2010 Ford Explorer

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2014· POWER TRAIN

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO SHIFT OUT OF PARK. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

• 12/30/2022· ENGINE

  Oil leak in both valve gasket covers oil on the crossmember it started slow then it was traced by Ford to the gaskets(fire hazard) 120 k on odometer

• 12/20/2018· POWER TRAIN

  TRUCK RECENTLY START HAVING PROBLEMS, HAS CORRECT AMOUNT OF TRANSMISSION FLUID, EVERYTHING. TRANSMISSION LIGHT CAME ON CAR STALLED, RESTARTED THE CAR TGE CAR DROVE BUT ACTED LIKE IT WAS SLIPPING, LIGHT STILL ON, TOOK IT TO MECHANIC... THE LIGHT DID NOT GIVE ANY CODES OF ANY SORT ON ANY OF THEIR SCAN TOOLS CAR DRIVES FINE TODAY KIND OF, IT "FALLS" OUT OF GEAR WHEN I COME TO A STOP AND KINDA STUTTERS WHEN I BEGIN TO DRIVE. AGAIN THERE SHOULD BE NO REASON FOR THIS UNLESS A MANUFACTURER DEFECT IS THE CAUSE. CORRECT FLUID LEVELS, CLEAN FLUID, REGULARLY CHANGED AS SCHEDULED IN THE MANUAL. VEHICLE ONLY HAS 119,XXX MILES. RIDICULOUS. NOTE THE LIGHT DOES NOT EVEN COME ON ANYMORE.

• 12/17/2012· SERVICE BRAKESCrash

  I WAS STUCK IN TRAFFIC AND AS I WAS AT A FULL STOP, I SAW THAT THE CAR IN FRONT OF ME HAD MOVED. SO I BEGAN TO ACCELERATE. WHEN I SAW THE CAR IN FRONT OF ME HAD STOPPED, I WENT TO HIT THE BRAKES AND NOTHING HAPPENED. I HIT THEM AGAIN AND STILL NOTHING, MY CAR KEPT ON GOING. BY THE THIRD SLAM ON THE BRAKES IT FINALLY TOOK HOWEVER I ENDED UP HITTING THE CAR IN FRONT OF ME AND HER THE CAR IN FRONT OF HER. THIS IS NOT OKAY!!! MY VEHICLE IS ONLY 2 YEARS OLD AND I'M NOT THE ONLY ONE WHO HAS EXPERIENCED THIS. WHY HASN'T A RECALL OCCURRED? DOES SOMEONE NEED TO PASS AWAY FOR ONE TO HAPPEN? MY ACCIDENT COULD HAVE BEEN WORSE. AT THE HOUR I WAS TRAVELING THERE IS NORMALLY NO TRAFFIC BUT OPEN HIGHWAY. MY SAVING GRACE WAS THAT THERE WAS TRAFFIC BECAUSE I COULD HAVE BEEN KILLED AND/OR KILLED THE PERSON I ACCIDENTALLY HIT. *TR

• 12/17/2010· ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM

  WE RENTED A 2011 4X4 EXPLORER FOR A SKI TRIP TO TAHOE. ONCE WE CAME OFF THE PASS, THE RSC LIGHTS CAME ON. THE ANTILOCK AND SLIP LIGHTS ALSO CAME ON. THE CAR LOST ALMOST ALL BRAKING ABILITY ON SNOWY ROADS. IT WAS UNDRIVABLE AND SCARY. THE RENTAL CAR COMPANY RESPONDED IMMEDIATELY AND SENT A NEW VEHICLE OUT TO US GIVEN THE GRAVITY OF THE SITUATION. WE HAD CHAINS ON THE REAR TIRES WHEN THIS HAPPENED. WE HAD 4 KIDS INTHE CAR. HAD THE PROBLEM HAPPENED ON THE PASS, WE COULD HAVE GONE OFF THE CLIFF. WE ALMOST RAN INTO PEOPLE AND A LIGHT POLE. *TR

• 12/15/2009· SEATS

  THE HEAD REST ON MY 2010 FORD EXPLORER LEANS SO FAR FORWARD THAT IT FORCES MY HEAD DOWN AND FORWARD. THE DEALER CANNOT ADJUST IT SO THAT YOU CAN SIT NORMALLY. THE ONLY RECOURSE IS TO REMOVE THE HEAD REST. THIS IS A SAFETY ISSUE BECAUSE YOU CAN'T DRIVE WITH IT AND REMOVING IT REMOVES ANY PROTECTION. *TR

