WARPING OF THE ONE-WAY CHECK VALVE CAUSES HOT EXHAUST GASES TO BACKFLOW INTO THE SOLENOID, AND MELTING THE GASKETS. THIS ENDS UP BLOCKING THE SEALING PLATE AND CAUSING IT TO REMAIN IN THE OPEN POSITION. THE DANGER IS THAT THE HOT EXHAUST IS THEN FED INTO A PLASTIC AIR PUMP CAUSING IT TO POTENTIALLY MELT OR CATCH FIRE! THE FACT THAT THIS FORCES THE VEHICLE INTO "LIMP MODE" IS ALSO A HUGE SAFETY CONCERN AS IT WILL NOT ALLOW THE VEHICLE TO TRAVEL ABOVE 35 MPH AND COULD LEAD TO SERIOUS ACCIDENTS IF TRAVELING AT HIGH SPEED ON THE INTERSTATE OR HIGHWAY DUE TO THE UNEXPECTED, SUDDEN DECELERATION. FAILED ASSEMBLY IS TOYOTA PART NUMBER : 25710-31020. THIS PART NUMBER HAS BEEN SUPERSEDED BY P/N: 25710-31022 AND TOYOTA CHARGES BETWEEN $1500-$3200 TO REPLACE. *TR

• 12/22/2017· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE

  ALMOST LOST CONTROL OF VEHICLE WHEN THE TRUCKS PERFORMANCE JUMPED INTO LIMP MODE "TRAC OFF" AS I WAS DRIVING. LOSS OF SPEED AND PERFORMANCE CAUSED ME TO BE A DRIVING HAZARD. 2 VENDORS TODAY FOUND THE CODES P2440 AND P2442, WHICH APPEAR TO HAVE TRIGGERED MY TRUCK INTO "TRAC OFF" AND "CHECK ENGINE" LIGHT ON. MODE CAUSES MY TRUCK TO ONLY DRIVE ABOUT 45 SIGNIFICANTLY IMPACTS PERFORMANCE AND DANGEROUS TO DRIVE. THIS IS A SAFETY HAZARD,I HAD NO WARNING THAT THE LOSS OF PERFORMANCE WAS GOING TO HAPPEN INITIALLY WHEN I WAS TRAVELING.THERE IS ANOTHER PROBLEM THAT APPEARS TO BE ON A LARGER SCALE.I HAVE BRIEFLY SCANNED THE INTERNET IN THE LAST HOUR AND SPOKE WITH VARIOUS VENDORS ABOUT THE PROBLEM & I HAVE CALLED MY DEALERSHIP & EVEN THE MAIN TOYOTA LINE AND EVERYONE IS AWARE OF THE ISSUE. THE CODES ARE P2440 & P2442. AFTER FINDING OUT THE CODES I LOOKED AT THE AIR INJECTION PUMP & I WAS ASTONISHED TO SEE THAT THE PUMP WAS COMPLETELY FULL OF WHAT, LIKE SOMEONE LITERALLY TOOK A WATERHOSE & FILLED IT UP. LOGICALLY, THIS IS WHY THE AIR INJECTION SWITCHING VALVES 1 AND 2 ARE BOTH STUCK OPEN ONE CODE FOR EACH OF THE VALVES. THE NEXT THING THAT IS UNUSUAL IS THAT THERE ARE AN INCREDIBLE AMOUNT OF PEOPLE HAVING THIS SAME PROBLEM BUT NO RECALL..THEN I FOUND THE TUNDRA RECALL FOR THE EXACT SAME PUMP ISSUE! IT IS PECULIAR, THAT A DIFFERENT MODEL TRUCK WITH THE SAME PUMP HAS THIS PROBLEM & NO RECALL OR REMEDY. FACT-TUNDRA IS A MORE EXPENSIVE TRUCK THAN TACOMA, IS TOYOTA FIXING PUBLIC RELATION ISSUES FOR THOSE MORE WELL OFF BECAUSE THEY KNOW HOW TO COMPLAIN TO THE RIGHT FOLKS OR CAUSE A BIG STIR AND THEY WILL HOLD OFF ON PULLING THE TRIGGER ON A "WARRANTY FIX OR RECALL" ON THE WORKING MANS TACOMA? THIS IS JUST AN OPINION BUT MY INTUITION TELLS ME THIS IS INTENTIONAL. THE FIX IS APPROX $2000 I AM STUCK DRIVING 45 MPH TILL THEN WITH SHADY STEERING & PERFORMANCE. #ACCOUNTABILITY #ME TOO

