2011 BMW 535I Xdrive GT

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2016· ENGINE

  TL* THE CONTACT OWNS A 2011 BMW 5-SERIES. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE TIMING CHAIN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

• 12/29/2019· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  DRIVETRAIN MALFUNCTION IS ON MAY BE DUE TO A BAD FUEL PUMP OR ENGINE COILS

• 12/28/2018· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  DRIVETRAIN MALFUNCTION -DRIVING ON HWY WHEN ERROR WAS DISPLAYED AND CAR SHUTDOWN IN ON ME AND WOULD NOT START BACK UP -DEALERSHIP STATED THEY REPLACED THE FUEL PUMP -ISSUE HAPPENED AGAIN -WHILE DRIVING - UNDER 3000 MILES LATER - SAME ERROR CODES OF LOW PRESSURE - CAR HESITANT TO CRANK AND STUDDERING ON LOW SPEEDS- TOWED TO DEALER WAS TOLD NO ISSUE FOUND AND THEY REPROGRAMMED THE FUEL PUMP -SAME ISSUE AGAIN - FUEL LINE AND SENSOR REPLACED -RAN FINE FOR ANOTHER 1000 MILES OR SO -WHILE DRIVING THE CAR JERKED REALLY HARD AND GAVE THE SAME DRIVETRAN MALFUNCTION ERROR --WAS ABLE TO MAKE IT TO THE DEALERSHIP HOWEVER CAR WOULD NOT DRIVE AT FULL SPEED- SAME CODES SEEN STORED -- BMW DO NOT KNOW WHATS CAUSING THE ISSUE HOWEVER REPLACING PARTS HOPING IT WILL FIX THE ISSUE AND CHARGING ME FOR THEIR TRIAL AND ERROR. -SINCE 2 MORE PARTS REPLACED CAR NOW WITH NEW ERROR AND OF COURSE BMW HAS NO CLUE BUT WANT TO CHARGE ME ANOTHER 1000 TO REPLACE ANOTHER PART.

• 12/28/2010· STEERING

  TL* THE CONTACT OWNS A 2011 BMW 550I. THE CONTACT STATED THAT SHORTLY AFTER PURCHASING THE VEHICLE AND DRIVING AT VARIOUS SPEEDS HE NOTICED THAT THE VEHICLE WOULD PULL TO THE RIGHT ABNORMALLY. THE VEHICLE WAS TAKEN BACK TO THE DEALER IN WHICH THEY INSPECTED THE VEHICLE AND MADE REPAIRS BY PERFORMING AN ALIGNMENT AND OTHER UNKNOWN REPAIRS. THE FAILURE PERSISTED. IN ADDITION, THE STEERING WHEEL WAS EXHIBITING AN ABNORMAL GRINDING WHEN TURNING IN EITHER DIRECTION. HE THEN TOOK THE VEHICLE BACK INTO THE DEALER AND THEY REPLACED THE FRONT TORSION BAR BUT TO NO AVAIL. THE MANUFACTURER WAS CONTACTED AND THEY INFORMED THE CONTACT THAT IF HE WAS UNSATISFIED WITH THE VEHICLE THEN HE SHOULD TURN IT BACK IN TO THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 50.

• 12/26/2018· VISIBILITY

  TL* THE CONTACT OWNS A 2011 BMW 535I. WHILE THE CONTACT'S SPOUSE WAS DRIVING 20 MPH, THE SUN ROOF EXPLODED WITH A LOUD BLAST. THERE WERE NO INJURIES. THE CONTACT PULLED THE VEHICLE OVER IN A NEARBY PARKING LOT TO INSPECT THE VEHICLE AND DROVE HOME. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ASSIGNED A CASE MANAGER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 54,945.

• 12/26/2017· STRUCTURE

  OCCASIONALLY DRIVER'S DOOR CANNOT BE UNLOCKED AND OPENED FROM INSIDE USING REGULAR DOOR LATCH, THUS TRAPPING THE DRIVER IN VEHICLE. DOOR WILL HOWEVER UNLOCK IF THE LOCK/UNLOCK BUTTON ON THE DASH IS PRESSED. THIS HAPPENS ABOUT ONE IN EVERY EIGHT TO TEN TIMES OF OPENING THE DOOR.

