2009 Hyundai Santa FE

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2016· FUEL/PROPULSION SYSTEM

  MY FUEL GAUGE IS NOT WORKING NOW THE ENGINE LIGHT HAS COME ONE

• 12/29/2015· POWER TRAIN,SERVICE BRAKES,ENGINE

  VEHICLE INSPECTION PERFORMED BY MANUFACTURE CERTIFIED TECHNICIAN. TWO ISSUES WERE RECOMMENDED BY THE TECHNICIAN: A) NEW TIRES. ALL 4 TIRES CURRENTLY ON THE VEHICLE ARE AROUND 5 YEARS OLD (BASED ON THE DOT DATE OF MANUFACTURE), AND HAVE BEEN DRIVEN FOR OVER 100,000 MILES (BASED ON ODOMETER READINGS FROM 2010 AND CURRENT). B) NEW REAR BRAKE PADS AND ROTORS. THE INSPECTION REVEALED REAR PADS AROUND 3 MM, AND ROTORS SHOWING RUST. THESE ARE SAFETY ISSUES, WHICH SHOULD BE ADDRESSED BEFORE SELLING THE VEHICLE. REGULAR MAINTENANCE HAS BEEN PERFORMED ON THIS VEHICLE, BUT EXISTING RECORDS DO NOT SPECIFY THAT RECOMMENDED FLUID/TIMING BELT REPLACEMENTS WERE PERFORMED.

• 12/29/2013· STRUCTURE,VEHICLE SPEED CONTROLCrash

  ENTERED HORSESHOE CASINO PARKING GARAGE AND TURNED INTO PARKING LEVEL. AS I FOLLOWED FORD TAURUS, HYUNDAI ENGINE CHANGED FROM NORMAL SPEED TO A ROARING ACCELERATION IN AN INSTANCE. I COULDN'T BRAKE IT TO A STOP AND IT RAMMED THE REAR END OF THE TAURUS. DAMAGE TO THE SANTE FE WAS LIMITED TO FRONT BUMPER DAMAGE WHILE THE BACK END OF THE TAURUS WAS DRIVEN FORWARD AND TORN UP. MY HUSBAND THOUGHT THE CRUISE MIGHT HAVE GONE ON; BUT, HE DECIDED THE ACCELERATION WAS TOO RAPID FOR THE CRUISE. HE WAS IN THE PASSENGER SEAT. WE DROVE HOME WITHOUT ANY FURTHER TROUBLE. *TR

• 12/28/2022· ELECTRICAL SYSTEM

  Alternator failed Due to valve gasket leaking, Hyundai issued a recall during time vehicle was in probate, I did not receive notification and had the valve gasket, manifold gasket, and alternator replaced. In June 30, 2022, When I learned the recall had been issued I filed for reimbursement of repair costs, Approximately $1900. The reimbursement claim was transferred to warrant department. The claim was transferred to claim reimbursement 8/29/2022, I received an email stating it would be 3-4 weeks for reimbursement. I called 9/29 and was informed it would be 120 days from submission date, On 12/6 additional information was needed. I was not notified, and saw the status changed, and called for update on 12/13. I submitted the same day. On 12/22, I received the repayment notification, but not the amount. I called on the phone for 4 hours for amount $727.74 breakdown missing $410 of labor costs.

• 12/28/2020· AIR BAGS

  THE AIR BAG LIGHT STAYS ON WHILE DRIVING. UNKNOWN CAUSE OF THE PROBLEM. RECALL WAS DONE PRIOR TO BUYING THE CAR TO MY KNOWLEDGE. BUT I ASSUME THAT THE PART WENT OUT AGAIN.

• 12/27/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STOPPED ACCELERATING SUDDENLY. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIANS REPLACED THE ACCELERATOR COMPUTER MODULE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

• 12/23/2015· UNKNOWN OR OTHERFire

  VEHICLE CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. VEHICLE HAD NOT BEEN DRIVEN FOR APPROXIMATELY 4 HOURS.