• 12/20/2022· UNKNOWN OR OTHER,SERVICE BRAKES,FUEL/PROPULSION SYSTEMCrash

  My truck lost drivability while I was going 60 I ran into a ditch to stop. It hads two codes . I took it in they replaced my rack n pinion. Check engine light came on . Mechanic said he could not work on it anymore because of the rust. To much corrosion he would be risking liability for other parts getting damaged because of all the rust. Took it to mike Shaw to have frame tested. It passed they said. But I can’t find a mechanic to work on it but mike Shaw and they’ll just keep charging for each item they don’t care.

• 12/18/2023· STRUCTURE

  Under the bottom of my truck, there is tons of rust. I know a lot of the trucks my year, make, and model has been recalled for rust on the body and other parts of the truck. I was told that a Toyota dealership should replace it with the amount it has, and now a hole has appeared but they only told me a price to fix everything that is rusted. Just puts my vehicle at risk driving it back and forth to work.

• 12/18/2016· ELECTRICAL SYSTEM,ENGINE

  WHEN I WAS LEAVING WORK THE OTHER NIGHT MY 2012 TACOMA WENT INTO LIMP MODE AND PRESENTED THE CEL AND TRAC OFF LIGHTS ON THE DASH. AFTER REVIEWING THE MANY BLOGS ON THE SUBJECT AND TAKING THE VEHICLE TO THE MECHANICS, I HAVE FOUND OUT THAT THE SECONDARY AIR VALVE IS LIKELY STUCK IN THE OPEN POSITION. THE MECHANIC HAS QUOTED ME A PRICE OF $1,142 ($780 FOR THE PART) TO REPLACE THE WHOLE SYSTEM (VALVE NOT SOLD SEPARATELY). I UNDERSTAND THAT THIS IS A COMMON PROBLEM WITH TUNDRAS/SEQUOIAS AND 2012 TACOS. HOWEVER, ONLY THE TUNDRAS ARE UNDER ANY TYPE OF WARRANTY. I BOUGHT A TACOMA BECAUSE THE LAST TWO TOYOTA'S HAVE RUN 300K MILES + WITH REGULAR MAINTENANCE. THIS TYPE OF EXPENSIVE REPAIR DUE TO POOR ENGINEERING IS LUDICROUS AND SHOULD BE A WARRANTY ISSUE. I GUESS TOYOTA WANTS TO BE TERRIBLE LIKE EVERYONE ELSE. GREAT. *TR

• 12/15/2014· POWER TRAIN

  MY 2012 TACOMA IS NOT SHIFTING PROPERLY. IT IS SHIFTING VERY HARD AND A BIT ERRATIC WHEN DRIVING, AND WHEN I AM COMPLETELY STOPPED AT A LIGHT, THE TRUCK WILL SOMETIMES VIOLENTLY SURGE FORWARD MAKING IT FEEL LIKE ANOTHER VEHICLE HAS HIT ME FROM BEHIND. IT DOES NOT HAPPEN ALL THE TIME, BUT IT SEEMS TO HAPPEN MORE WHEN IT IS COLD. I TOOK IT TO THE DEALERSHIP ONLY TO BE TOLD THEY COULD NOT REPLICATE IT, AND THIS IS NORMAL FOR A TOYOTA. THE DEALERSHIP ALSO SAID THAT TOYOTA IS AWARE OF THIS, ALL TOYOTAS DO IT (EVEN THE BRAND NEW ONES), AND NOTHING CAN BE DONE. MY TRUCK IS STILL COVERED BY THE TOYOTA 5 YEAR WARRANTY AND THE LIMITED LIFETIME WARRANTY OFFERED FROM THE DEALER WHEN I PURCHASED IT. I FEEL LIKE THEY ARE NOT HONORING THEIR WARRANTY. IF THIS IS TRUE AND TOYOTA IS NOT CORRECTING THESE ISSUES, GUESS I WON'T BE BUYING THAT 2015 4-RUNNER I REALLY WANT! *TR