• 12/23/2019· ENGINE,FUEL/PROPULSION SYSTEM

  CARE WAS IN MOTION ON LOCAL STREET CARE STARTED STALLING, DECREASE IN FUEL, SMOKE OUT OF TAIL PIPE, COMPLETE ENGINE FAILURE, UNABLE TO START ON ENGINE. THERE ARE MULTIPLE FORUMS ON THIS SPECIFIC VEHICLE WITH ISSUES DUE TO FUEL INJECTOR. SINCE I AM NOT THE ORIGINAL BUYER ON VEHICLE I WAS NOT AWARE AND WAS NEVER NOTIFIED BY THE NEW DEALER THAT THERE WOULD BE AN ISSUE. VEHICLE WAS BOUGHT AT 126K MILES IN SEPT 2019.

• 12/23/2010· SUSPENSION

  TL*THE CONTACT OWNS A 2011 BMW 550I. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A RATTLING NOISE COMING FROM THE PASSENGER SIDE FRONT END OF THE VEHICLE. THE STEERING WHEEL BEGAN TO VIBRATE. THE FAILURE OCCURRED WHENEVER ENCOUNTERING A SLIGHT IMPERFECTION IN THE ROAD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING WHERE THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FRONT END SUSPENSION FAILURE. THE TECHNICIAN TEST DROVE A SIMILAR MODEL YEAR VEHICLE WHICH EXHIBITED THE IDENTICAL FAILURE. THE VEHICLE WAS AT THE DEALER FOR A MONTH AND REMAINED THERE FOR FURTHER INVESTIGATION. THE FAILURE MILEAGE WAS 1,100.

• 12/19/2017· ENGINE

  OUR 2011 BMW 535I EXPERIENCED A FAILURE OF THE VANOS BOLTS WHICH MADE THE CAR INOPERABLE AND REQUIRED A $5,000 REPAIR. RESEARCH REVEALED THAT BMW RECALLED APPROXIMATELY 165,000 CARS MANUFACTURED IN THE SAME TIME FRAME AS OUR CAR FOR THE SAME PROBLEM AND EXTENDED THE WARRANTY FOR MANY OTHERS. WHEN WE CONTACTED BMW NORTH AMERICA ABOUT THE REPAIR COST THEY WOULD PROVIDE NO INFORMATION ABOUT WHY OUR CAR WAS NOT INCLUDED IN THE RECALL/EXTENDED WARRANTY. WE WOULD LIKE TO KNOW WHICH CARS WERE RECALLED BY BMW AND BETTER UNDERSTAND WHY OUR CAR WAS EXCLUDED.

• 12/18/2016· ENGINE

  CONTACTED THE LOCAL BMW DEALERSHIP REGARDING THE "FAULTY VANOS BOLTS" THEY TOLD ME THAT MY CAR IS NOT AFFECTED BY THE FAULTY BOLTS WEEK LATER CAR BROKE DOWN DUE DEFECTIVE VANOS BOLT

• 12/08/2021· ENGINE

  My car is leaking oil from one of the rings in the engine and it’s leaking on the manifold

• 12/08/2018· FUEL/PROPULSION SYSTEM

  FUEL SYSTEM WAS THE ALARM ON THE CAR AND IT WON'T STAY STARTED ON MORE THAN 2 SECONDS. FINAL AFTER 4 ATTEMPTS IT WON'T START AT ALL. HAD TO GET THE VEHICLE TOWED.

• 12/08/2016· AIR BAGSCrash

  IN MAY, 2014 I WAS DRIVING AT APPROXIMATELY 50 MILES PER HOUR ON THE OLD VALDOSTA HIGHWAY WHEN A SCHOOL BUS RAN A STOP SIGN AND T-BONED ME ON THE DRIVERS SIDE AND NONE OF THE AIRBAGS DEPLOYED. *TR

• 12/06/2022· ENGINE AND ENGINE COOLING

  The contact owns a 2011 BMW 335I. The contact stated that while driving at various speeds, the vehicle lost motive power and stalled with the check engine warning light illuminated. The contact inspected the vehicle and discovered that the bolts used to secure the housing for the camshaft timing adjustment (VANOS) unit had loosened over time, causing the vehicle to stall. Upon investigation, the contact discovered NHTSA Campaign Number: 14V176000 (Engine and Engine Cooling) which he linked to the failure. The contact called two dealers and the manufacturer and was informed that the vehicle was not under recall. The vehicle was not repaired. The failure mileage was approximately 129,000.

