2009 Smart Fortwo

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/26/2016· POWER TRAIN,VEHICLE SPEED CONTROL

  WITHIN THE SPACE OF THREE MONTHS, IN THE MIDDLE OF DRIVING MY SMARTCAR, MY DASH DISPLAY HAS GONE FROM SHOWING D (FOR DRIVE) TO N AND THEN FLASHING THREE VERTICAL BARS. I HAVE LOST ALL CONTROL OF DRIVING THE CAR AND LUCKILY THERE WAS SPACE ON THE SIDE OF THE ROAD TO COAST TO A STOP. WHEN TRYING TO TURN THE CAR BACK ON, THE THREE BARS REMAIN. THERE IS A WAY THROUGH THE SHIFTER TO RESTART THE CAR OR AT LEAST GETTING IT INTO NEUTRAL. A SERIES OF PUMPING THE BRAKE, TURNING THE START KEY AND TRYING TO MOVE THE SHIFTER BACK AND FORTH THROUGH GEARS. EVENTUALLY, THE CAR WILL START. UNFORTUNATELY, THE THREE BARS OF DEATH (AS NICKNAMED ON THE SMART CAR FORUMS) CAN HAPPEN FOR ANY NUMEROUS TYPES OF FAULTS SUCH AS WEAK BATTERY TO FAULTY COMMUNICATION WITH THE TRANSMISSION, TO HEATER/AIR CONDITIONING OPERATING UNIT IS DEFECTIVE. THE LIST IS LONG. THE PROBLEM IS MY CAR HAS COMPLETELY STOPPED WORKING IN THE MIDDLE OF THE ROAD WITHOUT WARNING AND THIS COULD BE VERY DANGEROUS. *TR

• 12/19/2013· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT STATED THAT THE ABS SYSTEM WARNING LIGHT REMAINED ILLUMINATED AND CAUSED THE TRACTION CONTROL TO ALSO FAIL. THE DEALER ADVISED THAT THE ABS MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 4,600.

• 12/12/2016· ELECTRICAL SYSTEM,STRUCTURE

  I AM ORIGINAL OWNER SINCE FEB 09 (MANF 12/08) AND ITS NOW 7 YRS OLD AND REQS NEW BATTERY. LIFTING UP FLOOR MAT TO REMOVE OLD BATTERY I NOTICED STICKY RED OILY SUBSTANCE (UNKOWN SOURCE BUT NOW SUSPECT BATTERY VAPOR CONDENSATION) AROUND TOP OF COMPARTMENT (MOSTLY WHERE HOLDDOWN BRACKET CONNECTS). REMOVING THE BATTERY THEN EXPOSED CORRODED FLOOR PAINT FROM BATTERY ACID. IN ATTEMPTING TO CLEAN UP THE MESS, I HAD TO REMOVE THE BATTERY VENT TUBE EXITING THE FLOOR. THIS TUBE HAD A SPIDER NEST INSIDE ABOUT 2" FROM OPENING. WD40 DID NOT PENETRATE NESTS END SEALS & HAD TO EXTRACT SPIDER & NEST MANUALLY. I CAN NOT PROVE THIS IS SAFETY RELATED BUT IM WONDERING IF OTHER VENTED BATTERY CARS HAVE THIS VENT BLOCKAGE-CORROSION PROBLEM AND ALSO IF THESE BLOCKED FUMES WERE TOXIC TO OCCUPANTS OF MY CAR? I TOOK SOME PHONE PHOTO EVIDENCE. ON UNRELATED PROBLEM. IN THE LAST 1-2 YEARS I ALSO HAVE THE PEELING TOP CLEARCOAT PROBLEM REPORTED BY OTHER OWNERS OF 2009 RED PAINT (NON METALIC) WHICH IS PRIMARILY ON HOOD PANEL & OTHER TOP SURFACES EXPOSED TO DIRECT SUN WHICH LEAVES THE DULL RED BASE COLOR OF THE PLASTIC PANELS. (THIS IS ONLY EXHIBITED ON 2009 RED MODELS). *TR

• 12/11/2013· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  THE CAR HAS A PROBLEM WITH NOT GOING IN REVERSE WHEN YOU PUT THE GEAR SHIFTER IN 'R' POSITION? USUALLY AFTER DRIVEN AND THE CAR IS WARMED UP. THE CAR JUST ROLLS WHEN PUT IN REVERSE, AS IF THOUGH IT'S IN NEUTRAL.. WHEN GIVING GAS IT JUST REVS THE ENGINE AND NOTHING HAPPENS.. THE CAR IS AUTOMATIC TRANSMISSION. AND IT CAN BE DANGEROUS PUTTING THE CAR IN REVERSE IF IT'S ON A SLOPE. THE VEHICLE CAN ROLL. THIS IS A NORMAL PROBLEM WITH THE 08-09 YEAR. THIS SHOULD DEFIANTLY BE A RECALL ISSUE. THANK YOU FOR TAKEN THE TIME TO READ MY COMPLAINT. *TR

• 12/06/2013· SEAT BELTS

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT BUCKLE BECAME INOPERABLE AND WOULD NOT LATCH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 28,800.