• 12/20/2015· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  I NOTICED THAT WHEN I WAS IN PARK, THE CAR WOULD JUST SHUT OFF. THIS HAPPENED THREE TIMES WITHIN A FEW WEEK'S TIME. I WAS CONCERNED AND WONDERED IF THE CAR WOULD EVER JUST SHUT OFF WHILE I WAS DRIVING ON THE FREEWAY OR A BUSY STREET. TO MY HORROR, IT HAPPENED! A FEW DAYS AGO I WAS TURNING INTO A PARKING LOT AND THE CAR JUST SHUT OFF!...THERE WAS A CAR BEHIND ME THAT CAME TO A SCREECHING HALT! AGAIN MY GREATEST FEAR IS THAT THE CAR WILL STALL ON ME WHILE THE VEHICLE IS IN MOTION AND IF THAT HAPPENS ON A ROAD WHERE CARS ARE TRAVELLING AT HIGH SPEEDS, THEN I WOULD PROBABLY NOT LIVE TO TELL THE STORY.

• 12/20/2010· SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

  WHILE TURNING THE STEERING WHEEL OF MY SUV TO PULL INTO A PARKING SPACE IN A LARGE GROCERY STORE PARKING LOT, THE SUV INVOLUNTARILY ACCELERATED FORWARD AT A GREAT AMOUNT OF SPEED. I APPLIED THE BRAKE FIRMLY, BUT THE SUV CONTINUED TO SPEED FORWARD INTO THE PARKING SPACE. MY FEAR WAS THAT THERE WAS A CAR IMMEDIATELY IN FRONT OF ME THAT WAS PARKED FACING IN. I ASSUMED THAT THE ONLY WAY I WAS GOING TO STOP WAS IF I CRASHED HEAD ON WITH THE CAR OPPOSITE ME. FORTUNATELY, I HAD THE BRAKE ALMOST TO THE FLOOR OF THE SUV WHEN IT FINALLY LURCHED TO A STOP. I THEN CALLED THE DEALERSHIP WHO SENT A TOW TRUCK TO PICK UP THE VEHICLE. IT HAS BEEN AT THE DEALERSHIP SINCE APPROXIMATELY 4:30 P.M. ON FRIDAY, DECEMBER 17, 2010. THE DEALERSHIP SAID THEY WOULD LOOK AT IT TODAY, MONDAY, DECEMBER 20. I HAVE YET TO HEAR FROM THEM THIS MORNING.

• 12/16/2009· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING BETWEEN 75-80 MPH THE VEHICLE BEGAN TO ACCELERATE WITHOUT INTENTION. EVEN AFTER REPEATED BRAKE APPLICATION THE VEHICLE WOULD NOT DECELERATE. HE HAD TO SHIFT THE VEHICLE INTO NEUTRAL TO DECELERATE. 5 DAYS PRIOR TO THE FAILURE THE VEHICLE ACCELERATED WHILE DRIVING BETWEEN 25-35 MPH IN HEAVY TRAFFIC. THERE WAS NOT INTERFERENCE BETWEEN THE FLOOR MAT AND THE ACCELERATOR PEDAL. THE TECHNICIAN HAVE INSPECTED THE VEHICLE, BUT COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000.

• 12/15/2016· ENGINE

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE HESITATED AND THE ENGINE STALLED. THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS LATER TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS WERE AFTERMARKET AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 87,371.

• 12/14/2015· FUEL/PROPULSION SYSTEM

  FUEL LEVEL STOPPED WORKING, CHECK ENGINE LIGHT CAME ON. MECHANIC SAID THE CODE CALLED FOR REPLACEMENT OF FUEL LEVEL SENSORS. $500 REPAIR AND THE PROBLEM WAS NOT CORRECTED. I NEVER KNOW HOW MUCH GAS I HAVE AND I CAN NEVER PUT MORE THAN 8 GALLONS IN WHEN I FUEL UP. BUT GAS GAUGE WILL GO UP TO HAVE THEN DROP TO EMPTY THEN GO UP TO HALF A TANK. VERY HORRIFIC. CHECK ENGINE LIGHT IS ON WHICH WILL CAUSE ME TO FAIL INSPECTION.

• 12/08/2021· STRUCTURE

  Passenger front and driver side rear door handle breaking off. Normal pulls have cause the handle to come in hand.

