2012 KIA Sedona

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2017· ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER

  REAR DRIVER SIDE SLIDING DOOR WILL NOT ALWAYS CLOSE COMPLETELY AND SOMETIMES OPENS WHILE DRIVING. MY THREE YEAR OLD GRANDDAUGHTER SITS IN THAT SEAT AND I'M WORRIED THAT THE DOOR IS ACTUALLY GOING TO COME OPEN WHILE WE'RE DRIVING THE CAR. I'VE READ OF PREVIOUS YEARS FOR THIS SAME VEHICLE HAVING THIS PROBLEM. I'VE PAID TO HAVE IT REPAIRED ONCE, BUT I FEEL THAT KIA SHOULD TAKE CARE OF THIS KNOWN ISSUE. ALSO, THERE IS AN ISSUE WITH THE FRONT END OF THE VEHICLE. IT SOMETIMES MAKES A GRINDING SOUND WHEN I'M SLOWING DOWN - NOT NECESSARILY WITH MY FOOT ON THE BRAKE. SOMETIMES IT'S DIFFICULT TO STOP THE VEHICLE AND I'M AFRAID I'M GOING TO GET INTO AN ACCIDENT.

• 12/29/2018· ELECTRICAL SYSTEM

  SIDE DOOR FLIES OPEN WHILE DRIVING, ELECTRONIC DOOR LATCH NO LONGER WORKS PROPERLY ALLOWING THE DOOR TO OPEN COMPLETELY WHILE DRIVING EXPOSING SECOND ROW PASSENGER.

• 12/28/2021· ENGINE AND ENGINE COOLINGFire

  The contact owns a 2012 Kia Sedona. The contact stated that after driving 70 MPH, and pulling into a parking lot, he noticed smoke coming from underneath the hood of the vehicle. The contact exited the vehicle and upon opening the hood of the vehicle, he saw that the engine compartment was on fire. The contact was able to extinguish the fire with the assistance of the fire department. A fire department report and a police report were filed. There were no injuries sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The approximate failure mileage was 190,102.

• 12/11/2011· VEHICLE SPEED CONTROL

  LET ME BEGIN BY PREFACING THAT THIS IS OUR 2ND SEDONA, AND WE PURCHASED BOTH BRAND NEW. WE HAVE HAD THIS VEHICLE FOR 4 MONTHS, AND IT ONLY HAS APPX. 6000 MILES ON THE ODOMETER. I WAS DRIVING DOWN A RESIDENTIAL SIDE STREET I APPROACHED THE A STOP SIGN, I BEGAN DEPRESSING THE BRAKES TO SLOW DOWN, AND THERE WAS A CAR AT THE STOP SIGN IN FRONT OF ME, WAITING TO TURN LEFT. AS I CONTINUED TO SLOW DOWN WITH MY FOOT STILL ON THE BRAKE, THE VAN'S ENGINE, OUT OF NOWHERE, BEGAN TO REV CONTINUOUSLY AT FULL THROTTLE. MY FOOT WAS STILL ON THE BRAKE, AND DESPITE THAT THE VAN BEGAN TO MOVE FORWARD DESPITE. I PUSHED MY FOOT DOWN AS HARD AS I POSSIBLY COULD ONTO THE BRAKE, BUT THE BRAKE PEDAL WAS RESISTING, DUE TO THE CONTINUOUS HIGH REV OF THE ENGINE. OUT OF DESPERATION BECAUSE I WAS JUST ABOUT TO REAR-END THE CAR IN FRONT OF ME, I REACHED FOR THE GEAR SHIFT TO THROW THE VAN INTO PARK, WHEN THE REV SUDDENLY STOPPED, AND THE VAN LURCHED TO A COMPLETE STOP. I THEN THREW IT INTO PARK AND SAT IN THE ROAD, SHAKING UNCONTROLLABLY WITH MY HEART POUNDING. I JUST BARELY MISSED THE CAR IN FRONT OF ME. ONCE I WAS COMPOSED, I VERY SLOWLY DROVE HOME (~ 2 BLOCKS). I VERIFIED THAT THERE WAS NOTHING ON THE FLOOR WHICH COULD HAVE ROLLED UNDER THE ACCELERATOR PEDAL. THE FLOOR MAT WAS IN PLACE, AND WAS NOT TURNED UP NEAR THE PEDALS. MY SEAT WAS IN ITS REGULAR POSITION. I WAS NOT USING THE CRUISE CONTROL (I.E. THE CRUISE CONTROL SYSTEM WAS 'OFF' AT THE TIME). MY FOOT DID NOT HIT THE GAS PEDAL AT ALL, IT WAS FIRMLY PLANTED ON THE BRAKE.MY PANTS OR SHOES WERE ALSO NOT CAUGHT ON THE PEDAL. THIS HAS NEVER HAPPENED BEFORE. I HAVE NEVER EXPERIENCED ANYTHING LIKE IT IN MY 21 YEARS OF DRIVING & CANNOT IMAGINE WHAT WOULD CAUSE AN EVENT LIKE THIS TO HAPPEN IN A BRAND NEW VEHICLE BUT WE ARE TERRIFIED TO DRIVE IT- ESPECIALLY WITH OUR CHILDREN IN IT! I IMMEDIATELY CALLED THE DEALERSHIP, AND WE DROPPED IT OFF TONITE. *TR