• 12/12/2017· UNKNOWN OR OTHER

  SECONDARY AIR CONTROL VALVE FAILURE IN THE OPEN POSITION

• 12/09/2018· ENGINE

  THE CHECK ENG & TRAC OFF LIGHT CAME ON WHILE I WAS ON THE INTERSTATE AND ALMOST GOT STRUCK FROM THE VEHICLE BEHIND ME. MY TRUCK WENT INTO LIMP MODE & SLOWED DOWN TO 2500 RPMS & WOULDN'T GO ANY FASTER THAN 25 MPH!! THIS IS A HAZARD AS I HAVE READ OTHER COMPLAINTS ABOUT THIS HAPPENING TO OTHERS, IT IS A KNOWN ISSUE TO TOYOTA, THEY HAVE REPAIRED THE TUNDRA'S BUT SO FAR AM NOT SHOWING ANY RECALL ON THE TACOMA'S. ERROR P2442 SECONDARY AIR INJECTOR FAILURE. THIS IS THE 2ND TIME THIS HAS HAPPENED TO ME. SCARY! PLEASE BEWARE 2012 TACOMA OWNERS! MERRY CHRISTMAS TO ME! $2000 REPAIR!

• 12/09/2015· ENGINE

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING 55 MPH, THE VEHICLE SEIZED AND THE SPEED DECREASED TO 20 MPH. THE VEHICLE STALLED IN THE MIDDLE OF THE HIGHWAY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACURER WAS NOT NOTIFIED OF TH FAILURE. THE FAILURE MILEAGE WAS 68,000. THE VIN WAS NOT AVAILIABLE.

• 12/06/2017· FUEL/PROPULSION SYSTEM

  CODE P2443 VALVE STUCK CLOSED CAME UP WHEN MY "TRAC AND CEL" LIGHTS CAME UP ON THE DASH. THIS HAPPENED ON STARTUP. THIS CODE IS A FAILURE OF THE SECONDARY AIR INJECTION SWITCHING VALVE STUCK CLOSED. THIS CONDITION CAN LEAD TO LOST POWER WHEN DRIVING CALLED A "LIMP MODE" AND IS OCCURRING ON TOYOTA TACOMA"S AT AROUND THE 50K MILE MARK AS I HAVE FOUND ON THE TACOMA WORLD WEBSITE. THIS ISSUE HAS ALSO BEEN NOTED ON THE TOYOTA TUNDRA AS WELL AND A TSB HAS BEEN ISSUED TO FIX THIS PROBLEM BUT NOT FOR THE TACOMA. I HAVE NOTED THAT MY POWER HAS DIMINISHED SINCE THE LIGHTS CAME ON (3 DAYS). I CHECKED WITH MY TOYOTA DEALER AND THEY SAY THEY HAVE NO HISTORY OF THIS HAPPENING. TACOMA OWNERS SAY THIS ISSUE IS WELL KNOWN AND TOYOTA IS FAILING TO ADDRESS A FIX. THE LOSS OF POWER CAN OCCUR ANYTIME AND IF IT HAPPENS ON A BUSY INTERSTATE OR HIGHWAY CAN RESULT IN ACCIDENTS.

• 12/05/2018· FUEL/PROPULSION SYSTEM

  TOYOTA HAS A KNOWN ISSUE OF THE SECONDARY AIR INJECTION SWITCHING VALVE THAT IS FAULTY THAT CAUSES THE 2012 TACOMA TO GO INTO "LIMP MODE" EXPECTANTLY. I WAS GETTING ON THE FREEWAY AND THE TRUCK CUT OUT DOWN TO 25 MPH WHILE TRAFFIC WAS RAPIDLY APPROACHING ALMOST CAUSING AN ACCIDENT. THE ENGINE CODES SHOWN ARE THE TYPICAL P2440 AND P2442 AND HAS BEEN REPORTED NUMEROUS TIMES. PLEASE PROMPT TOYOTA TO RECALL THIS PART TO AVOID UNFORTUNATE ACCIDENTS OR DEATH DUE TO A KNOWN ISSUE.