• 12/07/2015· VISIBILITY

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 30 MPH, THE REAR WINDOW DEFROSTER WAS ACTIVATED AND THE ENTIRE REAR WINDSHIELD EXPLODED, CAUSING GLASS TO SHATTER INSIDE THE VEHICLE. PRIOR TO THE FAILURE, THE VEHICLE REMAINED PARKED FOR THIRTY MINUTES WITH THE HEATER AND DEFROSTER ACTIVATED. THE OUTSIDE TEMPERAURE WAS 27 DEGREES. THE CONTACT SCHEDULED AN APPOINTMENT WITH AN INDEPENDENT MECHANIC WHO SPECIALIZED IN WINDSHIELD REPLACEMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

• 12/06/2018· VISIBILITY/WIPER

  SUN ROOF EXPLODED. NO APPARENT REASON. STATIONARY PARKED.

• 12/05/2016· FUEL SYSTEM, GASOLINE,FUEL/PROPULSION SYSTEM

  FAULTY FUEL SENSOR GAUGE. WHEN TRYING TO FILL AN EMPTY TANK THE PUMP SHUTS OFF AFTER ONLY A COUPLE OF GALLONS. IF I WASN'T PAYING ATTENTION I WOULD HAVE THOUGHT IT WAS FULL. I'VE SEEN COMPLAINTS THAT THE FUEL GAUGE STOPS WORKING ON THIS CAR AT SIMILAR MILEAGE, IF THAT HAPPENS TOO I WON'T KNOW HOW MUCH GAS IS IN MY CAR. I COULD THEN RUN OUT OF GAS WHILE DRIVING AND LOSE POWER STEERING. THIS IS AN ACCIDENT HAZARD. *TR

• 12/04/2013· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE ATTEMPTING TO ACCELERATE, THE ACCELERATOR PEDAL WOULD BECOME STUCK AND IN ORDER TO RELEASE IT, THE BRAKES NEEDED TO BE ENGAGED SIMULTANEOUSLY. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 86,000. UPDATED 01/07/14*LJ

• 12/04/2012· AIR BAGS

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE PASSENGER SIDE AIR BAG LIGHT WOULD NOT ILLUMINATE WITH THE PASSENGER SEAT OCCUPIED. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT DIAGNOSED FOR THE FAILURE. THE TECHNICIAN ADVISED THE CONTACT THAT THE SENSOR FOR THE PASSENGER SIDE AIR BAG COULD HAVE NEEDED REPLACEMENT BUT A DIAGNOSTIC TEST WAS REQUIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V354000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 68,900.

• 12/03/2015· AIR BAGS

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE PARKED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000. THE VIN WAS NOT AVAILABLE.

• 12/03/2014· ENGINE,FUEL/PROPULSION SYSTEM

  ENGINE LIGHT CAME ON AND THEN FUEL WARNING LIGHT CAME ON EVEN THOUGH I HAD A LEAST 1/2 TANK OF GAS. FILLED UP MY GAS TANK, ALL LIGHTS WERE OUT. WHEN I HAD APPROXIMATELY 1/2 TANK AGAIN, THE ENGINE AND FUEL LIGHTS CAME ON. I BROUGHT MY CAR TO MY MECHANIC AND WAS TOLD THE 2 FUEL SENSORS NEED TO BE REPLACED AT A COST OF OVER $350.00. UPON ONLINE RESEARCHING, I LEARNED THAT THERE ARE MANY OTHERS WHO ARE EXPERIENCING THE SAME PROBLEM. I FEEL THAT BECAUSE THIS IS HAPPENING TO OTHER HYUNDAI OWNERS, IT IS A PROBLEM THAT HYUNDAI NEEDS TO REPAIR AT NO COST TO THE OWNER OF THESE VEHICLES. IN MY CASE, I NEED TO BE REIMBURSE THE COST OF THE REPAIR. *JS

• 12/01/2015· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  THE ENGINE LIGHTS STAYS ON WHEN YOU FILL THE GAS TANK IT STILL SAYS EMPTY WHEN DRIVING EVERYTHING WILL SHUT OFF THIS IS FOR THE SECOND TIME IN LESS THAN A YEAR

• 11/30/2016· EXTERIOR LIGHTING

  THE HEADLIGHTS ARE SO POOR THAT WE DO NOT FEEL SAFE DRIVING AT NIGHT. ON LOW BEAMS, IT ALMOST SEEMS AS IF THE LIGHTS ARE TURNED OFF. ON HIGH BEAMS, VISIBILITY IS ADEQUATE BUT, OF COURSE, WE CANNOT KEEP HIGH BEAMS ON ALL THE TIME. I CALLED THE DEALER AND THEY SAID THEY COULD REPLACE THE BULBS WITH NEW ONES. HOWEVER, THEY COULD NOT REPLACE THE BULBS WITH BRIGHTER ONES SUCH AS LEDS. *TR