• 12/06/2016· AIR BAGS

  2011 BMW S335I. CONSUMER REQUESTS PERMISSION TO DEACTIVATE DRIVER AND PASSENGER AIRBAG MODULES UNTIL REPLACEMENT PARTS BECOME AVAILABLE. *SMD

• 12/06/2010· STEERING

  VEHICLE RAN OFF OF RIGHT EDGE OF ROAD DUE TO STEERING PULLING TO THE RIGHT. RIGHT WHEELS/TIRES SUFFERED $2400 DAMAGE. TIRES/WHEELS REPLACE, ALIGNMENT DONE AND CAR STILL PULLS TO THE RIGHT. THIS IS A DEFECT FROM BMW - NUMEROUS US OWNERS ARE EXPERIENCING PROBLEMS WITH STEERING ON 2011 BMW 5 SERIES CARS (SEE OTHER NHTSA REPORTS). *TR

• 12/05/2019· ENGINE

  2011 535XI WITH 95,000 MILES WAS SERVICED AND PASSED ALL INSPECTIONS, LESS THAN 700 MILES LATER ENGINE STARTS MAKING A KNOCKING SOUND WHILE DRIVING. IMMEDIATELY STOPPED AND TOWED TO DEALER WHERE THEY FOUND METALLIC SHAVINGS IN OIL FILTER. SAID ENGINE NEEDED TO BE REPLACED AT A COST OF $36,591 BUT OFFERED NO CAUSE FOR THE FAILURE.

• 12/03/2014· ELECTRICAL SYSTEM,AIR BAGS,SEAT BELTSCrash

  INVOLVED IN AN ACCIDENT. OTHER VEHICLE GOING SOUTHBOUND CROSSED OVER MEDIAN STRIP OF HIGHWAY, HIT THREE CARS GOING NORTHBOUND, MINE WAS THIRD CAR TO BE STRUCK. OFFENDING CAR DID A 360 IN FRONT OF ME, I SLOWED TO ABOUT 25 AND HE MOVED INTO ME. I STRUCK HIS REAR PASSENGER SIDE CORNER. I HAD FRONT END DAMAGE OVER $5K. NO AIRBAG, BUT DEFAULT MESSAGES AND AN AIRBAG ICON CAME ON THE VIDEO SCREEN AND THE FRONT INSTRUMENT PANEL. IT STATES "DRIVER AND PASSENGER AIRBAG OR RESTRAINT SYSTEM MALFUNCTION." *JS

• 12/03/2011· TIRES,WHEELS

  MY 2011 BMW 550IX HAS GOODYEAR EAGLE LS 2 RUN FLATS, 245/40. I TOOK DELIVERY OF THE CAR IN JULY 2011 AND HAD BUBBLES ON THE LEFT FRONT TIRE IN LESS THAN A MONTH PERIOD. I JUST NOTICED THAT I AM NOT THE ONLY ONE WITH SUCH PROBLEM AND WANT TO TAKE MY PART IN REPORTING THIS BUBBLE PROBLEM WITH THIS RUN FLAT TIRES. *TR

• 12/02/2013· WHEELS

  BUBBLE IN SIDEWALL OF RIGHT FRONT TIRE. TIRE REPLACED LESS THAN 2 MONTHS AGO. MINIMAL DRIVING, COMBINATION HIGHWAY/ROADS. *TR

• 12/01/2018· STEERING,POWER TRAIN,ENGINE

  WHILE MAKE TURNS WHILE DRIVING THE VEHICLE AXEL MAKES POPPING NOISE AND STEERING WHEEL JERKS VIOLENTLY. TOOK TO SHOP THEY SAID NOTHING FOUND WRONG WITH CAR. CV AXEL REPLACED ON BOTH SIDES PROBLEM STILL PERSISTS.ALSO NOT EVEN 10K MILES THE CAR WENT THRU 2 BELT TENSIONER CAUSING THE DRIVE BELT TO SNAP/TEAR.

• 11/30/2016· SEATS

  THE MEMORY POWER SEAT IN MY CAR MALFUNCTIONED AND WENT BACK WITHOUT STOPPING CAUSING A FRACTURE TO MY 2 1/2 YEAR OLD SON'S LEG WHO WAS SITTING IN THE CAR SEAT DIRECTLY BEHIND ME. THE VEHICLE WAS PARKED AT THE TIME OF THE INCIDENT. *TR

