2009 Toyota Highlander

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2023· SERVICE BRAKES

  2009 Toyota Highlander Hybrid; mileage 97,849. While driving a red BRAKE alert showed up along with an ABS light, traction symbol and an encircled exclamation mark. This malfunction (which I now see is a known safety issue) shut down my regular braking system and I had to use the emergency brake to stop. A message appeared telling me to pull over to a safe spot and contact my dealer. A shrill high pitched sound also went off. How can a faulty designed ABS module that blocks the braking system from working when it fails not be under a safety recall - just an expired Safety Bulletin? I was fortunate to think to use my emergency brake to stop to avoid an accident and injury to myself and/or others. Vehicle was towed to Gates Toyota, South Bend, IN. if you wish to contact them regarding codes & costly repair bill expenses. I have a call in to the Toyota Headquarters Resolution Team and am waiting for them to contact me back on my case.

• 12/29/2018· SERVICE BRAKES

  2009 VEHICLE (MANUFACTURED 9/2008) ONLY HAS 83K MILES ON IT. CROAKING SOUND FOR WEEK OR SO AND THEN ONE MORNING ABS FAILURE WARNING ON DISPLAY. CODES ARE C1241 AND C1391. SAME PROBLEM AS OTHERS. NEEDS NEW ABS PUMP AND ACTUATOR. THE PARTS ARE #44050-48320 AND #44070-48020AND COST OVER $3K FOR PARTS ALONE. VERY DISAPPOINTED IN TOYOTA, I THOUGHT TOYOTA QUALITY WAS BETTER THAN THIS.

• 12/23/2015· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  REAR DOOR MOTOR LIFT NOT WORKING

• 12/22/2015· ENGINE

  NOTICED LARGE OIL PUDDLE IN DRIVEWAY. HAD CAR TOWED AS OIL LOSS COULD HAVE CAUSED FATAL DAMAGE TO THE ENGINE. THE OIL LINE WAS DIAGNOSED AS DRY ROTTED AND NEEDED TO BE REPLACED. THE REPLACEMENT OIL LINE WAS VASTLY DIFFERENT THAN THAT OF THE ORIGINAL LINE INDICATING A PROBLEM WITH THE PREVIOUS DESIGN. THE LEAK BEGAN WHILE DRIVING AND WE WERE ABLE TO TRACE THE OIL FOR MILES LEADING HOME. THE OIL INDICATOR LIGHT DID NOT COME ON TO WARN OF LOW OIL. TOYOTA DID RECALL OTHER VEHICLES FOR THE SAME PROBLEM HOWEVER NOT THIS PARTICULAR MAKE AND MODEL. AFTER TALKING TO TOYOTA'S RECALL DEPARTMENT I WAS TOLD IF I HAD HAD THE REPAIRS TAKEN CARE OF AT A TOYOTA DEALERSHIP I MAY HAVE BEEN ABLE TO BE REIMBURSED SLIGHTLY (A PERCENTAGE OF THE BILL) HOWEVER SINCE I USED THE SHOP OF MY CHOICE THERE IS NO OPTION FOR ANY REIMBURSEMENT.

• 12/18/2012· POWER TRAIN

  THE VEHICLE SUDDENLY LOST POWER ON THE HIGHWAY. THE CAR WAS STILL RUNNING, BUT THERE WAS NO POWER TO THE WHEELS. THE FRONT DIFFERENTIAL HAD FAILED DUE TO A LEAK IN THE FRONT OF THE TRANSFER CASE. THIS FAILURE CAUSED THE TRANSMISSION TO FAIL AS WELL. *TR

• 11/29/2009· POWER TRAIN

  I PURCHASED A 2009 TOYOTA HIGHLANDER, IN FEBRUARY 2009. ON JUNE 1, 2009, I WAS NORTHEAST OF ROCKVILLE, INDIANA ON HIGHWAY 47 IN THIS TOYOTA HIGHLANDER. I APPROACHED A SLOW MOVING VEHICLE ON A STRAIGHT SECTION OF ROADWAY AND PASSED THE VEHICLE. AS I WAS PASSING I FELT LIKE THE CAR WAS GOING FASTER THAN I WAS ACCELERATING. WHEN I PULLED BACK INTO THE RIGHT LANE THE CAR WAS GOING EVEN FASTER AND I REALIZED THAT THE CAR WAS ACCELERATING ON ITS OWN. LUCKILY, I WAS STILL ON A LONG STRAIGHT SECTION OF THE ROAD AND HAD SOME TIME. I FIRST TRIED TO BRAKE BUT THE CAR KEPT GOING EVEN FASTER. I PUT THE CAR IN NEUTRAL AND STARTED BRAKING AND LUCKILY FOUND A PLACE TO PULL OFF THE ROAD. I WAS COMPLETELY SHOCKED THAT THE ENGINE WAS RACING UNCONTROLLABLY. I LOOKED DOWN AT THE ACCELERATOR AND NOTHING WAS PUSHING OR TOUCHING IT. I THEN TURNED OFF THE CAR, PUT THE CAR IN 'PARK', GOT OUT OF THE CAR AND LOOKED AROUND THE ACCELERATOR AGAIN TO MAKE SURE THAT NOTHING WAS PUSHING ON IT, THEN WAITED FOR ABOUT A MINUTE AND RESTARTED THE CAR. THE CAR STARTED WITH THE ENGINE RACING. I TURNED OFF THE CAR AND RESTARTED THE CAR TWO MORE TIMES AND EACH TIME THE ENGINE RACED UNCONTROLLABLY. I TURNED OFF THE CAR, LEFT A MESSAGE FOR MY HUSBAND ON HIS CELL PHONE AND WAITED FOR FIVE MINUTES WITH THE CAR TURNED OFF AS I WAITED FOR MY HUSBAND TO CALL BACK. HE NEVER DID CALL SO I DECIDED TO START THE CAR ONE MORE TIME. WHEN I DID, THE CAR STARTED NORMALLY AND THE ENGINE DID NOT RACE. I TRIED TO CALM DOWN EMOTIONALLY AND DROVE HOME NOT KNOWING WHEN OR IF THE ACCELERATOR WOULD BE A PROBLEM. I TOOK THE HIGHLANDER IN FOR SERVICE TO JORDAN AUTOMOTIVE GROUP, MISHAWAKA, INDIANA ON 6/3/2009 AND THEY INSISTED THAT THE FLOOR MATS WERE THE PROBLEM. I DO NOT BELIEVE THIS BECAUSE I HAD CHECKED EVERYTHING AROUND THE ACCELERATOR WHEN THE ENGINE WAS RACING AND THERE WAS ABSOLUTELY NOTHING TOUCHING THE ACCELERATOR. THE PROBLEM IS ELECTRONIC. I DO NOT FEEL SAFE IN THIS VEHICLE. *TR

• 11/28/2012· STRUCTURE

  THE POWER ARM BROKE OFF OF THE REAR POWER LIFT GATE WHEN CLOSING. THE DRIVER SIDE HINGE ON THE REAR POWER LIFTGATE IS BOWED. *TR

• 11/27/2017· VISIBILITY/WIPER

  TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER'S WINDOW INTERMITTENTLY CEASED TO FUNCTION. THE FAILURE OCCURRED WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 103,659. THE VIN WAS NOT PROVIDED.