• 12/09/2011· STRUCTURE

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. WHILE DRIVING 50 MPH, THE SLIDING DOORS AND THE REAR HATCH DOOR OPENED HAPHAZARDLY. THE DEALER MADE TWO ATTEMPTS TO DUPLICATE THE FAILURE. THE PASSENGER SIDE SLIDING DOOR WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER DID NOT OFFER ANY ASSISTANCE AND THE VEHICLE WAS NOT FURTHER REPAIRED. THE CURRENT MILEAGE WAS 2,000 AND THE FAILURE MILEAGE WAS UNKNOWN.

• 11/18/2014· STEERING,AIR BAGSCrash

  TL* THE CONTACT OWNED A 2012 KIA SEDONA. WHILE DRIVING 30 MPH IN RAINY WEATHER CONDITIONS, THE VEHICLE VEERED TO THE RIGHT, CRASHED INTO A CURB, AND ROLLED OVER. THE AIR BAGS FAILED TO DEPLOY. THE REAR PASSENGER SUSTAINED A CHIN INJURY THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 2,000. THE VIN WAS NOT AVAILABLE.

• 11/14/2020· STEERING,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  WHEN THE ABS BRAKES ACTIVATE WHILE GOING AT A VERY SLOW SPEED DURING SNOWY OR RAINY WEATHER THE STEERING WHEEL LOCKS AND THE DASHBOARD LIGHTS COME ON. I HAVE NO CONTROL OF THE CAR. IT'S VERY SCARY. VERY MUCH A SAFETY ISSUE. I TOOK IT TO THE SHOP, BUT THEY DIDN'T COME UP WITH ANYTHING. IT HAS HAPPENED ABOUT 5 TIMES OVER THE PAST 2 YEARS. THE MILEAGE VARIES. THE MOST RECENT INCIDENT THE VEHICLE HAD 210,000 MILES

• 11/12/2011· SERVICE BRAKES, HYDRAULIC

  IT IS ALMOST IMPOSSIBLE WHILE DRIVING ON A DAILY BASIS TO NOT STEP ON THE BRAKES WHILE ALSO DEPRESSING THE ACCELERATOR SIMULTANEOUSLY. I BELIEVE THIS IS A DESIGN FLAW, SINCE I'VE BEEN DRIVING FOR 42 YEARS AND HAVE DRIVEN DOZENS UPON DOZENS OF MAKES AND MODELS AND NEVER ONCE ENCOUNTERED AN ISSUE WHERE THE BRAKE & ACCELERATOR ARE POSITIONED IN SUCH A WAY THAT, UNLESS YOU PICK UP YOUR FOOT COMPLETELY OFF THE ACCELERATOR AND DELIBERATELY REPLACE IT TO THE FAR LEFT OF THE BRAKE PEDAL, THEN YOU FIND YOURSELF PRESSING BOTH AT ONCE CAUSING THE CAR TO LURCH FORWARD WHILE YOU ARE TRYING TO STOP. THIS IS NOT AN OCCASIONAL PROBLEM. IT OCCURS ON A NEAR DAILY BASIS, DESPITE THE FACT THAT I'M AWARE OF THE PROBLEM AND DO EVERYTHING TO AVOID IT. IT'S AN EXTREMELY DANGEROUS DESIGN FLAW AND NEEDS TO BE ADDRESSED AS QUICKLY AS POSSIBLE. THANK YOU. *TR