• 12/03/2017· ENGINE

  39K MILES THROWS CODES RELATING TO SECONDARY AIR INJECTION PUMP. $2100 QUOTE TO FIX. MANY OTHER OWNERS WITH THE SAME PROBLEM

• 11/29/2016· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  CHECK ENGINE LIGHT CAME ON, TRAC OFF LIGHT IS ON. MY TRUCK HAS NO POWER AND IS UNSAFE TO DRIVE. THE DTC IS P2442. SECONDARY AIR INJECTION SYSTEM SWITCH VALVE STUCK OPEN BANK 2. TOYOTA KNOWS THEY HAVE A EMISSIONS ISSUE. MY VEHICLE IS AT THE DEALERSHIP NOW.

• 11/29/2012· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED AND IT BEGAN TO PULSATE EXCESSIVELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE BOTH THE REAR ROTORS AND BRAKE DRUMS WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,000. .....UPDATED 01/14/13 *BF UPDATED 1/18/2013 *JS

• 11/28/2012· SERVICE BRAKESCrash

  PLASTIC FOOT-REST UNDER PARKING BRAKE PEDAL FALLS OFF EASILY & SLIDES AROUND FLOOR OF DRIVER'S SIDE. IN THIS INCIDENT, THE BLOCK FLIPPED UP ON IT'S SIDE AS IT SLIPPED UNDER BRAKE PEDAL, PARTIALLY BLOCKING THE BRAKE PEDAL OPERATION, ALLOWING VEHICLE TO CREEP FORWARD WHILE STOPPED IN TRAFFIC, WHILE IT FELT LIKE BRAKE WAS FULLY DEPRESSED, RESULTING IN VERY LOW SPEED IMPACT WITH VEHICLE STOPPED IN FRONT. PREVIOUSLY REPORTED TO DEALER WHO RE-ATTACHED IT AT A ROUTINE NEW VEHICLE SERVICE, BUT IT HAS FALLEN OFF A COUPLE TIMES SINCE THAT REPAIR, AND WAS SNAPPED BACK ONTO MOUNTING CLIP EACH TIME. *TR

• 11/27/2013· SERVICE BRAKESCrash

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH AND APPLYING THE BRAKES FOR AN APPROACHING STOP SIGN, THE BRAKES WOULD NOT RESPOND AND THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOOR BOARD. THE VEHICLE DID NOT STOP AND PROCEEDED TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE AS TOWED FROM THE SCENE AND WAS NOT REPAIRED. THE FAILURE WAS RECURRING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

• 11/21/2016· POWER TRAIN

  WE JUST PAID TOYOTA A LITTLE OVER $2,000 TO REPLACE THE SECONDARY AIR INJECTION SYSTEM. THE SWITCHING VALVE WAS STUCK CLOSED ACCORDING TO TOYOTA. THIS IS A 4 YEAR OLD TRUCK. IT IS UNREAL TO SPEND THIS KIND OF MONEY THIS EARLY FOR THIS. THE TUNDRA HAS RECALLS FOR THIS SAME ISSUE.

• 11/21/2016· ENGINE

  MY CHECK ENGINE LIGHT CAME ON AND MY VEHICLE ENTERED "LIMP MODE," WHICH KEEPS THE CAR UNDER ABOUT 35MPH AND PREVENTS IT FROM ACCELERATING QUICKLY. THE CEL READ AS A SECONDARY AIR INTAKE SYSTEM PROBLEM (P2440 AND P2442). JUDGING BY THE MULTITUDE OF SIMILAR COMPLAINTS I HAVE FOUND, THIS IS A SYSTEMIC PROBLEM THAT TOYOTA REFUSES TO RECTIFY FOR TACOMAS BUT HAS ALREADY ADMITTED TO FOR TUNDRAS. THIS IS A SERIOUS DANGER TO DRIVERS IF THE VEHICLE ENTERS "LIMP MODE" WHILE THEY ARE DRIVING THROUGH AN INTERSECTION OR IN HEAVY TRAFFIC. IT ISEEMS ALSO RIDICULOUS FOR TOYOTA TO EXPECT TACOMA OWNERS TO SPEND THOUSANDS OF DOLLARS TO FIX THEIR POORLY DESIGNED PART, ESPECIALLY CONSIDERING THE PART IS NOT VITAL TO THE PERFORMANCE OF THE ENGINE.

