2009 Mini Cooper

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/26/2020· AIR BAGS

  PASSENGER AIRBAG LIGHT STAYS ON AND IT IS DEACTIVATED WHEN I AM DRIVING. THIS APPEARS TO BE A KNOWN PROBLEM WITH NO RECALL IN EFFECT. I AM SEEKING BYPASS OPTIONS ONLINE TO BUY TO ALWAYS KEEP THE AIRBAG ON REGARDLESS OF HAVING A PASSENGER SITTING THERE. STILL VERY UNSAFE IF A KID SITS IN THAT SEAT. THIS NEEDS TO BE RECALLED

• 12/26/2017· ENGINE

  RECALL ID #167856 THE VEHICLE WAS IN MOTION ON A HIGHWAY AND IT BEGAN TO SMOKE, HEAT AND SMOKE BEGAN TO ARISE FROM THE ENGINE AFTER I JUST PICKED IT UP FROM CARMAX AND WAS REASSURED THAT THE CAR WAS FIXED AFTER PAYING +900 DOLLARS FOR MY VEHICLE FROM BEING IN THE SHOP TO NOT BE FIXED. VIN NUMBER IS [XXX] I BELIEVE MY COPPER IS APART OF THIS RECALL THAT OCCURRED IN 2012 I LEASED THE VEHICLE IN MARCH 2016 AND NOT EVEN A YEAR LATER IS MY CAR ABLE TO DRIVE AS THE INCIDENT DESCRIBED ABOVE OCCURRED SOMETIME IN FALL/WINTER 2016. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *PM *TR

• 12/26/2014· FUEL/PROPULSION SYSTEM

  THE FUEL LINE RUPTURED WHEN DRIVING MY CAR UNDER NORMAL CONDITIONS. THE CAR STARTED TO SMELL STRONGLY OF GASOLINE, SO I HAD IT TOWED TO THE DEALER RATHER THAN RE STARTING THE CAR. APPARENTLY, THIS IS A COMMON ISSUE IN MINI COOPERS DUE TO A POOR DESIGN PER THE AUTHORIZED MECHANIC. THE FUEL LINE SITS NEXT TO A HEATER LINE, AND A COMBINATION OF RUBBING AND HEAT CAUSED THE FUEL LINE TO RUPTURE. MINI IS AWARE OF THIS PROBLEM AS THEY HAVE CHANGED THE FUEL LINE DESIGN TO NOW HAVE A PROTECTIVE SLEEVE THAT PREVENTS ABRASION AND PROTECTS THE FUEL FROM HEAT. NOT ONLY DID THIS REPAIR COST ME $500, BUT IT SEEMS LIKE A MAJOR SAFETY CONCERN. WHY HAS THIS NOT BEEN A RECALL FOR MINI? I AM VERY CONCERNED AS A CONSUMER. *TR

• 12/15/2015· AIR BAGS

  TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STARTED THE IGNITION AND THE FRONT PASSENGER'S SIDE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THAT THE FRONT PASSENGER SIDE OCCUPANT DETECTION MAT WOULD NEED TO BE REPLACED WHICH INVOLVED DISABLING THE SEAT. THE VEHICLE WAS NOT INCLUDED UNDER NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE CONTACT MENTIONED THAT THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

• 12/14/2017· FUEL/PROPULSION SYSTEM

  AFTER TAKING A OFF RAMP FROM THE INTERSTATE THE CAR LOST POWER AND SPUTTERED AND JERKED. LATER THE SAME DAY. AFTER GETTING BACK ON THE INTERSTATE THE CAR AGAIN SPUTTERED, LOST ALL POWER AND I TOOK THE NEXT EXIT I WAS AFRAID I WAS GOING TO GET RAN OVER

• 12/10/2016· AIR BAGS

  TAKATA RECALL THE WARNING INDICATOR THAT MY PASSENGER AIR BAG IS OFF COMES ON FREQUENTLY (WITH OR WITHOUT PASSENGER). I AM AFRAID TO LET ANYONE RIDE IN MY CAR. WHEN I TOOK IT TO THE DEALER THEY SAID IT WAS AN INTERNAL FAILURE OF PASSENGER SIDE FRONT MAT SENSOR, THAT I HAD NOT DONE ANYTHING TO CAUSE THE PROBLEM, THAT THERE WAS A WORLDWIDE SHORTAGE OF THE PART, AND THAT IT IS A $1200.00 FIX. I DO NOT BELIEVE I SHOULD HAVE TO PAY FOR THAT REPAIR!! I WROTE TO BMW IN JULY---NO RESPONSE. THIS HAPPENS EVERY TIME I DRIVE SOMEWHERE---WITH OR WITHOUT PASSENGER. IT COMES ON AND OFF.....DRIVING OR STATIONARY, ALL SITUATIONS. THE ONLY DOCUMENTATION I HAVE IS COPY OF THE DEALERSHIP LABOR REPORT FROM THE DIAGNOSIS AND A COPY OF MY 7-19-2016 LETTER TO BMW SENT VIA EMAIL TO MINIUSA.COM. I HAVE NO WAY TO SCAN THOSE TO ATTACH.