• 11/11/2015· ELECTRICAL SYSTEM

  DRIVING TO MONTANA FROM COLORADO OVER THE SUMMER, AC WENT OUT. GOT IT BACK TO DEALERSHIP, WAS TOLD BLOWER MOTOR WENT BAD - ACTUALLY MELTED THE PLUG AND WE HAD SMOKE IN THE VAN! REPLACED THE BLOWER MOTOR AND PLUG (OUT OF POCKET) FROM DEALERSHIP SINCE THEY SAID OUT OF WARRANTY DUE TO MILEAGE. THEN, 3 WEEKS LATER, SAME PROBLEM. THEY REPLACED THE WIRING HARNESS CONNECTOR. 2 WEEKS LATER, SAME PROBLEM, REPLACED BLOWER MOTOR AGAIN AND WIRING PIGTAIL CONNECTOR TO BLOWER MOTOR. A/C IS ONE THING, BUT WHEN ENTERING INTO COLORADO WINTER DRIVING, NEED HEAT FOR THE WINDSHIELD! REPEATED PROBLEM DOZENS OF TIMES OVER THE LAST 2 MONTHS! VEHICLE ISN'T SAFE TO DRIVE NOW! WENT TO ANOTHER DEALERSHIP, NOW THAT IT'S WINTER IN COLORADO, NEED HEAT FOR WINDSHIELD. WAS TOLD NEEDED TO REPLACE FULL VEHICLE WIRING HARNESS AT ~$1,800 PARTS + ~$1,100 LABOR AND TO "SEE IF THAT WOULD FIX IT." NOPE! VEHICLE IS NOT SAFE DUE TO VISIBILITY DUE TO DEFECTIVE HEATING FOR DEFROST! I'M FINDING THIS IS A COMMON PROBLEM FOR 2012 KIA VEHICLES WITH CLIMATE CONTROL ISSUES, BLOWERS, ETC! NOT SURE IF IT'S DRAWING TOO MUCH POWER OR WHAT? HAVE HAD TWO BLOWER MOTORS INSTALLED AND WIRING PIGTAILS IN 3 MONTHS, AND NOT RIGHT. VEHICLE NOT SAFE FOR MY WIFE TO DRIVE WITH COLD CLIMATE! THIS IS INCREDIBLY DANGEROUS! VEHICLES NEED TO BE RECALLED AND IMMEDIATELY FIXED!

• 10/29/2023· ELECTRICAL SYSTEM,ENGINE

  Unknown. I've replaced the alternator and battery. The alternator many times and still having lights come on. Mostly the "brake and battery " lights. It's sitting till further notice. Not drive able.

• 10/27/2021· UNKNOWN OR OTHER

  The contact owns a 2012 Kia Sedona. The contact stated that upon purchase of the vehicle, the sliding door would not close as needed and would independently open while driving without warning. The contact also stated that the electrical power mirrors would also operate independently without warning. The contact then received notification of NHTSA Campaign Number: 20V101000 (Fuel System, Gasoline) and took the vehicle to the dealer for repair. The contact was also provided an estimate for the repair of other vehicle failures. Two days after the repair while driving 50 MPH, the contact depressed the brake pedal as he approached a stoplight. The light turned green and the accelerator pedal was depressed, and the vehicle stalled in the middle of the intersection. The contact was forced to make an illegal U-turn. The contact turned the key to the off position; however, the engine continued to run with several unknown warning lights on the instrument panel. The contact saw steam coming from the engine and upon inspection, the contact saw the radiator cap blow off as the vehicle lost motive power. The contact had the vehicle towed to the dealer where they informed him that the axle shaft, water pump, crankshaft pulley, alternator, oil pan gasket, drive belts, and battery all need to be replaced. The manufacturer was notified of the failure but offered no assistance. The vehicle remained in the possession of the dealer and was not yet repaired. The failure mileage was 69,107.

• 10/27/2015· AIR BAGS

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE AIR BAG ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 61,700. UPDATED 04/04/16*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED ON NOVEMBER 10, 2015. UPDATED 05/11/16.*JB

• 10/22/2018· POWER TRAIN

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. WHILE THE VEHICLE WAS ENGAGED IN PARK AND THE BRAKE PEDAL WAS NO LONGER DEPRESSED, IT WENT INTO REVERSE ON ITS OWN. THE CONTACT STATED THAT THE GEAR HAD TO BE FORCEFULLY PUSHED INTO THE PARK POSITION AND A LOUD NOISE WAS DETECTED FROM THE GEAR LEVER. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 78,000.

• 10/21/2014· STRUCTURE

  REAR HATCH WON'T OPEN WHEN SITTING OUT IN THE SUN FOR 4-5 HOURS. AFTER IT COOLS DOWN, IT WILL OPEN. WHEN SITTING FOR LONGER THAN 3 HOURS, IT WILL NOT OPEN. *TR

• 10/20/2018· SERVICE BRAKES

  BRAKE PEDAL SOFT, BRAKES FADE IN PANIC STOP , AT VEHICLE STOP BRAKE PEDAL FADES TO FLOOR

• 10/18/2025· ELECTRICAL SYSTEM,STRUCTURE,SERVICE BRAKESCrash

  While driving the vehicle and applying the brakes the vehicle shifted to one side of the road. There was an accident 03/2024 after having the brake control arm serviced. The braking system failed. There was a recall on the front control arm 2016. The vehicle was totaled and was salvaged due to damages to the vehicle. The brake inspection failed. Today the braking system has has no control even after the master cylinder was repaired. The vehicle is currently sitting at a service station without being serviced for at least 2 months. Kia needs to be responsible and refund for the arm control repair and other related part failures. The electrical system does not work for the windshield wipers or the air conditioner or sliding doors.