• 12/05/2022· AIR BAGS

  The air bag light will not go off. I have checked the the wiring, cleared the area, and checked all fuses. All checked out okay. I'm a new buyer and can't register the car until it passes inspection. My only conclusion is that it possibly has a defect or has been previously been deployed. There is no record of a previous collision as of yet, although that may not be factual as the car has had a drivers door panel replaced. Can you help with the air bag information? Also, Is there a financial aid grant or some help in obtaining/repairing the problem for low or no income families? Thank you for your time in this matter. Sincerely, Kelly F. kewkarooo@gmail.com

• 12/04/2015· AIR BAGS

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. AFTER THE VEHICLE WAS STARTED, THE DRIVER SIDE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

• 12/03/2009· SEATS

  TL*THE CONTACT OWNS A 2010 FORD EXPLORER. THE HEADREST ON THE DRIVER AND PASSENGER EXTENDS OUTWARD WHICH FORCES THE PASSENGER AND DRIVERS HEAD FORWARD. THE CONTACT HAS EXPERIENCED DISCOMFORT WHILE DRIVING EVEN WHEN HE ATTEMPTED TO REST HIS SHOULDERS AGAINST THE BACK OF THE SEAT. THE VEHICLE WAS PURCHASED SEVEN DAYS AGO WITHOUT HIM TEST DRIVING IT. THE DEALER ADVISED THE CONTACT THAT THEY WERE UNABLE TO MAKE ANY REPAIRS SINCE ALL OF 2010 FORD EXPLORERS WERE DESIGNED WITH THAT TYPE OF HEADREST. THE DEALER RECOMMENDED THAT THE CONTACT ROTATE THE HEADREST; HOWEVER, THE DRIVER STATED THAT THE HEADREST WOULD NOT SERVE IT?S PURPOSE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 100.

• 12/02/2014· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT THE HEADLIGHT SWITCH FRACTURED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE HEADLIGHT SWITCH BEZEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

• 12/02/2013· POWER TRAIN

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT HE WAS UNABLE TO SHIFT THE VEHICLE OUT OF PARK. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THAT THE SHIFTER ASSEMBLY WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

• 12/01/2011· SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

  I WAS APPROACHING A RED LIGHT AND PRESSED THE BRAKE. THERE WAS A TRUCK INFRONT OF ME, THE HARDER I PUSHES THE BREAK THE MORE THE ENGINE TRIED TO ACCELERATE. THE TIRES WERE SCREECHING BUT THE ENGINE WAS STILL TRYING TO GO. ME AND MY KIDS COULD HAVE BEEN SERIOUSLY INJURED AND I WOULD HAVE BEEN HELD RESPONSIBLE FOR HITTING ANOTHER VEHICLE IN THE REAR END. I HAVE AN APPOINTMENT TO TAKE IT TO THE DEALERSHIP TOMORROW. HOPING THEY CAN FIND A FIX BEFORE IT SERIOUSLY INJURES MY FAMILY OR SOMEONE ELSE'S LOVED ONES. *TR

• 11/29/2018· POWER TRAIN

  "TAKATA RECALL"-DIAGNOSIS/ENGINE LIGHT(WRENCH COMING UP ON SCREEN)-CODE PO741 TRANSMISSION TORQUE CONVERTER SYSTEM STUCK OFF. PCM WON'T COMMAND TRANSMISSION TO SHIFT AND WHEN DOES COMMAND TRANSMISSION WILL SLIP. TAKEN TO FORD DEALER-SHEEHY FORD MERCURY LINCOLN MERCURY-10601 MIDLOTHIAN TURNPIKE, RICHMOND, VA 804-794-0500-AFTER MECHANIC WAS NOT ABLE TO OBTAIN PARTS 9L2A-12A650-FD & 9L2A-AA. ADVISED COST TO REPAIR WILL BE $5,600 OR MORE. HAD TO PUT 20% DEPOSIT OR $3,400.00 DOWN BEFORE WORK COULD BEGIN. AS I SPEAK TO OTHER FORD OWNERS, ADVISED THAT THEY HAD TO MAKE SAME REPAIR. WRENCH LIGHT WARNING APPEARS WHILE DRIVING.

