2009 Volkswagen Jetta

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2009· FUEL SYSTEM, DIESEL

  POSSIBLE EVENTS LEADING UP TO THE FAILURE IS ONCE IN A WHILE WHEN THE CAR IS OFF AND PARKED THE ENGINE FAN WILL COME ON RUNNING VERY HIGH AND THE CAR SMELLS. THIS OCCURRED ABOUT 4 TIMES IN 4 MONTHS. THEN IN THE 5TH MONTH OF OWNERSHIP, WHILE DRIVING 50 MPH, I HEARD A BEEP, LOOKED DOWN AT MY DASH AND BEFORE I COULD FINISH READING THE MESSAGE THE CAR DIED. THE DASH INDICATED SOMETHING ABOUT GET TO A WORKSHOP, THEN THE MESSAGE DISAPPEARED AND THE COIL LIGHT CAME ON. I PUT MY FOOT ON THE GAS PEDAL AND NOTHING HAPPENED. THANKGOODNESS NO ONE WAS BEHIND ME OR WE WOULD HAVE BEEN HIT, I PUSHED THE CAR TO THE SHOULDER OF THE ROAD AND CALLED A TOW TRUCK. I WAS 80 MILES FROM HOME AND JUST MINUTES FROM GETTING ON THE MAIN FREEWAY. I WAS TOWED TO THE NEAREST VW DEALER. IT WAS A WEEKEND SO THE SERVICE DEPT WAS CLOSED. MONDAY I WAS TOLD THE ENTIRE FUEL SYSTEM WENT OUT AND WAS GOING TO BE COMPLETELY REPLACED. IT WAS REPLACED. IT'S BEEN 4 WEEKS SINCE IT WAS REPLACED AND TODAY WHEN I DROVE 25 MILES AND PARKED MY CAR, THE ENGINE FAN CAME ON RUNNING VERY HIGH, AND LOUD WITH THE SMELL OF BURNT RUBBER AND SMOKE COMING FROM THE HOOD. I CALLED THE DEALER AND WILL BE TAKING IT INTO THE DEALER NEXT WEEK, THEY ARE CONCERNED WITH THE SMELL. *TR

• 12/31/2009· ENGINE AND ENGINE COOLING

  2009 JETTA TDI HAS AN ISSUE WITH SUDDEN LOSS OF ENGINE POWER. USUALLY 100% REPRODUCIBLE IN WARM CLIMATE USUALLY HAPPENS WITHIN THE FIRST FEW MINUTES OF STARTING ENGINE WHILE TRAVELING AT 30MPH AT 2K RPMS WHILE HOLDING A STEADY SPEED. CAR WILL SUDDENLY JERK AND LOSE POWER ONE TIME THEN THE REMAINING TIME WILL BE WITHOUT ISSUE. ON AT LEAST TWO OCCASIONS WHILE PULLING OUT INTO TRAFFIC THE CAR HAS INTERMITTENTLY LOST ALL POWER FOR A FEW SECONDS ALMOST RESULTING IN CERTAIN PERSONAL INJURY ACCIDENTS. THIS WAS DUE TO THE FACT THAT AFTER STARTING THE CAR I TOOK A PHONE CALL BEFORE ENTERING TRAFFIC. I FEEL THAT THIS IS A TEMPERATURE/TIME RELATED PROBLEM AS THE TIME I WAS ON THE PHONE WOULD ABOUT EQUAL THE TIME THAT WHEN I NORMALLY WOULD HAVE LEFT THE LOT THE CAR WOULD HAVE HAD THE HICCUP/STUTTER. NUMEROUS COMPLAINTS ABOUT THIS PARTICULAR ISSUE CAN BE FOUND ON THE INTERNET AND THIS HAS BEEN DOCUMENTED THAT VWOA HAS BEEN CALLED ABOUT THIS BUT SEEMS TO NOT WANT TO DO ANYTHING TO RECTIFY THE SITUATION. *TR

• 12/30/2013· FUEL SYSTEM, DIESEL

  WHILE TRAVELING ON INTERSTATE THE VEHICLE LOST ACCELERATION AND LOST POWER WHILE ON EXIT RAMP. VEHICLE WAS TOWED TO NEAREST VW DEALER. INFORMED BY DEALER THAT THE HIGH PRESSURE FUEL PUMP HAD DISINTEGRATED AND SENT METAL THROUGHOUT FUEL SYSTEM AND THAT PARTS AND LABOR FOR REPAIR WOULD BE $6000-$8000. CALL TO VW FOR ASSISTANCE WAS REWARDED WITH THEIR OFFERING TO PAY FOR THE NEEDED REPAIRS. THERE WAS A LONG RECORDED HISTORY OF DEALER SERVICING AND PROOF OF ONLY DIESEL FUEL PURCHASES. NHTSA SHOULD INSURE THAT ALL TDI OWNERS BE NOTIFIED OF THIS PROBABILITY AND GIVEN THE OPPORTUNITY TO HAVE REPAIRS/REPLACEMENTS DONE BY VW. *TR

• 12/30/2010· SERVICE BRAKES, HYDRAULIC

  2009 VOLKSWAGEN JETTA 30,898 MILES REAR BRAKES ROTORS WORN AND PADS GONE. FRONT BRAKES STILL HAVE 40,000 MILES LEFT ON PADS, LOOK NEW ACCORDING TO CERTIFIED ASE BRAKE MECHANIC. CAR DOES NOT STOP SAFELY. MECHANIC WAS SHOCKED AT THE BRAKE WEAR ON REAR ROTORS AND PADS AND THE EXTREME WEAR ON THE BACK PADS AND ROTORS. CERTIFIED ASE MECHANIC ADVISED THAT FRONT WHEEL DRIVE CARS BRAKES SHOULD WEAR EVENLY, NOT ENTIRELY ON BACK BRAKES. VEHICLE NOT BREAKING RIGHT AT LOW OR HIGH SPEEDS. CAR STILL UNDER MANUFACTURER WARRANTY, DEALER REFUSES TO REPLACE. *TR

• 12/29/2020· POWER TRAIN

  THE CAR GOES INTO NEUTRAL WHILE DRIVING IT & WILL NOT RETURN TO GEAR. MY CAR ENDING UP STOPPING IN THE MIDDLE OF THE INTERSTATE! I WAS ALMOST IN A CRASH. THE DEALER REPAIR SAID IT WAS A MECHATRONIC ISSUE. THE RECALL INCLUDES MY YEAR & MODEL BUT SOMEHOW NOT MY CAR? THE DEALER & VW CORP TOLD ME MY VIN SPECIFICALLY WAS NOT PART OF THE TRANSMISSION MECHATRONIC RECALL BUT THAT'S EXACTLY WHAT IS HAPPENING. THE VIN'S NEED TO BE RE-EVALUATED BECAUSE THE PROBLEM STILL EXISTS. THE CAR JUST COMES OUT OF GEAR & STOPS -- NO WARNING!! NOW I'M STUCK WITH A CAR THAT I AM AFRAID TO DRIVE & CANNOT AFFORD $4K REPAIR (THE DEALER ALSO STATED IT'S A "DEALER ONLY" TYPE OF REPAIR).