• 11/29/2018· UNKNOWN OR OTHERFire

  MY WIFE WENT TO GET A HAIRCUT, PARKED HER 2011 BMW 535XI AWD AT APPROXIMATELY 1:30 P.M. MST (THE ENGINE WAS TURNED OFF AND THE CAR WAS LOCKED) IN THE RETAIL CENTER PARKING LOT. AT APPROXIMATELY 2:45 P.M. MST SOMEONE ENTERED THE SALON AND SAID A CAR WAS ON FIRE (HER CAR). THE FIRE APPEARS TO HAVE BEEN IN THE BACK SIDE OF THE ENGINE COMPARTMENT ON THE PASSENGER SIDE. THE FIRE DEPARTMENT ARRIVED AND PUT OUT THE FIRE. IT IS CONCERNING A PARKED CAR THAT WAS TURNED OFF AND LOCKED STARTED ON FIRE. THANKFULLY FOR MY WIFE AND TWO CHILDREN WHO ARE USUALLY WITH HER THE CAR DIDN'T CATCH FIRE WHEN THEY WERE IN THE CAR OR WHILE IT WAS PARKED IN OUR HOME GARAGE IN CLOSE PROXIMITY TO MY SON'S BEDROOM. I RESEARCHED THE ISSUE ONLINE AND FOUND MANY OTHER BMW OWNERS HAVE EXPERIENCED THE SAME PROBLEM AND THAT BMW ISSUED A RECALL TO FIX THE ISSUES. I CHECKED OUR CAR FOR RECALLS TONIGHT AND BOTH THE BMW SITE AND NHTSA SITE SHOWED ZERO OPEN RECALLS. PLEASE ADVISE ON WHAT STEPS WE SHOULD DO TO ENSURE THIS TRAGIC EVENT DOESN'T OCCUR TO OTHER OWNERS.

• 11/28/2011· TIRES

  MY 2011 BMW 550XI HAS GOODYEAR EAGLE LS 2 RUN FLATS, 245/40. I TOOK DELIVERY OF THE CAR IN JUNE 2011 AND HAVE HAD REPEATED BUBBLES ON THE FRONT TIRES. FOUR TIRES HAVE BEEN REPLACED TO DATE. I HAVE NEVER HAD AN ISSUE WITH TIRES FOR THE LAST 20 YEARS. THE BMW DEALER IS NOT ABLE TO SAY WHETHER IT IS DANGEROUS TO DRIVE ON TIRES WITH BUBBLES. *KB

• 11/27/2020· POWER TRAIN

  A WARNING CAME ON FOR DRIVETRAIN MALFUNCTION AND THE ENGINE STARTED TO CHOKE AND LOSE POWER WHILE DRIVING.

• 11/10/2011· TIRES

  I TOOK MY 2011, 5351 BMW IN FOR IT'S FIRST SERVICE AND WAS TOLD BY THE SERVICE DEPARTMENT THAT THE 2 FRONT TIRES (GOODYEAR EXCELLENCE RUNONFLAT) HAD BUBBLES OR BULGES IN THE SIDE WALLS AND THAT THEY SHOULD BE REPLACED. I SAW ON LINE THAT OTHERS HAD A SIMILAR PROBLEMS SO I CONTACTED THE BMW SERVICE AGAIN AND WAS TOLD TO CONTACT GOODYEAR. I WENT TO A LOCAL GOODYEAR DEALER WHO CALLED GOODYEAR AND I SPOKE WITH A CLAIMS WOMAN WHO WROTE UP A CLAIM. SHE CONTACTED BMW DEALER AND DEALER CALLED ME. I WAS TOLD THAT ALL OR PART OF REPLACEMENTS COSTS WILL BE COVERED. I AM SCHEDULED ON MONDAY TO DROP CAR OFF TO SEE WHAT WILL BE DONE TO CORRECT THIS DEFECT. *TR

• 11/09/2011· ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

  THERE IS A VERY NOTICEABLE DELAY WHEN ACCELERATING FROM A STOP BEFORE POWER IS DELIVERED TO THE WHEELS. THIS HAS POTENTIALLY DANGEROUS IMPLICATIONS IN SITUATIONS WHERE THE NEED FOR POWER DELIVERY IS IMMEDIATE. *TR

• 11/07/2011· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2011 BMW 5 SERIES. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT APPROACHED A STOP SIGN AND DEPRESSED THE BRAKE PEDAL WHEN THE VEHICLE SUDDENLY ACCELERATED ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE FAILURE OCCURRED DUE TO DRIVER ERROR. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. AN ENGINEER WAS SENT TO INSPECT THE VEHICLE AND PERFORMED SOFTWARE UPDATES. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.

• 11/04/2017· ENGINE

  THERE ARE WIRES ON THE ENGINE THAT ARE CRACKING AND WAS TOLD BY THE BMW DEALER THAT THIS CAN CAUSE A FIRE.