• 10/16/2020· UNKNOWN OR OTHER

  SIDE DOORS WILL NOT OPEN UNLESS YOU USE THE FRONT CONTROL BUTTON SOMETIMES THE REMOTES WORK BUT NOT ALL THE TIME SOMETIMES SHOWS ON DASHBOARD SIDE DOORS ARE OPEN AND THEY ARE CLOSED THIS WAS HAPPENING WHEN PREVIOUS OWNER HAD IT AND I'M NEW OWNER STILL HAPPENS

• 10/10/2022· UNKNOWN OR OTHER

  The passenger door will not open from the inside by pulling on the handle or pushing the door open button. Pulling on the outside door handle will not open the door as well. The remote wont open them as well. This is a safety issue as passengers can't get out of car in case of accident. I have brought it to a Kia dealer and they said it works fine for them and if the problem doesn't occur when they have it they can't fix it. I have an extended warranty letter from Kia that there is a problem with the rear sliding doors. I am mystified as to why I can't get this problem fixed.

• 10/09/2014· ELECTRICAL SYSTEMFire

  MY SON WAS DRIVING THE CAR WITH MY GRANDSON IN THE FRONT PASSENGER SEAT. SMOKE CAME OUT OF THE AIR CONDITIONING VENTS AND A FIRE STARTED IN THE WIRING BELOW THE DASH ON THE PASSENGERS SIDE. MY GRANDSON PUT OUT THE FIRE WITH HIS SHOE AND AFTER TURNING OFF THE AC THE SMOKE STOPPED. DEALERSHIP SAID BLOWER MOTOR WAS DRAWING TOO MUCH CURRENT. SUBSEQUENTLY THEY FOUND A 40 AMP FUSE HAD BLOWN AND A BAD MOTOR RESISTOR. THIS PROBLEM NEVER SHOULD HAVE HAPPENED AND IF THE FIRE HAD SPREAD, AT BEST THE CAR WOULD BE TOTALED AND WORST CASE A SERIOUS ACCIDENT WITH POSSIBLE LOSS OF LIFE. NEXT ISSUE IS A BAD IGNITION SWITCH. IT WAS VERY DIFFICULT TO TURN THE KEY IN THE SWITCH. REPLACING KEY DID NOT HELP. ENDING UP REPLACING IGNITION SWITCH. IN AN EMERGENCY NOT BEING ABLE TO USE YOUR CAR COULD BE LIFE THREATENING. *TR

• 10/03/2019· ELECTRICAL SYSTEM,STRUCTURE

  THE DOOR ACTUATOR WENT OUT. THE DOOR WORKED FINE WHEN WE WENT TO THE STORE. ON THE DRIVE HOME THE SLIDING DOOR FLEW OPEN. THE DOOR LATCH IS STUCK IN THE LOCKED POSITION AND WILL NOT UNLOCK. I HAVE MY DOORS BUNGEE CORDED TOGETHER.

• 10/02/2016· ENGINE

  UPON SERVICE STATION OIL CHANGE ENGINE WARNING CODES P0024,P0014 SHOWED IMMEDIATLEY NEXT MORNING. WIX FILTER, MGD MGL 10082, BOUGHT BY MY MECHANIC FROM ORIELLYS AUTO PARTS HAD NO RESEMBLANCE TO ORIGINAL FILTER EVEN THOUGH ADVERTIZED AS OEM REPLACEMENT. THIS HAD PERFORATED METAL SHELL AND SOLID RUBBER TOP AND BOTTOM WHEN KIA VERSION IS FAN FOLDED PAPER ALL OVER IT DAMAGED ENGINE VVTI, CAM EXHAUST MANIFOLD WARNING SINCE THIS IS A OIL TIMED ENGINE . I DID NOT DRIVE IT UNTIL FIXED, OIL SWITCH, AND PRESSURE SENDING UNIT. 100% PERCENT OF OIL HAD BEEN FORCED OUT TOP OF ENGINE AND POOLED IN THE V6. SEVERAL TECHNICAL SITES SAY THESE FILTERS DESIGN HAVE FAILED INCLUDING REDESIGN. NOW ORIELLYS AND WIX ARE DRAGGING THIER FEET IMN FIXING THIS AND REIMBURSING ME FOR EXSPENSE. NOT EVEN THIER PRODUCT. I WAS DRIVING VEHICLE LESS THAN 20 MILES

• 10/02/2015· ENGINE

  THE TIMING CHAIN TENSIONERS BLEED DOWN PRESSURE AFTER THE VEHICLE HAS SET FOR A FEW HOURS CAUSING CHAIN SLAP AT START UP WHICH OVER TIME WILL DAMAGE INTERNAL ENGINE COMPONENTS UP TO AND INCLUDING TIMING ISSUES THAT COULD CAUSE ENGINE FAILURE. WHILE THERE IS A TSB FROM KIA ON THIS KNOWN ISSUE KIA CLAIMS IT IS NORMAL TO HEAR THE CHAIN SLAP AGAINST THE ENGINE WALLS UNTIL THE TENSIONERS BUILD PRESSURE OVER SEVERAL SECONDS.