• 12/04/2015· POWER TRAIN

  WHILE DRIVING THE CAR, THE ENGINE WILL REV AND THEN THERE IS ONLY NEUTRAL SHOWING. I HAVE NO REVERSE OR DRIVE. THANK GOODNESS WHEN THIS HAPPENS I HAVE HAD A PLACE TO PULL OFF THE ROAD. I TURN THE CAR OFF AND SIT FOR A FEW MINUTES, TURN IT BACK ON AND HAVE ALL THE GEARS. I HAVE TRIED DRIVING IN THE "MANUAL" POSITION BUT IT STILL HAPPENS. LATELY IT IS MORE AND MORE FREQUENT. ONE OF THESE DAYS THIS CAR WILL GET ME SMUSHED. SMART NEEDS TO DO A MAJOR RECALL ON THIS! I AM ONLY THE SECOND OWNER OF THIS CAR AND GOT IT WITH ONLY 18,000 MILES ON IT. I NOW HAVE 35,025 MILES ON IT. TOOK IT TO A MECHANIC AND GIVES A PO803 CODE, WHICH STATES A CLUTCH SENSOR. SMART CARS CODE SAYS IT NEEDS A NEW CLUTCH! WTH!?? AND IF IT NEEDS A NEW CLUTCH THEN WHY DOES THIS ONLY OCCURR IN THE COLDER WEATHER AND NOT THE SUMMER!!??!! I AM SO PISSED! SMART CAR TAKE RESPONSIBILITY FOR YOUR SCREWUP IN THE DESIGN OF THIS CAR! THIS HAS HAPPENED SO MANY TIMES!!!

• 11/21/2021· FUEL/PROPULSION SYSTEM

  Fuel pump connectors cracked leaking fuel.

• 11/21/2016· AIR BAGS

  AIR BAG LIGHT ON. NO ACCIDENT

• 11/12/2015· UNKNOWN OR OTHER,ENGINEFire

  DRIVING TO A FRIENDS HOUSE, ABOUT A 10-15 MIN. DRIVE... FRIEND SAY HE SMELLS SMOKE, LOOK TO THE RIGHT SIDE ONTO THE MIRROR AND ITS SMOKE COMING FROM THE BACK SIDE OF MY CAR. OPEN THE BACK TO LOOK AT THE ENGINE - A LOT OF SMOKE IS COMING OUT AND AS THE SMOKE IS CLEARING MY FRIEND SEES FLAMES AND WE QUICKLY AFTER GRAB A HOSE AND CALL 9-1-1. DON'T KNOW WHAT CAUSED THE FIRE, FIREMEN SAID NOT TO START THE CAR CALLED AAA. FIREMEN SAID WE GOT LUCKY IT DIDN'T REACH THE GAS TANK.

• 11/11/2014· STRUCTURE

  WHILE A BODY PANEL WAS BEING REPLACED ON A 2009 SMART FORTWO PASSION, THE MECHANIC DISCOVERED THAT, UNBEKNOWNST TO THE CAR'S OWNER, THE MECHANISM SECURING THE TAILGATE IN PLACE HAD CORRODED SO BADLY THAT THE TAILGATE WAS IN DANGER OF, LITERALLY, FALLING OFF THE VEHICLE. HE REATTACHED THE TAILGATE BUT WAS SINCERELY CONCERNED THAT IT HAD BEEN IN DANGER OF FALLING OFF OR--GIVEN THE RIGHT CONDITIONS, LIKE OPEN WINDOWS AND HIGHWAY SPEED--FLYING OFF AND PERHAPS HITTING ANOTHER VEHICLE OR BEING HIT BY ANOTHER VEHICLE. THE MECHANIC ADVISED FILING A REPORT IN CASE THIS CORROSION PROBLEM AFFECTS OTHER SIMILAR MODELS. MORE DETAILS AND PHOTOGRAPHS ARE AVAILABLE FROM THE MECHANIC. TO CONTACT THE MECHANIC, SIMPLY EMAIL OR CALL THE FILER OF THIS REPORT. *TR

• 11/05/2019· ENGINE

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN AND REPAIRED PER NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE, ENGINE COOLING). MERCEDES-BENZ OF WESTMINISTER (LOCATED AT 10391 WESTMINISTER BLVD, WESTMINISTER, CO 80020, 303-410-7800) PERFORMED THE REPAIR. AFTER THE REPAIR, THE VEHICLE BEGAN TO MAKE A BOOMING NOISE WHEN THE ENGINE AND/OR RADIO WERE ACTIVATED. THE CONTACT HAD NOT TAKEN THE VEHICLE BACK TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

• 11/01/2017· STRUCTURE,UNKNOWN OR OTHER,ENGINEFire

  I REPRESENT THE OWNERS OF THIS 2009 SMART FORTWO VEHICLE. MY CLIENT DROVE THE VEHICLE HOME AFTER WORK AND PARKED IN THE GARAGE. APPROXIMATELY 30 MINUTES AFTER PARKING THE VEHICLE IN THE GARAGE, MY CLIENT WAS AWOKEN BY HIS SON WHO SMELLED SMOKE. MY CLIENT FOLLOWED THE SMOKE TO THE GARAGE WHERE HE FOUND THE VEHICLE ON FIRE. IT APPEARED THE FIRE STARTED IN THE ENGINE COMPARTMENT. THE FIRE SPREAD QUICKLY THROUGHOUT THE GARAGE AND INTO THE HOUSE. THE PROPERTY DAMAGE IS EXTENSIVE, INCLUDING TOTALING BOTH VEHICLES IN THE GARAGE AND EXTENSIVE PROPERTY DAMAGE TO THE HOME.