• 11/21/2016· ENGINE

  CHECK ENGINE AND TRAC OFF LIGHTS CAME ON. VEHICLE ACCELERATION BECAME VERY SLUGGISH. I FELT THE VEHICLE BECAME A SAFETY HAZARD AS IT HAD ALMOST NO ACCELERATION . MERGING INTO TRAFFIC BECAME DANGEROUS BECAUSE OF LACK OF ACCELERATION. HAD LOCAL SHOP CHECK TRUCK AND ERROR CODES RETURNED WERE P2440 AND P2442 WHICH THEY SAID INDICATED SECONDARY AIR INJECTOR PUMP NEEDS TO BE REPLACED. EST CHARGE ABOUT $2000!

• 11/20/2017· POWER TRAIN,FUEL/PROPULSION SYSTEM

  CHECK ENGINE LIGHT AND TRAC OFF LIGHT CAME ON. TRUCK WENT INTO "LIMP" MODE AND WOULD ONLY GO ABOUT 35MPH. CHECKED THE ERROR CODE AND IT WAS P2442 WHICH SAYS THE SECONDARY AIR INJECTION SYSTEM IS FAILING. TRUCK HAS ONLY 55K MILES ON IT AND HAS BEEN REGULARLY MAINTAINED BY TOYOTA DEALERSHIPS EVERY 6 MONTHS / 5K MILES. DEALERSHIP HAS SAID IT WILL BE $2023 TO REPLACE THE SYSTEM. THERE SHOULD BE A RECALL OR EXTENDED WARRANTY ON THIS INJECTION SYSTEM

• 11/19/2014· STRUCTURE

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT DISCOVERED THAT THE FRONT TOW END CAUSED EXTREME WEAR ON THE FRONT TIRES. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000.

• 11/18/2017· ENGINE

  CHECK ENGINE LIGHT AND TRAC OFF LIGHT CAME ON AND NEXT THING THE CAR WOULD NOT ACCELERATE PROPERLY WHILE PULLING OUT ON TO A HIGHWAY HEADING UP HILL I HAD NO POWER. FORTUNATELY I WAS NOT KILLED BY THE 50 PLUS MILE PER HOUR TRAFFIC. AFTER MAKING DOWN THE HIGHWAY WAS ABLE TO GET INTO A PEP BOYS WHERE THEY CODED THE SECONDARY AIR SYSTEM. THIS IS A SERIOUS ISSUE THAT COULD HAVE KILLED ME OR SOMEONE ELSE. I PLAN TO CONTACT AN ATTORNEY AFTER FINDING OUT THEY ONLY COVER THEIR MOST EXPENSIVE VEHICLES WITH THEY EXACT SAME SYSTEM. I GUESS 35K ON A TRUCK WASN'T ENOUGH. THE PART COST ME $770 DOLLARS AND I'M NOT SURE IF ITS SAFE BECAUSE I HAD TO DO JOB MYSELF BECAUSE I COULD NOT AFFORD $2000.00 FOR 2 HOURS WORK.

• 11/16/2018· ENGINE

  83K MILES. ENG LIGHT AND TRAC LIGHTS COMES ON, WHILE DRIVING TRUCK GOES INTO LIMP MODE AND WILL NOT EXCELERATE PAST 2500 RPMS AND WILL NOT GO ANY FASTER THAN 35 MPH. ERROR CODE P2442 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE PROBLEM. VERY DANGEROUS PROBLEM

• 11/11/2022· POWER TRAIN

  Drivetrain vibration and cricket chripping noise; likly coming from propeller shaft