• 09/27/2019· ELECTRICAL SYSTEM

  TOOK VEHICLE TO DEALERSHIP FOR RECALL, WIRING HARNESS. WHEN DONE, THE HORN, LEFT REAR DOOR LOCK SWITCH AND THE RADIATOR FANS STOPPED WORKING. ALL THESE WORKED PRIOR TO THE RECALL WORK. AND THESE ITEMS DO WORK WHEN BYPASSING WITH A BATTERY, HOOKING THEM DIRECTLY TO POWER.

• 09/22/2018· VISIBILITY/WIPER

  SIDE VIEW MIRRORS WILL GO DOWN IN BACKUP POSITION WHILE DRIVING RESULTING IN A LOSS OF VISION ON CARS BESIDE AND BEHIND YOU. TRIED REPLACING WITH AFTERMARKET MIRRORS AND THE SAME HAPPENS. THIS IS THIRD TIME THIS VEHICLE HAS HAD THE SAME PROBLEM. ISSUE OCCURS ANYTIME VEHICLE IS STARTED. YOU CAN SET THE MIRRORS, TURN OFF THE SETTINGS ADJUSTER AND AT A RANDOM TIME THEY WILL GO ALL THE WAY DOWN.

• 09/22/2017· STRUCTURE

  PASSENGER SIDE SLIDING DOOR WILL NOT LATCH WITH POWER MOTOR. I SWITCHED THE DOOR TO MANUAL MODE AND THE DOOR APPEARED TO LATCH. THE DOOR THEN POPPED OPEN WHEN VEHICLE WAS MOVING.

• 09/20/2018· AIR BAGS

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR HAD BEEN PERMANENTLY ILLUMINATED SINCE MARCH OF 2018. THE VEHICLE WAS TAKEN TO GRAND STAFF KIA (3608 BRISTOL HIGHWAY, JOHNSON CITY, TN 37601) WHERE IT WAS DIAGNOSED THAT THE SEAT SENSOR CAUSED THE FAILURE, WHICH WAS NOT PART OF NHTSA CAMPAIGN NUMBER: 18V363000 (AIR BAGS). THE CONTACT RECEIVED NOTIFICATION OF THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

• 09/17/2018· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINEFire

  LAST SEPTEMBER 6TH, 2018, SEDONA WAS ALMOST CAUGHT FIRE WHILE DRIVER WAS WITH HER CHILDREN. ONWER SAW A HUGE SMOKE AFTER SHE LOOKED AT DASHBOARD TEMPATURE GUAGE THAT REACHED OVERHEAT, QUICKLY PARKED, TURNED IT OFF, AND OPENED THE HOOD. SHE SMELLED STRONG BURNED. MECHANIC TOOK A LOOK AT ENGINE AND FOUND A LOT OF MOTOR OIL THAT WAS LEAKING THROUGH THE HEAD GASKET AND SPILLING OVER ONTO EXHAUST PIPE UNDER ENGINE BLOCK. OIL SPILLING ONTO EXHAUST PIPE COULD CAUSE FIRE. RESPONSE OF MECHANIC DIAGNOSIS, ORIGINAL ALTERNATOR WAS AT FAULT FOR STOPPING GENERATE POWER SUPPLY TO THE RADIATOR FAN ASSEMBLY. THEN RADIATOR FAN ASSEMBLY STOPPED OPERATING, RESULTING IN ENGINE OVERHEAT TO BREAK THE HEAD GASKET, LEAKING A LOT OF MOTOR OIL. FOLLOWING OVERHEAT ISSUE, TRANSMISSION WAS ALSO AFFECTED. MECHANIC NOTICED THAT ALARM WAS NOT BUILT IN FOR COOLANT FLUID LEVEL LOW AFTER HALF LOW IN RADIATOR FOUND. WHY WAS NOT A COOLANT FLUID LEVEL LOW ALARM BUILT IN BEFORE FIRST TIME VEHICLE WAS SOLD? WITHOUT A COOLANT FLUID LEVEL LOW ALARM COULD LEAD VEHICLE INTO FIRE.