• 11/26/2015· UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  ONLY 85K MILES ON THE HYUNDAI USED FOR NORMAL DRIVING. THE FUEL GAUGE/SENSORS HAVE BEGUN ACTING ERRATIC. FILLED THE GAS TANK AND GAUGE SHOWED FULL. VERY NEXT MORNING GAUGE DOWN TO A QUARTER TANK. PURCHASED GAS AND ONLY NEEDED 3 GALLONS. FUEL GAUGE ALL OVER THE PLACE AND NOT MEASURING GAS CORRECTLY. CREATES AN UNSAFE CONDITION AS DRIVER DOES NOT RELIABLY KNOW HOW MUCH FUEL IS AVAILABLE. MANY ISSUES LIKE THIS ACCORDING TO POSTS ON INTERNET. HYUNDAI HAS A SYSTEMATIC PROBLEM AND SHOULD REPAIR FREE OF CHARGE.

• 11/25/2015· FUEL/PROPULSION SYSTEM

  AFTER FILLING VEHICLE WITH FUEL, FUEL GAUGE SHOWED TANK EMPTY AND YELLOW LIGHT ON DASH SHOWS FUEL EMPTY. FUEL GAUGE RECOVERED TO SHOW 1/2 FULL, THEN DISPLAYS ERRATIC RESULTS. ONLINE FORUMS SHOW DEFECTIVE FUEL SENSOR WITH A LARGE NUMBER OF HYUNDAI VEHICLES. THERE SHOULD BE RECALL ON THIS ISSUE. DRIVERS MAY THINK THEY HAVE SUFFICIENT FUEL, TO THEN HAVE VEHICLE RUN OUT OF GAS IN A DANGEROUS DRIVING ENVIRONMENT.

• 11/24/2017· STEERING,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  ON SEVERAL OCCASIONS WHILE DRIVING THE CAR COMPLETELY SHUTS OFF NO STEERING NO GAS NOTHING QUITE DANGEROUS AND QUITE SCARY WHILE THE CAR IS IN MOTION ON THE STREET

• 11/22/2016· ENGINE,FUEL/PROPULSION SYSTEM

  AFTER FILLING MY GAS TANK, THE FUEL GAUGE ON MY 2009 SANTA FE WOULD READ EMPTY AND THE LOW FUEL LIGHT WOULD ILLUMINATE. IN ADDITION, THE "CHECK ENGINE" LIGHT CAME ON. AFTER DRIVING A FEW MILES THE FUEL GAUGE WOULD FLUCTUATE BETWEEN EMPTY AND HALF FULL. THE MECHANIC CHECKED THE ONBOARD COMPUTER AND THE CODE SAID IT WAS THE FUEL SENSORS. HE REPLACED BOTH OF THEM, AT A COST OF $500, AND IT SEEMS TO HAVE SOLVED THE PROBLEM. MILEAGE WAS SLIGHTLY UNDER 100,000 MILES.

• 11/20/2017· ELECTRICAL SYSTEM

  AT AROUND 90,000 MILES, THE FUEL GAUGE STOPPED WORKING. EVIDENTLY, THIS IS A COMMON PROBLEM. EVEN AFTER FILLING THE TANK WITH GAS, THE GAUGE SHOWS "EMPTY". THE PROBLEM SEEMS TO BE THE FUEL SENDING UNITS IN THE TANK - THE SENSOR BRUSHES BREAK OFF AND THE UNIT NO LONGER SENDS A SIGNAL TO THE GAUGE. THIS POSES SAFETY ISSUES TO PEOPLE WHO DON'T CAREFULLY TRACK THEIR CAR'S FUEL USE, WHICH COULD RESULT IN A CAR STALLING ON THE HIGHWAY DUE TO FUEL EXHAUSTION. THE PROBLEM SETS TROUBLE CODES AND LIGHTS THE "CHECK ENGINE" LIGHT.

