2009 Volkswagen Passat

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2016· POWER TRAIN,ENGINE

  THERE IS A LATENT DEFECT IN THE TENSIONER SYSTEM OF THE TIMING CHAIN THAT CAN CAUSE THE CHAIN TO 'JUMP A TOOTH' IN THE VEHICLE'S CAMSHAFT, WHICH CAUSES SERIOUS AND SOMETIMES FATAL DAMAGE TO THE ENGINE. UNFORTUNATELY THE DEFECT IS IMPOSSIBLE FOR CAR OWNERS TO DISCOVER, BUT AUDI AND VOLKSWAGEN KNEW OF THE TENSIONER SYSTEM PROBLEM SINCE AT LEAST JUNE 2010. NORMALLY, THE TIMING CHAIN IS MEANT TO FUNCTION PERFECTLY FOR AT LEAST 120,000 MILES. BECAUSE THE SYSTEM IS NOT ON THE SCHEDULE FOR RECOMMENDED MAINTENANCE FROM THE MANUFACTURERS. HOWEVER, WITH THE DEFECTIVE TENSIONER, THE TIMING CHAIN FREQUENTLY FAILS WELL BEFORE THAT MARK, BUT OFTEN AFTER THE WARRANTY HAS EXPIRED. THIS ISSUE CAUSED MY ENGINE TO HAVE CATASTROPHIC ENGINE FAILURE.

• 12/27/2017· ENGINE

  DEFECTIVE TIMING CHAIN TENSIONER IN 2.0 TSI ENGINE DAMAGE THE CAR AND ENGINE NOT GETTING STARTED. MECHANIC ASKED FOR $3500 APPROXIMATE ESTIMATE FOR REPAIR WHICH IS KNOWN DEFECT OF VW 2.0 TSI ENGINE. VEHICLE WAS IN MOTION WHEN I WAS PARKING THE CAR IN MALL PARKING AREA.

• 12/26/2017· FUEL/PROPULSION SYSTEM

  I HAVE CHANGED FEW BATTERIES BEFORE AND LAST SERVICE DEALER CLAIMED ISSUE WITH BATTERY IS DUE TO INSIDE LIGHT WHICH IT WASN'T AND IT LOOKS LIKE THE FUEL PUMP THAT NEED TO BE REPLACED SOON. THE DEALER SEEMS NOT READY READY YET WITHOUT WV APPROVAL.

• 12/19/2016· AIR BAGS

  I RECEIVED A NOTICE FROM WV IN APRIL 2016. IT IS NOT DECEMBER OF 2016 AND NOTHING HAS BEEN DONE TO ADDRESS THIS RECALL. IN ADDITION TO THE RECALL I DO HAVE THE AIRBAG LIGHT ON, IN THE DASHBOARD SIGNALING THAT SOMETHING MUST BE DONE ASAP. THANK YOU *TR

• 12/18/2017· ENGINE

  MY 2009 VOLKSWAGEN STOPED STARTING, SO I HAD IT TOWED INTO A DEALERSHIP WHERE THEY RAN A FEW TESTS AND DETERMINED THAT MY TIMING CHAIN TENSIONER FAILED WHICH RESULTED IN THE FAILURE OF MY ENGINE. AS A RESULT, I NEEDED TO PAY AROUND $7000-$8000 IN ORDER TO REPLACE. GIVEN I COULD NOT AFFORD, IVE BEEN MAKING MY MONTHLY PAYMENT AS I AM FINANCIALLY OBLIGATED TO DO SO. THE CAR ONLY HAD 70,000 MILES, THEREFORE I AM SURPRISED THAT THE ENGINE ALREADY WENT AND FEEL THIS IS SOMETHING VW SHOULD REPLACE.

• 12/18/2009· ELECTRICAL SYSTEMFire

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE PARKED FOR 30 MINUTES THE VEHICLE CAUGHT ON FIRE. THE FIRE STARTED IN THE FRONT UNDER THE ENGINE. THE FIRE DEPARTMENT STATED IT COULD BE AN ELECTRICAL FIRE OR A LEAK IN THE ENGINE. THE VEHICLE WAS COMPLETELY DESTROYED. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE INSURANCE COMPANY WAS PERFORMING AN INVESTIGATION. THE FAILURE MILEAGE WAS 20,000.

• 12/17/2014· ENGINEFire

  AFTER BEING DRIVEN FOR A SHORT TIME OUR 2009 VW PASSAT WAS PARKED IN OUR GARAGE. NO SIGNS OF ANY PROBLEMS WHEN DRIVER WENT INSIDE THE HOUSE. ABOUT 15-20 MINUTES AFTER BEING PARKED NOISE WAS HEARD FROM GARAGE AND AT THAT TIME INTENSE SMOKE AND FIRE FROM FRONT OF VEHICLE WAS DISCOVERED. BEFORE HELP COULD ARRIVE FRONT OF CAR WAS COMPLETELY ON FIRE AND NEARBY MATERIALS IN GARAGE WERE IGNITED. CAR WAS CONSIDERED TOTAL LOSS ALONG WITH EXTENSIVE DAMAGE TO INSIDE OF GARAGE. FIRE DEPARTMENT ATTRIBUTED THE CAUSE OF FIRE AS "CAR ENGINE/ELECTRICAL". FORTUNATELY, ,THERE WERE NO PERSONAL INJURIES BUT SIGNIFICANT PROPERTY DAMAGE.. *TR