• 11/04/2017· POWER TRAIN

  CAR SHOWS ERROR OF DRIVETRAIN MALFUNCTION AND THE CAR STARTS TO SHAKE.

• 11/04/2017· UNKNOWN OR OTHER,ENGINE

  POSITIVE CRANKCASE VENTILATION PCV VALVE HEATER THIS IS A RECALL BMW STATES REMEDY NOT AVAILABLE YET.

• 10/28/2016· ENGINE

  TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING). AFTER THE REPAIR, THE VEHICLE EXPERIENCED ENGINE FAILURE. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

• 10/27/2011· TIRES

  REPEATED SIDEWALL BUBBLES ON MY GOODYEAR EAGLE LS 2 TIRES, 245/40 R19, AND NEED FOR REPLACEMENT, BOTH FRONT TIRES IN TWO SEPERATE INCIDENTS, WITH LESS THAN 7,000 MILES ON THE CAR, AFTER HITTING MINOR BUMPS IN THE ROAD. THEY ARE UNRELIABLE AND DANGEROUS. *TT

• 10/26/2011· TIRES

  ORIGINAL TIRES ON BMW 550I XDRIVE WITH M SPORT PACKAGE HAVE FAILED DUE TO BUBBLES IN THE SIDEWALLS. THESE ARE GOOD YEAR EAGLE LS-2 RUNFLATS, 245/40R19 98 V. I HAVE HAD FRONT RIGHT TIRE REPLACED TWICE, AND FRONT LEFT TIRE NOW AWAITING 3RD REPLACEMENT. BUBBLES OCCUR AFTER TIRE TAKES ANY SMALL IMPACT IN THE ROAD, SUCH AS DRIVING OVER A MANHOLE THAT IS NOT QUITE UP TO THE LEVEL OF THE PAVEMENT, OR HITTING A SMALL POTHOLE. ON THIS PARTICULAR MODEL, THERE ARE NO OTHER TIRE REPLACEMENTS APPROVED, AND THE CURRENT TIRE REPLACEMENT IS ON BACKORDER. THIS IS A SERIOUS SAFETY HAZARD TO DRIVE ON TIRES THAT CAN POTENTIALLY BLOW OUT THE SIDEWALL WHILE DRIVING AT HIGH SPEED. I FEEL THERE NEEDS TO BE A NATIONAL RECALL ON THESE TIRES, WHICH WOULD THEN OBLIGATE BMW TO USE A DIFFERENT TIRE LINE. THANK YOU. *TT

• 10/24/2019· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  MY VEHICLE CUT OFF WHILE DRIVING DRIVE TRAIN/ DRIVE SHAFT MESSAGE CAME ON WHICH MADE MY ENGINE LIGHT COME ON SHUDDERING WITH HEAVY SHAKING MAKING WEIRD NOISES WHICH ARE THE SYSTEMS OF A DEFECTED DRIVE SHAFT SAME SYMPTOMS THAT APPLY TO RECALL 17V067000 VERY SCARY MY VEHICLE WAS JUST AT BMW DEALERSHIP FOR A RECALL DUE TO AN AGGRESSIVE FUEL LEAK...,I ASKED ABOUT THE RECALL FOR THE DRIVE TRAIN I WAS ADVISED YES IT'S A RECALL BUT NOT FOR MY VEHICLE WHICH IS A 2011 535I AT THE TOP OF THE RECALL LIST THIS IS VERY DANGEROUS AND THE 2ND TIME THIS CAR HAVE PUT MY LIFE IN DANGER HOW CAN YOU HAVE A RECALL ON THE 2011 535I AND THEN SAY NOT MY SPECIFIC VEHICLE BMW IS THE WORST I WILL NEVER PURCHASE ANOTHER BMW I CANNOT BELIEVE IT THESE PARTS CANNOT BE FROM WEAR AND TEAR THIS STARTS FROM PRODUCTION OF VEHICLE