• 11/08/2017· ENGINE

  OEM PARTS FAILURE DUE TO MANUFACTURERS DEFECT. THIS EXACT ISSUE PROMPTED RECALL OF THE TOYOTA TUNDRA. DEALERSHIP REPORTS NUMEROUS CUSTOMERS WITH SAME ISSUE. REPAIR IS OVER $2,000. THIS IS SERIOUS ISSUE. AIR INJECTION PUMPS AND SWITCHING VALVES ARE FAULTY ALLOWING WATER INTO THE SYSTEM AND CAUSING THE ENGINE TO SEIZE UP AND DECREASE ENGINE SPEED. THIS HAPPENED ON I-90 IN HEAVY TRAFFIC CAUSING OTHER MOTORISTS TO APPLY BREAKS QUICKLY. CONTACTED TOYOTA AND THEY ARE AWARE OF THE ISSUE BUT HAVE NO PLANS TO INITIATE A RECALL.

• 11/08/2016· FUEL/PROPULSION SYSTEM

  SECONDARY AIR INJECTION SYSTEM: STARTED THE VEHICLE AND CHECK ENGINE LIGHT CAME ON. OBD READ P2440/P2442. WHILE DRIVING UPHILL ON A VERY BUSY HIGHWAY, THE VEHICLE LOSS POWER AND WOULD NOT GO FASTER THAN 20MPH AND THE RPM'S RAMMED UP. AFTER SOME SOME RESEARCH FOUND OUT THIS IS A COMMON PROBLEM WITH THE TACOMA IN WHICH TOYOTA WAS AWARE OF.

• 11/08/2012· AIR BAGSCrash

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE CRASHED INTO A TREE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THE VEHICLE WAS DESTROYED BUT THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A BODY SHOP. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 20,000.

• 11/07/2020· EXTERIOR LIGHTING,STRUCTURE

  PAINT PROBLEMS ON ALL FOUR DOORS FLAKING OFF .RECIEVING A NOTICE FOR MY CAMARY BUT NOT THE TACOMA, BOTH COLORS WERE LISTED.

• 11/07/2019· ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  BRAKES ACTUATE ABNORNMAL. BRAKES ENGAGE APPROX. 2 SECONDS AFTER THEY ARE APPLIED. BRAKES ALSO WILL COME ON AT FULL FORCE LOCKING THE VEHICLE UP. MASTER TECH DIAGNOSTIC - FAULTY BRAKE BOOSTER. TOYOTA HAS RECALLS FOR 2012 TACOMA'S HOWEVER MY VIN IS NOT INCLUDED IN RECALL.

• 11/07/2011· STEERING

  TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE BEGAN TO VIOLENTLY SHAKE AND PULL TOWARDS THE LEFT WHILE DRIVING 57 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPAIRED, BUT THE FAILURES CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 3 AND THE CURRENT MILEAGE WAS 1,100.

• 11/06/2015· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  FUEL SYSTEM CAN BE HEARD HOURS AFTER THE TRUCK IS PARKED, FEW TIMES A WEEK AND SOMETIMES DAILY .AND RUNS 2 TO 15 MINUTES. CONTACTED DEALER AND SAYS IT NORMAL FOR FUEL EVAP TO DO A SYSTEM CHECK. ONGOING STARTED BEFORE 3000 MILES

• 11/06/2015· ENGINE

  ENGINE OIL LIGHT COMES ON AND FLASHES A FEW TIMES AFTER STARTUP, BEYOND THE NORMAL TIME FOR ALL THE OTHER LIGHTS WHILE IN THE STARTING MODE, DEALER COULD NOT DUPLICATE

• 11/06/2015· WHEELS

  CHANGING A FLAT TIRE, THE SPARE WHICH HAS NEVER BEEN USED WAS LOW ON AIR, DROVE FOR LESS THAN 5 MILES AND PARKED LATER IT WAS FLAT TOO.DEALER HAS DONE SEVERAL MULTI POINT INSPECTIONS, SPARE TIRES NOT ON LIST. DEALER STOLE THE HUBCAP DURING THE MOUNTING / INSTALLATION

• 11/06/2015· POWER TRAIN,ENGINE

  AT APROXIMATE 40 MPH AND AT A CONSTANT SPEED THE VEHICLE STARTS TO SHUTTER OR SHAKE, FEELS LIKE IT WANTS TO DOWN SHIFT OR UP SHIFT MAYBE ITS CONFUSED. DEALER COULD NOT DUPLICATE 2 TIMES

• 11/06/2015· POWER TRAIN,ENGINE

  VEHICLE LUNGES WHEN YOU COME TO COMPLETE STOP, BETTER HOLD THE BRAKE WITH SOME FORCE ANY TIME STOPPED, TOYOTA SERVICE SAYS IT HAPPENS ALL THE TIME, ITS NORMAL !!