• 12/13/2024· FUEL/PROPULSION SYSTEM

  On [XXX], a MIDAS shop found an alleged crack in the front part of the gas tank on the upper part of the tank by the floor board. The manager also stated that it could be a plastic seal from the fuel pump on the top part of the tank. The tank is located next to the exhaust system. My 2009 VW CC 4-Motion only has 122,xxx miles on it. I could see a wet spot and presumed I smelled gas but was not sure. He gave me a printout of what the cost would be to repair the system. I told him I would be filing a report with NHTSA. I then called Lunde's VW, W. Bell Rd., Peoria, AZ. I talked to a Tyler Rodriquez and he said there were no recalls and VW could not warrant the problem. I told him I would be filing a report with NHTSA and he did not respond to me. Both places were quite fast to elicit repairs from their business. Only MIDAS pointed out the exhaust pipes being near the gas tank. Approximately six years ago I had been to another VW dealership in Phoenix about my gas gauge needle not working properly and I was sold a gas cap to fix the problem. The problem has been a recurring one and my gas mileage fluctuates. This situation reminds me of the mid-1970s problem with the Ford Pinto gas tanks, which I believe was never resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/12/2017· ENGINE

  MY VEHICLE WAS IN MOTION ON A CITY STREET AND SUDDENLY IT STARTED SHAKING WHILE DRIVING AND WHEN I BRAKED, IT SHAKED EVEN MORE VIGOROUSLY. I TOOK IT TO A LOCAL MECHANIC WHO SAID THERE IS AN ISSUE WITH THE ENGINE AND THE DEALERSHIP WILL HAVE TO LOOK AT IT. THEY RECOMMENDED THAT I TOW THE CAR TO THE DEALERSHIP AND ADVISED AGAINST DRIVING IT. I TOWED THE CAR TO THE DEALERSHIP. AFTER TWO DAYS THE DEALERSHIP CALLS ME STATING THAT THE TIMING CHAIN HAS JUMPED AND THERE IS NO COMPRESSION. THEY WOULD HAVE TO REPAIR OR REPLACE THE ENGINE. THE DEARLSHIP TECHNICIAN SAID THAT THEY HAVE HAD SEVERAL VW VEHICLES BROUGHT IN WITH SIMILAR ISSUES BUT VW HAS REFUSED TO ISSUE A RECALL OR TAKE ANY ACTION TO CORRECT THIS ISSUE. THIS IS A DANGEROUS SAFETLY HAZARD. IF I WAS DRIVING ON A HIGHWAY AND THIS HAPPENED, I COULD HAVE EASILY CAUSED A BIG ACCIDENT BECAUSE I LITERALLY HAD VERY LITTLE CONTROL OVER THE CAR AND WHAT IT WAS DOING. THIS IS A DEFECT IN THE CAR'S MANUFACTURING AND VW NEEDS TO DO SOMETHING URGENTLY TO FIX THE ISSUE. THERE ARE OTHER CARS AND OWNERS OUT THERE UNAWARE OF THIS POTENTIALLY DANGEROUS ISSUE AND NHTSA NEEDS TO BRING THIS TO EVERYONE'S ATTENTION. THANK YOU.

• 12/09/2014· ENGINEFire

  I WAS STOPPED AT A RED LIGHT AND SMOKE WITH THE DISTINCT FIRE SMELL STARTED POURING OUT OF MY HOOD. I HAD TO RUN THE RED LIGHT TO GET OFF OF THE STREET WHERE I ENDED UP IN A BIG PARKING LOT. I RAISED THE HOOD AND SAW HEAVY SMOKE AND SMALL FLAMES. I GRABBED MY PHONE AND TOOK A PICTURE AND THEN RAN AND GOT WATER TO PUT THE FIRE OUT. THIS WILL COST ME A 500 DOLLAR DEDUCTIBLE AND THE POTENTIAL FOR MY INSURANCE COMPANY TO RAISE MY RATES. I AM SO PISSED TO FIND OUT THIS IS A RECURRING ISSUE! I AM GLAD I WAS DRIVING INSTEAD OF MY WIFE WITH OUR KIDS IN THE CAR! VW THE FIGHT IS NOW ON! I WAS WONDERING WHY MY SERVICE ADVISER NEW EXACTLY WHAT CAUSED THE FIRE. A 27 DOLLAR PART FAILED AND CAUSED A COUPLE OF GRAND IN DAMAGE. *TR

• 12/07/2017· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 12/04/2009· SERVICE BRAKES, HYDRAULICCrash

  ENGINE COLD. TRANS. IN EITHER REVERSE OR DRIVE. UPON RELEASING BRAKE CAR MOVES TOO FAST. WHEN APPLYING BRAKE NOTHING HAPPENS. AFTER REPEATEDLY APPLYING BRAKE THEY FINALLY CATCH HAS HAPPENED AT LEAST 5 TIMES. THIS TIME THEY DIDN'T CATCH AND I REARENDED A PICKUP WAITING AT A STOP SIGN. I DON'T THINK I FAILED TO APPLY THE BRAKES PROPERLY BECAUSE I RAISED MY FOOT OFF THE BRAKE AND REAPPLIED THEM AT LEAST TWICE BEFORE IMPACT BUT THAT IS NEVER-THE-LESS STILL A POSSIBILITY. *TR