• 11/24/2020· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  3 TIMES OVER THE LAST MONTH, WHILE I WAS DRIVING MY VEHICLE, THE CAR SUDDENLY LOST POWER WHILE I WAS DRIVING ON THE HIGHWAY. ALL THE DASHBOARD LIGHTS FLASHED ON, CHECK ENGINE LIGHT AND WARNING LIGHTS ILLUMINATED. THE VEHICLE LOST POWER, THE ACCELERATOR WAS NOT WORKING, AND I WAS JUST BARELY ABLE TO PULL THE CAR OVER TO THE SIDE OF THE ROAD. CAR TURNED OFF AND WAS ABLE TO TURN BACK ON, NOW WITH ILLUMINATED CHECK ENGINE LIGHT AND CHECK HYBRID SYSTEM WARNING LIGHT ILLUMINATED. THIS IS A BIG SAFETY ISSUE AS THE CAR IS LOSING POWER IN THE MIDDLE OF THE ROAD WHILE MY FOOT IS ON THE ACCELERATOR. THE FIRST TIME THIS HAPPENED I WAS ABLE TO PULL A COUPLE CODES FROM THE CODE READER. CODES WERE: U0001 & U0100 THE SECOND AND 3RD TIME THIS HAPPENED THERE WERE NO CODES COMING UP ON THE CODE READER.

• 11/16/2011· TIRES,WHEELS

  OUR CAR HAS 17,000. MILES AND TURNS OUT THE TIRES ARE BARE IN SPOTS AND THE CAR HYDROPLANED AND SKIDDED AND WOULD NOT HOLD THE ROAD IN A LIGHT SNOWSTORM. WE OFTEN SKIDDED RIGHT INTO ONCOMING TRAFFIC. WE HAVE DRIVEN MANY SUVS OVER THE YEARS -WE ARE 69- AND NEVER HAD A PROBLEM. TOYOTA EMAILED TO US THAT THE TOYO A20 P245/55R19 OPEN COUNTRY TIRES THE CAR CAME WITH ARE NOT MEANT FOR DRIVING IN SNOW. WE LIVE IN VT AND THE CAR WAS SOLD TO US AS AN ALL WHEEL DRIVE CAR FOR DRIVING IN SNOW. I HAVE LOOKED AT THE INTERNET AND OTHERS HAVE HAD THE SAME PROBLEM WITH THESE TIRES. I FEEL THERE SHOULD BE A RECALL ON THEM BEFORE SOMEONE IS KILLED. MY SON JUST PURCHASE A NEW HIGHLANDER AND I WORRY HIS TIRES ARE THE SAME. *TR

• 11/16/2009· VEHICLE SPEED CONTROL

  ACCELERATOR STUCK ALL THE WAY TO FLOOR ON 2009 TOYOTA HIGHLANDER WHILE VACATIONING IN TENNESSEE ON I40. HAD TO WEAVE THRU TRAFFIC TO SHOULDER WHILE TRAVELING TOWARDS 100 MPH, MASHING FULL FORCE TO THE FLOOR ALL THE TIME DURING INCIDENT. VERY FRIGHTENING. CAR IS PRESENTLY RETURNED TO DEALERSHIP, BUT NO ACTION HAS BEEN TAKEN & THEY CAN'T FIND "ANYTHING WRONG." I AM AFRAID TO DRIVE THE VEHICLE NOW. THIS WAS A LIFE THREATENING EVENT, BUT I DON'T FEEL TOYOTA IS TREATING AS SUCH. I AM TRYING TO FIND SOME HELP AS TO WHAT TO DO. IT HAS ONLY HAPPENED ONCE, BUT THERE COULD HAVE BEEN SERIOUS CONSEQUENCES TO BOTH MY HUSBAND AND I AND FOR OTHER VEHICLES ON THE ROAD. *TR THE CONSUMER HAS SINCE TRADED THE VEHICLE. UPDATED 04/05/10*JB

• 11/13/2014· AIR BAGS

  I HAVE NOT HAD AN ACCIDENT WITH THIS VEHICLE, HOWEVER I WAS TOLD BY TOYOTA TO CHECK THIS WEBSITE TO SEE IF MY PARTICULAR YEAR AND MODEL IS ONE OF THE ONES AFFECTED BY THE AIRBAG MALFUNCTION. IF SO, I WANT TO GET IT IN TO BE REPAIRED AS SOON AS POSSIBLE IN CASE THERE IS AN ACCIDENT AND SOMEONE IN MY VEHICLE IS KILLED OR INJURED. I AM A SPORTS MOM SO AT TIMES I HAVE 6 CHILDREN IN MY VEHICLE AND 2 ARE MY GRANDCHILDREN. *TR

• 11/06/2016· ENGINE

  2009 HIGHLANDER, PURCHASED NEW, HAD 105000 MILES ON 3.5L V6 ENGINE. OIL CHANGED EVERY 7000 MILES, FULLY SYNTHETIC. NO WARNING LIGHTS OR ENGINE NOISES PRIOR TO INCIDENT. CAR STARTED AFTER WORK, DROVE .6 MILE. STARTED RUNNING VERY ROUGH, PULLED OVER TO SHOULDER THINKING I HAD A FLAT TIRE. CAR DIED BEFORE FINISHING MANEUVER, COASTED TO SHOULDER. ENGINE WOULD NOT START. TOWED TO REPAIR SHOP, THEY DIAGNOSED "ENGINE FULLY SEIZED UP". CONTACTED TOYOTA, THEY OFFERED NO SATISFACTION AS " CAR NOT BEING REPAIRED BY DEALER, NOT UNDER WARRANTY". I FIND THIS ANSWER TO BE WRONG, DUE TO LOW MILEAGE, HISTORY OF MAINTENANCE, NO REASON FOR CATASTROPHIC FAILURE OF ENGINE. MECHANIC STATED THEORY OF "OIL PORTS CLOGGING UP", SINCE HEARD THEORY OF "OIL PUMP FAILURE".

• 11/04/2022· ENGINE

  When starting it would make grinding noise,sounds like metallic noise until the engine oil starts circulating.Dealer said that its normal due to cold starts but this can happen even when the engine is up to temperature.Toyota refuse to remedy the issue.

• 11/04/2017· VISIBILITY/WIPER

  THE SUN VISOR REPEATEDLY FLOPS DOWN OBSCURING THE DRIVER'S VIEW. THE VISOR WILL NOT STAY IN THE "UP" POSITION. ALSO WHEN ENTERING THE VEHICLE, IF THE VISOR IS IN THE VERTICAL POSITION, I.E. NOT UP WHERE IT SHOULD BE, THE DRIVER WILL HIT HIS/HER HEAD ON THE EDGE OF THE VISOR. THIS ISSUE IS NOT NEW TO THIS VEHICLE, THERE HAS BEEN A RECALL FOR EARLIER YEAR MODELS AS WELL AS OTHER TOYOTA MODELS AS WELL.