• 11/20/2010· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  WHILE GETTING ONTO THE HIGHWAY FROM THE ON RAMP THE CAR BEGAN TO ACCELERATE ON ITS OWN. THE GAS PEDAL BEGAN TO DEPRESS ITSELF WITHOUT ME DOING IT. THE CRUISE CONTROL WAS NOT ENGAGED AND THE FLOOR MATT WAS NOT THE CAUSE. BRAKING WAS DIFFICULT AND THE ENGINE CONTINUED TO REV. I PULLED OFF THE HIGHWAY AND STOPPED THE ENGINE. AFTER TELLING MY FAMILY ABOUT THE INCIDENT MY DAUGHTER TOLD ME THAT IT HAD OCCURRED TWICE BEFORE IN THE SAME MANNER ABOUT 2 MONTHS AGO.

• 11/19/2018· FUEL/PROPULSION SYSTEM

  FUEL GAUGE WENT UP AND DOWN. RAN OUT OF GAS GOING 70MPH ON TURNPIKE IT WAS HARROWING. GAUGE SAYS FULL AND THEN EMPTY RIGHT AWAY. FUEL SENSORS NEED REPLACED, CHECK ENGINE LIGHT IS NOW SHOWING. I NOTICE MANY OTHERS WITH THE SAME PROBLEM. MINE COULDVE CAUSED A BAD ACCIDENT. OUTRAGEOUSLY EXPENSIVE AND COST PROHIBITIVE TO FIX WHAT I THINK IS A SAFETY ISSUE. 70,000 MILES IS NOT A LOT FOR THIS TO HAVE HAPPENED.

• 11/19/2009· TIRES,EQUIPMENT

  TL*THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT THERE WAS A FACTORY DECAL INDICATING THAT THE LOAD CARRYING CAPACITY WAS REDUCED. HE CONTACTED THE DEALER AND WAS TOLD THAT THEY DID NOT PUT THE DECALS ON THE VEHICLE AND HAD NO KNOWLEDGE HOW TO UPDATE THEM. THE MANUFACTURER WAS ALSO UNABLE TO ASSIST THE CONTACT ON HOW TO CORRECT THE DECAL. THE VEHICLE ALSO HYDROPLANED WHILE DRIVING THE VEHICLE IN THE RAIN WHICH CAUSED HIM TO BE CONCERNED ABOUT THE TIRES. THE TIRES WERE BRIDGESTONE DUELER H/T TIRES SIZE P235/60/R18. THE DOT CODE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 3,400. THE FAILURE MILEAGE WAS APPROXIMATELY 300.

• 11/13/2018· POWER TRAIN

  MY VEHICLE WAS IN THE STATIONARY POSITION OR WAS SUPPOSED TO BE IN PARK. I HAD PULLED INTO MY DRIVEWAY, PUT MY CAR INTO PARK AND TURNED THE ENGINE OFF. UPON EXITING MY VEHICLE WITH GROCERIES IN HAND MY VEHICLE STARTED ROLLING (THANK GOD I WAS ABLE TO GET OUT OF THE WAY) VEHICLE ROLLED OUT OF MY DRIVEWAY, ACROSS THE STREET AND INTO MY NEIGHBOR'S DRIVEWAY WHERE IT CAME TO A STOP. (THANK GOD NO ONE WAS INJURED DURING THIS) I STARTED MY VEHICLE TO GET IT OUT OF MY NEIGHBOR'S DRIVEWAY AND NOTICED THAT EVEN THOUGH THE SHIFTER WAS IN PARK,MY DASH SHOWED THAT MY CAR WAS IN REVERSE! ATTACHED IS A PHOTO OF MY DASH SHOWING THAT IT IS IN "REVERSE" BUT AS YOU CAN CLEARLY SEE MY SHIFT LEVER IS IN PARK

• 11/11/2017· AIR BAGS

  AIR BAG LIGHT ON DASHBOARD WILL NOT GO OFF.