• 11/27/2022· STEERING,ELECTRICAL SYSTEM

  The power steering system failed. At first I thought the steering wheel was locked. I started the car and could not turn the wheel. The power steering light illuminated in red and there was a loud beeping sound when the car is turned on. It was not until the car was towed that I realized that the wheel was not locked. The tow truck driver was able to turn the wheel to steer the vehicle on to the truck bed. I had someone plug in a diagnostic machine. I do not recall the exact code but he said the power steering system was not getting a signal. He replaced the steering angle sensor but that did not fix the issue. I had passenger at the time and was concerned for my safety. Luckily, the system failed while the car was parked, but we were left stranded. I have come across the following information on the Kelley Blue Book website: Steering: gear box (other than rack and pinion) NHTSA CAMPAIGN ID: 08V577000 Report Date: Oct 31 2008 Vehicles Affected: 130 Consequence: DRIVER ATTEMPTS TO OVERCOME THE SYSTEM DURING MALFUNCTION WILL CAUSE (1) VIBRATIONS IN THE STEERING WHEEL; (2) THE STEERING SYSTEM MOTOR TO TURN OFF; (3) THE RED STEERING SYSTEM MALFUNCTION INDICATOR LIGHT TO ILLUMINATE; AND (4) AUDIBLE WARNINGS TO CHIME. A MALFUNCTIONING STEERING SYSTEM COULD LEAD TO A CRASH WITHOUT WARNING. What You Should Do: DEALERS WILL REPLACE THE STEERING GEAR IN THE AFFECTED VEHICLES. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 5, 2008. OWNERS MAY CONTACT VW AT 1-800-4822-8987. Summary: VW IS RECALLING 130 2009 PASSAT, PASSAT WAGON, AND PASSAT CC VEHICLES. SOME VEHICLES MAY HAVE AN ELECTROMECHANICAL STEERING GEAR CONTROL UNIT THAT CAN MALFUNCTION DUE TO A DAMAGED CAPACITOR. IF THIS MALFUNCTION OCCURS, THE DRIVER'S STEERING INPUT IS NOT PROPERLY PROCESSED BY THE SYSTEM AND THE VEHICLE MAY NOT RESPOND AS THE DRIVER INTENDS. THIS DEFECT CAN ONLY OCCUR IMMEDIATELY AFTER VEHICLE START-UP WHEN THE STEERING WHEEL IS MOVED FOR THE FIRST TIME AND AT SPEEDS LESS THAN 5 MPH.

• 11/24/2010· AIR BAGS,VEHICLE SPEED CONTROLCrash

  TL*THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE TURNING LEFT, THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO A BRICK PILLAR HOLDING UP A BUILDING. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE ALSO ACCELERATED TWO ADDITIONAL TIMES. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HER TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER WHO STATED THAT THERE WAS NOTHING WRONG. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 15,500.

• 11/23/2009· ELECTRICAL SYSTEM

  FAILURE OF KEY (FOB OR WHAT EVER VW CALLS IT) TO START VEHICLE WHEN INSERTED IN IGNITION SWITCH. THIS FAILURE HAS OCCURRED TWICE AND RESULTED IN IGNITION SWITCH NEEDING TO BE REPLACED BY DEALER. ON THE SECOND OCCURRENCE THE KEY ITSELF SHORTED OUT AND WOULD NOT ALLOW ME TO OPEN POWER DOORS; HOWEVER, THE KEY WOULD ALLOW ME TO OPEN THE POWER REAR HATCH SO THAT I COULD CRAWL THROUGH CAR TO UNLOCK DOORS. TODAY THE OTHER KEY STARTED ACTING UP FOR MY WIFE AND WOULD NOT ALLOW HER TO UNLOCK DOORS AND SHE HAD TO CRAWL THROUGH CAR TO UNLOCK DOORS. THE SERVICE MANAGER AT THE DEALER HAS THE FIRST FAULTY KEY FOR WHICH HE WAS TO GET US A REPLACEMENT AND WE ARE WAITING ON VW TO REPLACE FAULTY KEY. I DO NOT KNOW IF DEALERSHIP STILL HAS FAULTY IGNITION SWITCHES BUT THE SERVICE MANAGER STILL HAS MY KEY. THE DATES OF THE IGNITION SWITCH REPLACEMENTS ARE 01/20/2009 & 09/09/2009. THE CAR WAS IN SERVICE LESS THAN 15 DAYS BEFORE THE FIRST IGNITION SWITCH NEEDED TO BE REPLACED. I LEFT MY KEY WITH THE SERVICE MANAGER WHEN WE PICKED UP THE CAR ON 09/13/2009. *TR

• 11/21/2017· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN SEPTEMBER OF 2017. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART AFTER THE FIRST FAILURE, BUT HAD TO BE TOWED THE SECOND TIME. THE DEALERS (SUNRISE VOLKSWAGEN, 931 SUNRISE HWY, LYNBROOK, NY, 11563, AND SMITH VOLKSWAGEN, 4304 KIRKWOOD HWY, WILMINGTON, DE, 19808) VERIFIED THAT THE FUEL PUMP MODULE AND PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER CONFIRMED THAT THE PARTS WERE UNAVAILABLE FOR REPAIR AND THAT THE CONTACT WOULD BE NOTIFIED WHEN THE NEW REMEDY AND REIMBURSEMENT INFORMATION WERE AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 11/17/2018· STEERING

  MY CAR HAS LESS THAN 35000 MILES. THE STEERING WHEEL COLUMN LOCK IS DEFECTIVE HAS BEEN APPEARING ON MY INSTRUMENT PANEL. THIS DEFECTIVE PART WILL NOT ALLOW THE CAR TO START AT TIME. FURTHER INVESTIGATION REVEALED THAT IT COULD CAUSE THE CAR TO STALL WHILE IT IS BEING DRIVEN. A SEARCH OF THE INTERNET REVEALED THAT THIS IS A FREQUENT PROBLEM WITH THIS MAKE AND MODEL OF THE CAR. IT IS A SAFETY ISSUE WHICH IS NOT CAUSED BY NORMAL WEAR AND TEAR. VOLKSWAGEN REFUSES TO REPAIR THE VEHICLE AT NO CHARGE FOR A KNOWN SAFETY ISSUE. I WANT VOLKSWAGEN HELD RESPONSIBLE. IF THE VEHICLE STALLS WHILE IN MOTION, I WILL FILE A LAWSUIT. I WANT TO GIVE YOUR COMPANY THE OPPORTUNITY TO RESOLVE IT FIRST.