• 11/19/2015· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT NOTICED THAT THE VEHICLE WAS LEAKING FUEL CONTINUOUSLY. THE CONTACT WAS A CERTIFIED MECHANIC AND REPLACED THE FUEL FUME NECK AND RUBBER HOSE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

• 11/15/2011· SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

  INCIDENT HAS HAPPENED 4 TIMES. CAR IS IN DRIVE AND MOVING FORWARD. WHEN MOVING FOOT TO APPLY BRAKE AND PUSHING DOWN ON BRAKE PEDAL THE GAS PEDAL IS ALSO ENGAGED CAUSING THE CAR TO HAVE THE BRAKE AND GAS APPLIED AT THE SAME TIME. THE HARDER I PUSH ON THE BRAKE THE MORE GAS IS GIVEN TO THE ENGINE. SINCE THE CAR IS ALREADY MOVING FORWARD, REMOVING MY FOOT FROM THE BRAKE WILL LET THE CAR MOVE FORWARD. THE FIRST TIME THIS HAPPENED I WAS APPROACHING A RED LIGHT. ONLY BY PUTTING THE CAR IN NEUTRAL WAS I ABLE TO CONTROL THE SITUATION. I TOOK THE CAR TO THE DEALERSHIP AS I THOUGHT THERE WAS A MECHANICAL PROBLEM. THEY COULD FIND NOTHING WRONG. IT WAS ONLY AFTER THE 2ND TIME THIS HAPPENED I REALIZED I WAS APPLYING THE BRAKE AND GAS AT THE SAME TIME. EVEN THOUGH I AM AWARE THIS CAN HAPPEN, IT HAPPENED AGAIN IN MY DRIVEWAY AND AT THE LOCAL POST OFFICE. THE REAL PROBLEM IS GETTING YOUR FOOT OFF THE BRAKE WHILE THE CAR IS MOVING FORWARD AND THEN BACK ON THE BRAKE BEFORE YOU RAM INTO SOMETHING. SO FAR SO GOOD. OTHERS MAY NOT BE AS LUCKY. *TR

• 11/06/2014· POWER TRAIN,WHEELS

  I OWN A 2010 FORD EXPLORER XLT 4X4 THAT I PURCHASED NEW IN 2009. AT APPROXIMATELY 30,000 MILES THE DRIVER'S SIDE FRONT WHEEL BEARINGS WORE OUT AND WERE REPLACED UNDER WARRANTY. A SECOND TIME AFTER WARRANTY AT APPROXIMATELY 55, 000 MILES THE SAME WHEEL BEARINGS WERE REPLACED AT A COST OF OVER $500. THE ENTIRE WHEEL HUB ASSEMBLY WAS REPLACED AND I WAS TOLD BY THE DEALER THAT THIS IS FAIRLY COMMON? THE TRUCK NOW HAS ONLY 66, 000 MILES ON IT AND HAS 3 SETS OF WHEEL BEARINGS ON THE SAME SIDE. WHAT KIND OF DEFECT IN THE FRONT END CAN BE CAUSING THIS? (I RARELY USE THE FOUR WHEEL DRIVE IF THIS HELPS). *TR

• 10/27/2015· SEATS

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT THE FRONT DRIVER SIDE SEAT FAILED TO RE-ADJUST FORWARD. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.

• 10/26/2018· AIR BAGS

  HERE IN THE LAST FEW WEEKS THE AIR BAG LIGHT COME ON AIR BAG . LIGHT COME ON AS I WAS DRIVING O ROAD. IT DOSE THIS SOME TIMES AND DON'T AT OTHER TIMES.

• 10/25/2017· WHEELS

  WHEEL BEARINGS MAKING NOISE GETS WORSE COULD LOSE WHEEL TRUCK HAS 62000 MILES. HAVE HEARD OF MANY OF THESE SAME MODELS HAVING SAME PROBLEMS. I THINK FORD SHOULD RECALL THIS MODEL FOR BEARING REPLACEMENT.