• 11/04/2010· CHILD SEAT

  SUNSHINE KIDS RADIAN XTSL LATCH LOOSENS ITSELF. TWO TIMES I'VE GONE TO PUT MY 2 YEAR OLD INTO HER SEAT AND THE LATCH HAS HAD AT LEAST 2 INCHES OF SLACK!! PLEASE FIX THIS!! (RELATED VEHICLE INFORMATION: MODEL YEAR=2009, MAKE=TOYOTA, MODEL=HIGHLANDER). *TR

• 10/26/2015· ELECTRICAL SYSTEM,STRUCTURE

  LIFTGATE WILL NOT CLOSE OR OPEN WHEN AUTOMATIC BUTTON IS PUSHED EITHER ON THE DASH OR THE BUTTON ON THE LIFTGATE ITSELF. STAYS OPEN AND HAVE TO FORCE THE LIFTGATE DOWN MANUALLY. AT TIMES LIFTGATE WILL OPEN BY ITSELF WHILE STATIONARY OR VEHICLE IS MOVING. CLOSING OR OPENING THE LIFTGATE AUTOMATICALLY PROBLEM HAS BE ONGOING FOR ABOUT 6 MONTHS. BROUGHT TO DEALERSHIP AND THEY COULD NOT REPAIR, BUT I COULD TAKE TO BODY SHOP FOR REPAIR. CURRENTLY A SERVICE BULLETIN HAS BEEN ISSUED, BUT SHOULD BE A SAFETY RECALL.

• 10/25/2014· LATCHES/LOCKS/LINKAGES

  DOOR LOCK ON FRONT DRIVER DOOR DOES NOT LOCK WHEN REMOTE OR DOOR BUTTON INSIDE CAR PRESSED. GIVES IMPRESSION DOOR IS LOCKING WHEN IT IS NOT. *TR

• 10/25/2012· ENGINE AND ENGINE COOLING

  I WAS TRAVELING 50 -60 MILES PER HOUR ON THE NEW JERSEY GARDEN STATE PARKWAY. WHILE DRIVING ALL OF A SUDDEN A HUGE VIBRATION OCCURRED THROUGH OUT THE VEHICLE. WHILE IT VIBRATED A LOUD NOISE OCCURRED. IT WAS SO LOUD MY DOG BEGAN TO BARK AND MY EARS COULD NOT TAKE THE NOISE OF THE VEHICLE. I TRIED TO BRAKE AND THE NOISE CONTINUED AS WELL AS THE VIBRATION. I CONTINUED TO TRY AND GET IN THE RIGHT LANE HOWEVER THE NOISE AND VIBRATION CONTINUED. THE VIBRATION FELT LIKE WHEN YOU GO ACROSS SPEED BUMPS THAT GIVES A RUMBLE SOUND. THE ROAD WAS SMOOTH AND THERE WERE NO SPEED BUMPS HOWEVER IT FELT AS IF I WAS GOING OVER SPEED BUMPS. ON 10/25/12 I TOOK THE VEHICLE TO TOYOTA OF HACKENSACK NJ WHERE THE VEHICLE WAS PURCHASED ON. I INFORMED THE SERVICE GUY ABOUT THE SITUATION. THEY DID A MULTI-POINT INSPECTION AND NOTHING CAME UP. THEY TEST DROVE THE VEHICLE IN CITY LIMITS AND NOTHING CAME UP. I THEN INFORMED THEM THAT THE VIBRATION DOES NOT OCCUR UNTIL YOU ARE ON THE HIGHWAY. THE TECHNICIAN THEN TEST DROVE WITH ME IN THE VEHICLE. THE VIBRATION DID NOT OCCUR. THIS SPECIFIC VIBRATION AND NOISE HAS ONLY OCCURRED TWICE SINCE I PURCHASED THE VEHICLE. I PURCHASED THE VEHICLE OVER A MONTH AGO DUE TO A FAULTY 2005 KIA SORENTO CRANKSHAFT BOLT DESIGN. IF IT HAPPENS AGAIN I WILL FILE ANOTHER COMPLAINT. *TR

• 10/23/2011· AIR BAGSCrash

  WITHOUT PREJUDICE MY VEHICLE WAS REAR -ENDED BY ANOTHER VEHICLE AT SPEED OF APPROXIMATELY 75, AND GOT CRASHED ON TO THE CAR IN FRONT AT SPEED OF 40 TO 50. AIR BAGS FAILED TO DEPLOY AND DASH BOARD INDICATOR LIGHT CAME ON AND IT DOES NOT GO OFF. I STRONGLY BELIEVE THIS IS A MANUFACTURER DEFECT. THIS SUV CONSISTS WITH SIX AIR BAGS. NON OF THEM RESPONDED. I PURCHASE WITH CONFIDENCE THAT AIR BAGS ARE IN WORKING ORDER. MANUFACTURER RISK OUR LIFE FOR NEARLY TWO YEARS. I DESERVE COMPENSATION FOR RISKING 6 LIVES. *TR

• 10/22/2021· SERVICE BRAKES

  Brake Actuator and Pump Assembly. If I drive the car Toyota has told me it could be catastrophic when the brakes stop while I’m driving. Yes, Toyota inspected and gave the quote to me. This vehicle had 446,000 others fixed (2008-2010) under a “warranty” instead of a “recall”! The car has not stopped yet working, it’s parked because I don’t want to die or kill anyone. I can still drive it maybe 20 mph without using any brakes. The closest store to buy food is 16 miles one way! Yes I have on the middle console screen: “BRAKE (in red) Brake Malfunction” which then says underneath that “Stop the vehicle in a safe place immediately, and contact a dealer.” “ABS Check ABS” and “Check Brake System” both of which say “Have your vehicle checked by a Dealer“. And on the dashboard it shows Lights (warning light in yellow with a !,) BRAKE in red, ABS (!), there’s actually a circle around the ! between the two ( ). Than the anti-brake symbol is on which is yellow with a car symbol and skidmarks behind it. I have attached the photo of the inspection bill and the text from the Toyota rep of how much it’s going to cost to repair. I did speak with the service manager, Steve, who told me that the NTSB is who decides if there should be a recall on this type of thing or not. I feel like if there were 446,000 cars fixed this is a huge issue! Mine should be included! I cannot drive the car so therefore I am stranded!