• 11/14/2013· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 35,000.

• 11/13/2017· AIR BAGS

  TAKATA RECALL- I WAS NOTIFIED BY TK HOLDINGS INC. THAT MY 2009 VW PASSAT SHOULD HAVE AIRBAGS REPLACED AS PART OF THE NATIONAL RECALL. I CONTACTED VW AND THEY REFUSED TO REPLACE MY AIRBAGS STATING THAT MY CAR WAS NOT ELIGIBLE FOR AN AIRBAG RECALL, BUT ONLY ELIGIBLE FOR A FUEL PUMP RECALL.

• 11/07/2019· AIR BAGS

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. UPON PURCHASING THE VEHICLE USED, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO VOLKSWAGEN OF ORANGE PARK (7220 BLANDING BLVD, JACKSONVILLE, FL 32244 (855) 758-7110) WHERE SHE WAS INFORMED THAT SHE WOULD HAVE TO PAY $100 TO HAVE THE INDICATOR TURNED OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED AND ADVISED THE CONTACT TO FILE A COMPLAINT WITH NHTSA. THE FAILURE MILEAGE WAS UNKNOWN.

• 11/04/2015· ELECTRICAL SYSTEM,ENGINE

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

• 11/03/2017· ENGINE

  FOUND OUT THERE WAS A TIMING CHAIN ISSUE WITH THE VEHICLE WHERE IT JUMPED 22 DEGREES. AFTER RESEARCH HAVE FOUND ON A NUMBER OF FORUMS THAT THIS IS A WIDESPREAD ISSUE WITH THIS ENGINE IN BOTH VW AND AUDI VEHICLES. VW WILL NOT ISSUE A RECALL, THE CLAIM IS, DUE TO IT BEING TOO WIDESPREAD AND EXTREMELY EXPENSIVE. UNDER MOST CIRCUMSTANCES FROM WHAT I HAVE READ, IT CAUSES CATASTROPHIC ENGINE FAILURE. LUCKILY, MINE DID NOT JUMP THAT FAR, BUT IT STILL WAS AN EXPENSIVE REPAIR THAT SHOULDN'T HAVE HAD TO HAPPEN. WELL NOW I HAVE HAD $4200 IN REPAIRS MADE TO MY ENGINE DUE TO THIS ISSUE AND I THINK VW SHOULD HAVE PAID FOR IT.

• 10/26/2017· FUEL/PROPULSION SYSTEM

  THERE WAS A RECALL ON MY FUEL PUMP IN AUGUST. CONTACTED MY DEALER IN OCT. 23, AND THEY SAY THERE ARE NO PARTS TO REPLACE MY FUEL PUMP. I LOOKED AT THE DANGERS IF IT IS NOT WORKING PROPERLY, ONE OF WHICH IS MY CAR COULD LOOSE POWER AND JUST STOP AS I AM DRIVING MY CAR. I HAVE TO DRIVE ON HIGHWAYS AND I AM SCARED ABOUT THIS. WHY DON'T THEY HAVE THE PARTS FROM VW TO FIX MY FUEL PUMP?

• 10/23/2017· ELECTRICAL SYSTEM

  ABS MODULE FAILURE - PARKING LIGHT FLASHING AND TRACTION CONTROL FLASHING WHILE DRIVING

• 10/20/2017· UNKNOWN OR OTHER

  TAKATA RECALL NHTSA RECALL NUMBER 17V509 SUMMARY ON CERTAIN VEHICLES, THERE COULD BE AN INTERRUPTION IN ELECTRICAL POWER TO THE FUEL PUMP CONTROL MODULE. THIS COULD RESULT IN THE FUEL PUMP RUNNING CONTINUOUSLY, RESULTING IN A DRAINED BATTERY AND/OR A NO START CONDITION, OR CAUSE A LOSS OF MOTIVE POWER WHILE THE VEHICLE IS IN MOTION, WHICH COULD INCREASE THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY. RECALL STATUS RECALL INCOMPLETE. REMEDY NOT YET AVAILABLE REMEDY REPLACE THE FUEL PUMP CONTROL MODULE AND RELOCATE IT WITHIN THE VEHICLE. SAFETY RISK DESCRPITION A LOSS OF MOTIVE POWER WHILE THE VEHICLE IS IN MOTION COULD INCREASE THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY. MANUFACTURER RECALL NUMBER 20AE

• 10/19/2017· ENGINE

  SUDDEN LOSS OF ENGINE OIL CAUSING ENGINE FAILURE

• 10/18/2017· FUEL SYSTEM, GASOLINE,AIR BAGS

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER (BACHMAN VOLKSWAGEN, 9652 BLUEGRASS PKWY, LOUISVILLE, KY 40299, (502) 996-8943) DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS CONTACTED. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES AND WORSENED WHILE WAITING FOR THE PART. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 10/17/2018· FUEL/PROPULSION SYSTEM