• 11/05/2020· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  SUN VISOR , SPRING INSIDE VISOR BREAKS. MAKING THE VISOR HANG DOWN. WIRE HARNESS FROM AC BLOWER MOTOR, SO SOMEWHERE IN THE ENGINE COMPARTMENT OVERHEATS AND MELTS WIRING SO THE AIR CONDITIONING STOPS WORKING.

• 11/05/2017· ENGINE,FUEL/PROPULSION SYSTEM

  RECENTLY I WAS DRIVING MY 2012 TOYOTA TACOMA ON THE HIGHWAY AT A SUSTAINED SPEED OF 70 MPH. A CHECK ENGINE LIGHT CAME ON AND MY CAR INSTANTLY DROPPED IN SPEED TO LESS THAN 40 MPH WHILE IN FAST MOVING TRAFFIC. I WAS ALMOST REAR ENDED BY A LARGE TRUCK AND WAS FORCED TO CROSS MULTIPLE LANES OF TRAFFIC TO GET TO THE BERM AND ASCERTAIN THE SITUATION. AS I COULD FIND NO ISSUES UPON INSPECTION, I PRECARIOUSLY DROVE THE VEHICLE TO A SERVICE STORE TO READ THE ERROR CODES. THE VEHICLE SHOWED P2440 P2442 ERROR CODES INDICATING SECONDARY AIR INJECTION FAILURES. APPARENTLY, THE VEHICLE WENT INTO LIMP MODE UPON THROWING THESE CODES WHICH LIMITS SPEED AND ENGINE RPM. THIS ALMOST CAUSED A HUGE ACCIDENT AND PUT ME INTO A A VERY DANGEROUS SITUATION. ADDITIONALLY UPON RESEARCHING THESE ISSUES, IT SEEMS THIS IS A WELL DOCUMENTED ISSUE CAUSED BY MANUFACTURING DEFECTS ISOLATED TO THE 2012 MODEL YEAR. APPARENTLY, THE SYSTEM IS DEFECTIVE IN MULTIPLE WAYS. FIRST, A PIECE OF FOAM IS INSIDE THE SECONDARY AIR PUMP WHICH DEGRADES AND IS SUCKED INTO THE FAN WHICH NOT ONLY CAUSES STOPPAGE AND BURNING OUT THE FAN MOTOR BUT ALSO ALLOWS FOR STINKY RESIDUE AND DEBRIS TO ENTER THE VALVES CAUSING THEM TO JAM OPEN OR CLOSED. ADDITIONALLY, THE SYSTEM ALLOWS MOISTURE TO BE SUCKED INTO THE VALVES ADDING TO CORROSION AND DEGRADATION OF THE VALVES LEADING TO THEM TO BE STUCK. THIS IS A ROUGHLY 1500.00-2000.00 REPAIR. IT IS A QUITE FREQUENT PROBLEM WITH THIS MODEL YET IS NOT COVERED UNDER RECALL OR SERVICE BULLETIN. TOYOTA HAS ACKNOWLEDGED THE ISSUE YET NOT TAKEN ANY ACTION. ADDITIONALLY, THEY HAVE HAD SIMILAR PROBLEMS WITH THE TUNDRA/SEQUOIA AND OFFERED REMEDY TO OWNERS VIA EXTENDED WARRANTY. THIS IS NOT ONLY A QUALITY CONTROL ISSUE BUT MORE IMPORTANTLY A SEVERE SAFETY ISSUE WITH THE AUTOMATIC REDUCTION TO A SLOW SPEED IN FAST HEAVY TRAFFIC.