• 10/24/2016· FUEL/PROPULSION SYSTEM

  MY CAR IS A 2011 BMW 535 I X DRIVE, HAS 68,000 MILES. I BOUGHT IT NEW ON 10/19/2011 ON FRIDAY 10/21/2016 MY CAR STALLED AND WOULDN'T START WHILE DRIVING IN THE MIDDLE OF A MAIN HIGH TRAFFIC BUSY ROAD IN RUSH HOUR. LUCKILY, I DIDN'T HAVE A CRASH AND I CALLED BMW ROADSIDE ASSISTANCE, THEY SAID "THIS SERVICE IS NO LONGER AVAILABLE" TO ME. I CALLED MY INSURANCE ROADSIDE ASSISTANCE AND THEY TOWED THE CAR TO THE NEAREST BMW DEALER (WHERE I BOUGHT IT FROM). THE DEALER SERVICE DEPT. SAID THAT THE CAR WAS ON EMPTY (NO GAS) EVEN THOUGH THE FUEL SENSOR LIGHT DIDN'T COME ON AND IT SHOWED 70 MILES LEFT TO EMPTY. AFTER RESEARCHING BMW RECALLS I FOUND THIS PROBLEM WAS RECALLED FOR 2010 AND 2011 5 SERIES. I NEVER RECEIVED A RECALL LETTER. DEALER SERVICE DIDN'T BELIEVE ME FIRST AND SAID THAT I DROVE IT ON EMPTY AND JUST NEEDED GAS AND WANTED ME TO PICK IT UP AFTER THEY PUT IN 3 GALLONS OF GAS. I INSISTED THAT THAT WHAT HAPPENED, THE SENSOR LIGHT DIDN'T COME ON AND IT SHOWED 70 MILES LEFT. THEY WERE NOT AWARE OF THE PROBLEM OR THE RECALL. THE CAR IS STILL THERE AND THEY GAVE ME A SMALL CHEAP LOANER CAR WHICH I HAVE NOW. THIS COULD BE A MAJOR SAFETY HAZARD AND SHOULD BE TAKEN SERIOUSLY, NOT JUST ADD GAS AND GO. THANKS, REPORT RECEIPT DATE: JUL 22, 2010 NHTSA CAMPAIGN NUMBER: 10V331000 COMPONENT(S): FUEL SYSTEM, OTHER MAKES/MODELS/MODEL YEARS: BMW/5-SERIES/2010-2011 BMW/5-SERIES GRAN TURISMO/2010-2011 NHTSA CAMPAIGN NUMBER: 10V-331 MFG'S REPORT DATE: JULY 21, 2010 COMPONENTS: FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM POTENTIAL NUMBER OF UNITS AFFECTED: 6,080 SUMMARY: BMW IS RECALLING CERTAIN 2010 AND 2011 5-SERIES AND 5-SERIES GRAN TURISMO PASSENGER VEHICLES MANUFACTURED FROM JANUARY 12 THROUGH JULY 1, 2010. THE VEHICLE'S FUEL LEVEL SENSOR WITHIN THE FUEL TANK CAN BECOME WEDGED AGAINST THE TANK.

• 10/24/2011· TIRES

  MY 2011 BMW 535XI TIRE (245/40R-19 GOODYEAR EAGLE LS-2 RUNONFLAT BMW RUNFLAT X) NEEDED TO BE CHANGED TWICE IN ONE YEAR DUE TO BUBBLE ON TIRE WALL. I DO NOT REMEMBER GOING OVER ANY POTHOLES OR BUMPS. *TR

• 10/23/2019· ENGINE

  THE VEHICLE (2011 BMW 535I GT) INDICATED THAT IT WAS OVERHEATED AFTER DRIVING FOR ABOUT 25 MINUTES IN THE CITY AND HIGHWAY. THE VEHICLE AUTOMATICALLY SLOWED DOWN AND WOULD NOT ACCELERATE. FAN WAS CONTINUALLY RUNNING AFTER VEHICLE WAS STOPPED ON THE SIDE OF THE HIGHWAY AND WHEN THE VEHICLE WAS TURNED BACK ON HOURS LATER. TOOK THE VEHICLE TO A LOCAL MECHANIC WHO SAID IT WAS THE AUXILIARY WATER PUMP THAT NEEDED TO BE REPLACED. BMW HAS A RECALL BUT THE 535I GT IS NOT IN THE RECALL, THE 550I GT IS. THE RECALL SHOULD BE LOOKED AT FOR EXPANSION.