• 09/02/2015· ELECTRICAL SYSTEM,STRUCTURE,BACK OVER PREVENTION

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. THE CONTACT STATED THAT THE POWER SLIDING DOORS WOULD NOT OPEN OR CLOSE AND WERE EXTREMELY DIFFICULT TO MANUALLY OPEN OR CLOSE. IN ADDITION, THE REAR CAMERAS WERE NOT FUNCTIONING. THE DEALER LUBRICATED THE CAMERAS, BUT INDICATED THAT THE PART WAS ON BACK ORDER. THE FAILURE RECURRED AND THE DOORS FAILED TO OPEN AND CLOSE PROPERLY BOTH ELECTRONICALLY AND MANUALLY. WHILE DRIVING, THE DOORS OPENED MORE THAN ONCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

• 09/01/2025· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  There is a continuous leakage of oil from my van even after the dealer replaced valve cover gasket . When I complained they said it was the leftover oil. After a month again I complained . Then they re-checked and said it is my car's timing cover reseal leaking . Again after few days I had to complain as there was a leak. I got the same standard reply of leftover uncleaned oil is the cause. Few weeks later I took the van to them and they said they thoroughly cleaned and there won't be any leak. I sent them pictures of oil drops underneth the car like I did on earlier occassions. On August 11th this year they checked the car after my complaint and said there was no active leak. On 30th of this month I sent them the pictures of leaked oil spots which they are going to check on 18th September!. Since I got my first appointment on January 19 2025 I took the vehicle to the dealer 5-6 times. In between I complained to them about failure of door locks and wiper blades. They said they were fine and had no issues. A week ago passenger side door lock stopped working often . I took to a mechanic store run by AAA. Their response after few days was that the electrical system was failing due to bad alternator as the battery got depleted. They recommended me to the dealer again. I was searching google and realised that an oil leak can cause alternator to go bad leading to electric failure and even fire accidents. On [XXX] I noticed red flashing sign of alternator and some other (?) after 2 minutes drive from home. So I immediately turned back and went home and parked the van in the garage and waiting for September 18 for an inspection by the dealer. Last week drove to St Louis from Lexington, after the dealer confirmed there was no oil leak. In all their reports they mentioned vehicle is in good health! Each time when I sent a picture of a leak I requested managers at the receiving desk to park at a clean place and check the leak which they never did. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/26/2020· STRUCTURE

  THE SLIDING DOOR ON THE PASSENGER SIDE WOULD NOT LATCH VIA POWER CONTROL. IT WOULD CLOSE MANUALLY TO THE POINT WHERE IT WAS DIFFICULT TO RE-OPEN AGAIN (REQUIRED EXCESSIVE FORCE TO PULL THE DOOR OPEN), HOWEVER OVERHEAD LIGHTS REMAINED ON AND THE CAR WAS BEEPING. WHILE DRIVING THE CAR DOOR SLID OPEN 2X, BOTH WHILE MAKING A LEFT TURN, SLOWLY, ON A SIDE ROAD. AFTER THE SECOND TIME THE DOOR OPENED I ENGAGED THE CHILD LOCK FUNCTION WHICH SEEMED TO HELP. I WAS NOT COMFORTABLE DRIVING ON THE HIGHWAY AND WAS ABLE TO GET THE VEHICLE HOME DRIVING SLOWLY ON SIDE STREETS. I CALLED ROADSIDE ASSISTANCE AND ARRANGED A TOW TO THE DEALER FOR THIS WEEKEND. I CALLED KIA CONSUMER AFFAIRS AND WAS NOTIFIED MY CAR HAD PREVIOUSLY BEEN FIXED FOR A HOOD LATCH RECALL BUT THAT THERE WERE NO RECALLS FOR A PASSENGER DOOR LATCH.

• 08/26/2019· FUEL/PROPULSION SYSTEM

  WE DISCOVERED A FUEL LEAKAGE AFTER GETTING GAS, BUT DID NOT DISCOVER THIS LEAK UNTIL AFTER DRIVING HOME FROM THE GAS STATION. THERE WAS A STRONG SMELL OF GASOLINE AND WE NOTICED THAT THE FUEL GAUGE WENT DOWN RATHER QUICKLY. AFTER GETTING HOME FROM THE GAS STATION, WE NOTICED THE SMELL OF GAS WAS STILL VERY STRONG AND THAT WAS WHEN WE NOTICED THE LEAK, ON OUR DRIVEWAY. IN THE TIME THAT WE WERE DRIVING, WE HAD BEEN LEAKING GASOLINE THE WHOLE TIME, AND COULD HAVE LOST OUR LIVES ON OUR WAY HOME. WE TOOK OUR KIA TO BE INSPECTED AND REPAIRED AND THEY DISCOVERED THAT THE FUEL RAIL WAS DAMAGED: IT HAD A CRACK ALONG ONE SIDE.