• 12/09/2024· ELECTRICAL SYSTEM

  See attached document for complaint.

• 12/08/2015· AIR BAGS

  SAME ISSUE AS MANY OTHERS HAVE REPORTED. RECENTLY PURCHASED WITH 68K MILES. THE PASSENGER AIR BAG INDICATOR REMAINS ON NO MATTER IS A PASSENGER IS SITTING THERE OR NOT. AIR BAG SEAT MAT SENSOR ON THE PASSENGER SIDE NEEDS REPLACEMENT BUT THE DEALERSHIP REPORTED THAT THERE ARE NO SEAT REPLACEMENTS AVAILABLE OR EVEN IN PRODUCTION. NOR IS THERE A POSSIBLE DATE FOR A REPLACEMENT. THERE IS NO WAY TO MAKE THE CAR SAFE TO TRANSPORT PASSENGERS.

• 12/05/2014· VEHICLE SPEED CONTROL,SERVICE BRAKESCrash

  I WAS DRIVING ON THE HIGHWAY 12/04/2014 WITH CRUISE CONTROL ACTIVE GOING ABOUT 75 MPH. A TRUCK IN FRONT OF ME BECAME TOO CLOSE BECAUSE HE WAS GOING SLOWER. MY CAR BEGAN ACCELERATING AND I HIT THE BRAKE TO SLOW DOWN, AND DE-ACTIVATE THE CRUISE CONTROL. HOWEVER NOTHING HAPPENED AND MY MINI-COOPER CONTINUED TO ACCELERATE AND I HIT THE REAR END OF THE TRUCK. I USED THE CRUISE CONTROL ON/OFF AND TURNED OFF THE CRUISE CONTROL AND I STOPPED ACCELERATING. I CHANGED LANES TO PULL OVER, HOWEVER I HAD NO BRAKES. I EXITED THE HIGHWAY AS THERE WAS A BIG HILL, HOWEVER WITH NO BRAKES I WENT FLYING THROUGH AN INTERSECTION WHILE HONKING MY HORN, AND THROUGH THE RED LIGHT. THE ONLY OPTION WAS BACK ON THE HIGHWAY AFTER THE LIGHT AND I EVENTUALLY SLOWED DOWN AND THEN USED THE EMERGENCY BRAKE TO STOP. I REALLY PANICKED AND THOUGHT I WAS GOING TO DIE. THE TRUCK HAD NO DAMAGE, HOWEVER THE MINI-COOPER GOT A DENT ON THE HOOD. THIS ALSO HAPPENED BRIEFLY ABOUT A MONTH AGO, WHERE I HIT THE BRAKE AND MY MINI CONTINUED TO ACCELERATE WHILE IN CRUISE CONTROL, HOWEVER WHEN I TURNED OFF THE CRUISE CONTROL THAT TIME, THE BRAKES WERE FINE AND I HAD A CLOSE MISS OF REAR ENDING ANOTHER CAR. IN HINDSIGHT I SHOULD HAVE PUT MY 6 SPEED IN NEUTRAL OR TURNED OFF THE CAR. AT THE TIME, THESE OPTIONS DIDN'T COME TO ME IN A PANICKED STATE. *TR

• 12/05/2013· ENGINE

  TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING APPROXIMATELY 45 MPH WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE WATER PUMP WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. THE VIN WAS NOT AVAILABLE.

• 11/30/2018· AIR BAGS

  PASSENGER AIRBAG OFF LIGHT ON WHEN PASSENGER (OVER 25LBS) IS SITTING IN PASSENGER SEAT. AS IS THE SEAT BELT WARNING LIGHT IN SPEEDOMETER GAUGE. ALSO SRS RED WARNING LIGHT SHOWS ON TACHOMETER GAUGE. THESE WARNING INDICATORS ARE "ON" REGARDLESS OF WHETHER VEHICAL IS IDLE (NOT MOVING) OR WHEN AT SPEED( IN MOTION)

• 11/24/2016· ELECTRICAL SYSTEM,ENGINEFire

  WE PARKED THE CAR AND 3 HOURS LATER IS WAS ON FIRE. IT SEEMS TO HAVE EMANATED FROM THE POWER STEERING PUMP AREA BUT CANNOT TELL WITH ALL THE FIRE DAMAGE. THE CAR IS MOST LIKELY A TOTAL LOSS.