• 10/22/2014· AIR BAGS,SEATS

  I WAS DRIVING AT AROUND 20 MPH WITH A FRIEND OF MINE SITTING ON THE PASSENGER SEATS AND THE CAR SYSTEM TELLS ME "PASSENGER RESTRAINT SYSTEM MALFUNCTION. CONTINUE TO WEAR SEAT BELT." I CHECKED ONLINE AND ITS BECAUSE SENSORS FOR THE AIR BAG SYSTEM ARE MALFUNCTIONING. THIS HAS BEEN A PROBLEM IN ALL BMWS SINCE 2006. I READ ONLINE THAT IT REOCCURS FREQUENTLY AND THAT I WILL HAVE TO PAY AT LEAST $1200 TO REPAIR IT IF I AM OUT OF WARRANTY. I WILL HAVE TO PAY ATLEAST $150 FOR DIAGNOSTICS. I STRONGLY FEEL I SHOULD NOT BE THE ONE PAYING FOR BMWS MISTAKE AT ANY GIVEN TIME. BMW HAS RECALLED AROUND 200,000 CARS AFFECTED BY THIS PROBLEM AND HAVE EXTENDED THE WARRANTY PROGRAM FOR 10 YEARS FOR THE AFFECTED CARS. THIS IS A SERIOUS LIABILITY ISSUE. INCASE I AM IN AN ACCIDENT TOMORROW AND THE AIR BAGS ARE NOT DEPLOYED, IT COULD LEAD TO THE LOSS OF ONE'S LIFE. I URGE BMW TO LOOK INTO THIS ISSUE AS SOON AS POSSIBLE. MY CAR HAS NEVER BEEN IN AN ACCIDENT, NEVER IN FLOODS AND NEITHER IN FIRE. I HAVE ABSOLUTELY NO INCIDENTS WITH THE CAR. I HAVE A RECALL FOR THE VANOS BOLTS THAT AFFECTS THE ENGINE AS WELL AND I STILL HAVE NOT HEARD FROM BMW. INCASE THE BOLTS GO OFF THE ENGINE WOULD LOSE POWER AND IT COULD LEAD TO A UNFORTUNATE CIRCUMSTANCE. THESE BOTH ISSUES ARE LIFE THREATENING AND NEEDS TO BE FIXED RIGHT AWAY. I REQUEST YOU TO URGENTLY LOOK INTO THE MATTER. *TR

• 10/21/2017· POWER TRAIN

  DRIVE TRAIN MALFUNCTION, ENGINE OVER HEATS AND DOES NOT FUNCTION THE SAME. THE VEHICLE SLOWS DOWN, SPUTTERS AND DOES NOT HAVE POWER. IT HAS DIED OUT ON THE HIGHWAY WHILE GOING 65MPH AND HAD TO PULL OVER SUDDENLY THROUGH 3 LANES OF TRAFFIC.

• 10/21/2017· POWER TRAIN,FUEL/PROPULSION SYSTEM

  IT HAS ACCELERATION ISSUES ALL OF THE TIME. DOES NOT ACCELERATE AS IT SHOULD, INSTEAD IT JERKS. WHEN AT A STOP SIGN OR LIGHT AND LOOKING TO ACCELERATE IT WOULD JERK MAKING IT UNSAFE. I HAVE ALMOST HIT MULTIPLE VEHICLE ECAUSE OF THIS.

• 10/21/2017· POWER TRAIN

  WHILE DRIVING DRIVE TRAIN LIGHT COMES ON, MADE APPOINTMENT AND WAS INFORMED THAT THE LEFT CV JOINT BOOT WAS TORN AND LEAKING. HAD IT FIXED ON OCTOBER 2016, PAID OVER $1700. IN SEPTEMBER 2017 DRIVE TRAIN LIGHT COMES ON AGAIN, WAS INFORMED THAT THE LEFT AND THE RIGHT CV JOINT BOOTS WERE TORN/LEAKING HAD IT REPAIRED AND THIS TIME IT COST $4094. NOTICED THAT THERE WAS A RECALL FOR THE REAR CV JOINT AND WANT TO KNOW IF THE FRONT SHOULD BE INCLUDED IN THE RECALL.

• 10/20/2014· ENGINE AND ENGINE COOLING,ENGINE

  VEHICLE RUNS ROUGH. MURRAY BMW DENVER, COLO AGREED THAT THERE IS A RECALL ISSUED BY BMW FOR THIS PROBLEM BUT AS OF YET THEY ARE UNABLE TO REPAIR IT AS BMW OF NORTH AMERICA HAS NOT PROVIDED THE NECESSARY PARTS TO MAKE THE REPAIR.(SEE RECALL CAMPAIGN NO. 14V-176: VANOS ASSEMBLY BOLTS). *TR