• 10/24/2022· POWER TRAIN

  2008 Smart Fortwo has a recall open for reprograming the transmission computer because of rough shifting and bucking while shifting and lugging the engine to much before down shifting. Mine is a 2008 but the VIN was not included in the recall and I am having the same problems with mine. Can mine be added to the recall?

• 10/23/2017· SEAT BELTS

  DRIVER'S SIDE SEATBELT WILL NOT LATCH, I'M USING THE PASSENGER SIDE SEATBELT FOR NOW. I CAN'T HAVE A PASSENGER IN MY CAR BECAUSE OF THAT BROKEN SEATBELT. THIS HAPPENED ALREADY BEFORE, MAYBE A YEAR AGO AND MERCEDES BENZ OF GEORGETOWN WANTED ME TO PAY FOR IT AFTER BEING FIXED BUT I INSISTED THAT IT'S A SAFETY ISSUE AND I SHOULDN'T BE DRIVING FROM THEIR SHOP WITHOUT HAVING IT FIXED. SO FRUSTRATING SAFETY ISSUES THAT NO ONE WANTS TO TAKE CARE OF IT UNTIL SOMEBODY'S DEAD.

• 10/19/2015· POWER TRAIN,ELECTRICAL SYSTEM

  THE VEHICLE FAILS INTERMITTENTLY TO SHIFT FROM BRAKE TO REVERSE OR FROM REVERSE TO DRIVE. WHEN THE FAILURE OCCURS, ALL THAT IS SEEN ON THE FRONT DASHBOARD IS A BLANK SCREEN AND THE CAR ALERT SYSTEMS LETS OUT A CONTINUOUS BEEPING DENOTING THE FAILURE OF THE SHIFT. IT SOMETIMES REQUIRES IMMEDIATE TURNING OFF OF THE ENGINE AND RESTARTING IN ORDER TO GET TO THE DESIRED GEAR. SELDOM THAT DOES NOT WORK, AND TURNING OFF AND WAITING 10 MINUTES SEEMS TO ALLOW GEAR SHIFTS. THIS IS DANGEROUS ESPECIALLY IN THE REVERSE TO DRIVE FAILURE AS WHEN COMING OUT OF A DRIVEWAY ON A BUSY ROAD, IT MAY CAUSE AN ACCIDENT. THIS HAS OCCURRED AFTER WARRANTY AND I WAS TOLD THERE IS A MERCEDES BENZ SOFTWARE UPGRADE MEANT TO SOLVE IT. BUT THIS IS A CHARGED SERVICE. AS A SAFETY ISSUE, I IMPLORE THAT THIS SHOULD NOT BE A CHARGED BUT REQUIRED SAFETY RECALL. UPON VIEWING THE COMPLAINTS IT SEEMS A FEW OTHER SUFFER THE SAME DEGREE OF FAILURES. AS THE CAR IS A NICHE BRAND, THE CONSUMER BASE IS SMALLER AND YOU DO NOT HAVE AS LARGE A COMPLAINT POOL AS A HONDA ACCORD, WHICH IS FAIRLY POPULAR AND HAS A LARGE CONSUMER BASE. I HUMBLY REQUEST THE NHSTA MAKE DAIMLER AG AND MERCEDES BENZ USA RESPONSIBLE TO REPAIR THIS AND HAVE EVERY SMART ON THE ROAD'S TRANSMISSION SOFTWARE UPGRADED FREE OF COST.

• 10/18/2019· ENGINE

  2009 SMART FORTWO PURE/PASSION. CONSUMER WRITES IN REGARD TO SAFETY NHTSA RECALL NOTICE #18V273. *AS THE CONSUMER STATED THE DEALER WAS TO ARRANGE HAVING THE VEHICLE REPAIRED LOCALLY DUE TO THE CONSUMER'S DISABILITY. THE DEALER DID NOT MAKE AN ARRANGEMENT THAT THE CONSUMER FOUND REASONABLE. *JS

• 10/13/2016· STRUCTURE,UNKNOWN OR OTHER

  THERE IS THIS HORRIBLE PROBLEM WITH THE 2009 SMART FORTWO RALLY RED! THE CLEARCOAT IS PEELING FOR NO REASON AND THERE IS AT LEAST 60 PEOPLE AROUND THE COUNTRY WITH THE SAME EXACT ISSUE WITH PROOF AND STATEMENTS TO PROVE IT! MERCEDES/SMART SHOULD ISSUE A RECALL OR REPLACE THESE PANELS FREE OF CHARGE! THIS RUINS THE INTEGRITY OF THE CAR AND EVEN THE DEALERSHIP WONT HELP OUT BECAUSE THE CAR IS OUT OF WARRANTY OR IM NOT "LOYAL ENOUGH" TO THE DEALERSHIP! MY AND EVERYONE ELSE WITH A RED FORTWOS CLEAR COAT IS PEELING FOR NO EXACT REASON AT ALL, THIS IS A MAJOR DESIGN FLAW WITH VERY THIN CLEAR COAT, I UNDERSTAND IF IT WAS JUST A FEW CARS BUT WE ARE TALKING MORE THAN 60 CARS AND LETS NOT FORGET THE SAFETY RECALL THAT WAS MADE IN 2008 FOR MESSED UP PAINT AS WELL! FIX THIS MERCEDES! I HONESTLY BELIEVE SOMETHING BAD CAN HAPPEN IN THIS CAR, MAKES ME FEEL VERY UNSAFE

• 10/09/2019· ENGINE

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. WHILE DRIVING 25 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE ABS AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE AND ENGINE COOLING). THE CONTACT STATED THAT MERCEDES-BENZ OF EDISON (LOCATED AT 910 US-1, EDISON, NJ 08817, (732) 394-1870) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE PART WAS NOT AVAILABLE FOR THE REPAIR. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 89,000. PARTS DISTRIBUTION DISCONNECT.