• 12/29/2014· STRUCTURE

  WHEN IT RAINS THE DRAINS IN THE VOLKSWAGEN JETTA GET CLOGGED UP. ONCE THE DRAINS GET CLOGGED THE WATER COMES INSIDE THE INTERIOR OF THE CAR INTO THE ENTIRE FLOOR OF THE CAR. THE FLOOR IS THEN FLOODED WITH WATER. THEIR HAS BEEN A PREVIOUS LAWSUIT THAT WAS SETTLED FOR THE PREVIOUS VW MODELS 97-05 IN 2014. WHEN THE CAR WAS SOLD TO ME NO ONE NOTIFIED ME OF THIS PROBLEM AND HOW TO PREVENT THIS PROBLEM. NOW MY LOCAL VW DEALERSHIP WANTS TO CHARGE ME 1000 FOR THIS PROBLEM WHICH SHOULD NOT BE A PROBLEM FROM THE FIRST PLACE. *TR

• 12/28/2022· SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  This vehicle was purchased 11/2016 from a dealer/mechanic. He bought it at auction, reconstructed it and got the approvals to return it to full operation from the Massachusetts DOT. The title showed 'reconstructed' and 'prior collision'. Volkswagen notified us of Safety Recal 45F2 in 2017 - ABS control module - and we had the recall performed at Colonial VW in Westborough Mass in 2017. There is an extended warranty VWP-17-03 on vehicles repaired by Safety Recall 45F2. The car's ABS light illuminated and the dealership ran a diagnostic which ran code 16352 - control module faulty static. VW is telling the dealership that they will not honor the warranty because the car is a total loss. It is NOT a total loss, it has not been in an accident since it was reconstructed before we purchased it six years ago. I called VW and they said they won't cover it because it's a mechanical issue not a software issue but that's also not true. I see technical bulletin's online that say if Fault Code 01130 and or 16352 appear that warranty should apply, but they are not honoring their own warranty

• 12/28/2010· ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL,VEHICLE SPEED CONTROL

  WAS DRIVING ON RESIDENTIAL STREET, APPROXIMATELY 25-30 MPH, AND CAR JUST LOST POWER AND STALLED. AFTER A FEW MINUTES IT COULD START AGAIN - BUT THE VEHICLE WOULD NOT MOVE, EVEN IF GAS WAS PUSHED DOWN. AFTER A WEEK AT THE DEALERSHIP - THEY SAID IT WAS THE THROTTLE. MY CAR WOULD NOT START BEFORE (AFTER ONLY HAVING THE CAR FOR APPROXIMATELY 7 MONTHS AND APPROXIMATELY 2000 MILES) - AND AFTER HAVING IT TOWED TO THE DEALER, THEY JUST SAID THE FUEL WAS GELLING. BUT THEY DID DO A COMPUTER UPGRADE AND SAID THERE "PARTICLES IN THE FUEL LINE" THAT THEY CLEANED OUT AND SAID I MAY HAVE GOTTEN "BAD FUEL". 1 WEEK AFTER MY 40000 MILE ROUTINE MAINTENANCE CHECK - MY GLOW PLUG LIGHT WENT ON AND I HAD TO HAVE A SENSOR REPLACED.

• 12/28/2010· FUEL SYSTEM, DIESEL

  WHILE DRIVING ON INTERSTATE 5 IN CENTRAL OREGON, GOING APPROX. 60 MPH, 2009 DIESEL JETTA LOST POWER AND BEGAN TO STALL OUT. I HAD DRIVEN ALMOST 245 MILES ON THIS DAY (WITH THE SAME TANK OF FUEL), BEFORE THE STALL OCCURRED. MANY WARNING LIGHTS CAME ON THE DASH, INCLUDING A FLASHING GLOW PLUG LIGHT WITH ENGINE SYMBOL, ENGINE DEFAULT LIGHT AND WORKSHOP WARNING LIGHT. UPON COMING TO A STOP, THE CAR DIED COMPLETELY, WOULD NO LONGER START, AND HAD TO BE TOWED TO VW. UPON RECEIPT OF THE CAR, VW TRIED TO ACCUSE ME OF USING "BAD FUEL" BUT THEN CHANGED THEIR STORY, ONCE THEY DID MORE RESEARCH (AND THEY FOUND THAT MANY PEOPLE ACROSS THE US ARE HAVING THIS PROBLEM). VOLKSWAGEN STATES THAT THERE IS A COMPLETE FUEL PUMP SYSTEM FAILURE, WITH METAL PARTICULATE IN THE FUEL FILTERS AND SYSTEM, AND ALL COMPONENTS MUST BE REPLACED. THIS IS CURRENTLY IN PROGRESS, AND I AM STRANDED APPROXIMATELY 1,000 MILES FROM MY HOME, WITH NO INDICATION OF A SET COMPLETION DATE FOR REPAIRS. I AM VERY CONCERNED THAT THIS ISSUE WILL REOCCUR, AS IT IS BEING REPORTED ON A LARGE SCALE BY MANY TDI JETTA OWNERS ON THE WEB FORUMS. PLEASE SEE LINKS: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=273983 HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=269781 HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=280693 HTTP://WWW.TDI-ISSUES.COM/HPFP-CASES-TAC68/ HTTP://WWW.TDI-ISSUES.COM/HPFP-CASES-TAC68/2010-VW-JETTA-TDI-GAP186.HTM#COMMENT344 HTTP://WOT.MOTORTREND.COM/DIESEL-INVESTIGATION-NHTSA-INVESTIGATING-VOLKSWAGEN-JETTA-TDIS-OVER-STALLING-8723.HTML. *TR

• 12/27/2012· FUEL SYSTEM, DIESEL,FUEL/PROPULSION SYSTEM

  VW VOLKSWAGEN JETTA SPORTWAGEN TDI 2009. WAS DRIVING ABOUT 35 MPH WHEN ENGINE LOSES MOST OF ITS POWER. A GLOW PLUG INDICATOR LIGHT TURNED ON AND I SAW AN ENGINE FAULT/WORKSHOP ERROR. I QUICKLY TURNED ONTO A SIDE STREET AND STOPPED THE ENGINE. AFTER A COUPLE MINUTES I RESTARTED THE CAR BUT IT STILL HAD LOW POWER. AFTER ABOUT 10 SECONDS IT STALLED AND COULD NOT BE RESTARTED. HAD IT TOWED TO A VW DEALERSHIP AND 5 DAYS LATER THEY RAN DIAGNOSTICS AND SAID IT WAS A FAILED FUEL PUMP AND THAT METAL SHARDS WERE THROUGHOUT THE FUEL SYSTEM AND EVERYTHING NEEDED TO BE REPLACED. *TR

• 12/26/2021· SERVICE BRAKES

  As I was coming to an immediate stop, due to a deer jumping out in front of me, the car/ brake pedal shuddered and I had to perform an emergency braking procedure by swerving onto the shoulder of the road. Thankfully no one was injured, including the deer, however, my nerves were frayed, as had this been in the snow or any other adverse conditions, what would have been the outcome then? Immediately after this happened the ABS light and flashing brake light appeared on the dash. I have used a scan tool to diagnose the issue to which the code #01130 (ABS Operation Implausible Signal). Through research online- forums it has come to my attention that this is a very common VW issue to the point that the NHTSA has requested/ mandated that a recall should be issued- www.automotive-fleet.com (January 7, 2017). When I went to the VW recall site and plugged in my VIN no recalls were listed?? I will be taking my car to the dealer tomorrow, as I am a one car household and need my '09 Sportwagen for daily transportation to and from work, I am hoping that they will honor the replacement of this faulty safety device.