• 11/21/2013· ENGINEFire

  I WAS DRIVING HOME FROM WORK ON 21 NOVEMBER 2013 WHEN THE CHECK ENGINE LIGHT ON MY MINI CAME ON. I CALLED THE DEALER TO SCHEDULE THE APPOINTMENT. BY THE TIME I GOT OFF THE PHONE WITH THE DEALER, THE LIGHT TURNED OFF. AROUND 5 MILES FURTHER DOWN THE ROAD THE LIGHT CAME BACK ON AND THEN THE CAR ERUPTED IN FLAMES. I AM UNSURE WHERE ELSE TO FILE A COMPLAINT BUT I THOUGHT I WOULD BEGIN HERE. *TR

• 11/18/2014· ENGINE

  MY TIMING CHAIN WAS REPLACED AND HAS AN ISSUE WITH THE TENSION EXACTLY ONE YEAR LATER. *TR

• 11/13/2012· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED THAT AFTER INSTALLING A GPS SYSTEM IN THE VEHICLE HE BECAME AWARE THAT THE VEHICLE SPEEDOMETER WAS GIVEN THE INCORRECT READING. THE CONTACT MENTIONED THAT THE GPS READ 51MPH AND THE VEHICLE SPEEDOMETER READ 60 MPH, BUT VEHICLE WAS GOING SLOWER. THE DEALER STATED THAT THEY WERE NOT PROVIDING ANY ASSISTANCE GIVEN THAT THE VEHICLE SPEEDOMETER WAS IN TOLERANCE SINCE THE MARGIN OF ERROR ALLOWED WAS TEN PERCENT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 21,300 AND THE CURRENT MILEAGE WAS 22,000. UPDATED 11/29/12 *BF UPDATED 12/4/2012 *JS

• 11/12/2011· ENGINE AND ENGINE COOLING

  ENGINE LIGHT ON LOOSING POWER ENGINE SMOKING. *TR

• 11/07/2025· AIR BAGS,SEAT BELTS,SEATS

  The seatbelt and air bag warning light for the passenger front seat stays on.

• 11/04/2023· ELECTRICAL SYSTEM

  The car horn was going off randomly. I inspected the interior electrical panel on the passenger side of the car and it was damp. There is water getting into the passenger side of the car and infiltrating the panel causing this one issue and likely others. There is a recall for this problems in some places, but my vehicle is not included, currently.

• 11/04/2017· UNKNOWN OR OTHERFire

  AFTER SITTING IN THE PARKING LOT FOR 12 HOURS, THE CAR SPONTANEOUSLY BURST INTO FLAMES. THE CAR WAS A TOTAL LOSS.

• 11/04/2013· ENGINE

  THE VACUUM PUMP (ATTACHED TO EXHAUST CAM SHAFT) ON MY 2009 MINI COOPER JCW SEIZED ON THE HIGHWAY IN MOVING TRAFFIC (LUCKILY IN THE RIGHT HAND LANE) - VACUUM PUMP SEIZER LED TO EXHAUST CAM SHAFT FAILURE, WHICH LED TO MULTIPLE ENGINE PART FAILURE / ENGINE PUNCTURE (DESTROYED ENGINE AND TIMING CHAIN): DESTROYED ENGINE = NO POWER IN MOVING TRAFFIC = SERIOUS HAZARD. *TR

• 10/30/2015· AIR BAGS,SEAT BELTS

  WHILE I WAS DRIVING MY CAR, THE FRONT PASSENGER AIRBAG GOT DISCONNECTED AND THE LIGHT CAME ON. NOW THE LIGHTS INDICATING THAT THE AIRBAG IS OFF REMAIN ON AT ALL TIMES. AT THE EXACT SAME TIME THE LIGHT INDICATING THAT THE PASSENGER SEAT BELT WAS NOT FASTEN CAME ON AS WELL AND IT REMAINS ON AT ALL TIMES WHILE THERE IS NOBODY ON THE PASSENGER SEAT. THE LIGHT REMAINS ON EVEN IF I FASTEN THE SEATBELT. I WENT TO MINI DEALERSHIP AND WAS TOLD THAT I HAD TO PAY $140 IF I WANTED THEM TO INSPECT MY CAR, I DECIDED TO TAKE MY CAR TO AN INDEPENDENT MECHANIC INSTEAD WHO TOLD ME AFTER INSPECTION ($95 FOR THE INSPECTION) THAT THERE WAS AN ISSUE WITH THE SENSORS IN THE SEAT AND THAT THE ENTIRE SEAT HAD TO BE REPLACED ($1100 TO REPLACE IT). THIS IS A VERY SERIOUS ISSUE SINCE THE AIRBAG WILL NOT OPERATE IN CASE OF ACCIDENT. I KNOW SEVERAL MINI OWNERS HAVE EXPERIENCED THE SAME INCIDENT BUT MINI DEALERS REFUSE TO ASSUME THAT THERE IS AN ISSUE THAT NEEDS TO BE TAKEN CARE OF.