• 10/09/2018· POWER TRAIN

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. WHILE DRIVING VARIOUS SPEEDS, THE TRANSMISSION SHIFTED INTO NEUTRAL WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD COMPLETELY SHUT OFF, CAUSING THE BRAKES AND STEERING WHEEL TO FAIL. THE VEHICLE WAS TAKEN TO WORLD WIDE MOTORS, INC (3900 E 96TH ST, INDIANAPOLIS, IN 46240) WHERE THEY UPDATED THE SOFTWARE SYSTEM IN THE VEHICLE; HOWEVER, THE SAME FAILURES OCCURRED MULTIPLE TIMES. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 41,000. *TT UPDATED 12/12/18*JB

• 10/07/2016· POWER TRAIN

  WHEN CAR IS STATIONARY AND I START IT AND PUT IT INTO REVERSE THE CAR WOULD NOT MOVE. THE GEAR INDICATOR INSTEAD OF SHOWING "R" SHOWS BLANK. I HAVE TO TURN OFF ENGINE AND TRY AGAIN. I SUCCEED IN ABOUT 3 TRIES. THERE ARE TIMES THAT WHEN I SHIFT INTO REVERSE THE GEAR INDICATOR DISPLAYS "N". THIS EPISODE HAPPENS ABOUT TWO TIMES A WEEK. MY OBSERVATION IS THAT IT DOES NOT DEPEND ON THE TIME OF DAY - WHETHER MORNING, AFTERNOON, OR EVENING; OR, COLD OR HOT DAY. IT SEEMS TO OCCUR AT RANDOM.

• 10/03/2012· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEMFire

  AFTER GETTING HOME FROM SCHOOL, COMING IN SAYING HELLO TO THE FAMILY I WENT BACK OUT TO MY CAR TO GET MY BAG. WHEN I APPROACHED MY CAR I COULD HEAR WHAT I BELIEVED TO BE MY RADIATOR FANS STILL RUNNING DESPITE THE CAR WAS TURNED OFF. MY LOGIC WAS "MAYBE A GLITCH IN THE COMPUTER." SO I PROCEEDED TO SIMPLY TURN THE CAR ON AND THEN OFF TO SEE IF THAT WOULD HELP. NOPE, THAT DIDN'T DO THE TRICK. PUZZLED I CAME INSIDE TO INFORM MY DAD WHAT WAS GOING ON, WHILE I WAS TALKING TO MY DAD I COULD HEAR THE FACTORY ALARM GOING OFF, THEN IT STARTED HONKING, THE WINDSHIELD WIPERS WERE RUNNING. WHEN I APPROACHED MY CAR TO SEE IF THE THERE WAS A CHANCE THAT I LEFT SOMETHING ON. WHEN I OPENED THE DOOR, I SAW SMOKE COMING UNDER THE DRIVER SIDE CONSOLE, THEN SPARKS, THEN FIRE!!!! I RAN AND GRABBED THE HOSE TO PUT IT OUT BEFORE IT GOT WORSE AND POSSIBLY LOSING THE CAR. I HAVE TAKEN THE BATTERY OUT TO MAKE SURE THIS DOESN'T HAPPEN. THE CARPET NEAR THE PEDDLES ARE SINGLED FROM THE FIRE AND THE FUSE BOX IS EXPOSED AND MOST OF THE PLASTIC HOUSING HAS MELTED AWAY. SADLY MY CAR IS OUTSIDE THE WARRANTY SO SMART WILL NOT DO ANYTHING. SO NOW I AM MAKING SOME CALLS TO SEE WHAT MY NEXT OPTIONS ARE. I'VE CALLED SMART CUSTOMER CARE AND SAID THERE IS NOTHING THEY CAN DO. NOT SURE WHAT COULD HAVE CAUSED THIS TO HAPPEN, THE ONLY UPGRADE I'VE DONE ON MY SMART IS JUST UPGRADING THE HORN, BUT THAT WAS WHEN I FIRST GOT IT. I'LL POST PICTURES LATER. NEEDLESS TO SAY I'M GLAD THIS HAPPENED AFTER I PARKED THE CAR AT MY HOUSE RATHER THEN BEING STUCK ON THE SIDE OF ROAD WATCHING IT BEING ENGULFED IN FLAMES AND LOSING MY CAR COMPLETELY. *TR

• 10/02/2014· SEAT BELTS

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE DEALER STATED THAT THE DRIVER SIDE SEAT BELT RETRACTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 14,724. UPDATED 11/21/14*CN UPDATED 5/7/2015 *JS