• 10/22/2018· ELECTRICAL SYSTEM

  2009 TOYOTA HIGHLANDER LIMITED DOOR ACTUATORS HAVE ALL BROKE, BEEN REPLACED AND BROKE AGAIN. SOME ARE BEING REPLACED FOR THE 3RD TIME SINCE I OWED THE VEHICLE (MAKING IT THE 4TH LOCK ON THE CAR). AT THE MOMENT ONLY 1 DOOR LOCK WORKS AND I HAVE TO CLIMB ACROSS TO OPEN THE OTHER DOORS. I AM EXTREMELY CONCERNED THAT THEY WILL ALL BREAK AND I WILL NOT BE ABLE TO GET MY DAUGHTER OUT OF THE CAR. I STARTED CONTACTING TOYOTA IN 2013 WHEN THEY ALL STARTED BREAKING. I ALSO CAN NOT OPEN THE CAR WITH THE KEY. 8/2012- DRIVERS LOCK AND ACTUATOR REPLACED AND WINDOW 6/2013- RIGHT REAR DOOR ACTUATOR REPLACED 7/2013- PASSENGER DOOR ACTUATOR REPLACED 3/2014- LEFT REAR DOOR ACTUATOR REPLACED 4/2014- DRIVERS LOCK ACTUATOR REPLACED (AGAIN) 5/2014- RIGHT REAR DOOR ACTUATOR REPLACED (AGAIN) 2015- LEFT REAR ACTUATOR BROKE AGAIN THIS TIME MY EXTENDED WARRANTY IS UP AND THEY WANT 600 TO FIX. 2016- PASSENGER ACTUATOR BROKE 9/2018- DRIVERS ACTUATOR BROKE FOR THE 3RD TIME. I AM LEFT WITH LEAVING THE CAR UNLOCKED AND HOPING NO ONE GOES IN OR CLIMB ACROSS MY VEHICLE. I HAVE CONTACTED TOYOTA NUMEROUS TIMES TO TRY AND GET THEM TO HELP AND THEY HAVENT DONE ANYTHING BUT TELL ME I'M NOW OUT WARRANTY EVEN THOUGH I CONTACTED THEM REGARDING THE ISSUES BEFORE MY EXTENDED WARRANTY WAS UP.

• 10/20/2024· AIR BAGS,FORWARD COLLISION AVOIDANCE

  My airbag light came on and I don't understand why the airbag light came on. I took it to a auto shop and they said I would have to take it to a Toyato dealer. Also, my emergency brake is all the way to the floor and it has never released. It will not release at all. It has been that way ever since I bought the vehicle.

• 10/18/2014· ENGINE AND ENGINE COOLING

  THE RUBBER HOSE BETWEEN THE OIL PUMP AND THE VVT KEEPS BREAKING. I WAS DOING SOME RESEARCH AND FOUND THAT THE RUBBER HOSE HAS BEEN REPLACE WITH A METAL ONE. CAN YOU PLEASE HELP ME? IS THIS SOMETHING THAT IS POSSIBLY STILL UNDER WARRANT AND CAN BE FIXED? THANK YOU FOR HELP IN ADVANCE. *TR

• 10/18/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE VEHICLE WAS REPAIRED BY AN AUTHORIZED DEALER FOR THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V023000, VEHICLE SPEED CONTROL: ACCELERATOR PEDAL. UPON RECEIVING THE VEHICLE HE WAS DRIVING APPROXIMATELY 22 MPH AND WHEN HE REMOVED HIS FOOT FROM THE ACCELERATOR PEDAL, THE VEHICLE DID NOT STOP ACCELERATING. THE VEHICLE WAS NOT TAKEN TO BE EXAMINED FOR THE CAUSE OF FAILURE AND WAS NOT REPAIRED. THE FAILURE CONTINUED TO OCCUR WHENEVER HE RELEASED THE ACCELERATOR PEDAL. THE FAILURE AND CURRENT MILEAGES WERE 14,100.

• 09/28/2015· UNKNOWN OR OTHER,ENGINEFire

  AUGUST 6, 2015 I WAS DRIVING NORTHBOUND ON HWY 45. AFTER ABOUT 20 MINUTES ON THE ROAD MY 2009 TOYOTA HIGHLANDER BEGAN TO SMOKE, THE OIL PRESSURE WARNING LIGHT CAME ON AND I PULLED OVER TO THE SIDE OF THE ROAD. WITHIN A FEW MINUTES, BLACK SMOKE WAS POURING OUT FROM UNDERNEATH THE HOOD. WITHIN ANOTHER MINUTE OR TWO THE SUV WAS ON FIRE AND SOON THE FRONT HALF WAS COMPLETELY ENGULFED IN FLAMES. I THOUGHT IT WOULD EXPLODE. TWO MILWAUKEE FIRE DEPARTMENT TEAMS ARRIVED AND EXTINGUISHED THE FIRE. THANK GOD NO ONE WAS HURT AND MY CHILDREN WERE NOT IN THE CAR. ACCIDENT REPORT BMZ14XN WAS FILED WITH MILWAUKEE COUNTY. PRIOR TO THE FIRE THAT TOTALED THE HIGHLANDER, AN EMERGENCY REPAIR WAS MADE TO THE HIGHLANDER ON NOVEMBER 3, 2014. THAT NIGHT THE ENGINE BEGAN TO MAKE A STRANGE NOISE AND THE OIL WARNING LIGHT WENT ON. I PULLED INTO THE NEAREST AUTO REPAIR SHOP; THE TECH SAID IF I DROVE ANY FURTHER THE ENGINE WOULD HAVE BEEN SEVERELY DAMAGED BECAUSE THERE WAS NO OIL LEFT. THE ENGINE COOLANT PIPE SPRUNG A LEAK AND ALL OF THE OIL POURED OUT OF MY CAR. THAT WAS THE FIRST TIME MY HIGHLANDER LOST ALL OF ITS OIL BECAUSE OF A FAULTY OIL COOLANT PIPE- THE SECOND TIME IT RESULTED IN AN ENGINE FIRE. IN DECEMBER 2014 I RECEIVED A LETTER FROM TOYOTA STATING THEY REIMBURSE FOR REPAIRS RELATED TO LEAKING OIL OR ENGINE DAMAGE. TOYOTA DEALERS RECEIVED TECHNICAL SERVICE BULLETIN (TSB) #TSB-020-11 INDICATING THE REPLACEMENT PART SHOULD BE METAL; NOT RUBBER WHICH IS WHAT I HAD. I MENTIONED THE EMERGENCY REPAIR TWICE WHEN I WENT IN FOR SERVICE TO JACK SAFRO TOYOTA. NEITHER TIME DID A SERVICE TECH SUGGEST THAT THE OIL COOLANT PIPE BE CHECKED TO MAKE SURE IT WAS CORRECTLY REPAIRED. I BELIEVE THIS WAS A MAJOR OVERSIGHT ON THE PART OF THE SERVICE DEPARTMENT AND THAT TOYOTA SHOULD RECALL THE OIL COOLANT PIPE. THE FAULTY PART IS ON 2007-2010 HIGHLANDERS AND OTHER TOYOTA VEHICLES.

• 09/27/2019· ENGINE

  VVTI CAM GEAR ISSUE, MAKING GRINDING NOISE.VEHICLE JUST HIT 60,000 AND OUT OF WARRANTY. EARLIER TSB FROM TOYOTA DIDN'T COVER THIS SINCE THE VEHICLE DIDN'T SHOW ANY SIGNS.