• 12/26/2011· FUEL SYSTEM, GASOLINE

  GLOW PLUG LIGHT AND ENGINE FAULT WORKSHOP LIGHT CAME ON AS I WAS PULLING INTO WORK IN A.M. PARKED AND RESTARTED VEHICLE, WITH NO FURTHER WARNING LIGHTS. I MADE APPOINTMENT FOR SCHEDULED MAINTENANCE WITH DEALER. WHEN I LEFT FOR HOME THAT EVENING THE VEHICLE STARTED OK WITH NO WARNING LIGHTS. WHILE DRIVING DOWN THE INTERSTATE FREEWAY AT 70 MPH THE SAME WARNINGS SUDDENLY CAME BACK ON AND VEHICLE SUFFERED IMMEDIATE DECREASE IN POWER WITH SPEED DOWN TO ABOUT 50 MPH. I EXITED THE INTERSTATE AND TRIED TO MAKE IT TO THE VW DEALERSHIP, BUT ENGINE SHUT DOWN WHEN I STOPPED AT STOP SIGN AND WOULD NOT RESTART. VEHICLE WAS PUSHED TO THE ROADSIDE BY STATE POLICE AND HAD TO BE TOWED. VW MECHANIC FOUND THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED WITH EXCESSIVE METAL SHAVINGS FOUND THROUGHOUT THE FUEL SYSTEM. A DIESEL FUEL SAMPLE WAS SENT FOR TESTING AND WAS OKAY. DEALER HAD TO REPLACE THE ENTIRE FUEL SYSTEM. *TR

• 12/25/2014· ENGINE

  I AM "GUESSING AT SOME OF THE INFORMATION ABOVE SINCE IT WAS THE FIRST TIME IT HAPPENED AND I DIDN'T GIVE IT MUCH THOUGHT THEN. AT THAT TIME, I WAS MAKING A RIGHT-HAND TURN TO ANOTHER STREET AND THE ENGINE STALLED. THERE WAS NO WARNING LIGHT OR SIGNAL. I PULLED OVER TO THE SIDE OF THE ROAD, RESTARTED THE ENGINE AND IT WORKED FINE. THIS OCCURRED SOMETIME IN MID TO LATE SEPTEMBER. YESTERDAY (12/24/2014) I WAS AT A STOPLIGHT AND THIS HAPPENED AGAIN -- THE ENGINE STALLED WHILE I WAS ALREADY STOPPED WHILE WAITING FOR THE LIGHT TO CHANGE FROM RED TO GREEN. AGAIN, THERE WAS NO WARNING LIGHT OR SIGNAL. IT WAS REMNISCENT OF WHEN I DROVE A STANDARD TRANSMISSION VEHICLE AND INAPPROPRIATELY TOOK MY FOOT OFF THE CLUTCH. I WAS ABLE TO RE-START AND ENGINE RAN FINE. I AM LEERY OF DRIVING THE CAR AGAIN, HOWEVER, FOR FEAR THAT THIS WILL HAPPEN AGAIN. I PLAN TO TAKE TO MY MECHANIC ASAP. READING THE DESCRIPTIONS OTHERS HAVE HAD WITH THIS ISSUE ARE VERY SIMILAR TO MINE. I HAVE KEPT UP WITH MAINTENANCE AND CARE OF THE VEHICLE AND IT HAS LESS THAN 25K MILES ON IT. *TR

• 12/25/2012· ENGINE

  MY VW JETTA HAD SAT FOR A FEW DAYS IN A INDOOR PARKING SPACE IN THE MIDWEST DURING WINTER DECEMBER TO BE EXACT. WHEN I STARTED THE CAR, IT STARTED WEAK, THEN GAVE AN ERROR ON THE DISPLAY OF "ENGINE FAULT WORKSHOP.". THE CAT CONTINUED TO DRIVE, BUT LACKED POWER AND SEEMED TO SURGE. AFTER I RETURNED HOME, I DISCONNECTED THE LOWER INTERCOOLER HOSE TO FIND A LARGE ICE FORMATION AND WATER RESTRICTING THE OUTLET OF THE INTERCOOLER. THIS PROBLEM CAN CAUSE MAJOR ENGINE DAMAGE AND IS CAUSED.BY THE EXHAUST GASES AND WATER VAPOR FREEZING IN THE INTERCOOLER. EVERY VW WITH THIS STYLE INTERCOOLER SETUP HAS POTENTIAL FOR THIS PROBLEM. IT SHOULD BE RECALLED DO TO ITS SEVERITY. ALSO, THERE IS A TSB ALREADY WRITTEN FOR THE "FIX". BUT VW HAS NOT INFORMED ANYONE, NOR WILL TAKE CARE OF THE PROBLEM FOR ANYONE BEYOND THE 36000 MILE WARRANTY. EVEN THOUGH THIS IS A DESIGN FLAW. *TR

• 12/24/2011· FUEL SYSTEM, GASOLINE

  CAR WOULD NOT START. LUCKILY PARKED IN GARAGE. TOWED TO DEALER. DETERMINED TO BE HPFP FAILURE AND DPF FAILURE. HPFP AND DPF REPLACED ALONG WITH ASSOCIATED SMALL PARTS. BUT DID NOT REPLACE ENTIRE FUEL SYSTEM. A FUEL SAMPLE TAKEN FROM THE FUEL RETURN HOSE WHEN THE CAR DIED LOOKS LIKE FINE METALLIC PARTICLES. SETTLED TO THE BOTTOM OF THE JAR AFTER SEVERAL DAYS. A MAGNET DID NOT ATTRACT THE PARTICLES SO MUST HAVE BEEN ALUMINUM - MOST LIKELY FROM THE PISTON BORE OF THE HPFP. VW PAID FOR THE REPAIR. THE DAY I GOT THE CAR BACK I TOOK A FUEL SAMPLE FROM THE FUEL TANK. ONCE AGAIN METAL PARTICLES (ALONG WITH OTHER DEBRIS NORMALLY FOUND IN A FUEL TANK) WERE FOUND. NOW WE ARE FEARFUL OF DRIVING THE CAR DUE TO METAL PARTICLES IN THE FUEL SYSTEM WILL DESTROY THE NEW HPFP. PLEASE MAKE VW DO A RECALL AND REPLACE THE PUMP WITH A NEW DESIGN THAT WILL NOT SELF DESTRUCT! A CAR THAT SHOULD GO 200K MILES OR MORE HAS FAILED AT 67K MILES. AND IS GUARANTEED TO FAIL AGAIN DUE TO THE POOR DESIGN OF THE HPFP. THIS IS A HUGE FINANCIAL HIT FOR OUR FAMILY AS NOW WE ARE FEARFUL OF DRIVING THE CAR AND MAY HAVE TO SELL IT TO GET A MORE RELIABLE CAR. VW IS BLAMING THE PROBLEMS ON FUEL CONTAMINATION AND THAT MAY BE TRUE BUT THERE IS NO EXCUSE FOR A HUGE REPAIR BILL FROM ONE TANK OF FUEL THAT IS NOT UP TO SPECS. *TR

• 12/23/2016· ELECTRICAL SYSTEM,SEATS

  THE HEATED SEAT BURNED A HOLE IN THE SEAT. THE INTERIOR OF THE SEAT SOUNDS AND FEELS THAT IT HAS MELTED AND HAS BECOME HARD. THIS IS ON THE SEAT BACK. WE ARE UNSURE WHEN THIS BURNING OCCURRED, BUT HAVE NOTED BELOW WHEN WE NOTICED THIS DAMAGE.

• 12/22/2015· SEAT BELTS,FUEL/PROPULSION SYSTEM

  WHILE DRIVING ON A CITY STREET, MY CAR BEGAN TO MAKE A RUMBLING SOUND, FOLLOWED BY A ENGINE WARNING MESSAGE TURNING ON. WITHIN A MINUTE, MY CAR DIED AND WOULD NOT RESTART. WE TOWED OUR 2009 VW JETTA SPORTWAGEN TDI TO A VW SPECIALIZED MECHANIC WHO CONFIRMED THAT THERE WERE METAL SHAVINGS IN THE FUEL SYSTEM THAT SEEMS TO BE RESULTING FROM A HPFP FAILURE. MILEAGE WAS AT 131769 AT TIME OF FAILURE. (OUTSIDE OF THE EXTENDED WARRANTY TIME PERIOD FOR THE HPFP ISSUE) 12/21/2012 TWO FAULTY REAR PASSENGER SEAT BELTS WERE REPLACED. AIRBAGS HAD NOT BEEN DEPLOYED AND CAR HAD NOT BEEN IN AN ACCIDENT PRIOR TO SEAT BELTS BREAKING.