• 09/24/2018· POWER TRAIN,ELECTRICAL SYSTEM

  POSSIBLE SAFETY ISSUE WITH SMARTCAR 2009, VIN: [XXX] INTERMITTENT ISSUE WITH GEARBOX SHIFTER NOT ALLOWING CAR TO BE SHIFTED INTO REVERSE. SAFETY ISSUE. WHEN TRYING TO BACK INTO A PARKING SPACE, OR LEAVE A PARKING SPACE. IF A SIMILAR SMARCARS ARE STUCK ON TRAIN TRACKS, AND CANNOT MANEUVER TO GET OFF THE TRACKS THIS COULD BE A VERY SERIOUS SAFETY ISSUE. THIS IS NOT A ONE OFF ISSUE, IT IS NOTED ON MULTIPLE INTERNATIONAL SMARTCAR BLOGS, HTTPS://WWW.SMARTCAROFAMERICA.COM/FORUMS/F4/REVERSE-DOES-NOT-ENGAGE-140961 HTTPS://WWW.SMARTCAROFAMERICA.COM/FORUMS/F353/WON-T-GO-INTO-REVERSE-SOMETIMES-33556/ HTTPS://WWW.YOUTUBE.COM/WATCH?V=4IWBPVZKSZE ADDITIONALLY, THE CONSOLE WILL SHOW A FLASHING "D" AND WRENCHES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 09/17/2015· WHEELS

  AS I WAS DRIVING TO WORK ON A HIGHWAY AT 55 MPH, MY CAR'S RIGHT FRONT WHEEL GOT RIPPED APART AND MY CAR GOT UNSTABLE TO THE POINT I ALMOST KILLED MYSELF. MY CAR WAS TOWED AND I WAS TOLD THAT THE CAR'S TPMS STEM VALVE HOLDER BROKE OFF WHILE DRIVING. THIS IS NOT THE FIRST TIME IT HAPPENS. THE QUALITY OF THE STEM HOLDERS IS BAD AND BREAKS ALL THE TIME. SMART SHOULD RECALL THESE CARS AND CHANGE THE PIECES THAT COULD SAVE LIVES.

• 09/14/2017· POWER TRAIN

  FIRST START OF THE DAY IT WILL NOT SHIFT INTO R OR D. IT WILL SHOW P AND N WHEN YOU SHIFT BUT IT WILL NOT GO INTO GEAR FOR REVERSE OR DRIVE. YOU HAVE TO RESTART THE CAR SEVERAL TIMES TO GET IT TO SHIFT. JUST SPOKE WITH SMART CAR ON THE PHONE AND THEY DENY KNOWING ANYTHING ABOUT IT. HOWEVER SEARCHING THE WEB YOU WILL SEE ITS VERY COMMON. ITS A FACTORY DEFECT THAT SMART CAR IS DENYING.

• 09/12/2011· UNKNOWN OR OTHER

  I AM HAVING A PROBLEM WITH MY 2009 SMART FORTWO PASSION'S TRANSMISSION. WE PICKED UP OUR CAR ON SATURDAY FOR THE FOLLOWING PROBLEM: I WAS DRIVING ALONG & ALL OF A SUDDEN, THE CAR SEEMS TO THINK IT'S IN N. EVEN CHANGING THE GEARS PROMPTS AN "N" IN THE GEAR POSITION. ONCE I TURNED THE CAR OFF, IT WOULDN'T START AGAIN & THE DREADED THREE BARS APPEARED. WE TRIED THE "TEACH-IN" FIX & IT WORKED TEMPORARILY BEFORE ACTING UP AGAIN. WE HAD OUR CAR TOWED TO THE DEALER FOR SERVICE AND PICKED IT UP ON SATURDAY AFTER THE SERVICE DEPARTMENT SUPPOSEDLY FIXED IT. THE SERVICE DEPARTMENT DID A DIAGNOSTIC CHECK AND A CODE APPEARED. THEY THEN RESET WHATEVER NEED TO BE RESET FOR $112.98. WE WERE ALSO OFFERED A SOFTWARE UPGRADE FOR $75 ON THE BASIS THE SERVICE MANAGER DID NOT KNOW WHAT THE UPGRADE DOES, BUT HE DID KNOW IT WOULDN'T FIX THE PROBLEM. OBVIOUSLY, WE TURNED DOWN THE UPGRADE. I HAVE CONTACTED MERCEDES TO ABSORB THE COST OF FIXING THIS DEFECT. OUR WARRANTY EXPIRED ONLY 6 WEEKS AGO. SINCE THERE IS A METHOD TO "LIMP" TO A SAFE PLACE IN THE USER MANUAL, IT SEEMS THEY ANTICIPATED THIS PROBLEM TO BEGIN WITH. FROM READING BLOGS ABOUT THIS, I WAS NOT SURPRISED WHEN THE SAME PROBLEM STARTED AGAIN ON SUNDAY. NOW WE ARE HAVING IT TOWED IN FOR SERVICE AGAIN. I URGE MERCEDES-BENZ TO ACTIVATE A RECALL ON THIS MODEL! SOONER OR LATER THIS DEFECT IS GOING TO KICK IN ON THE FREEWAY AND SOMEONE WILL BE REAR-ENDED OR EVEN KILLED. THIS IS NOT SIMPLY A NUISANCE MALFUNCTION! *TR

• 09/07/2017· FUEL/PROPULSION SYSTEM

  FUEL PUMP CONNECTOR CRACKS

• 09/07/2017· AIR BAGSCrash

  AIRBAGS DID NOT DEPLOY PASSENGER SIDE OF MY CAR WAS DEMOLISHED.