• 09/10/2015· ELECTRICAL SYSTEM,AIR BAGS

  $7155 QUOTE TO REPLACE 2 ELECTRICAL HARNESSES. REASON: "WARNING: SRS AIRBAG CHECK. TAKE VEHICLE TO DEALER". THE JUNCTION BOX IS HIDDEN BEHIND THE DRIVER SIDE FRONT PANEL. THE PINS IN THE JUNCTION BOX BELONGING TO THE AIRBAG WIRING HARNESS (PART # 82141-48R51) THAT RUNS UNDERNEATH THE DASHBOARD WERE FRIED DUE TO ELECTRICAL SHORT (UNEXPLAINED). BECAUSE THE JUNCTION BOX ALSO BRINGS THE REAR WIRING HARNESS (PART # 82162-48D40 ) TO TAIL, HEADLINER, AND BACK OF THE VEHICLE, THIS MUST BE REPLACED AS WELL. I FEAR THAT THERE IS A MAJOR FLAW IN THE ELECTRICAL SYSTEM / SRS AIRBAGS OF THIS VEHICLE AND THE VEHICLE ELECTRICAL SYSTEM HAS EXPERIENCED PREMATURE FAILURE.

• 09/07/2019· ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  THIS IS FOR A 2009 TOYOTA HIGHLANDER HYBRID LIMITED WITH ABOUT 142000 MILES. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS AND IS NOT ABUSED IN ANY WAY. ALL MAINTENANCE ARE UP TO DATE WITH THE MAJOR TIMING KIT REPLACED MOST RECENTLY AT ABOUT 140000. WHILE DRIVING THE VEHICLE ON NORMAL ROADS (SOMETIMES HIGHWAY, SOMETIME CITY ROADS), I GET THREE WARNINGS THAT POP UP AT THE CENTER SCREEN BETWEEN THE AIR VENTS; 1) CHECK ABS, 2) CHECK BRAKE SYSTEM, AND 3) BRAKE MALFUNCTION. FOR THE FIRST TWO WARNINGS, IT IS FOLLOWED BY "HAVE YOUR VEHICLE CHECKED BY DEALER." BUT, FOR THE THIRD WARNING, IT IS ACCOMPANIED BY "STOP THE VEHICLE IN A SAFE PLACE IMMEDIATELY AND CONTACT DEALER." THESE WARNINGS ALSO CORRESPOND TO THREE LIGHTS THAT POP UP BY THE SPEEDOMETER; 1) VSC, 2) ABS, AND 3) BRAKE. THE LIGHTS STAY ON FOR TWO TO THREE DAYS AT A TIME AND THEN WILL GO AWAY WITHOUT ANY REASONABLE EXPLAINATION. THIS HAPPENS ABOUT EVERY OTHER WEEK. I WAS UNABLE TO BRING IT TO A DEALERSHIP WHEN THE LIGHT IS ON AS I LIVE VERY FAR AWAY FROM THE DEALERSHIP. WHEN I CALL AND DESCRIBE THE WARNINGS, I AM TOLD THAT THIS MAY BE A PROBLEM WITH THE ACTUATOR AND IT IS COMMON. THE DEALER ESTIMATED THE COST TO BE AROUND $3500. I DID A QUICK SEARCH ONLINE AND FIND THAT THIS IS A COMMON PROBLEM AMONG SAME GENERATION HIGHLANDERS. I SHOULD NOT HAVE TO PAY FOR THIS AND THE MANUFACTURER NEEDS TO GET THE VEHICLE RIGHT. I FEEL UNSAFE DRIVING THIS VEHICLE WITH THE UNCERTAINTY OF BEING ABLE TO STOP SAFELY WHEN NECESSARY. I UNDERSTAND THAT TOYOTA HAD A RECALL ON THE BRAKE SYSTEM FOR THE PRIUS AND CAMRY, BUT DID NOT INCLUDE THE HIGHLANDER. THEY SHOULD HAVE SINCE THIS IS A SAFETY PROBLEM THAT IS COMMON WITH THE FIRST AND SECOND GENERATION HIGHLANDERS. PLEASE GET TOYOTA TO TAKE RESPONSIBILITY BEFORE AN ACCIDENTS OCCURS. BRAKES ARE AN IMPORTANT SAFETY FEATURE THAT SHOULD NOT BE COMPROMISED.

• 09/05/2019· STEERING

  A CLUNKING OR THUMPING NOISE COMES FROM THE LOWER STEERING COLUMN AS YOU MAKE A LEFT OR RIGHT HAND TURN. THE THUMPING NOISE HAS BEEN STEADILY INCREASING OVER THE PAST WEEKS.

• 09/05/2013· ELECTRICAL SYSTEM,STRUCTURE

  REAR DOOR/HATCH ELECTRIC MOTOR AND LATCH/LOCK ASSEMBLY FAILED. SEVERAL INCIDENCES OF THE REAR ELECTRIC HATCH FAILING TO SEAT/CLOSE OCCURRED PRIOR TO THE FAILURE. THE DOOR WOULD START DOWN BUT WOULD NOT CLOSE/LATCH. TOYOTA SERVICE DEPARTMENT (DOTHAN, AL) SAID THE DOOR NEEDED TO BE ADJUSTED AND DID SO. ABOUT ONE MONTH LATER THE DOOR CLOSED WITH A LOUD NOISE AND WOULD NOT OPEN AFTERWARDS. UPON OUTSIDE INSPECTION, I SAW THE DOOR WAS OFFSET ABOUT A QUARTER OF AN INCH TOWARD THE PASSENGER SIDE AND SEATED ABOUT THE SAME (1/4 INCH) FURTHER IN THAN NORMAL. THE DOOR WOULD NOT OPEN AT ALL AT THAT POINT. THE SAME SERVICE DEPARTMENT INITIALLY ACCUSED ME OF DAMAGING THE CAR IN AN ACCIDENT (UNTRUE). THEY PRIED THE DOOR OPEN, AND RECOMMENDED I DISABLE THE ELECTRIC DOOR MOTOR AND ONLY OPERATE THE DOOR MANUALLY. LATER THE SAME SERVICE PERSONNEL ADMITTED THERE WAS A DESIGN PROBLEM WITH THE DOOR HINGES THAT CAUSED THE FAILURE. *JB

• 09/05/2013· STEERING

  ABOUT EIGHTY MILES/TWO DAYS PRIOR TO THE FAILURE, AN INTERMITTENT WHINE/HUMMING NOISE WAS HEARD IN THE VICINITY OF THE DRIVER SIDE DASH AREA WHILE TURNING AT SLOW SPEEDS. I WAS TOLD THIS WAS NOT UNUSUAL AS THE POWER STEERING IS ELECTRICALLY ASSISTED AND THE ELECTRIC MOTOR WAS LIKELY MAKING THE NOISE. TWO DAYS AFTER THE FIRST SOUNDS, THE POWER STEERING FAILED UPON ENGINE START. THE STEERING WHEEL IS NEARLY IMPOSSIBLE TO TURN NOW. *JB

• 09/04/2020· ENGINE

  BRIEF ENGINE KNOCK/RATTLE NOISE AT COLD STARTUP (1AR2AR) VDS(S):DA41A,ZA3EH WM(S)5TD

• 08/23/2010· STEERING,SUSPENSION,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,SEAT BELTS,VEHICLE SPEED CONTROL,WHEELS,SEATS

  TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SUSPENSION WAS LOOSE AND THE BRAKING SYSTEM WOULD NOT OPERATE PROPERLY. THE BRAKES WOULD GO TO THE FLOORBOARD WHEN DEPRESSED. THE BRAKES WOULD NOT ENGAGE INTERMITTENTLY WHEN DEPRESSED. THE CONTACT STATED THAT THE DRIVER'S SEAT WOULD NO LONGER MOVE BACKWARD, AND WAS POSITIONED ENTIRELY TOO CLOSE TO HE STEERING WHEEL. THE CONTACT STATED THERE WAS LITTLE ROOM FOR MOVEMENT WHEN DRIVING. THE VEHICLE WAS TAKEN TO FOUR SEPARATE DEALERS AND THE CONTACT WAS TOLD THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 400 AND THE CURRENT MILEAGE WAS 6,500. THE CONSUMER STATED WHEN SHE REALIZED A POLICE OFFICER WAS BEHIND SHE ATTEMPTED TO STOP, THE VEHICLE CONTINUED TO ACCELERATE AND THE BRAKES COLLAPSED VERY LOW TO THE FLOOR. THE CONSUMER HAD TO PUMP THE BRAKES TO SLOW THE VEHICLE DOWN. THE CONSUMER ALSO STATED THE LUG NUTS BROKE ON THE FRONT DRIVER SIDE WHEEL. THE CRUISE CONTROL WAS INOPERATIVE, AND THE ENGINE HAD A SLIGHT TICKING SOUND AND THE ROTORS WERE RUSTING. UPDATED EVOQ 12/23/10 THE CONSUMER STATED THE SEAT BELT WRAPPED TIGHTLY AROUND HER THROAT. THE FRONT WHEEL WAS LOOSE, THERE WAS A WHINING NOISE COMING FROM THE VEHICLE. WHEN THE CONSUMER ATTEMPTED TO ACCELERATE THE VEHICLE WOULD STALL, THE CRUISE CONTROL NO LONGER WORKED. THE ACCELERATOR PEDAL NO LONGER STAYS IN PLACE AND THE STEERING WHEEL TURNED IN DIFFERENT DIRECTIONS. UPDATED 07/07/11. *JB

• 08/20/2019· AIR BAGSCrash

  TL* THE CONTACT OWNED A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE PARKING THE VEHICLE IN A PARKING, THE VEHICLE ACCELERATED INDEPENDENTLY, WENT OVER A CEMENT BARRIER, AND CONTINUED ACCELERATING WITH SPEED. THE CONTACT WAS NOT ABLE TO CONTROL THE VEHICLE. THE CONTACT THEN ENTERED ANOTHER PARKING LOT, THE CONTACT ATTEMPTED TO TURN THE STEERING WHEEL, AS A RESULT THE CONTACT CRASHED INTO A CORNER DUNKIN DONUT STORE. THE AIR BAG FAILED TO DEPLOY. THE CONTACT SUSTAINED MINOR FACE INJURIES DUE TO THE GLASS, NECK INJURED FROM THE STEERING WHEEL AND BACK THAT REQUIRED MEDICAL ATTENTION; THE CONTACT WAS HOSPITALIZED FOR TWO DAYS. THE FRONT PASSENGER, SUSTAINED CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE VEHICLE WAS DESTROYED. THE CONTACT MENTION THAT THE VEHICLE WAS PREVIOUSLY TAKEN FOR SERVICE AT MILLENNIUM TOYOTA DEALER (267 N FRANKLIN ST, HEMPSTEAD, NY 11550, (516) 874-2581) AND WAS INFORMED THE SERVICE WAS COMPLETED AND ALL WAS GOOD. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 34,784. *TR CONSUMER STATED BAGS FAILED TO DEPLOY.*JB

• 08/13/2019· STEERING

  STEERING WHEEL IS CLICKING VERY BAD WHEN MAKING TURNS. CAR SHOP CHECKED EVERYTHING OUT AND DECIDED IT WAS COMING FROM THE STEERING COLUMN. CAR WAS IN A PRIOR CAR ACCIDENT IN 2012 WITH NO REPORTED FRAME DAMAGE. TAKING CAR TO LOCAL TOYOTA DEALERSHIP, AS RECOMMENDED FROM REGULAR CAR SHOP.

• 08/12/2018· STRUCTURE,SEATS,SERVICE BRAKES

  I WAS SOLD OVER INTERNET BY VANDERGRIFT TOYOTA OF ARLINGTON,TX A FALSELY ADVERTISED 2009 TOYOTA HIGHLANDER,THAT WAS DELIVERED TO ME IN SAN ANTONIO, TX IN ENCLIMATE WEATHER AND WHILE I WAS IN A FULL BODY BRACE, I HAD TOLD THEM OF WEATHER, AND WAS IN DOWN POUR WHEN THEY DELIVERED, I WAS UNABLE TO EXAMINE CAR IN MY CONDITION AND WEATHER TILL NEXT MORNING. CAR HAD BEEN WRECKED, HAD SILT IN REAR TAIL LIGHTS, I TRIED TO HAVE DEALERSHIP FIX IT, BY TAKING CAR BACK TO THEM, I DID NOT HV ANOTHER CAR. THE CONDITIONS OF THE CAR WERE NEVER DISCLOSED, I DID NOT RECEIVED A BUYERS GUIDE, ONLY A BLANK SALES CONTRACT WITH MY NAME, CAR MAKE AND MODEL AND VIN WITH PRICE PAID. I HV REPEATEDLY TRIED TO RESOLVE MATTER, DEALER HAS LIED REPEATEDLY AND BILLIGERENT. I HAVE CALLED OWNERS OF DEALERSHIP, BERKSHIRE HATHAWAY, THEY DEFER TO DEALER, DEALER HAS DONE NOTHING, I HAVE TRIED TO TELL PEOPLE AT BERKSHIRE HATHAWAY THIS IS SOMETHING A DEALER HAS DROPPED ON ME, WHO ARE AND REPRESENT THE BERKSHIRE HATHAWAY BRAND, I TOLD BH, I WOULD PERSUE AND SEEK TO EXPOSE TO AUTHORITATIVE ENTITIES, AND PRESS,THEY HAVE DONE NOTHING. I HAVE ALSO FILED A PENDING COMPLAINT WITH TEXAS DMV. I ALSO HAVE ACCORDING TO USE TITLE 18 2511 (2)(D), RECORDED CONVERSATIONS WITH DLRSHIPS USED SALES MNGR, GENERAL MNGR/PARTNER, AND BERKSHIRE HATHAWAY, AND PREVIOUS OWNER WHO TOLD ME WHEN CAR TRADED IN, DLR SD WOLD NOT KEEP DO TO MILES AND AGE, WD GO TO WHOLES AUCTION. I ALSO HV SCREEN SHOT WHERE DEALER CONTINUED TO ADVERTISE CAR FOR SALE AT REDUCED PRICE 12 DAYS AFTER INITIAL DEPOSIT AND OVER A WEEK AFTER WIRE TRNSFER, AND 5 DAYS AFTER DELIVERY. OTHER, PROBLEMS INCLUDED COMPONENTS ADVERTISED OR OPTIONS NOT INCLUDED. TOYOTA TOW PKG, TURNED OUT TO BE UHAUL HITCH BOLTED ON, NO WIRING TO EVEN COONECT TO BRAKES, AND NO ADDITIONAL RADIATOR/FANS/ TO AID IN HAULING /TOWING, AND NO STELLITE RADIO AS ADVERTISED. ORIGINAL AD PHOTOS FAKED

• 08/10/2017· STEERING

  WHEN YOU DRIVE BACK AND TURN, THE TIRES MAKE A STRANGE MOVEMENT, IT SEEMS LIKE IT WILL BE DETACHED FROM THE AXLE.