• 10/23/2013· ENGINE

  JUST PURCHASED USED 09 MINI , 2ND OWNER, ON START UP CAR SOUNDED ROUGH, DIESELING SOUND AND WAS TOLD BY DEALER THAT IT WAS COMMON. THEN WHEN DRIVING AT LOW SPEEDS OR WHEN SLOWING DOWN, TERRIBLE RATTLE SOUND. TOOK IT IN FOR AN OIL CHANGE, AND THE RATTLE WENT AWAY, BUT THEN CAME BACK SHORTLY BEFORE NEXT OIL CHANGE WAS DUE. TOOK IT IN FOR OIL CHANGE AGAIN, AND SOUND WENT AWAY AGAIN, BUT THEN CAME BACK WITHIN DAYS. FINALLY WAS ABLE TO GET AN APPT WITH THE CLOSEST AUTHORIZED DEALER, 50 MILES AWAY, BUT COULDN'T GET IN FOR TWO WEEKS IN ORDER TO GET A LOANER. THEY HAD IT FOR TWO DAYS, REPLACED THE TIMING CHAIN, NYLON PARTS WERE IN THE OIL PAN FROM THE GUIDES BEING SHREDDED. PICKED UP THE CAR ON THE THIRD DAY, AND FIR ALMOST ONE WEEK IT SEEMED FINE. JUST SHORT OF ONE WEEK OUT OF THE SHOP AND HEARD THE RATTLE AGAIN. BUT THEN IT WAS FINE, SO I THOUGHT IT WAS AN ANOMALY. ONE WEEK TO THE DAY SINCE PICKING IT UP FROM THE REPAIR, BARELY MADE IT INTO THE DRIVE FROM TAKING MY DAUGHTER TO SCHOOL. CALLED THE SHOP AND HAVE IT SCHEDULED TO GO BACK IN. HAVING THE CAR TOWED TO THE SHOP AS THE REPAIR TECH TREKS ME THAT IT IS "UNSAFE TO DRIVE." *TR

• 10/21/2013· ENGINE

  I AM BEING TOLD BY KNAUZ MINI REPAIR THAT THE TIMING BELT NEEDS TO BE FIXED. IT IS A $2000 REPAIR. IN LOOKING AT THE INTERNET, IT SEEMS THAT THIS IS A COMMON PROBLEM THAT CAN HAVE TRAGIC CONSEQUENCES. IN FACT, THERE IS ONE CLASS ACTION SUIT IN NJ ABOUT IT. MINI REFUSES TO TAKE RESPONSIBILITY TO A DESIGN FAILURE. SOMETHING NEEDS TO BE DONE. *TR

• 10/20/2019· STEERING,ELECTRICAL SYSTEM,ENGINEFire

  HELLO, YESTERDAY AFTERNOON I STARTED MY 2009 MINI COOPER AND NOTED THAT MY GAUGES SUDDENLY FAILED. THE TACH DROPPED TO ZERO. SUDDENLY I RECEIVED A TIRE PRESSURE WARNING LIGHT. I DECIDED I WOULD MOVE THE CAR TO A MORE FAVORABLE LOCATION TO LOOK UNDER THE HOOD. AS I PLACED THE CAR IN REVERSE I NOTED THAT MY POWER STEERING HAD FAILED. I STOPPED THE CAR IMMEDIATELY AND POPPED THE HOOD. I IMMEDIATELY NOTICED THE SMELL OF BURNING ELECTRICAL EQUIPMENT. I RAN DOWN TO THE BASEMENT TO GRAB A WRENCH TO DISCONNECT THE BATTERY. WHEN I RETURNED I COULD HEAR POPS AND CRACKS AND NOTED CHAR ON THE HOOD INTERIOR. THOUGH THE KEYS WERE OUT I CONTINUED TO HEAR POPS AND CRACKS AND FELT HEAT ACCUMULATING . I FINALLY GOT THE BATTERY DISCONNECTED AND THE POPPING STOPPED. AFTER SOME INVESTIGATION I FOUND THAT THE WIRING NEAR THE POWER STEERING MODULE WAS COMPLETELY BURNT OUT. THE CAR DROVE FINE THE DAY PRIOR. MY WIFE IS 38 WEEKS PREGNANT AND I AM SHAKEN BY THE IDEA THAT THIS COULD HAVE HAPPENED WHILE SHE WAS DRIVING THE DAY BEFORE.

• 10/18/2013· ENGINE

  WHILE TRAVELING ON A HIGHWAY AT @ 55MPH, THE COOLANT TEMPERATURE WARNING LIGHT ILLUMINATED YELLOW AND THEN RED ON MY 2009 MINI COOPER. I STOPPED THE VEHICLE AND OBSERVED THAT THE CLIPS WHICH SECURED THE LOWER RADIATOR HOSE IN PLACE HAD BROKEN AND THE RADIATOR HOSE WAS HANGING HORIZONALLY ACROSS THE FRONT OF THE VEHICLE, DRAGGING ALONG THE GROUND. A HOLE HAD BEEN WORN THROUGH THE HOSE AND THE COOLANT HAD LEAKED OUT. AFTER HAVING THE VEHICLE TOWED HOME ($285), I PURCHASED A NEW RADIATOR HOSE AND CLIPS FROM THE MINI DEALERSHIP ($160) AND HAD IT INSTALLED BY MY MECHANIC ($100). I ALSO LOST A 1/2 DAY OF WORK. A TOTAL LOSS OF OVER $600. BECAUSE OF POOR DESIGN AND/OR INFERIOR MATERIALS INTERNET RESEARCH SHOWS THAT THIS IS A COMMON MINI COOPER PROBLEM. I DID NOT HIT ANYTHING WHICH WOULD CAUSE THIS ISSUE, DESPITE MINI COOPER'S ATTEMPTS TO PLACE BLAME ON THE DRIVER'S WHO EXPERIENCE THIS ISSUE. IF MINI COOPER WOULD PROPERLY ADDRESS THIS ISSUE AND REMEDY THE SITUATION, IT WOULD SPARE COUNTLESS DRIVER'S FROM BEING STRANDED ON THE SIDE AND THE EXPENSE OF FIXING WHAT SHOULD HAVE BEEN REMEDIED BY A SERVICE BULLETIN OR RECALL. *TR