• 09/07/2011· UNKNOWN OR OTHER

  SIX WEEKS OUT OF WARRANTY - I WAS DRIVING ALONG & ALL OF A SUDDEN, THE CAR SEEMS TO THINK IT'S IN NEUTRAL, WON'T LET ME CHANGE GEARS - WAS ONLY ABLE TO COAST TO A SAFE AREA OFF THE HIGHWAY. ANY GEAR I SHIFTED TO KEPT COMING ACROSS THE DASH AS THE NEUTRAL POSITION. ONCE I TURNED THE CAR OFF, IT WOULDN'T START AGAIN & THE DREADED THREE BARS APPEARED. WE TRIED THE "TEACH-IN" FIX RECOMMENDED IN THE USER MANUAL & IT WORKED TEMPORARILY BEFORE ACTING UP AGAIN. FROM THE INTERNET BLOGS I'VE READ, THIS WAS A PROBLEM IN THE 2008 MODEL - AN UPGRADE WAS PROVIDED FOR A FIX. MY CAR IS A 2009 AND I FEEL SMART USA SHOULD RECALL THE 2009 MODEL DUE TO THIS OBVIOUS DEFECT. IT'S ABSOLUTELY RIDICULOUS I WOULD HAVE TO PAY FOR SOMETHING LIKE THIS WHEN THE CAR IS ONLY SIX WEEKS PAST WARRANTY! OUR DEALER KEEPS TRANSFERRING US TO MERCEDES-BENZ FINANCIAL SINCE THEY'RE THE ONE WHO APPROVE THE WARRANTY ISSUE. NO ONE FROM MERCEDES IS ANSWERING OR RETURNING OUR CALLS. *TR

• 09/06/2016· FUEL/PROPULSION SYSTEM

  I WAS DRIVING DOWN THE CITY HIGHWAY - ROUTE 283 TO GET SOMETHING TO EAT AS I TURNED MY CAR STALLED OUT COMPLETELY. TRYING TO TURN OVER IT WOULD TRY TO START BUT NEVER START. CAR HAS JUST OVER 17K MILES ON IT. THANKFULLY I WASN'T IN HEAVY TRAFFIC AS THIS COULD HAVE CAUSED AN ACCIDENT BY SOMEONE REAR-ENDING ME BECAUSE OF THE REDUCED SPEED AND STALL. I HAD TO HAVE SOMEONE PUSH ME UP TO A PARKING LOT WHILE I WAITED FOR A TOW TRUCK. A MONTH LATER I AM STILL WAITING ON A REPLACEMENT FUEL PUMP. THE ORIGINAL BOSCH KEEPS BLOWING FUSES AND STALLING OUT. MY MECHANIC TEST DROVE IT AND HE HAD TO BE TOWED BACK TO HIS SHOP AS WELL BECAUSE OF A STALL/BLOWN FUSE BECAUSE OF THE FUEL PUMP ISSUE. THESE FUEL PUMPS SEEM TO BE ON BACK ORDER BECAUSE LOTS OF SMART CARS ARE HAVING THE SAME ISSUE AT THE MOMENT WITH THEIR BOSCH FUEL PUMPS.

• 09/05/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2009 Mercedes-Benz Smart ForTwo. The contact received notification of NHTSA Campaign Number: 18V273000 (Engine and Engine Cooling); however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer scheduled an appointment at the dealer; however, the dealer contacted the contact and decline to honor the recall repair appointment. The contact contacted two dealers and was informed that they do not perform repair on Mercedes-Benz Smart Cars. The contact had not experienced a failure. Parts distribution disconnect.

• 08/29/2024· ENGINE AND ENGINE COOLING

  The contact owns a 2009 Mercedes-Benz Smart Fortwo. The contact received notification of NHTSA Campaign Number: 18V273000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer and several unknown dealers were contacted and informed the contact that they did not service Smart vehicles. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

• 08/29/2019· FUEL SYSTEM, DIESELFire

  TL* THE CONTACT OWNED A 2009 SMART FORTWO. THE CONTACT'S FRIEND WAS DRIVING HIS VEHICLE AT 60 MPH WHEN HE SMELLED PLASTIC BURNING INSIDE THE VEHICLE. MOMENTS LATER, SMOKE BEGAN TO ENTER THE VEHICLE FROM BEHIND THE DRIVER SEAT; NO WARNING LIGHTS ILLUMINATED DURING THE FAILURE. THE CONTACT'S FRIEND PULLED THE VEHICLE OVER AND WALKED TO THE REAR OF THE VEHICLE WHEN HE DISCOVER THAT FIRE STARTED FROM THE REAR LEFT BUMPER OF THE VEHICLE. THE CONTACT THEN RETRIEVED A BOTTLE OF WATER FROM THE VEHICLE AND TURNED THE VEHICLE OFF. THE FIRE BEGAN SPREAD AND COMPLETELY ENGULFED THE ENTIRE VEHICLE. THE CONTACT'S FRIEND THEN DIALED 911. FIRE AND STATE POLICE ARRIVED AT THE SCENE OF THE INCIDENT. THE FIRE WAS EVENTUALLY EXTINGUISHED. NO INJURIES OCCURRED DURING THE INCIDENT AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED DUE TO THE FIRE AND TOWED TO AN INDEPENDENT MECHANIC. UPON INVESTIGATION, THE CONTACT ASSOCIATED NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE AND ENGINE COOLING) WITH HIS FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND SENT HIM A QUESTIONNAIRE IN RELATION TO THE FAILURE. THE DEALER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000.