• 12/22/2014· FUEL SYSTEM, DIESEL,ELECTRICAL SYSTEM,ENGINE

  DRIVING DOWN FREEWAY AT 61MPH, ENGINE TURNS OFF. NO POWER STEERING OR BRAKES WHILE I CHANGED LANES IN HEAVY TRAFFIC TO GET TO THE SHOULDER OF THE ROAD. CAR WOULD NOT START AND HAD TO TOW TO THE DEALERSHIP. DEALER REPLACED BATTERY, PRIMED FUEL SYSTEM, GAVE CAR BACK. AFTER FIVE DAYS, CHECK ENGINE LIGHT CAME ON, SO I TOOK CAR TO DEALERSHIP. THEY REPLACED GLOW PLUG CONTROL MODULE AND GAVE CAR BACK. DRIVING DOWN HIGHWAY WHEN CAR AGAIN DIES, ENGINE TURNS OFF WITHOUT WARNING. I HAVE TO CHANGE LANES AGAIN WITH NO POWER STEERING OR BRAKES TO GET OFF THE ROAD. TOWED VEHICLE TO DEALERSHIP WHERE THEY SAY THE HIGH PRESSURE FUEL PUMP NEEDS TO BE REPLACED. THIS IS A VERY SCARY AND DANGEROUS PROBLEM TO HAVE A CAR TURN ITSELF OFF WHILE DRIVING DOWN THE FREEWAY. *TR

• 12/22/2011· ENGINE AND ENGINE COOLING

  CAR IS 2009 VOLKSWAGEN JETTA TDI 2.0L COMMON RAIL INTER COOLED TURBO DIESEL.L ISSUE OCCURS AFTER DRIVING IN BELOW FREEZING WEATHER, AND ATTEMPTING TO RESTART AFTER WEATHER HAS GONE ABOVE FREEZING (SUCH AS DRIVING TO WORK IN FREEZING WEATHER, TEMPS WARM UP DURING THE DAY, OCCURS ON ATTEMPT TO DRIVE HOME). VEHICLE WILL START, THEN DIE AFTER A VERY BRIEF RUN OF 5 SECONDS OR LESS. RESTARTS WILL RANGE TO VERY LONG CRANKING BEFORE A VERY ROUGH RUN, OR NO CRANKING WITH ALL LIGHTS AN EQUIPMENT GOING OUT DUE TO VERY HIGH AMP DRAW ON STARTER MOTOR. WATER AND OIL IS NOTED DRIPPING FROM THE INTER COOLER PIPING AS IT LEADS TO THE ENGINES INTAKE. PIPING REMOVED TO ALLOW SOME WATER TO DRAIN OUT. AFTER SEVERAL ATTEMPTS OF 1 REVOLUTION AT A TIME, CAR WILL START TO TURN MORE AND MORE IF A PAUSE OF 30 SECONDS BETWEEN ATTEMPTS IS ALLOWED. SUSPECTED WATER SUCKED INTO COMBUSTION CHAMBER AND HYDRO-LOCKING ENGINE. WATER IS SUSPECTED TO SEEP PAST THE PISTON RINGS INTO THE CRANKCASE WHILE PAUSING BETWEEN START ATTEMPTS. THIS IS PROVEN WITH FROTHY MOISTURE ON THE OIL FILL CAP AFTER EACH INCIDENT. SUSPECTED ISSUE IS MOISTURE FROM EGR SYSTEM GOES INTO INTAKE AIR, AND IS FREEZING IN THE INTER COOLER IN FREEZING WEATHER. WHEN WEATHER WARMS UP WHILE THE CAR IS OFF, THE WATER WILL POOL IN THE INTER COOLER PIPING. UPON ATTEMPTED RESTART, WATER IS SUCKED INTO THE ENGINE CAUSING ANYWHERE FROM SOME ROUGH STUMBLING TO FULL HYDRO-LOCK. INCIDENT HAS HAPPENED 6+ TIMES IN VARYING SEVERITY. ISSUE IS KNOWN TO HAPPEN TO CO-WORKERS CAR WITH THE SAME TURBO DIESEL ENGINE ON THE SAME DAY. NO CODES THROWN FOR ANY OCCURRENCE VIA OBD TESTER. ONE TIME, THE GLOW PLUG LIGHT FLASHED SEVERAL TIMES. *TR

• 12/22/2009· POWER TRAIN

  2009 VW JETTA TDI (TURBO-DIESEL) EQUIPPED WITH DSG (DIRECT SHIFT GEARBOX) TRANSMISSION. VEHICLE PREMATURELY DOWNSHIFTS FROM 2ND INTO 1ST GEAR AT SLOW SPEEDS. WHEN DRIVING IN 'TIPTRONIC' (MANUAL) SHIFT MODE AT SLOW SPEED CONDITIONS, SUCH AS RIGHT TURNS, PARKING LOTS/GARAGES, YIELD CONDITIONS, ETC., THE VEHICLE WILL DOWNSHIFT UNEXPECTEDLY FROM 2ND GEAR INTO 1ST AFTER REACCELERATION HAS ALREADY BEGUN, RESULTING IN THE ENGINE'S RPMS TO "SKYROCKET". IF THIS OCCURS WITHIN A TURN IN TRAFFIC, THE VEHICLE'S ACCELERATION IS STALLED DUE TO THE LOWER GEAR. PANICKING, ONE SHIFTS THE VEHICLE INTO 2ND AT THE HIGH RPMS AND THE TRANSMISSION JOLTS UNDER THE POWER AND CAUSES THE VEHICLE TO SURGE FORWARD RAPIDLY UNDER POWER. THIS HAS CONTRIBUTED TO NEAR REAR-END CRASH SITUATIONS FOR BOTH DRIVERS FOLLOWING AT THE DOWNSHIFT/STALL CONDITION AS WELL AS VEHICLES IN FRONT AT THE UPSHIFT/ACCELERATION CONDITION. IN PARKING LOTS WHILE MODERATELY TRAVELING IN 2ND GEAR LOOKING FOR A PARKING STALL, WITHOUT WARNING, AGAIN THE VEHICLE WILL SOMETIMES DOWNSHIFT INTO FIRST CAUSING THIS BRAKING "BUCKING' EFFECT AND THE ENGINE RPMS SKYROCKET UNTIL ONE EITHER LIFTS OFF THE ACCELERATOR OR SHIFTS BACK INTO 2ND. THIS CONDITION HAS BEEN INTERMITTENT FOR OVER A YEAR NOW AN OVERALL MAKES IT VERY DIFFICULT AND UNNERVING TO DRIVE IN STOP AND GO TRAFFIC, PARKING LOTS, AREAS WITH SPEED BUMPS, GARAGES, OR ANY OTHER SLOW SPEED ENVIRONMENTS WHERE ONE WOULD PREFER TO OPERATE THE VEHICLE IN 'MANUAL' SHIFT MODE AS PROVIDED BY THE DSG'S DESIGN. IT SEEMS APPARENT TO ME THAT THE SOFTWARE AND/OR SENSOR COMPONENTS RELATED TO THE SHIFTING CHARACTERISTICS OF THE DSG WHILE IN THESE MODES, SHOULD NOT ALLOW THE VEHICLE TO DOWNSHIFT INTO THE 1ST GEAR UNLESS THE VEHICLE COMES TO A STOP, OR AT LEAST AT AN ALMOST NON-DETECTABLE SPEED, THEREBY ALLOWING THE DRIVER TO REACCELERATE IN 2ND WHICH, IN COMBINATION WITH THE HIGH-TORQUE NATURE OF THE DIESEL ENGINE IS MORE THAN SUFFICIENT FOR THESE SCENARIOS. *TR