  I AM WRITING TO YOUR ORGANIZATION BECAUSE OF THE INJUSTICE I EXPERIENCED WITH A RECALL AT VOLKSWAGEN. A COUPLE OF YEARS AGO I HAD SOME ISSUES WITH MY PASSAT AND TOOK IT TO THE DEALER. DEALERS DOING WHAT DEALER'S GAUGED ME FOR WHATEVER THEY COULD. THIS YEAR, HOWEVER, VOLKSWAGEN CAME OUT WITH RECALL FOR THE PART WHICH I REPLACED TWO YEARS AGO. THEY PAID ME PARTIALLY FOR MY OUR OF POCKET EXPENSES BUT MY ARGUMENT TO THEM WAS THAT I WOULD NOT HAVE BEEN AT THE DEALER TO BE TAKEN ADVANTAGE OF IF NOT FOR THE RECALL. I INITIALLY REQUESTED THAT THEY REFUND FULL LABOR AND ONE OF THE PARTS. BUT COME TO THINK OF IT BOTH PARTS ARE RELATED TO THE FUEL SYSTEM AND NOW I WOULD LIKE A COMPLETE REFUND.

• 10/17/2017· ENGINE

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. MOMENTS LATER, THE VEHICLE COULD BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER (SUNTRUP VOLKSWAGEN IN ST. LOUIS, MO), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 80,000.

• 10/14/2019· FUEL/PROPULSION SYSTEM

  FUEL PUMP CRACKED, AND PLACEMENT OF PUMP CAUSED GASOLINE TO POOL UNDERNEATH BACK SEAT INSIDE THE CAR, RIGHT UNDER WHERE MY 4 YEAR OLDS CAR SEAT IS. TECH STARTED WE ARE EXTREMELY LUCKY THAT IT DIDNT CATCH ON FIRE, BECAUSE IT WAS BASICALLY A BOMB DIRECTLY UNDERNEATH HIM THAT COULD HAVE GONE OFF ANYTIME THE CAR WAS TURNED ON OR RUNNING. ONLY FOUND OUT ABOUT IT WHEN I TOOK IT TO GET THE FUEL PUMP MODULE REPLACED, AND ONLY FOUND OUT ABOUT THAT RECALL WHEN THE CAR STARTED STALLING OUT WHILE DRIVING. IT IS NOW AT VOLKSWAGEN OF MACON WAITING ON PARTS FOR A $1,000 REPAIR. WE ARE GOING TO GET RID OF THE CAR BECAUSE WE ARE NOT PUTTING MY SON BACK IN A CAR WHERE THAT IS EVEN POSSIBLE.

• 10/10/2013· ENGINE

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER CONFIRMED THAT THE MANIFOLD, CAM SHAFT, AND THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

• 10/06/2018· SUSPENSION

  TAKATA RECALL COIL SPRINGS BREAKAGES

• 10/05/2019· ELECTRONIC STABILITY CONTROL (ESC)

  BOUGHT THIS AT A USED CAR DEALERSHIP. WITHIN TWO DAYS, THE EPC LIGHT WAS COMING ON. WHEN DRIVING THE CAR OR WHEN STARTING TO PUSH THE GAS PEDAL, THE GAS PEDAL HAS NO RESPONSE. IT'S AS IF THE PEDAL IS NOT WORKING. WE TOOK IT BACK TO THE DEALERSHIP AND HAD THEIR MECHANIC LOOK AT IT. THEY SAID IT WAS A SENSOR. SAID THEY FIXED IT. WITHIN A WEEK, THE EPC LIGHT CAME ON AGAIN. THIS TIME, SAID IT WAS THE THROTTLE BODY. THEY SAID THEY FIXED IT BUT WITHIN ABOUT 3 WEEKS, THE PEDAL ISSUE HAPPENED AGAIN. LUCKILY, WE HAVE STAYED ON LOCAL ROADS 40 MPH MAX BUT WHEN THE CAR DOESN'T GO WHEN IT IS SUPPOSED TO, I'M EXPECTING TO GET REARENDED. WE BROUGHT THIS TO OUR MECHANIC AND $1700 LATER, THE CAR IS STILL DOING THE SAME THING. THE EPC LIGHT IS ON AND THE CAR IS NOT GOING WHEN YOU PRESS THE GAS PEDAL. THE CPU HAS BEEN SWITCHED OUT AND THE ACCELERATOR PEDAL HAS BEEN REPLACED. HOW MUCH MONEY DO WE DUMP IN THIS? THIS SEEMS TO BE A COMMON ISSUE FROM WHAT I AM READING ON THE INTERNET.

• 09/29/2011· AIR BAGSCrash

  TL* THE CONTACT OWNED A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT CRASHED INTO AN UNKNOWN OBJECT IN THE ROAD. NONE OF THE FRONT OR REAR AIR BAGS DEPLOYED. THE CONTACT SUFFERED INJURIES FROM A BUMP TO THE FOREHEAD. ALSO, THERE WAS AN OCCUPANT IN THE REAR PASSENGER SEAT, WHO SUSTAINED SEVERE INJURIES TO THE BRAIN AND REMAINED HOSPITALIZED. A POLICE REPORT OF THE INCIDENT WAS FILED. THE VEHICLE WAS DEEMED DESTROYED AND WAS TOWED TO A IMPOUND FACILITY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.