• 10/17/2012· ENGINE

  I WAS TRAVELING ON NJ TURNPIKE AND MY VEHICLE BLEW UP. CATASTROPHIC ENGINE FAILURE. WATER PUMP ALSO BROKE. *TR

• 10/14/2010· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2009 MINI COOPER. WHILE DRIVING APPROXIMATELY 62 MPH, THE CONTACT NOTICED THE SPEEDOMETER WAS DISPLAYING A READING OF 70 MPH. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THE SPEEDOMETERS ALL OF THE VEHICLES WERE 10% OFF AND THERE WAS NO REMEDY. THE FAILURE MILEAGE WAS 200 AND THE CURRENT MILEAGE WAS APPROXIMATELY 21,000. THE VIN WAS UNAVAILABLE.

• 10/05/2016· AIR BAGS

  MY AIRBAG SENSOR LIGHT IS ON CONTINUOUSLY AND MY MECHANIC DIAGNOSED IT AS PASSENGER SIDE AIRBAG SENSOR MAT PROBLEM. THIS IS THE SAME PROBLEM THAT RESULTED IN A RECALL FOR 2005-2008 MODELS IN THE NHTSA CAMPAIGN NUMBER 15V205000. I'VE CALLED MY LOCAL BMW/MINI SERVICE DEPARTMENT, BUT THEY SAY IT'S NOT PART OF THE RECALL AND THERE'S NOTHING THEY CAN DO.

• 10/03/2018· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  LIGHT IS COMING ON AND TRANSMISSION SHIFTS SMOOTHLY BUT WHEN YOU DECELERATE IT BUCKS DOWN. IT HAPPENS ANYWHERE ON THE ROADS WHEN DRIVING AND YOU DECELERATE. THE LIGHT THAT INDICATES ISSUE WITH TRANSMISSION, IN THE BOOK IT SAYS I WON'T BE ABLE TO SHIFT OUT OF PARK BUT THERE IS NO ISSUE SHIFTING OUT OF PARK, SO NOT SURE IF IT IS CONSIDERED ELECTRICAL OR IF IT IS POWERTRAIN

• 10/01/2012· ENGINE

  DURING MY COMMUTE TO WORK ON 9/27/12, MY CAR COMPLETELY DIED WHILE I WAS DRIVING IN THE MIDDLE LANE OF THE FREEWAY. THE CAR WAS TOWED TO A GARAGE, WHERE IT WAS FOUND TO BE LEAKING AN EXCESSIVE AMOUNT OF OIL. DURING INSPECTION, IT WAS ASSESSED THAT THE TIMING CHAIN "JUMPED" AND CAUSED A CATASTROPHIC ENGINE FAILURE. AT THE TIME OF THIS INCIDENT THE CAR HAD 54K MILES ON IT AND THERE WERE ABSOLUTELY NO WARNING SIGNS PRIOR TO THE FAILURE (I.E. LEAKING OIL, ENGINE RATTLE, ETC...). FURTHERMORE, SINCE I PURCHASED THE CAR IN FEBRUARY 2012, I HAVE PERFORMED REGULAR MAINTENANCE ON THIS CAR (NEW BRAKES, TIRES, ALIGNMENT, REGULAR SYNTHETIC OIL CHANGES) TO ENSURE IT STAYS IN GOOD DRIVING CONDITION. APPARENTLY, THIS HAS BEEN A FREQUENTLY REPORTED ISSUE WITH MINI COOPER AND THE PROBLEM COULD HAVE EASILY RESULTED IN A FATAL CAR ACCIDENT WHILE I WAS DRIVING ON THE FREEWAY! THE ESTIMATED REPAIR COST (WITH LABOR) FOR THIS FAILURE IS APPROX 10K!!! MINI SHOULD BE HELD RESPONSIBLE FOR THIS FAULTY CRAFTSMANSHIP. A 3 YR CAR WITH 54K MILES SHOULD ABSOLUTELY NOT NEED TO HAVE A NEW ENGINE REPLACED!!! *TR