• 12/20/2016· FUEL SYSTEM, DIESEL,ENGINE

  WIFE WENT OUTSIDE TO START HER TDI AND AFTER SITTING AND MAKING NO PROGRESS IN WARMING AND SMELLING A LOT OF UN-BURNT DIESEL SHE DECIDED TO SHUT IT OFF. AFTER SHE CAME INSIDE AND TOLD ME IT WAS NOT WARMING UP AND IT SEEMED TO BE RUNNING OUT OF FUEL VERY QUICKLY I WENT OUTSIDE TO CHECK IT OUT. I COULD SEE THAT DIESEL HAD LEAKED ONTO THE GROUND, SO I OPENED THE HOOD AND FUEL WAS DRIPPING FROM THE ENGINE MOUNTED FUEL PUMP. I LEFT IT OVERNIGHT AT THIS POINT TO MAKE SURE NO FIRES WHERE STARTED. THE NEXT MORNING I TOOK IT APART TO FIND OUT WHAT THE SOURCE OF THE LEAK AND AFTER REMOVING THE PUMP, ASSOCIATED ELECTRICAL, AND RUBBER LINES I SAW THE END OF THE PUMP HAD POPPED OUT OF ITS CRIMPED ALUMINUM CASE. THIS WAS ALLOWING DIESEL TO LEAK PAST THE RUNNING ELECTRIC PUMP AND ONTO THE RUNNING ENGINE WHICH AT THE POINT OF TURNING IT OFF HAD COVERED THE ENTIRE SERPENTINE SIDE OF THE ENGINE COMPLETELY IN FUEL. IT WAS A BOSCH PART #1K0 906 098A WE HAVE CONTACTED VW ABOUT THIS AND THEY OFFERED NO ASSISTANCE IN EITHER OFFERING TO INVESTIGATE THE LEAK OR EXPEDITING THE BUYBACK PROCESS TO REMOVE THIS VEHICLE FROM THE ROADS AND MY DRIVEWAY KNOWING THAT IT LEAKED FUEL. VW DID ACKNOWLEDGE A PRIOR RECALL ON A RUBBER FUEL SUPPLY LINE HAD BEEN PERFORMED BEFORE THE CAR WAS PURCHASED. *TR

• 12/20/2012· SERVICE BRAKES, AIR

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, SHE NOTICED THAT THE ABS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE THEN STALLED BY INDEPENDENTLY SHIFTING TO NEUTRAL WITHOUT WARNING. THE CONTACT HAD TO WAIT SEVERAL MINUTES IN ORDER TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THEY ADVISED HER THAT THE ABS MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 48,500. MAILED OUT 3/10/15*LJ UPDATED 03/31/15*LJ

• 12/20/2012· ELECTRICAL SYSTEM

  DOOR LOCKS BEGAN TO MALFUNCTION. LOCKS WILL NOT LOCK OR RELEASE WITH KEY FOB OR DOOR LOCKING MECHANISM. THIS PROBLEMS WAS IDENTIFIED BY THE SERVICE TECH AT THE DEALERSHIP AS NORMAL AND A REGULAR REPLACEMENT FOR MODEL YEARS 2006-2010. *TR

• 12/20/2011· FUEL SYSTEM, DIESEL

  WHILE DRIVING, OUR 2009 VW JETTA TDI STALLED AND STOPPED IN AN INTERSECTION. WHEN RESTARTED THE GLOW-PLUG LIGHT AND CHECK ENGINE LIGHT STAYED ON WHILE THE CAR LIMPED TO A STOP ON THE SIDE OF THE ROAD. WE HAD THE CAR TOWED TO THE LOCAL VW DEALER AND WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED AND THE TOTAL FUEL SYSTEM WOULD HAVE TO BE REPLACED DO TO CONTAMINATION. I WAS SURPRISED WHEN THE EST'D COST OF $7,500 TO REPAIR MY CAR WAS PRESENTED TO US WITH NO OFFER OF HELP BY VW. I WAS EVEN MORE SURPRISED WHEN THE SERVICE WRITER SAID THAT PART HAS BEEN REDESIGNED A NUMBER OF TIMES TO HELP DEAL WITH THIS ISSUE. *TR

• 12/20/2011· FUEL SYSTEM, DIESEL

  THE CAR IS A 2009 VW JETTA TDI CLEAN DIESEL. WHILE ON THE NEW YORK STATE THRUWAY AT 55 MPH, SUDDENLY THE CAR'S WARNING CHIME SOUNDED, THE CHECK ENGINE LIGHT CAME ON, THE GLOW PLUG WARNING LIGHT FLASHED AND THE CAR IMMEDIATELY LOST POWER, AND I COASTED TO A STOP ON THE SHOULDER. IT WAS TOWED TO THE NEAREST DEALER, WHO REPLACED THE ENTIRE FUEL SYSTEM AT VW'S COST. THEY SAID IT WAS THE HPFP (HIGH PRESSURE FUEL PUMP) THAT DISINTEGRATED AND DESTROYED THE FUEL SYSTEM, FROM THE FUEL TANK FORWARD. *TR

• 12/19/2012· FUEL/PROPULSION SYSTEM

  CAR: 2009 VOLKSWAGEN TDI SPORTWAGEN ON DECEMBER 16TH AT APPROXIMATELY 1230PM, I ENTERED INTERSTATE I-95 VIA EXIT 19 IN SOUTHPORT, CT HEADING SOUTHBOUND. AS I ACCELERATED AND MERGED INTO THE LANE FROM THE ONRAMP AS I GOT UP TO SPEED (@60 MPH) THE "GLOW PLUG LIGHT" CAME ON AND THEN THE ENGINE LIGHT CAME ON. THE CAR IMMEDIATELY BEGAN LOSING POWER AND I PULLED OVER TO THE SIDE OF THE VERY BUSY INTERSTATE. IT WAS DANGEROUS AS I LOST POWER AND HAD TO MANEUVER BETWEEN PASSING CARS IN ORDER TO GET TO THE SHOULDER TO PULL OVER. I TURNED OFF THE ENGINE AND LET THE CAR REST FOR A MINUTE OR SO. I TURNED THE ENGINE BACK ON AND THE CHECK ENGINE LIGHT CAME ON AGAIN. I ATTEMPTED TO ACCELERATE AND THE CAR HAD VERY LIMITED POWER SO I IMMEDIATELY STOPPED THE CAR AGAIN AND TURNED OFF THE ENGINE. I GOT OUT OF THE CAR, OPENED THE HOOD, AND NOTICED WHAT APPEARED TO BE GASOLINE COATING THE ENGINE AS WELL AS TRAILING BEHIND THE CAR. I CALLED AAA AND HAD MY CAR TOWED TO THE RIVERBANK VOLKSWAGEN DEALERSHIP IN STAMFORD, CT WHICH WAS CLOSED DUE TO THE FACT THAT IT WAS SUNDAY. THE FOLLOWING DAY I SPOKE WITH THE SERVICE MANAGER AND WAS INFORMED THAT THE CAR WOULD NOT BE LOOKED AT UNTIL FRIDAY DECEMBER DEC 21ST WHEN A "SPECIALIST" FROM VW WOULD ARRIVE TO INSPECT THE CAR. I HAVE PERFORMED MY OWN DILIGENCE AND HAVE FOUND THAT SIMILAR ISSUES WITH THE 2009 JETTA TDI'S HAVE BEEN FAIRLY COMMON AND I EXPECT (HOPE) VW WILL COVER ALL REPAIR AND RENTAL CAR COSTS FOR ME IN THIS MATTER. *TR