• 10/22/2018· POWER TRAIN,UNKNOWN OR OTHERCrash

  COMING TO A COMPLETE STOP WITH MY FOOT ON THE BRAKE, THE ENGINE ALL OF A SUDDEN SURGED FORWARD. I WAS NOT ABLE TO STOP IT WITH THE BRAKES. IT SURGED SO FAST AND HARD THAT IT REAR ENDED A YUKON WHICH WAS PARKED ABOUT 10 FEET IN FRONT OF ME , WHICH FORCED THE YUKON FORWARD APPROXIMATELY 7 FEET WHICH THEN BROADSIDED A PARKED PICKUP. THIS ACCIDENT HAPPENED IN A PARKING AREA, ADJACENT TO A GAS STATION. MY DAUGHTER WAS UNBUCKLING FROM HER SEATBELT WHEN THE VEHICLE SURGED FORWARD AND CAUSED HER HEAD TO HIT THE WINDSHIELD. TURNING THE BILL INTO INSURANCE, OUR VEHICLE WAS TOTALED. WE HAD BEEN WITHOUT A CAR FOR 2 MONTHS WHILE INSURANCE TOOK ITS TIME TOTALLING IT. WE NOW HAVE TO PURCHASE A NEW VEHICLE, START A NEW CAR LOAN WHEN OUR EXPLORER WAS HALF PAID OFF. AFTER THE ACCIDENT WE RESEARCHED OUR VEHICLE AND LEARNED THIS HAS HAPPENED TO MANY OTHERS WITH FORD EXPLORERS YEARS 2002 THRU 2010. FORD HAS REFUSED TO DEAL WITH ANY OF THIS, ALTHOUGH WE READ HALF WAY THRU 2010 THEY DID START CORRECTING THIS PROBLEM.

• 10/18/2016· POWER TRAIN

  THE WRENCH SYMBOL HAS COME ON SEVERAL TIMES. THE LAST TIME IT STAYED ON ALONG WITH AN ENGINE SYMBOL. FORD DEALERSHIP SAID THEY COULDN'T FIND ANYTHING TO INDICATE WHY THE WRENCH SYMBOL CAME ON BUT DID REPLACE THE THROTTLE BODY TO TAKE CARE OF THE ENGINE SYMBOL. I'M CONCERNED THAT IF THIS COMES ON AGAIN, IT MAY LEAD TO SERIOUS PROBLEMS. COULD THEY HAVE REMOVED A FUSE THAT CONTROLS THE WRENCH TROUBLE LIGHT? IN ALL CASES, I WAS DRIVING THE VEHICLE WHEN THE WRENCH SYMBOL CAME ON. *TR

• 10/03/2010· SEATS

  THE 2010 FORD EXPLORER HEADREST PITCHES YOUR HEAD UNCOMFORTABLY FORWARD. FORGET ABOUT WEARING A PONY TAIL, YOUR CHIN WILL TOUCH YOUR CHEST! PLEASE GET FORD TO REPLACE THE HEADREST! THIS IS NOT A COMFORT COMPLAINT, THIS IS A SAFETY ISSUE! *TR

• 10/01/2014· VISIBILITY

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. WHILE PARKED, THE REAR LIFTGATE WINDOW EXPLODED WITHOUT WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 98,000.

• 09/26/2025· SERVICE BRAKES,FUEL/PROPULSION SYSTEMCrash

  3 times this has happened. I brake and it seems like I'm pressing the gas pedal and the brakes feel like they aren't stopping the vehicle. The third time put me in incoming traffic and the vehicle was totaled as it already had a rebuilt salvage title when we bought it.

• 09/26/2016· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART AFTER ONE ATTEMPT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MAP SENSOR, PVC SENSOR AND TRANSMISSION CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT AVAILABLE.

• 09/26/2016· POWER TRAIN,ENGINE

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. WHILE DRIVING 30 MPH ENTERING THE HIGHWAY, THE CRANKSHAFT PULLEY FRACTURED AND CAUSED THREE OTHER VEHICLES TO BE STRUCK BY THE PULLEY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,000. UPDATED 01/06/2017*CT THE CONSUMER STATED THE HARMONIC BALANCER FELL APART WITHOUT WARNING. NOT ONLY DID IT FLY OFF IN TRAFFIC, IT RENDERED HIM WITHOUT BRAKES AND STEERING. UPDATED 03/01/17.*JB

• 09/25/2017· UNKNOWN OR OTHER

  TAKATA RECALL AND SHIFT ASSEMBLY NOT LETTING OPERATOR TAKE THE KEY OUT OF THE IGNITION. VEHICLE IS STATIONARY. HAVE NOTICED THIS IS A COMMON PROBLEM WITH 2010'S. AND RATCHET GEAR ON FRONT MANUAL RECLINING SEATS AND SEAT COVER PROBLEMS WITH AIR BAGS.