• 09/30/2020· AIR BAGS

  THE AIRBAG FOR THE PASSENGER SEAT STOPPED WORKING 3 YEARS AGO. I CHECKED SEVERAL TIMES FOR A RECALL BUT COULDN'T FIND ANYTHING. I WENT TO A DEALERSHIP AND WAS TOLD THAT IF THERE ISN'T A RECALL, THERE WAS NOTHING MINI COOPER COULD DO ABOUT IT. I TOOK IT TO A MECHANIC AND IT WILL BE OVER 900.00 TO FIX THE PROBLEM. ISN'T IT THE RESPONSIBILITY OF THE CAR MANUFACTURER TO FIX SOMETHING THAT JUST STOPPED WORKING (NO ACCIDENTS OR ANY REASON), ESPECIALLY SINCE IT IS SUCH A MAJOR SAFETY ISSUE?

• 09/30/2015· AIR BAGS

  THE PASSENGER SIDE AIRBAG WARNING LIGHT WENT ON AT ABOUT 28,000 MILES. FROM WHAT I READ ONLINE THIS HAS HAPPENED WITH OTHER MINI MODELS, WHICH HAVE BEEN RECALLED FOR THIS REASON (PRIOR YEARS). IT SEEMS TO MEAN THAT THE SENSOR IS NOT WORKING AND HAS TO BE REPLACED OR THE PASSENGER SIDE AIRBAG WILL NOT INFLATE IN AN ACCIDENT.

• 09/29/2016· ENGINE

  BOUGHT A 2009 MINI S FOR MY DAUGHTER IN AUGUST OF 2015 WITH 36K MILES ON IT. SINCE THEN I'VE SPENT OVER $5000 IN REPAIRS AND THE CAR IS CURRENTLY PARKED AND NOT BEING DRIVEN BECAUSE NOW THE TIMING CHAIN NEEDS TO BE REPLACED. MY CAR IS 5 MONTHS PAST THE "WARRANTY" PERIOD FOR THIS SERVICE BULLETIN CAMPAIGN, AND THIS REPAIR WILL LIKELY COST ANOTHER $3000OR MORE I'VE PAID FOR TO REPAIR THE OIL LEAK IN THE TURBO LINE AS WELL AS THE WATER PUMP FAILING, AND REPLACED THE VALVE COVER DUE TO OIL LEAKING, ALL WELL KNOWN ISSUES WITH THIS CAR. THE TIMING CHAIN AND TENSIONER ISSUES ARE WELL KNOWN BY BMW/MINI AS WELL AND THERE IS NO RECOURSE FOR OWNERS OF THESE CARS AT THIS POINT. MY CAR ONLY HAS 48,000 MILES ON IT! THERE IS NO REASON FOR ALL OF THESE PARTS TO BE FAILING THE WAY THEY ARE. I WILL HAVE SPENT MORE THAN DOUBLE WHAT I PAID FOR THIS CAR BEFORE ITS DRIVABLE AGAIN. VERY UNHAPPY WITH MINI!!!!!

• 09/27/2019· UNKNOWN OR OTHER

  CHECK ENGINE LIGHT AC NOT WORKING WATER PUMP

• 09/21/2019· ELECTRONIC STABILITY CONTROL (ESC)

  ADVISED FROM MECHANIC THAT WATER IS GETTING DOWN FROM THE FRONT AREA BELOW THE WINDSHIELD AND IS CAUSING THE BODY CONTROL MODULE AND OTHER ELECTRONICS TO SHORT OUT. GOT TO WHERE THE CAR WOULDN'T EVEN TURN OVER TO TRY AND START. HAD TO HAVE OVER $3450 WORTH OF REPAIRS DONE AND WAS TOLD THEY SPOKE WITH MINI AND THIS IS A KNOWN ISSUE, BUT THEY HAVEN'T DONE ANYTHING ABOUT IT. WAS TOLD THIS WILL HAPPEN AGAIN IF NOT FIXED. WAS TOLD TO TAKE TO MINI, BUT THEY WON'T DO ANYTHING ABOUT IT.

• 09/21/2019· AIR BAGS

  MY PASSENGER SIDE AIRBAG LIGHT STAYS ON CONSTANTLY, EVEN IF SOMEONE IS SITTING THERE

• 09/21/2016· UNKNOWN OR OTHERFire

  CAR WAS BOUGHT BRAND NEW AND TAKEN TO THE DEALERSHIP FOR SERVICE. INFACT IT WAS SERVICED JUST A FEW THOUSAND MILES BEFORE THIS HAPPENED. MY MOTHER WAS DRIVING ON THE HIGH WAY COMING HOME FROM WORK THEN IT SPONTANEOUSLY COMBUSTED AND EXPLODED. HAD SHE NOT NOTICED THE FLAMES SHE WOULD HAVE DIED. THIS IS NOT OKAY.