• 09/28/2016· ENGINE

  2009 VOLKSWAGEN PASSAT TIMING BELT/CHAIN TENSIONER PROBLEM IN JULY 2016 MY MOTHER-IN-LAW WAS LEAVING WORK, WHEN SHE TRIED STARTING THE CAR IT DIDN'T STARTED. SOMEONE IN THE PARKING VOLUNTEERED TO HELP HER. THEY DECIDED TO JUMP START THE CAR WITH A JUMP BOX, THE CAR STARTED AND SHE MADE IT HOME. ONCE SHE GOT HOME SHE TRIED TO START THE CAR AND IT DID NOT START. SHE IS A SINGLE MOTHER AND DO NOT MAKE A LOT OF MONEY TO FIX HER CAR, AFTER A MONTH AND HALF OF THE CAR BEEN PARK AT HOME AND TAKING RIDES FROM WHOEVER CAN TAKE HER, WE DECIDED TO GET A MECHANIC THAT WORKS FOR VW DEALERSHIP. HE CAME AND FULLY CHECKED THE CAR AND TOLD US THAT THE TIMING CHAIN/BELT JUMPED AND THAT ENGINE IT'S OUT OF TIME, WHICH IT COULD HAVE BEEN CAUSED FROM A BAD TENSIONER. HE SAID THIS IS A REAL BAD ISSUE THAT COULD CAUSE THE VALVE TO BE BENDED. HE GAVE US AN EXPENSIVE PRICE TO FIX THE CAR, SO WE DECIDED TO WAIT AND BE PATIENCE AND BE OPTIMISTIC THAT IT WASN'T THAT SINCE MY MOTHER IN LAW DOESN'T HAVE THE MONEY TO FIX IT. A MONTH LATER WE DECIDED TO GET OTHER MECHANICS TO GET DIFFERENT OPINIONS, THEY ALL SAID IT WAS THE SAME ISSUE. ONE OF THE MECHANICS CAME AND CHECKED THE PRESSURE OF THE ENGINE AND IT STAY ON 0 AND THAT'S WHEN HE CONFIRMED THAT VALVES ARE BENDED. I HAVE CHECKED ABOUT THIS PROBLEM ON THE INTERNET AND MANY PEOPLE ARE COMPLAINING ABOUT THE SAME ISSUE AND VW KNOWS ABOUT THIS ISSUE FOR SOME TIME, I ALSO SEE THERE IS A LAWSUIT GOING ON THIS ISSUE. I CAN'T BELIEVE AND IT SHOULD NOT BE ACCEPTABLE THAT VW KNOWING OF THIS PROBLEM, IT'S NOT DOING ANYTHING ABOUT FIXING THIS PROBLEM. THIS ISSUE COULD CAUSE VARIETIES OF ACCIDENT ON THE STREET, BECAUSE IF THIS ISSUE HAPPENS TO ANYBODY ON THE STREET DRIVING, IT COULD LOCK THE ENGINE AND CAUSE THE PERSON LOSE CONTROL OF THE VEHICLE AND EITHER HIT OR GET HIT BY SOMEBODY.

• 09/27/2011· STEERING

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT CC. THE CONTACT STATED THAT WHILE DRIVING 2 MPH, THE STEERING WHEEL SEIZED AND WOULD NOT TURN IN ANY DIRECTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE DEALER STATED THAT THE STEERING RACK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 112,199 AND THE CURRENT MILEAGE WAS 112,400.

• 09/26/2017· UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  ON 1 SEPTEMBER 2017, I PARKED MY VW IN MY GARAGE. THERE WERE NO ENGINE LIGHTS ON OR ANYTHING, BUT THE CAR HAD BEEN MAKING A LOUD FAN LIKE NOISE AFTER I REMOVED THE KEY FOB FROM THE IGNITION. ITS BEEN DOING THAT SINCE I BOUGHT IT. I DIDN'T START THE CAR BACK UP UNTIL 5 SEPTEMBER 2017 AFTER RETURNING FROM A WEEKEND WITH FAMILY. WHEN I STARTED MY VW UP I NOTICED THAT THE ENGINE LIGHT WAS NOW ILLUMINATED. I WAITED ABOUT A WEEK BEFORE I TOOK ANY ACTION HOPING THAT THE LIGHT WOULD JUST GO AWAY ON ITS OWN, BUT IT DIDN'T. ON 12 SEPTEMBER I TOOK THE CAR TO THE NEAREST AUTOZONE AND TOOK ADVANTAGE OF THEIR FREE ENGINE LIGHT DIAGNOSTIC CHECK. THE ERROR CODES READ "P0171 SYSTEM TOO LEAN (BANK 1)" AND "P12A2 FUEL RAIL PRESSURE SENSOR INAPPROPRIATELY HIGH." AT THE TOP OF THE PAPER IT STATED THAT THE MOST LIKELY SOLUTION FOR THESE ERROR CODES WAS TO REPLACE THE FUEL PUMP. ONCE I RETURNED HOME I CALLED THE LOCAL VOLKSWAGEN DEALERSHIP AND TOLD THEM WHAT THE PROBLEM WAS, THEY TOLD ME THAT THERE WAS A RECALL OUT FOR MY MODEL VEHICLE, BUT THERE IS NO FIX AT THE MOMENT. I THEN WENT ONLINE TO SEE FOR MYSELF, THE MANUFACTURER RECALL NUMBER IS: 20AE AND THE NHTSA MANUFACTURER NUMBER IS: 17V509. I AM NOT SURE WHAT CAUSED THE VEHICLE TO RANDOMLY START HAVING THESE ISSUES. I DO NOT FEEL SAFE DRIVING THE CAR OUT OF TOWN ANYMORE, I ONLY DRIVE IT TO AND FROM WORK.