• 08/29/2018· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM

  ELECTRICAL FUSES TEND TO CAUSE ELECTRICAL SHORTS, WITH A/C COMING ON AND OFF AT ANY GIVEN TIME, OFTEN WHEN I HIT SPEED BUMPS. THE LIGHTS CAN BE CAUSED BY THIS AS WELL HITTING THE SIMPLE RIGHT CORNER TURN CAN POP THE LIGHT RIGHT OUT. I HAVE REPEATEDLY TOLD THEM THAT IT NEEDS BETTER SHOCKS. I HAVE REPLACED THE LIGHTS BOTH FRONT AND BACK AT A VERY MINIMUM OF 12 TIMES A YEAR. THAT'S RIDICULOUS IN MY EYES.IT SHOULD BE SMARTER THAN THAT!!!!

• 08/27/2018· UNKNOWN OR OTHER

  SMART CAR RECALL I CONTACTED THE DEALERSHIP ON AUGUST 3, 2018 AND THEY WERE SUPPOSE TO CONTACT ME BACK - I AM STILL WAITING. THEY SAID THEY WOULD CONTACT ME ONCE THEY HAD PARTS AVAILABLE FOR THE RECALL.

• 08/24/2021· FUEL/PROPULSION SYSTEM

  Electric fuel pump inlet and outlet nipples to fuel hoses broke and caused fuel leakage.

• 08/24/2018· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (MERCEDES-BENZ OF OXNARD, 1511 AUTO CENTER DR, OXNARD, CA 93036, (805) 665-301) WAS CONTACTED AND CONFIRMED THAT THE PARTS AND TOOL NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED AND REFEREED THE CONTACT BACK TO THE DEALER. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *TT CONTACT STATES ISSUE HAS BEEN RESOLVED. *TT

• 08/24/2017· ELECTRICAL SYSTEM,UNKNOWN OR OTHERFire

  MY 2009 SMART FORTWO CAR CAUGHT ON FIRE YESTERDAY AND BURNED. WHEN I WAS PULLING INTO THE LOCAL POST OFFICE, THE CAR?S WINDSHIELD WIPERS CAME ON BY THEMSELVES AND THEN THE HORN BEGAN TO HONK AS WELL. I GOT INTO A PARKING SPACE AND TURNED OFF THE CAR. I SAW SOMETHING COMING FROM THE FRONT OF THE CAR BUT NO FLAMES. I GOT OUT AND WENT INTO THE POST OFFICE TO GET MY MAIL. WHILE IN THERE I HEARD SEVERAL PEOPLE YELLING THAT A CAR WAS ON FIRE. I RUSHED OUTSIDE TO SEE MY CAR FULLY ENGULFED IN FLAMES. I LOST ALL MY THINGS IN THE CAR; LAPTOP, TABLET, CELLPHONE AND MOST OF ALL ALL MY BUSINESS PAPERWORK, CONTACTS, ETC.

• 08/22/2025· SERVICE BRAKES, HYDRAULIC,POWER TRAIN

  The contact owns a 2009 Smart Fortwo. The contact stated that while driving at various speeds, the vehicle suddenly lost motive power. The vehicle was turned off, the contact waited, and then restarted the vehicle, and the vehicle operated as needed. The failure had occurred several times while driving. The contact stated that while depressing the brake pedal, the vehicle failed to brake immediately and drifted to the left. The brake pedal was depressed to the floorboard for the vehicle to come to a stop. The ABS warning light was illuminated. The vehicle was taken to the dealer, who diagnosed that the ABS was faulty and retrieved Diagnostic Trouble Codes: 1314 and C1443. The contact stated that the front brake pads were replaced by the dealer, and the rear brake pads were replaced by a certified mechanic. The vehicle was not repaired for the failure to accelerate, and the failure persisted. The vehicle was purchased on July 17, 2025, and the seller kept the repair issues with the vehicle from the contact and failed to provide information on the previous repairs. The contact stated that the failure recurred after retrieving the vehicle. The manufacturer was not informed of the failure. The failure mileage was 74,254.

• 08/16/2018· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE AND ENGINE COOLING). THE CONTACT CALLED SMART CENTER OF LOUISVILLE AT ((502) 896-4411, 4156 SHELBYVILLE RD, LOUISVILLE, KY 40207) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 08/13/2021· ENGINE AND ENGINE COOLING

  The contact owns a 2009 Mercedes-Benz Smart ForTwo. The contact stated while attempting to have the vehicle repaired under NHTSA Campaign Number: 18V273000 (Engine and Engine Cooling) but was denied repair due to the vehicle being a smart car. The manufacturer was informed of failure and told the contact that since the vehicle was not a Mercedes-Benz vehicle, they would not honor the recall repair. Parts distribution disconnect.

• 08/06/2014· TIRES,WHEELS

  THE VALVE STEMS ARE CRACKING AND IF THEY FAIL WHILE DRIVING A DRIVER MAY LOSE CONTROL. THE CRACKED VALVE STEMS WERE NOTICED WHEN THE WHEELS WERE REMOVED FOR SERVICE. PHOTOS ARE AVAILABLE IF NEEDED. *TR

• 08/03/2024· UNKNOWN OR OTHER

  When starting the car, the transmission will not respond to the shifter being put into any gear. A computer diagnostic says it is a communications issue. Mercedes, who sold the car to me new, refuses to do any repair work as they have discontinued Smart sales in the US. If the communications for the transmission fails during operation, this will be very dangerous. There are numerous reports on the internet of similar issues and owners trying to repair this themselves. Mercedes needs to be forced to repair what they have sold and represented. If this is a software update issue, who has the software to fix this issue? It is outrageous that NHTSA has not enforced these issues with Mercedes Benz of America.