• 11/11/2014· FUEL/PROPULSION SYSTEM

  LOW FUEL INDICATOR LIGHT COMES ON AND GAS GAUGE READS EMPTY AFTER RECENT FILL UP, THEN IT SLOWLY RISES TO FULL, INDICATOR LIGHT THEN GOES OUT AND CHECK ENGINE LIGHT COMES ON, ABOUT 20 MILES LATER CHECK ENGINE LIGHT GOES OUT AND GAS GAUGE RESPONDS CORRECTLY. THIS HAS HAPPENED SEVERAL TIMES, CURRENTLY CHECK ENGINE LIGHT IS OFF. *TR

• 11/11/2014· FUEL/PROPULSION SYSTEM

  ENGINE AND FUEL WARNING LIGHTS COME ON AND OFF SPORADICALLY, AND THE GAS GAUGE SHOWS THE TANK IS EMPTY EVEN AFTER WE FILLED IT. THIS HAPPENS REGARDLESS OF THE AMOUNT OF FUEL IN THE GAS TANK, AND IT MAKES IT IMPOSSIBLE TO KNOW THE ACTUAL AMOUNT OF GASOLINE IN THE VEHICLE. WE BROUGHT IT TO THE DEALER TODAY AND WAS TOLD THE 2 FUEL SENSORS NEED TO BE REPLACED AT A COST OF $600. WHEN WE PURCHASED THE VEHICLE NEW WE ALSO PURCHASED A MAINTENANCE PROGRAM, BUT, OF COURSE, THE FUEL SENSORS ARE EXCLUDED FROM COVERAGE. UPON DOING ONLINE RESEARCH WE LEARNED THERE ARE MANY OTHERS WHO ARE EXPERIENCING THIS SAME PROBLEM. WE FEEL THAT BECAUSE THIS HAS HAPPENED TO OTHER HYUNDAI OWNERS IT MAY BE A PROBLEM THAT HYUNDAI NEEDS TO REPAIR AT NO COST TO THE OWNERS OF THESE VEHICLES. *TR

• 11/11/2014· VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

  VEHICLE SLOWED WITHOUT WARNING ON FREEWAY AT FREEWAY SPEED, THEN WOULD NOT ACCELERATE. WENT TO IDLE MODE. BEFORE SLOWDOWN, HAD MILD SURGING AT SPEED. PROBLEM WAS DIAGNOSED AT TPS OR THROTTLE POSITION SENSOR. PROBLEM WITH SAME SENSOR REPORTED TO HYUNDAI DEALERSHIP PREVIOUS, DIAGNOSED AS LOOSE CONNECTION REPORTED FROM PERIODIC SURGING WHILE DRIVING. AFTER RECENT PROBLEM WITH ALTERNATOR, WHICH REQUIRED REPLACEMENT OF PART, WITHIN ONE WEEK, TPS PARTIALLY FAILED. FAILURE WAS NOT DIAGNOSED AS KIA DEALERSHIP (SISTER COMPANY TO HYUNDAI) WHEN UNDERWENT FIRST REPAIR. FAILURE REQUIRED HYUNDAI DEALERSHIP TO BE TOLD EXACT PROBLEM, WHEREBY THEY CONFIRMED DIAGNOSIS. PART REQUIRED REPLACEMENT WITH SOFTWARE UPDATES. PART PROBLEM LEADING TO FAILURE SHOULD HAVE BEEN ABLE TO BE DIAGNOSED UNDER FIRST ROUND OF TESTING, AND UNDER FIRST REPAIR A WEEK PRIOR. PARTS UNPREDICTABLE FAILURE IS BELIEVED TO PRESENT A SIGNIFICANT RISK WHILE VEHICLE IS OPERATING. *TR

• 11/09/2014· FUEL/PROPULSION SYSTEM

  FUEL LIGHT WAS ON. FILLED GAS TANK. FUEL LIGHT REMAINED ON AND FUEL GAGE DID NOT RISE TO FULL. CHECK ENGINE LIGHT CAME ON. AFTER DRIVING 20+ MILES THE FUEL GAGE ROSE BUT DROPS RAPIDLY. THE FUEL LIGHT WILL GO ON AND THE CHECK ENGINE LIGHT GOES ON AND OFF. HYUNDAI DEALER SAYS THEY KNOW IT IS AN ISSUE BUT NO RECALL HAS BEEN ISSUED. THE DANGER ARISES IF I FAIL TO RESET THE MILEAGE AND SHOULD RUN OUT OF GAS WITHOUT WARNING. *TR

• 11/06/2014· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE BRAKES FAILED DUE TO CORROSION. THE FAILURE OCCURRED THREE TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN EXPLAINED THAT DUE TO THE COLD WEATHER, THE CALIPERS AND BRACKETS CORRODED AND JAMMED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000. THE VIN WAS UNAVAILABLE.