• 09/26/2010· ENGINE AND ENGINE COOLINGFire

  PARKED CAR AND WENT INTO THE STORE TO SHOP AND APPROXIMATELY 10 MINUTES LATER SOMEONE SAID A CAR WAS ON FIRE AND THAT IT WAS A SILVER VW. MY HUSBAND WENT OUT AND FOUND THE WHOLE FRONT END ENGULFED IN FLAMES. *TR

• 09/25/2014· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  THE CAR SUDDENLY HAS 50% OR LESS POWER AND BEGINS STUMBLING VERY BADLY. ACCELERATION IS SO POOR THAT IT'S QUITE DANGEROUS IN HEAVY TRAFFIC AND THE ABILITY TO PULL OFF THE ROAD IS SEVERELY HAMPERED. THE ONLY WAY I'M ABLE TO KEEP THE CAR MOVING AND RUNNING IS TO USE THE MANUAL FEATURE OF THE AUTOMATIC TRANSMISSION AND KEEP THE RPM'S VERY HIGH. THE FOUR COIL PACKS IN THE CAR WERE REPLACED THIS SPRING. SUDDENLY, THE SAME EXACT PROBLEM IS BACK AGAIN 4 MONTHS LATER. CODES WERE RANDOM MISIFRE AND MULTIPLE MISFIRES AT VARIOUS CYLINDERS. STRANGE THAT ALL FOUR PACKS GO OUT AT THE SAME TIME....? THAT'S NOT LOGICAL UNLESS IS SOMETHING OTHER THAN NORMAL WEAR CAUSING THE ISSUE. THIS PROBLEM HAS OCCURRED TWICE AND BOTH TIME IT BEGINS IN THE MIDDLE OF HEAVY TRAFFIC WHERE THE SITUATION IS VERY DANGEROUS AS THE POWER LOSS IS NEARLY COMPLETE. BOTH TIMES WERE UNDER ACCELERATION WHEN THE HEAVY STUMBLING OCCURRED. I TURNED THE CAR OFF AND DISCONNECTED THE BATTERY FOR 5 MIN. TO HOPEFULLY RESET THE CARS EPC AS THE PROBLEM IS SO SUDDEN IT ALMOST CERTAINLY IS ELECTRICAL. THERE IS NO LOGICAL EXPLANATION FOR FOUR COIL PACKS ALL NEEDING TO BE REPLACED AT THE SAME TIME AND 4 MONTHS AFTER THE LAST REPLACEMENT...? UNDOUBTEDLY A CONSISTENTLY DANGEROUS SITUATION. *TR

• 09/25/2013· ELECTRICAL SYSTEMFire

  ON SUNDAY MORNING ABOUT 11:20 AM AS I TURNED MY CAR ON IT IMMEDIATELY STARTED TO RATTLE FOLLOWED BY BLACK SMOKE COMING FROM UNDER MY HOOD. I IMMEDIATELY TURNED MY CAR OFF, UNLOCKED MY HOOD AND UNBUCKLED MY 3 BOYS OUT OF THEIR CAR SEATS AND RAN OUT OF THE CAR. AS I MADE SURE THEY WERE AT A SAFE DISTANCE AWAY FROM THE CAR I WALKED BACK TO MY CAR POPPED THE HOOD UP AND NOTICED FIRE COMING FROM WHAT APPEARED TO BE THE ENGINE. I IMMEDIATELY CALLED 911 AND RAN TO MY NEIGHBORS APARTMENT TO ASK FOR WATER SO MY CAR WOULDN'T BURN TO THE GROUND. BY THE TIME THE FIRE DEPARTMENT MADE IT OUT MY NEIGHBOR AND I WERE ABLE TO PUT THE FIRE OUT THANK GOD. THE FOLLOWING DAY I HAD IT TO TOWED BY HANNA'S TOWING THROUGH MY CAR INSURANCE AGENCY TO THE NEAREST VOLKSWAGEN SERVICE CENTER. THE TOW TRUCK DRIVER WALTER HAD TO UNPLUG THE BATTERY BECAUSE WHEN HE TURNED IT ON TO PUT THE VEHICLE ON NEUTRAL TO HOOK IT UP TO THE TOW TRUCK IT STARTED TO SMOKE UP AGAIN. *JS

• 09/22/2021· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  I put fuel in the car and about to start the car and it won’t start. Lights flickering.

• 09/16/2009· POWER TRAINFire

  2009 VOLKSWAGEN PASSAT OVERHEATED AND CAUGHT FIRE WHILE ON A CAR DOLLY BEING PULLED BY A 2006 NISSAN X-TERRA. *KB ACCORDING TO THE FIRE DEPT AND TOW TRUCK OPERATOR THE FIRE WAS DUE TO THE TRANSMISSION OVERHEATING. THE CONSUMER STATED HE NOTICED LEAKING FROM THE FRONT OF THE VEHICLE 3 HOURS PRIOR TO THE FIRE. OHIO TRAFFIC CRASH REPORT #10-0747-91.

• 09/13/2018· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE VEHICLE AND A FUEL LEAK UNDERNEATH THE VEHICLE. THE DEALER (SOUTHERN VOLKSWAGEN GREENBRIER, 1248 S MILITARY HWY, CHESAPEAKE, VA 23320, (757) 424-4689) INDICATED THAT THEY PREVIOUSLY REPAIRED THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE) WHEN THE FUEL PUMP CONTROL MODULE WAS REPLACED; HOWEVER, THERE WAS A FUEL LEAK AFTER THE RECALL REPAIR WAS PERFORMED. THE DEALER INDICATED THAT THE FUEL PUMP MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,272.