• 09/24/2020· POWER TRAIN

  MY VEHICLE HAS BEEN SUFFERING A RADEK TRANSMISSION AND POWER TRAIN ISSUES AND I AM I AM TOLD THAT I WILL NEED TO REPLACE IT. AS WELL WHEN I LOOKED UP THE RECALL FOR THIS VEHICLE UNDER GENERAL YEAR AND MODEL IT DOES COME UP THAT THE TRANSMISSION IS UP FOR RECALL HOWEVER WHEN I TYPED THE PARTICULAR VAN AND AT STATED ON YOUR WEBSITE THERE ARE NO OUTSTANDING RECALLS AGAIN CONFLICTING WITH THE FACT THAT THE RECALLS ON TRANSMISSIONS HAVE BEEN NOTED AND NOTEWORTHY IN PREVIOUS C 2011 EXPLORERS SUCH AS MY OWN. PLEASE ADVISE AND LET ME KNOW IF IT IS COVERED BEFORE MY TRANSMISSION GIVES UP COMPLETELY THANK YOU SO MUCH FOR YOUR ATTENTION. MY VEHICLE BOTH HAS A TENDENCY TO JUMP YOURS AS WELL AS IDLE HIGH AND TRANSMISSION FLUID IS PROPER AND IN GOOD CONDITION PLEASE HELP ME.

• 09/22/2014· POWER TRAIN,ENGINE

  CAR IDLES AND SURGES WHILE EITHER IN PARK OR WHILE FOOT ON BRAKE QUITE SCARY AS YOU WATCH THE RPM RISE ON ITS OWN WONDERING IF THE CAR WILL JET OUT IN TRAFFIC. *TR

• 09/16/2014· ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  MY HUSBAND WAS DRIVING DOWN A HIGHWAY TO GET TO WORK WHEN THE ABS LIGHT, THE TRACTION CONTROL LIGHT AND THE WRENCH LIT UP ON THE DASHBOARD. HE IMMEDIATELY PULLED OVER AND SHUT OFF THE TRUCK. WHEN HE TURNED IT BACK ON, HE WAS UNABLE TO GET THE TRUCK TO MOVE. *TR

• 09/09/2011· WHEELS

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 55 MPH, THE FRONT PASSENGER SIDE TIRE DETACHED FROM THE VEHICLE. THE CONTACT APPLIED THE BRAKES AND WAS ABLE TO STOP THE VEHICLE ON THE SHOULDER OF THE ROAD. THE CONTACT NOTICED THE SCREWS AND LUG NUT COVERS WERE STILL ATTACHED TO THE TIRE. THE SCREWS WERE FRACTURED AND THE STEEL HAD SHAVED OFF .THE VEHICLE WAS TOWED TO A DEALER WHERE THE TECHNICIAN REPLACED THE HUB ASSEMBLY AND THE BALL JOINT ASSEMBLY. THE APPROXIMATE FAILURE MILEAGE WAS 13,700.

• 09/06/2021· POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  Driving 65 mph on I95 and it just shut off. The yellow wrench on dash came on. I somehow was able to Pull over to the shoulder without being killed. I cranked once then tried it again and it started. Drove all the way home and it’s running fine now. This is a common problem and Ford should be contacting me to warn me and fix it. By the way I had a baby in the car. Thanks Ford for the warning.

• 09/05/2014· ENGINE

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH AND DISENGAGING THE ACCELERATOR PEDAL, THERE WAS AN ABNORMAL NOISE AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

• 09/05/2014· ENGINE

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 70 MPH, THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SERPENTINE BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

• 09/04/2017· FUEL/PROPULSION SYSTEM

  FUEL GAUGE IS SWEEPING BACK AND FORTH BEFORE RESTING ON EMPTY WHEN THE CAR WAS STARTED. WAS AN INTERMITTENT PROBLEM BUT NOW THE GAUGE REMAINS ON EMPTY WITH THE LOW FUEL LIGHT ON AND THE MILES TO EMPTY READING AS "---" AND THE CHECK ENGINE LIGHT CAME ON. DEALER TOLD ME ALMOST ONE YEAR AGO THAT THE FUEL PUMP WAS THE REASON FOR THE GAUGE ACTING LIKE THIS.

• 09/03/2019· POWER TRAIN

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. WHEN THE VEHICLE WAS ENGAGED IN PARK, THE KEY BECAME STUCK INSIDE THE IGNITION. THE CONTACT MENTIONED THAT HE MANUALLY PUSHED A PIN IN THE SHIFTER TO REMOVE THE KEY. THE CONTACT ALSO MENTIONED THAT THE GEAR WAS ABLE TO BE REMOVED OUT OF PARK WITHOUT THE KEY BEING IN THE IGNITION. THE VEHICLE WAS TAKEN TO SHULTS FORD LINCOLN (10401 PERRY HWY, WEXFORD, PA 15090, (724) 934-2388) WHERE THE CONTACT WAS INFORMED THAT THE SHIFTER NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIRS. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