• 12/19/2009· SERVICE BRAKES, HYDRAULIC

  2009 VW JETTA SPORTWAGEN TDI INTERMITTENT HOT REAR BRAKE DISCS. EFFECTS MPG BY MINUS 10% PLUS. SOMETHING IS CAUSING REAR BRAKES TO GET HOT(REAR BRAKE BIAS). FRONT BRAKES ARE ALWAYS COOL. COULD CAUSE AN ACCIDENT IN ICE AND SNOW POSSIBLE FIRE. SOMETIMES UNABLE TO BACK UP!!! LIKE BRAKES ARE LOCKED UP! IT HAS A MIND OF ITS OWN!!!!!!!!!!!!!!!!!!!!! VW OF AMERICA IS NOT INTERESTED ! NOR CAN THE DEALER SOLVE THE PROBLEM. " THE VEHICLE MEETS SPECIFICATIONS" THIS HAS BEEN WRITTEN UP IN VW FORUMS AND BLOGS. WE ARE NOT THE ONLY ONES WITH THIS PROBLEM. HOW OFTEN DO YOU FIND SOMEONE THAT CHECKS THE TEMP. OF REAR AND FRONT BRAKE DISCS? I DID BECAUSE IN JANUARY OF 2009 THE REAR BRAKES WERE SO HOT THAT IT SMELLED UP MY GARAGE. COULD HAVE CAUSED A FIRE!!!!!!!!!!!!!!!!!!!!!!!! *TR

• 12/17/2016· UNKNOWN OR OTHER

  AUTOMATIC DOOR LOCKS WON'T WORK CAUSING THE VEHICLE DOORS TO REMAIN LOCKED OR UNLOCKED WITHOUT REPAIR AT $400 PER DOOR. IF DOOR IS STUCK IN LOCKED POSITION, PASSENGERS CAN NOT EXIT THE VEHICLE IN AN EMERGENCY. IF STUCK IN UNLOCKED POSITION, VEHICLE CAN NOT BE LOCKED AND UNINVITED PASSENGERS CAN ENTER THE VEHICLE. BOTH ARE SAFETY HAZARDS. ISSUE OCCURS REGARDLESS IF THE CAR IS STATIONARY OR IN MOTION.

• 12/17/2014· ENGINE

  AFTER NUMEROUS ATTEMPTS BY DEALER TO FIX ENGINE LIGHT INDICATOR (3 ATTEMPTS IN 5 DAYS) SAID MAF PART BAD AS PER COMPUTER CODES. *TR

• 12/17/2014· POWER TRAIN,ENGINE

  2009 VOLKSWAGEN JETTA TDI WITH DSG TRANSMISSION WITH 67,000MILES WHILE ACCELERATING TO ROADWAY SPEED THE VEHICLE BEGAN HESITATING FOLLOWED BY A DRAMATIC LOSS OF POWER AND STRUGGLED TO ACCELERATE AT ALL. GLOW PLUG LIGHT BEGAN FLASHING AND CHECK ENGINE LIGHT CAME ON AFTER ABOUT 1 MINUTE. DRAMATIC LOSS OF POWER COULD HAVE RESULTED IN CRASH. VOLKSWAGEN DEALER DIAGNOSED THE ISSUE AS A DEFECTIVE CRANK SHAFT POSITION SENSOR WHICH COULD ONLY BE REPLACED AT A COST OF OVER $2,000 DUE TO THE IN ACCESSIBILITY OF THE SENSOR AND NEEDING TO UNINSTALL AND RE-INSTALL THE ENGINE. *TR

• 12/17/2011· AIR BAGSCrash

  AIRBAGS FAILED TO DEPLOY, 55 MPH FRONTAL IMPACT. VEHICLE SUSTAINED SEVERE FRONTAL DAMAGE AND IS MORE THAN LIKELY TOTALED . NO ONE WAS HURT BUT I THINK THAT THE AIRBAGS SHOULD HAVE DEPLOYED. I HAVE PICTURES OF VEHICLE IF NEEDED. *TR

• 12/17/2011· ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL

  VEHICLE ABRUPTLY LOST POWER, NO CONTROL OVER ACCELERATION, HAD TO PULL OFF OF INTERSTATE TO SHOULDER OF ROAD. CAR RESTARTED FINE. TAKING TO VW DEALER FOR EVALUATION. *TR

• 12/17/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY HESITATE WHILE ACCELERATING FROM A STOP. THE CONTACT APPLIED PRESSURE TO THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT RESPOND FOR A FEW SECONDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES BUT THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 50,000.

• 12/17/2010· ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL

  CAR HAS STUTTERED WHEN ACCELERATING FROM STOP SINCE PURCHASING WITH 12 MILES. ON 12/21/2009, CAR LOST POWER AND STUTTERED AT SPEED ON INTERSTATE HIGHWAY. THE ROAD IMMEDIATELY CLIMBED A HILL. WITH ACCELERATOR TO THE FLOOR, THE CAR DROPPED TO UNDER 60 MPH AND I SHIFTED FROM 6TH TO 5TH. CAR STILL KEPT DECELERATING SO I SHIFTED TO 4TH. FORTUNE PROVIDED A REST AREA AS THE CAR GOT TO ABOUT 45 MPH ON THE INTERSTATE. AFTER PARKING, CAR STALLED WHILE IDLING. STARTING ENGINE WOULD ROUGHLY IDLE AT 1/2 OF THE IDLE RPM FOR ABOUT 5 SECONDS BEFORE STALLING. AFTER 4 TRIES, I LET THE CAR SIT FOR 10 MINUTES AND IT RESTARTED WITHOUT FURTHER INCIDENT. THE CAR HAD DIESEL PURCHASED IN UPSTATE NY IN THE WINTER, PRESUMABLY A WINTER BLEND. THE INCIDENT HAPPENED IN VA IN 30+ DEGREE TEMPERATURES, SO PRESUMABLY GELLING OF THE FUEL WAS NOT THE PROBLEM. ADDITIONALLY, ON 12/17/2010, CAR STARTED BUT WOULD NOT REV ABOVE 1500 RPM EVEN WHILE OUT OF GEAR. WOULD NOT GO MORE THAN 10 MPH. I ASSUME IT IS THE FUEL SYSTEM BUT THE VW DEALER CLAIMS EVERYTHING IS FINE WITH THE CAR.

• 12/16/2012· FUEL SYSTEM, DIESEL,FUEL/PROPULSION SYSTEM

  I STARTED MY CAR AND FOR THE FIRST TIME EVER, IT HESITATED AND FAILED TO START. I RESTARTED MY CAR AND IT STARTED. I PROCEEDED TO DRIVE HOME AND ABOUT A HALF MILE INTO THE DRIVE IT HESITATED AND LOST MUCH OF ITS POWER. A FLASHING GLOW PLUG WARNING LIGHT CAME ON AND THEN A QUICK MESSAGE ON THE DISPLAY ABOUT AN ENGINE FAILURE AND BRING TO SERVICE. I WAS ABOUT A MILE FROM MY VW DEALERSHIP AND DROVE TOWARDS IT. ABOUT A QUARTER OF A MILE LATER, THE CAR (STILL HESITATING - NOW I KNOW IT IS CALLED "LIMP MODE") MADE A GRINDING NOISE FROM THE PASSENGER SIDE OF THE ENGINE BAY, AND THE CAR LOST ALL POWER AND STOPPED IN TRAFFIC. I HAD TO HAVE IT TOWED TO THE DEALERSHIP, WHERE THEY DIAGNOSED A HIGH PRESSURE FUEL PUMP FAILURE. THE ENTIRE FUEL SYSTEM (FUEL TANK, 3 PUMPS, ALL FUEL LINES, COMMON RAIL FUEL DELIVERY SYSTEM, FUEL FILTER HOLDER, FUEL FILTER, FUEL INJECTORS) WERE REPLACED UNDER POWER TRAIN WARRANTY. I AM THE ONLY PERSON TO FILL THIS CAR WITH DIESEL FUEL AND ALWAYS DO SO AT REPUTABLE STATIONS. THE FUEL WAS TESTED AND DID NOT CONTAIN GASOLINE OR ANY ADDITIVES. THIS CAR WAS FIRST PURCHASED IN NORTH CAROLINA AND IS A US VEHICLE. I BOUGHT IT FROM THE ORIGINAL OWNER (AT 6200 MILES) AND DROVE IT TO CANADA. IT IS REGISTERED IN ONTARIO. I HAVE HAD ALL SERVICE DONE IN BUFFALO NY AT NORTHTOWN VW WHILE UNDER WARRANTY AND THIS REPAIR WAS ALSO PERFORMED (AS PER VW OF AMERICA RESTRICTIONS) IN BUFFALO NY. I HAD TO PAY THE EXPENSE OF HAVING IT TOWED FROM TORONTO TO BUFFALO. *TR

• 12/15/2020· SERVICE BRAKES

  SHORTLY AFTER THE EMISSIONS RECALLS WHERE DONE IN 2019 AT APROX 184,000. AT APPROX 186,000 MILES THE ABS CONTROL MODULE WENT OUT. THE VEHICLE HAS 190,000 MILES AND I HAVE CALLED MY LOCAL VW DEALER AND THEY SAY NO RECALLS FOR THIS. THERE HAS BEEN OVER 136,000 VEHICLES AFFECTED, SO WHY ISNT MINE UNDER A RECALL? I HAD JUST PURCHASED THE VEHILCE.