• 09/12/2017· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED JOSEPH VOLKSWAGEN (3813 MONTGOMERY RD, CINCINNATI, OH 45212, PHONE NUMBER: (800) 551-4240) AND WAS INFORMED THAT THE REMEDY PART WAS NOT AVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 09/12/2017· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL DEALER (HERITAGE VOLKSWAGEN PARKVILLE, 9215 HARTFORD RD, PARKVILLE, MD 21234) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD THE VEHICLE TOWED TO HER RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 105,000.

• 09/09/2019· ENGINE

  TL* THE CONSUMER OWNS A 2009 VOLKSWAGEN PASSAT. THE CONSUMER STATED THAT THE ENGINE INTAKE MANIFOLD FAILED AND CAUSED THE VEHICLE NOT TO ACCELERATE IN A TIMELY MANNER. THE CONSUMER STATED THAT THE VEHICLE FAILED THE STATE INSPECTION DUE TO THE INTAKE MANIFOLD FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE INTAKE MANIFOLD SYSTEM REPAIR. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 115,000. *BF *AS

• 09/06/2012· POWER TRAIN,ENGINE

  ACCELERATION HESITATION FOR 1-3 SECONDS WHEN THROTTLE ENGAGED AT LOW SPEED. *TR

• 09/05/2013· POWER TRAIN,ENGINE

  AT 43,321 MILES, THE CHECK ENGINE LIGHT WAS ON. VEHICLE WAS BROUGHT TO A VOLKSWAGEN DEALERSHIP WHERE THE INTAKE MANIFOLD HAD TO BE REPLACED ALONG WITH THE FUEL INDUCTION. THE MANIFOLD WAS COVERED BY WARRANTY BUT, NOT THE FUEL INDUCTION. OUT OF POCKET COST $136.90 AT 54,337 MILES, WHEN ACCELERATED THERE WAS A HESITATION IN THE ENGINE AND THE CHECK ENGINE LIGHT HAD COME ON. VEHICLE WAS BROUGHT TO THE DEALERSHIP WHERE THE IGNITION COIL FOR CYLINDER 1 HAD TO BE REPLACED (CYLINDER MISFIRE FAULT AND COOLING FAN FAULTS) AND ALSO THE COOLING FAN WHICH WAS FAULTY. ALL NOT COVERED BY THE WARRANTY. OUT OF POCKET COST $864.35. *JB

• 09/04/2015· FUEL/PROPULSION SYSTEM

  SUDDEN FUEL SYSTEM FAILURE CAUSED ENGINE TO QUIT MULTIPLE TIMES WHILE DRIVING IN TRAFFIC. AFTER A FEW MINUTES SITTING DEAD IN TRAFFIC, THE ENGINE WOULD RESTART AND THE CAR WOULD OPERATE A FEW MINUTES UNTIL THE ENGINE SHUT-OFF AGAIN. THERE WAS NO WARNING THAT THE ENGINE WAS GOING TO QUIT. THE CAR HAD PLENTY OF FUEL. THE FOLLOWING TROUBLE CODES WERE PRESENT WHEN THE CAR WAS TAKEN TO A MECHANIC: P3043- FUEL PUMP MECHANICAL MALFUNCTION P0087- FUEL RAIL SYSTEM PRESSURE TOO LOW ULTIMATELY, THE LOW PRESSURE FUEL PUMP, THE HIGH PRESSURE FUEL PUMP AND THE FUEL CONTROL MODULE WERE REPLACED. EVEN THOUGH THE CAR HAD ONLY 32,000 MILES, VW DECLINED TAKING ANY RESPONSIBILITY FOR THE FAILURE.

• 08/25/2016· ENGINE

  MY WIFE WAS DRIVING THE CAR TO THE AIRPORT AND STOPPED AT THE CELL PHONE WAITING AREA. TRIED TO START AGAIN AND CAR DIDN'T START. CHANGED THE BATTERY WITH AAA AND STILL DIDN'T START. TOWED IT TO DEALER. THEY SAID THE TIMING CHAIN TENSIONER FAILED AND IT COMPLETELY DAMAGED THE ENGINE. ENGINE NEEDS TO BE REPLACED WHICH COSTS ABOUT $7K. I HAVE CHECKED ABOUT THIS PROBLEM IN INTERNET AND MANY PEOPLE ARE COMPLAINING ABOUT THE SAME ISSUE AND VW KNOWS ABOUT THIS ISSUE FOR SOME TIME. AS THIS CAN HAPPEN IN MIDDLE OF THE TRAFFIC AND CAN CAUSE A FATAL ACCIDENT, WE REQUEST YOU TO INVESTIGATE AND MAKE VOLKSWAGEN RECALL AND REPLACE THIS PART. ALSO, VW SHOULD TAKE RESPONSIBILITY FOR THE FAILED PART AND THE REPAIRS CAUSED DUE TO THIS PART AS IT KNOWS ABOUT THIS AND IGNORED. I ALSO SEE THERE IS A LAWSUIT GOING ON THIS ISSUE. CHECK THE LINK HTTP://WWW.CARCOMPLAINTS.COM/NEWS/2016/VOLKSWAGEN-TIMING-CHAIN-TENSIONER-LAWSUIT.SHTML VW REALLY SHOULD BE MORE RESPONSIBLE TO AVOID SERIOUS ACCIDENTS