• 09/02/2010· SEATS

  I RENTED A 2010 FORD EXPLORER YESTERDAY (1-SEPT-2010) WHILE MY CAR WAS BEING REPAIRED--I IMMEDIATELY NOTICED THAT THE FRONT HEADRESTS ARE DESIGNED SO THEY LEAN FORWARD WAY TOO FAR, HITTING THE BACK OF MY HEAD AND PREVENTING ME FROM SITTING IN A COMFORTABLE DRIVING POSITION. TOTALLY RIDICULOUS! GLAD I ONLY WILL HAVE IT FOR A DAY OR TWO; I WOULD NEVER BUY SUCH A VEHICLE, IT HURTS MY BACK AND NECK. *TR

• 09/01/2010· SERVICE BRAKES, HYDRAULIC

  TL*THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH, APPROACHING A TRAFFIC STOP SIGN. THE BRAKES WERE ENGAGED AND THE VEHICLE WOULD NOT SLOW DOWN. THE CONTACT APPLIED HIS FULL BODY FORCE TO THE BRAKE PEDAL REPEATEDLY AND THE VEHICLE CAME TO A STOP. THE VEHICLE WAS ABLE TO RESUME OPERATION. THE SAME FAILURE OCCURRED ON A SEPARATE OCCASION. THE CONTACT STATED THE FAILURES WOULD OCCUR AFTER TRAVELING ON THE HIGHWAY FOR A PERIOD OF TWO HOURS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE REMAINED AT THE DEALER FOR FURTHER INVESTIGATION. IN ADDITION, THE FRONT DRIVER AND PASSENGER SIDE HEADREST WERE NOT ADJUSTABLE AND VERY UNCOMFORTABLE. THE FAILURE MILEAGE WAS 8,000. THE VIN WAS UNAVAILABLE. UPDATED 1/19/2010 UPDATED 01/27/11*JB

• 08/30/2010· VEHICLE SPEED CONTROLCrash

  TL*THE CONTACT OWNS A 2010 FORD EXPLORER. WHILE DRIVING AT LESS THAN 5 MPH THE CONTACT APPLIED THE BRAKES. YET, THE VEHICLE SURGED FORWARD. THE VEHICLE CRASHED INTO A BUILDING CAUSING FRONT END DAMAGE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TOWED BECAUSE IT WAS STILL ABLE TO BE DRIVEN. THE DEALER HAD NOT BEEN CONTACTED AND THERE HAVE BEEN NO REPAIRS. A POLICE REPORT IS AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 12000.

• 08/30/2010· SEATS

  HEAD RESTRAINT FORCES HEAD INTO DOWNWARD TILTING POSTURE CAUSING MODERATE TO SEVERE DISCOMFORT AFTER ANY EXTENDED PERIOD OF DRIVING. ONLY SOLUTION FOUND WAS TO REMOVE OR REVERSE HEAD RESTRAINT, OR TO RECLINE SEAT TO SEVERELY RECLINED POSITION. UNSATISFACTORY DESIGN FOR THOSE INDIVIDUALS WITH STRAIGHT POSTURE. VERY POOR DESIGN. *TR

• 08/28/2025· ELECTRICAL SYSTEM,VISIBILITY

  The contact owns a 2010 Ford Explorer. The contact stated that while driving approximately 45 MPH, the anti-theft, roll stability, and fuel filler messages were displayed with an audible alarm before the vehicle suddenly shut off. The contact was able to restart the vehicle and drove to the residence. However, the failure reoccurred, and the vehicle was towed to the local mechanic who diagnosed that the PCM and ECM had short circuited and failed. The contact was informed that the short circuit was caused by water drainage from the moonroof onto the PCM and ECM computers. The contact stated that the moonroof had previously failed and failed to properly close. The vehicle was not yet repaired. The local dealer and manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the ECM and PCM computers were no longer available. The failure mileage was 48,000.

• 08/22/2017· UNKNOWN OR OTHER

  THE AC AND HEATER BLOWER MALFUNCTION. DURING THE WINTER OF 2016 I BEGAN TO HEAR A LOUD THUMPING NOISE WHEN ADJUSTING THE TEMPERATURE GAUGE OF THE HEATER. THE ISSUE HAS PROGRESSED TO THE SAME EXPERIENCE, HOWEVER THE BLOWER FAN SPEEDS OF 1 & 2 ARE NOT WORKING AT ALL, BUT 3 & 4 ARE.