• 08/25/2023· UNKNOWN OR OTHER

  Car immobilizer/Theft deterrent - The company is telling me that my KIA's VIN indicated that it does not have the immobilizer/Theft deterrent issue. We drove the car to the dealership with a backup key we made just for unlocking doors. This is a key with no chip or FOB and the car starts and ran fine. This seems to be a clear example of how the immobilizer is not working. However, they refuse to say anything other than the VIN is not on the list. How do I get any help with this? Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 08/25/2016· ENGINE

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. WHILE THE VEHICLE WAS PARKED, ENGINE OIL LEAKED UNDERNEATH THE FRONT END OF THE VEHICLE AND THE ENGINE OIL WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE OIL PRESSURE SWITCH AND ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

• 08/23/2017· UNKNOWN OR OTHER

  ONE THREE SEPARATE OCCASIONS WITHIN A ONE WEEK PERIOD, THE KIA SEDONA STALLED RANDOMLY WHILE THE VEHICLE WAS IN MOTION. THIS OCCURRED ONCE ON A GRAVEL ROAD, ONCE IN TOWN, AND ONCE ON WHILE MERGING ONTO A HIGHWAY. THE VEHICLE WAS BROUGHT TO THE DEALER WHERE WE WERE TOLD THE CHECK ENGINE LIGHT WAS ON, BUT THEY COULD NOT DUPLICATE THE PROBLEM. WHEN WE EXPRESSED THIS SAFETY CONCERN TO KIA CUSTOMER SERVICE, WE HAVE BE COMPLETELY STONEWALLED AND CANNOT EVEN RECEIVE A RETURNED PHONE CALL FROM THE CASE MANAGER. I WISH I COULD SUPPLY MORE INFORMATION BUT THE DEALERSHIP AND KIA SEEM UNWILLING OR UNABLE TO DISCUSS THIS MATTER WITH US.

• 08/18/2018· POWER TRAIN

  DROVE HOME FROM CHURCH AND TRIED TO GO SOMEWHERE AND THE VAN IS STUCK IN PARK. WILL NOT SHIFT INTO ANY GEAR WHEN YOU PUSH IN ON THE BUTTON. MADE SURE MY FOOT WAS ON THE BRAKE PEDAL. BEEN RUNNING GREAT JUST CRAZY HOW THIS HAPPENED.

• 08/18/2016· STEERING,UNKNOWN OR OTHER

  KIA SEDONA RECALL ON HOOD LATCH AND FRONT LOWER CONTROL ARMS RELATED TO VIBRATION/STEERING. I EXPECT THE DEALER TO PICK UP, FIX AND RETURN THE VEHICLE. DEALER INDICATED THEY WOULD NOT. MY HAVING TO DELIVER AND PICK UP THE VEHICLE WOULD BE AN EXPENSE TO ME THROUGH NO FAULT OF MINE. RECALLS SHOULD COVER ALL EXPENSES INCLUDING PICK UP AND DELIVERY. MY DEALER IS 2 HOURS AWAY!

• 08/16/2016· ELECTRICAL SYSTEM,ENGINE

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. WHEN THE KEY WAS INSERTED INTO THE IGNITION AND TURNED TO START, THE VEHICLE FAILED TO RESPOND WITHOUT WARNING. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER ON MULTIPLE OCCASIONS, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000.

• 08/13/2012· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. WHILE THE VEHICLE WAS PARKED THE CONTACT REMOVED THE KEY FROM THE IGNITION AND NOTICED THE IGNITION AND THE KEY WERE EXTREMELY HOT. THE FAILURE OCCURRED AFTER DRIVING APPROXIMATELY THIRTY MILES OR MORE. THE CONTACT MEASURED THE TEMPERATURE OF THE KEY AND STATED IT REACHED 101 DEGREES FAHRENHEIT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 425.

• 08/12/2021· UNKNOWN OR OTHER

  electronic locks (not power door controls) lock and will not unlock via manual key or key fob - this is a crash and or fire hazard & could result in death to passengers if trapped. The rear and side doors are effected.

• 08/11/2020· TIRES

  ON JUNE 5, 2020 AND JUNE 14, 2020, RESPECTIVELY, TWO YOKOHAMA YK580 225/70R16 TIRES INSTALLED ON MY VEHICLE EXPERIENCED VIOLENT TREAD SEPARATION. THE TIRES WERE APPROXIMATELY 4 YEARS OLD WITH LESS THAN 30,000 MILES ON THEM (THE WARRANTY IS FOR 60,000 MILES). ONE EVENT OCCURRED WHILE DRIVING AT 70 MPH. BOTH TREAD SEPARATION EVENTS CAUSED DAMAGE TO THE VEHICLE, THE REPAIR OF WHICH WAS ESTIMATED AT $3,195. MORE IMPORTANTLY, THE EVENTS PUT THE SAFETY OF MY FAMILY AT RISK. YOKOHAMA REFUSED TO ASSUME RESPONSIBILITY DUE TO THE TIRES BEING UNAVAILABLE FOR FORENSIC EXAMINATION. THIS WAS IN SPITE OF MY PROVIDING PHOTOGRAPHS OF BOTH EVENTS CLEARLY SHOWING TREAD SEPARATION HAD OCCURRED. I GUESS YOKOHAMA EXPECTED ME TO CARRY TWO DAMAGED TIRES BACK FROM THE VACATION (AND LEAVE MY FAMILY BEHIND TO NOT OVERLOAD THE VEHICLE?).