• 08/10/2015· ELECTRICAL SYSTEM,STRUCTURE

  LIFT GATE AND POWER DOOR MOTOR BROKE. THE DOOR STOCKED AND COULD NOT BE OPENED OR LOCKED. I WAS LUCKY THAT MY TODDLER WAS NOT AROUND. I AM HORRIFIED WHAT WOULD HAPPENED IF HIS HAND STOCK IN IT AND THE DOOR COULD NOT BE OPEN. WE TOOK IT TO MOLLE TOYOTA. THEY TOLD ME THAT BESIDE THE LIFT GATE AND MOTOR THE WHOLE REAR DOOR AND HINGE HAS TO BE REPLACE. THEY SAID THAT IF I DON'T REPLACE THE DOORS I WILL HAVE SAME PROBLEM FEW MONTHS LATER. THEY SAID THAT TOYOTA MODIFIED THE NEW REAR DOOR THAT THEY ARE AWARE THAT THE DOOR IN MY VEHICLE CAUSING PROBLEMS. THEY REFUSED TO PAY FOR THE DOOR BECAUSE IT'S OUTSIDE WARRANTY. THE COST OF MOTOR AND LIFT GATE REPAIR IS $1500 THE COST WITH NEW DOOR IS $3500. I DON'T UNDERSTAND WHY TOYOTA DOES NOT PAY FOR DOOR THAT THEY ARE AWARE THAT ARE DEFECTIVE AND NEEDED TO BE MODIFIED. I ALSO THINK THAT THERE SHOULD BE A RECALL ON THIS PART BECAUSE SOMEONE CAN GET INJURED.

• 08/08/2013· STRUCTURE,VEHICLE SPEED CONTROLCrash

  AS MY WIFE CAME HOW WITH MY DAUGHTER, SHE PROCEEDED TO REVERSE THE CAR INTO OUR DRIVEWAY TO PARK THE CAR IN OUR GARAGE AS SHE NORMALLY DOES EVERYDAY. IN THE DRIVEWAY WAS ALSO MY CAR WHERE IT IS PARKED EVERYDAY. AS SHE WAS PROCEEDING TO GO BACK, THE CAR ALL OF A SUDDEN ACCELERATED ON ITS OWN AND TOOK OFF. SHE TRIED TO PRESS THE BRAKE BUT TO NO AVAIL. SHE CONTINUED TO PRESS THE BRAKE, HOWEVER THE CAR WOULD NOT STOP. SHE PROCEEDED TO HIT MY CAR AND DAMAGED BOTH CARS FROM FRONT TO BACK. HER CAR ON THE PASSENGER SIDE, AND MINE ON THE DRIVER SIDE. AFTER HITTING BOTH CARS, HER CAR PROCEEDED TO GO FURTHER BACK AND CRASH INTO THE HOUSE CAUSING MAJOR DAMAGE. THAT IS WHEN THE CAR ACTUALLY STOPPED. IT WAS AT THIS TIME THAT SHE WAS ABLE TO PUT THE CAR IN PARK AND TURN THE CAR OFF. BOTH CARS AND THE HOUSE NOW NEED MAJOR REPAIRS. MY DAUGHTER WAS SITTING IN THE BACK AT THE TIME OF THE INCIDENT. *TR

• 08/07/2018· STEERING

  AUGUST 4,2018 BACKING ON OF GARAGE AND POWER STEERING COMPLEXLY QUIT WORKING. YOU CAN STILL STEER BUT WITH GREAT EFFORT , MILEAGE 134,521. IN MARCH 1, 2015 POWER STEERING QUIT WORKING WHILE DRIVING ON A CITY STREET AT ABOUT 25MPH MAKING IT VERY DIFFICULT TO TURN .IT HAD 88644 MILES. THE TOYOTA DEALER REPLACED THE STEERING COLUMN PART # 45250-48181 & COMPUTER PART # 89650-48060. TWO STEERING FAILURES IN 134,000 SEEMS RATHER HIGH IN A SYSTEM THAT IMPORTANT.. THERE WAS NO PRIOR WARNING AND HAD THEY OCCURRED AT HIGHWAY SPEEDS ON A WINDING RROAD ONE COULD HAVE LOST CONTROL ON THE VEHICLE.08

• 08/05/2021· ENGINE

  Engine oil filler cap had interior motor part , melt through while driving , almost hurling all the way through , 2 inch cylindrical part viewed when opening hood to inspect damage . Braking , trac and vsc engaged and motor failed almost dieing , abs allowed brake pedal to go to floor with vehicle just stopping enough to move from traffic . No injuries and No collisions happened due to violent engine combusting or braking disabled , incident happened at 10 mph entering a parking lot .

• 08/05/2009· POWER TRAIN,EQUIPMENT

  MY 2009 TOYOTA HIGHLANDER WITH KEYLESS START ALLOWS THE VEHICLE TO SHUT OFF WHEN NOT IN PARK AND THE VEHICLE STARTS MOVING. IT ALSO WILL TURN OFF IN REVERSE, OR NEUTRAL AND WILL TURN BACK ON IN NEUTRAL AND WILL ALSO TURN OFF IN DRIVE. THIS DOES NOT FEEL SAFE AND SHOULD BE IMMEDIATELY INVESTIGATED. THE VEHICLE SHOULD HAVE TO BE IN PARK TO TURN OFF AND START LIKE ALL OTHER CARS WITH KEYS TO START THE VEHICLE. LOCAL DEALER INVESTIGATED BUT SAID ALL KEYLESS START VEHICLES OPERATE THIS WAY AND DIDN'T INDICATE THERE WAS A FIX TO THE SITUATION. *TR

• 08/04/2015· STRUCTURE

  REAR DOOR HATCH MADE A LOUD POPPING NOISE WHEN DOOR WAS LOWERED. DOOR NO LONGER OPENS OR CLOSES. DEALER STATES COST TO REPAIR $4,700 TO $5,400. TOYOTA HAS A TECHNICAL SERVICE BULLETIN COVERING THIS PROBLEM BUT DENIES RESPONSIBILITY IF VEHICLE IS BEYOND 36/36,000 WARRANTY. UPDATED 9/15/15*CW