• 09/18/2023· ELECTRICAL SYSTEM

  The contact owns a 2009 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the parking brake warning light and the tire pressure warning light was illuminated. Additionally, the contact stated that after the front driver’s and passenger side doors were closed, the windows failed to readjust. The vehicle was not diagnosed or repaired. An undisclosed dealer was contacted and confirmed that parts were not available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. VIN tool confirms parts not available.

• 09/16/2016· ENGINEFire

  TURBO OIL LINE LEAKS AND DRIPS ON TURBO MANIFOLD CAUSING BURNING OIL SMELL AND SMOKE. THE ENGINE CAUGHT A SMALL FIRE, LUCKY I WAS PARKED ON SIDE OF A HIGHWAY ROAD UP IN THE MOUNTAINS. (NO FIRE STATIONS OR VERY LITTLE TRAFFIC) I SMELT SOMETHING BURNING UNDER TO HOOD WHEN IT HAPPENED AND CAUGHT THE FLAMES IN TIME TO EXTINGUISH THE FIRE. 2 SEATTLE AREA MINI DEALERS STATE THAT THIS IS A PROBLEM WITH ALL THE TURBO ENGINES IN THIS CLASS. THEY WANT YOU TO PAY FOR THIS REPAIR IT'S A $1300 FIX. I BELIEVE THAT MINI/BMW NEEDS TO TAKE RESPONSIBILITY AND REPAIR/RECALL THE TURBO OIL LINE BECAUSE IT POSES A SAFETY ISSUE THE CAR COULD CATCH FIRE AND POTENTIALLY INJURE SOMEONE CAUSE AN ACCIDENT, OR WORSE DEATH.

• 09/16/2015· AIR BAGS

  FRONT PASSENGER AIRBAG SIGN WAS COME OUT, EVEN THOUGH PASSENGER IS SEATING AND GETTING SEAT BELT. ANY DAMAGE DIDN'T BE GOTTON ON THE PASSENGER SEAT, IT IS JUST SUDDENLY APPEARED. IT WILL MAKE SERIOUS SITUATION WHEN I GET ACCIDENT. AIRBAG IS REALLY RELATED WITH SAFETY. I STRONGLY BELIVE THAT IT HAS TECHNICAL PROBLEM AT MINI. THIS PROBLEM WILL COME OUT MORE AND PEOPLE MAY BE INJURED BY THIS PROBLEM. I SAW ARTICLE ABOUT AIRBAG PROBLEM AT MINI, AND MINI MADE A PROGRAM THAT RECALLS TO FIX AIRBAG MAT. HOWEVER, IT AFFECTS TO UNTIL 2008MINI. I DON'T THINK THIS PROBLEM ONLY AFFECTS TO UNTIL 2008 MINI. BWM MINI HAVE TO INVESTIGATE NEWER MODEL AND RECALL THE PASSENGER SEAT AIRBAG AS WELL.

• 09/11/2019· AIR BAGS

  PASSENGERS OC3 SEAT OCCUPANCY MAT FAILED CAUSING THE PASSENGER SIDE AIR BAG TO BE DEACTIVATED. MINI HAD EXTENDED THE WARRANTY ON THIS FOR 10 YEARS AND 120,000 MILES. MY MINI WAS LESS THAN 10 YEARS OLD BUT DID HAVE 130,000 MILES ON 4/3/2019 WHEN I TOOK IT INTO THE DEALER. MINI HAS REFUSED TO REPLACE THIS DEFECTED PART EVEN THOUGHT THEY KNOW IT WAS DEFECTIVE BECAUSE THEY EXTENDED THE WARRANTY. THEY ALSO KNOW THAT ON PREVIOUS YEARS MODELS THEY WERE FORCED TO RECALL THIS PART AS I ALSO OWN A 2006 MINI THAT WENT BAD AND IT TOOK OVER A YEAR BEFORE THEY FINALLY DID A RECALL. MINI DOES NOT HAVE A WORKABLE CUSTOMER RELATIONS SYSTEM THAT ALLOWS THE CUSTOMER TO APPEAL THIS SAFETY DEFECT REPLACEMENT REJECTION. THE BOTTOM LINE IS THAT MINI KNOW THEY HAVE A DEFECTIVE SAFETY SENSOR AND HAVE A HISTORY OF THIS BEING A BAD PART BUT ARE UNWILLING TO DO THE RIGHT THING AND REPLACE IT. THEY INSTEAD WANT THE CUSTOMER TO SPEND OVER $1,000 DOLLARS TO REPLACE IT FOR THEIR OWN SAFETY. THIS IS A BAD COMPANY DYNAMIC AND SHOWS NO CORPORATE RESPONSIBILITY.

• 09/11/2016· ENGINE

  MY 2009 MINI COOPER HARDTOP WITH 6 SPEED MANUAL TRANSMISSION CONSUMES ONE QUART OF ENGINE OIL PER 1000 MILES. THIS IS TRULY UNACCEPTABLE. IT IS AN ONGOING PROBLEM AND EXPENSE THAT IS VERY ANNOYING. NOT TO MENTION THE SAFETY SIDE OF IT AND THE POSSIBILITY OF BURNING OUT THE ENGINE. BMW/MINI NEEDS TO TAKE RESPONSIBILITY AND REBUILD AND REPAIR THE ENGINE TO CORRECT THIS VERY IMPORTANT PROBLEM.