• 08/19/2011· POWER TRAIN,VEHICLE SPEED CONTROL

  2010 FORD MOUNTAINEER STOPPING AT A RED LIGHT, PUTTING THE BRAKE ON AND THE CAR WOULD NOT STOP. THE ENGINE WAS REVVING AND HAD TO TAKE IT OUT OF GEAR TO STOP THE CAR. *TR

• 08/13/2015· VEHICLE SPEED CONTROL,SERVICE BRAKES

  I HAVE BEEN NOTICING THAT WHEN I AM ON THE HIGJWAY DRIVING IT FEELS LIKE THERE IS A INCREASE OF ACCELERATION WHEN I AM GOING SPEEDS OF 55 MPH - 60MPH. EVEN WHEN I HAVE TAPPED THE BRAKE, THERE IS STILL A LITTLE INCREASE OF SPEED. ON AUGUST 12, 2015 AT APPROXIAMTELY 5:30PM, WAS DRIVING AT SPEEDS OF 10MPH WHILE TURNING A CORNER. I HAD MY FOOT ON THE BRAKE WHEN I TURNED BUT MY TRUCK WOULD NOT STOP AND IT ACTUALLY TRIED TO OVERRIDE MY BRAKING AND ACCELERATED TO THE POINT WHERE I FELT LIKE I WAS NO LONGER IN CONTROL OF THE VEHICLE. AFTER 2 JOLTS OF ACCELERATION (WHILE MY FOOT WAS ON THE BRAKE), IT FINALLY STOPPED. I AM ON MY WAY TO THE DEALER RIGHT NOW TO GET THIS RESOLVED.

• 08/10/2010· SERVICE BRAKES, HYDRAULIC,STRUCTURE,VEHICLE SPEED CONTROL

  2010 FORD EXPLORER LIMITED WITH ADJUSTABLE PEDALS. THE BRAKE AND GAS PEDALS ARE TOO CLOSE TOGETHER. WHEN I STEPPED ON THE BRAKE MY FOOT CONTACTED THE ACCELERATOR PEDAL AND THE ENGINE ACCELERATED. WHEN THE BRAKE IS FULLY DEPRESSED IT IS BELOW THE LEVEL OF THE ACCELERATOR PEDAL. IF THE FOOT IS NOT FULLY ON THE BRAKE PEDAL, IT CONTACTS THE ACCELERATOR AND THE CAR JUMPS FORWARD. *TR

• 08/01/2018· ELECTRICAL SYSTEM

  WHEN I HOT A BUMP IN THE ROAD OR STEP ON THE BREAKS THE DOME LIGHTS COME ON, MY DRIVER EAT MOVES BAKE AND THE LIGHTS ON THE RADIO TURNS OFF.

• 07/27/2010· SEATS

  THE HEAD RESTS ON OUR 2010 FORD EXPLORER LIMITED HAVE SUCH A SEVERE FORWARD PITCH TO THEM THAT THEY MAKE IT VERY UNCOMFORTABLE TO SIT FOR ANY LENGTH OF TIME. DEALER SAYS NOTHING CAN BE DONE. PRIOR TO PURCHASE WE TEST DROVE NUMEROUS OTHER COMPETITIVE VEHICLES AND DID NOT EXPERIENCE THIS SAME ISSUE. AFTER 11 MONTHS OF OWNERSHIP AND ALMOST 14,000 MILES IT IS BECOMING A SAFETY ISSUE FOR US. I AM SERIOUSLY CONSIDERING REMOVING THE HEAD RESTS AND DRIVING WITHOUT THEM. I HAVE TRIED OTHER WORK AROUNDS, RECLINING THE SEATS TO MAKE THE HEAD REST ANGLE MORE ACCEPTABLE, BUT THIS DEFEATS THE SAFETY OF THE SEAT BELT SYSTEM. I'VE ALSO TRIED RAISING THE HEAD REST TO IT'S MAXIMUM EXTENSION, BUT THAT DEFEATS THE VALUE OF THE HEAD REST. WHAT FORD NEEDS TO DO IS REPLACE THE 2010 HEAD RESTS WITH ONE FROM AN EARLIER MODEL. NHTSA SHOULD FORCE FORD TO RECALL THESE HEAD RESTS AS HAZARDOUS. *TR

• 07/25/2012· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT WHILE ATTEMPTING TO STOP, THERE WAS AN INCREASE IN THE ENGINE RPMS AND THE VEHICLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO A DEALER, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 26,000 AND THE CURRENT MILEAGE WAS 35,700.