• 12/15/2019· ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  THE CAR DISABLES THE ABS WHILE DRIVING, AND THE ABS, BRAKE AND ELECTRONIC STABILITY CONTROL INDICATORS ARE LIT SIMULTANEOUSLY, WHILE THE CAR DINGS. QUITE DISTRACTING. A LITTLE RESEARCH SHOWS COMPLAINTS FOR THE SAME BEHAVIOR SINCE JUST OCT. 30, 2019: NHTSA ID NUMBER: 11277060 NHTSA ID NUMBER: 11288718 NHTSA ID NUMBER: 11283008 NHTSA ID NUMBER: 11279604 THERE IS A RECALL WHICH WAS CONSIDERED CLOSED FOR MY VEHICLE FOR THIS ISSUE: 16V913000 DEALERSHIP HAS ALSO QUOTED ABOUT $1500 TO REPLACE THE ABS MODULE, BECAUSE THE CURRENT MODULE CANNOT BE UPDATED. SEEMS LIKE THERE ARE LOTS OF BAD MODULES THAT CANNOT BE UPDATED. THIS IS A HAZARD CONDITION; ESPECIALLY HERE IN MICHIGAN.

• 12/15/2014· AIR BAGS

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE STEERING WHEEL AND PASSENGER SIDE AIR BAGS INADVERTENTLY DEPLOYED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

• 12/14/2010· FUEL SYSTEM, DIESEL

  THE VEHICLE WAS EMITTING A DIESEL FUEL TYPE ODOR. THE DRIVER OF THE VEHICLE WAS HEADED BACK TO THE OFFICE IMMEDIATELY UPON DISCOVERING THE ODOR. ON THE HIGHWAY THE VEHICLE DIED. THE ONLY LIGHT THAT ILLUMINATED WAS THE GLOW PLUG LIGHT. THE VEHICLE WAS TOWED INTO THE SHOP. THE DEALERSHIP AT THAT POINT REPLACED A LEAKING COMPONENT WITHIN THE FUEL SYSTEM. MY COMPANY AUTHORIZED THE PART REPLACEMENT. THE PART WAS REPLACED BUT THE VEHICLE STILL DID NOT START. LONG STORY SHORT, WE NEED A CYLINDER HEAD WHICH IS APPROX $7500 SINCE THE LEAKING FUEL HAD CAUSED THE TIMING BELT TO SKIP TIMING. THE VEHICLE AT THIS TIME IS STILL AT THE DEALERSHIP AWAITING OUR DECISION. THE ONLY THREE OPTIONS ARE REPLACE THE CYLINDER HEAD, ENGINE OR DECOMMISSION A CAR WITH LESS THAN 48K MILES. BASED ON THE INFORMATION FOUND ON THE INTERNET THIS PARTICULAR VEHICLE HAS SEVERAL INCIDENTS FILED IN REGARDS TO LEAKING FUEL SYSTEM AND STALLING. *TR

• 12/13/2016· ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  MY WIFE WAS DRIVING HER 2009 VW JETTA AND THE ABS, TRACTION CONTROL AND BRAKE LIGHT COMES ON THE DASHBOARD THE OTHER DAY WITH A BEEPING SOUND ALSO. FIRST LET ME SAY THIS CAR JUST TURNED 65,000 MILES. I HAVE OWNED MANY VEHICLES IN MY LIFETIME AND THIS IS UNACCEPTABLE FOR A MAJOR SAFETY DEVICE TO FAIL AS THIS DID SO EARLY IN THE LIFE OF THIS CAR. I HAVE READ MANY OTHER COMPLAINTS THAT THE ABS CONTROL MODULE FAILS AND CONSUMERS HAVE LOST STEERING. THIS PART IS $1550.00 AND ANOTHER $375.00 TO INSTALL, TOTAL OF $1925.00. YOU CAN ONLY BUY THIS PART NEW AT THE VW DEALER ( JUST CALLED). I CAN'T BELIEVE THIS HAS NOT BEEN RECALLED BY NOW. PLEASE SOMEONE LOOK INTO THIS PROBLEM. I DON'T WANT MY WIFE DRIVING THIS CAR, IT IS NOT SAFE WITH NO ABS WORKING AND POSSIBLE LOSS OF STEERING. ALSO DON'T KNOW IF THIS IS CONNECTED TO THE ABS PROBLEM BUT THE REAR BRAKES ARE USED UP WAY TO SOON. BRAKE DUST ALL OVER THE REAR WHEELS. I'M A CAR GUY AND WORK ON CARS, THIS IS NOT RIGHT.. THANK YOU.. *TR

• 12/13/2010· SERVICE BRAKES, HYDRAULIC

  TOOK MY CAR IN FOR THE 20000 MILE SERVICE. LAST SERVICE WAS AT 10000 MILES. WAS TOLD I NEEDED REAR BRAKE PADS AND ROTORS 300+ DOLLARS. SOMETHING IS WRONG HERE. I HAVE COMPLAINED ABOUT MY BRAKES SQUEAKING THE LAST THREE TIMES I BROUGHT IT IN TO THE DEALER. I WAS NEVER TOLD THERE WAS ANYTHING WRONG. I SPOKE TO VOLKSWAGEN CUSTOMER SERVICE THE 800 NUMBER, TOLD THEM THE ISSUES, THEY SAID THE BRAKES ARE APPLIED ON ALL 4 WHEELS WHEN STEPPING ON THE PEDAL, THIS RIGHT HERE TELLS ME SOMETHING IS WRONG, IF BRAKES ARE APPLIED TO ALL WHEELS THEN THE PADS SHOULD WEAR EVENLY, I WAS TOLD I WOULD HAVE TO REPLACE THE REAR PADS AND ROTORS AGAIN BEFORE I HAVE TO DO THE FRONT ONCE. I ALSO HAVE COMPLAINED ABOUT THE RPM'S SHOOTING UP VERY HIGH WHEN I START THE CAR AND NEED TO HOLD THE BRAKE HARD WHEN I PUT IT IN GEAR OR I WILL LUNGE BECAUSE THE RPMS ARE SO HIGH, AFTER ABOUT A MUINUTE I CAN RELEASE THE BRAKE AND DRIVE BECAUSE THE RPMS HAVE SETTLED DOWN. AGAIN I WAS TOLD THIS IS HOW THE CAR WORKS.

• 12/12/2019· SERVICE BRAKES

  TOOK VEHICLE IN FOR ABS RECALL AND WAS TOLD VOLKSWAGEN DENIED THE RECALL BECAUSE THE ABS MODULE WAS BAD. IT IS BAD TO BEGIN WITH. VOLKSWAGEN HAS CAME UP WITH A SCAM TO PLEASE NHTSA BUT NOT SATISFY CUSTOMERS. QUOTED $1532.62 FOR A NEW ONE THAT SHOULD BE REPLACED BY VOLKSWAGEN BECAUSE IT'S ALREADY FAULTY.