• 08/11/2018· ELECTRICAL SYSTEM

  WIRING HARNESS CONNECTIONS ARE MELTED AT THE BLOWER MOTOR AND RESISTOR. ALSO DID ON MY 06 SEDONA. WORRIED ABOUT A FIRE. THE CIRCUIT IS NOT SIZED RIGHT. THERE ARE A LOT OF COMPLAINTS ON LINE ABOUT THIS.

• 08/09/2016· ELECTRICAL SYSTEM

  WHEN SHIFTING FROM REVERSE TO FORWARD, BOTH SIDE MIRRORS NEED TO BE READJUSTED. WITHOUT BEING READJUSTED, THEY POINT AT SUCH AN ANGLE AS TO BE UNUSABLE.

• 08/03/2020· STRUCTURE

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. THE CONTACT STATED THAT WHILE LEANING INTO THE REAR SECTION OF THE VEHICLE, THE TAILGATE FAILED TO REMAIN IN THE OPEN POSITION. THE CONTACT WAS STRUCK ON THE BACK BY THE TAILGATE. THE CONTACT STATED THAT IT WAS DIFFICULT TO MANUALLY RAISE THE TAILGATE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000. *BF*JB

• 07/26/2020· FUEL/PROPULSION SYSTEM

  ON 4/25 WE NOTICED A SMELL OF GASOLINE WHEN DRIVING THE VEHICLE. WE HAD THE ISSUE CORRCETED ON 4/27/2020 AT A OUT OF POCKET COST OF $1090 2ND TIME SUBMITTING CLAIM. HAVE NOT RECEIVED ANY INFO ON ORIGINAL CLAIM FROM MAY 2020

• 07/25/2017· WHEELS

  RIGHT REAR TIRE BLEW OUT ON THE THRUWAY,CAUSING LOSS OF CONTROL AND BRAKING.

• 07/20/2026· ELECTRICAL SYSTEM

  The contact owns a 2012 Kia Sedona. The contact stated that the battery drained unexpectedly, and the vehicle failed to start. The battery was replaced twice, and the vehicle was temporarily repaired. The contact’s son replaced the alternator; however, the failure persisted. The vehicle was no longer operable. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 200,000.

• 07/16/2019· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTUREFire

  TL* THE CONTACT OWNS A 2012 KIA SEDONA. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE BOTH THE DRIVER SIDE AND PASSENGER SIDE DOOR WOULD ERRONEOUSLY OPENED. THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. ALSO, WHILE DRIVING SMOKE WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. AFTER STOPPING THE VEHICLE, THE DRIVER EXTINGUISHED THE FLAMES COMING FROM THE BLOWER MOTOR WIRE HARNESS LOCATED UNDER THE GLOVE BOX. ALSO THE FRONT LOW BEAM HEAD LIGHTS HAD FAILED ON MULTIPLE OCCASION AND HAD TO BE REPLACED AND THE BACKUP CAMERA WAS INOPERABLE. THE CAUSE OF THE FAILURES WERE NOT YET DETERMINED. THE LOCAL DEALER A & B KIA DEALER (100 MARSHALL ST. N, BENWOOD, WV 26031) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

• 07/15/2019· ELECTRICAL SYSTEM

  DRIVING ON RT 19 PITTSBURGH PA THE PASSENGER POWER SLIDING DOOR OPENED MY GRANDCHILDREN WERE IN CAR SEATS. THIS SHOULD HAVE BEEN INCLUDED IN THIS YEAR AS IT WAS KNOWN IN NEWER MODELS RECALL I MENTION TO DEALER AND HE STATED WELL NO ONE GOT HURT?

• 07/14/2019· ENGINE

  OIL PRESSURE WARNING LIGHT CAME ON WHILE TRAVELING ON THE HIGHWAY, TOOK IT TO MY DEALER. THEY ARE SAYING THE OIL PRESSURE SENSOR IS BAD AT ONLY 74,000 MILES. WAS QUOTED A PRICE OF $800 NOT COVERED UNDER THE POWER TRAIN WARRANTY

• 07/14/2019· STRUCTURE

  SLIDING PASSENGER SIDE DOOR OF THE VAN WILL NOT LATCH SHUT. WE HAVE TRIED THIS WITH THE POWER DOOR OPTION, AND ALSO MANUALLY. THE DOOR OPENS UNEXPECTEDLY WHILE DRIVING, BECAUSE OF THE FAULTY LATCH. THE LATCH FAILS, AND THE DOOR OPENS, WHILE STATIONARY AND WHILE IN MOTION, WITH VARYING SPEEDS, AND WHILE TURNING.