• 07/21/2014· WHEELS

  THE CAR WAS JUST UNDER 3 YEARS OLD AND JUST PAST IT'S WARRANTY MILEAGE. WE STARTED THE CAR TO DRIVE IT, AND IT WAS MAKING A GRINDING NOISE AND FELT LIKE SOMEONE WAS PRESSING ON THE BRAKES WHILE ACCELERATING. WE THEN PUT THE CAR IN PARK AND GOT OUT, AND IT STARTED TO ROLL. OUR SON WAS IN THE CAR AT THE TIME AND LUCKILY MY HUSBAND STILL HAD ONE FOOT IN THE CAR TO BE ABLE TO PULL THE EMERGENCY BRAKE. TOWED TO THE DEALERSHIP AND WERE TOLD THAT IT WAS A WHEEL BEARING ISSUE IN THE FRONT WHEEL. WE REPORTED THIS TO FORD, AT WHICH TIME THE SERVICE MANAGER AT THE BEECHMONT FORD IN CINCINNATI TOLD US THAT "WHEEL BEARING ISSUES ARE SYNONYMOUS WITH FORD EXPLORERS." FAST FORWARD TO JULY 2014, WE ARE DRIVING THE CAR AND ALARM BELLS START GOING OFF. SAME SYMPTOMS, TOWED TO A DIFFERENT DEALERSHIP, THE MIKE CASTRUCCI FORD IN MILFORD, OHIO. THIS TIME IT'S THE OTHER FRONT WHEEL BEARING. TALKED TO FORD CUSTOMER CARE REGIONAL REPRESENTATIVE AGAIN, AT FIRST HE TRIED TO IMPLY THAT IT'S THE WAY WE DRIVE THE CAR (EVEN THOUGH WE HAVE KEPT OTHER CARS FOR 10 YEARS AND LONGER AND NEVER HAD THIS ISSUE), THEN TRIED TO IMPLY THAT WE GO OFF-ROADING (ALSO NOT TRUE, JUST NORMAL HIGHWAY AND CITY ROADS) AND THEN HE TOLD ME THE ONLY WAY A RECALL WILL BE ISSUED IS IF THE GOVERNMENT FEELS THERE IS A SAFETY ISSUE. SO THIS TELLS ME THAT THEY ARE A) AWARE THAT IT'S AN ISSUE WITH THE WAY A FORD EXPLORER IS CONSTRUCTED AND B) NOT GOING TO RECALL THIS CAR OR PART UNTIL ENOUGH PEOPLE ARE INJURED OR KILLED. WE ARE STILL IN THE PROCESS OF TRYING TO GET FINANCIAL ASSISTANCE FROM FORD TO FIX THIS WHEEL BEARING ISSUE ON THE FRONT WHEEL, BOTH TIMES WE HAVE CALLED THEM EVERY DAY FOR OVER A WEEK AND NO ONE WILL RETURN OUR CALL. BUT WE CAN BASICALLY COUNT ON THE REAR WHEEL BEARING GOING BAD NEXT YEAR AND HAVING TO GO THROUGH THIS AGAIN. *TR

• 07/20/2021· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  While driving on the highway, my Explorer did a sudden jolt and I had no control over the vehicle. It acted as though it was no in gear. I almost crashed going 60 mph on a 4 lane highway. It then did another large jolt and revved high into the red line. I took it to Firestone and they recommended that I take it to the dealership to check the transmission. I called the dealership and they advised me to drive it over. They told me it was "probably the transmission as Explorers are notarious for transmission issues." The dealership inspected the Explorer and confirmed that it was a known transmission issue involving codes P0798 and P098. The dealership advised that there were MULTIPLE pressure code errors [that never did a warning] and that the transmission required replacement. I asked if it was covered under warranty and the dealership advised me that Ford had no issued a recall yet, even though it was a known and serious transmission issue. The dealership recommended that I call Ford Customer Care at 1-800-392-3673 and request that Ford cover the replacement. I called Ford Customer Care and spoke with Bruno who advised me that it was indeed a known issue and that I "was not the only one with this issue" and that "there will be a recall soon so [I] can get reimbursed." Bruno was to have a supervisor call me within 24 hours. It has been almost 2 weeks and there has been no response from Ford. This is a well known issue that Ford knows of. There has been recalls of other Explorers for the same problem but my VIN is not included for some reason. If you go online, there are thousands of complaints. SOMETHING NEEDS TO BE DONE BEFORE SOMEONE DIES OR IS SERIOUSLY INJURED. I have the telephone recordings of Ford but I am unable to upload them here.