• 11/06/2013· VEHICLE SPEED CONTROL

  DRIVING MY WIFE'S CAR AROUND 40 MPH AND FOR NO REASON THE CAR STARTED ACCELERATING TO A HIGH RATE OF SPEED AND I HAD TO LAY ON THE BRAKE BUT WHEN I TOOK MY FOOT OFF THE BRAKE IT AGAIN STARTED ACCELERATING AT A HIGH RATE OF SPEED. I PUT THE CAR IN NEUTRAL AND THE ENGINE WAS RACING VERY HIGH I SHUT THE CAR OFF AND STARTED IT AGAIN AND IT WAS BACK TO NORMAL. I AM CONCERNED THAT THIS WILL HAPPEN AGAIN. TALKED TO HYUNDAI SERVICE AND THEY COULD NOT GIVE ME AN ANSWER. *TR

• 11/05/2015· AIR BAGSCrash

  WE WERE REARENDED BY A LARGE PICKUP TRUCK THAT WAS TRAVELLING AT A HIGH RATE OF SPEED AND THE DRIVER DID NOT APPLY HIS BRAKES. WE WERE STRUCK WHILE ATTEMPTING AND MAKING A RIGHT TURN, SPUN AROUND CLOCKWISE AND FLIPPED ON OUR TOP, TOTALLY DEMOLISHING OUR CAR. OUR CONCERN: THE AIRBAG SYSTEM DID NOT ENGAGE RESULTING IN INJURIES REQUIRING IMMEDIATE TRANSPORTATION FOR HOSPITALIZATION FOR THE DRIVER AND PASSENGER. THE ACCIDENT OCCURRED ON A PAVED, RURAL-TYPE STREET WITH LITTLE TRAFFIC PRESENT. THE DRIVER HAS A BROKEN NECK, MULTIPLE INJURIES INCLUDING A CLOSED HEAD CONCUSSION.

• 11/04/2015· FUEL/PROPULSION SYSTEM

  CAR LOST POWER WHILE IN MOTION TAKING A TURN AND SLOWING DOWN TO A STOP. STARTED JULY 2015, ONCE AGAIN IN AUG. NOW SINCE OCT, HAPPENS MORE REGULARLY, SOMETIMES TWICE A DAY. DEALER LOOKED AT IT TWICE. NO CODES, CAN'T REPLICATE SO THEY DON'T KNOW WHAT'S CAUSING THE PROBLEM. REPLACED TCS AND DID RECALL 9H292430 ALL WITH NO LUCK. DEALERS NEXT BEST GUESS IS REPLACING THROTTLE BODY.

• 11/02/2015· FUEL/PROPULSION SYSTEM

  SEVERAL MONTHS AGO, THE CHECK ENGINE LIGHT CAME ON. I TOOK THE CAR TO THE DEALER AND WHILE NOTHING WAS WRONG WITH THE ENGINE, I NEEDED TO PAY $1000 TO REPAIR THE SENSOR BECAUSE I NEEDED MY CAR EMISSION INSPECTED. IN THE LAST MONTH, WHILE ON A ROAD TRIP, THE CHECK ENGINE LIGHT CAME ON AGAIN AND THE CAR JUST LOST POWER AND STALLED. WHEN WE RESTARTED THE CAR, THE LIGHT WAS STILL ON BUT WENT OFF THE NEXT DAY. SINCE THEN, THE CHECK ENGINE LIGHT COMES ON RANDOMLY AND THE FUEL GAUGE JUMPS ALL OVER THE PLACE. IT WILL INDICATE I HAVE 88 MILES TO EMPTY AND THEN JUMP BACK UP TO 130. THE CHECK ENGINE LIGHT WILL COME ON ONE DAY AND BE OFF THE NEXT.

• 11/01/2024· ENGINE

  This vehicle Dies while driving it I have to put in neutral and restart. I am afraid that I am going to be hurt or someone else is.