• 08/03/2013· ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES,ENGINE

  WHILE DRIVING DOWN THE EXPRESSWAY WITH THE FAMILY (50MPH), CHECK ENGINE LIGHT AND TRACTION CONTROL SUDDENLY TURN ON AND FLICKER ON AND OFF RANDOMLY. ENGINE POWER HESITATES. AT THE STOPLIGHT, CHECK ENGINE LIGHT CONTINUES TO TURN ON, AND OFF RANDOMLY, AS WELL AS TRACTION CONTROL LIGHT. ENGINE APPEARS TO BE STALLING AT TIMES, AND RPM BOUNCES BETWEEN 500-900. ACCELERATION WHEN PRESSING AGAINST GAS PEDAL RESULTS IN UNEVEN ACCELERATION. PULLED VEHICLE OFF TO THE SIDE, TURNED ENGINE OFF, AND EXAMINED VEHICLE. EXAMINED VEHICLE AND DO NOT SEE ANYTHING SUSPICIOUS. TURNED VEHICLE BACK ON, AND CHECK ENGINE LIGHT WITH TRACTION CONTROL OFF. MOMENTS LATER, LIGHTS TURN BACK ON. LIMPED VEHICLE BACK TO RESIDENCE VIA LOCAL ROADS. CONTINUED TO EXPERIENCE INTERMITTENT ON/OFF CHECK ENGINE LIGHT AND TRACTION CONTROL. AFTER ARRIVING AT RESIDENCE, PARKED VEHICLE AND PERFORMED ADDITIONAL EXAMINATION. NOTICED BURNING SMELL AT REAR BRAKE SHOES, POSSIBLY FROM TRACTION CONTROL HOLDING ON TO BRAKES. WILL BRING CAR TO DEALERSHIP ON 08/05/13 FIRST THING IN THE MORNING. *TR

• 08/03/2010· ELECTRICAL SYSTEM,EQUIPMENT

  TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED FOUR TIMES. THE CONTACT STATED THE REPAIRS WERE MADE BY AN AUTHORIZED DEALER AND THE UNIT WOULD WORK FOR A SHORT TIME BEFORE FAILING AGAIN. IN ADDITION, THE DOOR LOCKS WOULD FAIL INTERMITTENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER DUE TO THE FAILURE OF THE AIR CONDITIONING UNIT. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE FAILURE MILEAGE WAS 4,624.. UPDATED 11/22/10 *BF THE CONSUMER STATED THE CD PLAYER, DOOR AND HATCH LOCKS FAILED. THE CONSUMER HAS SINCE RECEIVED A 2010 REPLACEMENT VEHICLE. UPDATED 11/23/10

• 08/02/2018· AIR BAGS

  TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY, WHICH WAS A SAFETY CONCERN. IN ADDITION, THE HORN AND CRUISE CONTROL BECAME COMPLETELY INOPERATIVE. THE DEALER (ROYAL MOORE TOYOTA, 1415 SOUTHEAST RIVER ROAD, HILLSBORO, OREGON 97124) DIAGNOSED THAT THE SPIRAL CABLE IN THE AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE DEALER (BEAVERTON TOYOTA, 4300 SOUTHWEST MURRAY BLVD, BEAVERTON, OREGON 97705) SERVICED THE VEHICLE FOR NHTSA CAMPAIGN NUMBER: 14V168000 (AIR BAGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED THE CONTACT WITH CASE NUMBER: 1807132735. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000. THE VIN WAS NOT AVAILABLE.

• 08/01/2013· VISIBILITY

  I PURCHASED A 2009 TOYOTA HIGHLANDER IN OCTOBER 29, 2013. EVERYTHING WAS FINE,THEN STARTED HAVING PROBLEMS WITH WINDOW ON THE DRIVER'S SIDE, IT KEPT GOING OFF LINE, SO I ROLLED UP THE WINDOW AND DIDN'T USE IT UNTIL I WAS ABLE TO GO FOR SERVICE. I TOOK IT IN TO BE SERVICE IN APRIL /MAY 2013 FOR A OIL CHANGE AND ETC. I TOLD THE GUY IN THE SERVICE DEPARTMENT WHAT WAS WRONG AND HE SAID HE WOULD CHECK IT FOR ME. AFTER SERVICING THE SUV, HE TOLD ME IT WOULD COST $ 400.00 PLUS DOLLARS TO FIX. I HAD THE CAR LESS THAN 6MONTHS. HE TOLD ME THERE WAS A PIECE THAT WAS BROKEN DUE TO RESTING THE ARM ON THE GLASS AND HE HAD TO REPLACE THE PIECE AND THE GLASS. IT'S FINE ONE MINUTE AND THEN THE NEXT IT'S OFF THE TRACT. SO I TOLD THE SERVICE GUY TO UNPLUG IT. I 'M NOT TALL ENOUGH TO REST MY ARM ON THE GLASS TO BREAK ANYTHING. I'M THE ONLY ONE THAT DRIVES THIS CAR. I TRULY BELIEVE THIS PART/PIECE WAS ALREADY BROKEN WHEN I PURCHASE THIS VEHICLE, BUT I CAN'T PROVE IT. I DON'T HAVE $ 400. 00 DOLLARS IN MY BUDGET PLUS MONTHLY BILL. HELP! *TR

• 07/30/2025· SERVICE BRAKES, HYDRAULIC

  The contact owns a 2009 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal, loud clunking sound. The ABS, the parking brake, and the traction control warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the brake actuator assembly had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 137,000.

• 07/25/2016· ENGINE

  MARCH 10, 2016 VEHICLE WAS TAKEN TO DEALER FOR OIL CHANGE. PARKED VEHICLE AFTER RETURN HOME (10 MILES DRIVE BETWEEN DEALERSHIP AND HOME) SAME DAY AND AFTER A FEW HOURS, NOTICED ALL OIL HAD LEAKED FROM VEHICLE. VEHICLE WAS TOWED BACK TO DEALER THAT DAY. UPON INVESTIGATION DEALER SAID THE PROBLEM WAS THE OIL COOLER PIPE. DEALER SAID TOYOTA ISSUED A TECHNICAL SERVICE BULLETIN T-SB-0201-11 OVER 5 YEARS PRIOR THAT ISSUED A REPAIR PROCEDURE TO REPLACE THIS OIL COOLER PIPE. DEALER REPLACED OIL COOLER PIPE UNDER WARRANTY PER TECHNICAL SERVICE BULLETIN AND ASSURED ME THAT NO DAMAGE TO THE ENGINE WAS "APPARENT" AFTER THE REPAIR. JULY 18, 2016 RETURNED TO SAME DEALER FOR A PROBLEM WITH THE ENGINE MAKING A LOUD KNOCKING SOUND UPON FAST ACCELERATION. DEALER DIAGNOSED PROBLEM AS A ROD KNOCK AND CONFIRMED IT WAS DUE TO THE OIL COOLER PIPE LEAK FROM MARCH. THE REPAIR INVOLVES REPLACING THE ENGINE AN EXTENSIVE AND VERY EXPENSIVE REPAIR. TOYOTA NEEDS TO MAKE THIS TECHNICAL SERVICE BULLETIN PROBLEM A RECALL TO AVOID UNNECESSARY ENGINE DAMAGE AND POTENTIAL SAFETY HAZARD TO THE 533500 ESTIMATED VEHICLES INCLUDED IN THE BULLETIN.