• 10/20/2011· POWER TRAIN

  THIS CAR WAS PURCHASED ON 10/7/2011 AND WITHIN THE FIRST WEEK I REPORTED A PROBLEM WITH THE TIMING STATING THE CAR SEEMS TO HAVE A LAG ON TAKE OFF FROM A STOP. SALESMAN STATED HE WAS UNAWARE OF ANY PROBLEMS. ONE WEEK AFTER PURCHASE WHILE DRIVING AT 50MPH ON A HIGHWAY, A WARNING STATEMENT WAS DISPLAYED 'MAXIMUM DRIVETRAIN NOT AVAILABLE' AND CAR IMMEDIATELY DECELERATED TO 30MPH...VERY LUCKY TO BE ABLE TO GET OFF THE ROAD. AFTER TAKING TO THE DEALERSHIP, THEY SAID THEY COULD NOT FIND ANY PROBLEMS. THREE DAYS LATER I HAD THE SAME PROBLEM NOW GOING 60MPH. BACK INTO THE DEALER I ALSO COMPLAINED ABOUT THE CONTINUAL LAG IN ACCELERATION AFTER STOPS AND THEN LURCHING FORWARD. JUST RECEIVED A MESSAGE THAT THEY WERE REPLACING THE MASTER AIR FLOW SENSOR. THIS CAR IS DANGEROUS AND I WANT IT RETURNED TO DEALER. *TR

• 10/18/2017· FUEL/PROPULSION SYSTEM

  I WAS DRIVING MY BMW 535 XI ON INTERSTATE HIGHWAY. ALL OF A SUDDEN CARS GAVE A MESSAGE OF "DRIVETRAIN MALFUNCTION: CONTACT YOUR SERVICE CENTRE". AFTER THAT CAR'S POWER REDUCED. AFTER THAT WHENEVER I APPLY BRAKE, THE CAR IGNITION STOPPED AND CAR PUTS ITSELF IN NEUTRAL. I HAD TO START THE CAR AROUND 8 TIMES TO REACH HOME SAFELY. AFTER THAT I TOWED THE CAR TO NEARBY BMW SERVICE. BMW DEALERSHIP TOLD ME THAT MY CAR'S HIGH PRESSURE FUEL PUMP IS NOT WORKING. THIS IS TRAUMATIC EXPERIENCE AS I WAS ON INTERSTATE AND SUDDEN STALLING ON INTERSTATE COULD HAVE BEEN FATAL FOR ME AS WELL AS MY PASSENGER.

• 10/15/2020· FUEL/PROPULSION SYSTEM

  TRYING TO CHANGE LINE GO SEVENTH MILES CAUSES THE CAR TO GO IN LIMP MODE

• 10/12/2012· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS CONFIRMED THAT THE REMOTE CONTROL KEY FAILED, WHICH CAUSED A DISCHARGE IN THE BATTERY. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE DEALER THEN REPLACED THE REMOTE KEY HOWEVER, THE FAILURE RECURRED APPROXIMATELY TWO MONTHS LATER. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE WHERE THE REMOTE KEY BATTERY WAS RECHARGED SEVERAL TIMES, AS WELL AS REPLACED. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHERE IT REMAINED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 3,100 AND THE CURRENT MILEAGE WAS APPROXIMATELY 18,000.

• 10/11/2021· ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

  Passenger side door lock actuator has failed. Door lock actuators should not be failing on cars that are less than 10m years old. This causes a major safety issue when you are unable to open/unlock the door from the inside or outside because the lock can not be actuated (manually or with button). Given the vast amount of actuators failing, this should be addressed with BMW. This has become a common issue with BMW vehicles.

• 10/10/2016· ELECTRICAL SYSTEM

  WHEN TRYING TO EXIT THE CAR AND PULLING ON THE DOOR HANDLE, THE DOOR DOES NOT UNLOCK, THE LOCK STAYS IN A LOCKED POSITION EVEN AFTER MULTIPLE PULLES. THE ISSUE HAS BEEN DIAGNOSED AS THE DOOR LOCK ACTUATOR. THIS IS A SAFETY ISSUE AS YOU ARE UNABLE TO GET OUT OF THE CAR. I WAS ABLE TO USE THE MANUAL UNLOCK BUTTON TO OPEN THE DOOR.

• 10/05/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2011 BMW 528I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD HESITATE WHENEVER HE ATTEMPTED TO SLOW DOWN OR IMMEDIATELY AFTER THE ACCELERATOR PEDAL WAS ENGAGED. THE DEALER WAS INFORMED ABOUT THE FAILURE AND STATED THAT IT WAS NORMAL; HOWEVER, SHIFTING INTO SPORT MODE WOULD PREVENT THE FAILURE FROM OCCURRING. THE FAILURE OCCURRED EVERY TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 500 AND THE CURRENT MILEAGE WAS 1575.