• 11/01/2023· FUEL/PROPULSION SYSTEM

  My kids and I were going to town one afternoon and I started to smell gas coming from the air vents the gas smell was very strong I opened the hood and could see that it was wet I touched the spot and smelled it and it was fuel.i was worried about driving home with my children in the car so I called my brother he came looked and tracked down the issue and the fuel leak was coming from the front fuel rail.i had never heard of a fuel rail going out on a vehicle before so calling around to parts stores and auto parts recycling places to get it fixed and no one will sale me one they have all told me to take it to dealership.please help it's the only vehicle my children and i have.

• 11/01/2021· SUSPENSION

  Hi, so my mechanic checked my vehicle and my the subframe is Rusting and it’s unsafe to drive the vehicle. The vehicle only have 93k miles. I have pictures and proof about the rusted subframe. Hope to hear from you back because I really need vehicle to go to my job and now this is unsafe to drive.

• 11/01/2016· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE FUEL GAUGE DISPLAYED AN INCORRECT READING. THE DEALER DIAGNOSED THAT THE FUEL SENDER ASSEMBLY AND FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. UPDATED 01/05/2017*CT

• 10/31/2023· STEERING,AIR BAGS,SEAT BELTS

  Took my car in for repair because I was told that my power steering pump and gaskets were bad. Upon further investigation it wasn’t neither. It was the power steering hose that goes from the power steering to the racket pinion. Both of the hoses had holes in them and were rusted out. Here Hyundai upgraded the power steering pump because of problems and I was never notified about the upgrade and you cannot purchase the hoses needed you have to purchase a whole new power steering pump that I don’t need. The airbag light is on and I couldn’t even order the airbag it was on back order when asked. The seat belt on the right passenger side in the back will not lock in place due to I don’t know what. Campaign 947 the under body corrosion treatment didn’t protect what it was suppose to causing my frame and control arms to go bad. I have had to replace upper and lower ball joints more than 4-5 times since I purchase this vehicle new from the dealership.

• 10/30/2015· FUEL/PROPULSION SYSTEM

  ONCE THE GAS GAGE REACHES 1/4 FULL, IT GOES TO EMPTY. AFTER FILLING WITH GAS, IT WILL TAKE OVER 1 HOUR TO RECORD A FULL TANK. CANNOT USE THE GAGE AS WE ARE NEVER SURE HOW MUCH GAS IS IN THE TANK. THE ENGINE LIGHT ALSO APPEARS AND STAYS ON UNTIL THE GAS SENSOR RECORDS FULL.

• 10/29/2018· FUEL/PROPULSION SYSTEM

  THE CHECK ENGINE LIGHT COMES ON WHEN YOU ARE AROUND A HALF A TANK OF GAS AND EVEN IF YOU FILL IT UP IT TAKES IT 2 OR 3 TIMES OF STARTING IT FOR IT TO GO OFF. I'M NOT SURE WHAT IS CAUSING THIS. ALSO THE ESC AND THE ABS LIGHTS HAVE BEEN ON AND WON'T GO OFF. THE BOOK SAYS THE ABS LIGHT IS FOR SERVICE BUT I HAVE HAS IT SERVICED SEVERAL TIME AND IT STILL DOESN'T GO OUT.

• 10/28/2019· SERVICE BRAKES

  BRAKES COMPLEXLY FAILED WHILE I WAS DRIVING WITH BRAKES BEING PRESSED COMPLETELY TO FLOOR. I TOOK IT TO A MECHANIC BESIDE MY HOME IMMEDIATELY . BOTH BREAK LINES WERE LEAKING 'GUSHING' BRAKE FLUID. HYUNDAI RECALLED THIS SAME EXACT PROBLEM ON THEIR 2011 SANTA FE BUT WHEN I NOTIFIED HYUNDAI OF MY BRAKE FAILURE THEY INFORMED ME THAT MY VIN NUMBER WAS NOT PART OF THE RECALL. ALSO THERE WERE NO WARNING LIGHTS ON WHEN THIS OCCURRED ! I WILL UPLOAD AN ACTUAL IMAGE OF LEAKING BRAKE LINES WHEN I RETURN TO THE REPAIR SHOP. VEHICLE PARTS REFERENCE NUMBERS PER HYUNDAI ARE 58722D AND 58718F. REPAIRS ESTIMATE IS APPROXIMATELY $665

• 10/27/2020· ENGINE

  RANDOMLY HESITATES AND THEN STALLS WHILE DRIVING.