• 08/03/2015· SUSPENSION

  THE LEFT FRONT COIL SPRING BROKE WHILE THE VEHICLE WAS SITTING IN THE DRIVEWAY. THIS IS THE SECOND COIL SPRING TO BREAK WITHIN A ONE YEAR PERIOD. UPDATED 09/10/15*LJ..UPDATED 12/02/15 *BF *CN

• 07/31/2017· UNKNOWN OR OTHER

  WHILE DRIVING MY VEHICLE, I HAD REACHED ABOUT 40 MILES PER HOUR AND THE CAR JUST DIED. I HADN'T DONE ANYTHING, THE CAR SIMPLY DIED. WHEN I FIRST ATTEMPTED TO TURN THE CAR BACK ON, IT WOULDN'T CRANK. THE LIGHTS, AIR EVERYTHING ELECTRICAL CAME ON, BUT THE CAR DIDN'T CRANK. AFTER WAITING A FEW MINUTES, I TRIED AGAIN AND LUCKILY THE CAR STARTED. BUT THIS SCARED ME AND SHOULD NOT HAVE HAPPENED.

• 07/31/2010· SERVICE BRAKES, HYDRAULICCrash

  I HAVE A 2009 SMART FOR TWO PASSION MODEL ON 7/21 I WENT TO GO INTO A PARKING PLACE AT A SMALL SHOPPING AREA AND THE BRAKES SLOWED ME DOWN BUT WOULD NOT ALLOW ME TO COME TO A COMPLETE STOP. I WAS GOING VERY SLOW BUT COULD NOT STOP THUS I HIT THE WINDOW OF A FURNITURE STORE. IT BROKE THE WINDOW AND THE ONLY DAMAGE TO MY CAR WEE CUTS IN THE PLASTIC FROM THE FALLING GLASS AS IT TOOK THEM 2 HOURS TO PICK IT UP. THE POLICE FILED A REPORT, NO ONE WAS INJURED, THE AIR BAGS DID NOT DEPLOY, AND I WENT SUCH A SHORT DISTANCE I DID NOT HAVE TIME TO THINK ABOUT PUTTING ON THE EMERGENCY BRAKE. THERE WAS NO WARNING THAT I AM AWARE OF. ALL I REMEMBER IS PUSHING THE BRAKE PEDAL ALL THE WAY TO THE FLOOR AND IT WOULD NOT STOP. THERE ARE FACTORY FLOOR MATS IN THE CAR AND I HAVE MANY PICTURES. IT HAS BEEN AT THE DEALER SINCE THE ACCIDENT AND THEY SAID THEY CANNOT FIND ANYTHING WRONG. SMART IS SUPPOSE TO SEND A REPRESENTATIVE TO SEE IT. I REALLY HAVE LITTLE FAITH IN THIS DEALERSHIP AND YOU CAN NEVER REACH ANYONE TO TALK TO ALL YOU GET ARE VOICEMAILS AND NO CALL BACK. FINALLY GOT THROUGH ON WED 7/28 WHEN THEY SAID THEY FOUND NOTHING WRONG. IT IS STILL AT SMART OF TREVOSE (PA). *TR

• 07/28/2016· UNKNOWN OR OTHER

  THE FACTORY INSTALLED ALARM FROM SMART GOES OFF FOR NO REASON INTERMITTENTLY. I AM NOT THE ONLY ONE. SO MANY PEOPLE HAVE THIS ISSUE. IT SHOULD BE RECALLED OR COMPLIMENTARY FIXED!

• 07/17/2018· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE AND ENGINE COOLING). THE CONTACT CALLED MERCEDES-BENZ OF SAN JOSE AT 408-214-3009 (LOCATED AT 3000 E CAPITOL EXPY, SAN JOSE, CA 95148) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 07/17/2018· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2009 SMART FORTWO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V273000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND CONFIRMED THAT THE PARTS WERE UNAVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 07/12/2020· UNKNOWN OR OTHER

  I AM WRITING TO YOU TO VOICE A COMPLAINT I HAVE WITH MERCEDES-BENDS USA, LLC'S RECALL OF THEIR SMART VEHICLES, RECALL CAMPAIGN # 2018060010. IT CALLS FOR REPLACEMENT OF THE REAR INSULATION MAT, THAT IF NOT REPLACE COULD POTENTIALLY CAUSE A FIRE IN THE ENGINE COMPARTMENT. I HAVE CALLED SEVERAL OF THE LOCAL MERCEDES-BENDS DEALERSHIPS AND HAVE FOUND THAT THE NEAREST DEALERSHIP THAT CAN REPLACE THE MAT IS EITHER IN SALT LAKE CITY, UTAH OR SEATTLE WASHINGTON. I RESIDE IN HELENA MONTANA WHICH IS 485 MILES FROM SALT LAKE AND 590 MILES FROM SEATTLE. THESE DISTANCES ARE TOTALLY IMPRACTICAL FOR ME TO DRIVE TO WITH THIS VEHICLE. PLEASE REQUIRE MERCEDES-BENDS TO ESTABLISH A SMART MAINTENANCE FACILITY IN CLOSER PROXIMITY TO HELENA.