• 12/11/2013· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE DIESEL FUEL INJECTOR NUMBER ONE HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 156,000.

• 12/11/2009· VISIBILITY

  AFTER DRIVING IN THE RAIN AND PARKING MY CAR IN LIGHT RAIN FOR ABOUT TWO AND A HALF HOURS THE FRONT WINDSHIELD WIPERS WOULD NOT WORK WHEN I STARTED THE CAR. I TINKERED AROUND WITH THE LEVERS AND THE REAR WIPER WORKED AND THE WASHER FLUID WORKED, BUT NOT THE FRONT WIPERS. I CHECKED THE FUSE INDICATED IN THE MANUAL AND IT WAS NOT BLOWN. I WAS FORCED TO DRIVE HOME IN THE RAIN WITHOUT THE USE OF MY FRONT WIPERS. *TR

• 12/11/2009· LATCHES/LOCKS/LINKAGES

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE EXITING THE VEHICLE, ALL FOUR DOORS LOCKED WITHOUT INTENTION. THE ENGINE REMAINED ON, AND A CHILD WAS POSITIONED IN THE REAR OF THE VEHICLE. SHE ATTEMPTED TO ACCESS THE VEHICLE WITH THE KEY FOB AND MANUALLY. THE KEY FAILED TO UNLOCK THE DOOR. SHE HAD TO BREAK THE PASSENGER WINDOW TO OPEN THE DOOR. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 12,000. THE VIN WAS UNAVAILABLE.

• 12/10/2015· FUEL/PROPULSION SYSTEM

  "HIGH PRESSURE FUEL PUMP" ADDENDUM TO COMPLAINT #10808605 PLEASE ADD TO THE PREVIOUS THAT MY HUSBAND WAS DRIVING THE VEHICLE AT THE TIME & I FAILED TO MENTION THAT WHEN THE (HPFP) FAILED HE WAS IN THE FAST LANE OF THE FREEWAY & HIS POWER WAS IMMEDIATELY STOPPED. THIS HAPPENED ON THE I10 FREEWAY EASTBOUND JUST BEFORE THE "COUNTY LINE RD" OFFRAMP IN YUCAIPA, CA. THERE WAS NO SHOULDER IN THE FAST LANE FOR HIM TO PULL OVER. HE WAS VERY FORTUNATE THAT THERE WAS NO TRAFFIC TO HIS RIGHT AS HE HAD TO MAKE IT ACROSS 2 LANES OF TRAFFIC IN AN UPHILL GRADE. THE CAR BARELY MADE IT TO THE OFFRAMP! IF THERE HAD BEEN TRAFFIC (TYPICALLY SLOW MOVING TRUCK TRAFFIC), HE WOULD HAVE BEEN TRAPPED IN THE MIDDLE OF THE FREEWAY & SURELY HIT!! IN MY PREVIOUS COMPLAINT I WAS ANGRY ABOUT VW NOT TAKING RESPONSIBILITY FOR THE KNOWN FAILURE. WE ARE RESPONSIBLE CAR OWNERS & REGULARLY SERVICE OUR VEHICLES. I COULD UNDERSTAND HAD THIS BEEN NEGLIGENCE ON OUR PART. MY HUSBAND COMMUTES 200 MILES A DAY & WE RELY HEAVILY ON HAVING A RELIABLE VEHICLE, WHICH WE THOUGHT WE HAD IN A VW DIESEL. THEY RECOGNIZED THE DEFECT BY OFFERING A 10YR, 120,000 MILE WARRANTY EXTENSION. MIND YOU THIS IS A DIESEL ENGINE WHICH HAS A LIFE EXPECTANCY OF AT LEAST DOUBLE THIS. AT SOME POINT THIS FAILURE WAS BOUND TO HAPPEN & VW KNOWS IT. I SPOKE WITH MANY VW TECHNICIANS IN THE DIAGNOSIS OF THIS ISSUE & THEY ALL ACKNOWLEDGE THIS IS A FAULTY PART. SOME OF THE BLOGS TRY TO ALLUDE THAT POOR FUEL IS THE CAUSE, BUT THE MECHANICS DON'T AGREE.ANY ASSISTANCE YOU CAN PROVIDE IN GETTING VW TO TAKE RESPONSIBILITY WOULD BE GREATLY APPRECIATED. THIS NOT ONLY ENDANGERED THE LIFE OF MY HUSBAND, BUT THIS IS A $5500 REPAIR!!

• 12/10/2014· ENGINE

  TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED AND THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

• 12/10/2014· AIR BAGS

  TOOK TO DEALER FOR OIL CHANGE AND HORN NOT WORKING . IN DIAGNOSIS, FOUND THAT CLOCKSPRING NEEDS TO BE REPLACED WHICH WOULD ALSO PROBABLY RESOLVE THE AIR BAG LIGHT WHICH IS ON. THE PRICE FOR REPAIR $485.00. WHEN CALLING OTHER AUTO REPAIR SHOPS IN THE AREA ; COULD NOT FIND ANOTHER SHOP TO REPLACE THE CLOCKSPRING ,AS IT IS A LIABILITY BECAUSE OF THE AIRBAG INVOLVEMENT. THE DEALER COULD NOT TELL ME WHETHER THE AIR BAGS WORKED BUT SAID REPLACING THE CLOCKSPRING SHOULD TAKE CARE OF THE ISSUE. VOLKSWAGEN CUSTOMER CARE WAS CONTACTED AND SAID THE CAR IS OUT OF WARRANTY AND THEY CAN DO NOTHING ABOUT THIS, EVEN THOUGH MY VOICED CONCERN ABOUT THE AIRBAG ISSUE WAS HEARD. *TR

• 12/10/2009· ENGINE AND ENGINE COOLING

  WE WERE TRAVELING IN BRANSON, MO. FROM OUR HOME IN EAST TEXAS WHEN THERE WAS WHAT SOUNDED LIKE A SINGLE MUFFLED POP FROM THE ENGINE COMPARTMENT. THE GLOW PLUG LAMP STARTED BLINKING AND THE CHECK ENGINE LIGHT CAME ON AND I THINK IT WAS BLINKING ALSO. AT THE TIME I WAS TRAVELING ABOUT 30 MPH. AND I HAD JUST STARTED UP A STEEP GRADE. ALSO, ABOUT THE TIME THE GLOW PLUG LIGHT STARTED BLINKING, THE MFD DISPLAYED THE "MAJOR ENGINE MALFUNCTION" MESSAGE. THE ENGINE LOST POWER BUT DID NOT STOP AND I WAS ABLE TO GO ABOUT 300 YARDS TO A SAFE PLACE WHERE I COULD PULL OFF THE STREET OUT OF TRAFFIC AND PARK. THE VEHICLE WAS TOWED TO THE VOLKSWAGEN DEALER IN SPRINGFIELD, MO. (SPRINGFIELD VOLKSWAGEN) FAULT CODE THROWN WAS P0299. IT WAS DETERMINED THAT A COUPLING ON A LINE GOING INTO THE TURBOCHARGER HAD NOT BEEN ADEQUATELY TIGHTENED DURING ASSEMBLY OF THE ENGINE AND THE HOSE HAD COME LOOSE DISABLING THE TURBOCHARGER AND THE ENGINE. *TR

• 12/09/2011· FUEL SYSTEM, GASOLINE

  I WAS DRIVING THE VEHICLE WHEN THE GLOW PLUG LIGHT ON THE DASH BEGAN FLASHING, THEN THE COMPUTER DISPLAYED ENGINE FAULT, CONTACT WORKSHOP, THEN THE CHECK ENGINE LIGHT CAME ON AND THE CALL STALLED IN THE MIDDLE OF AN INTERSECTION AND HAD TO BE PUSHED TO THE SIDE OF THE ROAD. THE CAR WOULD NOT START AGAIN. *TR