• 09/02/2025· AIR BAGS

  The contact owns a 2009 Mini Cooper. The contact stated that while driving at an undisclosed speed, the seat belt warning light illuminated even though there was no passenger seated in the passenger’s seat. The contact stated that the warning light remained illuminated with the passenger’s seat occupied and the seat belt properly fastened. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 92,000.

• 08/31/2010· ELECTRICAL SYSTEM,AIR BAGS

  I HAVE A MINI COOPER 2009 WHICH TODAY MARKS A YEAR OF PURCHASE, FOR ABOUT SEVEN MONTHS HAS BEEN LEADING THE WARRANTY SERVICE DUE TO FAULTY ELECTRICAL SYSTEM, AIR BAG PASSENGER AND THE CAR TURNS OFF WHILE USING. UNFORTUNATELY TO GET THE CAR TO SERVICE NEVER CAN DIAGNOSE THE FAULT. *TR

• 08/28/2023· ELECTRICAL SYSTEM

  The contact owns a 2009 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 08/27/2013· AIR BAGS

  RE: 2009 MINI COOPER AIR BAG CONTROL UNIT ON JUNE 19TH, 2013, AT @ 54,200 MILES, THE AIR BAG WARNING LIGHTS ILLUMINATED ON THE TACHOMETER GAUGE AND CENTER SPEEDOMETER GAUGE AND AN OVERHEAD LIGHT WARNED THAT "PASSENGER AIRBAG IS OFF". ON AUGUST 26, 2013, AT 61,396 MILES, THE MORRISTOWN, NJ MINI COOPER DEALERSHIP CHARGED ME $140 FOR THE DIAGNOSES OF THIS ISSUE. INDICATED ON RECEIPT THAT "MRS MODULE HAS AN INTERNAL FAULT..... FAULT CODE 93D7 INTERNAL CONTROL UNIT FAULT.... AIR BAG CONTROL UNIT WILL NEED TO BE REPLACED AND PROGRAMMED.... PARTS AND LABOR COSTS $1100." SERVICE DEPARTMENT INFORMED ME THAT PART WAS OUT OF WARRANTY. RESEARCH SHOWS THAT THIS IS AN ONGOING PROBLEM AND THAT EARLIER MODEL YEARS HAVE HAD CORRECTIVE ACTIONS PROVIDED AT NO EXPENSE TO THE CONSUMER. NEEDS TO BE EXTENDED TO THE 2009 MODEL YEAR. *TR

• 08/25/2015· AIR BAGS

  PASSENGER AIR BAG LIGHT (YELLOW CEILING LIGHT) WILL INTERMEDIATELY TURN AND STAY ON TO INDICATE AIR BAG IS OFF WHEN A PASSENGER IS IN THE SEAT.

• 08/18/2015· ENGINE

  THE TIMING CHAIN TENSIONER ON MY MINI WAS CHANGED AS PART OF SILENT SERVICE BULLETIN WHICH AUGHT TO BE A RECALL. BY THE TIME IT WAS REPLACED IT WAS TOO LATE, NOW A YEAR LATER MY TIMING CHAIN IS OUT OF SPEC AND RATTLING AWAY IN MY CAR WITH A REPLACEMENT SET TO COST ABOUT $2000 FOR PARTS THAT MINI CLAIMED WOULD LAST THE LIFE OF THE VEHICLE. MINI REFUSES TO REPLACE ANY PARTS UNTIL THEY'VE FAILED SO I'M STUCK EITHER PAYING OUT OF POCKET AND NEVER SEEING A DIME BACK, OR RISKING LIFE AND LIMB ON THE ROAD UNTIL THESE PARTS FAIL SO THAT MINI CAN OWN UP TO THEIR MISTAKE...

• 08/12/2015· AIR BAGS

  AIR BAG FAILURE WARNING LIGHT COMES ON AND STAYS ON. BMW-MINI HAS RECALLS FOR MODEL YEARS UP TO 2008, BUT REFUSES TO ACKNOWLEDGE PROBLEM EXISTS ON 2009 AND NEWER CARS (SOME 2009'S WERE BUILT IN 2008, IN THE AFFECTED RECALL TIME FRAME, BUT BECAUSE THEY WERE DESIGNATED 2009, THESE CARS HAVE BEEN IGNORED)

• 08/12/2010· POWER TRAIN,EQUIPMENT

  A 2009 MINI COOPER CLUTCH WAS DEFECTIVE WAS REPLACED IN MAY OF 2010 AND IN AUGUST OF 2010 THE CLUTCH WENT AGAIN AND THIS TIME BURNT THE FLY WHEEL. THE CAR HAD TO BE TOWED SAFETY OF PASSENGER WAS COMPROMISED. *TR